Purification and Characterization of Soymilk-clotting Enzymes from Bacillus sp. K-295G-7

Enzymes I and II, which have a high soymilk-clotting activity, produced from K-295G-7 were purified by chromatographies on Sephadex G-100, CM-cellulose, hydroxylapatite, and 2nd Sephadex G-100.

The two purified enzymes were found to be homogeneous by polyacrylamide gel elec-trophoresis (PAGE) at pH 4.3. The molecular weights of enzymes I and II were 28,000 and 29,500 by SDS-PAGE, and their isoelectric points were 9.22 and 9.45, respectively. Enzymes I and II coagulated soymilk optimally at 65°C and were stable up to 45°C. Both enzymes were most active at pH 5.8, for soymilk coagulation between pH 5.8 to 6.7, and were stable with about 50 ~ 100% of the original activity from pH 5 to 10.

Each of the purified enzymes was a serine protease with an optimum pH of 9.0 for soy protein isolate (SPI) and casein digestions, because these enzymes were inhibited completely by diisopropylfluoro-phosphate (DFP).

The soymilk-clotting activity to proteolytic activity ratio of the enzyme II was 3 times higher than that of enzyme I. Enzymes I and II were more sensitive to the calcium ion concentration in soymilk than bromelain is.     

Crystallization and Some Properties of Alkaline Proteinase from Aspergillus sulphureus

An alkaline proteinase of Aspergillus sulphureus (Fresenius) Thorn et Church has been purified in good yields from wheat bran culture by fractionation with ammonium sulfate, treatment with acrynol, and DEAE-Sephadex A-50 column chromatography. The crystalline preparation was homogeneous on sedimentation analysis and polyacrylamide gel zone electrophoresis. The molecular weight was calculated to be 23,000 by gel filtration. The amino acid composition of the enzyme was determined. The enzyme did not precipitate with acrynol. Optimum pH for the hydrolysis of casein was 7 to 10 at 35°G for 15 min. Optimum temperature was 50°C at pH 7 for 10 min. The enzyme was highly stable at the range of pH 6 to 11 at 5°C, whereas relatively stable at pH 6 to 7 at 35°C. Metalic salts tested did not affect activity. Chelating agents, sulfhydryl reagents, TPCK, and oxidizing or reducing reagents tested, except iodine, had no effect on the activity. Diisopro-pylfluorophosphate and N-bromosuccinimide almost completely inactivated the proteinase.     

Characterization of a thermostable lipase showing loss of secondary structure at ambient temperature

A gene encoding extracellular lipase was cloned and characterized from metagenomic DNA extracted from hot spring soil. The recombinant gene was expressed in E. coli and expressed protein was purified to homogeneity using hydrophobic interactions chromatography. The mature polypeptide consists of 388 amino acids with apparent molecular weight of 43 kDa. The enzyme displayed maximum activity at 50°C and pH 9.0. It showed thermal stability up to 40°C without any loss of enzyme activity. Nearly 80% enzyme activity was retained at 50°C even after incubation for 75 min. However above 50°C the enzyme displayed thermal instability. The half life of the enzyme was determined to be 5 min at 60°C. Interestingly the CD spectroscopic study carried out in the temperature range of 25–95°C revealed distortion in solution structure above 35°C. However the intrinsic tryptophan fluorescence spectroscopic study revealed that even with the loss of secondary structure at 35°C and above the tertiary structure was retained. With p-nitrophenyl laurate as a substrate, the enzyme exhibited a K _m , V _max and K _cat of 0.73 ± 0.18 μM, 239 ± 16 μmol/ml/min and 569 s⁻¹ respectively. Enzyme activity was strongly inhibited by CuCl₂, HgCl₂ and DEPC but not by PMSF, eserine and SDS. The protein retained significant activity (~70%) with Triton X-100. The enzyme displayed 100% activity in presence of 30% n-Hexane and acetone.     

Studies on Tannin Acyl Hydrolase of Microorganisms

Tannin acyl hydrolase (Tannase) from Asp. oryzae No. 7 was purified. The purified enzyme was homogenous on column chromatography (DEAE-Sephadex A50, Sephadex G100), ultra centrifugation and electrophoresis.

The molecular weight of the enzyme estimated by gel filtration method was about 200,000.

The enzyme was stable in the range of pH 3 to 7.5 for 12 hr at 5°C, and for 25 hr at the same temperature in the range of pH 4.5 to 6. The optimum pH for the reaction was 5.5. It was stable under 30°C (over one day, in 0.05 M-citrate buffer of pH 5.5), and the optimum temperature was 30~40°C (reaction for 20min). The activity was lost completely at 55°C in 20 min at pH 5.5, or at 85°C in 10 min at the same pH.

Any metal salt tested did not activate the enzyme, Zink chloride and cupric chloride inhibited the activity or denatured the enzyme. The activity was lost completely by dialysis against EDTA-solution at pH 7.25, although it was not affected by dialysis against deionized water.     

Facile Syntheses of C-Glycosides of Aromatic Compounds

Aspartokinase (ATP: l-aspartate 4-phosphotransferase) was extracted and partially purified 11-fold from an extreme thermophile, Thermus flavus AT–62. The enzyme has a temperature optimum near 75°C and a pH optimum of 7 to 8. The enzyme activity was feedback inhibited 80% by l-threonine at the concentration of 0.1 mm at 60°C. No concerted effect of l-threonine with any other aspartate family amino acids was observed. The aspartokinase and homoserine dehydrogenase activities were eluted at different concentrations of KCl from DEAE-cellulose column. The aspartokinase was not inactivated after 30 min at 70°C, but 30% of the original activity was lost after 30 min at 80°C and rapid inactivation occurred above 85°C. The allosteric sensitivity of the enzyirie was maintained even at 60~80°C but was reduced with the increase of temperature, accompanying desensitization above 80°C. The heat stability of the enzyme activity and of the allosteric sensitivity was discussed in comparison with other allosteric enzymes of thermophiles.     

Purification and Characterization of a Thermostable Alkaline Protease from Alkalophilic Thermoactinomyces sp. H8682

Protease secreted into the culture medium by alkalophilic Thermoactinomyces sp. HS682 was purified to an electrophoretically homogeneous state through only two chromatograhies using Butyl-Toyopearl 650M and SP-Toyopearl 650S columns. The purified enzyme has an apparent relative molecular mass of 25, 000 according to gel filtration on a Sephadex G-75 column and SDS-PAGE and an isoelectric point above 11.0.

Its proteolytic activity was inhibited by active-site inhibitors of serine protease, DFP and PMSF, and metal ions, Cu²⁺ and Hg²⁺. The enzyme was stable toward some detergents, sodium perborate, sodium triphosphate, sodium-n-dodecylbenzenesulfonate, and sodium dodecyl sulfate, at a concentration of 0.1% and pH 11.5 and 37°C for 60 min. The optimum pH was pH 11.5–13.0 at 37°C and the optimum temperature was 70°C at pH 11.5. Calcium divalent cation raised the pH and heat stabilities of the enzyme. In the presence of 5 mM CaCl₂, it showed maximum proteolytic activity at 80°C and stability from pH 4–12.5 at 60°C and below 75°C at pH 11.5. The stabilization by Ca²⁺ was observed in secondary conformation deduced from the circular dichroic spectrum of the enzyme. The protease hydrolyzed the ester bond of benzoyl leucine ester well. The amino acid terminal sequence of the enzyme showed high homology with those of Microbiol serine protease, although alanine of the NH₂-terminal amino acid was deleted.     

Thermostable alkaline lipase from a newly isolated thermophilic Bacillus,strain A30-1 (ATCC 53841)

A thermophilic bacterium was isolated from a hot spring area of Yellowstone National Park. The organism grew optimally at 60–65°C and in the pH range of 6–9. It was characterized as Bacillus sp. In the presence of corn or olive oil (1.0%) as the growth substrate, this Bacillus produced an extracellular lipolytic activity (EC 3.1.1.3). The enzyme activity could be efficiently recovered by ultrafiltration of cell-free culture supernatant. The partially purified lipase preparation had an optimum temperature of 60°C, at an optimum pH of 9.5. It retained 100% of the original activity after being heated at 75°C for half an hour. The half life of the enzyme was 8 h at 75°C. The enzyme retained at least 90% of the original activity after it was incubated at 60°C for 15 h at pH's in the range of 5 to 10.5. The enzyme was active on triglycerides containing fatty acids having a carbon chain length of C16 : 0 to C22 : 0 as well as on natural fats and oils. The enzyme activity was stable to both hydrogen peroxide and alkaline protease which are detergent ingredients. The purified enzyme had an isoelectric point of 5.15 and an approximate molecular weight of 65,000.     

Purification and Some Properties of Crystalline Acid Protease from Acrocylindrium sp.

A crystalline acid protease produced by a strain of Acrocylindrium in a submerged culture was prepared by treatment with acetone (60%), salting out with ammonium sulfate (saturated) and, after chromatography on Duolite GS-101 column, dialysis against distilled water. This preparation was homogeneous on sedimentation analysis, starch-gel electrophoresis and gel filtration with Sephadex G-75. The optimum pH was 2.0 for milk casein digestion and the pH stability was for 2.0~5.0 at 30°C for one day. The crystalline enzyme was completely stable below 50°C, but lost the activity at 70°G in ten minutes. The acid protease was almost equal to pepsin on specific activity when milk casein solution (pH 2.0) was used as substrate.     

Immobilization of glucansucrase for the production of gluco-oligosaccharides from Leuconostoc mesenteroides

Glucansucrase from Leuconostoc mesenteroides was immobilized in 1?% (w/v) with sodium alginate to produce oligosaccharides. Glucansucrase gave three activity bands of approx. 240, 178, and 165?kDa after periodic acid-Schiff staining with sucrose. The immobilized enzyme had 40?% activity after ten batch reactions at 30?°C and 75?% activity after a month of storage at 4?°C, which is six times more stable than the free enzyme. Immobilized enzyme was more stable at lower (3.5?4.5) and higher (6.5?7.0) pH ranges and higher temperatures (35?40?°C) compared with the free enzyme. Immobilized and free glucansucrase were employed in the acceptor reaction with maltose and each produced gluco-oligosaccharide ranging from trisaccharides to homologous pentasaccharides.     

Purification and Characterization of an Extracellular Low Temperature-Active and Alkaline Stable Peptidase from Psychrotrophic Acinetobacter sp. MN 12 MTCC (10786)

An extracellular low temperature-active alkaline stable peptidase from Acinetobacter sp. MN 12 was purified to homogeneity with a purification fold of 9.8. The enzyme exhibited specific activity of 6,540 U/mg protein, with an apparent molecular weight of 35 kDa. The purified enzyme was active over broad range of temperature from 4 to 60 °C with optimum activity at 40 °C. The enzyme retained more than 75 % of activity over a broad range of pH (7.0–11.0) with optimum activity at pH 9.0. The purified peptidase was strongly inhibited by phenylmethylsulfonyl fluoride, giving an indication of serine type. The K _m and V _max for casein and gelatin were 0.3529, 2.03 mg/ml and 294.11, 384.61 μg/ml/min respectively. The peptidase was compatible with surfactants, oxidizing agents and commercial detergents, and effectively removed dried blood stains on cotton fabrics at low temperature ranging from 15 to 35 °C.     

Production of extracellular alkaline lipase by a new thermophilicBacillus sp

A thermophilic soil isolate—Bacillus sp. RS-12, grew optimally at 50°C and not below 40°C. Production of an extracellular lipase by this organism was substantially enhanced when the type and concentration of carbon and nitrogen sources and initial pH of the culture medium were consecutively optimized. The lipase production was found to be growth-associated with maximum secretion in the late exponential growth phase,i.e. 15h of incubation. The enzyme activity as high as 0.98 nkat/mL was obtained under optimum conditions. Tween 80 (0.5%) and yeast extract (0.5%) were found to be the best carbon and nitrogen sources inducing maximum enzyme yield with initial pH 8.0 at 50°C. The kinetic characteristics of the crude lipase indicated the highest activity at 50–55°C and pH 8.0. It had a half life of 60, 18 and 15 min at 65, 70 and 75°C, respectively.     

Studies on the Xylanase from Streptomyces

Xylanase from Streptomyces xylophagus nov. sp. has been purified by ammonium sulfate fractionation and chromatography on DEAE-cellulose column. The purification of the enzyme was 276-fold with a yield of 18.6% on the basis of the activity per weight of total nitrogen. The purified enzyme was homogeneous on moving-boundary electrophoresis. Optimum pH and temperature for the enzyme activity were 6.2 and 55~60°C, respectively. The enzyme was stable up to 40°C and in the range of pH from 5.3 to 7.3, but inactivated at higher than 50°C and at extreme pH values of 2.4 and 9.4. Hydrolyzed products of xylan by the enzyme were xylose and xylobiose.     

Purification and characterization of a family 5 endoglucanase from a moderately thermophilic strain of Bacillus licheniformis

Strains of thermophilic bacilli were screened for cellulolytic activity by gel diffusion assay on selective medium at 55°C. Strain B-41361, identified as a strain of Bacillus licheniformis, displayed activity against carboxymethylcellulose. Zymogram analysis demonstrated several catalytically active polypeptides with the most prominent species having a mass of 37 kDa. The enzyme was purified 60-fold with a 17% yield and specific activity of 183 U/mg. The amino terminal sequence was homologous to members of glycoside hydrolase family 5. Optimal temperature was 65°C (measured over 30 min), but the enzyme was most stable at 60°C, retaining greater than 90% activity after one hour. The enzyme had a broad pH range, with maximal activity at pH 6.0, 75% maximal activity at pH 4.5, and 40% at pH 10. The enzyme hydrolyzed p-nitrophenylcellobioside, barley β-glucan, and lichenan, but no activity was detected against avicel or acid-swollen cellulose.Mention of a trade name or commercial products in this publication is solely for the purpose of providing specific information and does not imply recommendation or endorsement by the U.S. Department of Agriculture.     

Biochemical characterization of a hemolymph phenoloxidase and its endogenous inhibitor in the larvae of an invasive moth,Cydalima perspectalis Walker (Lepidoptera: Crambidae)

Phenoloxidase system is a crucial component of insect innate immunity which contribute to oxidize phenols to quinones and to generate reactive oxygen and nitrogen intermediates. In the current study, a phenoloxidase (PO) was extracted by hemocyte lysate preparation and purified through ammonium sulfate precipitation, Sepharyl G-100, and DEAE-Cellulose fast flow columns. At the end of the purification process, an enzyme was purified with a specific activity of 0.462 U/mg protein, recovery of 40.47%, purification fold of 14.43 and molecular weight of ~78.7 kDa. The optimal activity was recorded at pH 7 while the optimal temperature was recorded at 30–35 °C, 35 °C and 25–35 °C, using L-dihydroxyphenylalanine, hydroquinone, and pyrocatechol, respectively. The highest V_max of PO was obtained using L-dopa while the lowest K_m value was gained using hydroquinone. Among used synthetic inhibitors of ethylenediaminetetraacetic acid (EDTA), diethyldithiocarbamate (DTC), N, N,N0,N0-tetraacetic acid (EGTA) and triethylenetetramine hexaacetic acid (TTHA), EDTA and DTC inhibited more than 60% of the enzyme activity. Moreover, an endogenous phenoloxidase inhibitor (POI) was purified by twice processing of Sepharyl G-100 chromatography with the molecular weight of ~52 kDa. The IC₅₀ of POI was found 31.3 mg against the purified PO of C. perspectalis and led to a higher value of K_m. Finally, larval injection by DTC and POI demonstrated significant inhibition of PO over the time of exposure. A comprehensive understanding of insect’s POs may better clarify the ways of their survival within infected areas and to potentially target them by specific and selective compounds.     

A novel alkalo- and thermostable phospholipase D from <Emphasis Type="Italic">Streptomyces olivochromogenes</Emphasis>

A 60 kDa phospholipase D (PLD) was obtained from Streptomyces olivochromogenes by one-step chromatography on Sepharose CL-6B. Maximal activity was at pH 8 and 75°C and the enzyme was stable from pH 7 to 13 and from 55 to 75°C. Thermal and pH stability with temperature optimum of the enzyme were highest among Streptomyces PLDs reported so far. The activity was Ca²⁺-dependent and enhanced by detergents. The Km and Vmax values for phosphatidylcholine were 0.6 mM and 650 μmol min⁻¹ mg⁻¹, respectively. In addition, the enzyme also revealed transphosphatidylation activity, which was optimum at pH 8 and 50°C. The first 15 amino acid residues of the N terminal sequence were ADYTPGAPGIGDPYY, which are significantly different from the other known PLDs. The enzyme may therefore be a novel PLD with potential application in the lipid industry.     

Studies on Pectolytic Enzymes of Molds

Exopolygalacturonase from Coniothyrium diplodiella has been purified by ammonium sulfate fractionation, chromatography on DEAE-cellulose and column zone electrophoresis. The enzyme was concentrated about 5-fold with a yield of 0.24% on the basis of polygalacturonase activity per weight of total nitrogen. The purified enzyme was homogenous On free-boundary electrophoresis. The enzyme was most active in the pH range 4.0~4.5. The enzyme was stable at 50°C and pH range of 3.5~6.0, but inactivated at higher than 55°C. Hydrolysis of pectic acid by the enzyme went to completion via galacturonic acid liberation from the end of the chain, but pectin was little affected by the enzyme.     

Purification and Properties of Neutral-cyclodextrin Glycosyl-transferase of an Alkalophilic Bacillus sp.

Neutral-cyclodextrin glycosyltransferase (EC 3.2.1.19) of alkalophilic Bacillus sp. (ATCC 21783) was purified by starch adsorption, DEAE-cellulose chromatography and Sephadex G–150 gel filtration chromatography followed by preparative polyacrylamide gel electrophoresis. Molecular weight of the purified enzyme was 85,000-88,000 by SDS-disc gel electrophoresis. The enzyme was most active at pH 7 and 50°C, and stable up to 60°C at pH 7 and in the range of pH 6~8 at 60°C by 30 min incubation. The apparent V_max and Km values for α- and β-cyclodextrin at a constant concentration of sucrose were 417, 70 µmoles glucose/min · mg protein and 10, 0.83 nm, respectively. About 85~90% of amylose, 75~80% of potato starch, 65~70% of amylopectin, 55~60% of glycogen, 45~50% of amylopectin β-limit dextrin, 20~25% of maltotriose and 10~15% of maltose were converted to cyclodextrins with 0.5~1% (w/v) of each substrate.

Schardinger β-dextrin was preferentially produced from starch, and α- or γ-dextrin was gradually formed after prolonged incubation. After 20 min incubation, about 0.4, 14 and 2.5% of α-, β- and γ-dextrin were formed from starch, respectively.     

Immobilization of urease on vermiculite

Urease (EC 3.5.1.5) of high activity was obtained when the enzyme was immobilized on vermiculite crosslinked with 2.5% glutaraldehyde in chilled EDTA-phosphate buffer (pH 5.5). The highest activity of the immobilized enzyme was at 65°C and pH 6.5 while the optimum temperature for free urease was found to be 25°C. The thermal stability of immobilized urease was observed to be much better than that of the free urease. When stored at 4°C, urease immobilized on vermiculite retained 69 to 81% of its activity after 60 days and 61 to 75% of its original activity was retained after 4 repeated uses.     

Simultaneous purification and immobilization of soybean hull peroxidase with a dye attached to chitosan mini-spheres

Soybean hull peroxidase (EC 1.11.1.7, SBP) was simultaneously purified and immobilized by dye affinity chromatography with Reactive Blue 4 attached to chitosan mini-spheres. Under optimized conditions, 96% of SBP was adsorbed to the matrix. Under the most stringent condition, only 49% was desorbed, whereas 2 M NaCl failed to desorb a significant amount of SBP. This behaviour allowed proposing the dye matrix as a support to immobilize SBP from a crude extract. The pH of maximum activity shifted from 7 to 3–5. SBP gained thermostability after immobilization: after 5?h at 85?°C, the remaining activity was 54%, whereas that of the free enzyme was 31%. The optimum temperature for the immobilized SBP was 75?°C, whereas that of the free enzyme was 55?°C. After two months at 4?°C, the activity loss of the immobilized SBP was only 3%. Immobilized SBP removed 80% of 2-bromophenol from wastewater in 180?min and, after five cycles of use, the activity loss was only 12.8%.     

Factors affecting ureolytic activities ofPenicillium waksmanii isolated from sewage sludge

Twenty one fungal isolates belonging to 7 genera were screened for ureolytic activity. APenicillium waksmanii isolate was found to be the most potent and was selected for further study. No ammonia-nitrogen was detected inP. waksmanii cultures either urea-free or containing up to 1 g urea per L. The maximum extracellular urease production was recorded at a urea concentration of 15 g/L. It peaked after 6 d of incubation at 25°C when the initial pH of the glucose—peptone broth was adjusted to 6. On the other hand, the highest fungus biomass was detected at a concentration of 2 g urea per L after 4 d of incubation at 35°C when the pH of the medium was 8. The intracellular urease activity (measured in cell-free extract) was the highest at 12 mg urea per mL after 75-min incubation at 25°C at pH 8. Incubation temperature of 25°C favored both urease production and activity.