Comparative Fluxome and Metabolome Analysis of Formate as an Auxiliary Substrate for Penicillin Production in Glucose‐Limited Cultivation of Penicillium chrysogenum

During glucose‐limited growth, a substantial input of adenosine triphosphate (ATP) is required for the production of β‐lactams by the filamentous fungus Penicillium chrysogenum. Formate dehydrogenase has been confirmed in P. chrysogenum for formate oxidation allowing an extra supply of ATP, and coassimilation of glucose and formate has the potential to increase penicillin production and biomass yield. In this study, the steady‐state metabolite levels and fluxes in response to cofeeding of formate as an auxiliary substrate in glucose‐limited chemostat cultures at the dilution rates (D) of both 0.03 h^?1 and 0.05 h^?1 are determined to evaluate the quantitative impact on the physiology of a high‐yielding P. chrysogenum strain. It is observed that an equimolar addition of formate is conducive to an increase in both biomass yield and penicillin production at D = 0.03 h^?1, while this is not the case at D = 0.05 h^?1. In addition, a higher cytosolic redox status (NADH/NAD⁺), a higher intracellular glucose level, and lower penicillin productivity are only observed upon formate addition at D = 0.05 h^?1, which are virtually absent at D = 0.03 h^?1. In conclusion, the results demonstrate that the effect of formate as an auxiliary substrate on penicillin productivity in the glucose‐limited chemostat cultivations of P. chrysogenum is not only dependent on the formate/glucose ratio as published before but also on the specific growth rate. The results also imply that the overall process productivity and quality regarding the use of formate should be further explored in an actual industrial‐scale scenario.     

Production of acetic acid by Acetogenium kivui

Summary The formation of acetic acid by the thermophilic nonsporeforming homoacetogenic bacterium Acetogenium kivui was studied under various conditions. In pH-controlled batch fermentation at pH 6.4 this bacterium was able to produce up to 625 mM of acetic acid from glucose within 50–60 h. The value of _max obtained was about 0.17 h^-1, the yield was about 2.55 mol of acetic acid per mol of glucose utilized. In continuous fermentation both substrate concentration and dilution rate (D) influenced the yield of acetate and the stationary concentration: a glucose concentration of 67 mM at D=0.09 h^-1 resulted in 2.82 mol acetate/mol glucose and 190 mM acetate at a production rate of 17.1 mM/1 h. When the dilution rate was increased the production rate reached a maximal value of 43.2 mM/1 h at D=0.32 h^-1. At a glucose concentration of 195 mM the dependence of yield upon dilution rate followed a similar pattern and an acetate concentration of 420 mM could be obtained. Enzymatic studies indicate that in A. kivui pyruvate ferredoxin-oxidoreductase and acetate kinase are inhibited at acetate concentrations higher than 800 mM. Based on these results a fed-batch fermentation was developed, which allowed to produce more than 700 mM acetic acid within 40–50 h.Dedicated to Prof. Dr. H. J. Rehm on the occasion of his 60th birthday     

2,3-Butanediol production by Enterobacter aerogenes in continuous culture: role of oxygen supply

Summary The influence of oxygen on growth and production of 2,3-butanediol and acetoin by Enterobacter aerogenes was studied in continuous culture. At all dilution rates (D) studied cell mass increased steadily with increasing oxygen uptake rate (OUR), hence the micro-aerobic cultivation was energy-limited. The biomass yield on oxygen increased with D which suggests that cells need more energy for maintenance functions at lower D. At each D an optimal OUR giving highest volumetric productivity for the sum of butanediol and acetoin was found. The optimal OUR increased with D. The occurrence of optimal OURs results from the various effects of O₂ on growth and specific productivity. The latter was found to be a linear function of the specific OUR irrespective of D. At optimal OUR the cells proved to have equal specific OURs and equal specific productivities representing a fixed relationship between fermentative and respiratory metabolism. The product yield based on glucose and corrected for biomass formation was 80%. A product concentration as high as 43 g/l was obtained at D =0.1 h^–1 while the volumetric productivity was the highest at D =0.28 h^–1 (5.6 g/l and hour). The findings further indicate that growth and product generation are obviously non-associated phenomena. Hence, high productivities may be achievable by cell recycling and cell immobilisation systems. Offprint requests to: W.-D. Deckwer     

An analysis of the growth of Gluconobacter oxydans in chemostat cultures

Gluconobacter oxydans was grown successively in glucose and nitrogen-limited chemostat cultures. Construction of mass balances of organisms growing at increasing dilution rates in glucose-limited cultures, at pH 5.5, revealed a major shift from extensive glucose metabolism via the pentose phosphate pathway to the direct pathway of glucose oxidation yielding gluconic acid. Thus, whereas carbon dioxide production from glucose accounted for 49.4% of the carbon input at a dilution rate (D)=0.05 h^-1, it accounted for only 1.3% at D=0.26 h^-1. This decline in pentose phosphate pathway activity resulted in decreasing molar growth yields on glucose. At dilution rates of 0.05 h^-1 and 0.26 h^-1 molar growth yields of 19.5 g/mol and 3.2 g/mol, respectively, were obtained. Increase of the steady state glucose concentration in nitrogen-limited chemostat cultures maintained at a constant dilution rate also resulted in a decreased flow of carbon through the pentose phosphate pathway. Above a threshold value of 15–20 mM glucose in the culture, pentose phosphate pathway activity almost completely inhibited. In G. oxydans the coupling between energy generation and growth was very inefficient; yield values obtained at various dilution rates varied between 0.8–3.4 g/cells synthesized per 0.5 mol of oxygen consumed.     

Effect of the dilution rate on the biomass yield ofBacillus thuringiensis and determination of its rate coefficients under steady-state conditions

Depending on the biomass yield on glucose and the cell morphology ofBacillus thuringiensis, three different metabolic states were observed in continuous culture. At dilution rates between 0.18 h^–1 and 0.31 h^–1 vegetative cells, sporulating bacteria and spores coexisted, while glucose and amino acids were consumed. Only vegetative cells were observed at dilution rates between 0.42 h^–1 and 0.47 h^–1 and glucose was used as the main carbon and energy source. AtD = 0.50 h^–1 the biomass yield on glucose decreases sharply. To define better the specific growth rate range in which the microorganism uses mainly glucose, a dilution rate of 0.25–0.45 h^–1 was studied. The experimental data could be adjusted to a Monod model and the following rate coefficients and growth yields were determined: maximum specific growth rate 0.54 h^–1, saturation constant 0.56 mg glucose ml^–1, biomass growth yields 0.43 g cells (g glucose)^–1, and 0.76 g cells (g oxygen)^–1, and maintenance coefficients 0.065 g glucose (g cells)^–1 h^–1 and 0.039 g oxygen (g cells)^–1 h^–1.     

Oxidative capacity determines the growth rate with Acetobacter methanolicus

The cultivation of Acetobacter methanolicus on various substrates revealed that the respective maximum growth rates are obtained at an almost identical oxidative capacity of about 16 mmoles of oxygen g (biomass)^?1·h^?1 under conditions of energy generations by complete substrate oxidation. This is considered to be an indication that the energy production rate determined by the capacity of the respiratory chain limits the growth rate in this strain. However, with glucose and glycerol, for example, a further increase in the growth rate is observed accompanied by the generation of products (gluconic acid or dihydroxyacetone, respectively). The incomplete oxidation should play the role of an additional energy generation. The potential for this rate increase is looked for in a higher energy gain derived from reduction equivalents (PQQH₂) in this periplasmic oxidation step in relation to the cytoplasmic reduction equivalents.     

Effect of malic acid on the growth kinetics of<Emphasis Type="Italic"> Lactobacillus plantarum</Emphasis>

The fermentation kinetics of Lactobacillus plantarum were studied in a specially designed broth formulated from commercially available, dehydrated components (yeast extract, trypticase, ammonium sulfate) in batch and continuous culture. During batch growth in the absence of malic acid, the specific growth rate was 0.20 h^–1. Malic acid in the medium, at 2 mM or 10 mM, increased the specific growth rate of L. plantarum to 0.34 h^–1. An increase in the maximum cell yield due to malic acid also was observed. Malic acid in the medium (12 mM) reduced the non-growth-associated (maintenance energy) coefficient and increased the biomass yield in continuous culture, based on calculations from the Luedeking and Piret model. The biomass yield coefficient was estimated as 27.4 mg or 34.3 mg cells mmol^–1 hexose in the absence or presence of malic acid, respectively. The maintenance coefficient was estimated as 3.5 mmol or 1.5 mmol hexose mg^–1 cell h^–1 in the absence or presence of malic acid. These results clearly demonstrate the energy-sparing effect of malic acid on the growth- and non-growth-associated energy requirements for L. plantarum. The quantitative energy-sparing effect of malic acid on L. plantarum has heretofore not been reported, to our knowledge.     

Optimization of gluconic acid synthesis by removing limitations and inhibitions

The optimization task was performed using the gluconic acid synthesis by the Acetobacter methanolicusMB 58 strain. The microorganisms were grown continuously on methanol as the growth substrate. After finishing the growth process by the deficiency of N and P, the gluconic acid synthesis was started by adding glucose. The synthesis process was performed continuously. The oxygen transfer rate depended on the gluconic acid concentration. During the growth process, the oxygen transfer rate reached a value of about 13 g O₂ · kg^?1 · h^?1using a 30-l glass fermenter equipped with a 6 blade stirrer and fully baffled. This rate declined to a value of between 2 and 5 g O₂ · kg^?1 · h^?1 in the presence of gluconic acid concentrations above 150 g gluconic acid · kg^?1medium. The yield (g gluconic acid · g^?1glucose) depended on the gluconic acid concentration and amounted to y = 0.7 in relation to 150 g gluconic acid · kg^?1medium and y = 0.8 in relation to 200 g · kg^?1medium, respectively. The fermenters were coupled with ultrafiltration moduls (Fa. ROMICON and Fa. SARTORIUS). The biomass concentrations amounted from 5 to 40 g dry mass kg^?1medium. The ultrafiltration modules retained the biomass within the fermentation system. A glucose solution (30 to 50 weight percent glucose) was continuously dosed into the fermenter. The retention time was chosen between 2 and 30 h. The gluconic acid synthesis rate reached values of up to 32 g gluconic acid · kg^?1 · h^?1. Within a range of up to 250 g gluconic acid · kg^?1medium, the acid concentration had no influence on the enzyme activity.     

Mixed substrate growth of methylotrophic yeasts in chemostat culture: Influence of the dilution rate on the utilisation of a mixture of glucose and methanol

The growth of Hansenula polymorpha and Kloeckera sp. 2201 with a mixture of glucose and methanol (38.8%/61.2%, w/w) and the regulation of the methanol dissimilating enzymes alcohol oxidase, catalase, formaldehyde dehydrogenase and formate dehydrogenase were studied in chemostat culture, as a function of the dilution rate. Both organisms utilized and assimilated glucose and methanol simultaneously up to dilution rates of 0.30 h^-1 (H. polymorpha) and 0.26h^-1, respectively (Kloeckera sp. 2201) which significantly exceeded _max found for the two yeasts with methanol as the only source of carbon. At higher dilution rates methanol utilisation ceased and only glucose was assimilated. Over the whole range of mixed-substrate growth both carbon sources were assimilated with the same efficiency as during growth with glucose or methanol alone.In cultures of H. polymorpha, however, the growth yield for glucose was lowered by the unmetabolized methanol at high dilution rates. During growth on both carbon sources the repression of the synthesis of all catabolic methanol enzymes which is normally caused by glucose was overcome by the inductive effect of the simultaneously fed methanol. In both organisms the synthesis of alcohol oxidase was found to be regulated differently as compared to catalase, formaldehyde and formate dehydrogenase. Whereas increasing repression of the synthesis of alcohol oxidase was found with increasing dilution rates as indicated by gradually decreasing specific activities of this enzyme in cell-free extracts, the specific activities of this enzyme in cell-free extracts, the specific activities of catalase and the dehydrogenases increased with increasing growth rates until repression started. The results indicate similar patterns of the regulation of the synthesis of methanol dissimilating enzymes in different methylotrophic yeasts.Abbreviations and Terms C₁ Methanol - C₆ glucose; D dilution rate (h^-1) - D _c critical dilution rate (h^-1) - q _s specific, rate of substrate consumption (g substrate [g cell dry weight]^-1 h^-1) - q _CO2 and q _O2 are the specific rates of carbon dioxide release and oxygen consumption (mmol [g cell dry weight]^-1 h^-1) - RQ respiration quotient (q _CO2 q _O2 ¹ ) - s ₀(C₁) and s ₀(C₆) are the concentrations of methanol and glucose in the inflowing medium (g l^-1) - s residual substrate concentration in the culture liquid (g l^-1) - Sp. A. enzyme specific activity - x cell dry weight concentration (gl^-1) - Y _X/C6 growth yield on glucose (g cell dry weight [g substrate]^-1     

Succinic acid-producing biofilms of Actinobacillus succinogenes: reproducibility,stability and productivity

Continuous anaerobic fermentations were performed in a biofilm reactor packed with Poraver® beads. Dilution rates (D) varied between 0.054 and 0.72 h^?1, and d-glucose and CO₂ gas were used as carbon substrates. Steady-state conditions were shown to be repeatable and independent of the operational history. Production stability was achieved over periods exceeding 80 h at values of D below 0.32 h^?1. In these situations, steady-state variation (expressed as fluctuations in NaOH neutralisation flow rates) exhibited a standard deviation of less than 5 % while no indication of biofilm deactivation was detected. The total biomass amount was found to be independent of the dilution rate with an average dry concentration of 23.8?±?2.9 g L^?1 obtained for all runs. This suggests that the attachment area controls the extent of biofilm accumulation. Specific succinic acid (SA) productivities, based on the total biomass amount, exhibited a substantial decrease with decreasing D. An SA volumetric productivity of 10.8 g L^?1 h^?1 was obtained at D?=?0.7 h^?1—the highest value reported to date in Actinobacillus succinogenes fermentations. SA yields on glucose increased with decreasing D, with a yield of 0.90?±?0.01 g g^?1 obtained at a D of 0.054 h^?1. Production of formic acid approached zero with decreasing D, while the succinic to acetic acid ratio increased with decreasing D, resulting in an increasing SA yield on glucose.     

Biosynthesis of superoxide dismutase and catalase in chemostat culture of Saccharomyces cerevisiae

Summary The effects of oxygen (100%), paraquat (0.5 mM), and copper (0.1 mM) on the growth and the biosynthesis of the antioxidant enzymes, superoxide dismutase (SOD) and catalase, were studied in Saccharomyces cerevisiae grown in glucose-limited chemostat cultures. The effect of dilution rates (D, h⁻¹) on cell mass, glucose consumption, ethanol production, oxygen uptake, and specific activities of SOD and catalase were also investigated at each steady state. SOD was optimally produced at D-values between 0.22 and 0.26 h⁻¹ in the presence of oxygen or paraquat, and at D-values greater than 0.17 h⁻¹ when copper was used. On the other hand, catalase activity decreased with increasing D-values. However, the presence of copper or 100% oxygen repressed catalase activity at low D-values (D<0.1 h⁻¹), and decreased the rate of oxygen uptake at all D-values tested. The presence of paraquat affected the rate of oxygen uptake only at high D-values (D>0.22 h⁻¹). We also studied the effect of oxygen concentration on the biosynthesis of SOD and catalase at D=0.1 h⁻¹. The data clearly show that synthesis of SOD and catalase, though correlated with changes in oxygen tension, are independent of one another. Paper Number 10871 of the Journal Series of North Carolina Agricultural Research Service, Raleigh, NC 27 695. The use of trade names in this publication does not imply endorsement by the North Carolina Agricultural Research Service of the products named, nor criticism of similar ones not mentioned     

Growth and butyric acid production by Clostridium populeti

The growth of Clostridium populeti in 2% (w/v) glucose medium containing 0.2% (w/v) yeast extract was optimal with 10 mM NH₄Cl as the nitrogen source. Although the maximum specific growth rate (=0.32 h^-1) with 5 mM NH₄Cl was similar, the biomass yield was about 30% lower than that at the optimum. Either sodium sulphide or cysteine-HCl at an optimum concentration of 0.33 mM and 5.0 mM respectively, could serve as the sole sulphur source for growth. The growth rate was unaffected by initial glucose concentrations of up to 10% (w/v), but in the presence of 15% glucose it declined by about 35%. The molar yield of butyric acid (mol/mol glucose) declined from 0.70 in 1% (w/v) initial glucose medium to 0.39 in 10% glucose medium. In 5.7% initial glucose medium, butyric acid levels of 6.3 g/l were obtained (0.56 mol butyrate/mol glucose) after 72 h of incubation in 2.5 l batch cultures. A decrease of about 50% in the maximum specific growth rate of C. populeti was observed in the presence of an initial concentration of either 1.2 g/l of butyric acid or 18.9 g/l of acetic acid.This paper is issued as NRCC No. 29032     

Dilution rates influence ammonia-assimilating enzyme activities and cell parameters of Selenomonas ruminantium strain D in continuous (glucose-limited) culture

Aims: The objective of this study was to examine the effect of dilution rates (Ds, varying from 0·05 to 0·42 h^?1) in glucose‐limited continuous culture on cell yield, cell composition, fermentation pattern and ammonia assimilation enzymes of Selenomonas ruminantium strain D. Methods and Results: All glucose‐limited continuous culture experiments were conducted under anaerobic conditions. Except for protein, all cell constituents including carbohydrates, RNA and DNA yielded significant cubic responses to Ds with the highest values at Ds of either 0·10 or 0·20 h^?1. At Ds higher than 0·2 h^?1, fermentation acid pattern shifted primarily from propionate and acetate to lactate production. Succinate also accumulated at the higher Ds (0·30 and 0·42 h^?1). Glucose was most efficiently utilized by S. ruminantium D at 0·20 h^?1 after which decreases in glucose and ATP yields were observed. Under energy limiting conditions, glutamine synthetase (GS) and glutamate dehydrogenase (GDH) appeared to be the major enzymes involved in nitrogen assimilation suggesting that other potential ammonia incorporating enzymes were of little importance in ammonia assimilation in S. ruminantium D. GS exhibited lower activities than GDH at all Ds, which indicates that the bacterial growth rate is not a primary regulator of their activities. Conclusions: Studied dilution rates influenced cell composition, fermentation pattern and nitrogen assimilation of S. ruminantium strain D grown in glucose‐limited continuous culture. Significance and Impact of the Study: Selenomonas ruminantium D is an ecologically and evolutionary important bacterium in ruminants and is present under most rumen dietary conditions. Characterizing the growth physiology and ammonia assimilation enzymes of S. ruminantium D during glucose limitation at Ds, which simulate the liquid turnover rates in rumen, will provide a better understanding of how this micro‐organism responds to differing growth conditions.     

Increase in Silk Production by the Silkworm,Bombyx morì L., due to Oral Administration of a Juvenile Hormone Analog

(R)-1,3-butanediol ((R)-1,3-BD) is an important substrate for the synthesis of industrial chemicals. Despite its large demand, a bioprocess for the efficient production of 1,3-BD from renewable resources has not been developed. We previously reported the construction of recombinant Escherichia coli that could efficiently produce (R)-1,3-BD from glucose. In this study, the fermentation conditions were optimized to further improve 1,3-BD production by the recombinant strain. A batch fermentation was performed with an optimized overall oxygen transfer coefficient (82.3?h^?1) and pH (5.5); the 1,3-BD concentration reached 98.5?mM after 36?h with high-yield (0.444?mol (mol glucose)^?1) and a high maximum production rate (3.63?mM?h^?1). In addition, a fed-batch fermentation enabled the recombinant strain to produce 174.8?mM 1,3-BD after 96?h cultivation with a yield of 0.372?mol (mol glucose)^?1, a maximum production rate of 3.90?mM?h^?1, and a 98.6% enantiomeric excess (% ee) of (R)-1,3-BD.     

Physiological properties of Cellulomonas fermentans,a mesophilic cellulolytic bacterium

Summary The fermentation of cellobiose, glucose and cellulose MN 300 by Cellulomonas fermentans was studied. The molar growth yields (i.e. grams of cells per mole of hexose equivalent) were similar on cellobiose and cellulose at low sugar consumption levels (47.8 and 46.5 respectively), but was lower on glucose (38.0). The occurrence of cellobiose phosphorylase activity, detected in cellobiose- and cellulose-grown cells, might explain this result. The specific growth rates measured in cultures on cellobiose, glucose and cellulose were 0.055 h^-1, 0.040 h^-1 and 0.013 h^-1 respectively. Growth inhibition was observed, and a drop in Y_H occurred after relatively low but different quantities of hexose were consumed (2.2 mM, 5 mM and 8 mM hexose equivalent with cellulose, glucose and cellobiose respectively), which coincided with a change in the fermentative metabolism from a typical mixed acid metabolism (1 ethanol, 1 acetate and 2 formate synthesized by consumed hexose) to a more ethanolic fermentation. When growth ceased in cellulose cultures, consumption of cellulose continued, as did production of ethanol.Molar growth yields of C. fermentans were similar in anaerobic and aerobic cellobiose cultures (47.8 g/mol and 42.2 g/mol respectively). Specific growth rates were also quite similar under both culture conditions (0.055±0.013 h^-1 and 0.070±0.007 h^-1 respectively). Aerobic metabolism was studied using ¹⁴C glucose. During the exponential growth phase, acetate, succinate and nonidentified compound(s) accumulated in the supernatant, but no ¹⁴CO₂ was produced. During the stationary phase, acetate was oxidized and ¹⁴CO₂ produced, but without any further biomass synthesis. It seems that a blocking of metabolite oxidation may have occurred in C. fermentans except in the case of acetate, but acetate oxidation was apparently not coupled with production of energy utilizable in biosynthesis.     

The effect of mixtures of glucose and formate on the yield and respiration of a chemostat culture of Beneckea natriegens

Beneckea natriegens oxidizes sodium formate constitutively when grown on glucose or glycerol in chemostat culture, but cannot utilize formate as the sole source of carbon and energy for growth. However, when grown on a mixture of glucose and formate (D=0.37 h^-1, pH 7.6) the yield is higher than on glucose alone.The yield, expressed in terms of g bacterial dry weight g^-1 glucose plus formate carbon utilized, gave a linear relationship when plotted against the total heat of combustion of glucose plus formate utilized. Extrapolation of the plot cut the abscissa at a value equivalent to the heat of combustion of formate, which suggests that formate is not utilised as a source of carbon but only energy.In cultures with nitrate as the sole source of nitrogen the yield from glucose was lower than that observed with ammonia but the addition of formate to the culture utilizing nitrate resulted in an increase in the yield from glucose to a value similar to that observed with ammonia.At a culture pH value of 7.65 unused formate (<0.15–227 mM) in the culture supernatant had no effect on respiration spiration or yield, but at a culture pH of 6.7 excess formate caused a marked increase in respiration rate and a large decrease in the yield from glucose; further decrease in the pH value caused washout of the culture. This may be explained by undissociated formic acid causing uncoupling of oxidative phosphorylation.     

Simultaneous utilization of glucose and D-xylose by Candida shehatae in a chemostat

The kinetics of biomass formation, D-xylose utilization, and mixed substrate utilization were determined in a chemostat using the yeast Candida shehatae. The maximum growth rate of C. shehatae grown aerobically on D-xylose was 0.42 h⁻¹ and the Monod constant, K _s, was 0.06 g L⁻¹. The biomass yield, Y _{X/S}, ranged from 0.40 to 0.50 g g⁻¹ over a dilution rate range of 0.2–0.3 h⁻¹, when C. shehatae was grown on pure D-xylose. Mixtures of D-xylose and glucose (∼1 : 1) were simultaneously utilized over a dilution rate from 0.15 to 0.35 h⁻¹ at pH 3.5 and 4.5, but pH 3.5 reduced μ_max and reduced the dilution rate range over which D-xylose was utilized in the presence of glucose. At pH 4.5, μ_max was not reduced with the mixed sugar feed and the overall or lumped K _s value was not significantly increased (0.058 g L⁻¹ vs 0.06 g L⁻¹), when compared to a pure D-xylose feed. Kinetic data indicate that C. shehatae is an excellent candidate for chemostat production of value added products from renewable carbon sources, since simultaneous mixed substrate utilization was observed over a wide range of growth rates on a 1 : 1 mixture of glucose and D-xylose. Received 21 August 1997/ Accepted in revised form 28 May 1998     

Legume-Rhizobium interactions: host induced alterations in capsular polysaccharides and infectivity of cowpea Rhizobia

Klebsiella aerogenes NCTC418 was cultured anaerobically under glucose-limited conditions in chemostat cultures at various growth rates, ranging from 0.13 h^-1 to 0.82 h^-1. It was found that the specific uptake rate of glucose varied linearly with the growth rate and that under these conditions glucose was fermented solely to acetate and ethanol plus CO₂+H₂ and formate.When steady-state cultures were pulsed with cell saturating concentrations of glucose, the specific glucose aptake rate increased immediately and substantially. However, at steady-state growth rates lower than 0.5 h^-1, this increase was not accompanied by a change in the growth rate, in contrast to cultures growing at higher rates. It was found that relief of the glucose limitation resulted in a shift in fermentation pattern: at the lower growth rates 50% or more of the extra glucose taken up was fermented to D-lactate.Incubation experiments with sonified cells revcaled that K. aerogenes possessed all the enzymes needed to convert dihydroxyacetone phosphate to methylglyoxal and subsequently to D-lactate, and that the rate at which this overall conversion occurred in vitro was in close agreement with the production rate of D-lactate in vivo. Moreover, it was found that the activities of the enzymes of the methylglyoxal bypass were dependent on the imposed growth rate. At higher growth rates, where cells possessed the potential to increase their growth rate immediately, the activity of methylglyoxal synthase was relatively low.it could be shown that, under low growth rate conditions, the uncoupling effect of the methylglyoxal bypass was highly effective and that, as a consequence thereof, a significant increase in the uptake rate of the energy source was accompanied by only a marginal increase in the rate at which ATP was synthesized.     

Ralstonia eutropha as a biocatalyst for desulfurization of dibenzothiophene

The potential of Ralstonia eutropha as a biocatalyst for desulfurization of dibenzothiophene (DBT) was studied in growing and resting cell conditions. The results of both conditions showed that sulfur was removed from DBT which accompanied by the formation of 2-hydroxybiphenyl (2-HBP). In growing cell experiments, glucose was used as an energy supplying substrate in initial concentrations of 55 mM (energy-limited) and 111 mM (energy-sufficient). The growing cell behaviors were quantitatively described using the logistic equation and maintenance concept. The results indicated that 2-HBP production was higher for the energy-sufficient cultures, while the values of the specific growth rate and the maintenance coefficient for these media were lower than those of the energy-limited cultures. Additionally, the kinetic studies showed that the half-saturation constant for the energy-limited cultures was 2 times higher than the energy-sufficient ones where the inhibition constant (0.08 mM) and the maximum specific DBT desulfurization rate (0.002 mmol g_cell ⁻¹ h⁻¹) were almost constant. By defining desulfurizing capacity (D _DBT) including both the biomass concentration and time to reach a particular percentage of DBT conversion, the best condition for desulfurizing cell was determined at 23% g_cell L⁻¹ h⁻¹ which corresponded with the resting cells that were harvested at the mid-exponential growth phase.

     

An elevation of the molar growth yield of Zymomonas mobilis during aerobic exponential growth

Elevated values of molar growth yield (Y_x/s = 14–26 g mol^–1) were obtained during exponential growth (μ > 0.4 h^–1) of Zymomonas mobilis ATCC 29191 by using reduced concentrations of glucose (6.25–100 mM) and increased oxygen supply (E _h > 300 mV) in the growth medium, as compared to the Y_x/s of anaerobic exponential growth (8–10 g mol^–1). Aerobically grown cells showed an increased maximum growth rate (μ_max), and a reduced specific glucose consumption rate (q_s), and specific ethanol formation rate (q_p), thus demonstrating a more pronounced energy-coupling growth under oxic conditions. These results can be neither explained by the concept of a solely operating Entner-Doudoroff pathway as an ATP source in aerobically growing cultures of Z. mobilis nor considered to be consistent with existing data on the lack of the Pasteur effect in this bacterium. Therefore, the results rather give evidence for the essential contribution of aerobic ATP generation under the reported conditions. Received: 24 September 1996 / Accepted: 9 December 1996