Effect of cellulose fine structure on kinetics of its digestion by mixed ruminal microorganisms in vitro

The digestion kinetics of a variety of pure celluloses were examined by using an in vitro assay employing mixed ruminal microflora and a modified detergent extraction procedure to recover residual cellulose. Digestion of all of the celluloses was described by a discontinuous first-order rate equation to yield digestion rate constants and discrete lag times. These kinetic parameters were compared with the relative crystallinity indices and estimated accessible surface areas of the celluloses. For type I celluloses having similar crystallinities and simple nonaggregating particle morphologies, the fermentation rate constants displayed a strong positive correlation (r2 = 0.978) with gross specific surface area; lag time exhibited a weaker, negative correlation (r2 = 0.930) with gross specific surface area. Crystallinity was shown to have a relatively minor effect on the digestion rate and lag time. Swelling of microcrystalline cellulose with 72 to 77% phosphoric acid yielded substrates which were fermented slightly more rapidly than the original material. However, treatment with higher concentrations of phosphoric acid resulted in a more slowly fermented substrate, despite a decrease in crystallinity and an increase in pore volume. This reduced fermentation rate was apparently due to the partial conversion of the cellulose from the type I to the type II allomorph, since mercerized (type II) cellulose was also fermented more slowly, and only after a much longer lag period. The results are consistent with earlier evidence for the cell-associated nature of cellulolytic enzymes of ruminal bacteria and suggest that ruminal microflora do not rapidly adapt to utilization of celluloses with altered unit cell structures.     

Inhibition of ruminal cellulose fermentation by extracts of the perennial legume cicer milkvetch (Astragalus cicer).

Cicer milkvetch (Astragalus cicer L.) is a perennial legume used as a pasture or rangeland plant for ruminants. A study was undertaken to determine whether reported variations in its ruminal digestibility may be related to the presence of an antinutritive material. In vitro fermentation of neutral detergent fiber (NDF) of cicer milkvetch by mixed rumen microflora was poorer than was the fermentation of NDF in alfalfa (Medicago sativa L.). Fermentation of cicer milkvetch NDF was improved by preextraction of the ground herbage with water for 3 h at 39 degrees C. Such water extracts selectively inhibited in vitro fermentation of pure cellulose by mixed ruminal microflora and by pure cultures of the ruminal bacteria Ruminococcus flavefaciens FD-1 and Fibrobacter succinogenes S85. Inhibition of the cellulose fermentation by mixed ruminal microflora was dependent upon the concentration of cicer milkvetch extract and was overcome upon prolonged incubation. Pure cultures exposed to the extract did not recover from inhibition, even after long incubation times, unless the inhibitory agent was removed (viz., by dilution of inhibited cultures into fresh medium). The extract did not affect the fermentation of cellobiose by R. flavefaciens but did cause some inhibition of cellobiose fermentation by F. succinogenes. Moreover, the extracts did not inhibit hydrolysis of crystalline cellulose, carboxymethyl cellulose, or p-nitrophenylcellobioside by supernatants of these pure cultures of cellulolytic bacteria or by a commercial cellulase preparation from the fungus Trichoderma reesei. The agent caused cellulose-adherent cells to detach from cellulose fibers, suggesting that the agent may act, at least in part, by disrupting the glycocalyx necessary for adherence to, and rapid digestion of, cellulose.     

Enhancement of enzymatic saccharification of cellulose by cellulose dissolution pretreatments

Attempts were made to enhance cellulose saccharification by cellulase using cellulose dissolution as a pretreatment step. Four cellulose dissolution agents, NaOH/Urea solution, N-methylmorpholine-N-oxide (NMMO), ionic liquid (1-butyl-3-methylimidazolium chloride; [BMIM]Cl) and 85% phosphoric acid were employed to dissolve cotton cellulose. In comparison with conventional cellulose pretreatment processes, the dissolution pretreatments were operated under a milder condition with temperature <130 °C and ambient pressure. The dissolved cellulose was easily regenerated in water. The regenerated celluloses exhibited a significant improvement (about 2.7- to 4.6-fold enhancement) on saccharification rate during 1st h reaction. After 72 h, the saccharification yield ranged from 87% to 96% for the regenerated celluloses while only around 23% could be achieved for the untreated cellulose. Even with high crystallinity, cellulose regenerated from phosphoric acid dissolution achieved the highest saccharification rates and yield probably due to its highest specific surface area and lowest degree of polymerization (DP).     

Fibrobacter succinogenes S85 ferments ball-milled cellulose as fast as cellobiose until cellulose surface area is limiting

Fibrobacter succinogenes S85 grew rapidly on cellobiose (0.31 h⁻¹) and the absolute rate of increase in fermentation acids was 0.68 h⁻¹. Cultures that were provided with ball-milled cellulose initially produced fermentation acids and microbial protein as fast as those provided with cellobiose, but the absolute cellulose digestion rate eventually declined. If the inoculum size was increased, the kinetics decayed from first to zero order (with respect to cells) even sooner, but in each case the absolute rate declined after only 20 to 30% of the cellulose had been fermented. Congo red binding indicated that the cellulose surface area of individual cellulose particles was not decreasing, and the transition of ball-milled cellulose digestion corresponded with the appearance of unbound cells in the culture supernatant. When bound cells from partially digested cellulose were removed and the cellulose was re-incubated with a fresh inoculum, the initial absolute fermentation rate was as high as the one observed for undigested cellulose and cellobiose. Based on these results, cellulose digestion by F. succinogenes S85 appears to be constrained by cellulose surface area rather than cellulase activity per se. Received: 19 January 2000 / Received revision: 18 April 2000 / Accepted: 1 May 2000     

Investigation of the digestion of cell-wall polysaccharides of spear grass and of cotton cellulose by viscometry and by x-ray diffraction

The lag of ≈ 10 hours in the onset of digestion of cotton cellulose in the rumen, observed by previous workers, has been confirmed. The molecular weight of the remaining cotton decreases only slowly during digestion, and the polysaccharide retains its fibrous form. The crystallinity decreases slightly at the same time, and it is concluded that the amorphous and crystalline regions of cellulose are attacked at approximately the same rate. The hemicelluloses of grass partly digested in the rumen and of faeces fibre have been isolated and found by viscometry to have molecular weights similar to those of the material isolated from the original grass. This finding confirms earlier conclusions that the digestion-resistant hemicelluloses are chemically identical with the digestible hemicelluloses and that the resistance is due to protection by lignin. The holocellulose prepared from faeces fibre by removal of lignin showed slightly less X-ray crystallinity than that from the original grass, but this effect is probably due to a decrease in cellulose-hemicellulose ratio during passage through the animal, rather than to preferential digestion of crystalline cellulose. A comparison of the chemical composition of the polysaccharides of grass and faeces fibre confirms that cellulose is digested more rapidly and completely than hemicelluloses, presumably because it is less effectectively protected by lignin. In the corresponding holocclluloses, however, where the lignin has been removed, the cellulose and hemicelluloses are digested at about the same rate.     

Effects of dilution rate and pH on the ruminal cellulolytic bacterium Fibrobacter succinogenes S85 in cellulose-fed continuous culture

The ruminal cellulolytic bacterium Fibrobacter succinogenes S85 was grown in cellulose-fed continuous culture at 22 different combinations of dilution rate (D, 0.014–0.076 h^-1) and extracellular pH (6.11–6.84). Effects of pH and D on the fermentation were determined by subjecting data on cellulose consumption, cell yield, product yield (succinate, acetate, formate), and soluble sugar concentrationto response surface analysis. The extent of cellulose conversion decreased with increasing D. First-order rate constants at rapid growth rates were estimated as 0.07–0.11 h^-1, and decreased with decreasing pH. Apparent decreases in the rate constant with increasing D was not due to inadequate mixing or preferential utilization of the more amorphous regions of the cellulose. Significant quantities of soluble sugars (0.04–0.18 g/l, primarily glucose) were detected in all cultures, suggesting that glucose uptake was rather inefficient. Cell yields (0.11–0.24 g cells/g cellulose consumed) increased with increasing D. Pirt plots of the predicted yield data were used to determined that maintenance coefficient (0.04–0.06 g cellulose/g cells · h) and true growth yield (0.23–0.25 g cells/g cellulose consumed) varied slightly with pH. Yields of succinate, the major fermentation endproduct, were as high as 1.15 mol/mol anhydroglucose fermented, and were slightly affected by dilution rate but were not affected by pH. Comparison of the fermentation data with that of other ruminal cellulolytic bacteria indicates that F. succinogenes S85 is capable of rapid hydrolysis of crystalline cellulose and efficient growth, despite a lower _max on microcrystalline cellulose.     

Differential Fermentation of Cellulose Allomorphs by Ruminal Cellulolytic Bacteria

In addition to its usual native crystalline form (cellulose I), cellulose can exist in a variety of alternative crystalline forms (allomorphs) which differ in their unit cell dimensions, chain packing schemes, and hydrogen bonding relationships. We prepared, by various chemical treatments, four different alternative allomorphs, along with an amorphous (noncrystalline) cellulose which retained its original molecular weight. We then examined the kinetics of degradation of these materials by two species of ruminal bacteria and by inocula from two bovine rumens. Ruminococcus flavefaciens FD-1 and Fibrobacter succinogenes S85 were similar to one another in their relative rates of digestion of the different celluloses, which proceeded in the following order: amorphous > III_I > IV_I > III_II > I > II. Unlike F. succinogenes, R. flavefaciens did not degrade cellulose II, even after an incubation of 3 weeks. Comparisons of the structural features of these allomorphs with their digestion kinetics suggest that degradation is enhanced by skewing of adjacent sheets in the microfibril, but is inhibited by intersheet hydrogen bonding and by antiparallelism in adjacent sheets. Mixed microflora from the bovine rumens showed in vitro digestion rates quite different from one another and from those of both of the two pure bacterial cultures, suggesting that R. flavefaciens and F. succinogenes (purportedly among the most active of the cellulolytic bacteria in the rumen) either behave differently in the ruminal ecosystem from the way they do in pure culture or did not play a major role in cellulose digestion in these ruminal samples.     

Influence of the supramolecular structure and physicochemical properties of cellulose on its dissolution in a lithium chloride/N,N-dimethylacetamide solvent system

The present work deals with the effects of structural variables of celluloses on their dissolution in the solvent system LiCl/N,N-dimethylacetamide, LiCl/DMAc. Celluloses from fast growing sources (sisal and linters), as well as microcrystalline cellulose (avicel PH-101) were studied. The following structural variables were investigated: index of crystallinity, I(c); crystallite size; polymer porosity; and degree of polymerization determined by viscosity, DPv. Mercerization of fibrous celluloses was found to decrease DPv, I(c), the specific surface area, and the ratio pore volume/radius. The relevance of the structural properties of cellulose to its dissolution is discussed. Rate constants and activation parameters of cellulose decrystallization, prior to its solubilization, have been determined under nonisothermal conditions. The kinetic parameters calculated showed that dissolution is accompanied with small, negative enthalpy and a large, negative entropy of activation.     

Use of in vitro gas production models in ruminal kinetics.

Physiological systems models for ruminant animals are used to predict the extent of ruminal carbohydrate digestion, based on rates of intake, digestion, and passage to the lower tract. Digestion of feed carbohydrates is described in these models by a first-order rate constant. Recently, an in vitro gas production technique has been developed to determine the digestion kinetics in batch fermentation, and nonlinear mathematical models have been fitted to the cumulative gas production data from these experiments. In this paper, we present an analysis that converts these gas production models to an effective first-order rate constant that can be used directly in rumen systems models. The analysis considers the digestion of an incremental mass of substrate entering the rumen. The occurrence of passage is represented probabilistically, and integration through time gives the total mass of substrate and total rate of digestion in the rumen. To demonstrate the analysis, several gas production models are fitted to a sample data set for corn silage, and the effective first-order rate constants are calculated. The rate constants for digestion depend on ruminal passage rate, an interaction that arises from the nonlinearity of the gas production models.     

Quantitative analysis of cellulose degradation and growth of cellulolytic bacteria in the rumen

Ruminant animals digest cellulose via a symbiotic relationship with ruminal microorganisms. Because feedstuffs only remain in the rumen for a short time, the rate of cellulose digestion must be very rapid. This speed is facilitated by rumination, a process that returns food to the mouth to be rechewed. By decreasing particle size, the cellulose surface area can be increased by up to 10⁶-fold. The amount of cellulose digested is then a function of two competing rates, namely the digestion rate ( K _d) and the rate of passage of solids from the rumen ( K _p). Estimation of bacterial growth on cellulose is complicated by several factors: (1) energy must be expended for maintenance and growth of the cells, (2) only adherent cells are capable of degrading cellulose and (3) adherent cells can provide nonadherent cells with cellodextrins. Additionally, when ruminants are fed large amounts of cereal grain along with fiber, ruminal pH can decrease to a point where cellulolytic bacteria no longer grow. A dynamic model based on stella ^® software is presented. This model evaluates all of the major aspects of ruminal cellulose degradation: (1) ingestion, digestion and passage of feed particles, (2) maintenance and growth of cellulolytic bacteria and (3) pH effects.     

The surface structure of well-ordered native cellulose fibrils in contact with water

CP/MAS ¹³C NMR spectroscopy was used in combination with spectral fitting to examine the surface structure of hydrated cellulose I fibrils from Halocynthia and Gluconoacetobacter xylinus. To increase the spectral intensities and minimize signal overlap, G. xylinus celluloses site-specifically enriched in ¹³C either on C4 or on both C1 and C6 were examined. The experimental data showed multiple C4 and C6 signals for the water accessible fibril surfaces in the highly crystalline celluloses. These signal multiplicities were attributed to structural features in the surface layers induced by the fibril interior, and could not be extracted by spectral fitting in celluloses with a lower degree of crystallinity such as cellulose from cotton.     

Ruminal fermentation and fill change with season in an arctic grazer: responses to hyperphagia and hypophagia in muskoxen (Ovibos moschatus)

We studied castrated adult muskoxen fed a standard diet of grass hay and supplement throughout the year to determine seasonal changes in digesta passage, fill, and fermentation without the confounding effects of reproductive demands or changes in food quality. Although food intake increased by 74% between spring and autumn, mean retention times of fluid and particulate digesta markers were maintained between seasons in both the rumen (9-13 h) and the intestines (27-37 h). The rumen contained 84.5% of digesta and accounted for 79% of dry matter digestion in the whole digestive tract. Ruminal fluid space and whole-gut digesta fill increased by 31%-34%, while ruminal rates of in situ degradation increased by more than 100% between spring and autumn for cellulose and hemicellulose. Hyperphagia in autumn was accompanied by increased bacterial counts in ruminal fluid (30%), declines in ruminal pH, and increases in the concentration of fermentation acids (16%) when compared with spring hypophagia. Consumption of fresh hay and supplement increased the concentrations of acids most markedly during winter and spring when bacterial counts were low. Low food intakes in winter and spring may limit the microbial population, whereas hyperphagia in autumn may foster a much more active microflora that requires consistent supplies of substrate. Plasticity of fill and fermentation in muskoxen minimizes winter costs and maximizes nutrients and energy gained from coarse forages in small home ranges throughout the year.     

Crystalline index change in cellulose during aerobic and anaerobic Cellulomonas uda growth

Summary Cultures of Cellulomonas uda were monitored under both aerobic and anaerobic conditions using three commercially available celluloses with varying degrees of crystallinity. In all cases, a high level of cellulose was metabolized and the same maximum carboxymethylcellulase activity (2.6 IU/mg of cellular protein) was observed. Measurement of the crystalline index of celluloses during cellulose growth revealed that the amorphous and crystalline regions were solubilized simultaneously. Investigation of the solubilization rate showed that a decline occurred when a considerable amount of cellulose still remained in the medium. Hypotheses were suggested to explain the biphasic pattern of the kinetics obtained.     

Cellulose morphology and enzymatic reactivity: A modified solute exclusion technique

An expeditious and accurate simplification of Stone and Scallan's solute exclusion technique was developed, thereby avoiding several sources of experimental error coupled with the determination of cellulose pore volume. Using this method, it is shown that cellulolytic enzymes do not enter into the micropores of five studied celluloses. These results suggestes that hydrolysis occurs initially at the external surface of the fibers. This surface area was calculated with the help of adsorption isotherms of bovine serum albumin. The obtained values for the different samples agree with the microscopically observed cellulose morphology. The correlation obtained by several authors relating cellulose porosity and its digestibility is explained as a consequence of the lower crystallinity and easier fragmentation of the more porous celluloses during hydrolysis. (c) 1994 John Wiley & Sons, Inc.     

Effect of soluble carbohydrates on digestion of cellulose by pure cultures of rumen bacteria.

The rate of cellulose digestion in the presence of either glucose or cellobiose was studied for the three predominant species of cellulolytic rumen bacteria: Ruminococcus albus, Ruminococcus flavefaciens, and Bacteroides succinogenes. When a soluble carbohydrate was added to cellulose broth, the lag phase of cellulose digestion was shortened. Presumably, this was due to greater numbers of bacteria, because increasing the size of the inoculum had a similar effect. Cellulose digestion occurred simultaneously with utilization of the soluble carbohydrate. The rate of cellulose digestion slowed markedly for B. succinogenes and R. flavefaciens and slowed less for R. albus after the cellobiose or glucose had been utilized, and was accompanied by a decrease in pH. Both the rate and the extent of cellulose digestion were partially inhibited when the initial pH of the medium was 6.3 or below. R. albus appeared to be less affected by a low-pH medium than were B. succinogenes and R. flavefaciens. When a soluble carbohydrate was added to the fermentation during the maximum-rate phase of cellulose digestion, the rate of cellulose digestion was not affected until after the soluble carbohydrate had been depleted and the pH had decreased markedly. Prolonged exposure of the bacteria to a low pH had little if any effect on their subsequent ability to digest cellulose. Cellulase activity of intact bacterial cells appeared to be constitutive in nature for these three species of rumen bacteria.     

Effect of soluble carbohydrates on digestion of cellulose by pure cultures of rumen bacteria

The rate of cellulose digestion in the presence of either glucose or cellobiose was studied for the three predominant species of cellulolytic rumen bacteria: Ruminococcus albus, Ruminococcus flavefaciens, and Bacteroides succinogenes. When a soluble carbohydrate was added to cellulose broth, the lag phase of cellulose digestion was shortened. Presumably, this was due to greater numbers of bacteria, because increasing the size of the inoculum had a similar effect. Cellulose digestion occurred simultaneously with utilization of the soluble carbohydrate. The rate of cellulose digestion slowed markedly for B. succinogenes and R. flavefaciens and slowed less for R. albus after the cellobiose or glucose had been utilized, and was accompanied by a decrease in pH. Both the rate and the extent of cellulose digestion were partially inhibited when the initial pH of the medium was 6.3 or below. R. albus appeared to be less affected by a low-pH medium than were B. succinogenes and R. flavefaciens. When a soluble carbohydrate was added to the fermentation during the maximum-rate phase of cellulose digestion, the rate of cellulose digestion was not affected until after the soluble carbohydrate had been depleted and the pH had decreased markedly. Prolonged exposure of the bacteria to a low pH had little if any effect on their subsequent ability to digest cellulose. Cellulase activity of intact bacterial cells appeared to be constitutive in nature for these three species of rumen bacteria.     

Response surface analysis of the effects of pH and dilution rate on Ruminococcus flavefaciens FD-1 in cellulose-fed continuous culture.

The ruminal cellulolytic bacterium Ruminococcus flavefaciens FD-1 was grown in cellulose-fed continuous culture with 20 different combinations of pH and dilution rate (D); the combinations were selected according to the physiological pH range of the organism (6.0 to 7.1) and growth rate of the organism on cellulose (0.017 to 0.10 h-1). A response surface analysis was used to characterize the effects of pH and D on the extent of cellulose consumption, growth yield, soluble sugar concentration, and yields of fermentation products. The response surfaces indicate that pH and D coordinately affect cellulose digestion and growth yield in this organism. As expected, the net cellulose consumption increased with increasing D while the fraction of added cellulose that was utilized decreased with increasing D. The effect of changes in pH within the physiological range on cellulose consumption was smaller than that of changes in D. Cellulose degradation was less sensitive to low pH than to high pH. At low Ds (longer retention times), cellulose degradation did not follow first-order kinetics. This decreased rate of cellulose digestion was not due to poor mixing, limitation by other medium components, or preferential utilization of the more amorphous fraction of the cellulose. The cell yield increased from 0.13 to 0.18 mg of cells per mg of cellulose with increasing Ds from 0.02 to 0.06 h-1 and decreased when the pH was shifted from the optimum of 6.5 to 6.8. The effect of pH on cell yield increased with increasing D. The reduced cell yield at low pH appears to be due to both an increase in maintenance energy requirements and a decrease in true growth yield.     

Response surface analysis of the effects of pH and dilution rate on Ruminococcus flavefaciens FD-1 in cellulose-fed continuous culture.

The ruminal cellulolytic bacterium Ruminococcus flavefaciens FD-1 was grown in cellulose-fed continuous culture with 20 different combinations of pH and dilution rate (D); the combinations were selected according to the physiological pH range of the organism (6.0 to 7.1) and growth rate of the organism on cellulose (0.017 to 0.10 h-1). A response surface analysis was used to characterize the effects of pH and D on the extent of cellulose consumption, growth yield, soluble sugar concentration, and yields of fermentation products. The response surfaces indicate that pH and D coordinately affect cellulose digestion and growth yield in this organism. As expected, the net cellulose consumption increased with increasing D while the fraction of added cellulose that was utilized decreased with increasing D. The effect of changes in pH within the physiological range on cellulose consumption was smaller than that of changes in D. Cellulose degradation was less sensitive to low pH than to high pH. At low Ds (longer retention times), cellulose degradation did not follow first-order kinetics. This decreased rate of cellulose digestion was not due to poor mixing, limitation by other medium components, or preferential utilization of the more amorphous fraction of the cellulose. The cell yield increased from 0.13 to 0.18 mg of cells per mg of cellulose with increasing Ds from 0.02 to 0.06 h-1 and decreased when the pH was shifted from the optimum of 6.5 to 6.8. The effect of pH on cell yield increased with increasing D. The reduced cell yield at low pH appears to be due to both an increase in maintenance energy requirements and a decrease in true growth yield.     

Establishment and development of ruminal hydrogenotrophs in methanogen-free lambs

The aim of this work was to determine whether reductive acetogenesis can provide an alternative to methanogenesis in the rumen. Gnotobiotic lambs were inoculated with a functional rumen microbiota lacking methanogens and reared to maturity on a fibrous diet. Lambs with a methanogen-free rumen grew well, and the feed intake and ruminal volatile fatty acid concentrations for lambs lacking ruminal methanogens were lower but not markedly dissimilar from those for conventional lambs reared on the same diet. A high population density (10(7) to 10(8) cells g(-1)) of ruminal acetogens slowly developed in methanogen-free lambs. Sulfate- and fumarate-reducing bacteria were present, but their population densities were highly variable. In methanogen-free lambs, the hydrogen capture from fermentation was low (28 to 46%) in comparison with that in lambs containing ruminal methanogens (>90%). Reductive acetogenesis was not a significant part of ruminal fermentation in conventional lambs but contributed 21 to 25% to the fermentation in methanogen-free meroxenic animals. Ruminal H(2) utilization was lower in lambs lacking ruminal methanogens, but when a methanogen-free lamb was inoculated with a methanogen, the ruminal H(2) utilization was similar to that in conventional lambs. H(2) utilization in lambs containing a normal ruminal microflora was age dependent and increased with the animal age. The animal age effect was less marked in lambs lacking ruminal methanogens. Addition of fumarate to rumen contents from methanogen-free lambs increased H(2) utilization. These findings provide the first evidence from animal studies that reductive acetogens can sustain a functional rumen and replace methanogens as a sink for H(2) in the rumen.     

Bioconversion of wheat stalk to hydrogen by dark fermentation: effect of different mixed microflora on hydrogen yield and cellulose solubilisation

This study determined hydrogen production, volatile fatty acids (VFAs) generation and cellulose solubilisation from anaerobic dark fermentation of wheat stalk and showed the effect of different mixed microflora. The cumulative hydrogen yields of anaerobic digested activated sludge (AS)-inoculated and anaerobic digested dairy manure (DM)-inoculated system were 23.3 and 37.0 mL/g VS at 204 h, respectively. A modified Gompertz equation was able to adequately describe the production of hydrogen from the batch fermentation by both mixed microflora. During the process, acetate and butyrate accounted for more than 76.1% of total VFAs for both fermentations. The extent of cellulose solubilisation approached 46.6% and 75.2% for AS- and DM-inoculated fermentation, respectively. The X-ray diffraction (XRD) showed that the crystallinities of both fermented stalks were partly disrupted by the mixed microflora, and DM-inoculated fermentation had more disruption than AS-inoculated one.