低温脂肪酶的产酶条件优化及其酶学性质

利用单因素筛选和正交试验对Burkholderia sp. SYBC LIP-Y发酵产酶的液体培养基和发酵条件进行了优化,其优化配方为：可溶性淀粉10 g/L、牛肉膏15 g/L、NaNO3 0.252 g/L、橄榄油40ml/L、Triton x-100 10ml/L、初始pH 7.5、接种量10%(V/V),脂肪酶酶活达到85.23U/ml,是优化前的3.63倍。通过对双水相纯化得到的脂肪酶进行酶学性质研究,确定该酶反应的最适pH为10.0,最适温度为30℃,40℃下保温60min酶活性还有80%以上,该脂肪酶为低温脂肪酶,热稳定性好,具有一定的耐醇性,应用前景广阔。     

鹰嘴豆孢克鲁维酵母利用菊芋原料同步糖化与发酵生产乙醇

菊芋含有大量的菊粉多糖,且种植简单、产量高,是极具开发价值的替代玉米等粮食作物生产燃料乙醇的原料。文中研究了鹰嘴豆孢克鲁维酵母Y179利用菊芋原料同步糖化与发酵生产乙醇。鹰嘴豆孢克鲁维酵母Y179具有高效分泌菊粉酶的能力,摇瓶试验显示Y179酵母能够利用完全由菊芋原料配制而成的培养基良好生长并发酵产生乙醇。通气及温度对乙醇产量影响明显,相对厌氧环境对Y179酵母发酵产乙醇具有促进作用,30℃发酵温度相对37℃和42℃更有利于乙醇产量提高。种子液培养时间及接种量对乙醇产量影响较小。在5 L发酵罐中以10%(V/V)量接入预培养36 h的Y179种子液,发酵液完全由菊芋干粉配制而成,总糖含量22%(W/V),30℃不通气,300 r/min搅拌,发酵144 h时,乙醇浓度达到12.3%(V/V),糖醇转化效率86.9%,糖利用率大于93.6%。初步研究结果显示鹰嘴豆孢克鲁维酵母Y179在利用菊芋原料生产乙醇方面具有良好应用前景。     

假丝酵母E-2产生物表面活性剂摇瓶发酵条件的优化

从扬子石化的废水淤泥中筛选到1株能发酵液体石蜡产脂肽类生物表面活性剂的假丝酵母Candida E-2.通过单因子实验和正交试验,得到了最佳发酵培养基组成(g/L):牛肉膏3.0,蔗糖2.0,酵母膏0.25,KH2PO4 12.5,MgSO4 0.3,NaCl 1.5,CaCl,0.05,尿素0.5 5;液体石蜡10％(体积分数).最佳培养条件:初始pH7.0,接种量0.12g/L,装液量为200mL三角瓶30mL,培养时间为5 d.最终产量提高了2.7倍,达1.582g/L.     

脂肪酶抑制剂产生菌Bacillus sp.LF深层发酵条件研究

随着生活水平的不断提高 ,肥胖在中国也开始成为影响人们健康的主要危险之一。目前市场上常见的减肥产品主要是作用于大脑 ,通过抑制食欲减少食物的摄入 ,由于这类药可能产生大脑、心血管及神经系统的副作用 ,不宜长期使用。瘦素 (Leptin)是一种肥胖基因表达的多肽激素 ,也是通过食欲中枢发挥作用 ,可以抑制食欲 ,提高代谢率 ,达到减肥的目的。因而另一类减肥药品脂肪酶抑制剂近年来受到国内外重视。脂肪酶抑制剂可直接阻断人体对脂肪的吸收 ,它不需要通过影响中枢神经系统来抑制人体的食欲 ,而是阻止脂肪在胃肠道的吸收。文献报道脂肪酶抑…     

Schizophyllan production by newly isolated fungus <Emphasis Type="Italic">Schizophyllum commune</Emphasis> IBRC-M 30213: optimization of culture medium using response surface methodology

Schizophyllan (SPG) is a commercially attractive biopolymer produced by Schizophyllum commune. An investigation on the potential for SPG production by Iranian native S. commune was conducted based on culture medium, fermentation conditions and bioreactor type, . Nine native fungal strains were isolated from the northern forest of Iran at different times. Based on growth rate and SPG production, one strain was selected for further study. Optimal medium composition and inoculum size for maximizing SPG production and minimizing biomass were determined using central composite design by setting sucrose, yeast extract, inoculum size, carboxymethyl cellulose and oleic acid in the ranges of 50–200 g/L, 1–4 g/L, 2–10%, 2–12 g/L and 0.032–0.222%, respectively. The results showed that optimal results were obtained at 93.47 g/L sucrose, 1.87 g/L yeast extract, 7.68% inoculum size, 9.07 g/L carboxymethyl cellulose and 0.13% oleic acid, with maximum SPG production of 9.97 g/L and minimum biomass of 35.18 g/L. Under these optimal conditions, the production of SPG was studied in stirred tank and bubble column bioreactors. The results revealed greater production in the stirred tank because of better mixing of the culture medium. The SPG produced was characterized using rheometery, Fourier transform infrared spectroscopy, nuclear magnetic resonance), scanning electron microscopy and gel permeation chromatography. The results of these characterizations demonstrated the similarity of the SPG produced by S. commune IBRC-M 30213 to commercial SPG. Thus, the SPG produced shows good potential as a polysaccharide for use in various industries.     

Role of some fermentation parameters on cyclosporin A production by a new isolate of Aspergillus terreus

A local isolate of Aspergillus terreus was selected among different microorganisms as a new cyclosporin A (Cy A) producing culture. The formation of Cy A was investigated under different fermentation conditions (including selection of the cultivation medium, fermentation time course, inoculum nature, medium volume, agitation rate, pH value). Relatively high Cy A productivities were maintained when the fermentation process was carried out using a medium composed of (g/L): glucose, 50; bactopeptone, 10; KH(2)PO(4), 5; KCl, 2.5; pH 5.3, inoculated with 2% standard inoculum of 48 h age, shaken at 200 rpm for 10 days.     

Influence of total solid and inoculum contents on performance of anaerobic reactors treating food waste

The aim of this paper was to analyze the biomethanization process of food waste (FW) from a university campus restaurant in six reactors with three different total solid percentages (20%, 25% and 30% TS) and two different inoculum percentages (20-30% of mesophilic sludge). The experimental procedure was programmed to select the initial performance parameters (total solid and inoculum contents) in a lab-reactor with V: 1100mL and, later, to validate the optimal parameters in a lab-scale batch reactor with V: 5000mL. The best performance for food waste biodegradation and methane generation was the reactor with 20% of total solid and 30% of inoculum: give rise to an acclimation stage with acidogenic/acetogenic activity between 20 and 60 days and methane yield of 0.49L CH4/g VS. Also, lab-scale batch reactor (V: 5000mL) exhibit the classical waste decomposition pattern and the process was completed with high values of methane yield (0.22L CH4/g VS). Finally, a protocol was proposed to enhance the start-up phase for dry thermophilic anaerobic digestion of food waste.     

裸脚菇0612-9液体菌种优化及其对后续发酵产活性物质的影响

裸脚菇0612-9次级代谢产物具有强烈抗青绿霉活性,可作为微生物源防腐剂用于柑橘保藏,但是其发酵周期长,产出能耗大效率低。用摇瓶对裸脚菇0612-9的液体菌种培养基、培养条件进行优化并对优化后液体菌种接种种龄、接种量进行探索,最后用5L发酵罐进行放大发酵验证。取样计数测定菌丝球数量、过滤称重测定菌丝干重、HPLC监测活性物质Ⅱ的积累、牛津杯法评价抗青绿霉活性。经研究最佳碳源为玉米粉和麦芽糖,最佳氮源为蛋白胨,最佳液体菌种培养基组成为：玉米粉30g/L、麦芽糖10g/L、蛋白胨15g/L、KH₂PO₄ 2g/L、MgSO₄·7H₂O 1g/L;最佳培养条件：起始pH 5、接种3×Ф7mm菌块、装液量100mL/250mL三角瓶、温度28℃、转速160r/min;优化前菌丝球数46个/10mL,菌丝干重0.28g/100mL,优化后菌球数达985个/10mL,菌丝干重达0.69g/100mL,分别为优化前的21.4倍、2.43倍;后续发酵使用种龄9d的液体菌种、接种量7.5%。优化后液体菌种在发酵罐中后续发酵周期从10d缩短至5d,缩短50%,产量比优化前提高8.28%。     

A glycerol-inducible thermostable lipase from Bacillus sp.: medium optimization by a Plackett-Burman design and by response surface methodology

The production of a neutral lipase from a Bacillus sp. was improved tremendously (193-fold) following media optimization involving both the "one-at-a-time" and the statistical designing approaches. The present lipase was poorly induced by oils, instead its production was induced in the presence of sugars and sugar alcohols, mainly galactose, lactose, glycerol, and mannitol. A high inoculum density of 15% v/v (A550 = 0.8) led to maximum lipase production. Interestingly, the enzyme induction was growth independent, a property very different from most of the lipases investigated to date. The optimal composition of the growth medium to achieve maximum lipase production was determined to be as follows: NH4Cl, 35 g x L(-1); glycerol, 10 mL x L(-1); K2HPO4, 3 g x L(-1); KH2PO4, 1 g x L(-1); MgSO4.7H2O, 0.1 g x L(-1); glucose, 2 g x L(-1); MgCl2, 0.6 mmol x L(-1), with 15% inoculum density and an incubation period of 24 h. About 62 U x mL(-1) of enzyme production was achieved in the optimized medium.     

Optimization of bacteriocin production by batch fermentation of Lactobacillus plantarum LPCO10

Optimization of bacteriocin production by Lactobacillus plantarum LPCO10 was explored by an integral statistical approach. In a prospective series of experiments, glucose and NaCl concentrations in the culture medium, inoculum size, aeration of the culture, and growth temperature were statistically combined using an experimental 2(3)(5-2) fractional factorial two-level design and tested for their influence on maximal bacteriocin production by L. plantarum LPCO10. After the values for the less-influential variables were fixed, NaCl concentration, inoculum size, and temperature were selected to study their optimal relationship for maximal bacteriocin production. This was achieved by a new experimental 3(2)(3-1) fractional factorial three-level design which was subsequently used to build response surfaces and analyzed for both linear and quadratic effects. Results obtained indicated that the best conditions for bacteriocin production were shown with temperatures ranging from 22 to 27 degrees C, salt concentration from 2.3 to 2.5%, and L. plantarum LPCO10 inoculum size ranging from 10(7.3) to 10(7.4) CFU/ml, fixing the initial glucose concentration at 2%, with no aeration of the culture. Under these optimal conditions, about 3.2 x 10(4) times more bacteriocin per liter of culture medium was obtained than that used to initially purify plantaricin S from L. plantarum LPCO10 to homogeneity. These results indicated the importance of this study in obtaining maximal production of bacteriocins from L. plantarum LPCO10 so that bacteriocins can be used as preservatives in canned foods.     

中国野生葡萄组织培养研究

对中国野生山葡萄左山—1、左山—2、燕山葡萄燕山—1和秋葡萄平利—7的叶片、叶柄、茎段及单芽茎段进行了离体培养研究。诱导左山—1叶片分化出不定芽的培养基为MS BA 5．0mg／L NAA0．1mg／L,诱导率2．5％;诱导平利—7叶柄分化出不定芽的培养基为MS BA7．0mg／L NAA0．1mg／L,诱导率1．95％;诱导左山—1、燕山—1和平利—7茎段分化出不定芽的培养基与叶柄相同,但诱导率相对较高,分别为8．25％、4．88％和6．49％;应用这一培养基对平利—7、左山—2的单芽茎段进行培养,丛状不定芽的诱导率均为100％。不定芽继代培养基为MS BA0．5mg／L IBA0．2mg／L;生根培养基为1／2MS IBA0．1—0.2mg／L。     

枯草芽孢杆菌B47菌株高产抗菌物质的培养基及发酵条件优化

枯草芽孢杆菌Bacillus subtilis B47菌株为番茄内生细菌, 也是玉米小斑病拮抗菌, 能产生对玉米小斑病菌有强烈抑制作用的抗菌物质。以B47菌株发酵液的无菌滤液对玉米小斑病菌的抗菌活性为检测指标, 测定B47菌株产抗菌物质培养所需的最佳碳、氮源和无机盐, 并通过正交试验法对该菌株产抗菌物质的培养基配方和摇瓶发酵条件进行优化。研究结果表明, B47菌株产抗菌物质最佳碳、氮源和无机盐分别为蔗糖、酵母浸膏和MgSO4·7H2O, 最优培养基是YSB (Yeast extract-sucrose-beef extract)培养基, 其配方为: 蔗糖2%, 酵母浸膏2%, 牛肉浸膏1.5%, MgSO4?7H2O 0.06%, FeSO4·7H2O 0.000 9%, 最优发酵条件组合为: 30 °C, pH 7.0, 170 r/min摇床培养6 d, 接种量为1%, 装液量为40 mL/200 mL。     

Metastatic capability of Leishmania (Viannia) panamensis and Leishmania (Viannia) guyanensis in golden hamsters

The pattern and kinetics of internal dissemination and frequency of cutaneous metastatic lesions resulting from experimental infection of golden hamsters with Leishmania (Viannia) panamensis and Leishmania (Viannia) guyanensis were examined. Nineteen strains were evaluated: 16 L. (V.) panamensis isolated from patients and 3 L. (V.) guyanensis, 2 isolated from human cases and 1 WHO reference strain originating from a sandfly vector. Lymphatic dissemination occurred within 3 mo and was observed for 16 of 16 (100%) of L. (V.) panamensis and 3 of 3 (100%) of L. (V.) guyanensis. Parasites were cultured infrequently from liver and spleen: 3 of 125 (2%) L. (V.) panamensis and 1 of 22 (5%) L. (V.) guyanensis. Decreased frequency of isolation from the inoculation site and draining lymph nodes over time was accompanied by increased frequency of isolation from distant lymph nodes. Dilution of triturated tissue samples resulted in an increased efficiency of parasite culture. Both primary lesions and secondary cutaneous metastatic lesions were more severe in hamsters infected with L. (V.) guyanensis than with L. (V.) panamensis. Cutaneous metastatic lesions were produced more frequently by L. (V.) guyanensis, 24 of 46 hamsters (52%), than by L. (V.) panamensis, 28 of 252 hamsters (11%). Individual Leishmania strains displayed distinctive propensities to produce cutaneous metastases, manifested as a reproducible phenotype. Metastatic pathogenicity was independent of the inoculum dose, supporting the dissociation of infectivity and pathogenicity.     

Kinetics of growth and ethanol production on different carbon substrates using genetically engineered xylose-fermenting yeast

Saccharomyces cerevisiae 424A (LNH-ST) strain was used for fermentation of glucose and xylose. Growth kinetics and ethanol productivity were calculated for batch fermentation on media containing different combinations of glucose and xylose to give a final sugar concentration of 20+/-0.8 g/L. Growth rates obtained in pure xylose-based medium were less than those for media containing pure glucose and glucose-xylose mixtures. A maximum specific growth rate micro(max) of 0.291 h(-1) was obtained in YPD medium containing 20 g/L glucose as compared to 0.206 h(-1) in YPX medium containing 20 g/L xylose. In media containing combinations of glucose and xylose, glucose was exhausted first followed by xylose. Ethanol production on pure xylose entered log phase during the 12-24h period as compared to the 4-10h for pure glucose based medium using 2% inoculum. When glucose was added to fermentation flasks which had been initiated on a pure xylose-based medium, the rate of xylose usage was reduced indicating cosubstrate inhibition of xylose consumption by glucose.     

Studies on microbial chromate reduction by Pseudomonas Sp. In aerobic continuous suspended growth cultures

Reduction of hexavalent chromium was studied in three bench-scale continuous stirred tank reactors. The inoculum was a culture of Pseudomonas sp., capable of giving 83% to 87% chromate reduction in 72-h batch assays with 60 mg Cr(VI) L(-1) in synthetic medium. The continuous culture studies were conducted for about 100 days using synthetic feed containing different levels of chromate (5 to 124 mg L(-1)) at 28 degrees to 30 degrees C and pH 6.8. The feed rate was varied over the range 0.5 to 1 L d(-1) to obtain hydraulic retention time of 36 to 72 h. Chromate reduction efficiency was 81% to 91% and 100% for influent Cr(VI) concentrations of 15 to 124 and 5 mg L(-1), respectively, with a hydraulic retention time of 72 h. (c) 1994 John Wiley & Sons, Inc.     

怀牛膝细胞悬浮培养及多糖含量变化的研究

采用正交实验设计研究基本培养基、碳源、2,4-D、6-BA、CH及接种量对怀牛膝悬浮培养细胞生长和细胞中多糖含量的影响。结果表明,(1)6-BA是影响怀牛膝细胞生长的关键因子,其影响效应依次为6-BA>CH>接种量>基本培养基>2,4-D>碳源,细胞生长的适宜培养基为MS 30 g/L葡萄糖 2 mg/L 2,4-D 1 mg/L 6-BA 0.5 g/L CH,适宜接种量为30 g/L。(2)碳源是影响细胞中多糖含量的关键因子,其影响效应依次为:碳源>2,4-D>6-BA>CH>接种量>基本培养基,利于细胞中多糖含量提高的适宜培养基为:LS 30 g/L蔗糖 0.5 mg/L 6-BA 0.5 g/L CH,适宜接种量为30 g/L。     

嗜线虫致病杆菌产生抗生素的培养基及条件

本对嗜线虫致病杆菌（Xenorhadbus nematophilus）产生抗生素的发酵培养基和发酵条件进行了研究,同时对该菌代谢过程pH值、还原糖、总糖、氨基氮与抗生素产量的关系进行了分析,通过筛选该菌对碳源和氮源的要求,用正交试验初步确定了该菌产素的最佳发酵培养基和条件为：玉米粉1％,大豆粉3％,蔗糖1％,蛋白胨1.5％,KH2PO40.02％,MgSO40.2％,活化剂T0.1％;发酵培养基的起始pH值在6.0－8.0,种龄16h,接种量4％,500mL摇瓶装量15－150mL的条件下培养72h可获得较高的抗生素产量;产素量与菌代谢过程中pH、还原糖、总糖和氨基氮的变化有一定关系,通过培养基和培养条件的研究使该菌的产抗生素能力提高了56.3％。     

低密度和条件培养对红豆杉细胞生长的影响

红豆杉种胚来源的细胞,在改良Ｂ５液体培养基中继代培养的临界接种密度为鲜重４０ｇ／Ｌ．低密度培养下,１０－１６ｄ的条件培养液（ＣＭ）与新鲜培养液按５７：４３的比例混合时,能显著缩短细胞生长的延迟期,提高生长率,１００Ｌ生物反应器中,按４５．５％体积分数添加条件培养液,在鲜重２７ｇ／Ｌ低接种密度下培养５周,生物量增长９倍,达干重１４．３ｇ／Ｌ．对内源植物激素、精胺、维生素和氨基酸等的比较分析表明,吲哚     

The effect of incubation conditions on the laboratory measurement of the methane producing capacity of livestock wastes

The effects of incubations conditions (dilution, mixing, incubation time and inoculum amount and origin) on the determination of the maximum methane producing capacity (B(0)) from various livestock slurries were evaluated. For this purpose, the methane yields of different livestock slurries were determined using batch anaerobic incubations performed at 30 degrees C as regard these different conditions. The B(0) and the methane (CH(4)) generation as a function of time were used to study the processes and to determine the best incubation conditions. Methanogenesis was identified as the major rate-limiting step during the anaerobic degradation of slurries, probably due to inhibition by volatile fatty acids. In some cases, high free NH(3) concentrations were suspected to inhibit the hydrolysis process. The addition of inoculum and/or the dilution of the substrate reduced the inhibition and allowed to reach the B(0) more rapidly. However, the addition of inoculum must be minimized to reduce the possible errors made by considering a similar production by the inoculum with and without the substrate. All experiments performed during this study allowed to define the incubation conditions required for the determination of the B(0) from livestock slurries. Applying these conditions, the B(0) values determined for swine slurries varied from 244 to 343L CH(4)kg V(added)(-1), from 204 to 296L CH(4)kg V(added)(-1) for dairy cattle slurries and equalled 386 and 319L CH(4)kg VS(added)(-1) respectively for calves and duck slurries.     

荷兰鸢尾(Iris xiphium L. var. hybridum)的组织培养

取荷兰鸢尾（ＩｒｉｓｘｉｐｈｉｕｍＬ．ｖａｒ．ｈｙｂｒｉｄｕｍ）鳞茎片不同部位外植体块,接种于附加不同激素配比的基本培养基上,其中取自鳞茎片基部外植体块２ｍｍ×２ｍｍ×２ｍｍ,培养基为ＭＳ＋ＢＡ１．０ｍｇ／Ｌ＋ＮＡＡ０．２ｍｇ／Ｌ的不定芽诱导率为最高（７０％）;最理想的增殖培养基为ＭＳ＋ＢＡ２．０ｍｇ／Ｌ＋ＮＡＡ０．２ｍｇ／Ｌ。不定芽直径４～５ｍｍ,培养基为ＭＳ＋ＢＡ０．２ｍｇ／Ｌ＋ＮＡＡ０．５ｍｇ／Ｌ有利于不定根的发生,诱导生根率达８３３％。试管苗不经练苗可直接出瓶,移栽于泥炭∶田土∶河沙＝１∶１∶１（Ｖ／Ｖ）的基质中。