Comparison of limulus amebocyte lysates and correlation with the United States Pharmacopeial pyrogen test.

Six limulus amebocyte lysate (LAL) preparations obtained from five different suppliers were evaluated for sensitivity, dependability, cost, convenience of use, and correlation with the United States Pharmacopeial (USP) rabbit pyrogen test method. Endotoxins from various gram-negative microorganisms were used for the evaluation. Major differences among the LAL preparations lie in the area of sensitivity. Differences, up to 100-fold, exist in the sensitivity of the various LAL preparations to the same endotoxin. The LAL tests in general were 3 to 300 times more sensitive than was the USP rabbit pyrogen test method. The LAL and the USP rabbit pyrogen test data correlated well when the endotoxin in a relatively pure and undegraded form was examined. However, large discrepancies in correlation were found when partially degraded endotoxins were compared. One LAL preparation responded to both intact and degraded endotoxin, whereas others responded only to intact endotoxin; the latter closely correlated with the febrile response of the rabbit. Therefore, proper selection of an LAL preparation is important for its application in clinical, pharmaceutical, public health, and environmental areas.     

A quantitative in vitro assay method for detecting biological activity of endotoxin using prostaglandin E2 induction in rabbit peripheral blood

The pyrogen test and the endotoxin test (the LAL test) have been playing crucial roles in detecting endotoxin in parenteral drugs. The current test methods, however, have disadvantages such as requiring a large number of animals or an inadequacy in evaluation of in vivo endotoxin activity. We attempted to establish a new assay method that can overcome the shortcomings of the current methods. We standardized the in vitro assay method by the use of prostaglandin E2 (PGE2) induction from peripheral blood of rabbits for detecting endotoxin activity. A linear dose-response regression was attained from approximately 0.15 to 5 endotoxin units/ml of Japanese national reference standard endotoxin by the in vitro assay. The assay showed a fine correlation with the pyrogen test but not with the LAL test, when endotoxins from various bacterial sources were tested. The in vitro assay was also shown to have the capability of detecting a synergistic effect of endotoxin and parenteral drugs. The in vitro PGE2 induction test using rabbit blood was, therefore, suggested to be the appropriate test method for guaranteeing the same level of safety of parenteral drugs as the pyrogen test does.     

Comparison of the rabbit pyrogen test and Limulus amoebocyte lysate (LAL) assay for endotoxin in hepatitis B vaccines and the effect of aluminum hydroxide.

The rabbit pyrogen test and Limulus amoebocyte lysate (LAL) assay have been used to detect endotoxins in vaccines, but interactions between the endotoxins and proteins or aluminum hydroxide can interfere with the results. Currently, the rabbit pyrogen test is used to detect endotoxin in hepatitis B (HB) vaccines even though the HB surface protein, the active ingredient, is over-expressed in and purified from eukaryotic cells which lack endotoxin. Therefore, we examined the possibility of replacing the animal tests with the more efficient LAL test. To this end, we determined whether the aluminum hydroxide in the HB vaccines affects the rabbit pyrogen test and the LAL assay. HB vaccines and HB protein solutions spiked with lipopolysaccharide (LPS) produced almost the same dose-dependent temperature rise in rabbits, indicating that the aluminum hydroxide in the HB vaccine does not interfere with the pyrogenic response in rabbit. In contrast, a spike recovery study showed that aluminum hydroxide interfered with the LAL clot and kinetic assays; however, the LAL clot assay was effective at detecting endotoxin without loss of LAL activity after serial dilution of the samples. Furthermore, there was good correlation in the LAL clot assay between the amount of LPS added and the amount recovered. However, both turbidimetric and chromogenic kinetic assays displayed no correlation between the LPS amount added and recovered. Our results suggest that the LAL clot assay is sensitive and reliable when samples are properly prepared, and can be used to replace the rabbit pyrogen test for the detection of endotoxin in HB vaccines.     

显色基质鲎试剂法在人血白蛋白热原检测中的应用

为了对显色基质法测定人血白蛋白中的内毒素含量方法进行探讨。以内毒素,鲎试剂及显色基质,在一定的条件下反应释放出对硝基苯胺(PNA),溶液呈现黄色,于波长545nm处比色读数,其产色深浅与内毒素浓度呈线性关系,从而定量测定出检品中内毒素含量。结果表明标准曲线的线性相关系数r≥0.98,人血白蛋白经3.3倍稀释后无干扰作用。显色基质法与家兔法比较,有灵敏、快速、能定量、重复性好的特点,可用于人血白蛋白内毒素含量的测定。     

Limulus amoebocyte lysate assay for detection and quantitation of endotoxin in a small-volume parenteral product.

A Limulus amoebocyte lysate gel-clotting method for the determination of endotoxin in a small-volume parenteral product has been described. Sample dilution with 0.1 M potassium phosphate monobasic buffer (pH 8.0) effectively eliminated assay interference, whereas dilution with water did not. The threshold pyrogenic dose for Escherichia coli EC-2 and O127:B8 endotoxins was determined to be 1.0 ng of endotoxin per kg of body weight. Not more than 1.0 ng of endotoxin (the threshold pyrogenic dose) per the highest recommended human dose or the USP pyrogen test dose per kg of body weight, whichever dose is more stringent, is a logical limit for the quantity of bacterial endotoxin in small-volume parenteral products. Excellent correlation was attained when this criterion was used to compare the Limulus amoebocyte lysate assay with the USP pyrogen test.     

Limulus amoebocyte lysate assay for detection and quantitation of endotoxin in a small-volume parenteral product

A Limulus amoebocyte lysate gel-clotting method for the determination of endotoxin in a small-volume parenteral product has been described. Sample dilution with 0.1 M potassium phosphate monobasic buffer (pH 8.0) effectively eliminated assay interference, whereas dilution with water did not. The threshold pyrogenic dose for Escherichia coli EC-2 and O127:B8 endotoxins was determined to be 1.0 ng of endotoxin per kg of body weight. Not more than 1.0 ng of endotoxin (the threshold pyrogenic dose) per the highest recommended human dose or the USP pyrogen test dose per kg of body weight, whichever dose is more stringent, is a logical limit for the quantity of bacterial endotoxin in small-volume parenteral products. Excellent correlation was attained when this criterion was used to compare the Limulus amoebocyte lysate assay with the USP pyrogen test.     

Measurements of lipopolysaccharide (endotoxin) in meningococcal protein and polysaccharide preparations for vaccine usage

Lipopolysaccharide (LPS, i.e. endotoxin) present in meningococcal outer-membrane protein and polysaccharide preparations made for vaccine use was quantitated by a silver-stain method following SDS-PAGE. The reactivities of LPS in the preparations were also measured by rabbit pyrogenicity and Limulus amoebocyte lysate (LAL) assay. Although rabbit pyrogenicity and LAL assay are more sensitive than the silver stain method, the latter provided an actual amount of LPS present in the protein or in the polysaccharide. For a meningococcal protein preparation, rabbit pyrogenicity showed about one-tenth, and even less by LAL assay, of the actual amount of LPS. This is because protein-bound LPS in meningococcal protein preparations is about 10-fold less active in causing fever in rabbits, and 20- to 40-fold less active in the gelation of LAL than the same amount of a purified free LPS which is generally used as a reference in quantitating LPS in these two assays. As for the small amount of LPS present in a meningococcal polysaccharide preparation, similar LPS content was obtained when measured by the three methods suggesting that the LPS is not bound to the polysaccharide in contrast to that in the proteins mentioned above. The purified meningococcal LPS was pyrogenic in rabbits at 1 ng/kg.     

鲎试剂在抗淋巴细胞免疫球蛋白热原检测中的应用

报道了鲎试剂在抗淋巴细胞免疫球蛋白内毒素检查中的应用。在用鲎试剂检测细菌内毒素时 ,按中国药典的要求对鲎试剂灵敏度进行标定 ,并作干扰实验 (增强或抑制实验 ) ,然后用鲎试法与家兔法同时测定 15批抗淋巴细胞免疫球蛋白。结果发现三批鲎试剂的灵敏度标示值均正确 ,五批抗淋巴细胞免疫球蛋白半成品在最大有效稀释度 (MVD)时对试验无干扰 ,这两种方法测定结果的符合率达到 91.7%。从而表明鲎试法很有可能代替家兔法     

Relative potencies of four reference endotoxin standards as measured by the Limulus amoebocyte lysate and USP rabbit pyrogen tests.

Four commonly used reference endotoxin standards, Escherichia coli O113:H10:K0, E. coli O55:B5, Salmonella abortusequi, and Shigella dysenteriae were compared by the USP rabbit pyrogen and the Limulus amoebocyte lysate tests. By the rabbit pyrogen test, S. abortus equi was identified as the most potent endotoxin, followed closely by E. coli O113:H10:K0 and E. coli O55:B5.     

抗淋巴细胞免疫球蛋白制品中热原处理

对热原不合格的抗淋巴细胞免疫球蛋白 (ALG)半制品再制条件进行了研究。将高热原的ALG半制品通过使用碱、酸以及A5 0处理后 ,细菌内毒素的含量明显降低 ,热原质经家兔和鲎试剂检测均合格 ,其生物学效价仍不低于 1 :4 0 0 0 ,而且它们的其它各项主要指标也都达到中国生物制品暂行规程的要求。这一试验结果表明碱、酸处理并辅以A5 0吸附是去除ALG制品中热原的一种有效方法     

A limulus amoebocyte lysate activating activity (LAL activity) that lacks biological activities of endotoxin found in biological products

Pyrogenic substances in influenza HA (IHA) vaccine have been controlled by the pyrogen test or the mouse body weight decreasing toxicity (BWD) test. We examined the possibility of replacing the animal tests with the endotoxin test Commercial IHA vaccines were found to show considerable levels of LAL activity ranging from 0.2 to 160 EU/ml. However, a batch of the vaccine having even 100 EU/ml of LAL activity showed neither pyrogenicity in rabbits nor tumor necrosis factor alpha (TNF-alpha) induction in RAW264.7 cells. The LAL activity of IHA vaccine was abolished by a monoclonal antibody that recognizes LPS-binding epitope of LAL factor C. The activity of IHA vaccine showed different physicochemical properties from those of LAL activity of endotoxin. LAL activity of endotoxin is known to be sensitive to polymyxin B treatment and was found to be resistant to polyoxyethylene 10 cetyl ether (Brij56) treatment. On the contrary, the LAL activity of IRA vaccine was shown to be resistant to polymyxin B but sensitive to Brij56 treatment. The difference in sensitivity of the two LAL activities to polymyxin B and Brij56 might suggest the possibility of their discriminative measurements.     

DNA疫苗的细菌内毒素检测

目的 :考察DNA疫苗细菌内毒素的检查方法的可行性及DNA疫苗的干扰作用。方法 :干扰试验和对比试验。结果 :供试品阴性对照系列样品溶液无干扰作用 ,与家兔法结果一致。结论 :将疫苗稀释 2倍可用灵敏度为 0 5EU ml的鲎试剂作细菌内毒素检查。     

Applicability of bacterial endotoxins test to various blood products by the use of endotoxin-specific lysates

Endotoxin contamination is a serious threat to the safety of parenteral drugs, and the rabbit pyrogen test has played a crucial role in controlling this contamination. Although the highly sensitive endotoxin test has replaced the pyrogen test for various pharmaceuticals, the pyrogen test is still implemented as the control test for most blood products in Japan. We examined the applicability of the endotoxin test to blood products for reliable detection and quantification of endotoxin. Nineteen types of blood products were tested for interfering factors based on spike/recovery of endotoxin by using 2 types of endotoxin-specific lysate reagents for photometric techniques. Interfering effects on the endotoxin test by the products could be eliminated by diluting from 1/2 to 1/16, with the exception of antithrombin III. However, conventional lysate reagents that also react with non-pyrogenic substances, such as (1–3)-β-d-glucan, produced results that were not relevant to endotoxin content or pyrogenicity. Our results showed that the endotoxin test would be applicable to most blood products if used with appropriate endotoxin-specific lysate reagents.     

Studies on Bacterial Pyrogenicity: III. Specificity of the United States Pharmacopeia Rabbit Pyrogen Test

The specificity of the first or “presumptive” portion of the USP rabbit pyrogen test was investigated by use of a new absolute standard of reference. The reference standard was a 0.9% sodium chloride solution prepared to be pyrogen-free. Details of the preparation were described. The hypothesis was explored that the temperature response of rabbits after intravenous injection of the standard solution was independent of exogenous pyrogen. Reactions observed among the rabbits in our colony allowed a classification of these animals ranging from “consistently reliable” to “consistently unreliable.” Details of the experimental results and implications for pyrogen testing are discussed. The recommendation was made that all rabbit test animals be “screened” in sham and actual tests before being used for pyrogen testing.     

Comparison and validation of novel pyrogen tests based on the human fever reaction

The Limulus amoebocyte lysate (LAL) test has replaced about 80% of the use of the rabbit pyrogen test. Ideally, human-based in vitro tests are needed, to replace the remaining use of the rabbit test and the use of the LAL test. The progress of an EU-funded project is described, in which a number of in vitro tests, based on the human fever reaction are passing through a prevalidation study on the way to evaluation in a formal validation study.     

Development of a highly sensitive in vitro assay method for biological activity of endotoxin contamination in biological products.

The pyrogen test in rabbits has been replaced by the bacterial endotoxin test. The endotoxin test, however, showed a considerable discrepancy with pyrogenicity and was, therefore, assumed to have an efficacy limitation in directly predicting harmful biological effects of endotoxin. We developed a sensitive in vitro assay method by making use of tumour necrosis factor alpha (TNF-alpha) induction in RAW264.7 cells, which showed a fine correlation with pyrogenicity in rabbits. RAW264.7 cells maintained by serial subculture under an endotoxin-free condition have gained the similar level of sensitivity as the endotoxin test to allow extensive dilutions of a drug for eliminating adverse effects on the cells. The in vitro TNF-alpha induction assay was shown to be capable to detect quantitatively a synergistic effect of a drug and endotoxin. The synergy is assumed necessary to be taken into consideration to define the limit value for the endotoxin test for guaranteeing the similar level of safety as by the pyrogen test.     

Sodium-Dependent Growth of Azotobacter chroococcum

Selected ion-monitoring gas chromatography-mass spectrometry was used for detection of beta-hydroxy fatty acids as an independent assay for the presence or absence of endotoxin in materials claimed to induce nonspecific activation of Limulus amoebocyte lysate. To this end, suspensions of gram-negative and -positive bacteria, one fungal species, cerebrospinal fluid, and hollow-fiber hemodialyzer rinses were assayed for endotoxin by gas chromatography-mass spectrometry and the Limulus amoebocyte lysate assay. Good qualitative agreement was shown for both methods when suspensions of test organisms were assayed. Two false-negative results were obtained by gas chromatography-mass spectrometry assays of cerebrospinal fluid and were shown to be a result of insufficient endotoxin in the cerebrospinal fluid specimens for detection by gas chromatography-mass spectrometry. Hemodialyzer rinses were Limulus assay positive; however, no beta-hydroxy fatty acids were detected by gas chromatography-mass spectrometry. These data were compared with data obtained from USP rabbit pyrogen tests of the rinse materials (nonpyrogenic) and chemical characterization of the Limulus assay-reactive rinses, which showed the rinses to be cellulosic in nature. It is suggested that beta-hydroxy fatty acids, as assayed by selected ion-monitoring gas chromatography-mass spectrometry, be used as chemical marker molecules for the presence or absence of endotoxin in materials reported to cause nonspecific activation of Limulus amoebocyte lysate.     

Study of the enterotoxic action of the neurotoxin of the Sonne dysentery microbe in a rabbit small intestine loop model]

The enterotoxic action of neurotoxin from Sonne dysentery microbes (obtained by the method of Mesrobeanu et al.), and also of the culture autolysates and homologous Boiven's endotoxin was studied on a model of the isolated loop of the rabbit small intestine. Neurotoxin preparations obtained from virulent strains as well as autolysates of these cultures possessed enterotoxic activity, whereas purifed endotoxin preparations in doses of 1--10 mg failed to cause any dilatation of the isolated intestinal segment. A significant individual rabbit sensitivity to the enterotoxic action of the neurotoxin preparation was revealed. Lyophilization of neurotoxin preparation did not influence its enterotoxicity. However dialysis against distilled water and boiling of the neurotoxin preparations led to the loss of enterotoxic activity.     

Sodium-Dependent Growth of Azotobacter chroococcum

Selected ion-monitoring gas chromatography-mass spectrometry was used for detection of beta-hydroxy fatty acids as an independent assay for the presence or absence of endotoxin in materials claimed to induce nonspecific activation of Limulus amoebocyte lysate. To this end, suspensions of gram-negative and -positive bacteria, one fungal species, cerebrospinal fluid, and hollow-fiber hemodialyzer rinses were assayed for endotoxin by gas chromatography-mass spectrometry and the Limulus amoebocyte lysate assay. Good qualitative agreement was shown for both methods when suspensions of test organisms were assayed. Two false-negative results were obtained by gas chromatography-mass spectrometry assays of cerebrospinal fluid and were shown to be a result of insufficient endotoxin in the cerebrospinal fluid specimens for detection by gas chromatography-mass spectrometry. Hemodialyzer rinses were Limulus assay positive; however, no beta-hydroxy fatty acids were detected by gas chromatography-mass spectrometry. These data were compared with data obtained from USP rabbit pyrogen tests of the rinse materials (nonpyrogenic) and chemical characterization of the Limulus assay-reactive rinses, which showed the rinses to be cellulosic in nature. It is suggested that beta-hydroxy fatty acids, as assayed by selected ion-monitoring gas chromatography-mass spectrometry, be used as chemical marker molecules for the presence or absence of endotoxin in materials reported to cause nonspecific activation of Limulus amoebocyte lysate.     

The concentration, physical state, and purity of bacterial endotoxin affect its detoxification by ionizing radiation

Increasing concentrations of a highly purified bacterial lipopolysaccharide preparation, the U.S. Reference Standard Endotoxin, were exposed to increasing doses of ionizing radiation from a 60Co source. At identical radiation doses both the structural change and Limulus amebocyte lysate (LAL) reactivity were progressively smaller with increasing concentrations of the lipopolysaccharide in an aqueous medium. Under the experimental conditions used, there was a linear relationship between the endotoxin concentration and radiation dose for the structural changes. In contrast to endotoxin in aqueous medium, endotoxin irradiated in its dry state showed no decrease in LAL reactivity and rabbit pyrogenicity. Endotoxin exposed to radiation in water in the presence of albumin showed a much smaller decrease in LAL and pyrogenic activities than expected. The results show that the concentration, physical state, and purity of endotoxin influence its structural and functional alteration by ionizing radiation.