Inactivation of Mycobacterium paratuberculosis in cows' milk at pasteurization temperatures.

The thermal inactivation of 11 strains of Mycobacterium paratuberculosis at pasteurization temperatures was investigated. Cows' milk inoculated with M. paratuberculosis at two levels (10(7) and 10(4) CFU/ml) was pasteurized in the laboratory by (i) a standard holder method (63.5 degrees C for 30 min) and (ii) a high-temperature, short-time (HTST) method (71.7 degrees C for 15 s). Additional heating times of 5, 10, 15, 20, and 40 min at 63.5 degrees C were included to enable the construction of a thermal death curve for the organism. Viability after pasteurization was assessed by culture on Herrold's egg yolk medium containing mycobactin J (HEYM) and in BACTEC Middlebrook 12B radiometric medium supplemented with mycobactin J and sterile egg yolk emulsion. Confirmation of acid-fast survivors of pasteurization as viable M. paratuberculosis cells was achieved by subculture on HEYM to indicate viability coupled with PCR using M. paratuberculosis-specific 1S900 primers. When milk was initially inoculated with 10(6) to 10(7) CFU of M. paratuberculosis per ml, M. paratuberculosis cells were isolated from 27 of 28 (96%) and 29 of 34 (85%) pasteurized milk samples heat treated by the holder and HTST methods, respectively. Correspondingly, when 10(3) to 10(4) CFU of M. paratuberculosis per ml of milk were present before heat treatment, M. paratuberculosis cells were isolated from 14 of 28 (50%) and 19 of 33 (58%) pasteurized milk samples heat treated by the holder and HTST methods, respectively. The thermal death curve for M. paratuberculosis was concave in shape, exhibiting a rapid initial death rate followed by significant "tailing." Results indicate that when large numbers of M. paratuberculosis cells are present in milk, the organism may not be completely inactivated by heat treatments simulating holder and HTST pasteurization under laboratory conditions.     

Inactivation of Salmonella Typhimurium and Listeria monocytogenes using high-pressure treatments: destruction or sublethal stress?

AIMS: To investigate potential resuscitation of Listeria monocytogenes and Salmonella Typhimurium after high hydrostatic pressure treatments. METHODS AND RESULTS: Pressure treatments were applied at room temperature for 10 min on bacterial suspensions in buffers at pH 7 and 5.6. Total bacterial inactivation (8 log(10) CFU ml(-1) of bacterial reduction) obtained by conventional plating was achieved regarding both micro-organisms. Treatments at 400 MPa in pH 5.6 and 600 MPa in pH 7 for L. monocytogenes and at 350 MPa in pH 5.6 and 400 MPa in pH 7 for S. Typhimurium were required respectively. A 'direct viable count' method detected some viable cells in the apparently totally inactivated population. Resuscitation was observed for the two micro-organisms during storage (at 4 and 20 degrees C) after almost all treatments. In the S. Typhimurium population, 600 MPa, 10 min, was considered as the treatment achieving total destruction because no resuscitation was observed under these storage conditions. CONCLUSIONS: We suggest a delay before performing counts in treated samples in order to avoid the under-evaluation of surviving cells. SIGNIFICANCE AND IMPACT OF THE STUDY: The resuscitation of pathogen bacteria after physical treatments like high hydrostatic pressure has to be considered from the food safety point of view. Further studies should be performed in food products to study this resuscitation phenomenon.     

Effects of high hydrostatic pressure on Clostridium sporogenes spores

Spores of Clostridium sporogenes were found to be resistant to ultra high pressure, with treatments of 600 MPa for 30 min at 20 °C causing no significant inactivation. Combination treatments including heat and pressure applied simultaneously (e.g. 400 MPa at 60 °C for 30 min) or sequentially (e.g. 80 °C for 10 min followed by 400 MPa for 30 min) proved more effective at inactivating spores. Pressure cycling (e.g. 60 MPa followed by 400 MPa at 60 °C) also reduced spore numbers. Overall, these pressure treatments resulted in less than a 3 log reduction, and it was concluded that the spores could not be inactivated by pressure alone. This could indicate that for the effective inactivation of bacterial spores, high pressure technology may have to be used in combination with other preservation methods.     

Combined effect of high-pressure treatments and bacteriocin-producing lactic acid bacteria on inactivation of Escherichia coli O157:H7 in raw-milk cheese

The effect of high-pressure (HP) treatments combined with bacteriocins of lactic acid bacteria (LAB) produced in situ on the survival of Escherichia coli O157:H7 in cheese was investigated. Cheeses were manufactured from raw milk inoculated with E. coli O157:H7 at approximately 10(5) CFU/ml. Seven different bacteriocin-producing LAB were added at approximately 10(6) CFU/ml as adjuncts to the starter. Cheeses were pressurized on day 2 or 50 at 300 MPa for 10 min or 500 MPa for 5 min, at 10 degrees C in both cases. After 60 days, E. coli O157:H7 counts in cheeses manufactured without bacteriocin-producing LAB and not pressurized were 5.1 log CFU/g. A higher inactivation of E. coli O157:H7 was achieved in cheeses without bacteriocin-producing LAB when 300 MPa was applied on day 50 (3.8-log-unit reduction) than if applied on day 2 (1.3-log-unit reduction). Application of 500 MPa eliminated E. coli O157:H7 in 60-day-old cheeses. Cheeses made with bacteriocin-producing LAB and not pressurized showed a slight reduction of the pathogen. Pressurization at 300 MPa on day 2 and addition of lacticin 481-, nisin A-, bacteriocin TAB 57-, or enterocin AS-48-producing LAB were synergistic and reduced E. coli O157:H7 counts to levels below 2 log units in 60-day-old cheeses. Pressurization at 300 MPa on day 50 and addition of nisin A-, bacteriocin TAB 57-, enterocin I-, or enterocin AS-48-producing LAB completely inactivated E. coli O157:H7 in 60-day-old cheeses. The application of reduced pressures combined with bacteriocin-producing LAB is a feasible procedure to improve cheese safety.     

Inactivation of Mycobacterium avium ssp. paratuberculosis in milk by UV treatment

Aims:  To determine the effect of UV radiation on the viability of two strains of Mycobacterium avium ssp. paratuberculosis (Map) inoculated into milk.
Methods and Results:  Mycobacterium avium ssp. paratuberculosis in a ultra heat treated milk matrix was subjected to increasing doses of UV-C radiation from 0 to 1836 mJ ml⁻¹ using a pilot-scale UV reactor (20 l capacity). Survival of Map was monitored by culture on Herrold's egg yolk medium, Middlebrook 7H10 medium and the FASTPlaque TB™ phage assay. Differences in sensitivity to UV treatment were observed between strains, however, at 1000 mJ ml⁻¹ a Map kill rate of 0·1–0·6 log₁₀ was achieved regardless of strain used or method employed to enumerate Map. Although the inactivation trend was similar on the culture and phage assay, the former gave a consistently higher viable count.
Conclusions:  The use of UV radiation alone does not represent an alternative to current pasteurization regimes for a large reduction in viable Map in milk.
Significance and Impact of the Study:  To the authors' knowledge the work here represents the first pilot-scale UV treatment process used to assess UV efficacy to inactivate Map in milk. The results are similar to those obtained with a laboratory-scale process indicating the difficulties associated with UV treatment of an opaque liquid and the recalcitrance of Map towards inimical treatments.     

Comparison of contamination and growth of Mycobacterium avium subsp. paratuberculosis on two different media

AIMS: The purpose of the study was to compare the growth of Mycobacterium avium subsp. paratuberculosis (Map) and the degree of contamination on Herrold's egg yolk medium (HEYM) and modified L?wenstein-Jensen medium (LJ). METHODS AND RESULTS: Culture of 2513 faecal samples from dairy cows was performed on each of the two media. The media were read after 5, 8 and 12 weeks of incubation. Overall, the proportion of contaminated samples was significantly higher on LJ (14.2%) than on HEYM (13.2%) after 12 weeks but the degree of contamination was slightly less on LJ. After 8 weeks of incubation, only 1.0% of the samples were Map positive in LJ with 4.9% on HEYM. After 12 weeks of incubation, 3.3% of the samples were Map positive in LJ whereas 6.9% were positive in HEYM. All suspect and culture positive samples were confirmed by IS900 PCR. CONCLUSIONS: HEYM supported growth of Map significantly better and faster than LJ, however it could not be determined conclusively which of the two media that provided the highest degree of decontamination when the incubation time was also included. SIGNIFICANCE AND IMPACT OF THE STUDY: HEYM should be the primary medium rather than LJ for detection of Map in cattle.     

Combined Effect of High-Pressure Treatments and Bacteriocin-Producing Lactic Acid Bacteria on Inactivation of Escherichia coli O157:H7 in Raw-Milk Cheese

The effect of high-pressure (HP) treatments combined with bacteriocins of lactic acid bacteria (LAB) produced in situ on the survival of Escherichia coli O157:H7 in cheese was investigated. Cheeses were manufactured from raw milk inoculated with E. coli O157:H7 at approximately 10⁵ CFU/ml. Seven different bacteriocin-producing LAB were added at approximately 10⁶ CFU/ml as adjuncts to the starter. Cheeses were pressurized on day 2 or 50 at 300 MPa for 10 min or 500 MPa for 5 min, at 10°C in both cases. After 60 days, E. coli O157:H7 counts in cheeses manufactured without bacteriocin-producing LAB and not pressurized were 5.1 log CFU/g. A higher inactivation of E. coli O157:H7 was achieved in cheeses without bacteriocin-producing LAB when 300 MPa was applied on day 50 (3.8-log-unit reduction) than if applied on day 2 (1.3-log-unit reduction). Application of 500 MPa eliminated E. coli O157:H7 in 60-day-old cheeses. Cheeses made with bacteriocin-producing LAB and not pressurized showed a slight reduction of the pathogen. Pressurization at 300 MPa on day 2 and addition of lacticin 481-, nisin A-, bacteriocin TAB 57-, or enterocin AS-48-producing LAB were synergistic and reduced E. coli O157:H7 counts to levels below 2 log units in 60-day-old cheeses. Pressurization at 300 MPa on day 50 and addition of nisin A-, bacteriocin TAB 57-, enterocin I-, or enterocin AS-48-producing LAB completely inactivated E. coli O157:H7 in 60-day-old cheeses. The application of reduced pressures combined with bacteriocin-producing LAB is a feasible procedure to improve cheese safety.     

Reduction of Escherichia coli O157:H7 by stimulated Pediococcus acidilactici

This study was conducted to determine if stimulating the growth of meat starter culture (Pediococcus acidilactici) in a laboratory medium (Brain Heart Infusion broth +2.3% NaCl + 1.5% sucrose; LBHI) and during meat fermentation would control Escherichia coli O157:H7. In LBHI medium without P. acidilactici, the numbers of E. coli O157:H7 increased from 4.00 to 8.34 log10 cfu ml-1, whereas in the presence of P. acidilactici (approximately 6.0 log10 cfu ml-1) in LBHI, LBHIM (LBHI + 0.005% MnSO4), LBHIO (LBHI + 0.3 unit ml-1 Oxyrase), and LBHIMO (LBHI + M + O), the numbers of E. coli O157:H7 increased from 4.00 to 8.05, 7.50, 7.99, and 6.50 log10 cfu ml-1, respectively, after incubation at 40 degrees C for 15 h. During salami fermentation, the numbers of E. coli O157:H7 changed from 7.00 to 6.40 and 5.10 log10 cfu g-1 without and with P. acidilactici (approximately 7.0 log10 cfu g-1), respectively. Stimulated P. acidilactici by M, O, and MO further reduced the number of E. coli O157:H7 from 7.00 to 4.00, 4.80, and 3.65 log10 cfu g-1, respectively. The combination of MO was a better growth stimulator for P. acidilactici, which controlled E. coli O157:H7 in both systems (P < 0.05).     

Resistance of Faecal Coliforms and Enterococci Populations in Sludge and Biosolids to Different Hygienisation Treatments

The composition of the most abundant facultative anaerobic bacteria populations [faecal coliforms (FC) and enterococci (ENT)] in sludge can be modified after different treatments. These involve the disposal or reuse of sludge and include: anaerobic digesters, incineration, composting, pasteurization and lime treatments. In this study, three treatment types (mesophilic anaerobic digestion, composting and pasteurization) were compared in terms of their ability to reduce both bacterial populations. The diversity and any changes in composition of main phenotypic groups for both populations were also analyzed. Mesophilic anaerobic digestion (MAD) was carried out at 35°C for 20 days. Digested sludge was then dehydrated by centrifugation at 2,500 rpm. Composting (COM) was performed at 55°C with windrow phases. Pasteurization was assayed at 60°C for 90 min (P60), at 80°C for 60 min (P80). A 1–1.5 log unit reduction was observed for FC, and 1 log unit reduction was noted for ENT by MAD treatment. In composting, this reduction proved higher for FC than for ENT (6 log and 3–4 log units, respectively). Optimal pasteurization was obtained at 80°C for 60 min, resulting in a 5 log unit reduction for FC and a 2 log unit reduction for ENT. High diversity indices (Di) for both bacterial populations were detected both before and after implementation of the different treatments. Analyses of the population’s similarity provided that FC were diverse both before and after COM, P60 and P80 treatments. However, no differences were observed on the composition of ENT populations after the different treatments assayed.     

Reduction of Escherichia coli O157:H7 populations in cattle by addition of colicin E7-producing E. coli to feed

A cattle trial using artificially inoculated calves was conducted to determine the effect of the addition of colicinogenic Escherichia coli strains capable of producing colicin E7 (a 61-kDa DNase) to feed on the fecal shedding of serotype O157:H7. The experiment was divided into three periods. In period 1, which lasted 24 days, six calves were used as controls, and eight calves received 10(7) CFU of E. coli (a mixture of eight colicinogenic E. coli strains) per g of feed. Both groups were orally inoculated with nalidixic acid-resistant E. coli O157:H7 strains 7 days after the treatment started. In periods 2 and 3, the treatment and control groups were switched, and the colicinogenic E. coli dose was increased 10-fold. During period 3, which lasted as long as period 1, both groups were reinoculated with E. coli O157:H7. The numbers of E. coli O157:H7 were consistently greater in the control groups during the three periods, but comparisons within each time period determined a statistically significant (P < 0.05) difference only at day 21 of period 1. However, when the daily average counts were compared between the period 1 control group and the period 3 treatment group that included the same six animals, an overall reduction of 1.1 log(10) CFU/g was observed, with a maximum decrease of 1.8 log(10) CFU/g at day 21 (overall statistical significance, P = 0.001). Serotype O157:H7 was detected in 44% of the treatment group's intestinal tissue samples and in 64% of those from the control group (P < 0.04). These results indicated that the daily addition of 10(8) CFU of colicin E7-producing E. coli per gram of feed could reduce the fecal shedding of serotype O157:H7.     

High-pressure inactivation of Saccharomyces cerevisiae and Lactobacillus plantarum at subzero temperatures

High hydrostatic pressure is a new technology in the food processing industry, and is used for cold pasteurization of food products. However, the pressure inactivation of food-borne microorganisms requires very high pressures (generally more than 400 MPa) and long pressure holding times (5 min or more). Carrying out pressure processing at low temperatures without freezing can reduce these parameters, which presently limit the application of this technology, in keeping the quality of fresh raw product. The yeast, Saccharomyces cerevisiae and the bacterium, Lactobacillus plantarum were pressurized for 10 min at temperatures between -20 and 25 degrees C and pressure between 100 and 350 MPa. Pressurization at subzero temperatures without freezing significantly enhanced the effect of pressure. For example, at a pressure of 150 MPa, the decrease in temperature from ambient to -20 degrees C allowed an increase in the pressure-induced inactivation from less than 1 log up to 7-8 log for each microorganism studied. However, for comparable inactivation levels, the kinetics of microorganism inactivation did not differ, which suggests identical inactivation mechanisms. Implications of water thermodynamical properties like compression, protein denaturation, as well as membrane phase transitions, are discussed.     

Effect of higher pasteurization temperatures, and longer holding times at 72°C, on the inactivation of Mycobacterium paratuberculosis in milk

Raw cow's milk spiked with 10(6) cfu ml-1 of Mycobacterium paratuberculosis was subjected to heat treatments of 72, 75, 78, 80, 85 or 90 degrees C for 15 s, and 72 degrees C for 20 and 25 s, using laboratory pasteurizing units. Three bovine strains of Myco. paratuberculosis were studied (NCTC 8578, B2 and DVL 943). Each strain was subjected to all the heat treatments indicated on three separate occasions. Although each of the heat treatments achieved a substantial (5-6 log10) reduction in numbers of viable Myco. paratuberculosis, small numbers of the organism (4-16 cfu 10 ml-1) survived in a proportion of the milk samples at each of the higher temperatures investigated, right up to 90 degrees C for 15 s. A longer holding time of 25 s at 72 degrees C was found to be more effective at inactivating Myco. paratuberculosis. Only one of the three strains studied, B2, yielded small numbers of survivors after heating at 72 degrees C for 20 s, but it was completely inactivated by extending the holding time at 72 degrees C by a further 5 s to 25 s. It was concluded that a longer holding time is more likely to achieve the complete inactivation of Myco. paratuberculosis in milk than a higher pasteurization temperature.     

Efficacy of various pasteurization time-temperature conditions in combination with homogenization on inactivation of Mycobacterium avium subsp. paratuberculosis in milk

The effect of various pasteurization time-temperature conditions with and without homogenization on the viability of Mycobacterium avium subsp. paratuberculosis was investigated using a pilot-scale commercial high-temperature, short-time (HTST) pasteurizer and raw milk spiked with 10(1) to 10(5) M. avium subsp. paratuberculosis cells/ml. Viable M. avium subsp. paratuberculosis was cultured from 27 (3.3%) of 816 pasteurized milk samples overall, 5 on Herrold's egg yolk medium and 22 by BACTEC culture. Therefore, in 96.7% of samples, M. avium subsp. paratuberculosis had been completely inactivated by HTST pasteurization, alone or in combination with homogenization. Heat treatments incorporating homogenization at 2,500 lb/in2, applied upstream (as a separate process) or in hold (at the start of a holding section), resulted in significantly fewer culture-positive samples than pasteurization treatments without homogenization (P < 0.001 for those in hold and P < 0.05 for those upstream). Where colony counts were obtained, the number of surviving M. avium subsp. paratuberculosis cells was estimated to be 10 to 20 CFU/150 ml, and the reduction in numbers achieved by HTST pasteurization with or without homogenization was estimated to be 4.0 to 5.2 log10. The impact of homogenization on clump size distribution in M. avium subsp. paratuberculosis broth suspensions was subsequently assessed using a Mastersizer X spectrometer. These experiments demonstrated that large clumps of M. avium subsp. paratuberculosis cells were reduced to single-cell or "miniclump" status by homogenization at 2,500 lb/in2. Consequently, when HTST pasteurization was being applied to homogenized milk, the M. avium subsp. paratuberculosis cells would have been present as predominantly declumped cells, which may possibly explain the greater inactivation achieved by the combination of pasteurization and homogenization.     

Combinations of intervention treatments resulting in 5-log10-unit reductions in numbers of Escherichia coli O157:H7 and Salmonella typhimurium DT104 organisms in apple cider

The U.S. Food and Drug Administration (FDA) recently mandated a warning statement on packaged fruit juices not treated to reduce target pathogen populations by 5 log10 units. This study describes combinations of intervention treatments that reduced concentrations of mixtures of Escherichia coli O157:H7 (strains ATCC 43895, C7927, and USDA-FSIS-380-94) or Salmonella typhimurium DT104 (DT104b, U302, and DT104) by 5 log10 units in apple cider with a pH of 3.3, 3.7, and 4.1. Treatments used were short-term storage at 4, 25, or 35 degrees C and/or freeze-thawing (48 h at -20 degrees C; 4 h at 4 degrees C) of cider with or without added organic acids (0.1% lactic acid, sorbic acid [SA], or propionic acid). Treatments more severe than those for S. typhimurium DT104 were always required to destroy E. coli O157:H7. In pH 3.3 apple cider, a 5-log10-unit reduction in E. coli O157:H7 cell numbers was achieved by freeze-thawing or 6-h 35 degrees C treatments. In pH 3.7 cider the 5-log10-unit reduction followed freeze-thawing combined with either 6 h at 4 degrees C, 2 h at 25 degrees C, or 1 h at 35 degrees C or 6 h at 35 degrees C alone. A 5-log10-unit reduction occurred in pH 4.1 cider after the following treatments: 6 h at 35 degrees C plus freeze-thawing, SA plus 12 h at 25 degrees C plus freeze-thawing, SA plus 6 h at 35 degrees C, and SA plus 4 h at 35 degrees C plus freeze-thawing. Yeast and mold counts did not increase significantly (P < 0.05) during the 6-h storage at 35 degrees C. Cider with no added organic acids treated with either 6 h at 35 degrees C, freeze-thawing or their combination was always preferred by consumers over pasteurized cider (P < 0.05). The simple, inexpensive intervention treatments described in the present work could produce safe apple cider without pasteurization and would not require the FDA-mandated warning statement.     

Evaluation of culture media for the recovery of Mycobacterium avium subsp. paratuberculosis from Cheddar cheese

AIMS: The study evaluated the efficacy of four Mycobacterium avium subsp. paratuberculosis (MAP) culture media in suppressing commonly used starter cultures and typical nonstarter microflora present during the manufacture and ripening of Cheddar cheese, with a view to identify a suitable medium for the enumeration of MAP during laboratory-scale Cheddar production. METHODS AND RESULTS: Four Cheddar starter cultures and Cheddar cheese manufactured with these starters were inoculated onto Herrold's egg yolk medium (HEYM); HEYM supplemented with vancomycin, amphotericin B and nalidixic acid (HEYM/VAN); Middlebrook 7H10 agar containing polymyxin, amphotericin B, nalidixic acid, trimethoprim and azlocillin (PANTA) antibiotic supplement; and BACTEC 12B radiometric medium with and without a preliminary decontamination step (0.75% w/v hexadecylpyridinium chloride (HPC), 5 h). The inclusion of a decontamination step inhibited all Cheddar cheese starter and nonstarter micro-organisms. The medium 7H10/PANTA and to a lesser extent HEYM/VAN were effective inhibitors of cheese microflora when no decontamination step was employed. CONCLUSIONS: Middlebrook 7H10 medium, supplemented with PANTA antibiotics, suppressed all micro-organisms associated with ripening Cheddar cheese manufactured with pasteurized milk. SIGNIFICANCE AND IMPACT OF THE STUDY: A MAP culture medium has been identified, which may be used to enumerate this bacterium during the laboratory manufacture and ripening of Cheddar cheese and hence facilitate further research into the persistence of this pathogen in the product.     

Increased salt- and nisin-sensitivity of pressure-injured bioluminescent Listeria monocytogenes

Suspensions of a bioluminescent (luxAB) transformant of Listeria monocytogenes in pH 7.0 phosphate buffer were pressurised and the effect of the pressure treatment was monitored by plate counting. When the bacteria were suspended in NaCl- and nisin-free buffer the number of colony forming units (CFU) decreased by 3 and 6 log cycles after 300 MPA for 10 and 30 min, respectively. Supplementing the plating medium with 5% NaCl did not influence the colony forming capacity of non-pressurised cells, however, CFU of residual populations after respective treatments of 300 MPa for 10 and 30 min were reduced by a further 2 and 3.5 log cycles in case of salt containing plates. Nisin-addition to the plating medium caused less than one log unit decrease in the CFU of the non-pressurised population. However, the CFU of 10 min-pressurised sample was 4 log cycles less in the nisin-containing plates than in the nisin-free ones, whereas no colonies were formed in the nisin-containing plates even when 1 ml was inoculated from the originally 10(10) CFU/ml population after 300 MPa for 30 min. The luciferase activities (bioluminescence intensities) decreased concomitant with the reduction of the viable cell counts, however, they were approx. 0.6-0.8 log units less in the presence of 5% NaCl in the pressurised suspension than those expected from the previously established linear correlation between the logarithmic light outputs and the logarithmic viable cell counts.     

Effect of high-temperature, short-time (HTST) pasteurization on milk containing low numbers of Mycobacterium paratuberculosis

The efficacy of high-temperature, short-time (HTST) pasteurization (72 °C/15 s) when low numbers (≤ 10³ cfu ml ⁻¹ ) of Mycobacterium paratuberculosis are present in milk was investigated. Raw cows' milk spiked with Myco. paratuberculosis (10³ cfu ml⁻¹, 10² cfu ml⁻¹, 10 cfu ml⁻¹, and 10 cfu 50 ml⁻¹) was subjected to HTST pasteurization using laboratory pasteurizing units. Ten bovine strains of Myco. paratuberculosis were tested in triplicate. Culture in BACTEC Middlebrook 12B radiometric medium detected acid-fast survivors in 14·8% and 10% of HTST-pasteurized milk samples at the 10³ and 10² cfu ml⁻¹ inoculum levels, respectively, whereas conventional culture on Herrold's egg yolk medium containing mycobactin J detected acid-fast survivors in only 3·7% and 6·7% of the same milk samples. IS900-based PCR confirmed that these acid-fast survivors were Myco. paratuberculosis . No viable Myco. paratuberculosis were isolated from HTST-pasteurized milk initially containing either 10 cfu ml⁻¹ or 10 cfu 50 ml⁻¹.     

Comparative survival of free shiga toxin 2-encoding phages and Escherichia coli strains outside the gut

The behavior outside the gut of seeded Escherichia coli O157:H7, naturally occurring E. coli, somatic coliphages, bacteriophages infecting O157:H7, and Shiga toxin 2 (Stx2)-encoding bacteriophages was studied to determine whether the last persist in the environment more successfully than their host bacteria. The ratios between the numbers of E. coli and those of the different bacteriophages were clearly lower in river water than in sewage of the area, whereas the ratios between the numbers of the different phages were similar. In addition, the numbers of bacteria decreased between 2 and 3 log units in in situ survival experiments performed in river water, whereas the numbers of phages decreased between 1 and 2 log units. Chlorination and pasteurization treatments that reduced by approximately 4 log units the numbers of bacteria reduced by less than 1 log unit the numbers of bacteriophages. Thus, it can be concluded that Stx2-encoding phages persist longer than their host bacteria in the water environment and are more resistant than their host bacteria to chlorination and heat treatment.     

Heat inactivation of Mycobacterium avium subsp. paratuberculosis in milk

The effectiveness of pasteurization and the concentration of Mycobacterium avium subsp. paratuberculosis in raw milk have been identified in quantitative risk analysis as the most critical factors influencing the potential presence of viable Mycobacterium paratuberculosis in dairy products. A quantitative assessment of the lethality of pasteurization was undertaken using an industrial pasteurizer designed for research purposes with a validated Reynolds number of 62,112 and flow rates of 3,000 liters/h. M. paratuberculosis was artificially added to raw whole milk, which was then homogenized, pasteurized, and cultured, using a sensitive technique capable of detecting one organism per 10 ml of milk. Twenty batches of milk containing 10(3) to 10(4) organisms/ml were processed with combinations of three temperatures of 72, 75, and 78 degrees C and three time intervals of 15, 20, and 25 s. Thirty 50-ml milk samples from each processed batch were cultured, and the logarithmic reduction in M. paratuberculosis organisms was determined. In 17 of the 20 runs, no viable M. paratuberculosis organisms were detected, which represented > 6-log10 reductions during pasteurization. These experiments were conducted with very heavily artificially contaminated milk to facilitate the measurement of the logarithmic reduction. In three of the 20 runs of milk, pasteurized at 72 degrees C for 15 s, 75 degrees C for 25 s, and 78 degrees C for 15 s, a few viable organisms (0.002 to 0.004 CFU/ml) were detected. Pasteurization at all temperatures and holding times was found to be very effective in killing M. paratuberculosis, resulting in a reduction of > 6 log10 in 85% of runs and > 4 log10 in 14% of runs.     

Efficacy of copper and silver ions and reduced levels of free chlorine in inactivation of Legionella pneumophila.

Water disinfection systems utilizing electrolytically generated copper and silver ions (200 and 20, 400 and 40, or 800 and 80 micrograms/liter) and low levels of free chlorine (0.1 to 0.4 mg/liter) were evaluated at room (21 to 23 degrees C) and elevated (39 to 40 degrees C) temperatures in filtered well water (pH 7.3) for their efficacy in inactivating Legionella pneumophila (ATCC 33155). At room temperature, a contact time of at least 24 h was necessary for copper and silver (400 and 40 micrograms/liter) to achieve a 3-log10 reduction in bacterial numbers. As the copper and silver concentration increased to 800 and 80 micrograms/liter, the inactivation rate significantly (P less than or equal to 0.05) increased from K = 2.87 x 10(-3) to K = 7.50 x 10(-3) (log10 reduction per minute). In water systems with and without copper and silver (400 and 40 micrograms/liter), the inactivation rates significantly increased as the free chlorine concentration increased from 0.1 mg/liter (K = 0.397 log10 reduction per min) to 0.4 mg/liter (K = 1.047 log10 reduction per min). Compared to room temperature, no significant differences were observed when 0.2 mg of free chlorine per liter with and without 400 and 40 micrograms of copper and silver per liter was tested at 39 to 40 degrees C. All disinfection systems, regardless of temperature or free chlorine concentration, showed increase inactivation rates when 400 and 40 micrograms of copper and silver per liter was added; however, this trend was significant only at 0.4 mg of free chlorine per liter.