Effects of gas periodic stimulation on key enzyme activity in gas double-dynamic solid state fermentation (GDD-SSF)

The heat and mass transfer have been proved to be the important factors in air pressure pulsation for cellulase production. However, as process of enzyme secretion, the cellulase formation has not been studied in the view of microorganism metabolism and metabolic key enzyme activity under air pressure pulsation condition. Two fermentation methods in ATPase activity, cellulase productivity, weight lose rate and membrane permeability were systematically compared. Results indicated that gas double-dynamic solid state fermentation had no obviously effect on cell membrane permeability. However, the relation between ATPase activity and weight loss rate was linearly dependent with r = 0.9784. Meanwhile, the results also implied that gas periodic stimulation had apparently strengthened microbial metabolism through increasing ATPase activity during gas double-dynamic solid state fermentation, resulting in motivating the production of cellulase by Trichoderma reesei YG3. Therefore, the increase of ATPase activity would be another crucial factor to strengthen fermentation process for cellulase production under gas double-dynamic solid state fermentation.     

Effect of culture phasing and mannanase on production of cellulase and hemicellulase by mixed culture of Trichoderma reesei D 1-6 and Aspergillus wentii pt 2804

Significant increase in extracellular cellulase and hemicellulase activities was observed in the biosynthesis of cellulase enzyme in mixed culture fermentation of Trichoderma reesei D 1-6 and Aspergillus wentii Pt 2804 when the A. wentii inoculation was phased by 15 h. The optimal conditions of fermentation by the mixed culture have been established. Presence of mannanase has been found to affect the release as well as activity of cellulase enzyme produced in mixed culture.     

A freeze-fracture study of hormone-induced branching in the fungus Achlya.

The induction of the male sexual organ primordia (antheridial hyphae) by the steriod hormone antheridiol in the water mold Achlya ambisexualis Raper requires the production and secretion of the enzyme cellulase. It is postulated that a localized secretion of cellulase produces a limited area of wall hydrolysis that is blown out into a lateral bleb by turgor pressure. Freeze-etch preparations show membrane profiles similar to those seen in other systems where exocytosis is occurring. Such a mechanism would provide the required localized secretion of cellulase. Water stress, imposed by polyethylene glycol, prevents the formation of antheridial hyphae, the secretion of cellulase and the expected membrane profiles. After a period of recovery from water stress antheridial hyphae are formed, cellulase secretion occurs and the expected membrane profiles are restored.     

Recent progress in cellulose biosynthesis

Cellulose comprises the major polymer of the plant cell wall. It consists of a set of parallel chains composed of glucans and these chains are highly oriented to form a structure known as a microfibril. The orientation of the microfibrils controls the extension of the direction of the plant cell. Extensive studies on the cellulose biosynthesis have been carried out for over three decades, and recently (1996) genes for cellulose biosynthesis in plants (CesA) were isolated. In the year 2002, a specific primer for cellulose biosynthesis reaction has been discovered and cellulose synthetic activity has been also confirmed by recombinant protein derived from the plant CesA gene. Furthermore, other proteins involved in cellulose biosynthesis besides CesA proteins were also proposed at the same time. One of these proteins, Korrigan cellulase, was suggested to act by removing sitosterol from the primer for biosynthesis reaction of cellulose. A membrane-bound sucrose synthase was also suggested to provide UDP-glucose as a substrate for cellulose biosynthesis. On the basis of these results, a new pathway for cellulose biosynthesis was proposed. Now, the research field of cellulose biosynthesis is facing a major turning point. Electronic Publication     

Induction of cellulolytic enzymes in Trichoderma reesei by sophorose.

Sophorose (2-O-beta-glucopyranosyl-D-glucose) induces carboxymethyl cellulase in Trichoderma reesei QM6a mycelium with 1.5 to 2 h. The induction response to sophorose concentration, although complicated by the metabolism of sophorose, shows saturation kinetics. Most of the cellulase appears after most of the sophorose has been taken up, but the presence of an inducer is required to maintain cellulase synthesis because enzyme production ceases after separation of the mycelium from the induction medium. Cellulase appears simultaneously in the medium and in the mycelium, and no appreciable levels accumulate in the mycelium. Response to pH suggest either that synthesis and secretion of the enzyme are closely associated or concurrent events affected by surface interactions with the medium. Effects of temperature and pH on cellulase induction by sophorose are similar to those reported for induction by cellulose. The kinetics of absorption by mycelium differs from that of other beta-linked saccharides and glucose, the uptake of sophorose being much slower. Under our cultural conditions, sophorose appears to induce an incomplete array of cellulase enzymes, as indicated by enzymatic and electrophoretic studies.     

Cell surface changes in Thermomonospora curvata during cellulase induction and repression

Cellulosomes are cell surface protuberances which contain cellulases functional in substrate adherence and hydrolysis. The mycelia of Thermomonospora curvata , which adhere to and grow on native cellulose fibres, formed cellulosomal structures during cellulase induction, but did not when cellulase biosynthesis was repressed. Cell-bound enzyme accounted for about 5% of total culture cellulase activity.     

Pyoverdine biosynthesis and secretion in Pseudomonas aeruginosa: implications for metal homeostasis

Pyoverdines are siderophores produced by fluorescent Pseudomonads to acquire iron. At least 60 different pyoverdines produced by diverse strains have been chemically characterized. They all consist of a dihydroquinoline‐type chromophore linked to a peptide. These peptides are of various lengths and the sequences are strain specific. Pyoverdine biosynthesis in Pseudomonas aeruginosa and fluorescent Pseudomonads is a complex process involving at least 12 different proteins, starting in the cytoplasm and ending in the periplasm. The cellular localization of pyoverdine precursors was recently shown to be consistent with their biosynthetic enzymes. In the cytoplasm, pyoverdine appears to be assembled at the inner membrane and particularly at the old cell pole of the bacterium. Mature pyoverdine is uniformly distributed throughout the periplasm, like the periplasmic enzyme PvdQ. Secretion of pyoverdine involves a recently identified ATP‐dependent efflux pump, PvdRT‐OpmQ. This efflux system does not only secrete newly synthesized pyoverdine but also pyoverdine that already transported iron into the bacterial periplasm and any pyoverdine–metal complex other than ferri‐pyoverdine present in the periplasm. This review considers how these new insights into pyoverdine biosynthesis and secretion contribute to our understanding of the role of pyoverdine in iron and metal homeostasis in fluorescent Pseudomonads.     

Mutants ofXanthomonas campestris defective in secretion of extracellular enzymes

Summary Mutants ofXanthomonas campestris B 1459 were isolated that are defective in secretion of both cellulase and amylase. Both enzymes accumulated in the periplasmic space. The defects in secretion of cellulase or amylase were partly overcome by introducing into the mutants specific multiple copies of DNA cloned fromX. campestris, and presumed to code for cellulase or amylase enzymes. The mutant strains also showed reduced amounts of extracellular pectinase and protease activities, as if the mutants were generally defective for secretion of extracellular enzymes. The mutants showed reduced pathogenesis for turnip seedlings. The secretion-defective mutants may allow production of xanthan gum with reduced cellulose, pectin, protein and starch-degrading enzyme activities, thereby allowing more widespread mixing of microbially produced xanthan gum with these commercially important water-soluble polymers.     

Cellulases: Biosynthesis and applications

Strains of Trichoderma, particularly T. reesei and its mutants, are good sources of extracellular cellulase suitable for practical saccharification. They secrete a complete cellulase complex containing endo- and exo-glucanases plus β-glucosidase (cellobiase) which act syngergistically to degrade totally even highly resistant crystalline cellulose to soluble sugars. All strains investigated to date are inducible by cellulose, lactose, or sophorose, and all are repressible by glucose. Induction, synthesis and secretion of the β-glucanase enzymes appear to be closely associated. The composition and properties of the enzyme complex are similar regardless of the strain or inducing substrate although quantities of the enzyme secreted by the mutants are higher. Enzyme yields are proportional to initial cellulose concentration. Up to 15 filter paper cellulase units (20 mg of cellulase protein) per ml and productivities up to 80 cellulase units (130 mg cellulase protein) per litre per hour have been attained on 6% cellulose. The economics of glucose production are not yet competitive due to the low specific activity of cellulase (0.6 filter paper cellulase units/mg protein) and poor efficiency (about 15% of predicted sugar levels in 24 h hydrolyses of 10–25% substrate). As hydrolysis proceeds, the enzyme reaction slows due to increasing resistance of the residue, product inhibition, and enzyme inactivation. These problems are being attacked by use of pretreatments to increase the quantity of amorphous cellulose, addition of β-glucosidase to reduce cellobiose inhibition, and studies of means to overcome instability and increase efficiency of the cellulases. Indications are that carbon compounds derived from enzymatic hydrolysis of cellulose will be used as fermentation and chemical feedstocks as soon as the process economics are favourable for such application.     

The epiphytic lichen Evernia prunastri synthesizes a secretable cellulase system that degrades crystalline cellulose

Evernia prunastri (L.) Ach. produces a cellulase system capable of solubilizing crystalline cellulose. The enzyme is secreted into the incubation medium in response to the presence of 0.5% (w/v) cellobiose. Cellulase secretion is pH dependent, the maximum occurring at an initial pH of 9.0, which is rapidly decreased by the action of the lichen. The effect of cellobiose on the cellulase system is inhibited by cycloheximide and 8-azaguanine. The cellulasc activity increases with the metabolic reactivation that is initiated by thallus hydration. Several functions of cellulase in this lichen are discussed.     

The potential of enzyme recycling during the hydrolysis of a mixed softwood feedstock

Despite recent improvement in cellulase enzymes properties, the high cost associated with the hydrolysis step remains a major impediment to the commercialization of full-scale lignocellulose-to-ethanol bioconversion process. As part of a research effort to develop a commercial process for bioconversion of softwood residues, we have examined the potential for recycling enzymes during the hydrolysis of mixed softwood substrate pretreated by organosolv process. We have used response surface methodology to determine the optimal temperature, pH, ionic strength, and surfactant (Tween 80) concentration for maximizing the recovery of bound protein and enzyme activity from the residual substrates after hydrolysis. Data analysis showed that the temperature, pH and surfactant concentration were the major factors governing enzyme desorption from residual substrate. The optimized conditions were temperature 44.4 °C, pH 5.3 and 0.5% Tween 80. The optimal conditions significantly increased the hydrolysis yield by 25% after three rounds of hydrolysis. This bound enzyme desorption combining with free enzyme re-adsorption is a potential method to recover cellulase enzymes and reduce the cost of enzymatic hydrolysis.     

Exogenous cellulases of thermophilic micromycetes. Part I. Selection of producers

More than 600 micromycetes – representatives of different genera have been investigated for their ability to produce exogenous cellulases. Most of the investigated cultures were found to produce these enzymes, 24 cultures being thermophilic, and 18 thermotolerant. Cellulase or its derivatives proved to be the most favourable carbon source for cellulase secretion. None of the thermophilic cultures studied manifested the ability of exogenous exoglucanase biosynthesis. Using UV-rays as mutagen, a mutant strain A. terreus T-49 has been obtained being characterized by an increased endo-glucanase and cellobiase activity, as compared to the initial strains. The cellulase preparations of thermophilic micromycetes contain one cellulasic component: endo-glucanase, or two: endo-glucanase and cellobiase.     

Cellulase digestibility of pretreated biomass is limited by cellulose accessibility

Attempts to correlate the physical and chemical properties of biomass to its susceptibility to enzyme digestion are often inconclusive or contradictory depending on variables such as the type of substrate, the pretreatment conditions and measurement techniques. In this study, we present a direct method for measuring the key factors governing cellulose digestibility in a biomass sample by directly probing cellulase binding and activity using a purified cellobiohydrolase (Cel7A) from Trichoderma reesei. Fluorescence-labeled T. reesei Cel7A was used to assay pretreated corn stover samples and pure cellulosic substrates to identify barriers to accessibility by this important component of cellulase preparations. The results showed cellulose conversion improved when T. reesei Cel7A bound in higher concentrations, indicating that the enzyme had greater access to the substrate. Factors such as the pretreatment severity, drying after pretreatment, and cellulose crystallinity were found to directly impact enzyme accessibility. This study provides direct evidence to support the notion that the best pretreatment schemes for rendering biomass more digestible to cellobiohydrolase enzymes are those that improve access to the cellulose in biomass cell walls, as well as those able to reduce the crystallinity of cell wall cellulose.     

L-山梨糖提高木霉纤维素酶合成速率机制的研究

在0.5％葡萄糖-Mandels盐培养液中添加终浓度为0.5％的L-山梨糖,可使里斯木霉(Trichoderma reesei C 30)和拟康氏木霉(Trichoderma pseudokoningii S38)的内切和外切β-1,4葡聚糖酶合成速率在培养的2天内提高4倍。与此同时β-葡萄糖苷酶的合成没有明显变化。L-山梨糖能明显抑制菌丝生长,但对葡萄糖的吸收没有影响,对菌丝分泌纤维素酶的机制影响不大。其对酶合成的促进可能主要是通过降低了菌丝体的生长速率。     

Two hypotheses on the feedback regulation of pancreatic enzyme secretion

We review the mechanisms underlying the feedback regulation of pancreatic enzyme secretion in response to a meal. Pancreatic enzyme secretion in the rat and pig is known to be regulated by a negative feedback mechanism mediated by intestinal trypsin and chymotrypsin. Such a mechanism has recently been noted in humans. The presence of these enzymes in the small intestine suppresses pancreatic enzyme secretion, whereas their removal increases it. Two novel peptides have been proposed to account for the stimulation of pancreatic enzyme secretion in response to feeding trypsin inhibitor. One was assumed to be present in rat pancreatic juice and the other to be spontaneously secreted from the rat small intestine. In either case, trypsin and trypsin inhibitors do not directly interact with the luminal surface of the small intestine, but their actions are mediated by a trypsin-sensitive, cholecystokinin-releasing peptide. This is a novel explanation of the well-recognized stimulation of pancreatic enzyme secretion in response to dietary protein intake.     

Production of cellulase by Trichoderma.

The cellulase complex in T. viride is inducible. For large-scale enzyme production the fungus should be cultured on media containing cellulose. The cellulase enzymes are respressible. To produce and maintain best cellulase yields cultural conditions which lead to carbohydrate consumption in excess of cellular needs should be avoided. With the present mutant (QM9414) extracellular enzyme preparations having 1.6 FP units/ml and 1.6 mg protein/ml have been obtained within four to five days in submerged fermentation. Such preparations are capable of producing a 5% sugar solution when mixed with 10% ball milled cellulose and incubated 24 hr at 50 degrees C. Further improvements of cellulase yields are being sought by continued mutagenesis and increased nutrient levels in the growth medium.