Resistance of Streptococcus bovis to acetic acid at low pH: relationship between intracellular pH and anion accumulation

Streptococcus bovis JB1, an acid-tolerant ruminal bacterium, was able to grow at pHs from 6.7 to 4.5, and 100 mM acetate had little effect on growth rate or proton motive force across the cell membrane. When S. bovis was grown in glucose-limited chemostats at pH 5.2, the addition of sodium acetate (as much as 100 mM) had little effect on the production of bacterial protein. At higher concentrations of sodium acetate (100 to 360 mM), production of bacterial protein declined, but this decrease could largely be explained by a shift in fermentation products (acetate, formate, and ethanol production to lactate production) and a decline in ATP production (3 ATP per glucose versus 2 ATP per glucose). YATP (grams of cells per mole of ATP) was not decreased significantly even by high concentrations of acetate. Cultures supplemented with 100 mM sodium acetate took up [14C]acetate and [14C]benzoate in accordance with the Henderson-Hasselbalch equation and gave similar estimates of intracellular pH. As the extracellular pH declined, S. bovis allowed its intracellular pH to decrease and maintained a relatively constant pH gradient across the cell membrane (0.9 unit). The decrease in intracellular pH prevented S. bovis from accumulating large amounts of acetate anion. On the basis of these results it did not appear that acetate was acting as an uncoupler. The sensitivity of other bacteria to volatile fatty acids at low pH is explained most easily by a high transmembrane pH gradient and anion accumulation.     

Resistance of Streptococcus bovis to acetic acid at low pH: relationship between intracellular pH and anion accumulation.

Streptococcus bovis JB1, an acid-tolerant ruminal bacterium, was able to grow at pHs from 6.7 to 4.5, and 100 mM acetate had little effect on growth rate or proton motive force across the cell membrane. When S. bovis was grown in glucose-limited chemostats at pH 5.2, the addition of sodium acetate (as much as 100 mM) had little effect on the production of bacterial protein. At higher concentrations of sodium acetate (100 to 360 mM), production of bacterial protein declined, but this decrease could largely be explained by a shift in fermentation products (acetate, formate, and ethanol production to lactate production) and a decline in ATP production (3 ATP per glucose versus 2 ATP per glucose). YATP (grams of cells per mole of ATP) was not decreased significantly even by high concentrations of acetate. Cultures supplemented with 100 mM sodium acetate took up [14C]acetate and [14C]benzoate in accordance with the Henderson-Hasselbalch equation and gave similar estimates of intracellular pH. As the extracellular pH declined, S. bovis allowed its intracellular pH to decrease and maintained a relatively constant pH gradient across the cell membrane (0.9 unit). The decrease in intracellular pH prevented S. bovis from accumulating large amounts of acetate anion. On the basis of these results it did not appear that acetate was acting as an uncoupler. The sensitivity of other bacteria to volatile fatty acids at low pH is explained most easily by a high transmembrane pH gradient and anion accumulation.     

初始pH值对产氢产乙酸/耗氢产乙酸两段耦合工艺定向生产乙酸的影响

以葡萄糖为底物,以经加热预处理并活化过的厌氧污泥为种泥,研究了初始pH值对产氢产乙酸/耗氢产乙酸两段耦合工艺厌氧发酵定向生产乙酸的影响。实验考察了7个初始pH值(5、6、7、8、9、10、11)条件下的底物降解、产物产生和发酵过程pH值的变化。结果表明:产氢产乙酸段初始pH值的变化不仅影响本阶段产酸,而且影响耗氢产乙酸段产酸。初始pH=5时主要进行乙醇型发酵;pH=6和7时主要进行丁酸型发酵;pH=8时混合酸型发酵类型逐渐占优势,pH=8~11时均以乙酸为主要产物,耦合系统生产乙酸最优初始pH值为10。在初始pH=8~11范围内,产氢产乙酸段初期的乙醇浓度一般较高,但到后期因乙醇被微生物进一步代谢转化成乙酸而使其含量下降。     

pH值和产甲烷抑制剂对两相耦合系统污泥发酵定向产乙酸的影响

采用产氢产乙酸/同型产乙酸两相耦合工艺对剩余污泥进行了半连续式厌氧发酵,主要研究了pH值和产甲烷抑制剂2-bromoethanesulphonate(BES)对耦合系统定向产乙酸的影响.结果表明:碱性pH(pH=10.0)和添加BES都能促进A相乙酸的积累,提高乙酸的产率,同时碱性pH比添加BES更有利于污泥的水解.当...     

Improving the Expression of Recombinant Proteins in E. coli BL21 (DE3) under Acetate Stress: An Alkaline pH Shift Approach

Excess acetate has long been an issue for the production of recombinant proteins in E. coli cells. Recently, improvements in acetate tolerance have been achieved through the use of genetic strategies and medium supplementation with certain amino acids and pyrimidines. The aim of our study was to evaluate an alternative to improve the acetate tolerance of E. coli BL21 (DE3), a popular strain used to express recombinant proteins. In this work we reported the cultivation of BL21 (DE3) in complex media containing acetate at high concentrations. In the presence of 300 mM acetate, compared with pH 6.5, pH 7.5 improved cell growth by approximately 71%, reduced intracellular acetate by approximately 50%, and restored the expression of glutathione S-transferase (GST), green fluorescent protein (GFP) and cytochrome P450 monooxygenase (CYP). Further experiments showed that alkaline pHs up to 8.5 had little inhibition in the expression of GST, GFP and CYP. In addition, the detrimental effect of acetate on the reduction of 3-(4,5-dimethylthiazol-2-yl)-2,5-diphenyl tetrazolium bromide (MTT) by the cell membrane, an index of cellular metabolic capacity, was substantially alleviated by a shift to alkaline pH values of 7.5–8.0. Thus, we suggest an approach of cultivating E. coli BL21 (DE3) at pH 8.0±0.5 to minimize the effects caused by acetate stress. The proposed strategy of an alkaline pH shift is a simple approach to solving similar bioprocessing problems in the production of biofuels and biochemicals from sugars.     

Physiological adaptations of anaerobic bacteria to low pH: metabolic control of proton motive force in Sarcina ventriculi.

Detailed physiological studies were done to compare the influence of environmental pH and fermentation end product formation on metabolism, growth, and proton motive force in Sarcina ventriculi. The kinetics of end product formation during glucose fermentation in unbuffered batch cultures shifted from hydrogen-acetate production to ethanol production as the medium pH dropped from 7.0 to 3.3. At a constant pH of 3.0, the production of acetate ceased when the accumulation of acetate in the medium reached 40 mmol/liter. At a constant pH of 7.0, acetate production continued throughout the entire growth time course. The in vivo hydrogenase activity was much higher in cells grown at pH 7.0 than at pH 3.0. The magnitude of the proton motive force increased in relation to a decrease of the medium pH from 7.5 to 3.0. When the organism was grown at pH 3.0, the cytoplasmic pH was 4.25 and the organism was unable to exclude acetic acid or butyric acid from the cytoplasm. Addition of acetic acid, but not hydrogen or ethanol, inhibited growth and resulted in proton motive force dissipation and the accumulation of acetic acid in the cytoplasm. The results indicate that S. ventriculi is an acidophile that can continue to produce ethanol at low cytoplasmic pH values. Both the ability to shift to ethanol production and the ability to continue to ferment glucose while cytoplasmic pH values are low adapt S. ventriculi for growth at low pH.     

Toward a Solution for Acid Mine Drainage Treatment: Role of Electron Donors in Sulfate Reduction at Low pH

Abstract

Sediment historically impacted by acid mine drainage was exposed to different initial pH and electron donors to investigate the effect that both conditions had on the performance and fingerprint of the community from naturally acidic sediments. Batch experiments were fed with either acetate, lactate, or glycerol at initial pH of 5, 4, or 3, under sulfate-reducing conditions. The performance results indicated that sulfide production efficiency was above 85% in the treatments fed with lactate and glycerol at pH 5 and 4. However, acetate consumption efficiency was greater than 85% only in the treatments with acetate at pH 5 and lactate at pH 5 and 4. Glycerol fed treatments successfully produced sulfide even at initial pH?=?3. Sulfide production rates were related to the initial pH in treatments fed with lactate and acetate and independent of the pH in the glycerol fed treatments. 16S rRNA gene T-RFLP analysis of the enriched communities indicated that the initial pH could explain the differences of the microbial community fingerprint obtained after 90?days. This study points out the fact that acidic stress is a heavy burden for the development of sulfate-reducing microorganisms, especially for those that use acetate as substrate.     

End Products of Glucose Fermentation by Brochothrix thermosphacta

Anaerobically, Brochothrix thermosphacta fermented glucose primarily to l-lactate, acetate, formate, and ethanol. The ratio of these end products varied with growth conditions. Both the presence of acetate and formate and a pH below about 6 increased l-lactate production from glucose. Small amounts of butane-2,3-diol were also produced when the pH of the culture was low (相似文献   

Effects of Acetate and Butyrate During Glycerol Fermentation by Clostridium butyricum

The effects of acetate and butyrate during glycerol fermentation to 1,3-propanediol at pH 7.0 by Clostridium butyricum CNCM 1211 were studied. At pH 7.0, the calculated quantities of undissociated acetic and butyric acids were insufficient to inhibit bacterial growth. The initial addition of acetate or butyrate at concentrations of 2.5 to 15 gL⁻¹ had distinct effects on the metabolism and growth of Clostridium butyricum. Acetate increased the biomass and butyrate production, reducing the lag time and 1,3-propanediol production. In contrast, the addition of butyrate induced an increase in 1,3-propanediol production (yield: 0.75 mol/mol glycerol, versus 0.68 mol/mol in the butyrate-free culture), and reduced the biomass and butyrate production. It was calculated that reduction of butyrate production could provide sufficient NADH to increase 1,3-propanediol production. The effects of acetate and butyrate highlight the metabolic flexibility of Cl. butyricum CNCM 1211 during glycerol fermentation. Received: 2 January 2001 / Accepted: 6 February 2001     

Fermentation characteristics of Clostridium pasteurianum LMG 3285 grown on glucose and mannitol

Clostridium pasteurianum fermented glucose to acetate, butyrate, CO₂ and H₂. In batch cultures the fermentation pattern was only slightly affected by culture pH over the range 8·0 to 5·5. The acetate/butyrate ratio was always higher than or equal to one. Between 2·14 and 2·33 mol H₂ was produced per mol glucose fermented. At unregulated pH, more butanol and less butyrate was formed. In a carbon-limited chemostat, the steady-state acetate/butyrate ratio was always lower than one. H₂ production was approximately 1·70 mol per mol glucose consumed. Substantial amounts of extracellular protein were formed. With decreasing pH, acetate and formate production decreased, while H₂ production was highest at pH 6.0. With increasing dilution rate ( D ), the product spectrum hardly changed, but more biomass was formed. Y _glucose^max and Y _ATP^max were 55·97 and 31·48 g dry weight per mol glucose or ATP respectively. With increasing glucose input the formation of fatty acids and H₂ slightly decreased.
Continuous cultures fermented mannitol to acetate, butyrate, butanol, CO₂ and H₂. With acetate as co-substrate, butanol production and molar growth yields, Y _mannitol and Y _ATP, markedly decreased, while the butyrate and H₂ production increased. The latter reached a value of 2·21 mol H₂ per mol mannitol consumed.     

Effects of various acids and salts on growth and aflatoxin production by Aspergillus flavus NRRL 3145.

The effects of sodium chloride, sodium acetate, benzoic acid, sodium benzoate, malonic acid, and sodium malonate on growth and aflatoxin production by Aspergillus flavus were investigated in synthetic media. Sodium chloride at concentrations equivalent to or greater than 12 g/100 ml inhibited growth and aflatoxin production, while at 8 g or less/100 ml, growth and aflatoxin production were stimulated. At 2 g or less/100 ml, sodium acetate also stimulated growth and aflatoxin production, but reduction occurred with 4 g or more/100 ml. Malonic acid at 10, 20, 40, and 50 mM reduced growth and aflatoxin production (over 50%) while sodium malonate at similar concentrations but different pH values had the opposite effect. Benzoic acid (pH 3.9) and sodium benzoate (pH 5.0) at 0.4 g/100 ml completely inhibited growth and aflatoxin production. Examination of the effect of initial pH indicated that the extent of inhibitory action of malonic acid and sodium acetate was a function of initial pH. The inhibitory action of benzoic acid and sodium benzoate appeared to be a function of undissociated benzoic acid molecules. Aflatoxin reduction was usually accompanied by an unidentified orange pigment, while aflatoxin stimulation was accompanied by unidentified blue and green fluorescent spots but with lower Rf values that aflatoxins B1, G1, B2, and G2 standards.     

Substrate and product inhibition of hydrogen production by the extreme thermophile,Caldicellulosiruptor saccharolyticus

Substrate and product inhibition of hydrogen production during sucrose fermentation by the extremely thermophilic bacterium Caldicellulosiruptor saccharolyticus was studied. The inhibition kinetics were analyzed with a noncompetitive, nonlinear inhibition model. Hydrogen was the most severe inhibitor when allowed to accumulate in the culture. Concentrations of 5-10 mM H(2) in the gas phase (identical with partial hydrogen pressure (pH(2)) of (1-2) x 10(4) Pa) initiated a metabolic shift to lactate formation. The extent of inhibition by hydrogen was dependent on the density of the culture. The highest tolerance for hydrogen was found at low volumetric hydrogen production rates, as occurred in cultures with low cell densities. Under those conditions the critical hydrogen concentration in the gas phase was 27.7 mM H(2) (identical with pH(2) of 5.6 x 10(4) Pa); above this value hydrogen production ceased completely. With an efficient removal of hydrogen sucrose fermentation was mainly inhibited by sodium acetate. The critical concentrations of sucrose and acetate, at which growth and hydrogen production was completely inhibited (at neutral pH and 70 degrees C), were 292 and 365 mM, respectively. Inorganic salts, such as sodium chloride, mimicked the effect of sodium acetate, implying that ionic strength was responsible for inhibition. Undissociated acetate did not contribute to inhibition of cultures at neutral or slightly acidic pH. Exposure of exponentially growing cultures to concentrations of sodium acetate or sodium chloride higher than ca. 175 mM caused cell lysis, probably due to activation of autolysins.     

Improvement of biohydrogen production by Enterobacter cloacae IIT-BT 08 under regulated pH

The present study investigates the effect of pH and intermediate products formation on biological hydrogen production using Enterobacter cloacae IIT-BT 08. Initial pH was found to have a profound effect on hydrogen production potential, while regulating the pH 6.5 throughout the fermentation was found to increase the cumulative hydrogen production rate and yield significantly. Modified Gompertz equation was used to fit the cumulative hydrogen production curves to obtain the hydrogen production potential P, the hydrogen production rate R and lag phase λ. At regulated pH 6.5, higher H(2) yield (3.1molH(2)mol(-1) glucose), specific hydrogen production potential (798.1mL/g) and specific rate of H(2) production (72.1mLL(-1)h(-1)g(-1)) were obtained. The volatile fatty acid profile showed butyrate, ethanol and acetate as the major end metabolites of fermentation under the operating pH conditions tested; however, their pattern of distribution was pH dependent. At the optimum pH of 6.5, the acetate to butyrate ratio (A/B ratio) was found to be higher than that at any other pH. The study also investigates the effect of sodium ions on biohydrogen production potential. It was also found that sodium ion concentration up to 250mM enhanced the hydrogen production potential; however, any further increase in the metal ion concentration had an inhibitory effect.     

High production of 2,3-butanediol from glycerol by <Emphasis Type="Italic">Klebsiella pneumoniae</Emphasis> G31

The microbial production of high amounts of 2,3-butanediol (2,3-BD) from glycerol as a sole carbon source by the Bulgarian isolate Klebsiella pneumoniae G31 was studied in a series of fed-batch processes. The following conditions were evaluated as optimal: micro-aerobic cultivation in modified media, without pH control. Beginning at pH 8, 49.2 g/l of 2,3-BD was produced as negligible concentrations of by-products were received. The pH is the most important factor ruling the 2,3-BD production. Spontaneous pH changes and products formation in time were investigated, performing fermentations with non-controlled pH starting at different initial pH. In lack of external maintenance, the microorganism attempted to control the pH using acetate/2,3-BD alternations of the oxidative pathway of glycerol catabolism, which resulted in pH fluctuations. Thus, the culture secreted 2,3-BD at unequal portions, either allowing or detaining the acetate synthesis. More alkaline initial pH led to enhanced 2,3-BD accumulation as a response to the increased amplitudes of the pH variations. When the pH was maintained constant, the yield of 2,3-BD was very poor. These cultures remained viable only 72 h; whereas, the pH self-controlling cells lived and produced 2,3-BD up to 280 h. In conclusion, the formation of 2,3-BD is a result of an adaptive mechanism of pH self-control, responding to spontaneous pH drops during glycerol fermentation.     

Metabolic activities of Listeria monocytogenes in the presence of sodium propionate, acetate, lactate and citrate

The effects of sodium propionate, acetate, lactate and citrate on cell proliferation, glucose and oxygen consumption, and ATP production in Listeria monocytogenes were investigated in growing and resting cells. Media pH was 6.7-6.8. Growth inhibition increased while glucose consumption continued in the presence of ≥ 1% propionate, ≥ 3% acetate and ≥ 5% lactate in broth during incubation at 35°C, indicating that glucose consumption was uncoupled from cell proliferation. Acetate and propionate were the most effective antilisterials, whereas citrate (5%) was only slightly inhibitory. Of the four salts, only lactate supported growth, oxygen consumption and ATP production. While concentrations of 1 and 5% propionate, acetate and citrate did not have an effect on oxygen consumption, they inhibited ATP production. ATP production in the presence of the four salts was consistently lower at pH 6.0 than at neutral pH. Lactate served as an alternative energy source for L. monocytogenes in the absence of glucose but became toxic to the organism in the presence of the carbohydrate.     

Conditions for forming ethanol during bioconversion of cellulose-containing raw material

Several natural associations composed by thermophilic anaerobic bacteria capable of utilizing various cellulose materials at 60 +/- 2 degrees C and pH 6.0-7.0 were isolated from the sludge of Kamchatka geothermal springs. The rate of ethanol production (up to 1.7 g/l per day) and the concentration of ethanol in the medium (up to 1.2%), as well as the fermentation period (10-15 days) were determined under anaerobic conditions in the presence of cellulose, coniferous sawdust, newsprint, or paper pulp as a carbon source. Microorganisms were found that inhibited the production of ethanol. The initial pH value was found to influence both the ethanol production rate and ethanol/acetate ratio. A pH decrease from 7.0 to 5.0 led to 6.7-fold increased the ethanol production and caused a 23.8-fold increase in the ethanol/acetate ratio.     

Heterofermentative pattern and exopolysaccharide production by Lactobacillus helveticus ATCC 15807 in response to environmental pH

AIMS: The objective of this work was to evaluate the fermentation pattern of and the exopolysaccharide (EPS) production by Lactobacillus helveticus ATCC 15807 in milk batch cultures under controlled pH (4.5, 5.0 and 6.2). METHODS AND RESULTS: EPS concentration was estimated by the phenol/sulphuric acid method and the chemical composition of purified EPS by HPLC. Fermentation products and residual sugars were determined by HPLC and enzymatic methods. The micro-organism shifted from a homofermentative to a heterofermentative pattern, producing acetate (9.5 and 5.8 mmol l(-1)) at pH 5.0 and 6.2, respectively, and acetate (7.1 mmol l(-1)) plus succinate (1.2 mmol l(-1)) at pH 4.5. At pH 5.0 and 6.2, acetate derived from citrate while at pH 4.5 it came from both citrate and pyruvate splitting. The EPS has a MW of 10(5)-10(6) and contains phosphate (81% in average), rhamnose (traces), and glucose and galactose in a ratio of 1 : 1 (pH 6.2) and 2 : 1 (pH 4.5 and 5.0). The highest production (549 mg l(-1)) corresponded to pH 5.0 and the lowest (49 mg l(-1)) to pH 6.2. CONCLUSIONS: The heterofermentative pattern of Lact. helveticus ATCC 15807 was linked to alternative pyruvate pathways and/or citrate metabolism according to the environmental pH. The EPS production was improved under low environmental pH conditions. SIGNIFICANCE AND IMPACT OF THE STUDY: This work provides relevant information of the effect of pH on the metabolism of citrate and EPS production by Lact. helveticus. It may contribute to improve technological aspects of ropy and citrate-utilizing lactic acid bacteria.     

Evaluation of metabolism using stoichiometry in fermentative biohydrogen

We first constructed full stoichiometry, including cell synthesis, for glucose mixed-acid fermentation at different initial substrate concentrations (0.8-6 g-glucose/L) and pH conditions (final pH 4.0-8.6), based on experimentally determined electron-equivalent balances. The fermentative bioH2 reactions had good electron closure (-9.8 to +12.7% for variations in glucose concentration and -3 to +2% for variations in pH), and C, H, and O errors were below 1%. From the stoichiometry, we computed the ATP yield based on known fermentation pathways. Glucose-variation tests (final pH 4.2-5.1) gave a consistent fermentation pattern of acetate + butyrate + large H2, while pH significantly shifted the catabolic pattern: acetate + butyrate + large H2 at final pH 4.0, acetate + ethanol + modest H2 at final pH 6.8, and acetate + lactate + trivial H2 at final pH 8.6. When lactate or propionate was a dominant soluble end product, the H2 yield was very low, which is in agreement with the theory that reduced ferredoxin (Fd(red)) formation is required for proton reduction to H2. Also consistent with this hypothesis is that high H2 production correlated with a high ratio of butyrate to acetate. Biomass was not a dominant sink for electron equivalents in H2 formation, but became significant (12%) for the lowest glucose concentration (i.e., the most oligotrophic condition). The fermenting bacteria conserved energy similarly at approximately 3 mol ATP/mol glucose (except 0.8 g-glucose/L, which had approximately 3.5 mol ATP/mol glucose) over a wide range of H2 production. The observed biomass yield did not correlate with ATP conservation; low observed biomass yields probably were caused by accelerated rates of decay or production of soluble microbial products.     

Production of Solvents by Clostridium acetobutylicum Cultures Maintained at Neutral pH

The formation of acetone and n-butanol by Clostridium acetobutylicum NCIB 8052 (ATCC 824) was monitored in batch culture at 35°C in a glucose (2% [wt/vol]) minimal medium maintained throughout at either pH 5.0 or 7.0. At pH 5, good solvent production was obtained in the unsupplemented medium, although addition of acetate plus butyrate (10 mM each) caused solvent production to be initiated at a lower biomass concentration. At pH 7, although a purely acidogenic fermentation was maintained in the unsupplemented medium, low concentrations of acetone and n-butanol were produced when the glucose content of the medium was increased (to 4% [wt/vol]). Substantial solvent concentrations were, however, obtained at pH 7 in the 2% glucose medium supplemented with high concentrations of acetate plus butyrate (100 mM each, supplied as their potassium salts). Thus, C. acetobutylicum NCIB 8052, like C. beijerinckii VPI 13436, is able to produce solvents at neutral pH, although good yields are obtained only when adequately high concentrations of acetate and butyrate are supplied. Supplementation of the glucose minimal medium with propionate (20 mM) at pH 5 led to the production of some n-propanol as well as acetone and n-butanol; the final culture medium was virtually acid free. At pH 7, supplementation with propionate (150 mM) again led to the formation of n-propanol but also provoked production of some acetone and n-butanol, although in considerably smaller amounts than were obtained when the same basal medium had been fortified with acetate and butyrate at pH 7.