壳聚糖固定化半纤维素酶的研究

从青霉菌m8提取出半纤维素酶,将其固定在用戊二醛交联的壳聚糖载体上.0.5 g壳聚糖与4%的戊二醛结合固定2.5 mg蛋白质,酶活回收率为45.6%. 原酶的最适pH为4.6,固定化酶为pH 3.6.原酶的最适温度为55℃,固定化酶在60～75℃都具有较高活性.固定化酶的耐热性优于原酶. 以半纤维素为底物,固定化酶的表观K_m值略低于原酶,前者为5.0×10^－2 g/L,后者为3.58×10^－2 g/L.     

金属螯合载体定向固定化木瓜蛋白酶的研究

以磁性金属螯合琼脂糖微球为载体,利用金属螯合配体（IDACu²⁺）与蛋白质表面供电子氨基酸相互作用的原理,定向固定了木瓜蛋白酶。固定化最适条件为Cu²⁺1.5×10^-2mol/g载体、固定化时间4h、固定化pH7.0、给酶量30mg/g载体。固定化酶的最适反应温度70℃、最适反应pH8.0,固定化酶的热稳定性明显高于溶液酶,固定化酶活力回收为68.4％,且有较好的操作稳定性,载体重复使用5次后固定化酶酶活为首次固定化酶79.71%。     

氧化铝为载体的固定化葡萄糖异构酶某些性质的研究

本文报道了以廉价的大孔氧化铝作为葡萄糖异构酶的固定化载体。该固定化酶的热稳定性是60—70℃,如高于70℃就开始失活。最适Ph和温度分别为7．2—8．0和70℃。Gu²⁺、Fe²⁺、Zn²⁺、Mn²⁺和Ba²⁺等金属离子对它的酶活有抑制作用,Co²⁺和Mg²⁺金属离子却有明显的激活作用。该固定化酶酶活是6000—7000μ／g。通过柱运转,它的半衰期为40天以上,转化率是葡萄糖异构为果糖理论值的80一85％。     

利用渗透交联固定化细胞促进生物转化

固定化技术已在生物工程中得到广泛的实际应用,特别是应用于生物转化以提高酶或细胞的稳定性,实现连续操作等。对于含胞内酶的细胞的生物转化．一般先破碎细胞,使酶释放出来,再进行酶固定化。由于酶的稳定性通常与细胞膜的结台有关^[1],细胞破碎中常导致酶的失活。如果不破碎细胞,对完整细胞固定化,又会有传质困难抑制酶活力的发挥。我们研究出渗透交联固定化细胞技术以解决这个矛盾。先采用某种试剂(多为表面活性剂)处理细胞,提高细胞的通透性,再进行交联固定化．可以保证酶的活力破坏较小,又减小了传质阻力。既提高了固定化细胞的稳定性,又提高了固定化细胞的表观酶活。称这种固定化技术为渗透交联固定化细胞技术。Prabhuaney等采用CTAB-戊二醛处理聚丙烯酰胺凝胶包理的含青霉素酰化酶E. coli细胞^[2]。Nmhida采用1,6-己二胺-戊二醛处理含天冬氨酸酶的E．Coli细胞^[3]。渗透交联固定化处理会损伤细胞和酶是这种技术的一个矛盾。本文采用多乙烯多胺-戊二处理方法．因多乙烯多胺既起到表面活性剂的作用．又是交联剂。而且渗透能力比CTAB和1,6-已二 胺为低,故对细胞和酶损伤较小。     

韭菜化感物质草莓酸对香蕉枯萎病菌的影响

香蕉枯萎病主要由尖孢镰刀菌 4 号生理小种(Fusarium oxysporum f. sp. cubense,Foc4)引起的一种土传病害,严重威胁香蕉产业的可持续发展。为寻求一种经济有效且环保的防治措施,以韭菜化感物质的衍生物草莓酸(strawberry acid,SA)为材料,通过平板和盆栽实验,研究了SA对Foc4的菌丝生长、香蕉枯萎病病情指数、土壤微生物数量、土壤酶活性的影响。结果表明:(1)随着SA浓度的增加,Foc4的菌落生长直径显著减小,第5天时菌落直径在SA浓度为300、450 μL·L^-1时比150 μL·L^-1分别减小了49.15%、70.89%; 液体培养条件下SA浓度为600 μL·L^-1时Foc4的分生孢子数量显著低于对照处理(相差 470 多倍); pH为5时SA对Foc4的抑制效果显著比pH为7和9时好。(2)随实验处理时间的延长,添加 SA后香蕉幼苗的病情指数显著低于对照。(3)土壤细菌、真菌数量和微生物总量在SA为600 μL·L^-1时均为最高; Foc4数量随SA浓度升高而降低,在1 200 μL·L^-1时显著降低。(4)各土壤酶在浓度(300～600 μL·L^-1)SA处理时活性较高; 1 200 μL·L^-1时显著降低,过氧化氢酶和多酚氧化酶较对照分别降低了41.88%、54.82%。(5)相关性分析得出,土壤微生物总量与细菌、真菌数量极显著正相关; 土壤真菌与放线菌显著负相关; 土壤细菌、真菌和放线菌数量均与蔗糖酶、多酚氧化酶显著正相关; 蔗糖酶与脲酶、过氧化氢酶与多酚氧化酶均显著正相关。综上认为,添加SA浓度为600 μL·L^-1能较好地抑制Foc4的菌丝生长且能提高其抑制率,病情指数明显降低,有利于改善香蕉的生长环境。该研究结果为有效利用SA防治香蕉枯萎病提供了科学依据。     

人工神经网络在米曲霉菌体固定化研究中的应用

在液体培养基中,将米曲霉3042菌体培养成直径为1～2mm、菌壁上含较高氨基酰化酶浓度的菌丝球,以甲醛为交联剂,明胶为酶活性保护剂对米曲霉菌丝球进行固定化研究。在正交实验L₁₆(4⁵)的基础上,选用结构为410-15-1的BP(Back propagation)人工神经网络,对固定化工艺条件进行优化和预测,得到了优化的固定化条件。实验测定在此条件下制备的固定化米曲霉菌体比酶活为1500u,比酶活保留率达到83%,说明人工神经网络可以用于米曲霉菌体固定化工艺条件的优化。     

固定化技术研究的新进展

固定化生物催化剂的研究近一、二十年来发展非常迅速。它已由原来的单一固定化酶、固定化微生物细咆发展到动植物细胞、组织器官、微生物孢子^[1]、细胞与酶^[2]、好氧微生物与厌氧微生物^[3]的混合固定化等,其应用研究巳涉及发酵、食品、化工、分析、医疗、生化、环境净化等各个领域^[4],展示了广阔的发展前景。     

固定化在多孔玻璃上的青霉素酰化酶性质

从大肠杆菌As 1．76提取青霉素酰化酶,经纯化,用戊二醛圈定在氯烷基硅烷化多孔玻璃上。初步摸索了固定化条件。固定化酶的米氏常数为7．7 x 10^-4M,比自然酶大10倍,但竞争性抑制剂苯乙酸对固定化酶和自然酶的抑制常数基本相同,固定化酶的最大反应速度为5．8×10^-2M／min,比自然酶大2．5倍,水解NIPAB的最适pH为7．O,比自然酶低1个pH单位,最适反应温度比自然酶低i0℃,固定化酶在pH 5．8—8．0之间较稳定,较自然酶的范围略窄;固定化酶在40℃以下稳定,而自然酶在45℃以下稳定。     

非水体系中脂肪酶催化合成乳酸乙基糖苷酯的工艺研究

在非水体系中 ,通过固定化脂肪酶催化合成一种新型α 羟基酸衍生物 乳酸糖苷酯。考察了常压下有机溶剂、酰基供体、不同种固定化酶、乙基糖苷的浓度、酶量和反应温度对反应的影响。研究表明在无溶剂体系中以乳酸丁酯作为酰基供体可有效地合成乳酸糖苷酯 ,固定化酶Novozym435和来源于Candida sp .菌株的细胞固定化酶 ,化学修饰的干酶粉均是合适的催化剂。最佳反应条件为 :酶浓度 75g L ,乙基葡萄糖苷的浓度为 0.4mol L ,温度为 70℃ ,转速 200r min ,反应 50h ,转化率可达 71%。在真空度为 0.09MPa的压力下 ,反应温度 65℃ ,酶浓度 75g L ,乙基葡萄糖苷 0.35mol L时 ,反应初速率可达到 607(mmol·L^-1·h^-1 ) ,40h后转化率可达到 90%。反应产物经过萃取法和硅胶柱层析方法分离 ,纯度达到 95 % (W/W)。     

抗腺苷酸激酶单克隆抗体的制备及鉴定

克隆了6株稳定分泌抗腺苷酸激酶(Adenylate kinase,AK)单克隆抗体的杂交瘤细胞株,并鉴定或测定了其中3株细胞所分泌抗体的亚型和分子量.通过测定抗体和固相及均相抗原的结合能力,发现McAb3D3与固定化及溶液中腺苷酸激酶的亲和常数分别为8.4×10⁸和7.0×10~4(mol·L^-1)^-1,而McAb4D8与固定化及溶液中腺苷酸激酶的亲和常数分别为9.6×10⁸和3.9×10⁶(mol·L.¹)^-1McAb3D3和McAb4D8与不同存在形式抗原之间亲和常数如此大的差别,说明这2个抗体更适合与固定化腺苷酸激酶的结合.由于蛋白质分子常因吸附在酶标板上而发生部分变性,所以用间接ELISA方法筛选出的单克隆抗体McAb3D3和McAb4D8可能是针对部分变性腺苷酸激酶分子的.这2种抗腺苷酸激酶单克隆抗体的制备及鉴定为我们进一步将其用于蛋白质折叠机制的研究奠定了基础.     

Application of chitosan beads immobilized Rhodococcus sp. NCIM 2891 cholesterol oxidase for cholestenone production

The cell-bound cholesterol oxidase from the Rhodococcus sp. NCIM 2891 was purified three fold by diethylaminoethyl–sepharose chromatography. The estimated molecular mass (SDS-PAGE) and K_m of the enzyme were ∼55.0 kDa and 151 μM, respectively. The purified cholesterol oxidase was immobilized on chitosan beads by glutaraldehyde cross-linking reaction and immobilization was confirmed by Fourier transform infrared spectroscopy, scanning electron microscopy and energy dispersive X-ray analysis. The optimum temperature (45 °C, 5 min) for activity of the enzyme was increased by 5 °C after immobilization. Both the free and immobilized cholesterol oxidases were found to be stable in many organic solvents except for acetone. Fe²⁺ and Pb²⁺ at 0.1 mM of each acted as inhibitors, while Ag⁺, Ca²⁺, Ni²⁺ and Zn²⁺ activated the enzyme at similar concentration. The biotransformation of cholesterol (3.75 mM) with the cholesterol oxidase immobilized beads (3.50 U) leads to ∼88% millimolar yield of cholestenone in a reaction time of 9 h at 25 °C. The immobilized enzyme retains ∼67% activity even after 12 successive batches of operation. The biotransformation method thus, shows a great promise for the production of pharmaceutically important cholestenone.     

Ethylene production in rice bronzing leaves induced by ferrous iron

Bronzing, a nutritional disorder of rice plants which is widely distributed in tropical lowlands, was induced by dipping the cut end of rice leaves into FeSO₄ solution (pH 3.5). Ethylene production; the activities of peroxidase, polyphenol oxidase, and phenylalanine ammonia-lyase; and the effects of Co²⁺, aminoethoxyvinylglycine, Ag⁺, cycloheximide, and 1-aminocyclopropane-1-carboxylate, were investigated in the course of bronzing development. It was found that ethylene production could be stimulated up to about 20 times that of the control by Fe²⁺, and a peak could be reached at about 24 h after incubation. The Fe²⁺-treated leaves also had 10-fold higher peroxidase activity than the control, whereas in vitro enzyme activity was inhibited by Fe²⁺. Cycloheximide retarded in vivo stimulation of peroxidase, indicating that in vivo stimulation resulted from inducing de novo synthesis of the enzyme. No changes in the activities of phenylalanine ammonia-lyase and polyphenol oxidase were observed. The results, obtained from the incubation of leaves with Co²⁺, aminoethoxyvinylglycine, Ag⁺, cycloheximide, or 1-aminocyclopropane-1-carboxylate, showed that ethylene production was the effect of Fe²⁺ stress and that it was not involved in the process of bronzing development, which is probably an acclimation process to enable plants to cope with stress. The accelerated peroxidase activity may be associated with bronzing development.Abbreviations ACC 1-aminocyclopropane-1-carboxylic acid - AVG aminoethoxyvinylglycine - EFE ethylene forming enzyme - PAL phenylalanine ammonia-lyase - POD peroxidase - PPO polyphenol oxidase - SE standard error     

Covalent immobilization of acetylcholinesterase on a novel polyacrylic acid‐based nanofiber membrane

In this study, polyacrylic acid‐based nanofiber (NF) membrane was prepared via electrospinning method. Acetylcholinesterase (AChE) from Electrophorus electricus was covalently immobilized onto polyacrylic acid‐based NF membrane by demonstrating efficient enzyme immobilization, and immobilization capacity of polymer membranes was found to be 0.4 mg/g. The novel NF membrane was synthesized via thermally activated surface reconstruction, and activation with carbonyldiimidazole upon electrospinning. The morphology of the polyacrylic acid‐based membrane was investigated by scanning electron microscopy, Fourier Transform Infrared Spectroscopy, and thermogravimetric analysis. The effect of temperature and pH on enzyme activity was investigated and maxima activities for free and immobilized enzyme were observed at 30 and 35°C, and pH 7.4 and 8.0, respectively. The effect of 1 mM Mn²⁺, Ni²⁺, Cu²⁺, Zn²⁺, Mg²⁺, Ca²⁺ ions on the stability of the immobilized AChE was also investigated. According to the Michaelis–Menten plot, AChE possessed a lower affinity to acetylthiocholine iodide after immobilization, and the Michaelis–Menten constant of immobilized and free AChE were found to be 0.5008 and 0.4733 mM, respectively. The immobilized AChE demonstrated satisfactory reusability, and even after 10 consecutive activity assay runs, AChE maintained ca. 87% of its initial activity. Free enzyme lost its activity completely within 60 days, while the immobilized enzyme retained approximately 70% of the initial activity under the same storage time. The favorable reusability of immobilized AChE enables the support to be employable to develop the AChE‐based biosensors.     

Immobilization and stabilization of d-hydantoinase from Vigna angularis and its use in the production of N-carbamoyl-d-phenylglycine. Improvement of the reaction yield by allowing chemical racemization of the substrate

This work reports the immobilization of a multimeric d-hydantoinase (DHTase) from Vigna angularis (E.C. 3.5.2.2.) on agarose beads activated with glyoxyl groups aiming to improve its stability via multipoint covalent attachment. The final reduction with sodium borohydride resulted in a drop in enzyme activity that could be decreased by adding Zn²⁺ or Mg²⁺. The optimal preparation with high activity (58 % recovered activity) and stability (around 86-fold more stable than the free enzyme) was obtained by DHTase immobilization on glyoxyl agarose for 24 h at 25 °C and pH 10.05, and a borohydride reduction step in the presence of 10 mM Zn²⁺ (DHTase-Glx). The enzyme was almost fully immobilized on glyoxyl agarose (19.8 mg/g of support) when offering 20 mg/g. This immobilized biocatalyst was used to catalyze the hydrolysis of d,l-phenylhydantoin under substrate racemization conditions, which produced 99 % of N-carbamoyl-d-phenylglycine after 9 h reaction.     

Errata

Optimal conditions for activation of adenylate cyclase in membrane particles were studied. Enzyme activation with serotonin (5-hydroxytryptamine), NaF, and guanosine $\text{5′-(3-O-}\text{thio}\text{)-}\text{triphosphate}$ (GTPγS) was time- and temperature-dependent. Mg²⁺ was required for enzyme activation. Adenylate cyclase that was activated by NaF or GTPγS was gradually inhibited by $\text{N-}\text{methylmaleimide}$ while enzyme activated with serotonin and GTP responded faster to inhibition by the same sulfhydryl reagent. The enzyme responded in a similar fashion to a spin-labeled $\text{N-}\text{methylmaleimide}$ analog 3-(maleimidomethyl)-2,2,5,5-tetramethyl-1-pyrolidinyloxyl (i.e., $\text{N-}\text{methylmaleimide}$ nitroxide). Binding of the spin label was enhanced following enzyme activation by serotonin, NaF, or GTPγS in the presence of Mg²⁺. Activation of the enzyme was accompanied by an increase in the strong immobilization peaks in the EPR spectra. Both effects, the increase in binding and in the strong immobilization peaks, can be induced by Mg²⁺ alone. The results indicate that a general conformational change induced by Mg²⁺ may be essential for adenylate cyclase activation.     

Biochemical properties of a serine protease from Aspergillus flavus and application in dehairing

The proteases are enzymes produced by several filamentous fungi with important biotechnological applications. In this work, a protease from Aspergillus flavus was characterized. The culture filtrate of A. flavus was purified to homogeneity by Sephacryl S-200 column chromatography followed by CM–cellulose. The molecular weight of the purified enzyme was estimated to be approximately 32?kDa by SDS–PAGE. The enzyme hydrolysed BTpNA (N-α-benzoyl-dl-tyrosyl-p-nitroanilide), azo-casein and casein as substrates. Optimal temperature and pH were 55?°C and 6.5, respectively. The enzyme was stimulated by Mg²⁺, Ca²⁺, Zn²⁺ and inhibited by Hg²⁺ and Ag²⁺ and Cu²⁺. The protease showed increased activity with detergents, such as Tween 80 and Triton X, and was stable to the reducing agents, such as β-mercaptoethanol. The protease activity was strongly inhibited in the presence of phenylmethylsulfonyl fluoride, indicating it is a serine protease. The enzyme entrapped in calcium alginate beads retained its activity for longer time and could be reused up to 10 times. The thermostability was increased after the immobilization and the enzyme retained 100% of activity at 45?°C after 60?min of incubation, and 90% of residual activity at 50?°C after 30?min. In contrast, the free enzyme only retained 10% of its residual activity after 60?min at 50?°C. The enzymatic preparation was demonstrated to be efficient in the capability of dehairing without destruction of the hide. The remarkable properties such as temperature, pH and immobilization stability found with this enzyme assure that it could be a potential candidate for industrial applications.     

Activity of tocopherol oxidase in Phaseolus coccineus seedlings

In the present study, we have demonstrated that membrane-free extracts of etiolated shoots of Phaseolus coccineus seedlings show tocopherol oxidase activity. For this reaction, presence of membrane lipids, such as lecithin and mixture of plant lipids was required. The rate of the reaction was the highest for α-tocopherol and decreased in the order α ? β > γ > δ tocopherols. In the case of α-tocopherol, the main oxidation product was α-tocopherolquinone, while for the other tocopherol homologues the dominant products were other derivatives. When the enzyme activity was measured in leaves, hypocotyls and roots of etiolated seedlings of P. coccineus, the oxidase activity was the highest in extracts of leaves and decreased towards the roots where no activity was detected. The effect of hydrogen peroxide and of different inhibitors on the reaction suggest that tocopherol oxidase does not belong to peroxidases or flavin oxidases but rather to multi-copper oxidases, such as polyphenol oxidases or laccases. On the other hand, catechol, the well-known substrate of polyphenol oxidases and laccases, was not oxidized by the enzyme, indicating a high substrate specificity of the tocopherol oxidase.     

Evaluation of a silica-coated magnetic nanoparticle for the immobilization of a His-tagged lipase

Magnetic particles of size 10 nm have been coated with silica to a mean diameter of 40 nm and charged with Cu²⁺ ions via a multidentate ligand, iminodiacetic acid (IDA), for the immobilization of His-tagged Bacillus stearothermopilus L1 lipase. Microporous (average pore diameter of 60 Å) silica gel with a mean particle diameter of 115 µm has been used as a comparative support material. The molar ratio of Cu²⁺ to IDA was found to be 1:1.14 and 1:1.99 in the silica gel and the silica-coated magnetic nanoparticles (SiMNs), respectively. The specific activity of the immobilized enzyme was found to conform to the following order: Cu²⁺-charged SiMN>SiMN>Cu²⁺-charged silica gel>silica gel. When it was immobilized on the Cu²⁺-charged SiMNs, over 70% of the initial activity of the lipase remained after it had been reused five times. However, only 20% of the initial activity remained after the enzyme immobilized on the Cu²⁺-charged silica gel had been reused five times. For the enzyme immobilized on supports without Cu²⁺ cations, all activity was lost after threefold reuse. The differences in the specific activities and the efficiencies of reuse of the enzymes immobilized on the various support materials are discussed in terms of immobilization mechanisms (physical adsorption vs. coordination bonding), mass transfer of a substrate and a product of the enzyme reaction, and the status of the Cu (Cu bound to the IDA on the silica layer vs. Cu directly adsorbed on the silica layer).     

Catalytic properties of the immobilized Talaromyces thermophilus β-xylosidase and its use for xylose and xylooligosaccharides production

The present study explores the efficiency of Talaromyces thermophilus β-xylosidase, in the production of xylose and xylooligosaccharides. The β-xylosidase was immobilized by different methods namely ionic binding, entrapment and covalent coupling and using various carriers. Chitosan, pre-treated with glutaraldehyde, was selected as the best support material for β-xylosidase immobilization; it gave the highest immobilization and activity yields (94%, 87%, respectively) of initial activity, and also provided the highest stability, retaining 94% of its initial activity even after being recycled 25 times. Shifts in the optimal temperature and pH were observed for the immobilized β-xylosidase when compared to the free enzyme. The maximal activity obtained for the immobilized enzyme was achieved at pH 8.0 and 53 °C, whereas that for the free enzyme was obtained at pH 7.0 and 50 °C. The immobilized enzyme was more thermostable than the free β-xylosidase. We observed an increase of the K_m values of the free enzyme from 2.37 to 3.42 mM at the immobilized state. Native and immobilized β-xylosidase were found to be stimulated by Ca²⁺, Mn²⁺ and Co²⁺ and to be inhibited by Zn²⁺, Cu²⁺, Hg²⁺, Fe²⁺, EDTA and SDS. Immobilized enzyme was found to catalyze the reverse hydrolysis reaction, forming xylooligosaccharides in the presence of a high concentration of xylose. In order to examine the synergistic action of xylanase and β-xylosidase of T. thermophilus, these two enzymes were co-immobilized on chitosan. A continuous hydrolysis of 3% Oat spelt xylan at 50 °C was performed and better hydrolysis yields and higher amount of xylose was obtained.     

Microplate assay for aptamer-based thrombin detection using a DNA-enzyme conjugate based on histidine-tag chemistry

We report a method to prepare a DNA–enzyme conjugate using histidine-tag (His-tag) chemistry. A DNA oligonucleotide was modified with nitrilotriacetate (NTA), whose K_d was approximately 10^?6 (M^?1) toward a His-tag present on a recombinant protein via the complexation of Ni²⁺. His-tagged alkaline phosphatase (His-AP) was used as the model enzyme. Enzyme immobilization on the microplate revealed the conjugation of His-AP and the NTA-modified DNA via an Ni²⁺ complex. SPR measurements also proved the conjugation of His-AP with the NTA-modified DNA via an Ni²⁺ complex. The DNA–enzyme conjugate was then used for the detection of thrombin using a DNA aptamer. The DNA-AP conjugate successfully amplified the binding signal between the DNA aptamer and the thrombin, and the signal was measured as the fluorescent intensity derived from the AP-catalyzed reaction. The detection limit was 11 nM. Finally, we studied the effect of the release of the immobilized His-AP from the microplate on the AP activity, because the present strategy used a cleavable linker for the conjugation and the enzyme immobilization. The DNase-catalyzed release of the immobilized His-AP resulted in a 1.7-fold higher AP activity than observed when the His-AP was surface-immobilized.