Concentration of 6-aminopenicillanic acid from penicillin bioconversion solution and its mother liquor by nanofiltration membrane

In this study, nanofiltration was applied to the concentration of the 6-aminopenicillinic acid (6-APA) from bioconverted penicillin solution and also to its mother liquor. The 6-APA in the solution was concentrated from 0.211 mol/L to 0.746 mol/L by nanofiltration. The final maximum concentration was 3.6 times higher than the initial concentration and the recovery yield was 97% to 99% of the original 6-APA. The concentrated solution was crystallized with the yields of 88.9–90.2% and the purity of the crystallized product was about 98%. The concentration of 6-APA in the mother liquor after crystallization was 0.014 mol/L and thus was concentrated 20–30 fold by nanofiltration and crystallization. The recovery of 6-APA was over 98%. The salts contained in the mother liquor, such as NH₄Cl and KCl, could be removed by allowing them to permeate through the membrane.     

重组人尿激酶原纯化中浓缩方法的比较

对尿激酶原纯化中的浓缩方法进行了探索,先后采用了3种不同的方法,即超滤、CM-阳离子柱、疏水色谱柱浓缩。结果表明,超滤只适合于大量样品的浓缩,样品量较小时损失较大,而且机械作用较强会使部分产品分解;CM-阳离子枉浓缩回收率较高,但得到的产品盐浓度高,还需要经过脱盐处理,增加了操作步骤,而疏水柱浓缩方法较为理想,经它浓缩后的产品用SDS-PAGE分析,非还原条件下,纯度在98％以上,还原条件下单链占90％以上,浓缩16倍,尿激酶原浓度达到3mg/ml以上。     

重组逆转录病毒浓缩方法研究

选择含有新霉素磷酸转移酶Ⅱ（Neor)的重组逆转录病毒载体,通过包装细胞进行包装,得到了含有重组逆转录病毒粒子的病毒溶液,该病毒溶液分别采用差速离心和滤膜截留两种方法进行浓缩,浓缩前,后的病毒溶液体外感染靶细胞NIH3T3以测定其滴度。结果显示,差速离心法的浓缩效率要优于滤膜截留法的浓缩效率,其浓缩效率能达到34．5％。     

Influence of the toxic compounds present in brewer's spent grain hemicellulosic hydrolysate on xylose-to-xylitol bioconversion by Candida guilliermondii

Fermentation media containing different concentrations of toxic compounds were prepared from brewer's spent grain (BSG) hemicellulosic hydrolysate, and used for xylose-to-xylitol bioconversion by Candida guilliermondii. Such fermentation media were composed of the hydrolysate in the following ways: raw (RH); concentrated four-fold (CH); concentrated and treated with activated charcoal (TCH); raw supplemented with sugars until a concentration four-fold higher (SRH); concentrated and subsequently diluted but supplemented with sugars until a concentration four-fold higher (SDCH). All media presented an initial xylose concentration of 85 g/l, except RH, which contained 23 g/l xylose. Fermentation results revealed that the sugars supplementation to raw hydrolysate favored the xylitol production. Nevertheless, xylitol production from CH was negatively affected due to the high concentration of toxic compounds present in the medium. The hydrolysate treatment with activated charcoal partially removed the toxic compounds, and the xylitol production was higher than in CH, but not so efficient as in SRH. It was thus concluded that to obtain an efficient xylose-to-xylitol bioconversion from BSG hydrolysate, the sugars concentration must be increased, but the toxic compounds concentration must be reduced to the same level present in the raw hydrolysate.     

Transient concentration of a gamma-tubulin-related protein with a pericentrin-related protein in the formation of basal bodies and flagella during the differentiation of Naegleria gruberi

The distribution of two proteins in Naegleria gruberi, N-gammaTRP (Naegleria gamma-tubulin-related protein) and N-PRP (Naegleria pericentrin-related protein), was examined during the de novo formation of basal bodies and flagella that occurs during the differentiation of N. gruberi. After the initiation of differentiation, N-gammaTRP and N-PRP began to concentrate at the same site within cells. The percentage of cells with a concentrated region of N-gammaTRP and N-PRP was maximal (68%) at 40 min when the synthesis of tubulin had just started but no assembled microtubules were visible. When concentrated tubulin became visible (60 min), the region of concentrated N-gammaTRP and N-PRP was co-localized with the tubulin spot and then flagella began to elongate from the region of concentrated tubulin. When cells had elongated flagella, the concentrated N-gammaTRP and N-PRP were translocated to the opposite end of the flagellated cells and disappeared. The transient concentration of N-gammaTRP coincided with the transient formation of an F-actin spot at which N-gammaTRP and alpha-tubulin mRNA were co-localized. The concentration of N-gammaTRP and formation of the F-actin spot occurred without the formation of microtubules but were inhibited by cytochalasin D. These observations suggest that the regional concentration of N-gammaTRP and N-PRP is mediated by actin filaments and might provide a site of microtubule nucleation for the assembly of newly synthesized tubulins into basal bodies and flagella.     

Concentrating Autographa californica nuclear polyhedrosis virus and recombinant alkaline phosphatase from insect cells using a temperature-sensitive hydrogel

Recombinant alkaline phosphatase expressed in insect cells was concentrated by a factor of one and half times at a separation efficiency of 54.2% using hydrogel ultrafiltration. Enzyme concentration was confirmed by SDS-PAGE as well as by spectrophotometric measurement. Wild and recombinant Autographa californica nuclear polyhedrosis viruses (AcNPV) were concentrated 1.4 and 1.6 times of the feed solution at 48.5 and 60.0% separation efficiency, respectively. Hydrogel ultrafiltration appears to be an attractive alternative for the concentration of AcNPV and recombinant proteins from insect cells. This revised version was published online in June 2006 with corrections to the Cover Date.     

Biological detoxification of different hemicellulosic hydrolysates using Issatchenkia occidentalis CCTCC M 206097 yeast

This work had as its main objective to contribute to the development of a biological detoxification of hemicellulose hydrolysates obtained from different biomass plants using Issatchenkia occidentalis CCTCC M 206097 yeast. Tests with hemicellulosic hydrolysate of sugarcane bagasse in different concentrations were carried out to evaluate the influence of the hydrolysate concentration on the inhibitory compounds removal from the sugarcane bagasse hydrolysate, without reduction of sugar concentration. The highest reduction values of inhibitors concentration and less sugar losses were observed when the fivefold concentrated hydrolysate was treated by the evaluated yeast. In these experiments it was found that the high sugar concentrations favored lower sugar consumption by the yeast. The highest concentration reduction of syringaldehyde (66.67%), ferulic acid (73.33%), furfural (62%), and 5-HMF (85%) was observed when the concentrated hydrolysate was detoxified by using this yeast strain after 24 h of experimentation. The results obtained in this work showed the potential of the yeast Issatchenkia occidentalis CCTCC M 206097 as detoxification agent of hemicellulosic hydrolysate of different biomass plants.     

Kinetic behavior of Candida guilliermondii yeast during xylitol production from Brewer's spent grain hemicellulosic hydrolysate

Brewer's spent grain, the main byproduct of breweries, was hydrolyzed with dilute sulfuric acid to produce a hemicellulosic hydrolysate (containing xylose as the main sugar). The obtained hydrolysate was used as cultivation medium by Candidaguilliermondii yeast in the raw form (containing 20 g/L xylose) and after concentration (85 g/L xylose), and the kinetic behavior of the yeast during xylitol production was evaluated in both media. Assays in semisynthetic media were also performed to compare the yeast performance in media without toxic compounds. According to the results, the kinetic behavior of the yeast cultivated in raw hydrolysate was as effective as in semisynthetic medium containing 20 g/L xylose. However, in concentrated hydrolysate medium, the xylitol production efficiency was 30.6% and 42.6% lower than in raw hydrolysate and semisynthetic medium containing 85 g/L xylose, respectively. In other words, the xylose-to-xylitol bioconversion from hydrolysate medium was strongly affected when the initial xylose concentration was increased; however, similar behavior did not occur from semisynthetic media. The lowest efficiency of xylitol production from concentrated hydrolysate can be attributed to the high concentration of toxic compounds present in this medium, resulting from the hydrolysate concentration process.     

Short-term physiologic effects of mechanical flow sorting and the Becton-Dickinson cell concentrator in cultures of the marine phytoflagellata Emiliania huxleyi and Micromonas pusilla.

BACKGROUND: In contrast to large, high-efficiency cytometers, mechanically sorting benchtop instruments provide a feasible alternative for shipboard cell sorting of oceanic microbial communities. However, sorting efficiency of these instruments is constrained by their maximum sorting rate of approximately 300 cells/s and by constant dilution of sorted samples by sheath flow. These factors often render too low sorted cell concentrations for postsorting experiments of oceanic phytoplankton populations of low natural abundance. A Cell Concentrator module has been marketed to overcome these dilution effects. Postsorting experiments also have to consider potential physiologic effects of cell sorting. Short-term physiologic effects on phytoplankton photosynthetic rates and esterase activities by mechanical flow sorting and cell concentration and on the efficiency of the Cell Concentrator module are evaluated. METHODS: Increasing numbers of the oceanic phytoflagellates Micromonas pusilla and Emiliania huxleyi were sorted and concentrated, and recovery in the concentrated samples was compared with the sorted-only samples (concentration rate) and the total number of sorted cells (recovery rate). Photosynthetic rates and metabolic activities of sorted and sorted/concentrated cells were compared with unsorted cells. Photosynthetic rates were estimated from 14CO2 uptake experiments and metabolic activity quantified cytometrically after cleavage of fluorescein diacetate. RESULTS: Irrespective of the total number of sorted cells, concentration rates between concentrated and sorted cells remained mostly below 10-fold and did not increase with the number of concentrated cells. Recovery rates in the concentrated samples amounted to fewer than 10% of total sorted cells, except for forceful resuspension attempts in the Concentrator insert (25-44%), which might be unsuitable for delicate species. Cell sorting resulted in a 24-49% decrease in photosynthetic rates. Metabolic activity within metabolically active cells was not affected by cell sorting, but the share of metabolically active cells decreased by 32-37%. Cell concentration did not affect metabolic activity or the fraction of active cells but did increase photosynthetic rate several-fold compared with unsorted cells. CONCLUSION: Low recovery of concentrated cells, probably due to cell adhesion to the filer bottom of the Concentrator insert, render the Cell Concentrator of limited use to overcome dilution problems of mechanical flow sorting, particularly when results are extrapolated to natural, low-abundance populations. Severe changes in photosynthetic rates also render concentrated cells suspicious for subsequent physiologic experiments. Mechanical sorting alone also exhibited significant physiologic effects on sorted cells, some of which might not be temporary. Comparable effects between mechanical sorting and droplet sorting as previously reported confirm that physiologic effects might be caused predominantly by shear stress and laser exposure during cytometric analysis rather than the sorting process. Sufficient recovery time must be allowed before postsorting experiments, but potential changes in cell physiology from the natural conditions during postsorting recovery must be considered.     

In Situ Rhamnolipid Production at an Abandoned Petroleum Refinery

A simple screening method was developed to detect in situ biosurfactant production by exploiting the relationship between surface tension (ST) and surfactant concentration. Filtered groundwater from contaminated wells with ST values of 60 to 70 dynes/cm decreased to 29 dynes/cm after being concentrated 10 to 15 times in a rotary evaporator, indicating that biosurfactants in the sample reached the critical micelle concentration (CMC). Samples from uncon-taminated groundwater concentrated 25 times showed no decrease in ST below 72 dynes/cm, suggesting that biosurfactants were not present. Microorganisms from soil cores were cultured on diesel fuel and identified using fatty acid methyl ester (FAME) analysis. Pseudomonas aeruginosa was found at very low numbers in uncontami-nated soil but was the dominant species in contaminated soil, indicating that hydrocarbon release impacted microbial diversity significantly. High-performance liquid chromatography (HPLC) was used to quantify rhamnolipids, biosurfactants produced by P. aeruginosa, in concentrated ground-water samples. Rhamnolipid concentrations in samples from contaminated soil were observed equal to their CMC (50 mg/L), but were not detected in samples from un-contaminated wells. We conclude that biosurfactant production may be an indicator of intrinsic bioremediation.     

Concentration and purification of influenza virus from allantoic fluid

A simple procedure which enables the concentration and purification of influenza virus, using an angular rotor, is described. Virus is concentrated over a sucrose step gradient. The same gradients are reused and volumes up to 4 liters are concentrated in 1 day. The concentrated virus is further purified by a simplified density-gradient technique. No host cell protein is detectable in the final product. The technique offers a broad application potential for concentrating and purifying other viruses.     

Highly efficient transduction of repopulating bone marrow cells using rapidly concentrated polymer-complexed retrovirus

Using the cationic polymer, Polybrene, and the anionic polymer, chondroitin sulfate C, we concentrated recombinant retrovirus pseudotyped with an ecotropic envelope, which is susceptible to inactivation by high-speed concentration methods. To evaluate gene marking, murine bone marrow was harvested from C3H mice, transduced with polymer-concentrated GFP virus, and transplanted into lethally irradiated recipients. Total gene marking in mice averaged 30-35% at 8 weeks post-transplant and transgene expression remained stable for over 16 weeks. Using the polymer concentration method, a second retroviral vector encoding the drug resistant variant of dihydrofolate reductase (L22Y-DHFR) was concentrated and tested. Approximately 40% of transduced murine bone marrow progenitor cells were protected against trimetrexate concentrations that completely eliminated the growth of non-modified cells. These results show that anionic and cationic polymers can be combined to rapidly concentrate viruses that are normally difficult to concentrate, and the concentrated virus efficiently transduces hematopoietic stem cells.     

Concentration and Purification of Viruses by Adsorption to and Elution from Insoluble Polyelectrolytes

Acid-resistant, nonenveloped viruses belonging to the enterovirus, reovirus, and adenovirus groups were readily concentrated on PE60, an insoluble cross-linked polyelectrolyte based on isobutylene maleic anhydride. Hydrolysis of PE60 by NaOH increased its capacity to adsorb viruses. Hydrogen ion levels played an important role in virus concentration; optimal pH levels for maximal virus adsorption were between pH 3.0 and 4.5. Undiluted virus was easily concentrated from large volumes on PE60, and the adsorbed virus was readily eluted at pH 8 to 9.     

Concentration-based self-assembly of phycocyanin

Cyanobacteria light-harvesting complexes can change their structure to cope with fluctuating environmental conditions. Studying in vivo structural changes is difficult owing to complexities imposed by the cellular environment. Mimicking this system in vitro is challenging, as well. The in vivo system is highly concentrated, and handling similar in vitro concentrated samples optically is difficult because of high absorption. In this research, we mapped the cyanobacteria antennas self-assembly pathways using highly concentrated solutions of phycocyanin (PC) that mimic the in vivo condition. PC was isolated from the thermophilic cyanobacterium Thermosynechococcus vulcanus and measured by several methods. PC has three oligomeric states: hexamer, trimer, and monomer. We showed that the oligomeric state was changed upon increase of PC solution concentration. This oligomerization mechanism may enable photosynthetic organisms to adapt their light-harvesting system to a wide range of environmental conditions.     

Inhibition of NaCl appetite when DOCA-treated rats drink saline

Marked increases in the consumption of concentrated NaCl solution were elicited in rats by daily injection of the synthetic mineralocorticoid, deoxycorticosterone acetate (DOCA). DOCA-treated rats drank different volumes of NaCl solution depending on its concentration (between 0.15 M and 0.50 M), with less consumed (in milliliters) the more concentrated the fluid was. In consequence, total Na(+) intake (in milliequivalents) was roughly similar in all groups. Gastric emptying of Na(+) also diminished as the concentration of the ingested NaCl solution increased, and the delivery of Na(+) to the small intestine was remarkably similar in all groups. Cumulative volume of ingested fluid in the stomach and small intestine was very closely related to intake (in milliliters) of the concentrated NaCl solutions. Systemic plasma Na(+) levels did not increase until after rats stopped consuming concentrated NaCl solution, although they were elevated at the onset of water ingestion. The situation appeared to be different when 0.15 M NaCl was consumed. This isotonic solution emptied and was absorbed relatively rapidly, and DOCA-treated rats drank larger amounts of it throughout a 1-h test period than when they drank concentrated NaCl solutions. Collectively, these findings suggest that saline consumption by DOCA-treated rats may be inhibited by two presystemic factors, one related to the volume of ingested fluid (i.e., distension of the stomach and small intestine) and one related to its concentration (i.e., elevated osmolality of fluid in the small intestine and/or in adjacent visceral tissue).     

A comparison of six methods for the concentration of a porcine enterovirus.

Single-step concentration of porcine enterovirus strain T80 by adsorption to the polyelectrolyte PE60 gave virus concentration factors of 35- to 88-fold in terms of plaque-forming units, with recovery rates of 22 to 75% of total virus present in the original virus suspension. Concentration by separation in an aqueous polymer two-phase system gave virus concentration factors of 56- to 105-fold and recovery rates of 37 to 107%. In the latter procedure, sodium dextran sulfate appeared to have no effect on plaque numbers, although plaques were sharper and clearer when this substance was incorporated in the overlay. The failure of sonication of virus concentrated by either procedure to increase plaque numbers indicated the absence of virus aggregates in the concentrates. T80 virus was not effectively concentrated by cobalt chloride or polyethylene glycol precipitation or by adsorption to either aluminium hydroxide or calcium hydrogen phosphate.     

Simple method for the concentration of influenza virus from allantoic fluid on microporous filters.

Membrane filter adsorption-elution is an efficient method for concentration and partial purification of several types of viruses from various aqueous solutions. For efficient virus adsorption to negatively charged filters, the sample is adjusted to pH 3.5 and trivalent salts are added before filtration. Since influenza virus is sensitive to extremes in pH, it cannot be concentrated by ordinary filters. Zeta Plus filters, which have a net positive charge of up to 5 or 6, were evaluated for the concentration of influenza virus from infectious allantoic fluids. Influenza virus efficiently adsorbed to Zeta Plus filters at pH 6, and addition of salts was not necessary. Adsorbed virus was eluted in a small volume of 2% bovine serum albumin plus 1 M NaCl at pH 10. By this procedure, viruses in 100 ml of allantoic fluid were concentrated to a final volume of 8 ml, with an average recovery efficiency of 71.0%.     

On-line recovery of large molecules and concentration of small molecules using reciprocating size exclusion chromatography with temperature swing

The reciprocating size exclusion chromatography (RSEC) was operated with swing between two temperatures in a synchronous way with flow direction to recover a large solute on-line from the mixture, in addition to the small solute concentration. The concentration of small solutes in RSEC with a temperature swing was made possible by taking advantage of the temperature-dependent swelling properties of the porous gel. After 7 cycles of frontal mode operation, 76% of Blue Dextran in the feed was recovered and nickel nitrate in the feed reservoir was concentrated by 13%.     

Formation of giant liposomes from lipids in chaotropic ion solutions

Liposomes with diameters in the range of 10–20 μm, evidently uni- and oligolamellar, were generated upon removal of sodium trichloroacetate by dialysis or dilution from a solution containing egg phospholipids and sodium trichloroacetate. At room temperature, giant liposomes were formed only from concentrations of sodium trichloroacetate which induced the transformation of phosphatidylcholine from the lamellar to the micellar phase. The yield of giant liposomes increases with increasing phospholipid concentration in the sodium trichloroacetate solution. Inclusion of a freeze-thaw step reduced the concentration of sodium trichloroacetate needed to generate giant liposomes to less than 0.1 M and substantially lowered the minimum lipid concentration. Apparently sodium trichloroacetate is concentrated during freezing to above the critical concentration which solubilizes phospholipids. The micelles, so generated, also become concentrated so that giant liposomes form upon thawing as the melting ice dilutes the trichloroacetic acid and the micellar phase reverts to the lamellar phase. Other chaotropic solutions, such as guanidine-HCl and urea, which did not solubilize lipids at room temperature, also generated giant liposomes when their solutions, containing dispersed lipids, were frozen, thawed and then dialyzed to remove the solutes. In the case of chaotropic anions such as thiocyanate and nitrate, potassium salts are more effective than sodium salts.