Bioconversion of para-substituted monophenolic compounds into corresponding catechols by alginate entrapped cells ofMucuna pruriens

Alginate-entrapped cells ofM. pruriens were able to convert a number of parasubstituted monophenolic compounds into the corresponding catechols. All catechols produced were released into the medium, which offered the opportunity to isolate these products via a relatively simple procedure. Prepurification was performed on a Sephadex G10 gel and catechols were concentrated on Affigel 601. The identity of all products was confirmed with combined liquid chromatography/mass spectrometry (LC/MS) or MS using the desorption chemical ionization technique, depending on the catechol. For the entrapped cells and for a cell homogenate prepared of the same cell line ofM. pruriens the substrate specificities were qualitatively identical when judged on initial rates of synthesis calculated on protein basis.     

Further kinetic characterization of alginate-entrapped cells of Mucuna pruriens L

Alginate-entrapped cells of Mucuna pruriens L. hydroxylate L -tyrosine, tyramine, para-hydroxyphenylpropionic acid, and para-hydroxyphenylacetic acid to their corresponding catechols, which were released into the incubation medium. Michaëlis-Menten kinetics was applied for each bioconversion. The apparent affinity constants were comparable with the affinity constants obtained with a homogenate directly prepared from the cells used for entrapment and with a derived partly purified phenoloxidase. The values found for the apparent maximum rates of bioconversion of the entrapped cells were ca. 50% of the values of the maximum rates of bioconversion of the cell homogenate, indicating that the entrapped cell system was not operating optimally. The effective diffusivities of the substrates and products were measured with alginate-entrapped, inactivated cells. From the five inactivation methods tested, glutaric aldehyde treatment was chosen as the general procedure. Calculated effective diffusivities for the monophenols and catechols demonstrated that these compounds could diffuse freely into and out of the beads. For each bioconversion, the observable modulus was calculated from the initial rate of bioconversion and the effective diffusivity of the substrate. The resulting values indicated that the diffusional supply rate of the substrates was not the limiting factor, except for the conversion of tyramine for which a modulus higher than one was obtained. Analogously, the observable moduli were calculated for oxygen, which was utilized for bioconversion and cell respiration, and these values pointed towards strong oxygen limitation in all cases. The bioconversion rates of the entrapped cells increased with decreasing cell aggregate size. Therefore, it was concluded that direct cell-matrix contact determined the amount of phenoloxidase involved in the bioconversions. The bioconversion rate on a protein basis was constant with enhancement of the bead charge and thus, in spite of limitations, the mixing conditions as such were relatively optimal. In conclusion, the nonoptimal efficiency of the plant cell system studied was caused by oxygen limitation and a partial phenoloxidase participation, but not by mass transfer limitations for substrates and products with the exception of the conversion of tyramine into dopamine.     

Assessment of nodulation of Mucuna pruriens by promiscuous indigenous rhizobia in the moist savanna zone of Nigeria

Leucaena leucocephala failed to nodulate effectively with promiscuous indigenous rhizobia with which Mucuna pruriens nodulated effectively. Mucuna pruriens was adequately established and well nodulated due to the presence of favourable climatic and edaphic factors which enhanced its establishment in the humid/moist savanna zone of Nigeria. The microsymbiont for M. pruriens seems to thrive more in an alkaline rhizosphere. Introduction of M. pruriens into the farming system in Nigeria may serve as a low input agricultural system, which is not only sustainable but also economically viable.     

Degradation of ethylbenzene by free and immobilized <Emphasis Type="Italic">Pseudomonas</Emphasis><Emphasis Type="Italic">fluorescens-</Emphasis>CS2

Pseudomonas fluorescens-CS2 metabolized ethylbenzene as the sole source of carbon and energy. The involvement of catechol as the hydroxylated intermediate during the biodegradation of ethylbenzene was established by TLC, HPLC and enzyme analysis. The specific activity of Catechol 2,3-dioxygenase in the cell free extracts of P. fluorescens-CS2 was determined to be 0.428 μmoles min⁻¹ mg⁻¹ protein. An aqueous-organic, Two-Phase Batch Culture System (TPBCS) was developed to overcome inhibition due to higher substrate concentrations. In TPBCS, P. fluorescens-CS2 demonstrated ethylbenzene utilization up to 50 mM without substrate inhibition on inclusion of n-decanol as the second phase. The rate of ethylbenzene metabolism in TPBCS was found enhance by fivefold in comparison with single phase system. Alternatively the alginate, agar and polyacrylamide matrix immobilized P. fluorescens-CS2 cells efficiently degraded ethylebenzene with enhanced efficiency compared to free cell cultures in single and two-phase systems. The cells entrapped in ployacrylamide and alginate were found to be stable and degradation efficient for a period of 42 days where as agar-entrapped P. fluorescens was stable and efficient a period of 36 days. This demonstrates that alginate and polyacrylamide matrices are more promising as compared to agar for cell immobilization.     

Radiochemical high-performance liquid chromatographic assay for the determination of catechol O-methyltransferase activity towards various substrates

A new chromatographic catechol O-methyltransferase (COMT) assay based on S-adenosyl- -[methyl-¹⁴C]methionine and on-line radioactivity detection was developed. With minor modifications in the mobile phase composition the methylation velocities for 30 structurally diverse compounds including simple catechols, neurotransmitters, catecholestrogens and catecholic drugs could be measured using human and rat recombinant soluble COMT. The enzymes showed very similar substrate selectivities. The radiochemical method was validated using 3,4-dihydroxybenzoic acid as a model substrate and it was shown that accurate and reproducible methylation velocity values could be achieved for both of the catecholic hydroxyls. The method proved to be suited for determining the enzyme kinetic parameters and can probably be further used for gathering enzyme kinetic data on differentially substituted catechols in order to construct proper structure-activity relationships for COMT.     

Degradation of diphenylether by Pseudomonas cepacia Et4: enzymatic release of phenol from 2,3-dihydroxydiphenylether

2,3-Dihydroxybiphenyl dioxygenase from Pseudomonas cepacia Et 4 was found to catalyze the ring fission of 2,3-dihydroxydiphenylether in the course of diphenylether degradation. The enzyme was purified and characterized. It had a molecular mass of 240 kDa and is dissociated by SDS into eight subunits of equal mass (31 kDa). The purified enzyme was found to be most active with 2,3-dihydroxybiphenyl as substrate and showed moderate activity with 2,3-dihydroxydiphenylether, catechol and some 3-substituted catechols. The K _m-value of 1 M for 2,3-dihydroxydiphenylether indicated a high affinity of the enzyme towards this substrate. The cleavage of 2,3-dihydroxydiphenylether by 2,3-dihydroxybiphenyl dioxygenase lead to the formation of phenol and 2-pyrone-6-carboxylate as products of ring fission and ether cleavage without participation of free intermediates. Isotope labeling experiments carried out with ¹⁸O₂ and H₂ ¹⁸O indicated the incorporation of ¹⁸O from the atmosphere into the carboxyl residue as well as into the carbonyl oxygen of the lactone moiety of 2-pyrone-6-carboxylate. Based on these experimental findings the reaction mechanism for the formation of phenol and 2-pyrone-6-carboxylate is proposed in accordance with the mechanism suggested by Kersten et al. (1982).Non-standard abbreviations DPE diphenylether - 2,3-dihydroxy-DPE 2,3-dihydroxydiphenylether - PCA 2-pyrone-6-carboxylic acid - 2,3-dihydroxy-BP dioxygenase 2,3-dihydroxybiphenyl dioxygenase - GC gas chromatography     

Degradation of phenol and phenolic compounds by Pseudomonas putida EKII

Summary The phenol-degrading strain Pseudomonas putida EKII was isolated from a soil enrichment culture and utilized phenol up to 10.6 mM (1.0 g·1 ^-1) as the sole source of carbon and energy. Furthermore, cresols, chlorophenols, 3,4-dimethylphenol, and 4-chloro-m-cresol were metabolized as sole substrates by phenol-grown resting cells of strain EKII. Under conditions of cell growth, degradation of these xenobiotics was achieved only in co-metabolism with phenol. Phenol hydroxylase activity was detectable in whole cells but not in cell-free extracts. The specificity of the hydroxylating enzyme was found during transformation of cresols and chlorophenols: ortho- and meta-substituted phenols were degraded via 3-substituted catechols, while degradation of para-substituted phenols proceeded via 4-substituted catechols. In cell-free extracts of phenol-grown cells a high level of catechol 2,3-dioxygenase as well as smaller amounts of 2-hydroxymuconic semialdehyde hydrolyase and catechol 1,2-dioxygenase were detected. The ring-cleaving enzymes were characterized after partial purification by DEAE-cellulose chromatography.     

Degradation of 3-nitrophenol by Pseudomonas putida B2 occurs via 1,2,4-benzenetriol

Growth of Pseudomonas putida B2 in chemostat cultures on a mixture of 3-nitrophenol and glucose induced 3-nitrophenol and 1,2,4-benzenetriol-dependent oxygen uptake activities. Anaerobic incubations of cell suspensions with 3-nitrophenol resulted in complete conversion of the substrate to ammonia and 1,2,4-benzenetriol. This indicates that P. putida B2 degrades 3-nitrophenol via 1,2,4-benzenetriol, via a pathway involving a hydroxylaminolyase. Involvement of this pathway in nitroaromatic metabolism has previously only been found for degradation of 4-nitrobenzoate.Reduction of 3 nitrophenol by cell-free extracts was strictly NADPH-dependent. Attempts to purify the enzymes responsible for 3-nitrophenol metabolism were unsuccessful, because their activities were extremely unstable. 3-Nitrophenol reductase was therefore characterized in cell-free extracts. The enzyme had a sharp pH optimum at pH 7 and a temperature optimum at 25°C. At 30°C, reductase activity was completely destroyed within one hour, while at 0°C, the activity in cell-free extracts was over 100-fold more stable. The K_m values for NADPH and 3-nitrophenol were estimated at 0.17 mM and below 2 M, respectively. The substrate specificity of the reductase activity was very broad: all 17 nitroaromatics tested were reduced by cell-free extracts. However, neither intact cells nor cell-free extracts could convert a set of synthesized hydroxylaminoaromatic compounds to the corresponding catechols and ammonia. Apparently, the hydroxylaminolyase of P. putida B2 has a very narrow substrate specificity, indicating that this organism is not a suitable biocatalyst for the industrial production of catechols from nitroaromatics.     

Estimation of genetic diversity in varieties of Mucuna pruriens using RAPD

Genetic diversity was estimated in 13 accessions of the otherwise self pollinated Mucuna pruriens (L.) DC. (velvetbean) comprising varieties pruriens and utilis collected from tropical humid forest using 15 RAPD primers. Similarity index value of 0.68 based on Nei and Li's similarity coefficient indicated high degree of genetic variability. Analysis of various genetic diversity indices like total heterozygosity, Nei's gene diversity, percentage of polymorphic loci, expected and observed number of alleles and Shannon index strongly suggests that variety pruriens is genetically more diverse than variety utilis. Chemical analysis with respect to 3,4-dihydroxy-L-phenylalanine (L-DOPA) content showed uniform distribution. Cluster analysis showed grouping of accessions into two major clusters and tendency of accessions of variety pruriens to group according to their geographical locations. Bootstrap analysis confirmed the robustness of the phenogram. The putative hybrid MMP6 with relatively low similarity value index and low L-DOPA content was promising as food or fodder.     

Micropropagation of Two Australian Native Fruit Species,Davidsonia pruriens and Davidsonia jerseyana G. Harden & J.B. Williams

Nodal explants from in vitro grown seedlings of Davidsonia pruriens and D. jerseyana, established on MS media were treated with various concentrations of three cytokinins. D. pruriens developed optimum shoot growth in terms of shoot height and number of leaves per shoot when 1.0 µM BA was added to basal MS medium while optimum shoot growth for D. jerseyana was obtained when 0.01 µM 2iP was added to the medium. Optimum root initiation and development was obtained when actively growing axillary shoots were cultured on 1/2MS medium plus 32.2 µM IBA for 3–5 days for D. pruriens and 2–3 days for D. jerseyana before transfer to PGR-free medium containing 10 µM riboflavin. Root initiation of more than 80% was achieved with multiple genotypes of D. pruriens and three genotypes of D. jerseyana using juvenile material. The plantlets were transferred to pots and grown in the greenhouse with a success rate of 60% for D. pruriens and 75% for D. jerseyana. Adult D. jerseyana stem explants produced 2–5 shoots per nodal explant upon treatment with 0.1 µM BA. Side shoots from adult D. jerseyana produced similar results for shoot multiplication as for juvenile material. Protocol for multiplication of adult D. pruriens was achieved with much greater difficulty by using material from the green house. Axillary shoots were initiated when 100 µM TDZ was applied to the stem of an adult pot plant and the resultant side shoots were cultured on MS medium containing 1.0 µM BA and 1.0 µM GA₃.     

Utilization and cooxidation of chlorinated phenols byPseudomonas sp. B 13

Pseudomonas sp. B13 was grown in continuous culture on 4-chlorophenol as the only carbon source. Maximum growth rate of 0.4h^-1 was observed at a substrate concentration of >0.01 mM and <0.15 mM. In addition to the enzymes of phenol catabolism, high specific 1,2-dioxygenase activities with chlorocatechols as substrates were found. The isomeric monochlorinated phenols were also totally degraded by 4-chlorophenol grown cells. (+)-2,5-Dihydro-4-methyl- and (+)-2,5-dihydro-2-methyl-5-oxo-furan-2-acetic acid were formed in high yield as dead-end catabolites from cooxidation of cresoles.Several dichlorophenols except 2,6-dichlorophenol were removed from the culture fluid by chlorophenol grown cells. Ring cleavage of chlorinated catechols were shown to be one of the critical steps in chlorophenol catabolism. A catabolic pathway for isomeric chlorophenols is discussed.Non-Standard Abbreviations HPLC High performance liquid chromatography - DHB Dihydrodihydroxybenzoate 3,5-cyclohexadiene-1,2-diol-1-carboxylic acid     

Cometabolic turnover of aniline,phenol and some of their monochlorinated derivatives by the Rhodococcus mutant strain AM 144

One-step conversion of aniline, phenol and some of their monochlorinated derivatives into the corresponding catechols by resting pre-adapted cells of the Rhodococcus mutant strain AM 144 (defective in synthesis of catechol 1,2-dioxygenase) was shown to depend on the availability of an additional metabolizable carbon substrate, e.g. glucose or acetate. A stoichiometric relation existed between the amount of the latter compounds added and the amount of aniline (or phenol, respectively) converted into catechol suggesting that the primary function of the cosubstrates was to provide reducing power to the oxygenative transformation reaction. The observed cosubstrate-dependence generally parallels that seen in previous studies on turnover of different monochloroaromatic non-growth substrates by aromatics-utilizing Rhodococcus wildtype-strains. Cell cultures of strain AM 144 growing at the expense of acetate also proved able to convert aniline into catechol. Typically, growth of the cells was retarded during the phase of aniline transformation as compared to the respective control cultures. Based on the results of these model experiments, it was concluded that (i) in natural microbial communities cometabolically active bacteria would hardly enrich under cometabolic conditions over fast-growing non-cometabolizing bacteria if the latter organisms will tolerate the particular non-growth substrate, and (ii) cometabolizing bacteria would have a selective advantage only if the non-growth substrate to be transformed is a toxic one or if it can serve as a potential nutrient source (e.g., of nitrogen or sulfur).Abbreviations MCA monochloroaniline - MCP monochlorophenol - MCC monochlorocatechol - TLC thin-layer chromatography - MS mass spectrometry - GLC gas-liquid chromatography - UV ultraviolet (range of the spectrum)     

Immobilization and characterization of Saccharomyces cerevisiae in crosslinked,prepolymerized polyacrylamide-hydrazide

Summary Baker's yeast (Saccharomyces cerevisiae) was immobilized in gels made of prepolymerized, linear, water soluble polyacrylamide, partially substituted with acylhydrazide groups. Gelation was effected by the addition of controlled amounts of dialdehydes (e.g. glyoxal). The immobilized yeasts retained full glycolytic activity. Moreover, the entrapped cells were able to grow inside the chemically corsslinked gel during continuous alcohol production. Glyoxal was found to be the most favourable crosslinking agent for this system. the system employed allowed for the free exchange of substrate and products. The gel surrounding the entrapped cells had no effect on temperature stability profile. On the other hand, substantial enhancement in survival of cells in presence of high ethanol concentrations was recorded for the entrapped yeast. The capability of the immobilized yeast to carry out continuous conversion of glucose to ethanol was demonstrated.     

Structural characterization of the N-glycans of gpMuc from Mucuna pruriens seeds

Mucuna pruriens seeds are used in some countries as a human prophylactic oral anti-snake remedy. Aqueous extracts of M. pruriens seeds possess in vivo activity against cobra and viper venoms, and protect mice against Echis carinatus venom. It was recently demonstrated that the seed immunogen generating the antibody that cross-reacts with the venom proteins is a multiform glycoprotein (gpMuc), and the immunogenic properties of gpMuc seemed to mainly reside in its glycan chains. In the present study, gpMuc was found to contain only N-glycans. Part of the N-glycans could be released with peptide-(N ⁴-(N-acetyl-β -glucosaminyl)asparagine amidase F (PNGase F-sensitive N-glycans); the PNGase F-resistant N-glycans were PNGase A-sensitive. The oligosaccharides released were analyzed by a combination of MALDI-TOF mass spectrometry, HPLC profiling of 2-aminobenzamide-labelled derivatives and ¹H NMR spectroscopy. The PNGase F-sensitive N-glycans comprised a mixture of oligomannose-type structures ranging from Man₅GlcNAc₂ to Man₉GlcNAc₂, and two xylosylated structures, Xyl₁Man₃GlcNAc₂ and Xyl₁Man₄GlcNAc₂. The PNGase A-sensitive N-glycans, containing (α 1-3)-linked fucose, were identified as Fuc₁Xyl₁Man₂GlcNAc₂ and Fuc₁Xyl₁Man₃GlcNAc₂. In view of the determined N-glycan ensemble, the immunoreactivity of gpMuc was ascribed to the presence of core (β 1-2)-linked xylose- and core α (1-3)-linked fucose-modified N-glycan chains.     

Uptake of lactose and continuous lactic acid fermentation by entrapped non-growing Lactobacillus helveticus in whey permeate

 Continuous production of lactic acid from lactose has been carried out in a stirred-tank reactor with non-growing Lactobacillus helveticus entrapped in calcium alginate beads. A considerably longer operation half-life was obtained in a continuously operated reactor than in a batch-operated reactor. It is possible to simulate the action of entrapped non-growing cells on the basis of information from diffusion and kinetic experiments with suspended free cells. The simulation fit the experimental data over a broad range of substrate concentrations if the specific lactic acid production rate, q _P, was used as a variable parameter in the model. The dynamic mathematical model used is divided into three parts: the reactor model, which describes the mass balance in a continuously operated stirred-tank reactor with immobilized biomass, the mass-transfer model including both external diffusion and internal mass transfer, and the kinetic model for uptake of substrate on the basis of a Michaelis-Menten-type mechanism. From kinetic data obtained for free biomass experiments it was found, with the use of non-linear parameter estimation techniques, that the conversion rate of lactose by L. helveticus followed a Michaelis-Menten-type mechanism with K _S at half-saturation=0.22±0.01 g/l. The maximum specific lactose uptake rate for growing cells, q _S,max, varied between 4.32±0.02 g lactose g cells^-1 h^-1 and 4.89 ±0.02 g lactose g cells^-1 h^-1. The initial specific lactose uptake rate for non-growing cells, q _S,0, was found to be approximately 40% of the maximum specific lactose uptake rate for growing cells. Received: 4 October 1995/Received last revision: 23 April 1996/Accepted: 29 April 1996     

Effects of Canavalia ensiformis and Mucuna pruriens intercrops on Pratylenchus zeae damage and yield of maize in subsistence agriculture

Host status of four leguminous cover crops [Canavalia ensiformis (L.) DC. (Jack bean), Crotalaria ochroleuca G. Don (Sunnhemp), Lablab purpureus L. (Hyacinth bean) and Mucuna pruriens (L.) DC. (velvet bean)] to Pratylenchus zeae Filipjev and effects of intercropping C. ensiformis and M. pruriens with Pan5195, H627 and Emap11 maize cultivars on P. zeae population and disease severity on maize were determined in greenhouse and field tests. Pratylenchus zeae significantly (P<0.05) reduced growth of C. ochroleuca by 36% but had no effect on C. ensiformis, M. pruriens and L. purpureus. While C. ensiformis, M. pruriens and L. purpureus reduced P. zeae population, C. ochroleuca increased it. In the greenhouse test, intercropping maize with C. ensiformis significantly (P<0.05) improved maize growth by up to 34%, Nematode populations in the roots of maize intercropped with either C. ensiformis or M. pruriens were significantly (P<0.05) reduced by up to 32% while nematode disease severity in these intercropping systems was reduced by up to 26%. In the field test, intercropping Emap11, Pan5195 and H627 with C. ensiformis significantly (P<0.05) increased maize grain yield by 190, 29 and 22%, respectively. Intercropping H627 with M. pruriens significantly (P<0.05) increased maize grain yield by 12%, but grain yields of Pan5195 and Emap11 declined by 79 and 40%, respectively. Root necrosis and soil nematode populations in the C. ensiformis–maize intercrop declined by up to 50 and 30%, respectively. Under pure maize stands, soil nematode populations increased by up to 35% in 90 days relative to the initial nematode population of three nematodes g⁻¹ of fresh soil. Section Editor: P. A. M. Bakker     

Purification and properties of a phenol oxidase derived from suspension cultures of Mucuna pruriens

From cells of Mucuna pruriens, grown in suspension, a monophenol monooxygenase (EC 1.14.18.1) was purified to homogeneity, as deduced from sodium dodecyl sulfate-polyacrylamide gel electrophoresis. The enzyme appeared to have a native molecular weight of 90000±5000 dalton, and consisted of two subunits, each of 42000±1000 dalton. High-performance liquid chromatography with electrochemical detection for specific measurement of catecholes, was used to determine separately the tyrosinehydroxylating and catecholase activities of the enzyme. For the enzymatic activities, pH optima of, respectively, 7.5 and 5.5–6.5 were found; the effects of some inhibitors on both activities appeared to be different. Michaelis-Menten characteristics for some mono-and o-dihydroxysubstrates were determined.Abbreviations DEAE diethylaminoethyl - HPLC high-performance liquid chromatography - L-DOPA L-3,4-dihydroxyphenylalanine     

Continuous immobilized cell reactor for amide hydrolysis

Summary This article deals with continuous hydrolysis of acrylamide into acrylic acid using the wild-typeBrevibacterium sp. R312 which can hydrolyze all water-soluble amides into their corresponding acids. Biotransformation has been carried out in a fluidized bed reactor specially designed to obtain good contact conditions between cells entrapped into small calcium alginate beads (2–3 mm) and low-concentration acrylamide solutions (10–40g·l^–1). Different flow rates, biocatalyst loads and substrate concentrations have been investigated. Kinetic constants for the immobilized enzyme have been identified. It appears that the Michaelis constant does not change with operating conditions and remains roughly equal to the value obtained for free cells. In contrast, the maximum rate of hydrolysis is considerably decreased, as if only cells on the outskirts of beads were involved in the transformation. On the whole it is proved that corynebacteria cells could be usefully used for the bioconversion of amides in a continuous immobilized cell reactor; the higher the solid hold-up and/or the smaller the beads, the more efficient the biological transformation.     

Halotolerance studies onChlamydomonas reinhardtii: glycerol excretion by free and immobilized cells

The freshwater green algaChlamydomonas reinhardtii can tolerate a maximum saline concentration of 200 mM NaCl. In response to this osmotic shock, the cells accumulated during the first 24 h 15% of the total glycerol synthesized as osmoregulatory metabolite, to provide the corresponding osmotic balance. After this period all glycerol synthesized was excreted to the medium, 4 g L^-1 at 120 h in optimal conditions, before cell degradation occurred. This excretion was about 2-fold higher in Ca-alginate entrapped cells in the presence of 250 mM NaCl. It was concluded that immobilized cells may be of biotechnological interest for continuous glycerol photoproduction in air-lift bioreactors.