Recycle of cellulases and the use of lignocellulosic residue for enzyme production after hydrolysis of steam-pretreated aspenwood

Summary Various modes of substrate and enzyme addition were used to hydrolyze a 10% concentration (w/v) of steam-exploded, water-and-alkali extracted aspenwood withTrichoderma harzianum E58 cellulases. Although cellulose conversion was high (94–100%), enzyme recovery was low in all cases. Low enzyme recovery was due to a combination of thermal inactivation and adsorption of the cellulases onto the lignocellulosic residue. Enzyme recycle was not feasible as the activity of the recovered cellulases towards crystalline cellulose was low. However, the residual material from enzyme hydrolysis was a suitable carbon source for cellulase enzyme production byT. harzianum based on enzyme yield and hydrolytic potential. These residues could only be used up to a 1% substrate concentration, since at higher substrate loadings cellulase production was reduced, likely because of lignin inhibitors.     

Penicillium sp. 23 alpha-galactosidase: purification and substrate specificity

α-Galactosidase, a glycoprotein with carbohydrate and protein in ratio 1:6, has been isolated from liquid culture of micromycete Penicillium sp. 23 and purified to homogeneous state by ammonium sulphate precipitation followed by ion exchange and gel-filtration chromatography on TSK-gels. The Penicillium sp. 23 α-galactosidase specificity against a series of natural and synthetic substrates has been studied. The enzyme was found to exhibit strict specificity towards the glycon and hydrolyze exclusively α- -galactosides such as p-nitrophenyl-α- -galactopyranoside (p-NPhGal), melibiose, raffinose and stachyose. The configuration at C1 and C4 atoms of substrate as well as substitution at C2 and C6 of substrate made an important contribution to the interaction with the enzyme. The tested α-galactosidase exerted the highest affinity (K_m) with respect to the synthetic substrate p-NPhGal and maximal rate of hydrolysis (V_max), about 10 times higher, comparing with natural substrates (melibiose, raffinose and stachiose). The Penicillium sp. 23 α-galactosidase possesses wide specificity towards α-galactosidase hydrolysis link type, splitting off at varying rates the terminal galactose from disaccharides, attached by α-1,2-, α-1,3- and α-1,6-links. The enzyme is ineffective towards disaccharides with α-1,4-link. The enzyme showed potential to splitting off α-1,3-bound terminal galactose residues from antigens of the human blood group B(III) erythrocytes.     

An acidic and thermostable carboxymethyl cellulase from the yeast Cryptococcus sp. S-2: purification, characterization and improvement of its recombinant enzyme production by high cell-density fermentation of Pichia pastoris

The extracellular carboxymethyl cellulase (CSCMCase) from the yeast, Cryptococcus sp. S-2, was produced when grown on cellobiose. It was purified to homogeneity from the supernatant by ultrafiltration, DEAE-5PW anion exchange column and TSK-Gel G3000SW gel filtration. The purified enzyme was monomeric protein with molecular mass of approximately 34 kDa. The optimum temperature and pH for the action of the enzyme were at 40–50 °C and 3.5, respectively. It was stable at pH range of 5.5–7.5 and retained approximately 50% of its maximum activity after incubating at 90 °C for 1 h. Moreover, it could able to hydrolyze carboxymethyl cellulose sodium salt higher than insoluble cellulose substrate such as Avicel, SIGMACELL^® and CM cellulose. Due to its action at acidic pH and moderately stable at high temperature, the gene encoding carboxymethyl cellulase (CSCMCase) was isolated and improved the enzyme yield by high cell-density fermentation of Pichia pastoris. The CSCMCase cDNA contains 1023 nucleotides and encodes a 341-amino acid. It was successfully expressed under the control of alcohol oxidase I promoter using methanol induction of P. pastoris fermentation in a 2L ABLE bioreactor. The production of the recombinant carboxymethyl cellulases was higher than that from Cryptococcus sp. S-2 of 657-fold (2.75 and 4.2 × 10⁻³ mg protein L⁻¹, respectively) indicating that the leader sequence of CSCMCase has been recognized and processed as efficiently by P. pastoris. Furthermore, the recombinant enzyme was purified in two-step of ultrafiltration and hydrophobic interaction chromatography which would be much more convenient for large-scale purification for successful industrial application.     

Purification and characterization of a novel halostable cellulase from Salinivibrio sp. strain NTU-05

A halostable cellulase with a molecular mass of 29 kDa was purified from culture supernatants of the halophilic bacterium Salinivibrio sp. NTU-05 by way of the Fast Protein Liquid Chromatography method and the biochemical properties of the halostable cellulase was studied. The enzyme was active over a range of 0–25% sodium chloride examined in culture broth. The optimum cellulase activity was observed at 5% sodium chloride. Results from the salinity stability test indicated 24% of enzyme activity was retained at 25% sodium chloride for 4 h. The enzyme was also shown to be slightly thermostable with 40% residual activity under 60 °C for 4 h. The enzyme has a K_m of 3.03 mg/ml and a V_max of 142.86 mol/min/mg when tested using carboxymethyl-cellulose (CMC). The enzyme activity increased in the presence of K⁺, Mg²⁺, Na⁺ ions and decreased when Hg²⁺ ions were present. The deduced internal amino acid sequence of the Salinivibrio sp. NTU-05 cellulase showed similarity to the sequence of the glycoside hydrolase family protein. These are some of the novel characteristics that make this enzyme have potential applications in cellulose biodegradation.     

Studies on Cellulose Hydrolysis by Acetivibrio cellulolyticus

Acetivibrio cellulolyticus extracellular cellulase extensively hydrolyzed crystalline celluloses such as Avicel (FMC Corp., Food and Pharmaceutical Products Div., Philadelphia, Pa.) but only if it was desalted and supplemented with Ca²⁺. The Ca²⁺ effect was one of increased enzyme stability in the presence of the ion. Although preincubation of the cellulase complex at 40°C for 5 h without added Ca²⁺ had a negligible effect on endoglucanase activity or on the subseqent hydrolysis of amorphous cellulose, the capacity of the enzyme to hydrolyze crystalline cellulose was almost completely lost. Adsorption studies showed that 90% of the Avicel-solubilizing component of the total enzyme preparation bound to 2% Avicel at 40°C. Under these conditions, only 15% of the endoglucanase and 25% of the protein present in the enzyme preparation adsorbed to the substrate. The protein profile of the bound enzyme, as analyzed by sodium dodecyl sulfate-polyacrylamide gel electrophoresis, was complex and distinctly different from the profile observed for total cellulase preparations. The specific activity of A. cellulolyticus cellulase with respect to Avicel hydrolysis was compared with that of commercially available Trichoderma reesei cellulase.     

The effect of temperature on growth and cellulase (β-1,4-endoglucanase) production in the compost fungusChaetomium thermophile var.dissitum

Chaetomium thermophile var.dissitum, isolated from an experimental urban refuse compost, had the following growth characteristics: Minimum temperature, 27±1°C; optimum, 45–50°C; maximum, 57±1°C; pH optimum 5.5–6.0.A number of carbohydrates could be used for growth, but cellulase formation measured with carboxymethylcellulose as substrate was initiated only on cellulose or xylan. With cellulose as the carbon source, cellulase accumulation in the culture filtrate followed closely that of growth, when the temperature was varied. pH optimum for the cellulase system was 5.0.The optimum temperature for cellulase activity with carboxymethylcellulose as substrate varied between 77°C with 1/2 h incubation time and 58°C with 10 h incubation time.With cotton as substrate, the optimum temperature was 58°C regardless of incubation time. Carboxymethylcellulose had a higher stabilizing effect on the enzyme than cotton. The temperature stability of the cellulase was highest at pH 6.0.     

(Na + K)-ATPase activity of crude homogenates of rat skeletal muscle as estimated from their K-dependent 3-O-methylfluorescein phosphatase activity

A highly sensitive fluorimetric assay using 3-O-methylfluorescein phosphate as substrate was used in the determination of K⁺-dependent phosphatase activity in preparations of rat skeletal muscle. The gastrocnemius muscle was chosen because of mixed fibre composition. Crude, detergent treated homogenate was used so as to avoid loss of activity during purification. K⁺-dependent phosphatase activities in the range 0.19–0.37 μmol · (g wet weight)⁻¹ · min⁻¹ were obtained, the value decreasing with age and K⁺-deficiency. Complete inhibition of the K⁺-dependent phosphatase was obtained with 10⁻³ M ouabain. Using a KSCN-extracted muscle enzyme the intimate relation between K⁺-dependent phosphatase activity and (Na⁺ + K⁺)-activated ATP hydrolysis could be demonstrated. A molecular activity of 620 min⁻¹ was estimated from simultaneous determination of K⁺-dependent phosphatase activity and [³H]ouabain binding capacity using the partially purified enzyme preparation. The corresponding enzyme concentration in the crude homogenates was calculated and corresponded well with the number of [³H]ouabain binding sites measured in intact muscles or biopsies hereof.     

Enzymatic production of N-acetyl- -glucosamine from chitin. Degradation study of N-acetylchitooligosaccharide and the effect of mixing of crude enzymes

N-Acetyl- -glucosamine (GlcNAc) was produced from chitin by use of crude enzyme preparations. The efficient production of GlcNAc by cellulases derived from Trichoderma viride (T) and Acremonium cellulolyticus (A) was observed by HPLC analysis compared to lipase, hemicellulase, and pectinase. β-Chitin showed higher degradability than α-chitin when using cellulase T. The optimum pH of cellulase T was 4.0 on the hydrolysis of β-chitin. The yield of GlcNAc was enhanced by mixing of cellulase T and A.     

Catalytic properties of the immobilized Talaromyces thermophilus β-xylosidase and its use for xylose and xylooligosaccharides production

The present study explores the efficiency of Talaromyces thermophilus β-xylosidase, in the production of xylose and xylooligosaccharides. The β-xylosidase was immobilized by different methods namely ionic binding, entrapment and covalent coupling and using various carriers. Chitosan, pre-treated with glutaraldehyde, was selected as the best support material for β-xylosidase immobilization; it gave the highest immobilization and activity yields (94%, 87%, respectively) of initial activity, and also provided the highest stability, retaining 94% of its initial activity even after being recycled 25 times. Shifts in the optimal temperature and pH were observed for the immobilized β-xylosidase when compared to the free enzyme. The maximal activity obtained for the immobilized enzyme was achieved at pH 8.0 and 53 °C, whereas that for the free enzyme was obtained at pH 7.0 and 50 °C. The immobilized enzyme was more thermostable than the free β-xylosidase. We observed an increase of the K_m values of the free enzyme from 2.37 to 3.42 mM at the immobilized state. Native and immobilized β-xylosidase were found to be stimulated by Ca²⁺, Mn²⁺ and Co²⁺ and to be inhibited by Zn²⁺, Cu²⁺, Hg²⁺, Fe²⁺, EDTA and SDS. Immobilized enzyme was found to catalyze the reverse hydrolysis reaction, forming xylooligosaccharides in the presence of a high concentration of xylose. In order to examine the synergistic action of xylanase and β-xylosidase of T. thermophilus, these two enzymes were co-immobilized on chitosan. A continuous hydrolysis of 3% Oat spelt xylan at 50 °C was performed and better hydrolysis yields and higher amount of xylose was obtained.     

Purification and characterization of a thermostable intracellular β-xylosidase from the thermophilic fungus Sporotrichum thermophile

An intracellular β-xylosidase from the thermophilic fungus Sporotricum thermophile strain ATCC 34628 was purified to homogeneity by Q-Sepharose and Mono-Q column chromatographies. The protein properties correspond to molecular mass and pI values of 45 kDa and 4.2, respectively. The enzyme is optimally active at pH 7.0 and 50 °C. The purified β-xylosidase is fully stable at pH 6.0–8.0 and temperatures up to 50 °C and retained over 58% of its activity after 1 h at 60 °C. The enzyme hydrolyzes β-1,4-linked xylo-oligosaccharides with chain lengths from 2 to 6, releasing xylose from the non-reducing end, but is inactive against xylan substrates. The apparent K_m and V_max values from p-nitrophenyl β-d-xylopyranoside are 1.1 mM and 114 μmol p-nitrophenol min⁻¹ mg⁻¹, respectively. Alcohols inactivate the enzyme, ethanol at 10% (v/v) yields a 30% decrease of its activity. The enzyme is irreversibly inhibited by 2,3-epoxypropyl β-d-xylobioside while alkyl epoxides derived from d-xylose were not inhibitors of the enzyme. The enzyme catalyses the condensation reaction using high donor concentration, up to 60% (w/v) xylose.     

Some kinetic properties of the β- -glucosidase (cellobiase) in a commercial cellulase product from Penicillium funiculosum and its relevance in the hydrolysis of cellulose

Some kinetic parameters of the β- -glucosidase (cellobiase, β- -glucoside glucohydrolase, EC 3.2.1.21) component of Sturge Enzymes CP cellulase [see 1,4-(1,3;1,4)-β- -glucan 4-glucanohydrolase, EC 3.2.1.4] from Penicillium funiculosum have been determined. The Michaelis constants (K_m) for 4-nitrophenyl β- -glucopyranoside (4NPG) and cellobiose are 0.4 and 2.1 mM, respectively, at pH 4.0 and 50°C. -Glucose is shown to be a competitive inhibitor with inhibitor constants (K_i) of 1.7 mM when 4NPG is the substrate and 1 mM when cellobiose is the substrate. Cellobiose, at high concentrations, exhibits a substrate inhibition effect on the enzyme. -Glucono-1,5-lactone is shown to be a potent inhibitor (K_i = 8 μM; 4NPG as substrate) while -fructose exhibits little inhibition. Cellulose hydrolysis progress curves using Avicel or Solka Floc as substrates and a range of commercial cellulase preparations show that CP cellulase gives the best performance, which can be attributed to the activity of the β- -glucosidase in this preparation in maintaining the cellobiose at low concentrations during cellulose hydrolysis.     

Performance of Aspergillus niger B 03 β-xylosidase immobilized on polyamide membrane support

The dynamics of β-xylosidase biosynthesis from Aspergillus niger B 03 was investigated in laboratory bioreactor. Maximum xylosidase activity 5.5 U/ml was achieved after 80 h fermentation at medium pH 4.0. The isolated β-xylosidase was immobilized on polyamide membrane support and the basic characteristics of the immobilized enzyme were determined. Maximum immobilization and activity yield obtained was 30.0 and 6.8%, respectively. A shift in temperature optimum and pH optimum was observed for immobilized β-xylosidase compared to the free enzyme. Immobilized enzyme exhibited maximum activity at 45 °C and pH 4.5 while its free counterpart at 70 °C and pH 3.5, respectively. Thermal stability at 40 and 50 °C and storage stability of immobilized β-xylosidase were investigated at pH 5.0. Kinetic parameters K_m, V_max and K_i were determined for both enzyme forms. Free and immobilized β-xylosidase were tested for xylose production from birchwood xylan. The substrate was preliminarily depolymerized with xylanase to xylooligosaccharides and the amount of xylose obtained after their hydrolysis with free and immobilized β-xylosidase was determined by HPLC analysis. Continuous enzyme hydrolysis of birchwood xylan was performed with xylanase and free or immobilized β-xylosidase. The maximum extent of hydrolysis was 25 and 30% with free and immobilized enzyme, respectively. Immobilized preparation was also examined for reusability in 20 consecutive cycles at 40 °C.     

Screening strains for directed biosynthesis of β-d-mono-glucuronide-glycyrrhizin and kinetics of enzyme production

One fungus, tentatively named Penicillium sp. Li-3, was screened to biosynthesize β-d-mono-glucuronide-glycyrrhizin (GAMG), directly. Using glycyrrhizin as elicitor and the sole carbon source, this strain was capable of expressing β-d-glucuronidase, one intracellular enzyme with high substrate specificity. And glycyrrhizin was hydrolyzed directly into GAMG by enzyme from Penicillium sp. Li-3 with high production. It was found that the mol conversion ratio of this reaction was up to 88.45%. Research about kinetics of β-d-glucuronidase production showed that the cell growth and enzyme production of this strain was partial coupled. During the expressing of target enzyme, carbon catabolite repression existed, so only glycyrrhizin was the best carbon source as well as the elicitor. It was found that the surfactant (Tween 80 0.12%) could improve the ability of enzyme production markedly. Under the condition of initial pH 4.8 of the medium and 32 °C of the culture temperature, the maximum enzyme activity of 181.53 U ml⁻¹ was obtained.     

Purification and properties of a novel raw starch degrading-cyclodextrin glycosyltransferase from Klebsiella pneumoniae AS- 22

A novel raw starch degrading α-cyclodextrin glycosyltransferase (CGTase; E.C. 2.4.1.19), produced by Klebsiella pneumoniae AS-22, was purified to homogeneity by ultrafiltration, affinity and gel filtration chromatography. The specific cyclization activity of the pure enzyme preparation was 523 U/mg of protein. No hydrolysis activity was detected when soluble starch was used as the substrate. The molecular weight of the pure protein was estimated to be 75 kDa with SDS-PAGE and gel filtration. The isoelectric point of the pure enzyme was 7.3. The enzyme was most active in the pH range 5.5–9.0 whereas it was most stable in the pH range 6–9. The CGTase was most active in the temperature range 35–50°C. This CGTase is inherently temperature labile and rapidly loses activity above 30°C. However, presence of soluble starch and calcium chloride improved the temperature stability of the enzyme up to 40°C. In presence of 30% (v/v) glycerol, this enzyme was almost 100% stable at 30°C for a month. The K_m and k_cat values for the pure enzyme were 1.35 mg ml⁻¹ and 249 μM mg⁻¹ min⁻¹, respectively, with soluble starch as the substrate. The enzyme predominantly produced α-cyclodextrin without addition of any complexing agents. The conditions employed for maximum α-cyclodextrin production were 100 g l⁻¹ gelatinized soluble starch or 125 g l⁻¹ raw wheat starch at an enzyme concentration of 10 U g⁻¹ of starch. The α:β:γ-cyclodextrins were produced in the ratios of 81:12:7 and 89:9:2 from gelatinized soluble starch and raw wheat starch, respectively.     

Purification and characterization of β-agarase from agar-liquefying soil bacterium, Acinetobacter sp., AG LSL-1

The extracellular β-agarase LSL-1 produced by an agar-liquefying, soil bacterium Acinetobacter sp., AG LSL-1 was purified to homogeneity by combination of ion-exchange and size exclusion chromatography with final yield of 44%. The enzyme has a specific activity of 397 U mg⁻¹ protein and with a molecular mass of 100 kDa. The agarase was active in the pH range of 5.0–9.0, optimally at pH 6.0 and temperature between 25 °C and 55 °C and optimal at 40 °C. The enzyme retained 63% of native activity at 50 °C suggesting it is a thermostable. The activity of the agarase was completely inhibited by metal ions, Hg²⁺, Ag⁺ and Cu²⁺, whereas 25–40% of native activity was retained in the presence of Zn²⁺, Sn²⁺ and SDS. Neoagarobiose was the final product of hydrolysis of both agarose and neoagarohexaose by the purified agarase LSL-1. Based on the molecular mass and final products of agarose hydrolysis, the β-agarase LSL-1 may be further grouped under group III β-agarases and may be a member of GH-50 family. This is the first report on the purification and biochemical characterization of β-agarase from an agar-liquefying Acinetobacter species.     

Long-term exposure of the freshwater shrimp Macrobrachium olfersii to elevated salinity: Effects on gill (Na,K)-ATPase α-subunit expression and K-phosphatase activity

The kinetic properties of a microsomal gill (Na⁺,K⁺)-ATPase from the freshwater shrimp, Macrobrachium olfersii, acclimated to 21‰ salinity for 10 days were investigated using the substrate p-nitrophenylphosphate. The enzyme hydrolyzed this substrate obeying cooperative kinetics at a rate of 123.6 ± 4.9 U mg^− 1 and K_0.5 = 1.31 ± 0.05 mmol L^− 1. Stimulation of K⁺-phosphatase activity by magnesium (V_max = 125.3 ± 7.5 U mg^− 1; K_0.5 = 2.09 ± 0.06 mmol L^− 1), potassium (V_max = 134.2 ± 6.7 U mg^− 1; K_0.5 = 1.33 ± 0.06 mmol L^− 1) and ammonium ions (V_max = 130.1 ± 5.9 U mg^− 1; K_0.5 = 11.4 ± 0.5 mmol L^− 1) was also cooperative. While orthovanadate abolished p-nitrophenylphosphatase activity, ouabain inhibition reached 80% (K_I = 304.9 ± 18.3 μmol L^− 1). The kinetic parameters estimated differ significantly from those for freshwater-acclimated shrimps, suggesting expression of different isoenzymes during salinity adaptation. Despite the ≈2-fold reduction in K⁺-phosphatase specific activity, Western blotting analysis revealed similar α-subunit expression in gill tissue from shrimps acclimated to 21‰ salinity or fresh water, although expression of phosphate-hydrolyzing enzymes other than (Na⁺,K⁺)-ATPase was stimulated by high salinity acclimation.     

Enzymatic hydrolysis and simultaneous saccharification and fermentation of steam-pretreated spruce using crude Trichoderma reesei and Trichoderma atroviride enzymes

The aim of this study was to compare the performance of the enzymes produced by Trichoderma reesei Rut C30 and the good extracellular β-glucosidase-producing mutant Trichoderma atroviride TUB F-1663 to that of commercial preparations in the enzymatic hydrolysis and the simultaneous saccharification and fermentation (SSF) of steam-pretreated spruce (SPS).The concentrated TUB F-1663 enzyme was found to be the most efficient in the hydrolysis of washed SPS at 50 g/L water-insoluble solids (WIS) in terms of the glucose produced (18.5 g/L), even in comparison with commercial cellulases (14.1–16.7 g/L). The enzyme preparations were studied at low enzyme loadings (5 FPU/g WIS) in SSF to produce ethanol from SPS. The enzyme supernatant and whole fermentation broth of T. atroviride as well as the whole broth of T. reesei proved to be as efficient in SSF as the commercial cellulase mixtures (ethanol yields of 61–76% of the theoretical were achieved), while low ethanol yields (<40%) were obtained with the β-glucosidase-deficient T. reesei supernatant.Therefore, it seems, that instead of using commercial cellulases, the TUB F-1663 enzymes and the whole broth of Rut C30 may be produced on-site, using a process stream as carbon source, and employed directly in the biomass-to-bioethanol process.     

Novel Penicillium cellulases for total hydrolysis of lignocellulosics

The (hemi)cellulolytic systems of two novel lignocellulolytic Penicillium strains (Penicillium pulvillorum TUB F-2220 and P. cf. simplicissimum TUB F-2378) have been studied. The cultures of the Penicillium strains were characterized by high cellulase and β-glucosidase as well moderate xylanase activities compared to the Trichoderma reesei reference strains QM 6a and RUTC30 (volumetric or per secreted protein, respectively). Comparison of the novel Penicillium and T. reesei secreted enzyme mixtures in the hydrolysis of (ligno)cellulose substrates showed that the F-2220 enzyme mixture gave higher yields in the hydrolysis of crystalline cellulose (Avicel) and similar yields in hydrolysis of pre-treated spruce and wheat straw than enzyme mixture secreted by the T. reesei reference strain. The sensitivity of the Penicillium cellulase complexes to softwood (spruce) and grass (wheat straw) lignins was lignin and temperature dependent: inhibition of cellulose hydrolysis in the presence of wheat straw lignin was minor at 35 °C while at 45 °C by spruce lignin a clear inhibition was observed. The two main proteins in the F-2220 (hemi)cellulase complex were partially purified and identified by peptide sequence similarity as glycosyl hydrolases (cellobiohydrolases) of families 7 and 6. Adsorption of the GH7 enzyme PpCBH1 on cellulose and lignins was studied showing that the lignin adsorption of the enzyme is temperature and pH dependent. The ppcbh1 coding sequence was obtained using PCR cloning and the translated amino acid sequence of PpCBH1 showed up to 82% amino acid sequence identity to known Penicillium cellobiohydrolases.     

Direct evidence for an ADP-sensitive phosphointermediate of (K + H-ATPase

Direct evidence for the occurrence of an ADP-sensitive phosphoenzyme of (K⁺ + H⁺)-ATPase, the proton-pumping system of the gastric parietal cell is presented. The enzyme is phosphorylated with 5 μM [γ-³²P]ATP in 50 mM imidazole-HCl (pH 7.0) and in the presence of 7–15 μM Mg²⁺. Addition of 5 mM ADP to this preparation greatly accelerates its hydrolysis. We have been able to establish this by stopping the phosphorylation with radioactive ATP, by adding 1 mM non-radioactive ATP, which leads to a slow monoexponential process of dephosphorylation of ³²P-labeled enzyme. The relative proportion of the ADP-sensitive phosphoenzyme is 22% of the total phosphoenzyme. Values for the rate constants of breakdown and interconversion of the two phosphoenzyme forms have been determined.     

Continuous monitoring of cellulase action on microcrystalline cellulose

Summary Cellobiose oxidase from Phanerochaete chrysosporium was used for continuous monitoring of cellulase action on microcrystalline cellulose (Avicel). Two protocols are described, the parameter monitored being either the decline in electrode potential as ferricyanide is reduced or consumption of dioxygen. Most experiments used a commercial cellulase preparation from Trichoderma reesei and ferricyanide as acceptor. Within 1 min of an addition of cellulase, ferricyanide reduction reached a steady rate. This was converted into a rate of production of substrate for celobiose oxidase, in mol·min^–1. Experiments were conducted either with a constant concentration of cellulase and increasing Avicel, or with constant Avicel and increasing cellulase. Kinetic analysis of the experiments with constant cellulase indicated a K _mof 4.8 ± 1.0 (g cellulose)·1^–1, which was close to the value predicted from binding studies. The specific activity of the cellulase was measured as 375±25 mol·(g cellulase)^–1·min^–1 in experiments with a high cellulose concentration, but was less than half this value when the cellulose was saturated with cellulase. The maximal rate of cellulose degradation was 9.6±1.3 mol·(g cellulose)^–1·min^–1.