Influence of areal density on β-carotene production by Dunaliella salina

High irradiance is probably the most important factor responsible for the massive accumulation of β-carotene by the halotolerant green alga Dunaliella salina. Operating outdoor cultures at optimal areal densities should result in maximal productivity. It is known that the optimal areal density is not fixed for all algae, where it could vary depending on the type of algae cultured, pond construction, turbulence and prevailing environmental conditions. At biomass concentrations below the optimum, more light per cell is available than that which could be absorbed by the biomass. These high light conditions should favour carotenogenesis and could result in higher β-carotene production rates. The results obtained clearly showed that over and above light and nutrient stress, an extremely important aspect is the residence time of the cells in the ponds. Longer residence times resulted in the development of larger cells, containing larger quantities of β-carotene. Productivity of biomass and β-carotene were about 70% higher at areal densities of 35–45 g m^-2, compared to areal densities of 15–25 g m^-2.     

Spray-drying of Dunaliella salina to produce a β-carotene rich powder

Powders of Dunaliella salina biomass were obtained by spray drying a cell concentrate under different drying regimes. A three-factor, two-level experimental design was employed to investigate the influence of inlet temperature, outlet temperature and feed solids on β-carotene recovery. The effect of microencapsulation in a polymer matrix of maltodextrin and gum arabic was also studied. All powders were stored under specific conditions to assess the stability of the native β-carotene. There was a trend indicating that lower outlet temperature yielded higher carotenoid recoveries, β-carotene recovery varying between 57% and 91%. Microencapsulated biomass yielded 100% recoveries. All non-microencapsulated powders were unstable in terms of β-carotene content in the presence of natural light and oxygen showing 90% degradation over a 7-day period. The incorporation of a microencapsulating agent had a significant increase in the storage stability. Results indicated a first-order degradation of the β-carotene in microencapsulated powders with kinetic constants of 0.06 day⁻¹ and 0.10 day⁻¹. HPLC analysis showed no effect of drying processes on isomer composition (9-cis-β-carotene and all-trans-β-carotene ratio). This behaviour was also observed during storage of the microencapsulated powders. Received 16 October 1996/ Accepted in revised form 13 November 1997     

Effect of pH, light intensity, salt and nitrogen concentrations on growth and β-carotene accumulation by a new isolate of Dunaliella sp

Summary In the present study Dunaliella sp. that could grow in the Johnson medium was isolated from hypersaline Lake Tuz and its β-carotene production was studied in a batch system, in order to determine the optimal conditions required for the highest β-carotene accumulation. In the experiments with light intensity, the cell numbers and β-carotene content were maximum at pH 9, with 20% of NaCl concentration and 48 kerg cm⁻² s⁻¹ light intensity. At this light intensity, the β-carotene content of Dunaliella sp. ranged between 0.177 and 1.095 mg/ml for the culture broth and 0.119 to 0.261 ng/cell on a per cell basis under the nitrogen limitation. At the end of the experiments, the maximum β-carotene accumulation and the cell number were obtained at pH 7, 5 mM NaNO₃ and 20% NaCl concentrations as 0.261 ng/cell, 4.2×10⁶ cell/ml, respectively.     

Photosynthetic characteristics of Dunaliella salina (Chlorophyceae,Dunaliellales) in relation to β-carotene content

Photosynthetic characteristics of Dunaliella salina with high (red form) and low β-carotene (green form) concentrations were studied. D. salina growing in brine saltworks exhibited a high level of β-carotene (15 pg cell⁻¹). The rate of oxygen evolution as a function of irradiance was higher in the red than in the green form (on chlorophyll basis). Photosynthetic inhibition of the green form was observed above 500 μmol m⁻² s⁻¹. The red form appeared more resistant to high irradiance and no inhibition in O₂ evolution was observed up 2000 μmol m⁻² s⁻¹. However, when these results are expressed on a cell number basis the rate of oxygen evolution was significantly higher in the green form. Carbonic anhydrase (CA) activity (total, soluble, membrane bound) was found in red and green forms. CA was higher in the red form on a chlorophyll basis, but lower if expressed on a protein basis. The light dependent rate of oxygen evolution and photoinhibition depends on the concentration of β-carotene in D. salina cells.     

Adsorption of glycinin and β-conglycinin on silica and cellulose: surface interactions as a function of denaturation, pH, and electrolytes

Soybean proteins have found uses in different nonfood applications due to their interesting properties. We report on the kinetics and extent of adsorption on silica and cellulose surfaces of glycinin and β-conglycinin, the main proteins present in soy. Quartz crystal microgravimetry (QCM) experiments indicate that soy protein adsorption is strongly affected by changes in the physicochemical environment. The affinity of glycinin and the mass adsorbed on silica and cellulose increases (by ca. 13 and 89%, respectively) with solution ionic strength (as it increases from 0 to 100 mM NaCl) due to screening of electrostatic interactions. In contrast, β-conglycinin adsorbs on the same substrates to a lower extent and the addition of electrolyte reduces adsorption (by 25 and 57%, respectively). The addition of 10 mM 2-mercaptoethanol, a denaturing agent, reduces the adsorption of both proteins with a significant effect for glycinin. This observation is explained by the cleavage of disulfide bonds which allows unfolding of the molecules and promotes dissociation into subunits that favors more compact adsorbed layer structures. In addition, adsorption of glycinin onto cellulose decreases with lowering the pH from neutral to pH 3 due to dissociation of the macromolecules, resulting in flatter adsorbed layers. The respective adsorption isotherms fit a Langmuir model and QCM shifts in energy dissipation and frequency reveal multiple-step kinetic processes indicative of changes in adlayer structure.     

Effects of High K+ and Alkaline pH on Ultrastructure of Dunaliella salina Chloroplasts

It was reported that the growth of Dunaliella salina Teod. cultured in medium containing 1 mol/L NaC1 was almost completely inhibited by the addition of 100 mmol/L KC1. The high K+ (100 mmol/L KC1) treatment also significantly inhibited the photosynthetic rate of D. salina and decreased chlorophyll contents in algae. This study focuses on possible effects of high K+ or alkaline pH on the ultrastructural change of chloroplasts in D. salina. After D. salina was cultured in a medium containing 100 n,anol/L KC1 or in a medium with alkaline pH for 8 to 10 days, dramatic ultrastructural changes occurred in the chloroplasts including thylakoid swelling, volume increase of chloroplast, and significant accumulation of starch grains in chloroplasts. The results are consistent with our previous report indicating that the ultrastmctuml changes in chloroplast under high K + or alkaline pH may lead to an inhibitory effects on photosynthesis and overall growth of D. salina.     

Production of β-carotene by a mutant of Rhodotorula glutinis

Wild strains of Rhodotorula glutinis and R. rubra were investigated concerning their carotenoid production, proportion of beta-carotene and cell mass yield. R. glutinis NCIM 3353 produced 2.2 mg carotenoid/l in 72 h; and the amount of beta-carotene was 14% (w/w) of the total carotenoid content (17 microg/g cell dry weight). It was subjected to mutagenesis using UV radiation for strain improvement. Out of 2,051 isolates screened, the yellow coloured mutant 32 produced 120-fold more beta-carotene (2,048 microg/g cell dry weight) than the parent culture in 36 h, which was 82% (w/w) of the total carotenoid content. Mutant 32 was grown on different carbon and nitrogen sources. The best yield of beta-carotene (33+/-3 mg/l) was obtained when glucose and yeast extract were supplied as carbon and nitrogen sources, respectively. Divalent cation salts further increased the total carotenoid content (66+/-2 mg/l) with beta-carotene as the major component (55+/-2%, w/w).     

Pilot culture of three strains of Dunaliella salina for β-carotene production in open ponds in the central region of Iran

Summary Three strains of Dunaliella salina (I, G and A) were cultivated under the climatic conditions of Iran, in open ponds to compare the β-carotene production and the specific rate of growth. The experiments were accomplished in two separate stages. In the first stage, the cells were grown in ponds on nutrient-rich medium containing 2 M NaCl to obtain the necessary biomass. In the second stage, cells were stressed on nutrient-poor medium containing 2.5 M NaCl for β-carotene induction. The results showed that the specific growth rate of strain I was the highest during the first stage, whereas during the second stage, the growth rates of three strains were approximately the same. The overall results indicated that strain G had the highest potential for β-carotene accumulation of the strains tested and hence it was concluded that this strain is more suitable for outdoor cultivation under the climatic conditions of Iran than the other two.     

Transcriptome profiling of β-carotene biosynthesis genes and β-carotene accumulation in leaf blades and petioles of celery cv. Jinnanshiqin

β-carotene is a kind of carotenoids and has many biological functions.Proper amount of β-carotene is beneficial to promote the synthesis of vitamin A [1].The unsaturated double bonds in β-carotene structure make it have strong antioxidant capacity.     

Differential scanning calorimetry and fluorescence study of lactoperoxidase as a function of guanidinium–HCl,urea, and pH

The stability of bovine lactoperoxidase to denaturation by guanidinium–HCl, urea, or high temperature was examined by differential scanning calorimetry (DSC) and tryptophan fluorescence. The calorimetric scans were observed to be dependent on the heating scan rate, indicating that lactoperoxidase stability at temperatures near T_m is controlled by kinetics. The values for the thermal transition, T_m, at slow heating scan rate were 66.8, 61.1, and 47.2 °C in the presence of 0.5, 1, and 2 M guanidinium–HCl, respectively. The extrapolated value for T_m in the absence of guanidinium–HCl is 73.7 °C, compared with 70.2 °C obtained by experiment; a lower experimental value without a denaturant is consistent with distortion of the thermal profile due to aggregation or other irreversible phenomenon. Values for the heat capacity, C_p, at T_m and E_a for the thermal transition decrease under conditions where T_m is lowered. At a given concentration, urea is less effective than guanidinium–HCl in reducing T_m, but urea reduces C_p relatively more. Both fluorescence and DSC indicate that thermally denatured protein is not random coil. A change in fluorescence around 35 °C, which was previously reported for EPR and CD measurements (Boscolo et al. Biochim. Biophys. Acta 1774 (2007) 1164–1172), is not seen by calorimetry, suggesting that a local and not a global change in protein conformation produces this fluorescence change.     

Effect of β-carotene,lutein and violaxanthin on structural properties of dipalmitoyl-phosphatidylcholine liposomes as studied by ultrasound absorption technique

The effect of three carotenoid pigments, -carotene, lutein, and violaxanthin, on structural properties of dipalmitoylphosphatidylcholine liposomes was studied by means of ultrasound absorption technique. It was found that the polar carotenoid-lutein enhances drastically ultrasound absorption related to energy consumption during phase transition of a lipid component. The effect of apolar -carotene was not so much evident. No differences between the sample and control were found in the case of violaxanthin presence in liposomes. The effect of a polar carotenoid is discussed in terms of the reinforcement of the lipid matrix. Physiological aspects of carotenoid action in membranes are also briefly discussed.     

Genetic mapping of a major codominant QTL associated with β-carotene accumulation in watermelon

The common flesh color of commercially grown watermelon is red due to the accumulation of lycopene. However, natural variation in carotenoid composition that exists among heirloom and exotic accessions results in a wide spectrum of flesh colors. We previously identified a unique orange flesh watermelon accession (NY0016) that accumulates mainly β-carotene and no lycopene. We hypothesized this unique accession could serve as a viable source for increasing provitamin A content in watermelon. Here we characterize the mode of inheritance and genetic architecture of this trait. Analysis of testcrosses of NY0016 with yellow and red fruited lines indicated a codominant mode of action as F₁ fruits exhibited a combination of carotenoid profiles from both parents. We combined visual color phenotyping with genotyping-by-sequencing of an F_2:3 population from a cross of NY0016 by a yellow fruited line, to map a major locus on chromosome 1, associated with β-carotene accumulation in watermelon fruit. The QTL interval is approximately 20 cM on the genetic map and 2.4 Mb on the watermelon genome. Trait-linked marker was developed and used for validation of the QTL effect in segregating populations across different genetic backgrounds. This study is a step toward identification of a major gene involved in carotenoid biosynthesis and accumulation in watermelon. The codominant inheritance of β-carotene provides opportunities to develop, through marker-assisted breeding, β-carotene-enriched red watermelon hybrids.     

The rate of ATP synthesis as a function of ΔpH in normal and dithiothreitol-modified chloroplasts

The rate of ATP synthesis catalyzed by normal and by dithiothreitol-modified ATPases is investigated as a function of ΔpH in spinach chloroplasts at constant pH_out. The transmembrane ΔpH was generated by an acid-base transition and the reaction time was limited to 150 ms by using a rapidly mixing quenched-flow apparatus. The result was that the functional dependence of the rate on ΔpH is shifted to lower ΔpH values and that the shape of this curve is altered after dithiothreitol modification. The maximal rate (400 ATP / CF₁ per s) is the same under both conditions.     

Absolute configuration of β,γ-carotene and biosynthetic implications

Racemic γ-ionone, partly resolved via its menthydrazone, was used for total synthesis of β,γ-carotene enriched in the 6′R and 6′S enantiomers. By CD correlation with natural β,γ-carotene isolated from Caloscypha fulgens 6′S-chirality is demonstrated for the natural carotene. Biosynthetic implications regarding the cyclization reaction are discussed.