Use of trypsin for rapid and efficient purification of murine sarcoma and leukemia virus.

A method is described for purification of MSV-MuLV from culture supernatant of chronically infected 78A,1 rat embryo cell line. This method involves direct polyethylene glycol-NaCl precipitation of the low speed supernatant of culture fluid followed by digestion of the pellet with trypsin. This procedure efficiently disrupts large aggregates which normally entrap most of the virus. Highly purified virus can be obtained in very good yield by a combination of sedimentation velocity and isopycnic centrifugation : yields up to 100 A280 units (17 mg of protein) of purified virus per liter of culture fluid can be observed. This procedure appears well suited for large scale isolation of virion associated enzymatic activities.     

Purification of intracellular phospholipase A2 from rat spleen supernatant by reverse-phase high-performance liquid chromatography

Intracellular phospholipase A₂ was purified to homogenity from rat spleen supernatant by reverse-phase high-performance liquid chromatography with a trifluoroacetic acid-acetonitrile solvent system. The method simplified the purification procedure, which includes three consecutive chromatographic steps. The recovery of the enzyme activity was greater than 70% with an about 23,000-fold purification. The solvent system did not affect the catalytic properties of the enzyme. Phospholipases A₂ from rat spleen, human pancreatic juice, and porcine pancreas were eluted in that order from a column of octadecasilyl silica gel in a similar concentration range of acetonitrile. This result suggests that the phospholipases A₂ examined have similar hydrophobicities. This method may be applicable to the purification of phospholipases A₂ from other sources.     

A rapid and simple method for the purification of rat liver RNase inhibitor

A rapid and simple method for the purification of rat liver alkaline RNase inhibitor from a 105,000 g supernatant is reported. It involves protein precipitations by (NH₄)₂SO₄ and chromatography on carboxymethyl cellulose-RNase column. The purification procedure gives a 1020-fold increase in specific activity with a yield of 32%. This purified inhibitor can be stored for 5 weeks without any loss in activity.     

Improved Method for the Purification of Biologically Active Transcobalamin II

Transcobalamin II (TC II) was purified about 300, 000-fold from Cohn fraction III using a modification of the procedure described by Allen and Majerus (J. Biol. Chem. 247, 7709–7717 (1972)). The simplified method incorporated isoelectric precipitation of the TC II into the purification scheme which permitted the elimination of two colimn chromatographic steps originally reported by the above worke-s. The final preparation had 26.7 jjg of vitamin B, ～ (B₁₂) bound per mg of protein and an A₂₈₀/A₃₆₁ ratio of 2.05, both of which are in good agreement with the reported values. The purified TC II was biologically active with respect to its ability to facilitate penetration of B₁₂ into lleLa cells in tissue culture.     

Isoelectric precipitation and gel chromatography for purification of monoclonal IgM

A preparative scale purification procedure of monoclonal IgM from hybridoma culture supernatant with high protein content is described. The procedure consists of three steps starting with ultrafiltration followed by isoelectric precipitation and gel chromatography. Cells and debris from culture supernatant were removed by microfiltration. The clarified supernatant was concentrated 400-fold in a hollow fibre ultrafiltration apparatus (cut off 100 000 daltons). The concentrate was titrated with dilute histidine/HCl buffer close to the isoelectric point of the IgM. Precipitated proteins were harvested by centrifugation, washed and redissolved. The protein fraction containing the IgM was further purified by gel chromatography on a Sephacryl S300 column. This procedure leads to product recovery of 40% and purity of 99% related to total protein.     

Purification and characterization of extracellular β-galactosidase from the psychrotolerant yeast Guehomyces pullulans 17-1 isolated from sea sediment in Antarctica

A psychrotolerant yeast Guehomyces pullulans 17-1 isolated from sea sediment in Antarctica could produce high level (17.2 U/ml) of both extracellular and cell-bound β-galactosidase. The extracellular β-galactosidase in the supernatant of the cell culture of the psychrotolerant yeast G. pullulans 17-1 was purified to homogeneity with a 2.4-fold increase in specific activity as compared to the supernatant by concentration, gel filtration chromatography (Sephadex G-200) and cation-exchange chromatography (CM-Sepharose Fast Flow cation-exchange). The molecular mass of the purified extracellular β-galactosidase was estimated to be 335 kDa. The optimal temperature and pH of the purified β-galactosidase were 50 °C and 4.0, respectively. K_m and V_max values of the purified β-galactosidase for o-nitrophenyl-β-d-galactopyranoside were 3.3 mM and 9.2 μmol/min. Lactose can be converted into glucose and galactose and a large amount of reducing sugar can be released from milk under catalysis of the purified β-galactosidase. The matrix-assisted laser desorption/ionization time-of-flight/time-of-flight mass spectroscopy identified a peptide ALEEYKK which is the conserved motif of the β-galactosidases from other yeasts. The results show that the enzyme may have potential applications in food industry.     

Efficient Expression and Rapid Purification of Human T-Cell Leukemia Virus Type 1 Protease

Human T-cell leukemia virus type 1 (HTLV-1) is an oncovirus that is clinically associated with adult T-cell leukemia. We report here the construction of a pET19-based expression clone containing HTLV-1 protease fused to a decahistidine-containing leader peptide. The recombinant protein is efficiently expressed in Escherichia coli, and the fusion protein can be easily purified by affinity chromatography. Active mature protease in yields in excess of 3 mg/liter of culture can then be obtained by a novel two-step refolding and autoprocessing procedure. The purified enzyme exhibited K_m and K_cat values of 0.3 mM and 0.143 sec⁻¹ at pH 5.3 and was inhibited by pepstatin A.     

Purification, serological relationships and some characteristics of plum line-pattern virus

Plum line-pattern virus (PLV) was purified by homogenizing inoculated leaves of Nicotiana megalosiphon in 0·02 M phosphate buffer, pH 8·0 (1·5 ml/g leaf), containing 0·02 M 2-mercaptoethanol. The homogenate was centrifuged at low speed and the supernatant liquid was clarified by adjusting the pH to 4·8 with 0·1 M citric acid. The green coagulum was removed by centri-fugation and the extract adjusted to pH 6·5. After concentrating the virus by high-speed centrifugation, remaining host protein was precipitated with the gamma-globulin fraction of antiserum to N. megalosiphon protein. Purification was completed with two cycles of high- and low-speed centrifugation. Purified PLV had an A₂₆₀/A₂₈₀ ratio of c. 1·7 and formed two zones when centrifuged in density gradients at pH 6·0–7·0. The virus was about 30 mμ in diameter in negatively stained preparations. The particles were easily disrupted. PLV was closely serologically related to cultures of plum line-pattern virus from other areas, but no relationship was found to apple mosaic, Prunus necrotic ringspot or prune dwarf viruses, or to a plum line-pattern virus from Denmark.     

A new procedure for fast isolation and purification of plastocyanin from the cyanobacterium Anabaena variabilis

Methods are described for growing the cyanobacterium A. variabilis and for the isolation and purification of plastocyanin from the grown culture. Cell paste which had been stored at –35°C was suspended in 1 mM MES buffer, pH 6.5 and centrifuged. The supernatant was diluted to a conductivity of 0.12 mS, [Fe(CN)₆]^3- added to a concentration of 0.5 mM and the solution loaded on a S Sepharose Fast Flow column. After elution and ultrafiltration, the plastocyanin containing fractions were reloaded on a S Sepharose Fast Flow column for final purification. A typical yield in three days from cells harvested from 3×20 l of medium was 32 mg plastocyanin with a minimum absorbance ratio A₂₇₈/A₅₉₇=1.14. This procedure is faster and the yield higher than for previous procedures.Abbreviations MES 2(N-morpholino)ethanesulfonic acid - PC plastocyanin     

Partial purification and characterization of an initiation protein for germination from Clostridium perfringens spores

An initiation protein which promoted genermination of dithiothreitol-sodium dodcyl suflate-trated spores of clostridium perfringens was purified from 7-h culture supernatant fluid of cell of Cl. perfringenes. A 3100-fold purification was obtained after cellulose-phosphate and Sephadex G-100 chromatography. The isolated product had an apparent molecular weight of 100 000, an isoelectric point of 7.9, was reversibly inhibited by HgCl₂ and lysed isolated cortical fragments from Cl. perfringens spores.     

Size distribution analysis of recombinant adenovirus using disc centrifugation

Recombinant adenovirus is one of the primary vectors for human gene therapy. However, the aggregation of unstable virus has been a recurring problem during the production of purified virus for human therapeutics. To facilitate the development of a robust manufacturing process for recombinant adenovirus vectors, a convenient and reliable size distribution analytical assay is necessary and we demonstrate here that disc centrifuge sedimentation is applicable to this purpose. Using the disc centrifuge system and the line start method, the assay can provide particle size distribution of adenovirus samples within 30 min. The assay can detect virus concentrations down to 0.01% (w/v) or 3 × 10¹¹ particles per ml. The apparent hydrodynamic diameter of recombinant adenovirus was determined to be about 0.063 μm. Furthermore, the disc centrifuge analysis was able to detect adenovirus dimers, trimers, and tetramers, consistent with a rigid sphere approximation for adenovirus, as well as a large aggregate of 0.35 μm. The appearance of viral aggregates is confirmed by increased light scattering based on A₃₂₀/A₂₆₀ ratios. The technique could be useful for monitoring the kinetics of aggregation for adenovirus and other DNA and RNA viruses in the submicron region. Therefore, this novel assay provides a critical tool for purification development of viral vectors for meeting therapeutic and research needs. Received 18 September 1997/ Accepted in revised form 15 May 1998     

Isolation, purification and characterization of levorin produced by Streptomyces levoris 99/23

Levorin produced by Streptomyces levoris 99/23 was isolated, purified and characterized. It was established that 80% of the levorin was localized in the mycelium and only 20% was in the cell-free supernatant. Amorphous yellow levorin with activity of 24 000 IU/mg and 96% purity was obtained. The preparation exhibited three absorption maxima: at λ 362, 382 and 404 nm. The antibiotic contained seven components: A₀, A₁, A₂, A₃, A₄, and two unidentified ones. According to its composition, the preparation corresponded to the levorin used for medicinal purposes. However, the levorin produced by S. levoris 99/23 contained half as much levorin A₂ and a more than 100 times larger quantity of the more active and less toxic component levorin A₃.     

Chromatin fractionation of normal and virus-transformed cells in culture

A simple technique for the obtaining of purified chromatin fractions from mammalian cells in culture is described. The procedure involves the isolation of clean nuclei in 0.30 M sucrose, 1.5 mM MgCl₂, 0.2 mM CaCl₂, 0.01 M Tris HCl pH 7.2, followed by sonication and differential centrifugation to collect specific chromatin fractions. Heterochromatin of SV-40 and Rous sarcoma virus transformed 3T3 cells showed a 6- to 7-fold enrichment in satellite DNA while a 2- to 3-fold enrichment in repetitive DNA was obtained in established and RSV transformed cells of Microtus agrestis. This method will facilitate the search for the site of integration of oncogenic viruses in the chromatin of mammalian cells.     

Production and Purification of Large Amounts of Rous Sarcoma Virus

Procedures are described for production and purification of large amounts of Rous sarcoma virus. The virus was produced by Rous sarcoma virus-transformed chicken embryo fibroblasts in roller culture which produced up to 6 mg of virus per day per liter of supernatant fluid. Various methods of concentrating virus were evaluated; pelleting yielded the best results in terms of recovery of infectious virus. Purification was achieved by means of successive velocity and equilibrium density centrifugation by using sucrose solutions made in low-salt buffer. A rapid method for the optical density measurement of virus concentration was also developed.     

Method for Rapid Purification of Class IIa Bacteriocins and Comparison of Their Activities

A three-step method was developed for the purification of mesentericin Y105 (60% yield) from the culture supernatant of Leuconostoc mesenteroides Y105. The same procedure was successfully applied to the purification of five other anti-Listeria bacteriocins identified by mass spectrometry. Specific activities of the purified bacteriocins were compared.     

Isolation and purification of plastocyanin from spinach stored frozen using hydrophobic interaction and ion-exchange chromatography

A new simple three-day procedure for preparative isolation and purification of plastocyanin from spinach stored in the frozen state is described. This procedure is based on batch adsorption on ion-exchange resin, ammonium sulphate precipitation, and purification on a Phenyl-Sepharose hydrophobic interaction column and a single Q Sepharose High Performance ion-exchange column. Approximately 100 mg of plastocyanin with an absorbance ratio A₂₇₈/A₅₉₇ of 1.10±0.02 in the oxidized state was typically obtained from 12 kg of spinach leaves. The purified spinach plastocyanin is shown to be homogeneous to the resolution of free solution capillary electrophoresis.Abbreviations MES 2(N-morpholino)ethanesulfonic acid - Tris Tris(hydroxymethyl)aminomethane - FSCE free solution capillary electrophoresis     

Simple production of resilin-like protein hydrogels using the Brevibacillus secretory expression system and column-free purification

Resilin, an insect structural protein, has excellent flexibility, photocrosslinking properties, and temperature responsiveness. Recombinant resilin-like proteins (RLPs) can be fabricated into three-dimensional (3D) structures for use as cell culture substrates and highly elastic materials. A simplified, high-yielding production process for RLPs is required for their widespread application. This study proposes a simple production process combining extracellular expression using Brevibacillus choshinensis (B. choshinensis) and rapid column-free purification. Extracellular production was tested using four representative signal peptides; B. choshinensis was found to efficiently secrete Rec1, an RLP derived from Drosophila melanogaster, regardless of the type of signal peptide. However, it was suggested that Rec1 is altered by an increase in the pH of the culture medium associated with prolonged incubation. Production in a jar fermentor with controllable pH yielded 530 mg Rec1 per liter of culture medium, which is superior to productivity using other hosts. The secreted Rec1 was purified from the culture supernatant via (NH₄)₂SO₄ and ethanol precipitations, and the purified Rec1 was applied to ring-shaped 3D hydrogels. These results indicate that the combination of secretory production using B. choshinensis and column-free purification can accelerate the further application of RLPs.     

Conversion of squid pen by using Serratia sp. TKU020 fermentation for the production of enzymes,antioxidants, and N-acetyl chitooligosaccharides

A chitinase (CHT), a chitosanase (CHS) and a protease (PRO) were purified from the culture supernatant of Serratia sp. TKU020 with squid pen as the sole carbon/nitrogen source. The molecular masses of CHT, CHS and PRO determined by SDS-PAGE were approximately 65 kDa, 55 kDa and 55 kDa, respectively. CHT and CHS were inhibited by Mn²⁺, EDTA and PRO was inhibited by Mg²⁺, EDTA. The antioxidant activity of TKU020 culture supernatant was 78% (DPPH scavenging ability). N-Acetylglucosamine (GlcNAc) and N-acetyl chitobiose (GlcNAc)₂ were also produced from the culture supernatant by using TKU020 strain fermentation. The maximum production of GlcNAc and (GlcNAc)₂ was 1.3 mg/mL and 2.7 mg/mL, respectively, after 4 days of fermentation. With this method, we have shown that squid pen wastes can be utilized and it is effective in the production of enzymes, antioxidants, and N-acetyl chitooligosaccharides, facilitating its potential use in industrial applications and functional foods.     

Isolation and characterization of two isoperoxidases from tobacco tissue cultures

Two isoperoxidases (A_f and C_n) from the medium of tobacco tissue suspension culture WR-132 grown in darkness have been purified to apparent homogeneity and partially characterized. C_n and A_f have MWs of ca 30 000 and 54 000, respectively. A_f has ca 5.1% carbohydrate, but none could be detected in C_n. Both isoperoxidases appear to follow simple Michaelis-Menten kinetics with respect to guaiacol as the substrate. The K_ms for guaiacol are 4 and 13.3 mM for Af and C_n, respectively, while both isoperoxidases have a pH optimum at 6.5. C_n, is dissimilar to other isoperoxidases from tobacco tissue cultures, but A_f is very similar to isoperoxidase A₃ from W-38 tobacco tissue culture.     

A Novel Metalloproteinase,Almelysin, from a Marine Bacterium,Alteromonas sp. No. 3696: Purification and Characterization

We have discovered a novel metalloproteinase, which has high activity at low temperatures, from the culture supernatant of a marine bacterium. The strain was identified as Alteromonas sp. No. 3696. The metalloproteinase, named almelysin, was purified to homogeneity from the cultured supernatant at 10°C by two column chromatographies. About 20 mg of purified almelysin was obtained from 18.4 liters of the culture supernatant. The molecular mass of almelysin was estimated to be 28 kDa by SDS–PAGE and the isoelectric point was 4.3. The optimum pH for activity of almelysin was pH 8.5–9.0 and 6.5 using casein and (7-methoxycoumarin-4-yl)acetyl(MOCAc)-Pro-Leu-Gly-Leu-(N³-[2,4-dinitrophenyl]-L-2,3-di-aminopropionyl)[A₂pr(Dnp)]-Ala-Arg-NH₂ as substrates, respectively. Almelysin was stable between pH 7.5–8.0 and below 40°C. The optimum temperature for the activity was observed to be 40°C using both casein and MOCAc-Pro-Leu-Gly-Leu-A₂pr(Dnp)-Ala-Arg-NH₂ as substrates. The activity of almelysin was inhibited by such metallo chelators as EDTA and o-phenanthroline, while talopeptin, phosphoramidon, and SMPI, typical metalloproteinase inhibitors, had no effect. Almelysin primarily cleaved the Ala¹⁴-Leu¹⁵ bond and Phe²⁴-Phe²⁵ bond, and secondarily the Tyr¹⁶-Leu¹⁷ bond in oxidized insulin B-chain. However, almelysin could not cleave the His⁵-Leu⁶, His¹⁰-Leu¹¹, and Gly²³-Phe²⁴ bonds, which were cleaved by other metalloproteinases. These results indicate that the substrate specificity of almelysin is different from other metalloproteinases. Interestingly, Alteromonas sp. No. 3696 strain produced another proteinase as well as almelysin at 25°C.