The effect of the sugar source on citric acid production by Aspergillus niger

Summary Under otherwise identical fermentation conditions, the sugar source has been shown to have a marked effect on citric acid production by Aspergillus niger. Sucrose was the most favourable source, followed by glucose and fructose and then lactose. No citric acid was produced from galactose. Strong relationships were observed between citric acid production and the activities of certain enzymes in myccelial cell-free extracts prepared from fermentation samples. When sucrose, glucose, or fructose was the sugar source pyruvate carboxylase activity was high, but 2-oxoglutarate dehydrogenase activity was not detected. When galactose was the sugar source pyruvate carboxylase activity was low, but 2-oxoglutarate dehydrogenase activity was high. It is suggested that whereas glucose and fructose repress 2-oxoglutarate dehydrogenase, thereby causing accumulation of citric acid, galactose does not. The activity of aconitase showed a direct relationship to the citric acid production rate. Thus, the activity was highest when sucrose was the sugar source, and lowest when galactose was the source. It is suggested that when large amounts of citric acid are lost from the cell the activity of aconitase increases as a response to the diminished intracellular supply of its substrate.     

The influence of type and concentration of the carbon source on production of citric acid by Aspergillus niger

Summary The influence of various carbon sources and their concentration on the production of citrate by Aspergillus niger has been investigated. The sugars maltose, sucrose, glucose, mannose and fructose (in the given order) were carbon sources giving high yields of citric acid. Optimal yields were observed at sugar concentrations of 10% (w/v), with the exception of glucose (7.5%). No citric acid was produced on media containing less than 2.5% sugar. Precultivation of A. niger on 1% sucrose and transference to a 14% concentration of various other sugars induced citrate accumulation. This could be blocked by the addition of cycloheximide, an inhibitor of de novo protein synthesis. This induction was achieved using maltose, sucrose, glucose, mannose and fructose, and also by some other carbon sources (e.g. glycerol) that gave no citric acid accumulation in direct fermentation. Precultivation of A. niger at high (14%) sucrose concentrations and subsequent transfer to the same concentrations of various other carbohydrates, normally not leading to citric acid production, led to formation of citrate. Endogenous carbon sources were also converted to citrate under these conditions. A 14%-sucrose precultivated mycelium continued producing some citrate upon transfer to 1% sugar. These results indicate that high concentrations of certain carbon sources are required for high citrate yields, because they induce the appropriate metabolic imbalance required for acidogenesis.     

Glucose transport byAspergillus niger: the low-affinity carrier is only formed during growth on high glucose concentrations

The filamentous fungusAspergillus niger accumulates large levels of citric acid in the medium when grown under conditions favouring a high rate of sugar catabolism. With the aim of understanding the mechanisms involved in this process we investigated glucose transport in this fungus. To this end a medium was designed that enables growth of the fungus into a fine, hairy filamentous mycelium, suitable for transport studies. It was found thatA. niger contains a single, high-affinity glucose transporter when grown on a low (1% w/v) glucose concentration, but forms an additional low-affinity transporter when grown on a high (15% w/v) glucose concentration. Both glucose transporters exhibit decreased activities at low pH and are inhibited by citric acid. However, the activity of the low-affinity transporter is much less affected by these conditions. Two 2-deoxyglucose-resistant (dgr) mutants ofA. niger, which produce citric acid at a much lower rate than the parent strain, are impaired in the formation of the low-affinity transporter, but form the high-affinity transporter with higher activities. We conclude that the low-affinity glucose transporter takes part in the mechanism by whichA. niger responds to high extracellular glucose concentrations leading to citric acid accumulation.     

Citric acid production from extract of Jerusalem artichoke tubers by the genetically engineered yeast Yarrowia lipolytica strain 30 and purification of citric acid

In this study, citric acid production from extract of Jerusalem artichoke tubers by the genetically engineered yeast Yarrowia lipolytica strain 30 was investigated. After the compositions of the extract of Jerusalem artichoke tubers for citric acid production were optimized, the results showed that natural components of extract of Jerusalem artichoke tubers without addition of any other components were suitable for citric acid production by the yeast strain. During 10 L fermentation using the extract containing 84.3 g L^?1 total sugars, 68.3 g L^?1 citric acid was produced and the yield of citric acid was 0.91 g g^?1 within 336 h. At the end of the fermentation, 9.2 g L^?1 of residual total sugar and 2.1 g L^?1 of reducing sugar were left in the fermented medium. At the same time, citric acid in the supernatant of the culture was purified. It was found that 67.2 % of the citric acid in the supernatant of the culture was recovered and purity of citric acid in the crystal was 96 %.     

Overexpression of the NADP+-specific isocitrate dehydrogenase gene (icdA) in citric acid-producing Aspergillus niger WU-2223L

In the tricarboxylic acid (TCA) cycle, NADP⁺-specific isocitrate dehydrogenase (NADP⁺-ICDH) catalyzes oxidative decarboxylation of isocitric acid to form α-ketoglutaric acid with NADP⁺ as a cofactor. We constructed an NADP⁺-ICDH gene (icdA)-overexpressing strain (OPI-1) using Aspergillus niger WU-2223L as a host and examined the effects of increase in NADP⁺-ICDH activity on citric acid production. Under citric acid-producing conditions with glucose as the carbon source, the amounts of citric acid produced and glucose consumed by OPI-1 for the 12-d cultivation period decreased by 18.7 and 10.5%, respectively, compared with those by WU-2223L. These results indicate that the amount of citric acid produced by A. niger can be altered with the NADP⁺-ICDH activity. Therefore, NADP⁺-ICDH is an important regulator of citric acid production in the TCA cycle of A. niger. Thus, we propose that the icdA gene is a potentially valuable tool for modulating citric acid production by metabolic engineering.     

Selection of a hyperproducing strain ofAspergillus niger for biosynthesis of citric acid on unusual carbon substrates

Several tens of mutants were obtained by UV irradiation of a spore suspension ofAspergillus niger. Producers yielding large amounts of citric acid were selected on a moditied Czapek agar containing methyl red as pH indicator. After a submerged cultivation in flasks with baffles, a mutant characterized by yellow pigmentation on wort agar and by yields of citric acid up to 74.6% in the medium containing glucose was chosen from 130 isolates tested.     

Buffer-stimulated citrate efflux in Penicillium simplicissimum: an alternative charge balancing ion flow in case of reduced proton backflow?

Organic acids excreted by filamentous fungi may be used to win metals from industrial secondary raw materials. For a future commercial use a high production rate of organic acids is necessary. The conditions under which the commercially used fungus Aspergillus niger excretes high amounts of citric acid can not be maintained in metal leaching processes. However, Penicillium simplicissimum showed an enhanced citric acid efflux in the presence of an industrial filter dust containing 50% zinc oxide. Because Good buffers of high molarity were able to mimic the effect of zinc oxide, the high buffering capacity of zinc oxide and not an effect of the zinc ions was held responsible for the enhanced citric acid efflux. The presence of ammonium and trace elements reduced this buffer-stimulated citric acid efflux, whereas the plant hormone auxine canceled this reduction. This citric acid efflux was influenced by a depolarization of the membrane: the freely permeable compound tetraphenylphosphoniumbromide decreased the citric acid efflux, without decreasing intracellular citric acid or consumption of glucose and oxygen. Vanadate, an inhibitor of the plasma membrane H⁺-ATPase also reduced the buffer-stimulated citric acid efflux. The role of the efflux of citrate anions as an alternative charge balancing ion flow in case of impaired backflow of extruded protons because of a high extracellular buffering capacity is discussed.Abbreviations CCCP carbonyl cyanide m-chlorophenylhydrazone - delta electrochemical potential gradient - DES diethylstilbestrol - DMSO dimethyl sulfoxide - TAPS N-tris(hydroxymethyl)methyl-3-aminopropanesulfonic acid - TEA triethanolamine - TFP trifluoperazine - TPP tetraphenylphosphonium bromide     

柠檬酸和EDTA-Na2对黑麦草吸收Pb及营养元素特性的影响

为探究柠檬酸或EDTA-Na_2对Pb污染下黑麦草(Lolium perenne L.)吸收Pb和营养元素特性的影响,对水培黑麦草进行不同处理,研究黑麦草一些生理生化指标的变化。结果表明,与对照相比,Pb处理降低黑麦草干重,增加质膜透性和根系脱氢酶活性,且在叶和根中积累Pb,而叶和根中6种营养元素含量的变化不尽相同。与Pb处理同时加入低浓度的柠檬酸或EDTA-Na_2对其生长影响较小,且叶片的Pb积累量较低;而同时加入高浓度的柠檬酸或EDTA-Na_2,虽然强化Pb在叶片中的积累,但是加重了生长的抑制作用和营养元素的稳态失衡;1 mmol L~(–1)的柠檬酸强化叶片积累Pb的效应强于同浓度的EDTA-Na_2,而5和10 mmol L~(–1)柠檬酸的强化作用则弱于同浓度的EDTA-Na_2。因此,适当浓度的柠檬酸或EDTA-Na_2在治理Pb污染环境中具有一定作用。     

Growth ofMethylomonas methanolica: Factors Influencing growth yield

Summary The activities of ACH¹, NAD-ICDH, NADP-ICDH and CS were determined in cell extracts of high and low citric acid-producing strains of A. niger, cultivated on molasses medium by the surface or submerged method. A high differentiation in the activities of the enzymes studied was found to occur at various accumulation stages of citric acid and during its decomposition by moulds. During intensive citric acid synthesis, the activity of ACH and that of both dehydrogenases decreased significantly (though they did not disappear completely) compared to their initial activities during the growth period of the mycelium. CS activity, however, was maintained at almost the same level over the whole fermentation period or increased slightly, particularly in the case of low citric acid-producing strains. The relationships between the activities of these enzymes were reversed during citric acid decomposition by moulds. Moreover, it was shown that in the period of mycelium growth the maximal activities of the enzymes were much higher in submerged culture than in surface culture.     

Accumulation and partial re-consumption of polyols during citric acid fermentation by Aspergillus niger

Summary Quantitative balances have been made for sugar and oxygen uptake rates during citric acid accumulation by Aspergillus niger: during the first phase of citric acid accumulation (up to 130 h) more sugar is taken up than the production of biomass, CO₂ and citric acid account for. In contrast, during later phases of fermentation more citric acid, CO₂ and biomass are formed than sugar uptake would theoretically allow. A similar pattern is obtained for oxygen uptake, where less uptake occurs during the early phase of fermentation than needed for complete balance, and the reverse is observed during the late stage of fermentation. It could subsequently be shown that this is caused by the intermediate accumulation and partial re-consumption of a number of polyhydric alcohols (glycerol, arabitol, erythritol and mannitol) during citric acid fermentation.Dedicated to Professor H. J. Rehm on the occasion of his 60th birthday with kind regards     

A High Performance Fermentation Process for Citric Acid Production by Aspergillus niger NGGCB-101, Using Vermiculite as an Additive in a Stirred Bioreactor

The present study describes the use of vermiculite for enhanced citric acid productivity by a mutant strain of Aspergillus niger NG^GCB-101 in a stirred bioreactor of 15.0 l capacity. The maximum amount of citric acid (96.10 g/l) was obtained with the control 144 h after mycelial inoculation. To enhance citric acid production, varying levels of vermiculite were added as an additive into the fermentation medium. The best results were observed when 0.20 g/l vermiculite was added into the medium 24 h after inoculation resulting in the production of 146.88 g citric acid monohydrate/l. The dry cell mass and residual sugar were 11.75 and 55.90 g/l, respectively. Mixed mycelial pellets (1.08–1.28 mm, dia) were observed in the fermented culture broth. When the culture grown at different vermiculite levels was monitored for Q _p , Q _s and q _p , there was a significant enhancement (P 0.05) in these variables over the control (vermiculite-free). Based on these results, it is concluded that vermiculite might affect mycelial morphology and subsequent TCA cycle performance to improve carbon source utilization by the mould, basic parameters for high performance citric acid fermentation.     

Differences in sucrose metabolism relative to accumulation of bird-deterrent sucrose levels in fruits of wild and domestic Vaccinium species

We examined variability in sucrose levels and metabolism in ripe fruits of wild and domestic Vaccinium species and in developing fruits of cultivated blueberry (V. ashei and V. corymbosum). The objective was to determine if sufficient variability for fruit sucrose accumulation was present in existing populations to warrant attempts to breed for high-sucrose fruit, which potentially would be less subject to bird predation. Threefold differences in fruit sucrose concentration were found among Vaccinium species, ranging from 19 to 24 mg (g fresh weight)^?1 in V. stamineum and V. arboreum to approximately 7 mg (g fresh weight)^?1 in cultivated blueberry (V. ashei and V. corymbosum) and V. darrowi. Hexose levels were similar among species, ranging from 90 to 110 mg (g fresh weight)^–1, and glucose and fructose were present in equal amounts. Soluble acid invertase (EC 3.2.1.26) activity was negatively correlated with fruit sucrose concentration. There was no apparent correlation between fruit sugar concentration and either sucrose synthase (EC 2.4.1.13) or sucrose phosphate synthase (EC 2.4.1.14) activities, both of which were low for all species studied. Developmental increases in fruit sugar levels of cultivated blueberry followed a pattern similar to that observed in fruit fresh weight accumulation. Hexose concentrations ranged from 6 to 30 mg (g fresh weight)^?1 during the first 60 days after anthesis. Between 60 days and fruit ripening (80 days), hexose levels rose from 30 to 80 mg (g fresh weight)^?1. Sucrose was not detected in fruits until ripening, when low levels were found. Insoluble acid invertase activity was relatively high early in fruit development, decreasing as soluble acid invertase activity increased. Between 60 days and fruit ripening, soluble acid invertase activity increased from 3 to 55 μmol (g fresh weight)^–1 h^–1. Both sucrose synthase and sucrose phosphate synthase activities were low throughout development. The extent of sucrose accumulation in fruits and the degree of variability for this trait among Vaccinium species support the feasibility of developing high sucrose fruits, which would be a potentially valuable addition to current strategies of minimizing crop losses to birds.     

Citric acid in tomato plant roots and its effect on cadmium uptake and distribution

Experiments were carried out to investigate the effects of root citric acid on uptake and initial distribution of cadmium (Cd) in tomato plants (Lycopersicon esculentum, cv. Tiny Tim). Cd was measured by γ-spectrometry, using ¹¹⁵Cd spikes. Citric acid was measured by UV-detection, and, after spiking with ¹⁴C-citric acid, by β-spectrometry. Cd was applied for 48 h periods, in control experiments, in the presence of citric acid, and after 24 h plant pre-incubation with citric acid. Pre-incubation resulted in two-fold increases in fast-exchangeable amounts of root citric acid, as measured by the presence of citric acid in xylem exudates of decapitated and pressurized roots. Simultaneous application of Cd and citric acid did not change Cd accumulation in total plants and in the roots, nor did any significant change occur with respect to Cd root-to-shoot transport, and Cd concentrations in shoot tissues and xylem fluid. After citric acid pre-incubation, total plant uptake of Cd increased twofold, without any significant change in Cd accumulation in the roots. Cd root-to-shoot transport was increased 5–6 fold, and Cd concentrations in shoot tissues and xylem fluid were increased 6–8 fold. Speciation calculations indicated that, under the conditions applied, xylem Cd may be, at least partly, complexed in citric acid. A C Borstlap Section editor     

Biochemical studies of citric acid production and accumulation by Aspergillus niger mutants

The biochemical rationale for the inhibition of citric acid fermentation by Aspergillus niger in the presence of Mn²⁺ ions has been investigated using high citric acid-yielding, Mn²⁺ ion-sensitive as well as Mn²⁺ ion-tolerant mutant strains of A. niger. In the presence of Mn²⁺ (1.5 mg/l), citric acid production by the Mn²⁺ ion-sensitive strain (KCU 520) was reduced by about 75% with no apparent effect on citric acid yield by the Mn²⁺ ion-tolerant mutant strain (GS-III) of A. niger. The significantly increased level of the Mn²⁺ ion-requiring NADP⁺-isocitrate dehydrogenase activity in KCU 520 cells and the lack of effect on the activity level of the enzyme in GS-III mutant cells by Mn²⁺ ions during fermentation seem to be responsible for the Mn²⁺ ion inhibition of citric acid production by the KCU 520 strain and the high citric acid yield by the mutant strain GS-III of A. niger even in the presence of Mn²⁺.     

Differential effects of drought and light levels on accumulation of citric and malic acids during CAM in Clusia

Night-time citrate accumulation has been proposed as a response to stress in CAM plants. To address this hypothesis, gas exchange patterns and nocturnal acid accumulation in three species of Clusia were investigated under controlled conditions with regard to water stress and responses to low and high photosynthetic photon flux density (PPFD). Under high PPFD, leaves of Clusia nocturnally accumulated large amounts of both malic and citric acids. Under low PPFD and well-watered conditions, substantial night-time citrate accumulation persisted, whereas malate accumulation was close to zero. Malate accumulation and night-time CO₂ uptake from the atmosphere declined in all three species during prolonged drought periods, whereas citrate accumulation remained similar or increased. Recycling of respiratory CO₂ was substantial for both well-watered and water-stressed plants. The suggestion that citrate accumulation is energetically more favourable than malate accumulation is not supported if the source of CO₂ for the formation of malate is respiratory CO₂. However, the breakdown of citric acid to pyruvate in the light period releases three molecules of CO₂, while the breakdown of malic acid releases only one CO₂ per pyruvate formed. Thus, citric acid should be more effective than malic acid as a mechanism to increase CO₂ concentration in the mesophyll and may help to prevent photoinhibition. Organic acid accumulation also affected the vacuolar pH, which reached values of 2·6–3·0 at dawn. At these pH values, the transport of 2H⁺/ATP is still feasible, suggesting that it is the divalent form of citrate which is being transported in the vacuoles. Since citrate is a well-known buffer, and Clusia spp. show the largest day-night changes in organic acid levels measured in any CAM plant, it is possible that citrate increases the buffer capacity of the vacuoles. Indeed, malate and titratable acidity levels are positively related to citrate levels. Moreover, Clusia species that show the highest nocturnal accumulation of organic acids are also the ones that show the greatest changes in citric acid levels.     

Citric acid production from sucrose using a recombinant strain of the yeast Yarrowia lipolytica

The yeast Yarrowia lipolytica is able to secrete high amounts of several organic acids under conditions of growth limitation and carbon source excess. Here we report the production of citric acid (CA) in a fed-batch cultivation process on sucrose using the recombinant Y. lipolytica strain H222-S4(p67ICL1) T5, harbouring the invertase encoding ScSUC2 gene of Saccharomyces cerevisiae under the inducible XPR2 promoter control and multiple ICL1 copies (10–15). The pH-dependent expression of invertase was low at pH 5.0 and was identified as limiting factor of the CA-production bioprocess. The invertase expression was sufficiently enhanced at pH 6.0–6.8 and resulted in production of 127–140 g l⁻¹ CA with a yield Y _CA of 0.75–0.82 g g⁻¹, whereas at pH 5.0, 87 g l ⁻¹ with a yield Y _CA of 0.51 gg⁻¹ were produced. The CA-productivity Q _CA increased from 0.40 g l ⁻¹ h⁻¹ at pH 5.0 up to 0.73 g l ⁻¹ h⁻¹ at pH 6.8. Accumulation of glucose and fructose at high invertase expression level at pH 6.8 indicated a limitation of CA production by sugar uptake. The strain H222-S4(p67ICL1) T5 also exhibited a gene–dose-dependent high isocitrate lyase expression resulting in strong reduction (<5%) of isocitric acid, a by-product during CA production.     

Sugarcane-pressmud as a novel substrate for production of citric acid by solid-state fermentation

Sugarcane-pressmud, a by-product of cane-sugar manufacture, was used as a substrate for production of citric acid by Aspergillus niger CFTRI 30, in a solid-state fermentation system. Of the 170 g of sugar supplied, 131 g were consumed, with a 79% yield of citric acid over 120 h. Potassium ferrocyanide improved the conversion to about 88% and lowered the fermentation time by 24 h. Enrichment with sugar and NH₄NO₃ was essential to improve productivity. About 174 g citric acid/kg dry sugarcane-pressmud were produced after 120 h in ferrocyanid-treated medium which initially contained 12.5% (w/w) effective sugar and 0.1% (w/w) NH₄NO₃. About 3% (w/w) of the original sugar present in the sugarcane-pressmud was non-utilizable. This is the first report on the potential of sugarcane-pressmud for citric acid production.V.S. Shankaranand and B.K. Lonsane are with the Fermentation Technology and Bioengineering Discipline, Central Food Technological Research Institute, Mysore-570 013, India     

Continuous production of citric acid from sugarcane molasses using a combination of submerged immobilized and surface stabilized cultures of Aspergillus niger KCU 520

Summary A high performance fermentation process for the continuous production of citric acid from sugarcane molasses by using the combination of submerged calcium alginate-immobilized and surface-stabilized cultures of Aspergillus niger KCU 520 in a continuous flow horizontal bioreactor is described. The citric acid productivity was dependent on the dilution rate with an optimum value of 0.015/h. Presaturation of fermentation medium with sterile air, in addition to surface aeration, before feeding into the bioreactor enhanced the citric acid productivity. The highest productivity, citric acid product concentration and yield obtained were 1.7 kg M^–3h^–1, 110kg M^–3 and 91% respectively. The cultures were continuously used for 30 days without any apparent loss in citric acid productivity.     

Biosynthesis of citric acid

Summary TheA. niger strain 363 is better in its citric acid producing capacity than other strains studied. The pH value of the culture media differs from strain to strain for the good yield of citric acid. When there is good yield of citric acid the sugar consumption is less and mycelial growth is also less.     

Citric Acid Production from Hydrolysate of Pretreated Straw Cellulose by Yarrowia lipolytica SWJ-1b Using Batch and Fed-Batch Cultivation

In this study, crude cellulase produced by Trichoderma reesei Rut-30 was used to hydrolyze pretreated straw. After the compositions of the hydrolysate of pretreated straw were optimized, the study showed that natural components of pretreated straw without addition of any other components such as (NH₄)₂SO₄, KH₂PO₄, or Mg²⁺ were suitable for citric acid production by Yarrowia lipolytica SWJ-1b, and the optimal ventilatory capacity was 10.0 L/min/L medium. Batch and fed-batch production of citric acid from the hydrolysate of pretreated straw by Yarrowia lipolytica SWJ-1b has been investigated. In the batch cultivation, 25.4 g/L and 26.7 g/L citric acid were yields from glucose and hydrolysate of straw cellulose, respectively, while the cultivation time was 120 hr. In the three-cycle fed-batch cultivation, citric acid (CA) production was increased to 42.4 g/L and the cultivation time was extended to 240 hr. However, iso-citric acid (ICA) yield in fed-batch cultivation (4.0 g/L) was similar to that during the batch cultivation (3.9 g/L), and only 1.6 g/L of reducing sugar was left in the medium at the end of fed-batch cultivation, suggesting that most of the added carbon was used in the cultivation.