Properties of a cold-active protease from psychrotrophic Flavobacterium balustinum P104

Protease activity was detected in the culture medium of Flavobacterium balustinum P104 grown at 10 °C, which was isolated from salmon (Oncorhynchus keta) intestine. The enzyme, designated as CP-70 protease, was purified to homogeneity from the culture broth by ion exchange and gel filtration chromatographyies. The molecular mass of the protease was 70 kDa, and its isoelectric point was close to 3.5. Maximal activity toward azocasein was observed at 40 °C and from pH 7.0 to 9.0. The activity was strongly inhibited by phenylmethylsulfonyl fluoride, suggesting that the enzyme is a serine protease. The n-terminal amino acid sequence was Asp-Thr-Arg-Gln-Leu-Leu-Asn-Ala-Asn-Ser-Asp-Leu-Leu-Asn-Thr-Thr-Gly-Asn-Val-Thr-Gly-Leu-Thr-Gly-Ala-Phe-Asn-Gly-Glu-Asn. A search through the database for sequence homology yielded no significant match. The initial cleavage sites for oxidized insulin B-chain were found to be the Glu13-Ala14 and Phe24-Phe25 bonds. The result of the cleavage pattern of oxidized insulin B-chain suggests that CP-70 protease has a broader specificity than the other cold-active proteases against the peptide substrate. Received: 17 April 1998 / Received last revision: 17 June 1998 / Accepted: 10 July 1998     

Production, purification and characterization of a 50-kDa extracellular metalloprotease from Serratia marcescens

The extracellular metalloprotease (SMP 6.1) produced by a soil isolate of Serratia marcescens NRRL B-23112 was purified and characterized. SMP 6.1 was purified from the culture supernatant by ammonium sulfate precipitation, acetone fractional precipitation, and preparative isoelectric focusing. SMP 6.1 has a molecular mass of approximately 50 900 Da by sodium dodecyl sulfate/polyacrylamide gel electrophoresis (SDS-PAGE). The following substrates were hydrolyzed: casein, bovine serum albumin, and hide powder. SMP 6.1 has the characteristics of a metalloprotease, a pH optimum of 10.0, and a temperature optimum of 42° C. The isoelectric point of the protease is 6.1. Restoration of proteolytic activity by in-gel renaturation after SDS-PAGE indicates a single polypeptide chain. SMP 6.1 is inhibited by EDTA (9 μg/ml) and not inhibited by antipain dihydrochloride (120 μg/ml), aprotinin (4 μg/ml), bestatin (80 μg/ml), chymostatin (50 μg/ml), E-64 (20 μg/ml), leupeptin (4 μg/ml), Pefabloc SC (2000 μg/ml), pepstatin (4 μg/ml), phosphoramidon (660 μg/ml), or phenylmethylsulfonyl fluoride (400 μg/ml). SMP 6.1 retains full activity in the presence of SDS (1% w/v), Tween-20 (1% w/v), Triton X-100 (1% w/v), ethanol (5% v/v), and 2-mercaptoethanol (0.5% v/v). The extracellular metalloprotease SMP 6.1 differs from the serratiopeptidase (Sigma) produced by S. marcescens ATCC 27117 in the following characteristics: isoelectric point, peptide mapping and nematolytic properties. Received: 22 November 1996 / Received revision: 27 February 1997 / Accepted: 7 March 1997     

Process development for high-level secretory production of carboxypeptidase Y by Saccharomyces cerevisiae

In order to develop a production process for carboxypeptidase Y (CPY, yeast vacuolar protease) secreted by Saccharomyces cerevisiae KS58-2D, medium composition, culture conditions, and expression systems were investigated. We found that the addition of histidine to thiamine-free medium, in which CPY production was almost negligible, raised the intracellular thiamine level, resulting in the increase of CPY production. On the basis of the choice of an expression system that uses an inducible GAL10 promoter, reassessment of histidine concentration in the medium, and optimization of the pH level during cultivation (pH 6.5), active CPY was secreted in a quantity of over 400 mg/l, which was more than tenfold that higher than that previously reported. The process developed could be easily scaled-up to industrial-scale fermentation. Received: 16 January 1998 / Received revision: 16 February 1998 / Accepted: 27 February 1998     

Heterologous gene expression of bovine plasmin in Lactococcus lactis

Heterologous production of bovine plasmin was studied in the industrially relevant bacterium Lactococcus lactis. Two sets of lactococcal gene expression signals were coupled to the region of the plasmin gene coding for the serine protease domain. When the promoter region of the prtP gene was used, plasmin was detected mainly intracellularly in strain BPL25 by Western blot hybridization. The intracellular presence of plasmin led to physiological stress. Expression of the plasmin gene driven by the promoter and complete signal sequence of the lactococcal usp45 gene resulted in efficient plasmin secretion in strain BPL420. Cell lysis was observed in strains producing plasmin fragments including the catalytic domain, but not in control strains, which only produced a non-catalytic region of plasmin. The plasmin produced was shown to be biologically active. Received: 2 December 1996 / Received revision: 17 March 1997 / Accepted: 27 April 1997     

Diacetyl and acetoin production from the co-metabolism of citrate and xylose by Leuconostoc mesenteroides subsp. mesenteroides

The co-metabolism of citrate plus xylose by Leuconostoc mesenteroides subsp. mesenteroides results in a growth stimulation, an increase in d-lactate and acetate production and repression of ethanol production. This correlated well with the levels of key enzymes involved. A partial repression of alcohol dehydrogenase and a marked stimulation of acetate kinase were observed. High citrate bioconversion yields in diacetyl plus acetoin were obtained at pH 5.2 in batch (11.5%) or in chemostat (up to 17.4%) culture. In contrast, no diacetyl or acetoin was detected in citrate plus glucose fermentation. Received: 6 December 1996 / Received revision: 14 February 1997 / Accepted: 14 February 1997     

Evaluation of Candida acidothermophilum in ethanol production from lignocellulosic biomass

A Saccharomyces-cerevisiae-based simultaneous saccharification and fermentation (SSF) of lignocellulosic biomass is limited to an operating temperature of about 37 °C, and even a small increase in temperature can have a deleterious effect. This points to a need for a more thermotolerant yeast. To this end, S. cerevisiae D₅A and a thermotolerant yeast, Candida acidothermophilum, were tested at 37 °C, 40 °C, and 42 °C using dilute-acid-pretreated poplar as substrate. At 40 °C, C. acidothermophilum produced 80% of the theoretical ethanol yield, which was higher than the yield from S.cerevisiae D₅A at either 37 °C or 40 °C. At 42 °C, C. acidothermophilum showed a slight drop in performance. On the basis of preliminary estimates, SSF with C. acidothermophilum at 40 °C can reduce cellulase costs by about 16%. Proportionately greater savings can be realized at higher temperatures if such a high-temperature SSF is feasible. This demonstrates the advantage of using thermophilic or thermotolerant yeasts. Received: 20 February 1997 / Received revision: 24 June 1997 / Accepted: 4 July 1997     

Cloning, sequencing and overexpression of a Rhodothermus marinus gene encoding a thermostable cellulase of glycosyl hydrolase family 12

A gene library from the thermophilic eubacterium Rhodothermus marinus, strain ITI 378, was constructed in pUC18 and transformed into Escherichia coli. Of 5400 transformants, 3 were active on carboxymethylcellulose. Three plasmids conferring cellulase activity were purified and were all found to contain the same cellulase gene, celA. The open reading frame for the celA gene is 780 base pairs and encodes a protein of 260 amino acids with a calculated molecular mass of 28.8 kDa. The amino acid sequence shows homology with cellulases in glycosyl hydrolase family 12. The celA gene was overexpressed in E. coli when the pET23, T7 phage RNA polymerase system was used. The enzyme showed activity on carboxymethylcellulose and lichenan, but not on birch xylan or laminarin. The expressed enzyme had six terminal histidine residues and was purified by using a nickel nitrilotriacetate column. The enzyme had a pH optimum of 6–7 and its highest measured initial activity at 100 °C. The heat stability of the enzyme was increased by removal of the histidine residues. It then retained 75% of its activity after 8 h at 90 °C. Received: 5 August 1997 / Received revision: 6 November 1997 / Accepted: 7 November 1997     

Selection of a subtilisin-hyperproducing Bacillus in a highly structured environment

Mutants that secrete increased amounts of enzyme into a selection medium can be efficiently enriched from large populations of mutagenized microorganisms during growth in hollow fibers. Under these conditions, each colony grows in its own microenvironment and cross-feeding between neighboring colonies is limited. We applied the technique to B. subtilis carrying a plasmid-encoded protease gene. The plasmid was subjected to random mutagenesis and clones secreting up to fivefold-increased amounts of enzyme were selected using a medium containing bovine serum albumin as the sole nitrogen source. Received: 22 May 1997 / Received revision: 21 October 1997 / Accepted: 7 November 1997     

Bioconversion of 2-cyanopyrazine to 5-hydroxypyrazine-2-carboxylic acid with Agrobacterium sp. DSM 6336

5-Hydroxypyrazine-2-carboxylic acid, a versatile building block for the synthesis of new antituberculous agents, was prepared by whole-cell biotransformation from 2-cyanopyrazine via pyrazinecarboxylic acid using Agrobacterium sp. DSM 6336. By developing a fermentation process for this two-enzyme-step bioconversion, a product concentration of 286 mM (40 g/l) was obtained. After the isolation method had been optimized the total yield was 80%. Received: 28 February 1997 / Received revision: 28 April 1997 / Accepted: 4 May 1997     

Acid protease from Trichoderma reesei: limited proteolysis of fungal carbohydrases

Mechanisms regulating post-secretory limited proteolysis, carried out by the acid protease from Trichoderma reesei, were studied by following the release of α-galactosidase and multiple forms of cellobiohydrolase from this species. Both the rate of the proteolysis and the mode of action of the protease were affected by the pH of the culture medium, and only weakly depended on the amount of the enzyme. At pH between 2.7 and 3.5 the proteolytic reaction was limited, while at lower pH proteins were completely digested. Proteolysis depended on the degree of glycosylation of secreted enzymes. Inhibition of post-secretory deglycosylation decreased the rate of limited proteolysis in the culture medium in the course of fungal growth. Glucose and cellobiose, the main products of cellulose degradation carried out by the fungal cellulolytic complex, inhibited the proteolysis of the cellobiohydrolase in a concentration-dependent manner. A 32-kDa aspartic protease (EC 3.4.23.18) secreted by T. reesei was purified to homogeneity. The acid protease cleaved α-galactosidase and cellobiohydrolase into the same proteolytic fragments that had been isolated from the culture medium. Received: 4 December 1998 / Received revision: 22 February 1999 / Accepted: 5 March 1999     

Purification and characterization of an alkaline protease from Pseudomonas aeruginosa MN1

An alkaline protease produced by Pseudomonas aeruginosa MN1, isolated from an alkaline tannery waste water, was purified and characterized. The enzyme was purified 25-fold by gel filtration and ion exchange chromatography to a specific activity of 82350 U mg⁻¹. The molecular weight of the enzyme was estimated to be 32000 daltons. The optimum pH and temperature for the proteolytic activity were pH 8.00 and 60°C, respectively. Enzyme activity was inhibited by EDTA suggesting that the preparation contains a metalloprotease. Enzyme activity was strongly inhibited by Zn²⁺, Cu²⁺ and Hg²⁺(5 mM), while Ca²⁺ and Mn²⁺ resulted in partial inhibition. The enzyme is different from other Pseudomonas aeruginosa alkaline proteases in its stability at high temperature; it retained more than 90% and 66% of the initial activity after 15 and 120 min incubation at 60°C. Journal of Industrial Microbiology & Biotechnology (2000) 24, 291–295. Received 09 June 1999/ Accepted in revised form 24 January 2000     

On-line enzyme activity determination using the stopped-flow technique: application to laccase activity in pulp mill waste-water treatment

An automated system for on-line measurement of enzyme activity is proposed. The system uses a flow injection manifold in the stopped-flow mode to measure initial reaction rates. The time during which the flow is halted is selected in such a way as to optimise the enzyme/substrate ratio for the correct determination of activity values. The proposed system was used to determine the activity of laccase produced by the fungus Trametes versicolor immobilised on nylon in a fixed-bed reactor used for treating pulp mill waste water. Received: 17 February 1997 / Received revision: 23 April 1997 / Accepted: 27 April 1997     

Possible Involvement of Cysteine and Histidine Residues in the (NH4 + + Na+)-Activated ATPase of an Anaerobic Alkaliphile, Amphibacillus xylanus

Effect of various inhibitors on the (NH₄ ⁺ + Na⁺)-activated ATPase of an anaerobic alkaliphile, Ep01(a strain of Amphibacillus xylanus), was examined. Among the chemicals tested, the enzyme was drastically inactivated by p-chloromercuribenzoic acid and diethyl pyrocarbonate. The ATPase activity of the enzyme, which was inactivated by p-chloromercuribenzoic acid and diethyl pyrocarbonate, was remarkably restored by β-mercaptoethanol and hydroxylamine, respectively, suggesting the involvement of cysteine and histidine residues in the enzyme activity. Analysis of the inhibition kinetics by diethyl pyrocarbonate indicated that modification of a single histidine residue per ATPase molecule was sufficient to inactivate the enzyme. Received: 2 June 1997 / Accepted: 7 July 1997     

Production of trehalose synthase from a basidiomycete, Grifola frondosa, in Escherichia coli

The genomic DNA and cDNA for a gene encoding a novel trehalose synthase (TSase) catalyzing trehalose synthesis from α-d-glucose 1-phosphate and d-glucose were cloned from a basidiomycete, Grifola frondosa. Nucleotide sequencing showed that the 732-amino-acid TSase-encoding region was separated by eight introns. Consistent with the novelty of TSase, there were no homologous proteins registered in the databases. Recombinant TSase with a histidine tag at the NH₂-terminal end, produced in Escherichia coli, showed enzyme activity similar to that purified from the original G. frondosa strain. Incubation of α-d-glucose 1-phosphate and d-glucose in the presence of recombinant TSase generated trehalose, in agreement with the enzymatic property of TSase that the equilibrium lay far in the direction of trehalose synthesis. Received: 12 January 1998 / Received revision: 20 February 1998 / Accepted: 20 March 1998     

Purification and characterization of two extracellular alkaline proteases from a newly isolated obligate alkalophilic Bacillus sphaericus

Two novel extracellular serine proteases were purified to homogeneity from the cell-free culture filtrate of an obligate alkalophilic Bacillus sphaericus by a combination of ultrafiltration, ammonium sulfate precipitation and chromatographic methods. The enzymes showed similar substrate specificities, but differed in hydrophobicity and molecular mass. Protease A was a monomeric protease with a relative molecular mass (M _r) of 28.7 kDa, whereas protease B, with a M _r of 68.0 kDa, apparently consisted of smaller subunits. The purified protease A had a specific activity on hemoglobin of 5.1 U/mg protein compared to 40.9 U/mg protein in the case of protease B. Both proteases were most active on SAAPF-pNa, a substrate for chymotrypsin-like serine proteases. However, the K _m values of these two proteases on SAAPF-pNa were higher than that for α-chymotrypsin, indicating a lower affinity of proteases A and B for this substrate compared to chymotrypsin. Unlike other Bacillus serine proteases, neither protease A nor B stained with Coomasie blue R-250, even with loading of a large amount of protein, and they stained poorly with the silver staining method. However, NH₂-terminal amino acid sequencing of protease B revealed a high similarity with subtilisin Carlsberg (67% homology). Almost total inhibition of both proteases by PMSF, but very little/no inhibition by trypsin and chymotrypsin inhibitors (TPCK and TLCK) or thiol reagents (PCMB and iodoacetic acid), further supported the view that the enzyme belonged to the serine protease family. Journal of Industrial Microbiology & Biotechnology (2001) 26, 387–393. Received 05 November 2000/ Accepted in revised form 23 April 2001     

Biotransformation of linoleic acid with the Candida tropicalis M25 mutant

Linoleic acid was transformed by mutant Candida tropicalis M25 and transformations were studied in batch and fed-batch cultures. Cofermentations with palmitic acid as inducer of the fatty acid degradation pathway were performed. Besides the (Z),(Z)-octadeca-6,9-dienedioic acid, (Z),(Z)-3-hydroxyoctadeca-9,12-dienedioic acid and (Z),(Z)-3-hydroxytetradeca-5,8-dienedioic acid were obtained as the main fermentation products. The maximum concentrations of (Z),(Z)-octadeca-6,9-dienedioic acid and (Z),(Z)-3-hydroxyoctadeca-9,12-dienedioic acid reached values of 6.4 g/l and 6.9 g/l respectively. The structures of the products were characterized by chemical and spectroscopic methods. The configuration of the double bonds was not changed during bioconversion. As only one regioisomer of the hydroxylated fatty acid was detected, the hydroxylation is site-specific. Received: 11 November 1996 / Received revision: 11 February 1997 / Accepted: 24 February 1997     

Superior survival and degradation of dibenzo-p-dioxin and dibenzofuran in soil by soil-adapted Sphingomonas sp. strain RW1

The dibenzo-p-dioxin(DD)- and dibenzofuran(DF)-degrading bacterium, Sphingomonas sp. strain RW1, was tagged by insertion of a mini-Tn5 lacZ transposon in order to follow its fate in complex laboratory soil systems. The tagged strain was tested for its ability to survive in soil and degrade DF and DD applied at a concentration of 1 mg/g. Bacteria pre-adapted to soil conditions were found to survive better in DF- and DD-amended soil and degrade the substrate more efficiently than bacteria that had not been subjected to pre-adaptation. The concentration of soil-applied DF and DD, individually and in combination, decreased to less than 2% of the original concentrations within 3 weeks of addition of the RW1 derivative, accompanied by a short, but significant exponential increase in RW1 viable cells. During the same period the native bacterial population in soil was stable while viable fungi declined. Received: 12 November 1996 / Received revision: 21 February 1997 / Accepted: 22 February 1997     

Degradation of active-oxygen-modified ribulose-1,5-bisphosphate carboxylase/oxygenase by chloroplastic proteases requires ATP-hydrolysis

Active oxygen (AO) species generated in plants under stress conditions trigger degradation of Rubisco (EC 4.1.1.39). To find out whether AO species activate proteases or make the protein susceptible to proteolysis, purified and ¹⁴C-labelled Rubisco protein was incubated with stromal preparations obtained from barley (Hordeum vulgare L.) leaves. The protein was degraded into distinct fragments only after a treatment with AO. This result shows that AO-treated Rubisco has been modified to become a substrate for stromal protease(s) and dismisses the possibility of protease activation. Upon degradation, distinct fragments accumulated with time. The fragmentation pattern was indistinguishable from that obtained with intact chloroplasts subjected to oxidative conditions (cf. M. Desimone et al., 1996, Plant Physiol 111: 789–796). Degradation required ATP-hydrolysis, since AMP, ADP or non-hydrolysable ATP-analogs did not support proteolysis. The ClpP-deficient stromal preparations degraded AO-modified Rubisco, making the involvement of the ClpC/P protease unlikely. Received: 1 September 1997 / Accepted 15 November 1997     

One-step transformation of the dimorphic yeast Yarrowia lipolytica

An efficient one-step transformation method for the dimorphic yeast Yarrowia lipolytica is described. Using cells grown overnight on agar plates, the whole process is carried out within 1 h. The transformant clones could be recovered on selective plates as early as 36–48 h after plating. The efficiency was better than 10⁵ transformants/μg replicative plasmid DNA. Effects of cell density, dithiothreitol, heat shock, poly(ethylene glycol) 4000 concentration and the wetness of selective plates were investigated. Received: 17 February 1997 / Received revision: 4 April 1997 / Accepted: 19 April 1997     

The de novo production of drosophilin A (tetrachloro-4-methoxyphenol) and drosophilin A methyl ether (tetrachloro-1,4-dimethoxybenzene) by ligninolytic basidiomycetes

Ligninolytic basidiomycetes were screened for their ability to produce the tetrachlorinated hydroquinone metabolites drosophilin A (DA, tetrachloro-4-methoxyphenol) and drosophilin A methyl ether (DAME, tetrachloro-1,4-dimethoxybenzene). Five fungal strains produced these metabolites in detectable amounts, including strains from Bjerkandera and Peniophora, which are genera not previously known for DA or DAME production. Phellinus fastuosus ATCC26.125 had the highest and most reliable production of DA and DAME in peptone medium, respectively 15–60 μM and 4–40 μM. This fungus was used to study culture conditions that could increase DAME production. A fourfold increase in DAME production was found after the addition of hydroquinone to growing cultures of P. fastuosus. Therefore, hydroquinone is postulated to be a possible biosynthetic precursor of DAME in the fungus. Antagonising P. fastuosus by adding filter-sterilised culture fluid of a competing fungus, Phlebia radiata, increased DAME production significantly by tenfold. This result suggests that DAME production is elicited by compounds present in the culture fluid of P. radiata, indicating that DAME has an antibiotic function in P. fastuosus. Received: 17 September 1996 / Received revision: 7 February 1997 / Accepted: 15 February 1997