Toxicity of quinoline alkaloids to cultured Cinchona ledgeriana cells

The toxicity of Cinchona alkaloids to cell cultures of C. ledgeriana has been studied in relation to alkaloid uptake and possibilities for selecting high-yielding cell lines. The most toxic, quinine, was completely toxic at 5.5 mM. Both quinine and quinidine were more toxic than their unmethoxylated precursors, cinchonidine and cinchonine. The permanently-charged metho-chlorides of quinine and cinchonidine were less toxic than the parent alkaloids, despite showing similar accumulation ratios in 5-day uptake experiments at sub-toxic concentrations (ca 1.7mM). The toxicity of the natural quinoline alkaloids appears to be a non-specific effect which may be caused by intracellular alkalinisation following uptake of the uncharged bases. The use of precursors of quinine and quinidine as toxic agents for the selection of cell lines with enhanced quinine and quinidine production is ruled out by the lower toxicity of these precursors and by the correlation of an apparently non-specific toxicity with uptake.     

Alkaloid formation by habituated and tumorous cell suspension cultures of Catharanthus roseus

Habituated and tumorous Catharanthus roseus cells grown in the absence of hormones accumulated indole alkaloids. Total alkaloids and alkaloid pattern were the same when cells were cultured in medium without hormones or in alkaloid production medium with and without indole acetic acid. Treatment of cells with Pythium homogenate as elicitor did not increase total alkaloids or change the pattern of alkaloids produced. When either habituated or tumorous cells were grown in 1B5 medium after Gamborg et al (1968) containing 2,4-dichlorophenoxyacetic acid (2,4-D), their capacity to accumulate alkaloids decreased with time. The levels of tryptophan decarboxylase (TDC) and strictosidine synthase (SS) specific activities were constant throughout growth except when cells were exposed to 2,4-D in 1B5 medium, where enzyme activities declined in step with the decrease in alkaloid accumulation. Neither habituated nor tumorous cell suspension cultures accumulated vindoline, nor could they be induced to produce this alkaloid by any of the given treatments.NRCC No. 27514     

Production of canthin-6-one alkaloids by cell suspension cultures of Brucea javanica (L.) Merr.

Cell suspension cultures of Brucea javanica (L.) Merr. were used to determine culture growth characteristics and production of canthin-6-one alkaloids. The major alkaloids produced were canthin-6-one, 11-hydroxycanthin-6-one, 5-methoxycanthin-6-one and 11-methoxycanthin-6-one. Alkaloids were synthesised throughout the 36 day growth cycle of the cells with maximum amounts within the cells occurring between days 20 to 28; approximately 10% of the alkaloids were in the medium at day 24 rising to 45% at day 32.     

Cellular localization of quinolizidine alkaloids by laser desorption mass spectrometry (LAMMA 1000)

Stem sections of Lupinus polyphyllus and Cytisus scoparius have been analyzed for the distribution of quinolizidine alkaloids by laser desorption mass spectrometry, employing a LAMMA 1000 instrument. Sparteine and lupanine could be recorded and were found to be restricted to the epidermis and probably also to the neighbouring 1 or 2 subepidermal cell layers.Abbreviations QA quinolizidine alkaloids - GLC gas liquid chromatography - MS mass spectrometry     

Effect of some broad-spectrum antibiotics on the high-production strainClaviceps fusiformis W1

Summary The effect of chloramphenicol, streptomycin, oxytetracycline and tetracycline on growth intensity and production of clavine alkaloids in submerged cultures ofClaviceps fusiformis W1 was studied. Chloramphenicol (70–275 g/mL) is suitable for prevention of bacterial contaminations of saprophyticClaviceps cultures and has no negative effect on the magnitude and spectrum of alkaloid production.     

Secondary product formation by cultures of Beta vulgaris and Nicotiana rustica transformed with Agrobacterium rhizogenes

Hairy root cultures of Beta vulgaris and Nicotiana rustica were established after roots were induced on plants following infection with Agrobacterium rhizogenes. The transformed cultures of B. vulgaris and N. rustica synthesised their characteristic secondary products, the betalain pigments and nicotine alkaloids respectively, at levels comparable with those of in vivo roots from the same variety. Betalains were entirely retained inside the root tissue. In contrast, a proportion of the nicotine alkaloids was secreted into the medium. The potential of this type of in vitro plant tissue culture for the production of valuable plant secondary products is identified and confirmed.     

Permeabilization of Cinchona ledgeriana cells by dimethylsulphoxide. effects on alkaloid release and long-term membrane integrity

Dimethyl sulphoxide (DMSO) has been used to permeabilize cells of Cinchona ledgeriana in suspension culture and promote the release of intracellular alkaloids. 5–6% v/v is required before any release is seen, and greater than 20% DMSO is required for full release. Even at these high levels of DMSO release is slow, taking in excess of seven hours to reach completion. Conditions which produce significant release of alkaloids have a deleterious effect on cells. Many of the membranes permeabilized did not recover their ability to selectively exclude compounds such as mannitol when the DMSO was removed. It is concluded that DMSO is not a suitable material for inducing alkaloid release in any biotechnological exploitation of alkaloid production by C. ledgeriana.Abbreviations DMSO Dimethyl sulphoxide - 2,4D 2,4-Dichlorophenoxyacetic acid     

Triggered efflux of protoberberine alkaloids from cell suspension cultures ofThalictrum rugosum

Cell cultures ofThalictrum rugosum released their protoberberine alkaloids into the medium, when cells were transferred to fresh medium lacking phosphate. The nutritional factors required and the impact of the cells' physiological state for the alkaloid excretion were analyzed. Cell cultures, having released their alkaloids into the medium, continued to grow when the alkaloid containing medium was replaced by fresh growth medium.     

In situ adsorption for enhanced alkaloid production byCatharanthus roseus

Summary A significant fraction (10–40%) of the indole alkaloids produced byCatharanthus roseus was observed to be secreted into the medium. When a neutral polymeric resin, known to adsorb these alkaloids, was added to the cultivation medium, the accumulation of total indole alkaloids and the specific alkaloids, ajmalicine and serpentine were stimulated. Sorbent addition was also observed to result in increased ratios of ajmalicine to serpentine, which suggests the potential of using in situ adsorption to direct metabolism toward a specific product or intermediate within a given pathway.     

Nutritional factors affecting lipase production byRhizopus delemar CDBB H313

Summary Some nutritional factors that affect lipase yields byRhizopus delemar were studied. Dextrin proved to be the best carbon source when used at 1% level. Yeast extract was the best nitrogen source for lipase production. The presence of a lipidic source in the growth medium, at a level not higher than 2% resulted in higher enzyme production. Tween 80 exerted a positive effect on enzyme production, used in a range that goes from 0.02% to 2.00%.     

Adsorption ofCatharanthus roseus cells on various support particles

Summary Adsorption ofC. roseus cells producing indole alkaloids on various support particles were investigated in an attempt to find a suitable support material for surface culture of plant cells. Five different support particles namely gelatin, agar, alginate, polypropylene and glass beads were tested. Gelatin was found to be the most effective adsorbent resulting in nearly 30% adsorption of cells initially present in suspension. Adsorption isotherm of cells on gelatin beads was represented by a three parameter expression due to sigmoidal shape of the isotherm. The constants of the adsorption isotherm were determined using the experimental data.     

D-Xylose fermentation to ethanol bySchizosaccharomyces pombe cloned with xylose isomerase gene

Summary Schizosaccharomyces pombe cloned with the xylose isomerase gene from E. coli is able to grow on YNB and YMP broths containing xylose as the sole carbon source. This yeast can ferment D-xylose to ethanol directly; however, the ethanol production rate and the yield were dependent on the nitrogen source. With the YMP broth as a nitrogen source, the final ethanol concentration can reach 3.7% (w/v), and the ethanol yield was 80% of the theoretical value based on the amount of xylose that was metabolized. The ethanol production is slow, and the xylitol production is still very active; apparently, the limiting step is the isomerization of xylose to xylulose.     

Production of tropane alkaloids in cultured cells of Hyoscyamus niger

Tests for calluses rich in tropane alkaloids were made with newly induced calluses of Atropa belladonna, Datura stramonium and Hyoscyamus niger. Only calluses of H. niger gave an alkaloid-positive test.A Hyoscyamus cell line had the highest total alkaloid content of all the calluses screened by the cell-squash alkaloid assay. Both hyoscyamine and scopolamine were identified in the cultured cells of this line by TLC, GLC and GC-MS.Abbreviations NAA 1-Naphthaleneacetic acid - BA Benzyladenine - BSA N,O-Bis(trimethylsilyl) acetamide     

Cytological changes associated with alkaloid production in cultured cells of Coptis japonica and Thalictrum minus

Cell structures were compared between alkaloid-producing and non-producing cell cultures of Coptis japonica and Thalictrum minus by electron microscopic observation. In alkaloid-producing cells of C. japonica, prior to the onset of alkaloid synthesis, the vacuoles showed a greater volume than in non-producing cells. These were characterized by a number of large starch grains in the cytoplasm. Furthermore, alkaloid-producing cells contained stacks of rough endoplasmic reticulum. Comparison of different cell lines suggested that there might be a negative correlation between accumulation of alkaloids and starch. Similar cytological differences were observed with T. minus cell cultures that release berberine into the culture medium. Alkaloid producing cells were found to contain an abundance of cytoplasmic vesicles (0.5 – 1 m in diameter).     

Alkaloid production in Catharanthus roseus (L.) G. Don cell cultures. XIII. Effects of bioregulators on indole alkaloid biosynthesis

A study on the effect of various bioregulators on the biosynthesis of ajmalicine (8) and catharanthine (9) in plant tissue cultures of Catharanthus roseus is described. It is shown that 1,1-dimethylpiperidine bromide (3) and 2-diethylaminoethyl-3,4-dimethylphenylether (7) are effective in increasing these alkaloid levels in the cell line PRL #200. Such studies may prove beneficial in larger scale experiments designed for the production of these alkaloids.     

High-yield production of tropane alkaloids by hairy-root cultures of aDatura candida hybrid

Hairy root cultures were obtained following inoculation of the stems of sterile plantlets of aDatura candida hybrid withAgrobacterium rhizogenes. The scopolamine and hyoscyamine content was quantified by HPLC and compared with the non-transformed plants. The alkaloid yield (0.68% dry weight) obtained with the hairy roots was 1.6 and 2.6 times the amount found in the aerial parts and in the roots of the parent plants, respectively. Only a small proportion of alkaloids was released into the growth medium. Scopclamine was the principal alkaloid and the scopolamine/hyoscyamine ratio of ca. 5:1 makes these hairy roct cultures worthy of consideration as a source of scopolamine.     

Development of media for growth ofDioscorea Deltoidea cells andin vitro diosgenin production: Influence of media constituents and nutrient stress

Summary Callus culture ofDioscorea deltoidea produced diosgenin and sterols during stationary phase. Ammonium nitrate (420 mg Nitrogen/l) as sole nitrogen source supported better growth than a combination of ammonium nitrate and potassium nitrate (totally equivalent to 840 mg Nitrogen/l). The production of diosgenin increased under low phosphate concentration (100 mg/l) whereas high phosphate concentration (240 mg/l) promoted growth. Micronutrients, when used at 1 1/2 strength, enhanced growth and diosgenin production. Depletion of nitrogen increased the diosgenin synthesis by a factor of 2. Adoption of a two stage culture method enhanced the diosgenin production in cultured cells by eight-fold.     

Growth and alkaloid contents in leaves of Tabernaemontana pachysiphon Stapf (Apocynaceae) as influenced by light intensity,water and nutrient supply

The growth of Tabernaemontana pachysiphon (Apocynaceae) plants and the alkaloid content of leaves were investigated in the greenhouse at three levels of nutrient supply under two contrasting water and light regimes. We determined height increment, above-ground biomass production, leaf size, specific leaf weight and the content of the alkaloids apparicine, A2, isovoacangine, tubotaiwine and tubotaiwine-N-oxide. The effects of major controlling factors such as light, water and nutrient supply could be directly correlated with growth and were largely independent of each other. In contrast, leaf-alkaloid contents were influenced by interdependencies among the main factors and individually affected in a synergistic or antagonistic manner which deviated from the effects on growth. The following general trends could be identified with respect to the quantitatively predominant alkaloids apparicine, tubotaiwine and isovoacangine. Increasing nutrient supply had a positive effect on both growth and alkaloid content. Drought increased alkaloid content, but retarded growth. High light intensity lowered alkaloid content but promoted growth. We investigated the relationship between primary production and the production of secondary metabolites with respect to relative and total alkaloid content as well as in relation to the leaves' nitrogen status. Our results showed that under conditions of low nutrient supply, higher proportions of leaf nitrogen were allocated to alkaloids than at moderate or high nutrient supply. Under conditions of drought and low light, all plants allocated almost equal proportions of leaf nitrogen to alkaloids, regardless of fertiliser. Total alkaloid content per plant, however, increased with fertilisation. With respect to the N-allocation strategy, we found no indication of a trade-off between primary production and the production of secondary metabolites in this species. Rather, our results are in accordance with the carbon nutrient balance hypothesis.     

Alkaloid formation by Catharanthus roseus cells in a packed column biofilm reactor

Summary Catharanthus roseus cells producing indole alkaloids were grown on surfaces of Ca-alginate beads within the interspacial volume of a packed column. Production media was circulated through the packed column in an upflow mode. Growth and indole alkaloid formation were quantified and compared with suspension culture of cells. Final alkaloid concentration and alkaloid yield obtained in the packed bed was superior to those obtained in suspension culture. This is thought to be due to improved cell-cell contact and interaction in the packed column.     

Release and crystallization of berberine in the liquid medium of Thalictrum minus cell suspension cultures

Cell suspension cultures of Thalictrum minus L. var. hypoleucum Miq. were found to produce a large amount of berberine (400–800 mg/l) when 5–10 M 6-benzyladenine was added to Linsmaier and Skoog's medium containing 100 M 1-naphthaleneacetic acid. Most of the berberine produced was released continuously from the cells into the liquid medium, and an excess of berberine crystallized as its nitrate in the medium. When the cells were cultured in a modified LS medium containing 20 mM KNO₃ and 40 mM NH₄Cl in place of 20.6 mM NH₄NO₃ as nitrogen source, most of the alkaloid crystallized to form berberine chloride instead of nitrate. Minor alkaloids, thalifendine and magnoflorine, were also isolated from the medium and identified.Abbreviations LS Linsmaier and Skoog (1965) - 2,4-D 2,4-dichlorophenoxyacetic acid - NAA 1-naphthaleneacetic acid - BA 6-benzyladenine