The Respiratory Activity of Rhodococcus rhodochrousM8 Cells Producing Nitrile-Hydrolyzing Enzymes

The respiratory activity of Rhodococcus rhodochrousM8 cells containing nitrile hydratase and amidase was studied in the presence of nitriles and amides of carbonic acids. The culturing of cells with acrylonitrile and acrylamide yielding maximum respiratory activity was studied. The optimum conditions for measurements and maintenance of respiratory activity were found. Curves for the linear concentration dependence of cell respiratory activity on 0.01–0.5 mM acrylonitrile, 0.025–1.0 mM acetonitrile, and 0.01–0.1 mM acrylamide were plotted. The selectivity of cell respiratory activity for some substrates was analyzed.     

Biotransformation of acrylonitrile to acrylamide using immobilized whole cells of Brevibacterium CH1 in a recycle fed-batch reactor

Acrylamide was produced from acrylonitrile using immobilized Brevibacterium CH1 cells that were isolated from soil and found to possess nitrile hydratase activity. The reaction conditions and stability of the enzyme activity were studied. The conversion yield was nearly 100%, including a trace amount of acrylic acid. This strain showed strong activity of nitrile hydratase toward acrylonitrile and extremely low activity of amidase toward acrylamide. A packed bed reactor was operated in a fed-batch manner for acrylamide production of high concentration. The acrylonitrile concentration was maintained below 3% and the operating temperature at 4 degrees C to minimize enzyme deactivation.     

Operational stability of Brevibacterium imperialis CBS 489-74 nitrile hydratase

Brevibacterium imperialis CBS 489-74 was grown in broths prepared with yeast and malt extract, bacteriological peptone and 2% glucose or differently modified with the addition of Na-phosphate buffer, FeSO₄, MgSO₄ and CoCl₂. The peak production of nitrile hydratase (NHase) did not change significantly. At the stationary growth phase, the units per milliliter of broth (60 units ml⁻¹) were more important than those at the exponential growth phase.

The NHase operational stability of whole resting cells was monitored following the bioconversion of acrylonitrile to acrylamide in continuous and stirred UF-membrane reactors. The rate of inactivation was independent on buffer molarity from 25 to 75 mM and on pH from 5.8 to 7.4. Enzyme stability and activity remained unchanged in distilled water. The initial reaction rate increased from 12.8 to 23.8 g acrylamide/g dry cell/h, but NHase half-life dropped from 33 to roughly 7 h when temperature was varied from 4°C to 10°C. The addition of butyric acid up to 20 mM did not improve enzyme operational stability, and largely reduced (94%) enzyme activity. Acrylonitrile caused an irreversible damage to NHase activity. High acrylonitrile conversion (86%) was attained using 0.23 mg cells/ml in a continuously operating reactor.     

Methods for increasing nitrile biotransformation into amides using Mesorhizobium sp

Nitriles are potential soil pollutants from industrial wastewater. There has been increased demand for efficient process for nitrile degradation process. Nitrile hydratase (NHase) has been extensively used in the production of acrylamide and treatment of organocyanide contaminated industrial effluents. The NHase of Mesorhizobium sp., isolated from polyacrylonitrile activated sludge from fiber manufacturing wastewater treatment systems was studied in the whole bacterial cells. Different chemicals were added to observe the variation in the percentage of acrylonitrile converted into acrylamide. The result indicated that cobalt ions were the NHase cofactor and could increase the NHase activity. The addition of propionaldehyde, or butyraldehyde could enhance the acrylonitrile conversion rate. Therefore, acrylamide could be accumulated effectively and the percentage of acrylonitrile converted into acrylamide increased. Propionaldehyde was the most effective NHase activator. The percentage of acrylonitrile converted into acrylamide was nearly 100% at 3.8 h when propionaldehyde was added at about 207.4 mg/l. The addition of benzaldehyde was unable to increase the percentage of acrylonitrile converted into acrylamide. EDTA and acrylamide showed no effect on NHase activity. However, 0.1 mg/l of Ag2SO4 would slightly inhibit NHase activity, producing an acrylonitrile conversion rate of 492.9 mg/l with 54.9% converted at 29.1 h. The ability of the acrylonitrile biotransformation was completely inhibited if the Ag2SO4 concentration was above 0.5 mg/l.     

Solvent Effects on Circular Dichroism of Colominic Acid

To produce acrylamide from acrylonitrile by use of a new enzyme, nitrile hydratase, a number of nitrile-utilizing microorganisms were screened for the enzyme activity by an intact cell system. An isobutyronitrile-utilizing bacterium, strain B23, showed the best productivity among 186 strains tested. The strain was identified taxonomically as Pseudomonas chlor or aphis. The culture and reaction conditions for the production were studied for the strain. Under the optimum conditions, 400 grams/liter of acrylamide was produced in 7.5 hr. The yield was nearly 100% with a trace amount of acrylic acid. The cell-free extract of the strain showed strong activity of nitrile hydratase toward acrylonitrile and extremely low activity of amidase toward acrylamide.     

微生物法生产丙烯酰胺的研究（Ⅱ）—腈水合酶催化反应动力学与失活动力学

在以丙烯腈为原料 ,微生物转化生产丙烯酰胺的过程中 ,酶催化反应是过程的关键。为了了解酶催化的动力学 ,本研究以自由细胞的酶为催化剂 ,进行了腈水合酶的反应动力学和失活动力学的研究。首先研究了菌体浓度、温度、pH值、丙烯腈浓度、丙烯酰胺浓度等对腈水合酶催化反应速度的影响。结果表明 ,在这些因素中 ,温度和丙烯酰胺浓度是最主要的影响因素。 2 8℃时酶活为 5 6 5 9u mL(菌液 ) ,在 5℃时的反应速率仅为 2 8℃时的11 72 % ,相应的表观酶活为 6 6 3u mL(菌液 )。而在丙烯酰胺 45 %浓度条件下的酶活大约只有丙烯酰胺 5 %浓度下的酶活的 1 2。经过对不同温度下的反应速度的研究 ,得到腈水合酶水合反应的活化能为 6 5 5 7kJ·mol- 1 。本文进一步研究了自由细胞状态下 ,菌体浓度、pH值、温度、丙烯腈浓度、丙烯酰胺浓度对腈水合酶失活的影响 ,得到了失活动力学。结果表明 ,在这些因素中 ,对酶失活影响的最主要因素还是温度和丙烯酰胺浓度。尤其当丙烯酰胺浓度到达 35 %时 ,酶活下降得很快 ,在 5 5h后 ,酶活几乎为零。而在丙烯酰胺浓度为 10 %的情况下 ,5 5h的酶活仍然还存在约 5 0 %。试验结果还表明 ,丙烯腈对酶的稳定性的影响很小。经过数据处理 ,得到的 2 8℃的酶失活速率常数为 5℃下的 2 1 7     

Methods for increasing nitrile biotransformation into amides using Mesorhizobium sp.

Nitriles are potential soil pollutants from industrial wastewater. There has been increased demand for an efficient process for the nitrile degradation process. Nitrile hydratase (NHase) has been extensively used in the production of acrylamide and treatment of organocyanide-contaminated industrial effluents. The NHase of Mesorhizobium sp., isolated from polyacrylonitrile (PAN) activated sludge from fiber manufacturing wastewater treatment systems was studied in the whole bacterial cells. Different chemicals were added to observe the variation in the percentage of acrylonitrile converted into acrylamide. The result indicated that cobalt ions were the NHase cofactor and could increase the NHase activity. The addition of propionaldehyde, or butyraldehyde, could enhance the acrylonitrile conversion rate. Therefore, acrylamide could be accumulated effectively and the percentage of acrylonitrile converted into acrylamide increased. Propionaldehyde was the most effective NHase activator. The percentage of acrylonitrile converted into acrylamide was nearly 100% at 3.8 h when propionaldehyde was added at about 207.4 mg/l. The addition of benzaldehyde was unable to increase the percentage of acrylonitrile converted into acrylamide. EDTA and acrylamide showed no effect on NHase activity. However, 0.1 mg/l of Ag₂SO₄ would slightly inhibit NHase activity, producing an acrylonitrile conversion rate of 492.9 mg/l with 54.9% converted at 29.1 h. The ability of the acrylonitrile biotransformation was completely inhibited if the Ag₂SO₄ concentration was above 0.5 mg/l. Published in Russian in Prikladnaya Biokhimiya i Mikrobiologiya, 2008, Vol. 44, No. 3, pp. 304–307. The text was submitted in English.     

Acrylamide synthesis using agar entrapped cells of <Emphasis Type="Italic">Rhodococcus rhodochrous</Emphasis> PA-34 in a partitioned fed batch reactor

The nitrile hydratase (Nhase) induced cells of Rhodococcus rhodochrous PA-34 catalyzed the conversion of acrylonitrile to acrylamide. The cells of R. rhodochrous PA-34 immobilized in 2% (w/v) agar (1.76 mg dcw/ml agar matrix) exhibited maximum Nhase activity (8.25 U/mg dcw) for conversion of acrylonitrile to acrylamide at 10°C in the reaction mixture containing 0.1 M potassium phosphate buffer (pH 7.5), 8% (w/v) acrylonitrile and immobilized cells equivalent to 1.12 mg dcw (dry cell weight) per ml. In a partitioned fed batch reaction at 10°C, using 1.12 g dcw immobilized cells in a final volume of 1 l, a total of 372 g of acrylonitrile was completely hydrated to acrylamide (498 g) in 24 h. From the above reaction mixture 87% acrylamide (432 g) was recovered through crystallization at 4°C. By recycling the immobilized biocatalyst (six times), a total of 2,115 g acrylamide was produced.     

Metabolism of acrylonitrile by Klebsiella pneumoniae

A gram-negative rod-shaped bacterium capable of utilizing acrylonitrile as the sole source of nitrogen was isolated from industrial sewage and identified as Klebsiella pneumoniae. The isolate was capable of utilizing aliphatic nitriles containing 1 to 5 carbon atoms or benzonitrile as the sole source of nitrogen and either acetamide or propionamide as the sole source of both carbon and nitrogen. Gas chromatographic and mass spectral analyses of culture filtrates indicated that K. pneumoniae was capable of hydrolyzing 6.15 mmol of acrylonitrile to 5.15 mmol of acrylamide within 24 h. The acrylamide was hydrolyzed to 1.0 mmol of acrylic acid within 72 h. Another metabolite of acrylonitrile metabolism was ammonia, which reached a maximum concentration of 3.69 mM within 48 h. Nitrile hydratase and amidase, the two hydrolytic enzymes responsible for the sequential metabolism of nitrile compounds, were induced by acrylonitrile. The optimum temperature for nitrile hydratase activity was 55°C and that for amidase was 40°C; both enzymes had pH optima of 8.0.Abbreviations PBM phosphate buffered medium - GC gas chromatography - GC/MS gas chromatography/mass spectrometry     

Bioconversion of acrylonitrile to acrylamide using polyacrylamide entrapped cells of <Emphasis Type="Italic">Rhodococcus rhodochrous</Emphasis> PA-34

The nitrile hydratase (NHase) of Rhodococcus rhodochrous PA-34 catalyzed the conversion of acrylonitrile to acrylamide. The resting cells (having NHase activity) (8 %; 1 mL corresponds to 22 mg dry cell mass, DCM) were immobilized in polyacrylamide gel containing 12.5 % acrylamide, 0.6 % bisacrylamide, 0.2 % diammonium persulfate and 0.4 % TEMED. The polyacrylamide entrapped cells (1.12 mg DCM/mL) completely converted acrylonitrile in 3 h at 10 °C, using 0.1 mol/L potassium phosphate buffer. In a partitioned fed batch reactor, 432 g/L acrylamide was accumulated after 1 d. The polyacrylamide discs were recycled up to 3×; 405, 210 and 170 g/L acrylamide was produced in 1st, 2nd and 3rd recycling reactions. In four cycles, a total of 1217 g acrylamide was produced by recycling the same mass of entrapped cells.     

Cytoskeletal dynamics in rabbit synovial fibroblasts: I. Effects of acrylamide on intermediate filaments and microfilaments

Rabbit synovial fibroblasts respond to changes in cell shape and cytoskeletal architecture by altering specific gene expression. We have tested the ability of acrylamide, a neurotoxin that alters the distribution of intermediate filaments in cultured PtK1 cells, to induce metalloprotease expression in synovial fibroblasts. Cells treated with 2-20 mM acrylamide for 5 to 24 h underwent shape changes similar to cells treated with the tumor promoter phorbol myristate acetate. Intermediate filaments visualized with anti-vimentin antibodies did not collapse into a perinuclear cap in these rounded cells, but were still present in the extended cell processes. Unexpectedly, when actin was visualized in acrylamide-treated cells, extensive dissociation and clumping of microfilaments was observed. Concentrations of acrylamide greater than 10 mM were cytotoxic, but cells recovered completely after 24 h incubation with 5 mM acrylamide. Like other agents that alter cell shape and actin distribution in synovial fibroblasts, acrylamide also induced expression of the secreted metalloprotease collagenase. Although some recent evidence suggests that acrylamide may be able to exert its collagenase-inducing effects extracellularly, perhaps through transmembrane matrix receptors, our observation that this neurotoxin dramatically alters protein synthesis in synovial fibroblasts suggests that direct effects on cell metabolism may also play a role in acute acrylamide intoxication.     

Nitrile bioconversion by Microbacterium imperiale CBS 498-74 resting cells in batch and ultrafiltration membrane bioreactors

The biohydration of acrylonitrile, propionitrile and benzonitrile catalysed by the NHase activity contained in resting cells of Microbacterium imperiale CBS 498-74 was operated at 5, 10 and 20°C in laboratory-scale batch and membrane bioreactors. The bioreactions were conducted in buffered medium (50 mM Na₂HPO₄/NaH₂PO₄, pH 7.0) in the presence of distilled water or tap-water, to simulate a possible end-pipe biotreatment process. The integral bioreactor performances were studied with a cell loading (dry cell weight; DCW) varying from 0.1 mg_DCW per reactor to 16 mg_DCW per reactor, in order to realize near 100% bioconversion of acrylonitrile, propionitrile and benzonitrile without consistent loss of NHase activity.     

High-level expression in Corynebacterium glutamicum of nitrile hydratase from Rhodococcus rhodochrous for acrylamide production

The nhhBAG gene of Rhodococcus rhodochrous M33 that encodes nitrile hydratase (NHase), converting acrylonitrile into acrylamide, was cloned and expressed in Corynebacterium glutamicum under the control of an ilvC promoter. The specific enzyme activity in recombinant C. glutamicum cells was about 13.6 μmol/min/mg dry cell weight (DCW). To overexpress the NHase, five types of plasmid variants were constructed by introducing mutations into 80 nucleotides near the translational initiation region (TIR) of nhhB. Of them, pNBM4 with seven mutations showed the highest NHase activity, exhibiting higher expression levels of NhhB and NhhA than wild-type pNBW33, mainly owing to decreased secondary-structure stability and an introduction of a conserved Shine-Dalgarno sequence in the translational initiation region. In a fed-batch culture of recombinant Corynebacterium cells harboring pNBM4, the cell density reached 53.4 g DCW/L within 18 h, and the specific and total enzyme activities were estimated to be 37.3 μmol/min/mg DCW and 1,992 μmol/min/mL, respectively. The use of recombinant Corynebacterium cells for the production of acrylamide from acrylonitrile resulted in a conversion yield of 93 % and a final acrylamide concentration of 42.5 % within 6 h when the total amount of fed acrylonitrile was 456 g.     

Immobilization of Rhodococcus ruber strain gt1, possessing nitrile hydratase activity, on carbon sorbents

Rhodococcus ruber strain gtl, possessing nitrile hydratase activity, was immobilized by adsorption on carbon supports differing in structure and porosity. The adsorption capacity of the supports towards cells, the substrate of the nitrile hydratase reaction (acrylonitrile), and the product (acrylamide) was studied. Also, the effect of immobilization and nitrile hydratase activity of bacteria was investigated, and the operational stability of the immobilized biocatalyst was determined. It was shown that crushed and granulated active coals were more appropriate for immobilization than fibrous carbon adsorbents.     

Acrylamide is genotoxic to the somatic and germ cells of Drosophila melanogaster

The genotoxic effects of acrylamide, a recently detected carcinogen, have been studied in the somatic (wing primordia) and germ cells of Drosophila melanogaster by the wing mosaic assay and the sex-linked recessive lethal test respectively. Larvae, 72 +/- 4 h old, were exposed to 6 different concentrations of acrylamide ranging between 0.25 mM and 5.0 mM in instant medium for 48 h. It is observed that acrylamide is both mutagenic and recombinogenic in the wing disc cells and induces sex-linked recessive lethals.     

Immobilization of <Emphasis Type="Italic">Rhodococcus ruber</Emphasis> strain gt1, possessing nitrile hydratase activity,on carbon supports

Rhodococcus ruber strain gt1, possessing nitrile hydratase activity, was immobilized by adsorption on carbon supports differing in structure and porosity. The adsorption capacity of the supports towards cells, the substrate of the nitrile hydratase reaction (acrylonitrile), and the product (acrylamide) was studied. Also, the effect of immobilization on nitrile hydratase activity of bacteria was investigated, and the operational stability of the immobilized biocatalyst was determined. It was shown that crushed and granulated active coals were more appropriate for immobilization than fibrous carbon adsorbents.     

Superiority of cobalt induced acrylonitril hydratase of Arthrobacter sp. IPCB-3 for conversion of acrylonitrile to acrylamide

Summary The activity of cobalt induced acrylonitrile hydratase was found to be 130% higher than the iron induced acrylonitrile hydratase in Arthrobaeter sp. IPCB-3. The activity of cobalt induced hydratase was not affected up to 6% (w/v) acrylonitrile and 25% (w/v) acrylamide. However, iron induced hydratase activity was significantly inhibited even at half the concentration of the above components. Such a higher tolerance for the substrate and the product makes the Arthrobacter sp. IPCB-3 a potential candidate for the commercial production of acrylamide.     

Rhodococcus pyridinovorans MW3, a bacterium producing a nitrile hydratase

Rhodococcus pyridinovorans MW3 was isolated from an arable land of manioc from the Congo for its ability to transform acrylonitrile to acrylamide. This strain contains a cobalt nitrile hydratase (NHase) showing high sequence homology with NHases so far described. The specific NHase activity was 97 U mg(-1) dry wt. NHase production by R. pyridinovorans MW3 was urea and Co-dependent. The NHase was active for acrylamide up to 60% (w/v) indicating its potential for acrylamide production.     

Construction of a New Shuttle Vector for Zymomonas mobilis

The culture conditions for Rhodococcus sp. N-774 cells showing high nitrile hydratase activity and the reaction conditions for acrylamide production by the resting cells were optimized. Thiamine was essential for the growth of the strain. Yeast extract and Fe^{2 +} or Fe^{3 +} remarkably promoted the formation of nitrile hydratase of the cells. The reaction proceeded optimally at temperatures below 30°C. Incubation for 1 hr at above 40°C resulted in inactivation of the enzyme. Through reaction at a temperature as low as 0°C, the inhibition and inactivation of the enzyme activity by the substrate, acrylonitrile, and the product, acrylamide, were remarkably reduced, and higher accumulation of acrylamide could be attained. Under the optimal conditions, a more than 20% (w/v) acrylamide solution was obtained with a conversion yield of nearly 100%. Thus, the aqueous acrylamide solution obtained showed a high enough quality for use for the commercial preparation of polyacrylamide.