里氏木霉纤维素酶的分离纯化及酶学性质

通过(NH4)2SO4分级沉淀、HiPrep 26/10 Desalting凝胶色谱脱盐、Source 15 Q阴离子交换色谱技术,里氏木霉(Rut C-30)纤维素酶主要组分得以初步分开,再经过Source 15 S阳离子交换色谱、HiPrep Sephacryl S-100 HR凝胶过滤色谱、Superdex 75 PrepGrade凝胶过滤色谱进一步分离纯化,得到2个纯化的内切葡聚糖酶组分EGⅡ、EGⅠ和一个外切葡聚糖酶组分CBHⅠ;经过SDS-PAGE电泳鉴定为电泳纯,测得相对分子质量分别为5.22×104,5.62×104和6.90×104。EGⅡ的最适反应pH是5.6,最适反应温度为65℃;EGⅠ的最适反应pH是4.4,最适反应温度为55℃;以羧甲基纤维素(CMC)为底物时,EGⅠ、EGⅡ的米氏常数(Km)分别为2.20 mg/mL、3.38 mg/mL。CBHⅠ的最适反应pH是5.8,最适反应温度为60℃,以对硝基苯基-β-D-纤维二糖苷(PNPC)为底物时,米氏常数(Km)为0.12 mg/mL。     

里氏木霉液体发酵产纤维素酶的研究

在摇瓶试验基础上,采用里氏木霉(Trichoderma reesei)HC-415菌株进行5L自控罐产纤维素酶深层发酵试验。在通气量为 0.2—0.6vvm、搅拌速度为 400r/min、发酵液pH控制在5.8—6.1的条件下,发酵液的羧甲基纤维素(CMC)酶酶活最高为325.0mg糖/ml,滤纸糖酶(FPA)酶活最高达17.9mg糖/ml。发酵周期为108h。所得冻干纤维素酶粉CMC酶活最高3111IU/g,FPA最高135IU/g ,对发酵液得率平均6.7g/L。酶活总收率CMC酶活平均78.2％,FPA酶活平均73.5％。     

里氏木霉内切葡萄糖苷酶Ⅳ在毕赤酵母中的表达

进行了内切葡萄糖苷酶Ⅳ（EGⅣ）在毕赤酵母（Pichia pastoris）表达系统中的表达。采用RT—PCR的方法从里氏木霉（Trichoderma reesei）中分离到eg4基因。将eg4基因与毕赤酵母表达载体pPICZαA连接,得到重组质粒pPICZαA-eg4。将该重组质粒线性化后转化毕赤酵母GS115,eg4基因通过同源重组被整合到毕赤酵母的染色体上,并处于酵母α因子的下游,得到重组菌株P.pastoris—EGⅣ1。在甲醇诱导下,重组菌株P.pastoris-EGⅣ1可以合成并分泌EGⅣ,培养液的CMC活力达到2．11U／mL。     

里氏木霉LW1固态发酵纤维素酶条件的研究

采用里氏木霉LW 1(Trichoderma.Reesei)固体发酵生产纤维素酶,研究了秸杆粉和麦麸用量、料水比、起始pH值、发酵温度和发酵时间对该菌株产纤维素酶活力的影响。试验结果表明,里氏木霉LW 1的适宜发酵条件为:在秸秆∶麦麸=1∶1,料水比为1∶2的前提条件下,培养温度28℃,发酵周期为72h,起始pH5.5时产酶活力最高。浸出液中FPA酶活为119.417u/g干物质,CMC酶活为452.433u/g干物质。     

里氏木霉重组t-PA的酶性质的研究

利用分光光度计对里氏木霉重组t-PA的性质进行了研究,结果表明该酶对高温较为敏感,60℃酶完全失活;在pH6.4~7.6范围内,作用时间的长短对酶活力影响不大,保持较大的酶活;Zn2+和Fe3+离子对其有抑制的作用,Mg2+、Ca2+、Cu2+、Fe2+、Mn2+、Na+、K+对酶有激活的作用。     

里氏木霉产纤维素酶研究进展

木质纤维素类生物质被认为是重要且可持续的可再生能源,其主要组成部分是纤维素.纤维素酶是一种能将纤维素分解为葡萄糖的复合酶,能有效地降解木质纤维素生物质.真菌、细菌、放线菌、酵母等多种微生物均可以产生纤维素酶,其中里氏木霉具有完整的纤维素酶系结构,常作为生物技术领域中一个重要菌株,广泛应用于纤维素酶的商业生产.介绍了纤维...     

里氏木霉及其纤维素酶高产菌株的研究进展

随着纤维素在能源、材料及化工等领域的广泛开发和应用,里氏木霉作为一种重要的产纤维素酶工业用菌种,越来越受到人们的广泛关注.为了提高其酶活,人们做了大量的工作,获得了一些相当好的突变株.对里氏木霉及其突变株的基因组进行研究,有助于人们理解其高效产酶的机制,同时也有利于构建其基因工程菌.介绍里氏木霉Trichoderma reesei 的背景及其部分高产纤维素酶突变株,并阐述近些年来对其突变株的基因组的研究进展.     

里氏木霉与米根霉混合固态发酵产纤维素酶

以里氏木霉及米根霉单菌固态发酵为对象,考察不同混合发酵形式对里氏木霉与米根霉混合固态发酵产纤维素酶的影响。结果表明:同时接种里氏木霉与米根霉,试验考察的两菌种接种量比1∶1(以孢子个数计)及5∶1条件下,两菌未产生明显协同产酶作用。米根霉延时(24 h)接种且菌种量比5∶1以及米根霉延时(48 h)接种且菌种量比1∶1,2种发酵形式产酶情况类似,滤纸酶活(FPA)及羧甲基纤维素酶(CMCase)酶活相对米根霉单菌发酵有所提高,而β-葡萄糖苷酶(β-GA)酶活相对里氏木霉单菌固态发酵结束时分别增加4.66及4.40倍,可以发现两菌产生一定协同作用。在米根霉延时(48 h)接种且菌种量比5∶1的发酵形式下,FPA及CMCase在发酵第7天酶活分别达到44.04 IU/g、627.14 U/g(以1 g干曲计),分别是里氏木霉固态单菌发酵产酶达到稳定期时酶活的1.36和1.63倍,两菌产生了有效的协同作用。     

里氏木霉表达异源中性内切纤维素酶蛋白以改善最佳酶活pH

为了提高里氏木霉中天然纤维素酶的最佳活性pH,本实验从特异腐质霉,灰腐质霉的变种,枯草芽孢杆菌LH中分别筛选并克隆了其含有的中性纤维素酶基因,将其置于里氏木霉cbh1启动子的启动下,在里氏木霉中进行异源表达。改造株在pH 6.0下酶活提升16%,pH 7.0下活性保留75%以上,而此时原始菌酶活残留20%。本实验所得的产中性纤维素酶里氏木霉基因改造株,由于其良好的中酸性活性表现,在食品,纺织,纸浆和造纸行业应也有良好的使用潜力。     

Stimulatory effect of oxidized cellulose on cellulase formation by Trichoderma reesei

Crystalline cellulase has been electrochemically oxidized to yield preparations containing various different percentages of oxidized end-groups. These celluloses have been used as carbon sources for growth and cellulase production by Trichoderma reesei . A low content of oxidized end groups in the celluloses (0.1–0.65%) stimulated cellulase production but not growth, whereas higher contents (> 1%) where inhibitory to both. The cellulolytic enzyme system secreted under stimulated conditions contained the same proportion of individual cellulase enzymes (cellobiohydrolase I and II, endoglucanase I) as the control, indicating a general stimulatory effect of oxidized cellulose. Activity of cellulases against oxidized celluloses in vitro was not stimulated, and only slightly inhibitory at high degrees of oxidation. The data support a potential role of cellulose oxidation in regulating cellulase formation by T. reesei .     

Purification and characterization of pectinesterase and polygalacturonase from Trichoderma reesei

Abstract Exopolygalacturonase, endopolygalacturonase and pectinesterase were separated from culture filtrates of Trichoderma reesei QM9414 by Sephadex chromatography. Exopolygalacturonase was characterized by specific cleavage of pectic acid to form d -galactopyranuronic acid, and by the hydrolysis of oligomers (highest reaction rate at pentamer). Polygalacturonase exhibited 2 pH-optima peaks (at 4.8 and 5.1) and 10 bands with enzyme activity by isoelectric focusing (IEF) (p I 4.6–8.5). Pectinesterase showed a pH-optimum at 7.6, and 6 enzyme-activity bands on an IEF zymogram which seemed identical with those of higher plants (tomato, alfalfa).     

Action of purified Trichoderma reesei cellulases on cotton fibers and yarn

In this work the possibility and potential of treating cotton fibers and yarns instead of fabrics with monocomponent cellulases was investigated. Different pretreatments on fibers were performed and tested in order to improve the accessibility of cotton to enzymatic modification. The enzymatic treatments were evaluated microscopically and by analysing the effects of treated fibers on spinnability, yarn evenness, tenacity and pilling. The accessibility of the cotton fibers for cellulases could be increased by different pretreatments. Steaming of fibers prior to enzymatic treatment was found to be an efficient way to increase hydrolysis levels. Cellulase treatments of carded yarns resulted in modification of yarn properties. Decrease in yarn hairiness was observed and the knitted fabric made of the treated yarn showed a lowered tendency towards pilling. In all cases endoglucanase activity rather than cellobiohydrolase activity was responsible for these modifications.     

Complexity of cellulases from Trichoderma reesei with acidic isoelectric points: A two-dimensional gel electrophoretic study using immunoblotting

Antibody specific to Trichoderma reesei cellulase (65 kDa, isoelectric point, pI, 7.7) shows immuno-cross reactivity with acidic hydrolase complexes containing other cellulases, (pI_app. 3.4–4.5) when tested under conditions of 2D-electrophoresis (1^st dim. PAGIF, 2^nd dim. SDS-PAGE) together with Western blotting. Degradation pattern of ¹⁴C(U)-labeled G₁–G₅ of the 65 kDa cellulase was followed by a 2-directional oligodextrin mapping procedure.Using preparative IEF, homologous antigen portions were detected in cellulases present within acidic hydrolase complexes showing mainly identical molar weight (M_r 65 kDa and 57 kDa) but a range of charge (pI 3.4–4.5). The pattern of acidic cellulases as found after analytical 2D-electrophoresis was reconstituted by preparative IEF (pI_app. 2.7–5.1) followed by SDS-PAGE separation. Homogeneous fractions (upon IEF) gave up to 8 different polypeptides per complex upon SDS-PAGE (M_r 70−20 kDa). Charge heterogeneity of individual acidic hydrolase complexes upon IEF is discussed as one reason for ‘multiplicity’ of acidic cellulases.     

Effect of endoglucanase and cellobiohydrolase from Trichoderma reesei on cellulose microfibril structure

Abstract Cellobiohydrolase (CBH, EC 3.2.91) was purified to homogeneity from Trichoderma reesei culture fluids by means of preparative isoelectric focussing (IEF). Its isoelectric points was 4.2. The degradation product of crystalline cellulose (Avicel and cotton) was predominantly cellobiose. The action of purified endoglucanase (EG) and CBH on cellulose microfibrils was followed by transmission electron microscopy (TEM) observations after Pt-C shadowing of the specimen. EG pretreatment of microfibrils resulted in submicrofibril formation. Addition of CBH induced the conversion of submicrofibrils into heterogeneous cellulose clusters and into homogeneous cellulose plaques. One structural effect of CBH was the increase in accessible cellulose surface area, possibly providing intermolecular entrace of water molecules between adjacent cellulose chains. Plaque formation is interpreted as a visible CBH action on crystalline cellulose to form swollen water-insoluble cellulose intermediates.     

Characterization of cellulases in an extracellular fraction from Trichoderma reesei under conditions of isoelectric focusing (IEF)

Abstract A cellulase-containing fraction present in the culture fluid of Trichoderma reesei grown on cellulose was obtained by fractionated centrifugation. The buoyant density of this fraction was D = 1.060 g/ml. Its ultrastructural properties, as detected by transmission electron microscopy, are given. The fraction consists of membrane vesicles attached to a carbohydrate polymer. This polymer is positive to Ruthenium red staining.
The effect of urea on the extraction and separation of acidic cellulases from this fraction is described. Linear gradient gels for both urea (up to 8.0 M urea) and polyacrylamide gels (up to 30%) were used to determine adequate separation conditions for isoelectric focusing (IEF) in a polyacrylamide gel matrix. The effect of urea on the extraction and separation conditions was tested by titration curves. In the presence of 6.0−8.0 M urea, the main cellulase-containing hydrolase complex (pI_app4.2) from this fraction is split into 3 isoenzymes and a further cellulase (pI 5.65).     

The competitive inhibition of Trichoderma reesei C30 cellobiohydrolase I by guanidine hydrochloride

TheP-nitrophenylcellobiosidase (PNPCase) activity of Trichoderma reesei cellobiohydrolase I (CBH I) was competitively inhibited by concentrations of guanidine hydrochloride (Gdn HC1) that did not affect the tryptophan fluorescence of this enzyme. The K_m of CBH I, 3.6 mM, was increased to 45.4 mM in the presence of 0.14 M Gdn HCl, the concentration that was required to inhibit the enzyme by 50%. A similar concentration of lithium chloride and urea had little effect on the PNPCase activity of CBH I. Maximal inhibition was pH dependent, occurring in the range of pH 4.0 to 5.0, which is in the range for maximal activity. Analysis of the inhibition data indicated that 1.2 molecules of Gdn HCl combine reversibly with I molecule of CBH I. Other hydrolases and proteases were also inhibited by Gdn HCl. It is suggested that the inhibition of CBH I by Gdn HCl occurs as a result of the interaction between the positively charged guanidinium group of Gdn HCl and the carboxylate group of glutamic acid 126, postulated to be in the catalytic center of this enzyme.     

里氏木霉分泌型表达载体的构建及绿色荧光蛋白的表达

【目的】构建里氏木霉分泌型表达载体,通过表达绿色荧光蛋白论证载体的可行性并初步观察绿色荧光蛋白在里氏木霉中的分泌过程。【方法】应用PCR及分子克隆技术将里氏木霉(Trichoderma reesei)纤维二糖水解酶(CBH1)的启动子及CBH1自身信号肽、终止子和潮霉素筛选基因依次插入骨架质粒pUC19中,构建出T.reesei表达载体Ppth15。将增强型绿色荧光蛋白(eGFP)基因装载入Ppth15中,获得eGFP表达载体Ppth15-eGFP。再将Ppth15-eGFP转化进T.reesei原生质体,通过潮霉素抗性筛选、基因组PCR检测等方法鉴定,获得阳性重组转化子。【结果】用PDA培养基培养阳性转化子2-3 d后,可在菌丝顶端、隔膜及培养基中清晰地观察到大量绿色荧光。【结论】表达载体构建成功且能够用于eGFP的表达,实验为进一步研究T.reesei表达其他基因提供了有效工具,同时为T.reesei胞外蛋白分泌的研究提供了参考。