A thermostable lipase produced by a newly isolated <Emphasis Type="Italic">Geotrichum</Emphasis>-like strain,R59

Growth and production of lipase by a new Geotrichum-like strain, R59, were studied. Production of extracellular lipase was substantially enhanced when the initial pH of the culture medium, types of carbon and nitrogen sources, substances probably stimulating the lipase biosynthesis, the temperature, and time of growth were optimized. Sucrose and triolein were the most effective carbon sources for lipase production. Maximum lipase activity (146 U/ml^–1) was obtained with urea as the nitrogen source. Growth at 30°C, an initial pH of 6.0 and incubation time of 48 h were found as optimum conditions for cell growth and production of lipase by Geotrichum-like strain R59. The enzyme was thermostable and exhibited very high activity after 1 h incubation at 60°C.     

The effect of temperature on growth and cellulase (β-1,4-endoglucanase) production in the compost fungusChaetomium thermophile var.dissitum

Chaetomium thermophile var.dissitum, isolated from an experimental urban refuse compost, had the following growth characteristics: Minimum temperature, 27±1°C; optimum, 45–50°C; maximum, 57±1°C; pH optimum 5.5–6.0.A number of carbohydrates could be used for growth, but cellulase formation measured with carboxymethylcellulose as substrate was initiated only on cellulose or xylan. With cellulose as the carbon source, cellulase accumulation in the culture filtrate followed closely that of growth, when the temperature was varied. pH optimum for the cellulase system was 5.0.The optimum temperature for cellulase activity with carboxymethylcellulose as substrate varied between 77°C with 1/2 h incubation time and 58°C with 10 h incubation time.With cotton as substrate, the optimum temperature was 58°C regardless of incubation time. Carboxymethylcellulose had a higher stabilizing effect on the enzyme than cotton. The temperature stability of the cellulase was highest at pH 6.0.     

Heterologous production of Aspergillus fumigatus keratinase in Pichia pastoris

Aspergillus fumigatus Fresenius was previously shown to grow in mineral medium containing chicken feather flour as carbon and nitrogen source. Substantial proteolytic keratin-degrading activity was present in the culture supernatant after 24–72 h of growth at 42 °C. The keratinase was successfully purified by a single ion exchange chromatographic procedure and had a molecular mass of 31 kDa as determined by SDS–PAGE. The keratinase cDNA was expressed in Pichia pastoris cells and the recombinant clones were shown to be able to produce substantial caseinolytic, azo-keratinolytic and keratinolytic activities. SDS–PAGE and Western-blotting analysis using antibody against keratinase of A. fumigatus showed the presence of a single protein in the culture supernatants of several recombinant P. pastoris cells. This protein had a molecular mass corresponding to that of the A. fumigatus keratinase. The enzyme production profile showed that theP. pastoris recombinant cells produced an increasing amount of proteolytic and azo-keratinolytic activities over a 72 h growth period. Dry weight determination analysis indicated that 10% of the keratin flour was hydrolysed over a 24 h incubation period with 510 U (caseinolytic activity) of the recombinant keratinase.     

Biosynthesis of a thermostable gellan lyase by newly isolated and characterized strain of Geobacillus stearothermophilus 98

The thermophilic strain able to degrade gellan was isolated from Bulgarian hot spring. According to its morphological and biochemical properties and by partial sequencing of its 16S rDNA, it was classified as Geobacillus stearothermophilus. It grew in a synthetic medium with gellan as the only carbon source with a specific growth rate of 0.69 h⁻¹ and generation time of 60 min. The strain produced thermostable gellan lyase extracellularly during exponential phase. Its synthesis was inducible; the enzyme was not registered in culture liquid without gellan. The enzyme activity was increased tenfold in conditions of continuous cultivation compared to data from batch fermentations and enzyme productivity was almost sixfold higher. The enzyme showed optimal activity at 75°C in a very large pH area 4–8.5. This enzyme is the first reported thermostable gellan lyase, its residual activity was 100% after 24 h incubation at 60°C and its half-life was 60 min at 70°C.     

Isolation of a mutant strain of Pseudomonas sp ATCC 31461 exhibiting elevated polysaccharide production

A mutant strain of the bacterium Pseudomonas sp. ATCC 31461 that exhibited elevated production of the polysaccharide gellan on glucose or corn syrup as a carbon source was isolated. Gellan production by the mutant strain was about twofold higher than its parent strain on glucose or corn syrup after 48 h of growth, and about 1.4-fold higher after 72 h. An increase in biomass production was not correlated with enhanced gellan synthesis by the mutant strain. The increased gellan production by the mutant strain on either carbon source resulted in an increase in its culture medium viscosity and the viscosity of the isolated polysaccharide produced by glucose-grown cells. No differences in the glucuronic acid content of the polysaccharides produced by the mutant and parent strains were observed. Journal of Industrial Microbiology & Biotechnology (2002) 29, 185–188 doi:10.1038/sj.jim.7000278 Received 13 February 2002/ Accepted in revised form 20 May 2002     

Investigation of lipase production by a new isolate of Aspergillus sp.

Fungi isolated from soil were screened for exogenous lipolytic activity. The highest lipase activity was found in a new soil isolate of Aspergillus sp. Some optimal cultural parameters influencing the growth and production of extracellular lipase from this Aspergillus sp. were investigated. The lipase yield was maximum on day 4 of incubation of the culture at pH 5.5 and 30 °C. When the medium was prepared using olive oil as carbon source and peptone as a nitrogen source, better lipase yields were obtained. Aeration enhanced growth and lipase production.     

Enzymatic properties of lipase and characteristics production byLactobacillus delbrueckii subsp.bulgaricus

Some properties of an extracellular lipase produced byLactobacillus delbrueckii subsp.bulgaricus were studied. Maximum enzyme activity was found against olive and butter oil as enzyme substrates. Addition of 9% acacia gum, 0.1% Na-deoxycholate and 0.01 M CaCl₂ to the enzyme reaction mixture increased-lipase activity from 5.3 to 14.5 (FFA/mg protein/minute) at pH 6.0 and at 40° C. Maximum lipase production was reached in the presence of glucose as a sole source of carbon, wheat bran as nitrogen source, olive oil as a sole lipid source and butyric acid as fatty acid supporting the growth medium. An initial pH value of the culture medium of 6.0 and a temperature of 35° C gave the highest lipolytic activity.     

Regulation of exoprotease production by temperature and oxygen in Vibrio alginolyticus

The production of an extracellular collagenase and an alkaline protease by Vibrio alginolyticus during stationary phase was inhibited by a temperature shift from 30 to 37°C and by a lack of oxygen. The stability of the exoproteases was unaffected by incubation at 37°C and aeration. The optimum growth temperature for the V. alginolyticus strain was 33.5°C Aeration enhanced the rate of growth of exponential phase cells. Temperature and oxygen did not affect the growth of stationary phase cells when the exoproteases were being produced. Macromolecular synthesis in stationary phase cells was not affected by temperature. There was no rapid release of the exoproteases after temperature shift down and chloramphenicol inhibited the production of the enzymes when added at time of temperature shift down from 37 to 30°C. The regulation of exoprotease production by temperature and oxygen was specific and has implications regarding the ecology of V. alginolyticus. Cerulenin, quinacrine and O-phenanthroline inhibited the production of the exoproteases.     

A lipase from a newly isolated thermophilicRhizopus rhizopodiformis

Two strains ofRhizopus rhizopodiformis that produced lipases in broth culture were isolated. Maximum lipase production (23 U/ml) was obtained after 72 h culture. Both the crude lipases were stable at 50°C for 30 min and at 45°C for 24 h. Maltose was the best carbon source and peptone the best nitrogen source for the production of lipases. Only glycerol and lecithin stimulated lipase production further.     

Effect of culture medium pH on bacterial gellan production.

The effect of the initial pH of the culture medium used in the production of the exopolysaccharide gellan by the bacterium Pseudomonas species ATCC 31461, when glucose or corn syrup served as the carbon source, was investigated. With glucose as the carbon source, exopolysaccharide formation was highest after 72 h of growth when the initial pH of the culture medium was 6.8 to 7.4. Polysaccharide production by the bacterial cells grown on corn syrup for 72 h was maximal when the initial pH of the medium was 7.0 or 7.2. Cell weights of the strain after 72 h tended to be higher for the glucose-grown cells than for the corn syrup-grown cells.     

Production of cellulase-free thermostable xylanases by an isolated strain of Aspergillus niger PPI, utilizing various lignocellulosic wastes

A strain of Aspergillus niger PPI having prolific xylanolytic potential was isolated and the optimum conditions for maximum xylanase production was studied, resulting in the following: 4% substrate concentration, 10% v/v inoculum size, 72 h of incubation and pH 3.5–4.5 at 28 °C. The production profile of xylanase was examined with various lignocellulosics and maximum yield was achieved with oat. The hemicellulose content of wastes was also determined and oatmeal was found to have maximum hemicellulose content followed by wheat straw, sugarcane bagasse, rice husk and gram residue respectively. The enzyme showed maximum activity at pH 4 and temperature 60 °C. However, maximum stability was achieved at pH 3.5 and temperature 55 °C. Cellulase activity was found altogether absent in the enzyme broth.     

Growth characteristics of an obligately psychrophilic Vibrio sp.

The growth characteristics of an obligately psychrophilic Vibrio sp. have been studied in a chemostat with glucose or lactose as the limiting substrate over a temperature range 0–23°C. Vibrio AF-1 has an optimum growth temperature of 15°C and maximum growth temperature which is dependent upon the carbon source. On glucose growth ceases at 20°C whereas on lactose growth continues to 23°C. Growth rate is also a function of the carbon source provided. When grown on glucose, fructose, sucrose, maltose and galactose _max values of 0.046 h^-1 at 15°C were recorded whereas on lactose, mannose, ribose and xylose _max values of 0.020 h^-1 were obtained. Substrate affinities (K _s ) for the 9 sugars also fall into 2 divisions as for _max and are temperature dependent. Those sugars which support a high growth rate have highest K _s values at 0°C whereas these which give a low growth rate show maximum affinities at 15°C. Vibrio AF-1 produces the maximum cell yield (0.6 g/g sugar consumed) at temperature <8°C irrespective of the carbon source utilised and correlated with maximum rates of sugar uptake and minimum O₂ consumption. Maintenance energy determination on glucose grown cells show that at 2° C 2% of the carbon input is used for maintenance whereas at 20°C the requirement increases to 10% of the carbon input.     

Production of α-galactosidase by a novel actinomycete <Emphasis Type="Italic">Streptomyces griseoloalbus</Emphasis> and its application in soymilk hydrolysis

α-Galactosidase production by a newly isolated actinomycete Streptomyces griseoloalbus under submerged fermentation was investigated. The influence of initial pH of medium, incubation temperature, inoculum age and inoculum size on α-galactosidase formation was studied. Various carbon sources were supplemented in the medium to study their effect on enzyme production. The influence of the concentration of locust bean gum on enzyme production also was optimized. Optimization of process parameters resulted in a highest α-galactosidase activity of 20.4 U/ml. The highest α-galactosidase activity was obtained when the fermentation medium with initial pH 6.0 and containing 1% locust bean gum as growth substrate was inoculated with 10% (v/v) of 72 h grown inoculum and incubated at 30°C. The hydrolysis of flatulence-causing oligosaccharides in soymilk by the enzyme was also investigated. Thin layer chromatographic analysis of enzyme-treated soymilk samples showed the complete hydrolysis of soy oligosaccharides liberating galactose, the final product.     

Effect of glycine betaine on the sucrose catabolism of an l-lysine producing mutant of Brevibacterium lactofermentum

Summary Effect of exogenous betaine on the growth of an l-lysine-producing mutant of Brevibacterium lactofermentum was examined in a medium containing different carbon sources such as glucose, fructose, or sucrose. The growth rate decreased significantly with a rise in temperature when sucrose was the carbon source. Both the specific sucrose consumption rate and the invertase activity of the mutant decreased with the culture period when the cultivation temperature was 35°C. The addition of betaine restored both growth and invertase activity on medium containing sucrose as the carbon source at 35°C. Betaine protected the invertase activity against the inactivating effects of high temperature in vitro. Furthermore, the addition of exogenous invertase into production medium at 35°C restored the growth rate to that at 32°C. These results indicated that growth decreased on medium containing sucrose at 35°C due to a decrease in invertase activity, and that addition of betaine was an effective way to enhance growth on this medium at a higher temperature. Offprint requests to: Y. Kawahara     

Effect of temperature and glucose supply on the production of polyunsaturated fatty acids by the fungus Mortierella alpina CBS 343.66 in fermentor cultures

The fungus Mortierella alpina CBS 343.66 was grown in a fermentor at different pH, temperatures and supplies of carbon source (glucose) in order to optimize the culture conditions for rapid biomass and lipid production with a high proportion of polyunsaturated fatty acids, especially arachidonic acid (AA). Good growth and lipid production with 31% AA was obtained at pH 6.5 and 25°C. A temperature decrease to 18°C gave a significantly higher degree of polyunsaturated fatty acids. Eicosapentaenoic acid was not detected at 25°C, but was formed at 18°C at about 10%. The AA concentration but was similar for 18°C about 10%. The AA concentration was similar for 18°C and 25°C (around 30%): 18°C allowed relatively good growth and had a beneficial effect on the fungus morphology, i.e. pellets were formed. Best lipid production and a AA content of up to 33% was achieved at an excess of glucose (carbon source) and a deficit of ammonium chloride (nitrogen source). The percentage of AA of the total fatty acid composition was constant as ong as glucose was present. At glucose exhaustion, the proportion of AA increased to 57%. The increase in AA corresponded to a decrease in palmitic acid, stearic acid and oleic acid. Correspondence to: G. Molin     

Improved xylanase production from a haloalkalophilic Staphylococcus sp. SG-13 using inexpensive agricultural residues

The production of an alkali-stable xylanase, with dual pH optima, from haloalkalophilic Staphylococcus sp. SG-13 has been enhanced using agro-residues in submerged fermentation and a biphasic growth system. The agro-residues such as wheat bran, sugarcane bagasse, corncobs and poplar wood when used as sole carbon source, improved the xylanase yield by five-fold as compared to xylose and xylan. Staphylococcus sp. SG-13 also produced equally good amounts of xylanase when grown simply in deionized water (pH 8.0) supplemented with agro-residues as sole carbon source. In the biphasic growth system (lower layer containing agricultural residue set in agar medium with liquid medium above it), the prime substrate, wheat bran (1% w/v), resulted in maximum xylanase production of 4525 U l^–1 (pH 7.5) and 4540 U l^–1 (pH 9.2) at an agar: broth ratio of 4.0 after 48 h of incubation at 37 °C under static conditions. In general, the cost-effective agro-residues were found to be more suitable inducers for xylanase production over expensive substrates like xylan.     

Growth conditions of a pectinolyticAspergillus fumigatus for degumming of natural fibres

Summary Optimum growth conditions forA. fumigatus strain 4 when citric pectin was the sole carbon source were at a temperature of 45°C, pH 4.0 and an incubation time from 36 to 42h. Under these conditions no cellulase activity was found. When orange pulp was the sole carbon source, optimum polygalacturonase activities were found when the fungus was cultured for 36 h at 45°C and a pH 3.0 to 4.5.     

Partial characterization ofAspergillus fumigatus polygalacturonases for the degumming of natural fibers

Summary Aspergillus fumigatus strain 4, cultured on citrus pectin as the sole carbon source, produced polygalacturonases whose activity was optimum at 65°C and pH 3.5–4.5. The enzymes presented a bimodal thermostability for 10 min, but not 60 min, of incubation. Polygalacturonases showed pH stability between 3.0 to 9.0. The enzymes were stable when stored at 4–6°C for 90 days, but their activity was reduced by 24% when they were stored at 26–30°C. Orange pulp was the best pectic carbon source tested for the production of pectinases capable of retting ramie fibers. The reutilization of these enzymes was possible, suggesting the viability of industrial use of pectinases for degumming ramie fibers.     

Production of amylase by Arthrobacter psychrolactophilus

Arthrobacter psychrolactophilus ATCC 700733 grew with a doubling time of 1.5–2.3 h (22°C) and produced up to 0.2 units/mL (soluble starch assay) of extracellular amylase in tryptic soy broth without dextrose (TSBWD) containing 0.5% or 1.0% (w/v) soluble starch or maltose as the fermentable substrate. Time-course experiments in media containing soluble starch as substrate showed that amylolytic activity appeared in cultures at 24 h (after exponential growth had ceased), reached peak levels in 72–96 h, and declined rapidly after reaching peak levels. Peak levels were highest in TSBWD containing 1.0% soluble starch. Proteolytic activity appeared at about the same time as amylolytic activity and increased during the period of amylase production. Significant amylase production was not observed in cultures in TSBWD with 0.5% glucose or in cultures grown at 28°C, but low levels of amylase were observed in TSBWD cultures grown at 19–23°C which contained no added carbohydrate. A single band of activity was observed after electrophoresis of supernatant fractions in non-denaturing gels, followed by in situ staining for amylolytic activity. The amylase possessed a raw starch-binding domain and bound to uncooked corn, wheat or potato starch granules. It was active in the Phadebas assay for -amylase. Activity was maximum on soluble starch at a temperature between 40°C and 50°C. The amylase after purification by affinity chromatography on raw starch granules exhibited two starch-binding protein bands on SDS gels of 105 kDa and 26 kDa.     

Production of poly-3-hydroxybutyrate by Bacillus sp. JMa5 cultivated in molasses media

A strain of Bacillus sp. coded JMa5 was isolated from molasses contaminated soil. The strain was able to grow at a temperature as high as 45°C and in 250 g/l molasses although the optimal growth temperature was 35–37°C. Cell density reached 30 g/l 8 h after inoculation in a batch culture with an initial concentration of 210 g/l molasses. Under fed-batch conditions, the cells grew to a dry weight of 70 g/l after 30 h of fermentation. The strain accumulated 25–35%, (w/w) polyhydroxybutyrate (PHB) during fermentation. PHB accumulation was a growth-associated process. Factors that normally promote PHB production include high ratios of carbon to nitrogen, and carbon to phosphorus in growth media. Low dissolved oxygen supply resulted in sporulation, which reduced PHB contents and dry weights of the cells. It seems that sporulation induced by reduced supply of nutrients is the reason that PHB content is generally low in the Bacillus strain.