Oxidation of Ferrous Iron and Elemental Sulfur by Thiobacillus ferrooxidans

The oxidation of ferrous iron and elemental sulfur by Thiobacillus ferrooxidans that was absorbed and unabsorbed onto the surface of sulfur prills was studied. Unadsorbed sulfur-grown cells oxidized ferrous iron at a rate that was 3 to 7 times slower than that of ferrous iron-grown cells, but sulfur-grown cells were able to reach the oxidation rate of the ferrous iron-adapted cells after only 1.5 generations in a medium containing ferrous iron. Bacteria that were adsorbed to sulfur prills oxidized ferrous iron at a rate similar to that of unadsorbed sulfur-grown bacteria. They also showed the enhancement of ferrous iron oxidation activity in the presence of ferrous iron, even though sulfur continued to be available to the bacteria in this case. An increase in the level of rusticyanin together with the enhancement of the ferrous iron oxidation rate were observed in both sulfur-adsorbed and unadsorbed cells. On the other hand, sulfur oxidation by the adsorbed bacteria was not affected by the presence of ferrous iron in the medium. When bacteria that were adsorbed to sulfur prills were grown at a higher pH (ca. 2.5) in the presence of ferrous iron, they rapidly lost both ferrous iron and sulfur oxidation capacities and became inactive, apparently because of the deposition of a jarosite-like precipitate onto the surface to which they were attached.     

Partial Removal of Lipopolysaccharide from Thiobacillus ferrooxidans Affects Its Adhesion to Solids

Conditions for the partial removal of lipopolysaccharide (LPS) from Thiobacillus ferrooxidans are described. Raising the pH of the solution containing the cells from pH 1.5 to pH 6.8 to 8.0 releases about 50% of the LPS without cell lysis. The release of LPS begins at pH 3.5, and it was not affected by EDTA concentration. Partial removal of LPS exposed higher amounts of a 40-kDa outer membrane protein in the bacteria, as detected by a dot immunoassay employing an antiserum against the T. ferrooxidans surface protein. This higher protein exposure and the reduced LPS content increased the hydrophobicity of the cell surface, as determined by an increased adhesion (50%) to hydrophobic sulfur prills and ¹⁴C-dodecanoic acid binding (2.5-fold) compared with control cells. In addition, adhesion of radioactively labeled microorganisms to a sulfide mineral was inhibited (40%) in the presence of previously added LPS. Our results suggest that not only LPS but also surface proteins probably play important roles in T. ferrooxidans adhesion to solid surfaces.     

Investigation of energy gene expressions and community structures of free and attached acidophilic bacteria in chalcopyrite bioleaching

In order to better understand the bioleaching mechanism, expression of genes involved in energy conservation and community structure of free and attached acidophilic bacteria in chalcopyrite bioleaching were investigated. Using quantitative real-time PCR, we studied the expression of genes involved in energy conservation in free and attached Acidithiobacillus ferrooxidans during bioleaching of chalcopyrite. Sulfur oxidation genes of attached A. ferrooxidans were up-regulated while ferrous iron oxidation genes were down-regulated compared with free A. ferrooxidans in the solution. The up-regulation may be induced by elemental sulfur on the mineral surface. This conclusion was supported by the results of HPLC analysis. Sulfur-oxidizing Acidithiobacillus thiooxidans and ferrous-oxidizing Leptospirillum ferrooxidans were the members of the mixed culture in chalcopyrite bioleaching. Study of the community structure of free and attached bacteria showed that A. thiooxidans dominated the attached bacteria while L. ferrooxidans dominated the free bacteria. With respect to available energy sources during bioleaching of chalcopyrite, sulfur-oxidizers tend to be on the mineral surfaces whereas ferrous iron-oxidizers tend to be suspended in the aqueous phase. Taken together, these results indicate that the main role of attached acidophilic bacteria was to oxidize elemental sulfur and dissolution of chalcopyrite involved chiefly an indirect bioleaching mechanism.     

Kinetic quantitation of sulfur-oxidizing bacteria adsorbed on sulfur

A hyperbolic equation was fitted to the time dependence of Thiobacillus ferrooxidans adsorption on sulfur. This procedure allowed the determination of an asymptote value which represented a free cell count at equilibrium. The data thus obtained were used to calculate the numbers of adsorbed bacteria without attainment of equilibrium. The maximum number of adsorbed bacteria based on the Langmuir isotherm was 8.3 × 10⁹ per g of sulfur.     

Ferric iron reduction by Thiobacillus ferrooxidans at extremely low pH-values

When ferrous iron and sulfur were supplied, cells of T. ferrooxidans in a well-aerated medium started growth by oxidizing ferrous iron. After ferrous iron depletion a lagphase followed before sulfur oxidation started. During sulfur oxidation at pH-values below 1.3 (±0,2) the ferrous iron concentration increased again, although the oxygen saturation of the medium amounted to more than 95%. The number of viable cells did not increase. Thus resting cells of T. ferrooxidans, which are oxidizing sulfur to maintain their proton balance, reduce ferric to ferrous iron. The ferrous iron-oxidizing system seemed to be inhibited at pH-values below 1.3. At a pH-value of 1.8 the ferrous iron was reoxidized at once. A scheme for the linkage of iron- and sulfur metabolism is discussed.     

The effect of different Fe2+ concentrations in culture media on the recycling of ground tyre rubber by Acidithiobacillus ferrooxidans YT-1

Waste rubber has posed challenging environmental and disposal problems across the world. This study focused on the microbial reclaiming of ground tyre rubber (GTR) by Acidithiobacillus ferrooxidans YT-1 cultured in media with variable Fe²⁺ concentrations. The Acidithiobacillus ferrooxidans YT-1 strain with the ability of oxidizing sulfur and reclaiming waste rubber was isolated and identified. Toxicity tests of different rubber and additives in tyre rubber compounds to microorganisms was quantitatively investigated. After desulfurization, there were many small colonies on the surface of the desulfurizated GTR (DGTR), due to surface degradation by A. ferrooxidans YT-1. The amount of small colonies increased and sulfur content decreased with the increase of Fe²⁺ concentrations in the media, implying that Fe²⁺ concentration had a great influence on the degradation ability of A. ferrooxidans YT-1. A medium with a high Fe²⁺ concentration was good for growth of A. ferrooxidans YT-1. Compared with styrene butadiene rubber (SBR)/GTR blends, the tensile strength and elongation at the break of the SBR/DGTR blends were significantly improved. The scanning electron microscope (SEM) photographs of the fracture surface further indicated a good coherency between DGTR and the SBR matrix. These results revealed that A. ferrooxidans YT-1 cultured in a medium with a high Fe²⁺ concentration could improve the reclaiming efficiency of waste rubber.     

Ferric iron reduction by Thiobacillus ferrooxidans at extremely low pH-values

When ferrous iron and sulfur were supplied, cells of T. ferrooxidans in a well-aerated medium started growth by oxidizing ferrous iron. After ferrous iron depletion a lagphase followed before sulfur oxidation started. During sulfur oxidation at pH-values below 1.3 (±0,2) the ferrous iron concentration increased again, although the oxygen saturation of the medium amounted to more than 95%. The number of viable cells did not increase. Thus resting cells of T. ferrooxidans, which are oxidizing sulfur to maintain their proton balance, reduce ferric to ferrous iron. The ferrous iron-oxidizing system seemed to be inhibited at pH-values below 1.3. At a pH-value of 1.8 the ferrous iron was reoxidized at once. A scheme for the linkage of iron- and sulfur metabolism is discussed.     

An Exported Rhodanese-Like Protein Is Induced during Growth of Acidithiobacillus ferrooxidans in Metal Sulfides and Different Sulfur Compounds

By proteomic analysis we found a 21-kDa protein (P21) from Acidithiobacillus ferrooxidans ATCC 19859 whose synthesis was greatly increased by growth of the bacteria in pyrite, thiosulfate, elemental sulfur, CuS, and ZnS and was almost completely repressed by growth in ferrous iron. After we determined the N-terminal amino acid sequence of P21, we used the available preliminary genomic sequence of A. ferrooxidans ATCC 23270 to isolate the DNA region containing the p21 gene. The nucleotide sequence of this DNA fragment contained a putative open reading frame (ORF) coding for a 23-kDa protein. This difference in size was due to the presence of a putative signal peptide in the ORF coding for P21. When p21 was cloned and overexpressed in Escherichia coli, the signal peptide was removed, resulting in a mature protein with a molecular mass of 21 kDa and a calculated isoelectric point of 9.18. P21 exhibited 27% identity and 42% similarity to the Deinococcus radiodurans thiosulfate-sulfur transferase (rhodanese; EC 2.8.1.1) and similar values in relation to other rhodaneses, conserving structural domains and an active site with a cysteine, both characteristic of this family of proteins. However, the purified recombinant P21 protein did not show rhodanese activity. Unlike cytoplasmic rhodaneses, P21 was located in the periphery of A. ferrooxidans cells, as determined by immunocytochemical analysis, and was regulated depending on the oxidizable substrate. The genomic context around gene p21 contained other ORFs corresponding to proteins such as thioredoxins and sulfate-thiosulfate binding proteins, clearly suggesting the involvement of P21 in inorganic sulfur metabolism in A. ferrooxidans.     

The extremophile Acidithiobacillus ferrooxidans possesses a c-di-GMP signalling pathway that could play a significant role during bioleaching of minerals

Aims: The primary goal of this study was to characterize the existence of a functional c‐di‐GMP pathway in the bioleaching bacterium Acidithiobacillus ferrooxidans. Methods and Results: A bioinformatic search revealed that the genome sequence of At. ferrooxidans ATCC 23270 codes for several proteins involved in the c‐di‐GMP pathway, including diguanylate cyclases (DGC), phosphodiesterases and PilZ effector proteins. Overexpression in Escherichia coli demonstrated that four At. ferrooxidans genes code for proteins containing GGDEF/EAL domains with functional DGC activity. MS/MS analysis allowed the identification of c‐di‐GMP in nucleotide preparations obtained from At. ferrooxidans cells. In addition, c‐di‐GMP levels in cells grown on the surface of solid energetic substrates such as sulfur prills or pyrite were higher than those measured in ferrous iron planktonic cells. Conclusions: At. ferrooxidans possesses a functional c‐di‐GMP pathway that could play a key role in At. ferrooxidans biofilm formation during bioleaching processes. Significance and Impact of the Study: This is the first global study about the c‐di‐GMP pathway in an acidophilic bacterium of great interest for the biomining industry. It opens a new way to explore the regulation of biofilm formation by biomining micro‐organisms during the bioleaching process.     

Kinetic studies on elemental sulfur oxidation by Acidithiobacillus ferrooxidans: sulfur limitation and activity of free and adsorbed bacteria

The kinetics of sulfur oxidation by Acidithiobacillus ferrooxidans in shaking flasks and a 10-L reactor was studied. The observed linearity of growth and sulfur oxidation was explained by sulfur limitation. Total cell yield was not significantly different for exponential growth as compared to growth during the sulfur-limiting phase. Kinetic studies of sulfur oxidation by growing and nongrowing bacteria indicated that both free and adsorbed bacteria oxidize sulfur. Changes in the number of free bacteria rather than cells adsorbed on sulfur were better predictors of the kinetics of sulfur oxidation, indicating that the free bacteria were performing sulfur oxidation. The active growth phase always followed adsorption of bacteria on sulfur; however, the special metabolic role of adsorbed bacteria was unclear. Their activity in sulfur solubilization was considered.     

Kinetics of growth and elemental sulfur oxidation in batch culture of thiobacillus ferrooxidans

The kinetics of oxidation of elemental sulfur by Thiobacillus ferrooxidans in a batch reactor was followed by measuring the concentration of adsorbed cells on the sulfur surface, the concentration of free cells in liquid medium, and the amount of sulfur oxidized. As the elemental sulfur was oxidized to sulfate, the liquid-phase concentration of free cells continued to increase with time, whereas the surface concentration of adsorbed cells per unit weight of sulfur approached a limiting value, i.e., the maximum adsorption capacity. During sulfur oxidation, there was a close correlation between the concentrations of adsorbed and free cells, and these data were well correlated with the Langmuir isotherm. The observed rates of batch growth and sulfur oxidation were consistent with a kinetic model, assuming that the growth rate of batch growth and sulfur oxidation were consistent with a kinetic model. Assuming that the growth rate of adsorbed bacteria is proportional to the product of the concentration of adsorbed cells and the fraction of adsorption sites unoccupied by cells. The kinetic and stoichiometric parameters appearing in the model were evaluated using the experimental data and were compared with parameters determined previously for a few metal sulfides. (c) 1994 John Wiley & Sons, Inc.     

Leaching of Zinc Sulfide by Thiobacillus ferrooxidans: Bacterial Oxidation of the Sulfur Product Layer Increases the Rate of Zinc Sulfide Dissolution at High Concentrations of Ferrous Ions

This paper reports the results of leaching experiments conducted with and without Thiobacillus ferrooxidans at the same conditions in solution. The extent of leaching of ZnS with bacteria is significantly higher than that without bacteria at high concentrations of ferrous ions. A porous layer of elemental sulfur is present on the surfaces of the chemically leached particles, while no sulfur is present on the surfaces of the bacterially leached particles. The analysis of the data using the shrinking-core model shows that the chemical leaching of ZnS is limited by the diffusion of ferrous ions through the sulfur product layer at high concentrations of ferrous ions. The analysis of the data shows that diffusion through the product layer does not limit the rate of dissolution when bacteria are present. This suggests that the action of T. ferrooxidans in oxidizing the sulfur formed on the particle surface is to remove the barrier to diffusion by ferrous ions.     

Existence of a Hydrogen Sulfide:Ferric Ion Oxidoreductase in Iron-Oxidizing Bacteria

The existence of a hydrogen sulfide:ferric ion oxidoreductase, which catalyzes the oxidation of elemental sulfur with ferric ions as an electron acceptor to produce ferrous and sulfite ions, was assayed with washed intact cells and cell extracts of various kinds of iron-oxidizing bacteria, such as Thiobacillus ferrooxidans 13598, 13661, 14119, 19859, 21834, 23270, and 33020 from the American Type Culture Collection, Leptospirillum ferrooxidans 2705 and 2391 from the Deutsche Sammlung von Mikroorganismen, L. ferrooxidans BKM-6-1339 and P3A, and moderately thermophilic iron-oxidizing bacterial strains BC1, TH3, and Alv. It was found that hydrogen sulfide:ferric ion oxidoreductase activity comparable to that of T. ferrooxidans AP19-3 was present in all iron-oxidizing bacteria tested, suggesting a wide distribution of this enzyme in iron-oxidizing bacteria.     

Attachment of Acidithiobacillus ferrooxidans and Leptospirillum ferriphilum cultured under varying conditions to pyrite, chalcopyrite, low-grade ore and quartz in a packed column reactor

The attachment of Acidithiobacillus ferrooxidans and Leptospirillum ferriphilum spp. grown on ferrous medium or adapted to a pyrite mineral concentrate to four mineral substrata, namely, chalcopyrite and pyrite concentrates, a low-grade chalcopyrite ore (0.5 wt%) and quartzite, was investigated. The quartzite represented a typical gangue mineral and served as a control. The attachment studies were carried out in a novel particle-coated column reactor. The saturated reactor containing glass beads, which were coated with fine mineral concentrates, provided a quantifiable surface area of mineral concentrate and maintained good fluid flow. A. ferrooxidans and Leptospirillum spp. had similar attachment characteristics. Enhanced attachment efficiency occurred with bacteria grown on sulphide minerals relative to those grown on ferrous sulphate in an ore-free environment. Selective attachment to sulphide minerals relative to gangue materials occurred, with mineral adapted cultures attaching to the minerals more efficiently than ferrous grown cultures. Mineral-adapted cultures showed highest levels of attachment to pyrite (74% and 79% attachment for A. ferrooxidans and L. ferriphilum, respectively). This was followed by attachment of mineral-adapted cultures to chalcopyrite (63% and 58% for A. ferrooxidans and L. ferriphilum, respectively). A. ferrooxidans and L. ferriphilum exhibited lower levels of attachment to low-grade ore and quartz relative to the sulphide minerals.     

Differential Protein Expression during Growth of Acidithiobacillus ferrooxidans on Ferrous Iron, Sulfur Compounds, or Metal Sulfides

A set of proteins that changed their levels of synthesis during growth of Acidithiobacillus ferrooxidans ATCC 19859 on metal sulfides, thiosulfate, elemental sulfur, and ferrous iron was characterized by using two-dimensional polyacrylamide gel electrophoresis. N-terminal amino acid sequencing and mass spectrometry analysis of these proteins allowed their identification and the localization of the corresponding genes in the available genomic sequence of A. ferrooxidans ATCC 23270. The genomic context around several of these genes suggests their involvement in the energetic metabolism of A. ferrooxidans. Two groups of proteins could be distinguished. The first consisted of proteins highly upregulated by growth on sulfur compounds (and downregulated by growth on ferrous iron): a 44-kDa outer membrane protein, an exported 21-kDa putative thiosulfate sulfur transferase protein, a 33-kDa putative thiosulfate/sulfate binding protein, a 45-kDa putative capsule polysaccharide export protein, and a putative 16-kDa protein of unknown function. The second group of proteins comprised those downregulated by growth on sulfur (and upregulated by growth on ferrous iron): rusticyanin, a cytochrome c₅₅₂, a putative phosphate binding protein (PstS), the small and large subunits of ribulose biphosphate carboxylase, and a 30-kDa putative CbbQ protein, among others. The results suggest in general a separation of the iron and sulfur utilization pathways. Rusticyanin, in addition to being highly expressed on ferrous iron, was also newly synthesized, as determined by metabolic labeling, although at lower levels, during growth on sulfur compounds and iron-free metal sulfides. During growth on metal sulfides containing iron, such as pyrite and chalcopyrite, both proteins upregulated on ferrous iron and those upregulated on sulfur compounds were synthesized, indicating that the two energy-generating pathways are induced simultaneously depending on the kind and concentration of oxidizable substrates available.     

Importance of Extracellular Polymeric Substances from Thiobacillus ferrooxidans for Bioleaching

Leaching bacteria such as Thiobacillus ferrooxidans attach to pyrite or sulfur by means of extracellular polymeric substances (EPS) (lipopolysaccharides). The primary attachment to pyrite at pH 2 is mediated by exopolymer-complexed iron(III) ions in an electrochemical interaction with the negatively charged pyrite surface. EPS from sulfur cells possess increased hydrophobic properties and do not attach to pyrite, indicating adaptability to the substrate or substratum.     

Enzyme-Linked Immunofiltration Assay To Estimate Attachment of Thiobacilli to Pyrite

An enzyme-linked immunofiltration assay (ELIFA) has been developed in order to estimate directly and specifically Thiobacillus ferrooxidans attachment on sulfide minerals. This method derives from the enzyme-linked immunosorbent assay but is performed on filtration membranes which allow the retention of mineral particles for a subsequent immunoenzymatic reaction in microtiter plates. The polyclonal antiserum used in this study was raised against T. ferrooxidans DSM 583 and recognized cell surface antigens present on bacteria belonging to the genus Thiobacillus. This antiserum and the ELIFA allowed the direct quantification of attached bacteria with high sensitivity (10⁴ bacteria were detected per well of the microtiter plate). The mean value of bacterial attachment has been estimated to be about 10⁵ bacteria mg⁻¹ of pyrite at a particle size of 56 to 65 μm. The geometric coverage ratio of pyrite by T. ferrooxidans ranged from 0.25 to 2.25%. This suggests an attachment of T. ferrooxidans on the pyrite surface to well-defined limited sites with specific electrochemical or surface properties. ELIFA was shown to be compatible with the measurement of variable levels of adhesion. Therefore, this method may be used to establish adhesion isotherms of T. ferrooxidans on various sulfide minerals exhibiting different physicochemical properties in order to understand the mechanisms of bacterial interaction with mineral surfaces.     

A new solid medium for the isolation and enumeration of Thiobacillus ferrooxidans and acidophilic heterotrophic bacteria

A solid medium (FeTSB) was developed for the simultaneous isolation and enumeration of the iron-oxidising bacterium Thiobacilluls ferrooxidans and acidophilic heterotrophic bacteria. The medium consisted of ferrous sulfate, tryptone soya broth and basal salts, solidified with agarose, although bacteriological agar could be substituted for some strains. The medium has been used to isolate bacteria from natural environments and also in laboratory studies of characterised strains. The factors which influence the success of colony growth on solid media are discussed.     

Surface Chemistry of Thiobacillus ferrooxidans Relevant to Adhesion on Mineral Surfaces

Thiobacillus ferrooxidans cells grown on sulfur, pyrite, and chalcopyrite exhibit greater hydrophobicity than ferrous ion-grown cells. The isoelectric points of sulfur-, pyrite-, and chalcopyrite-grown cells were observed to be at a pH higher than that for ferrous ion-grown cells. Microbe-mineral interactions result in change in the surface chemistry of the organism as well as that of the minerals with which it has interacted. Sulfur, pyrite, and chalcopyrite after interaction with T. ferrooxidans exhibited a significant shift in their isoelectric points from the initial values exhibited by uninteracted minerals. With antibodies raised against sulfur-grown T. ferrooxidans, pyrite- and chalcopyrite-grown cells showed immunoreactivity, whereas ferrous ion-grown cells failed to do so. Fourier transform infrared spectroscopy of sulfur-grown cells suggested that a proteinaceous new cell surface appendage synthesized in mineral-grown cells brings about adhesion to the solid mineral substrates. Such an appendage was found to be absent in ferrous ion-grown cells as it is not required during growth in liquid substrates.