Inorganic carbon and pH effect on growth and lipid productivity of Tetraselmis suecica and Chlorella sp (Chlorophyta) grown outdoors in bag photobioreactors

There has been considerable interest in cultivation of green microalgae (Chlorophyta) as a source of lipid that can alternatively be converted to biodiesel. However, almost all mass cultures of algae are carbon-limited. Therefore, to reach a high biomass and oil productivities, the ideal selected microalgae will most likely need a source of inorganic carbon. Here, growth and lipid productivities of Tetraselmis suecica CS-187 and Chlorella sp were tested under various ranges of pH and different sources of inorganic carbon (untreated flue gas from coal-fired power plant, pure industrial CO₂, pH-adjusted using HCl and sodium bicarbonate). Biomass and lipid productivities were highest at pH 7.5 (320?±?29.9 mg biomass L^?1 day^?1and 92?±?13.1 mg lipid L^?1 day^?1) and pH 7 (407?±?5.5 mg biomass L^?1 day^?1 and 99?±?17.2 mg lipid L^?1 day^?1) for T. suecica CS-187 and Chlorella sp, respectively. In general, biomass and lipid productivities were pH 7.5?>?pH 7?>?pH 8?>?pH 6.5 and pH 7?>?pH 7.5?=?pH 8?>?pH 6.5?>?pH 6?>?pH 5.5 for T. suecica CS-187 and Chlorella sp, respectively. The effect of various inorganic carbon on growth and productivities of T. suecica (regulated at pH?=?7.5) and Chlorella sp (regulated at pH?=?7) grown in bag photobioreactors was also examined outdoor at the International Power Hazelwood, Gippsland, Victoria, Australia. The highest biomass and lipid productivities of T. suecica (51.45?±?2.67 mg biomass L^?1 day^?1 and 14.8?±?2.46 mg lipid L^?1 day^?1) and Chlorella sp (60.00?±?2.4 mg biomass L^?1 day^?1 and 13.70?±?1.35 mg lipid L^?1 day^?1) were achieved when grown using CO₂ as inorganic carbon source. No significant differences were found between CO₂ and flue gas biomass and lipid productivities. While grown using CO₂ and flue gas, biomass productivities were 10, 13 and 18 %, and 7, 14 and 19 % higher than NaHCO₃, HCl and unregulated pH for T. suecica and Chlorella sp, respectively. Addition of inorganic carbon increased specific growth rate and lipid content but reduced biomass yield and cell weight of T. suecica. Addition of inorganic carbon increased yield but did not change specific growth rate, cell weight or content of the cell weight of Chlorella sp. Both strains showed significantly higher maximum quantum yield (F_v/F_m) when grown under optimum pH.     

Vitamin E (alpha-tocopherol) production by the marine microalgae Dunaliella tertiolecta and Tetraselmis suecica in batch cultivation

Batch experiments with Dunaliella tertiolecta and Tetraselmis suecica were performed to investigate alpha-tocopherol (alpha-T) production in time, in order to assess the effect of light availability per cell on the production of this antioxidant. In D. tertiolecta alpha-T content increased during growth, in other words, as the cell density increased and the light availability per cell decreased. In T. suecica the pattern was different: alpha-T content was highest during the exponential phase, decreased significantly during the linear phase and increased again towards the end of the cultivation. Chlorophyll (chl-a) content of T. suecica cells decreased after the exponential phase, instead of the expected increase typically observed in shade-adapted cells, suggesting that the culture was nutrient limited. An experiment with extra nutrients showed that chl-a and alpha-T content increased significantly during both the linear and the stationary phase when compared with values in nutrient-deficient conditions. No correlation between alpha-T and chl-a was observed. Our results indicate that diminished light availability does not limit alpha-T production in D. tertiolecta and T. suecica, opening up the possibility of using high cell density, light-limited cultures for the production of this commercially interesting compound.     

Mitochondrial NDP kinase from Dunaliella tertiolecta (Chlorophyceae, Chlorophyta)

A cDNA (DtNDK1) encoding a nucleoside diphosphate (NDP) kinase with a putative mitochondrial targeting signal sequence was previously isolated from the halo‐tolerant green alga Dunaliella tertiolecta. When expressed in Saccharomyces cerevisiae, the processed DtNDK1 enzyme was specifically localized to mitochondria. The present study reports several biochemical characteristics of the mitochondrial NDP kinase from D. tertiolecta. The mature protein was expressed as either N‐ or C‐terminal hexahistidine‐tagged protein and purified to homogeneity by affinity chromato‐graphy. Native gel electrophoresis and sedimentation velocity in sucrose density gradients showed that the active enzyme consisted of a hexamer. The enzyme, with a pH optimum of 7, showed the highest specificity to dCDP (K_m= 50 μmol/L) and the highest turnover towards the synthesis of UTP (up to 140‐fold higher). The present study also provides evidence that purified DtNDK1 proteins are capable of transferring a phosphate group to another protein.     

Growth of Dunaliella tertiolecta and associated bacteria in photobioreactors

The aim of this study was to test three flat-plate photobioreactor configurations for cultivation of marine green alga Dunaliella tertiolecta under non-axenic growth conditions and to characterize and quantify the associated bacteria. The photobioreactor cultivations were conducted using tap water-based media. Static mixers intended to enhance mixing and light utilization did not generally increase algal growth at the low light intensities used. The maximum biomass concentration (measured as volatile suspended solids) and maximum specific growth rate achieved in the flat plate with no mixer were 2.9?g?l(-1) and 1.3?day(-1), respectively. Based on quantitative polymerase chain reaction, bacterial growth followed the growth of D. tertiolecta. Based on 16S rDNA amplification and denaturing gradient gel electrophoresis profiling, heterotrophic bacteria in the D. tertiolecta cultures mainly originated from the non-axenic algal inocula, and tap water heterotrophs were not enriched in high chloride media (3?% salinity). Bacterial communities were relatively stable and reproducible in all flat-plate cultivations and were dominated by Gammaproteobacteria, Flavobacteria, and Alphaproteobacteria.     

PCR-identification of Dunaliella salina (Volvocales, Chlorophyta) and its growth characteristics

The saline pond microalga, Dunaliella salina (Dunal) Teod. maintained in De Walne's (basal) medium under laboratory conditions was confirmed by amplifying the chromosomal DNA of the microalga by PCR with specific primers MA1 and MA2. Seaweed extracts obtained from Sargassum wightii and Ulva lactuca were amended separately at 1.0%, 1.5%, 2.0% and 2.5% levels to the basal medium in order to assess their potential on the growth and concentration of pigments, viz. Chl a, Chl b and beta-carotene of the alga. beta-Carotene was isolated and visible absorption spectrum was taken at 443 and 475 nm confirmed the presence of 9-cis-beta-carotene and all-trans-beta-carotene isomers. Maximum yield, highest division rate (mu) and highest pigment concentrations were observed in the cells grown in 1.5% S. wightii and 2.0% U. lactuca amended medium and these cells were subjected to DAPI staining. The results of epifluorescence microscopy and image analysis revealed a significant enhancement of the cell and nuclear area of the microalgae.     

Physiological characterization of Dunaliella sp. (Chlorophyta, Volvocales) from Yucatan, Mexico

Physiological responses of Dunaliella salina and Dunaliella viridis, isolated from solar saltworks on the Yucatan Peninsula, were studied. Optimal growth temperature for D. salina was 22 degrees C (3.06 x 10(6) cells mL(-1)) and 26 degrees C for D. viridis (4.04 x 10(6)cells mL(-1)). Total carotenoid content in D. salina increased with temperature to a maximum of 35.14 pg cell(-1) at 38 degrees C. Dunaliella salina alpha-carotene and beta-carotene content was 0.083+/-0.003 and 0.598+/-0.020 mg 100g dry wt(-1) respectively, whereas lower values were found in D. viridis cultured under same experimental conditions (0.018+/-0.002 and 0.136+/-0.012 mg 100g dry wt(-1) respectively). The highest specific growth rate in D. salina was obtained at 10% NaCl (0.28 d(-1)), while its cell volume increased from 524 to 2066.93 microm(3) when cultured from 10% to 35% NaCl. Maximum photosynthetic rates were attained when increasing from optimal growing temperature to 30 degrees C for D. viridis (108 n mol O(2)microg chl alpha h(-1)) and D. salina (139 n mol O(2)microg chl alpha h(-1)). Photosynthetic responses to temperature variations indicated physiological adjustments in both species, with higher acclimation in D. salina. Evaluation of physiological attributes of these species will be used for to carry out mass cultivation.     

Effect of nutrients on growth and lipid accumulation in the green algae Dunaliella tertiolecta

Production of biofuel from algae is dependent on the microalgal biomass production rate and lipid content. Both biomass production and lipid accumulation are limited by several factors, of which nutrients play a key role. In this research, the marine microalgae Dunaliella tertiolecta was used as a model organism and a profile of its nutritional requirements was determined. Inorganic phosphate PO4(3-) and trace elements: cobalt (Co2+), iron (Fe3+), molybdenum (Mo2+) and manganese (Mn2+) were identified as required for algae optimum growth. Inorganic nitrogen in the form of nitrate NO3- instead of ammonium (NH4+) was required for maximal biomass production. Lipids accumulated under nitrogen starvation growth condition and this was time-dependent. Results of this research can be applied to maximize production of microalgal lipids in optimally designed photobioreactors.     

Hyposalinity induces significant polar lipid remodeling in the marine microalga Dunaliella tertiolecta (Chlorophyceae)

Journal of Applied Phycology - Marine microalgae often live in a fluctuating environment including a decrease in salinity caused by global warming induced sea ice melting and freshwater inflows....     

Occurrence of jasmonic acid in Dunaliella (Dunaliellales, Chlorophyta)

The occurrence of jasmonic acid and related compounds in Dunaliella species was investigated using gas-liquid chromatography/mass spectroscopy (GCY MS). Jasmonic acid was identified in the ethyl acetate soluble-acidic fraction of Dunaliella tertiolecta and Dunaliella salina (Dunal) Teodoresco, The concentration of jasmonic acid in D. salina. which is extremely halophilic, was much higher than that in D. tertiolecta Butcher, These results indicate that jasmonic acid might play an important role in salt-tolerance in Dunaliella.     

Assessment of key biological and engineering design parameters for production of Chlorella zofingiensis (Chlorophyceae) in outdoor photobioreactors

For the design of a large field of vertical flat plate photobioreactors (PBRs), the effect of four design parameters—initial biomass concentration, optical path length, spacing, and orientation of PBRs—on the biochemical composition and productivity of Chlorella zofingiensis was investigated. A two-stage batch process was assumed in which inoculum is generated under nitrogen-sufficient conditions, followed by accumulation of lipids and carbohydrates in nitrogen-deplete conditions. For nitrogen-deplete conditions, productivity was the most sensitive to initial biomass concentration, as it affects the light availability to individual cells in the culture. An initial areal cell concentration of 50 g m^?2 inoculated into 3.8-cm optical path PBR resulted in the maximum production of lipids (2.42?±?0.02 g m^?2 day^?1) and carbohydrates (3.23?±?0.21 g m^?2 day^?1). Productivity was less sensitive to optical path length. Optical path lengths of 4.8 and 8.4 cm resulted in similar areal productivities (biomass, carbohydrate, and lipid) that were 20 % higher than a 2.4-cm optical path length. Under nitrogen-sufficient conditions, biomass productivity was 48 % higher in PBRs facing north–south during the winter compared to east–west, but orientation had little influence on biomass productivity during the spring and summer despite large differences in insolation. An optimal spacing could not be determined based on growth alone because a tradeoff was observed in which volumetric and PBR productivity increased as space between PBRs increased, but land productivity decreased.     

Factors affecting the growth and the oil accumulation of marine microalgae, Tetraselmis suecica

Biomass production and oil productivity in microalgae culture are the most important key factors for algal biodiesel production. However, proper culture condition for the biomass production of microalgae is different from that for the oil production of microalgae. A study on the biomass production of Tetraselmis suecica using various light intensities and nitrate concentrations as growth factors was carried out to evaluate proper culture conditions in 20-L batch culture. The effect of nitrate depletion on the oil accumulation was also evaluated with two-stage culture. It took 5 days to reach the stationary phase for the cultures of T. suecica on the light intensities of 108.9 and 133.1 μmol m(-2 )s(-1) with biomass of 0.89 and 0.88 g dcw L(-1), respectively. Biomass productions of 1.07 and 1.00 g dcw L(-1) were obtained with the nitrate concentrations of 18.6 and 24.7 mg L(-1), respectively. The two-stage culture increased oil contents from 7.6 to 17.3% (w/w) and contents of C(16)-C(18) fatty acids from 540.2 to 720.5 mg g(-1) oil. The predominant fatty acid was palmitic acid (C(16:0)) in nitrate depletion group, however, oleic acid (C(18:1)) was predominated in nitrate added groups. The two-stage culture enhanced overall oil productivity of 18.7 mg g(-1) day(-1) which is higher than that of 12.2 mg g(-1) day(-1) in single-stage culture.     

Genotype versus phenotype variability in Chlorella and Micractinium (Chlorophyta, Trebouxiophyceae)

The most recent revision of the genus Chlorella, based on biochemical and SSU rDNA analyses, suggested a reduction to a set of four "true" spherical Chlorella species, while a growing number of morphologically different species such as Micractinium (formerly Micractiniaceae) were found to cluster within the clade of "true"Chlorella. In this study, the generic concept in Chlorellaceae to Chlorella and Micractinium was evaluated by means of combined SSU and ITS-2 rDNA sequence analyses and biotests to induce development of bristles on the cell wall. Molecular phylogenetic analyses of Chlorella and Micractinium strains confirmed their separation into two different genera. In addition, non-homoplasious synapomorphies (NHS) and compensatory base changes (CBC) in the secondary structures of SSU and ITS-2 rDNA sequences were found for both genera using this approach. The Micractinium clade can be differentiated into three different genotypes. Using culture medium of the rotifer Brachionus calyciflorus, phenotypic plasticity in Chlorella and Micractinium was studied. Non-bristled Micractinium cells developed bristles during incubation with Brachionus culture medium, whereas Chlorella did not produce bristles. Grazing experiments with Brachionus showed the rotifer preferred to feed on non-bristled cells. The dominance of colonies versus solitary cells in the Micractinium culture was not correlated with the "Brachionus factor". These results suggest that morphological characteristics like formation of bristles represent phenotypic adaptations to the conditions in the ecosystem.     

Survival in the dark: strategies adopted by Tetraselmis indica (Chlorodendrophyceae,Chlorophyta)

The adaptive strategy of Tetraselmis indica to survive darkness was evaluated over a period of 182 days. Resting cells formation and reduction in catabolic activity facilitated dark survival and their rejuvenation. The occurrence of thick-walled cells (type 1) and thin-walled cells with the condensed chloroplast (type 2) in light-dark and dark conditions respectively indicated differential resting cell formation. The dissolved organic carbon remained nearly constant throughout the dark period signifying T. indica did not favour heterotrophy. Upon re-illumination of dark-adapted cells, the lag phase lengthened from 2 to 28 days when darkness period increased from 8 to 182 days, respectively. However, this negative influence on growth was compensated by an increase in growth rate from 0.35 to 0.95 d^?1. This resurgence capability of T. indica after six months of dark exposure and distinctive resting cell formation indicate a differential population sustenance mechanism. Further elucidation of dark adaptability and survival strategies in T. indica may have significance in ecological and evolutionary processes.     

Productivity, CO2/O2 exchange and hydraulics in outdoor open high density microalgal (Chlorella sp.) photobioreactors operated in a Middle and Southern European climate

Two variants of open photobioreactors were operated at surface-to-volume ratios up to 170 m⁻¹. The mean values for July and September obtained for photobioreactor PB-1 of 224 m² culture area (length 28 m, inclination 1.7%, thickness of algal culture layer 6 mm), operated in Třeboň (49^∘N), Czech Republic, were: net areal productivity, P _net = 23.5 and 11.1 g dry weight (DW) m⁻² d⁻¹; net photosynthetic efficiency (based on PAR – Photosynthetic Active Radiation), η = 6.48 and 5.98%. For photobioreactor PB-2 of 100 m² culture area (length 100 m, inclination 1.6%, thickness of algal culture layer 8 mm) operated in Southern Greece (Kalamata, 37^∘N) the mean values for July and October were: P _net = 32.2 and 18.1 g DW m⁻² d⁻¹, η = 5.42 and 6.07%. The growth rate of the alga was practically linear during the fed-batch cultivation regime up to high biomass densities of about 40 g DW L⁻¹, corresponding to an areal density of 240 g DW m⁻² in PB-1 and 320 g DW m⁻² in PB-2. Night biomass loss (% of the daylight productivity, P _L) caused by respiration of algal cells were: 9–14% in PB-1; 6.6–10.8% in PB-2. About 70% of supplied CO₂ was utilized by the algae for photosynthesis. The concentration of dissolved oxygen (DO) increased from about 12 mg L⁻¹ at the beginning to about 35 mg L⁻¹ at the end of the 100 m long path of suspension flow in PB-2 at noon on clear summer days. Dissipation of hydraulic energy and some parameters of turbulence in algal suspension on culture area were estimated quantitatively.     

Effect of Mg, Si, and Sr on growth and antioxidant activity of the marine microalga Tetraselmis suecica

Efforts to increase the productivity of microalgal cultures have been focused on the improvement of photobioreactors, but little attention has been paid to the nutritional requirements of microalgae in order to improve culture media formulation. In this study, the main goal was obtaining a high productivity for Tetraselmis suecica (Chlorophyta) in semicontinuous culture by adding magnesium (Mg), silicon (Si), and strontium (Sr) at concentrations from 0.01 to 10 mM; at the time, the effect on steady-state cell density, biochemical composition, and antioxidant activity of T. suecica was evaluated. Because productivity is higher in high-density cultures, the work was focused many times to cell density. Mg (3 mM) and Sr (0.1 mM) added separately reached the highest steady-state cell density (7.0?×?10⁶?±?0.4 cells mL^?1) in comparison to control (4.2?±?0.1 cells mL^?1), but simultaneous addition had a synergic effect, achieving 8.7?×?10⁶?±?0.6 cells mL^?1. Silicon (3 mM) significantly affected the steady-state cell density, reaching 6.0?±?0.3 cells mL^?1 and increased the cell ash-free dry weight, reaching 127?±?7.9 pg cell^?1 in comparison to control (102.7?±?5.0 pg cell^?1), resulting in an ash-free dry weight productivity of 0.75?±?0.07 g?L^?1 day^?1. The highest fatty acids content and antioxidant activity, measured by 2, 2-diphenyl-1-picrylhydrazyl (DPPH) method were obtained with Sr 10 mM. Sr treatments showed a high correlation (R ²?=?0.98) between DPPH inhibition and polyphenolic content, explaining its high antioxidant activity. Therefore, the addition of Mg, Si, and Sr to culture medium of T. suecica is recommended to achieve high steady-state cell density in semicontinuous cultures.     

Lipid accumulation and growth of Chlorella zofingiensis in flat plate photobioreactors outdoors

Culturing microalgae using natural sunlight is an effective way to reduce the cost of microalgae-based biodiesel production. In order to evaluate the feasibility of culturing Chlorella zofingiensis outdoors for biodiesel production, effects of nitrogen limitation and initial cell concentration on growth and lipid accumulation of this alga were investigated in 60 L flat plate photobioreactors outdoors. The highest μmax and biomass productivity obtained was 0.994 day(-1) and 58.4 mg L(-1)day(-1), respectively. The lipid content was much higher (54.5% of dry weight) under nitrogen limiting condition than under nitrogen sufficient condition (27.3%). With the increasing initial cell concentrations, the lipid contents declined, while lipid concentrations and productivities increased. The highest lipid content, lipid concentration, and lipid productivity obtained was 54.5%, 536 mg L(-1) and 22.3 mg L(-1)day(-1), respectively. This study demonstrated that it was possible to culture C. zofingiensis under outdoor conditions for producing biodiesel feedstock.     

Effects of NaCl and KNO3 concentrations on the abscisic acid content of Dunaliella sp. (Chlorophyta)

Abscisic acid (ABA) is a hormone which has a number of roles during the life cycle of a plant. We demonstrated the occurrence of ABA in a halotolerant green alga, Dunaliella sp. isolated from a salt pond near Adelaide, South Australia, using thin layer chromatography (TLC), high performance liquid chromatography (HPLC) and gas chromatography-mass spectrometry (GC-MS). The variation of cellular ABA and protein content during the growth of an axenic clonal culture of Dunaliella sp. was investigated under different concentrations of NaCl and KNO₃.Experimental results can be summarized as follow: (1) ABA content was changed with the growth stage of culture: A rapid increase in ABA content was observed in the logarithmic phase. After this, the content rapidly decreased to very low values. (2) ABA content was also affected by the NaCl concentration. The content had a minimum value at the NaCl concentration (15%) where growth rate was maximal, and higher values at higher or lower concentrations of NaCl. (3) The ABA content also increased with decreasing nitrogen concentration of the medium.     

Growth-associated biosynthesis of astaxanthin in heterotrophic Chlorella zofingiensis (Chlorophyta)

The green microalga Chlorella zofingiensis can produce the ketocarotenoid astaxanthin under heterotrophic culture conditions. Here we report the growth-associated biosynthesis of astaxanthin in this biotechnologically important alga. With glucose as sole carbon and energy source, C. zofinginesis grew fast in the dark with rapid exhaustion of nitrogen and carbon sources from media, leading to a high specific growth rate (0.034 h⁻¹). Cultures started at a cell concentration of about 3.4 × 10⁹ cells l⁻¹ reached, after 6 days, standing biomass values of 1.6 × 10¹¹ cells or 8.5 g dry weight l⁻¹. Surprisingly, the biosynthesis of astaxanthin was found to start at early exponential phase, independent of cessation of cell division. A general trend was observed that the culture conditions benefiting cell growth also benefited astaxanthin accumulation, indicating that astaxanthin was a growth-associated product in this alga. The maximum cell dry biomass and astaxanthin yield were 11.75 g l⁻¹ and 11.14 mg l⁻¹ (about 1 mg g⁻¹), simultaneously obtained in the fed-batch culture with a combined glucose–nitrate mixture addition, which were the highest ever reported in dark-heterotrophic algal cultures. The possible reasons why dark-heterotrophic C. zofingiensis could produce astaxanthin during the course of cell growth were discussed.     

Comparison of suitable protein measurement for Thalassiosira weissflogii (Bacillariophyta) and Tetraselmis chuii (Chlorophyta)

To perform effective measurement of the protein contents, it is necessary to apply the most suitable extraction technique. We compared protein extraction techniques for two microalgal species with entirely different cell wall structures, such as diatom Thalassiosira weissflogii and green flagellate Tetraselmis chuii, using mechanical, physical, and chemical extraction methods. Our results showed that in Th. weissflogii, the control treatment without extraction and mechanical disruption using ultrasonication was sufficient to disrupt its brittle cell wall, resulting in the protein yield of 19.03 and 19.46% of dry weight (DW), respectively. In case of Te. chuii, the chemical extraction using 6% trichloroacetic acid at 95°C was the most suitable extraction method, resulting in the protein yield of 23.78% of DW. Therefore, the most suitable extraction technique must be individually selected for each species depending on their cell wall properties.