Conversion of membrane lipid acyl groups to triacylglycerol and formation of lipid bodies upon nitrogen starvation in biofuel green algae Chlorella UTEX29

Algal lipids are ideal biofuel sources. Our objective was to determine the contributors to triacylglycerol (TAG) accumulation and lipid body formation in Chlorella UTEX29 under nitrogen (N) deprivation. A fivefold increase in intracellular lipids following N starvation for 24 h confirmed the oleaginous characteristics of UTEX29. Ultrastructural studies revealed increased number of lipid bodies and decreased starch granules in N-starved cells compared to N-replete cells. Lipid bodies were observed as early as 3 h after N removal and plastids collapsed after 48 h of stress. Moreover, the identification of intracellular pyrenoids and differences in the expected nutritional requirements for Chlorella protothecoides (as UTEX29 is currently classified) led us to conduct a phylogenetic study using 18S and actin cDNA sequences. This indicated UTEX29 to be more phylogenetically related to Chlorella vulgaris. To investigate the fate of different lipids after N starvation, radiolabeling using ¹⁴C-acetate was used. A significant decrease in ¹⁴C-galactolipids and phospholipids matched the increase in ¹⁴C-TAG starting at 3 h of N starvation, consistent with acyl groups from structural lipids as sources for TAG under N starvation. These results have important implications for the identification of key steps controlling oil accumulation in N-starved biofuel algae and demonstrate membrane recycling during lipid body formation.     

Effect of triarimol on sterol and fatty acid composition of three species of Chlorella

The concentration of triarimol giving ca 50% inhibition of growth was different for each of 3 species of Chlorella [C. emersonii, 1 mg/l. (1.5 × 10^?6 M), C. ellipsoidea 10 mg/l. (3 × 10^?5 M), C. sorokiniana, 2 mg/l. (6 × 10^?6 M)]. The total lipid of 3 species of Chlorella grown in a culture medium containing triarimol were analysed for chlorophyll, fatty acids and sterol composition. Growth rates were studied in the presence of different concentrations of triarimol. The growth rates of the 3 species were differentially inhibited by triarimol. The growth of Chlorella sorokiniana was 50% inhibited by 2 mg/l. triarimol but 20 mg/l. did not produce a cessation of growth. The greatest inhibition of growth rates and chlorophyll content was observed in Chlorella emersonii. The quantity of unsaturated fatty acids was increased by triarimol treatment in all 3 species of Chlorella. Triarimol strongly inhibited 14α-demethylation in Chlorella emersonii, and C. ellipsoidea and less in C. sorokiniana, resulting in accumulation of 14α-methyl sterols. Triarimol also inhibited the second alkylation of the side chain in C. ellipsoidea and C. emersonii. The introduction of the 22-double bond was inhibited in all 3 species of Chlorella studied. Although some differences were apparent, the effect of triarimol was quite similar to that of triparanol and AY-9944 in these 3 species of Chlorella.     

An alternative high-throughput staining method for detection of neutral lipids in green microalgae for biodiesel applications

A simple and high-throughput method for determining in situ intracellular neutral lipid accumulation in Chlorella ellipsoidea and Chlorococcum infusionum with flow cytometry and confocal microscopy was established by employing different solvents and a lipophilic dye, Nile red. Seven different organic solvents, acetic acid, dimethyl sulfoxide (DMSO), acetone, methanol, ethanol, n-hexane, and chloroform at different concentrations ranging from 0 to 80% (v/v) were tested. The fluorescence signal for neutral lipids was collected with a 586/42 emission filter (PE-A) and the maximum fluorescence intensity (% grandparent) was measured as 74.01 ± 4.82% for Chlorella and 70.1 ± 5.52% for Chlorococcum at 30% acetic acid (v/v). The statistical analysis of Nile red-stained cells showed a high coefficient of variation (CV), standard deviation (SD), mean, and median values in the acetic acid-based staining method, followed by DMSO, n-hexane and chloroform. Confocal microscopy revealed a high rate of accumulation of cytosolic neutral lipids when stained with Nile red and other organic solvents. Higher lipid accumulation in Fesupplemented conditions was also detected and a maximum lipid content of 57.36 ± 0.41% (4-fold) in Chlorella and 48.20 ± 0.43% (4-fold) in Chlorococcum were measured at 0.001 g/L of ferrous sulfate (FeSO₄). High fluorescence intensity (75.16 ± 0.24% in Chlorella and 72.24 ± 1.07% in Chlorococcum) in Fe-treated cells confirmed the efficiency of the staining procedure.     

Morphological and phylogenetic study of algal partners associated with the lichen-forming fungus Porpidia crustulata from the Guancen Mountains, northern China

The algal photobiont of the lichen Porpidia crustulata from the Guancen Mountains was successfully cultivated under axenic conditions and tentatively designated as Chlorella sp. GC. The phylogenetic analysis of ribulose bisphosphate carboxylase (rbcL) and internal transcribed spacer (ITS) nucleotide sequence data revealed that this alga is closely related to C. sorokiniana. There are clear morphological differences between Chlorella sp. GC associated with Porpidia crustulata and the free-living C. sorokiniana, the former having a larger central pyrenoid. Based on our genetic and morphological characterization, the Chlorella photobiont of Porpidia crustulata is distinct from closely related Chlorella species.     

Enhancement of extraplastidic oil synthesis in Chlamydomonas reinhardtii using a type‐2 diacylglycerol acyltransferase with a phosphorus starvation–inducible promoter

When cultivated under stress conditions, many plants and algae accumulate oil. The unicellular green microalga Chlamydomonas reinhardtii accumulates neutral lipids (triacylglycerols; TAGs) during nutrient stress conditions. Temporal changes in TAG levels in nitrogen (N)‐ and phosphorus (P)‐starved cells were examined to compare the effects of nutrient depletion on TAG accumulation in C. reinhardtii. TAG accumulation and fatty acid composition were substantially changed depending on the cultivation stage before nutrient starvation. Profiles of TAG accumulation also differed between N and P starvation. Logarithmic‐growth‐phase cells diluted into fresh medium showed substantial TAG accumulation with both N and P deprivation. N deprivation induced formation of oil droplets concomitant with the breakdown of thylakoid membranes. In contrast, P deprivation substantially induced accumulation of oil droplets in the cytosol and maintaining thylakoid membranes. As a consequence, P limitation accumulated more TAG both per cell and per culture medium under these conditions. To enhance oil accumulation under P deprivation, we constructed a P deprivation‐dependent overexpressor of a Chlamydomonas type‐2 diacylglycerol acyl‐CoA acyltransferase (DGTT4) using a sulphoquinovosyldiacylglycerol 2 (SQD2) promoter, which was up‐regulated during P starvation. The transformant strongly enhanced TAG accumulation with a slight increase in 18 : 1 content, which is a preferred substrate of DGTT4. These results demonstrated enhanced TAG accumulation using a P starvation–inducible promoter.     

Rapid Induction of Lipid Droplets in Chlamydomonas reinhardtii and Chlorella vulgaris by Brefeldin A

Algal lipids are the focus of intensive research because they are potential sources of biodiesel. However, most algae produce neutral lipids only under stress conditions. Here, we report that treatment with Brefeldin A (BFA), a chemical inducer of ER stress, rapidly triggers lipid droplet (LD) formation in two different microalgal species, Chlamydomonas reinhardtii and Chlorella vulgaris. LD staining using Nile red revealed that BFA-treated algal cells exhibited many more fluorescent bodies than control cells. Lipid analyses based on thin layer chromatography and gas chromatography revealed that the additional lipids formed upon BFA treatment were mainly triacylglycerols (TAGs). The increase in TAG accumulation was accompanied by a decrease in the betaine lipid diacylglyceryl N,N,N-trimethylhomoserine (DGTS), a major component of the extraplastidic membrane lipids in Chlamydomonas, suggesting that at least some of the TAGs were assembled from the degradation products of membrane lipids. Interestingly, BFA induced TAG accumulation in the Chlamydomonas cells regardless of the presence or absence of an acetate or nitrogen source in the medium. This effect of BFA in Chlamydomonas cells seems to be due to BFA-induced ER stress, as supported by the induction of three homologs of ER stress marker genes by the drug. Together, these results suggest that ER stress rapidly triggers TAG accumulation in two green microalgae, C. reinhardtii and C. vulgaris. A further investigation of the link between ER stress and TAG synthesis may yield an efficient means of producing biofuel from algae.     

Two-stage heterotrophic and phototrophic culture strategy for algal biomass and lipid production

A two-stage heterotrophic and phototrophic culture strategy for algal biomass and lipid production was studied, wherein high density heterotrophic cultures of Chlorellasorokiniana serve as seed for subsequent phototrophic growth. The data showed growth rate, cell density and productivity of heterotrophic C.sorokiniana were 3.0, 3.3 and 7.4 times higher than phototrophic counterpart, respectively. Hetero- and phototrophic algal seeds had similar biomass/lipid production and fatty acid profile when inoculated into phototrophic culture system. To expand the application, food waste and wastewater were tested as feedstock for heterotrophic growth, and supported cell growth successfully. These results demonstrated the advantages of using heterotrophic algae cells as seeds for open algae culture system. Additionally, high inoculation rate of heterotrophic algal seed can be utilized as an effective method for contamination control. This two-stage heterotrophic phototrophic process is promising to provide a more efficient way for large scale production of algal biomass and biofuels.     

Enhancement of thiamine release during synthetic mutualism between <Emphasis Type="Italic">Chlorella sorokiniana</Emphasis> and <Emphasis Type="Italic">Azospirillum brasilense</Emphasis> growing under stress conditions

Thiamine release during synthetic mutualism between Chlorella sorokiniana co-immobilized in alginate beads with the microalgae growth-promoting bacterium Azospirillum brasilense was measured under stress conditions of pH, light intensity, and nitrogen starvation in short-term experiments. Thiamine release in the co-immobilized treatment was significantly higher at acidic pH compared to thiamine released by either microorganism alone. Under slightly alkaline pH, C. sorokiniana released the highest amount of thiamine. At stressful pH 6, the co-immobilized treatment released a higher quantity of thiamine than the sum of thiamine released by either microorganisms when immobilized separately. Release of thiamine by C. sorokiniana alone or co-immobilized was light intensity dependent; with higher the light intensity, more thiamine was released. Extreme light intensity negatively affected growth of the microalgae and release of thiamine. Nitrogen starvation during the first 24 h of culturing negatively affected release of thiamine by both microorganisms, where C. sorokiniana was more severely affected. Partial or continuous nitrogen starvation had similar negative effects on C. sorokiniana, but co-immobilization improved thiamine release. These results indicate that thiamine is released during synthetic mutualism between C. sorokiniana and A. brasilense, and this happens specifically during the alleviation of pH stress in the microalgae.     

Positive correlation between superoxide dismutase and resistance to paraquat toxicity in the green alga Chlorella sorokiniana

Paraquat (10–30 μm) exerted a dose-dependent and light-dependent toxicity on Chlorella sorokiniana. Paraquat was also seen to increase the superoxide dismutase content of these cells and to cause the appearance of a new electrophoretically distinct isozyme. Cells grown in the absence of paraquat contained one manganese-superoxide dismutase and two iron-superoxide dismutases, while the paraquat-grown cells contained an additional manganese-superoxide dismutase. Cells which were grown in the presence of 25 μm Paraquat, and which therefore possessed elevated levels of superoxide dismutase, were resistant to 30 μm Paraquat, whereas control cells were bleached and killed by this level of Paraquat. Electron micrography and chemical analysis revealed that Paraquat decreased the starch content of the cells and caused a failure of dividing cells to separate. It appears that Paraquat increases the photoproduction of O₂^? in C. sorokiniana and that an increase in the cell content of superoxide dismutase is an adaptive response which provides protection against this herbicide.     

A Constitutive Enzyme System for Glucose Transport by Chlorella sorokiniana

It was found that the transport system for glucose (as measured by deoxyglucose uptake) in the high temperature strain of Chlorella (strain 07-11-05 or C. sorokiniana) was constitutive and the rate of uptake did not increase upon incubation of autotrophically grown cells with either deoxyglucose or glucose. The uptake obeyed Michaelis-Menten type kinetics with a concentration of 200 micromolar for half-saturation. The maximum rate of uptake was nearly 10 times faster per cell (at 38 C) than that reported for any other Chlorella. This rapid accumulation of deoxyglucose causes the passive efflux to become significant compared to the pump-driven influx and nonlinear uptake appears even after only 3 to 4 minutes.     

RCB-mediated chlorophagy caused by oversupply of nitrogen suppresses phosphate-starvation stress in plants

Inorganic phosphate (Pi) and nitrogen (N) are essential nutrients for plant growth. We found that a five-fold oversupply of nitrate rescues Arabidopsis (Arabidopsis thaliana) plants from Pi-starvation stress. Analyses of transgenic plants that overexpressed GFP-AUTOPHAGY8 showed that an oversupply of nitrate induced autophagy flux under Pi-depleted conditions. Expression of DIN6 and DIN10, the carbon (C) starvation-responsive genes, was upregulated when nitrate was oversupplied under Pi starvation, which suggested that the plants recognized the oversupply of nitrate as C starvation stress because of the reduction in the C/N ratio. Indeed, formation of Rubisco-containing bodies (RCBs), which contain chloroplast stroma and are induced by C starvation, was enhanced when nitrate was oversupplied under Pi starvation. Moreover, autophagy-deficient mutants did not release Pi (unlike wild-type plants), exhibited no RCB accumulation inside vacuoles, and were hypersensitive to Pi starvation, indicating that RCB-mediated chlorophagy is involved in Pi starvation tolerance. Thus, our results showed that the Arabidopsis response to Pi starvation is closely linked with N and C availability and that autophagy is a key factor that controls plant growth under Pi starvation.

Disturbance of the carbon/nitrogen ratio induces partial chloroplast degradation via autophagy under phosphate starvation and rescues phosphate starvation stress.     

Phospholipid Metabolism in an Industry Microalga Chlorella sorokiniana: The Impact of Inoculum Sizes

Chlorella sorokiniana is an important industry microalga potential for biofuel production. Inoculum size is one of the important factors in algal large-scale culture, and has great effects on the growth, lipid accumulation and metabolism of microalgae. As the first barrier of cell contents, membrane plays a vital role in algal inoculum-related metabolism. The knowledge of phospholipids, the main membrane component and high accumulation of phospholipids as the major content of total lipids mass in some microalgae, is necessary to understand the role of membrane in cell growth and metabolism under different inoculum density. Profiling of C. sorokiniana phospholipids with LC-MS led to the identification of 119 phospholipid species. To discover the phospholipid molecules most related to change of inoculum sizes, Partial Least Squares Discriminant Analysis (PLS-DA) was employed and the results revealed that inoculum sizes significantly affected phospholipid profiling. Phosphatidylglycerol (PG), phosphatidyl- ethanolamine (PE) and several phosphatidylcholine (PC) species might play an important role under our experimental conditions. Further analysis of these biomarkers indicated that cell membrane status of C. sorokiniana might play an important role in the adaption to the inoculum sizes. And the culture with inoculum size of 1×10⁶ cells mL⁻¹ presented the best membrane status with the highest content of PC and PG, and the lowest content of PE. We discovered that the inoculum size of 1×10⁶ cells mL⁻¹ might provide the best growth condition for C. sorokiniana. Also we proposed that PG, PE and several PC may play an important role in inoculum-related metabolism in C. sorokiniana, which may work through thylakoid membrane and photosynthetic pathway. Thus this study would provide more potential targets for metabolic engineering to improve biofuel production and productivity in microalgae.     

Comparative Analyses of Three Chlorella Species in Response to Light and Sugar Reveal Distinctive Lipid Accumulation Patterns in the Microalga C. sorokiniana

While photosynthetic microalgae, such as Chlorella, serve as feedstocks for nutritional oils and biofuels, heterotrophic cultivation can augment growth rates, support high cell densities, and increase triacylglycerol (TAG) lipid content. However, these species differ significantly in their photoautotrophic and heterotrophic characteristics. In this study, the phylogeny of thirty Chlorella strains was determined in order to inform bioprospecting efforts and detailed physiological assessment of three species. The growth kinetics and lipid biochemistry of C. protothecoides UTEX 411, C. vulgaris UTEX 265, and C. sorokiniana UTEX 1230 were quantified during photoautotrophy in Bold''s basal medium (BBM) and heterotrophy in BBM supplemented with glucose (10 g L⁻¹). Heterotrophic growth rates of UTEX 411, 265, and 1230 were found to be 1.5-, 3.7-, and 5-fold higher than their respective autotrophic rates. With a rapid nine-hour heterotrophic doubling time, Chlorella sorokiniana UTEX 1230 maximally accumulated 39% total lipids by dry weight during heterotrophy compared to 18% autotrophically. Furthermore, the discrete fatty acid composition of each strain was examined in order to elucidate lipid accumulation patterns under the two trophic conditions. In both modes of growth, UTEX 411 and 265 produced 18∶1 as the principal fatty acid while UTEX 1230 exhibited a 2.5-fold enrichment in 18∶2 relative to 18∶1. Although the total lipid content was highest in UTEX 411 during heterotrophy, UTEX 1230 demonstrated a two-fold increase in its heterotrophic TAG fraction at a rate of 28.9 mg L⁻¹ d⁻¹ to reach 22% of the biomass, corresponding to as much as 90% of its total lipids. Interestingly, UTEX 1230 growth was restricted during mixotrophy and its TAG production rate was suppressed to 18.2 mg L⁻¹ d⁻¹. This constraint on carbon flow raises intriguing questions about the impact of sugar and light on the metabolic regulation of microalgal lipid biosynthesis.     

Mixed Wastewater Coupled with CO2 for Microalgae Culturing and Nutrient Removal

Biomass, nutrient removal capacity, lipid productivity and morphological changes of Chlorella sorokiniana and Desmodesmus communis were investigated in mixed wastewaters with different CO₂ concentrations. Under optimal condition, which was 1:3 ratio of swine wastewater to second treated municipal wastewater with 5% CO₂, the maximum biomass concentrations were 1.22 g L^-1 and 0.84 g L^-1 for C. sorokiniana and D. communis, respectively. Almost all of the ammonia and phosphorus were removed, the removal rates of total nitrogen were 88.05% for C. sorokiniana and 83.18% for D. communis. Lipid content reached 17.04% for C. sorokiniana and 20.37% for D. communis after 10 days culture. CO₂ aeration increased intracellular particle numbers of both microalgae and made D. communis tend to be solitary. The research suggested the aeration of CO₂ improve the tolerance of microalgae to high concentration of NH₄-N, and nutrient excess stress could induce lipid accumulation of microalgae.     

Characterization of Nitrate Reductase Deficient Mutants of Chlorella sorokiniana

After x-ray irradiation, 13 mutants of Chlorella sorokiniana incapable of using NO₃⁻ as N source were isolated using a pinpoint method. Using immunoprecipitation and Western blot assays, no nitrate reductase was found in five strains while in eight mutants the enzyme was detected. The latter strains contained different patterns of nitrate reductase partial reactions. All isolates were of the nia-type as indicated by the inducibility of purine hydroxylase I and by complementation of nitrate reductase activity in the Neurospora crassa mutant Nit-1. A restoration of NADP-nitrate reductase in Nit-1 was also obtained with NH₄⁺-grown cells indicating that Mo-cofactor is constitutive in Chlorella. Complementation experiments among the Chlorella mutants resulted in restoration of NADH-nitrate reductase activity. The characteristics of some of the Chlorella mutants are discussed in view of an improper orientation of Mo-cofactor in the residual nitrate reductase protein.     

On the characteristics and taxonomic position of symbiotic Chlorella

Three strains of symbiotic Chlorella (NC64A, CE/76, UTEX-130) could be assigned to C. vulgaris by physiological and DNA-hybridization studies and a fourth symbiotic strain, 3N8/13-1, exhibited characteristics intermediate between C. vulgaris and C. sorokiniana. None of the strains contained detectable sporopollenin or was nutritionally fastidious but the capacity for sugar release (usually maltose) may be a characteristic of all symbiotic Chlorella.     

Lipid productivity and fatty acid composition in Chlorella and Scenepdesmus strains grown in nitrogen-stressed conditions

Thirty Chlorella and 30 Scenedesmus strains grown in nitrogen-stressed conditions (70 mg L^?1 N) were analyzed for biomass accumulation, lipid productivity, protein, and fatty acid (FA) composition. Scenedesmus strains produced more biomass (4.02?±?0.73 g L^?1) after 14 days in culture compared to Chlorella strains (2.57?±?0.12 g L^?1). Protein content decreased and lipid content increased from days 8 to 14 with an increase in triacylglycerol (TAG) accumulation in most strains. By day 14, Scenedesmus strains generally had higher lipid productivity (53.5?±?3.7 mg lipid L^?1 day^?1) than Chlorella strains (35.1?±?2.8 mg lipid L^?1 day^?1) with the lipids consisting mainly of C16–18 TAGs. Scenedesmus strains generally had a more suitable FA profile with higher amounts of saturated fatty acids and monounsaturated fatty acids (MUFAs) and a smaller polyunsaturated fatty acid (PUFA) component. Chlorella strains had a larger PUFA component and smaller MUFA component. The general trend in the FA composition of Chlorella strains was oleic > palmitic > α-linolenic = linoleic > eicosenoic > heptadecenoic > stearic acid. For Scenedesmus strains, the general trend was oleic > palmitic > linoleic > α-linolenic > stearic > eicosenoic > palmitoleic > heptadecenoic acid. The most promising strains with the highest lipid productivity and most suitable FA profiles were Scenedesmus sp. MACC 401, Scenedesmus soli MACC 721, and Scenedesmus ecornis MACC 714. Although Chlorella sp. MACC 519 had lower lipid productivity, the FA profile was good with a lower PUFA component compared to the other Chlorella strains analyzed and a low linolenic acid concentration.     

Upper limits of temperature for growth inChlorella (Chlorophyceae)

The upper limit of temperature for growth is a species-specific character in the genusChlorella. The limits of 14Chlorella species range from 26–30°C (C. saccharophila) to 38–42°C (C. sorokiniana), withC. fusca var.vacuolata (34°C) andC. kessleri (34–36°C) assuming an intermediate position. Thus, there is no wide gap in the temperature limits between the normal (“low-temperature”) species ofChlorella and the “high-temperature” species,C. sorokiniana.     

Lipid sovent systems are not equivalent for analysis of lipid classes in the microeukaryotic green alga,Chlorella

A comparison of three lipid solvent system indicated that they are not equivalent for the analysis of lipid classes in the green alga, Chlorella. Soxhlet extraction (methylene chloride/methanol, 3 h refulx) recovers more neutral lipid than the other methods but is equivalent to the room-temperature Bligh and Dyer (chloroform/methanol/water) extraction modified with phosphate buffer in glycolipid and polar lipid recovery. The Soxhlet method, however, gave a significantly lower recovery of many polyunsaturated fatty acids. The hexane/isopropanol method is selective for algal neutral lipids with poor recovery of membrane lipids (glyco- and polar lipids). Although this selectivity may have some useful applications, for biochemical studies of lipid synthesis in Chlorella, the modified Bligh and Dyer provides the most quantitative and reproducible recovery of all Chlorella lipid classes while minimizing artifacts due to the extraction procedure.