Distraction osteogenesis of costochondral bone grafts in the mandible

Costochondral grafting for reconstruction of the Pruzansky type III mandible has given variable results. Lengthening of the rib graft by means of distraction had been advocated when subsequent growth of the grafted mandible is inadequate. This retrospective study reviews a series of patients with mandibular costochondral grafts who underwent subsequent distraction osteogenesis of the graft. A retrospective review identified two patient groups: group 1 consisted of individuals (n = 9) who underwent costochondral rib grafting of the mandible followed by distraction osteogenesis several months later at a rate of 1 mm/day. Group 2 consisted of patients with Pruzansky type II mandibles who had distraction osteogenesis without prior rib grafting (n = 9). The biomechanical parameters, orthodontic treatment regimens, and complications were examined versus patient age and quality of the rib graft. Distraction osteogenesis was successfully performed in six of the rib graft patients (group 1) and in all of the group 2 individuals. On the basis of the Haminishi scale, the computed tomographic scan appearance of the regenerate was classified as "standard or external" in six of the group 1 patients and as either "agenetic" or "pillar" (fibrous union) in the remaining three patients. In group 1, the average device was expanded 23 mm (range, 20 to 30 mm). Group 2 mandibular distraction results were all classified as either standard or external, and there was an average device expansion of 22.4 mm (range, 16 to 30 mm). The length of consolidation averaged 12.6 weeks in group 1, compared with 8.5 weeks in the traditional mandibular distraction patients (group 2). The mean shift of the dental midline to the contralateral side was 2.5 mm in group 1 versus 4.0 mm in group 2. Complex multiplanar and transport distractions were successfully performed on grafts of adequate bony volume. All four patients in group 1 with tracheostomies were successfully decannulated after consolidation. Rib graft distraction complications included pin tract infections in two patients, hardware failure with premature pin pullout in one patient, and evidence of fibrous nonunions in three young patients with single, diminutive rib grafts. In group 2, there were no distraction failures. Distraction osteogenesis can be successfully performed on costochondral rib grafts of the mandible; however, the complication rate is higher than in non-rib-graft patients. Performing the technique on older, more cooperative individuals seems to reduce this risk. In addition, placement of a double rib graft or an iliac bone graft of sufficient volume to create a neomandible with greater bone stock is an absolute requirement to decrease the risk of fibrous nonunion and provide a bone base of sufficient size for retention of the distraction device and manipulation of the regenerate.     

Mandibular distraction in temporomandibular joint ankylosis

Condylar damage during childhood can produce ankylosis and alteration of the mandibular growth. In case of unilateral ankylosis occurring in early childhood, a mandibular hypoplasia of the affected side may develop. The patients have limitation of mouth opening, facial asymmetry, and chin deviation toward the affected side. The aims of this study are to show the use of distraction osteogenesis in mandibular hypoplasia associated with ankylosis and to present our experience with a new therapeutic option for the treatment of mandibular hypoplasia with unilateral ankylosis in the childhood consisting of the association of arthroplasty to treat the ankylosis and mandibular distraction to correct the facial asymmetry, both accomplished in the same surgical procedure. From November of 1996 to November of 1997, three male patients aged 2, 7, and 13 years with mandibular hypoplasia and ankylosis were treated by distraction osteogenesis. An arthroplasty consisting of the resection of the ankylotic block and interposition of a temporalis muscle flap, plus coronoidectomy was done in two of them and mandibular distraction was done in all three patients. Articular functional rehabilitation began on the first postoperative day. Mandibular distraction began on the fifth postoperative day with a rate of 1 mm per day, ending when the facial symmetry was achieved. From the first postoperative day, an increase in the mouth opening was achieved; this increase continued until ending the distraction. The average duration of distraction was 22 days. Average duration of consolidation was 6 weeks. Oral opening increased from 10 mm to 35 mm in the 7-year-old patient, from 9 mm to 27 mm in the 2-year-old patient, and from 14 mm to 38 mm in the 13-year-old patient. To date, oral opening and facial symmetry persist. Osseous mandibular distraction together with arthroplasty offers an excellent new alternative for treatment of patients with mandibular hypoplasia and associated ankylosis, with minimal morbidity and complications.     

Expression of bone morphogenetic proteins during mandibular distraction osteogenesis

Distraction osteogenesis is a form of in vivo tissue engineering in which the gradual separation of cut bone edges results in the generation of new bone. In this study, the temporal and spatial expression of bone morphogenetic proteins (BMPs) 2, 4, and 7 was examined in a rabbit model of mandibular distraction osteogenesis. Fourteen skeletally mature male rabbits were studied. After osteotomy, a distractor was applied to one side of the mandible. After 1 week of latency, distraction was initiated at 0.25 mm every 12 hours for 3 weeks (distraction period), followed by a 3-week consolidation period. Two animals were killed each week after surgery. The generate bone was analyzed for the expression of BMP-2, -4, and -7 by using standard bone histological and immunohistochemical techniques. BMP-2 and -4 were highly expressed in osteoblastic cells during the distraction period and in chondrocytes during the consolidation period. BMP-7 demonstrated relatively minor expression in osteoblastic cells during the distraction period. All BMPs were strongly expressed in vascularized connective tissue during the distraction period. These data indicate that BMPs participate in the translation of mechanical stimuli into a biological response during mandibular distraction osteogenesis.     

Treatment of craniomaxillofacial fibrous dysplasia: how early and how extensive?

Twenty-eight craniomaxillofacial fibrous dysplasia patients were treated as early as the symptoms occurred. The principles of surgical treatment were based on the zones of involvement: total excision of dysplastic bone of fronto-orbital, zygoma, and upper maxillary origin (zone 1) and bone reconstruction primarily; conservative excision on hair-bearing skull (zone 2), central cranial base (zone 3), and tooth-bearing bones (zone 4); and optic canal decompression on patients with orbital dysplasia and decreasing visual acuity. Patients were followed for 1 to 11 years (average 5.3 years). No recurrence or invasion of the fibrous dysplasia into the grafted bone was seen. One patient had orthognathic maxillary osteotomy on the reconstructed maxilla 6 years after initial reconstruction. Five of 19 patients with alveolar dysplasia had a recurrence and were reshaped. One patient had mandibular sagittal osteotomies to set back the prognathic, fibrous dysplasic mandible after three attempts at conservative shaving. Another patient with mandibular fibrous dysplasia had recurrence with pain and a hemimandibulectomy with successful immediate free vascularized iliac bone graft reconstruction.     

The osteocutaneous scapular flap for mandibular and maxillary reconstruction

Microfil injections in 8 cadavers and clinical experience with 26 patients have demonstrated a reliable blood supply to the lateral border of the scapula based on branches of the circumflex scapular artery. This tissue has been used successfully for reconstruction of a variety of defects resulting from maxillectomy and mandibular defects from cancer and benign tumor excisions. Advantages of this tissue over previous reconstructive methods include the ability to design multiple cutaneous panels on a separate vascular pedicle from the bone flap allowing improvement in three-dimensional spatial relationships for complex mandibular and maxillary reconstructions. The lateral border of the scapula provides up to 14 cm of thick, straight corticocancellous bone that can be osteotomized where desired. The thin blade of the scapula provides optimum tissues for palate and orbital floor reconstruction. There have been no flap failures and minimal donor-site complications.     

Lengthening the human mandible by gradual distraction.

Lengthening of the mandible by gradual distraction was performed on four young patients (average age 78 months). The amount of mandibular bone lengthening ranged from 18 to 24 mm; one patient with Nager's syndrome underwent bilateral mandibular expansion. Following the period of expansion, the patients were maintained in external fixation for an average of 9 weeks to allow ossification. The patients were followed for a minimum of 11 months to a maximum of 20 months with clinical and dental examinations as well as photographic and radiographic documentation. The technique holds promise for early reconstruction of craniofacial skeletal defects without the need for bone grafts, blood transfusion, or intermaxillary fixation.     

Early definitive bone and soft-tissue reconstruction of major gunshot wounds of the face

The use of craniofacial surgical techniques, extended open reduction, rigid fixation with plates and screws, and the replacement of severely damaged or missing bone with immediate bone grafting in the treatment of complex facial fractures has been applied to the management of severe gunshot wounds of the face. Early definitive bone and soft-tissue reconstruction has been performed in 37 patients. One-hundred and seventy-seven primary bone grafts were utilized in 33 patients for orbital, nasal, zygomatic, and maxillary reconstruction. Twenty-six patients required mandibular repair with compression or reconstruction plates. Soft-tissue reconstruction was provided by a combination of flaps. Four patients had extensive soft-tissue loss replaced by free vascularized omental flaps. The omentum provided circumferential coverage of the mandibular reconstruction and reconstruction of the floor of the mouth and was then tunneled in a circle through both cheeks into the middle and upper face. The omentum reconstructed deficits in the hard palate and upper buccal sulcus and was then wrapped around all zygomatic, orbital, and midfacial bone grafts and used to fill in dead space in the maxillary, ethmoid, and frontal sinuses. The omentum is not used to provide contour and bulk, but to cover bone grafts and plates and fill in dead space. Carefully shaped bone grafts provide the correct craniofacial scaffold. Early restoration of a midfacial bony scaffold and the prevention of soft-tissue contraction facilitate secondary reconstruction. Four late total nasal reconstructions with tissue-expanded forehead skin wrapped around bone grafts were performed.     

Limb reconstruction by free-tissue transfer combined with the Ilizarov method.

In four complex cases of extremity reconstruction, we have been able to overcome the problems of combined bone and soft-tissue loss and length discrepancy by a combination of free-tissue transfer and the Ilizarov method of slow distraction. It is our observation that gradual distraction of a free tissue is a safe and viable procedure; the free tissue tolerates the pins of the circular external fixator well, and there is an equal degree of distraction and regeneration of the transferred free tissue and the native recipient tissue without evidence of wound dehiscence. Corticotomy through free tissue and in close proximity to vascularized bone is safe, with the subsequent bone regeneration not unlike that of normal bone. Manipulation by slow distraction does not appear to compromise the vasculature of the recipient bed for later microsurgical procedures or endanger the axial flow pattern of the transferred free tissue.     

Functional reconstruction of maxilla with free latissimus dorsi-scapular osteomusculocutaneous flap

Restoration of oral and nasal function together with facial appearance is still challenging in maxillary reconstruction. Use of a composite flap transfer merely to fill the defect results in unsatisfactory functional and aesthetic outcomes. The authors present a reconstructive procedure for complex maxillary defects using the latissimus dorsi-scapular rib osteomusculocutaneous flap. Some modifications for the reconstruction of the nasal cavity and the hard palate contributed to excellent postoperative functions. Five cases of extended maxillary defect were reconstructed using a novel procedure between February of 1997 and October of 2000. The hard palate was reconstructed with a vascularized scapular angle. The infraorbital rim was reconstructed with a vascularized rib if it was required. A prop bone graft, replacing the zygomatic buttress, was added between the infraorbital rim and the hard palate. The latissimus dorsi muscle flap, which was supported by a skeletal framework and obliterated the remaining cavities around the bone grafts, was left exposed into the nasal cavity, and an 8-French (no. 10) nasal airway tube was placed as a stent in the nasal meatus for 3 weeks after surgery. A skin graft was applied on the scapular angle to reconstruct the oral side of the hard palate. If required, facial skin defect was repaired with a latissimus dorsi musculocutaneous flap or scapular flap. No major complications at the recipient or the donor sites occurred postoperatively in any of the five cases. In cases in which the eyeballs were preserved, almost normal facial appearance was obtained and an orbital extirpation case showed an acceptable postoperative appearance. All five patients returned to an unrestricted diet and their speech was assessed as normal by a speech test. Nasal breathing through the re-epithelialized meatus was possible in all cases. The reconstructed nasal cavity was maintained for more than 6 months in all cases and for more than 2 years in one early case. Rhinometry demonstrated normal function, and histologic findings of the re-epithelialized mucosa over the muscle flap in the nasal cavity revealed a nearly normal architecture. This technique simplifies the reconstructive procedure of massive maxillary defects, including those in the lateral wall of the nasal cavity. It also improves the postoperative oral and nasal functions of the patients.     

Segmental mandibulectomy and immediate free fibula osteoseptocutaneous flap reconstruction with endosteal implants: an ideal treatment method for mandibular ameloblastoma

Thirteen patients with large ameloblastomas of the mandible underwent segmental mandibulectomy and immediate reconstruction, with simultaneous placement of osseointegrated implants. All patients received palatal mucosal grafts around the dental implants 6 to 10 months after surgical treatment and received implant-supported prostheses another 1 to 2 months later. There were five female and eight male patients, with a mean age of 32 years (range, 17 to 50 years). The mean length of the mandibular defect was 8.8 cm (range, 5 to 13 cm). All free fibula flap procedures were successful, with no reexplorations or partial flap losses. There was no clinical or radiographic evidence of failure during the osseointegration process for any implant. With functional occlusal loading, the marginal bone loss around the implants was less than 1.5 mm in a mean follow-up period of 40 months (range, 18 to 70 months). There were no recurrences during that time. The technique described allows improved access to the bone at the time of reconstruction, immediate assessment of alveolar ridge relationships, and accurate fixation of the implant-fibula construct. The advantages of this procedure include a reduced risk of recurrence with segmental resection, reliable mandibular reconstruction, and reduction of the number of surgical procedures, allowing full oral rehabilitation in a shorter time. It is concluded that segmental mandibulectomy and immediate vascularized fibula osteoseptocutaneous flap reconstruction, with simultaneous placement of osseointegrated implants, represent an ideal treatment method for large ameloblastomas of the mandible.     

Remodeling of the temporomandibular joint following mandibular distraction osteogenesis in the transverse dimension

Transverse mandibular distraction osteogenesis involves moving the osteotomized segments of the mandible in either a varus or valgus direction. This maneuver allows for widening of the bigonial distance or for a lateral shift of an asymmetric mandibular midline. During this process, a significant amount of torque is placed on the mandibular condyles, because they act as the pivot point for the mandibular translation. Although standard linear distraction osteogenesis induces transient, reversible changes in the temporomandibular joint, it is not known what effect the varus and valgus stresses of transverse distraction have on the temporomandibular joint. We therefore designed a study to document the temporomandibular joint changes following various degrees of transverse distraction.Bilateral transverse mandibular distraction was performed on 10 adult, female mongrel dogs using an external, multiplanar mandibular distraction device. The distraction protocol was as follows: (1) complete osteotomy at the angle of the mandible, (2) 5-day latency period, (3) distraction rate of 1 mm/day, (4) rhythm of one turn per day, (5) linear activation 16 to 30 mm bilaterally, and (6) 8-week consolidation period. A variety of varus and valgus distraction vectors were applied to the mandible only after 10 mm of initial linear distraction had been achieved. Posteroanterior and lateral cephalograms were performed throughout the entire process. Pre-distraction and post-consolidation computed tomographic scans were also performed. Changes in mandibular conformation, axis of rotation, temporomandibular joint structure, and glenoid fossa changes were directly assessed by evaluating the postmortem craniofacial skeleton. The findings were compared with those of normal, age-matched mongrel dog skulls.Significant remodeling changes were observed in the temporomandibular joints of all animals involved in the study. The mandibular condyles demonstrated varying degrees of flattening and erosion at all contact points with the craniofacial skeleton. In some cases, the condyle became part of the distraction regenerate process and was hypertrophied in all dimensions. The condyles were frequently displaced out of the glenoid fossa, particularly on the side in the direction of varus distraction. When the latter occurred, a new fossa was created on the undersurface of the zygomatic arch. Varying degrees of mandibular rotation in the sagittal plane were also observed, which led to abnormal torquing of the condyles in the coronal plane, depending on whether the axis of rotation occurred primarily around the condyle or around the distraction regenerate zone.In conclusion, transverse mandibular distraction is an effective means of producing a varus or valgus shift in the gonion relative to the midsagittal plane. However, unlike linear or angular mandibular distraction, transverse distraction has a multitude of nontransient effects on the temporomandibular joint. Therefore it must be emphasized that in clinical practice, transverse distraction should be used cautiously. One must also be aware that such a maneuver in distraction can have negative effects on the temporomandibular joint.     

Use of the AO plate for immediate mandibular reconstruction in cancer patients

Free vascularized bone grafts have revolutionized mandibular reconstruction, yet their use in all mandibulectomy patients is not always necessary. A recently developed alternative to bony reconstruction has been the use of the AO reconstruction plate. We compared the use of the AO reconstruction plate with immediate free bone graft mandibular reconstruction in 31 patients. Reconstruction plates were used in 20 and immediate free bone grafts were used in 11 patients. The overall success rate for use of the plate was 15 of 20 (75 percent). There were 6 anterior reconstructions, of which only 2 (33 percent) were successful. This is opposed to 13 of 14 (93 percent) lateral reconstructions that were successful in lateral plate placements. There were 11 immediate composite free flaps: 4 iliac crest, 4 scapula, 2 fibula, and 1 composite radial forearm flaps. Six repairs were for anterior defects, and there were 5 full-thickness defects, 3 of which were in the anterior position. All 11 flaps were successful. In conclusion, we believe the reconstruction plates are a useful adjunct for mandibular replacement in the head and neck cancer patient but should be reserved for lateral defects. For anterior reconstructions, even in patients with locally advanced disease, free-tissue transfer of composite osteocutaneous flaps is the reconstructive method of choice.     

Craniofacial distraction with a modular internal distraction system: evolution of design and surgical techniques.

The present report summarizes the evolution of design for a modular internal distraction system that is applicable throughout the craniofacial region. Eleven patients (5 boys, 6 girls), whose ages ranged from 4 months to 10 years at the time of distraction, constitute the basis for this study. The clinical indications for distraction were exorbitism with corneal exposure (n = 1), obstructive sleep apnea (n = 4), tracheostomy decannulation (n = 1), severe maxillary hypoplasia with class III malocclusion (n = 3), severe vertical and sagittal maxillary deficiency with anophthalmia (n = 1), and relapse following frontoorbital advancement in a case of rare craniofacial clefting (n = 1). Twenty-two distraction devices were used in these 11 patients. Two initial prototypes were tested (prototype 1 = 8 devices; prototype 2 = 2 devices) until the modular internal distraction system (MIDS, Howmedica-Leibinger, Inc.) was developed (n = 12 devices). The craniofacial osteotomies used were Le Fort III (n = 4), monobloc (n = 3), mandibular (n = 3), Le Fort I (n = 2), and cranial (n = 1). The distraction distances ranged from 11 to 28 mm. One patient undergoing mandibular distraction developed transient swelling in the left mandibular region, which responded to antibiotics. There were no other complications. Depending on the age of the patient and the length of distraction, the distraction gap was allowed to consolidate from 6 weeks to 3 months. The devices were then removed on either an outpatient or a 23-hour-stay basis. The modular internal distraction system permits widespread application of easily customizable, buried distraction devices throughout the craniofacial region.     

Distraction osteogenesis of the craniofacial skeleton

Distraction osteogenesis is becoming the treatment of choice for the surgical correction of hypoplasias of the craniofacial skeleton. Its principle is based on the studies of Ilizarov, who showed that osteogenesis can be induced if bone is expanded (distracted) along its long axis at the rate of 1 mm per day. This process induces new bone formation along the vector of pull without requiring the use of a bone graft. The technique also provides the added benefit of expanding the overlying soft tissues, which are frequently deficient in these patients. This article reviews the authors' 11-year clinical and research experience with mandibular distraction osteogenesis. It highlights the indications and contraindications of the technique and emphasizes the critical role that basic science research has played in its evolution.     

The use of Champy miniplates for osteosynthesis in craniofacial deformities and trauma

Champy miniplates have been used in the treatment of craniofacial fractures and in osteotomies for correction of posttraumatic deformities, congenital craniofacial deformities, and secondary bony deformities due to pathologies such as hemangioma and neurofibroma. An additional use has been to stabilize free and vascularized bone grafts. The total number of cases reviewed were 50 (25 acute trauma, 4 vascularized mandible reconstruction, and 21 osteotomies of varied types). There were three infections, two in mandibular fractures that were comminuted and compound into the mouth and one in a compound comminuted fracture of the frontal and maxillary area that was judged to be infected when the plate was placed in position. Two plates have been obvious under the skin. No patient has requested plate removal. The advantages of plating in selected cases are decreased operating time, rigid fixation at surgery, good fixation of bone grafts, and the ability to remove intermaxillary fixation in children at the end of the procedure or within the first few postoperative days.     

Distraction osteogenesis of the porcine mandible: histomorphometric evaluation of bone

Distraction osteogenesis is a technique for skeletal lengthening that exploits the body's innate capacity for bone formation in response to tension forces on the repair callus. The authors developed a distraction osteogenesis model with a semiburied device in the Yucatan minipig mandible because of similarities between human and porcine mandibular anatomy, temporomandibular function, chewing patterns, and bone turnover rates. The purpose of this study was to measure histomorphometric bone fill after different latency periods, rates of distraction, and duration of neutral fixation in the minipig mandible. In addition, the relationship between histomorphometric bone fill and clinical stability was investigated. Mandibular osteotomies in 20 female Yucatan minipigs weighing 25 to 30 kg were distracted with modified semiburied distraction devices. Variables included 0-day or 4-day latency; 1-mm, 2-mm, or 4-mm daily distraction rates; gap size of 7 or 12 mm; and evaluation after neutral fixation for various lengths of time. Specimens were fixed in 2% paraformaldehyde, pH 7.4, before being embedded in methylmethacrylate. Sections were prepared from the region just below the inferior alveolar canal. The area of new bone formation within the gap was measured and expressed as a percentage of the total area of the distraction gap. Bone fill ranged from 0 to 100 percent. A pilot study with 7-mm advancements showed similar bone fill with 0-day or 4-day latency, but with poor reproducibility. Mandibles that were distracted to 12 mm at 1 mm per day exhibited nearly complete bone fill, either with 0-day latency (average, 93 percent) or 4-day latency (average, 100 percent). Mandibles that had been distracted for 3 days at 4 mm per day showed moderate osteogenesis and clinical stability with increasing time of neutral fixation. Bone fill was significantly correlated with clinical stability (Spearman r = 0.801, p = 0.001). Histological examination showed exuberant periosteal osteogenesis in distracted mandibles, even in those that showed poor bone fill and clinical stability. Thus, the periosteum appears to be a major source of new bone formation. These results show that osteogenesis was nearly complete with 1 mm per day and 0-day or 4-day latency. These results are consistent with the authors' previously reported clinical and radiographic observations that a latency period is not necessary for successful healing of the mandibular distraction osteogenesis wound.     

Mandibular distraction osteogenesis in very young patients to correct airway obstruction

The purpose of this study was to measure changes in the airway cross-sectional area of pediatric patients with micrognathia and obstructive airway symptoms after treatment by mandibular distraction. The measurements obtained were correlated with the clinical outcomes.Ten patients, ranging in age from 3 months to 8 years, underwent measurement and distraction. Eight patients were under 30 months of age. Six were diagnosed with Pierre Robin sequence, two with Treacher Collins syndrome, and two with Nager syndrome. All patients had retrognathia of greater than 8 mm and obstructive airway symptoms while awake that had resulted in tracheostomy (3), repeated apnea monitor triggering (5), or abnormal sleep study (2). Cephalometric analysis was performed pretreatment and posttreatment by distraction. The effective airway space was defined with the following boundaries: a horizontal line from the tip of the odontoid to the velum, the uvula tip to the tongue base along the shortest line, the tongue base down to the base of the epiglottis, and the horizontal line to the posterior pharynx. These lines were traced for each cephalogram, the outline was digitized, and the area was calculated by computer. An analysis of the square area change was done by paired t test. The range of distraction was 8 to 22 mm; the mean effective airway increase was 67.5 percent, with a range of 26 to 120 percent. Measurable airway increase occurred in all patients who underwent distraction, and all patients showed clinical improvement. Six patients with Pierre Robin sequence became asymptomatic, with normal sleep, feeding, and weight gain. Two patients with Nager syndrome and tracheostomies were decannulated and were asymptomatic postdistraction. One patient with Treacher Collins syndrome without tracheostomy became asymptomatic after mandibular distraction; one patient failed to distract because of premature consolidation and continued to require a cannula.Mandibular distraction seems to provide a consistent change in tongue base position that improves obstructive airway symptoms by increasing measured effective airway space. The potential for mandibular distraction exceeds the simple correction of malocclusion also by eliminating soft-tissue obstruction of the micrognathic airway. Airway improvement is independent of the syndrome diagnosed. Mandibular distraction osteogenesis may be useful to avoid or decannulate existing tracheostomy in infants with micrognathia.     

Removal of mandibular tooth follicles before distraction osteogenesis

Distraction osteogenesis is an innovative technique that has transformed the treatment of craniofacial malformations in young children. Bone generation obviates the need for graft material, which is in short supply in young patients, thus making possible surgical procedures on the craniofacial skeleton in young children. Sufficient mandibular volume is required for the osteotomy and placement of the device screws and/or pins. To have adequate bone stock and to facilitate distraction, the authors preoperatively examined all patients radiographically and selected those with tooth follicles that precluded successful osteotomy and pin placement for planned mandibular distraction. This report is of the first 13 children, aged 9 months to 6 years, who underwent predistraction enucleation. The osteotomy and device placement were performed successfully at least 4 months after enucleation. The described procedure has minimal morbidity and has resulted in successful subsequent distraction. The advantages, disadvantages, and cost-benefit issues are discussed.     

Mandibular distraction osteogenesis in Pierre Robin sequence: application of a new internal single-stage resorbable device

Pierre Robin sequence may result in physiologically significant obstructive apnea in the neonatal and infant period. This may be life threatening and is most often treated by tracheostomy. To avoid tracheostomy or allow for early decannulation in severely affected infants and children, the authors have developed a new class of neonatal and infant mandibular bone distraction devices. These devices require a single operative procedure for placement and no operative removal is necessary. Fifteen infants (aged 7 days to 11 months; mean age, 3 months) and five children (aged 2 to 8 years; mean age, 5.5 years), 10 boys and 10 girls, with severe obstructive apnea and Pierre Robin sequence were treated with the mandibular infant devices over a 24-month period. Tracheostomy was avoided in 14 patients, whereas five of six patients who had previous tracheostomy were decannulated after mandibular distraction. The final tracheostomy status in one patient will be determined after surgery for gastroesophageal reflux. There were no major complications and no structural device failures.     

Use of virtual surgery and stereolithography-guided osteotomy for mandibular reconstruction with the free fibula

Fibular osteotomy remains a challenging aspect of mandibular microsurgical reconstruction, dependent largely on surgeon experience, intraoperative judgment, and technical speed. Virtual surgical planning and stereolithographic modeling is a relatively new technique that can allow for reduction in the learning curve associated with neomandible contouring, enhanced levels of accuracy, and acceleration of a time-consuming intraoperative step. The authors present a video (narrated and edited from planning sessions and intraoperative use of technique to illustrate the technology) and describe their favorable results. Five patients underwent composite resection of the mandible and free fibula osteocutaneous reconstruction over a 6-month period (December of 2009 to June of 2010) at a single institution using a virtual planning session and stereolithographic modeling. Outcomes assessed included technical accuracy, aesthetic contour, and functional outcomes. All patients achieved negative margins with cutting guide-directed resection. Use of this technique eliminated the need for intraoperative measurement and yielded fibular segments with excellent apposition and faithful duplication of the preoperative plan. Minimal adjustments were needed for inset. Flap survival was 100 percent. All patients have maintained preoperative occlusion and a symmetric mandibular contour on Panorex study, three-dimensional computed tomography, and clinical examination. Accuracy of the reconstructed contour was confirmed using computed tomographic image overlay. This virtual surgical planning technique combined with stereolithographic model-guided osteotomy is the mainstay of the authors' approach to fibular osteotomy when dealing with patients requiring mandibular reconstruction. The authors feel this technology facilitates realization of technical accuracy, aesthetic contour, and functional outcomes and may be particularly useful if free fibular mandibular reconstruction is performed less frequently. CLINICAL QUESTION/LEVEL OF EVIDENCE: Therapeutic, IV.