Solvent-free glycerolysis of palm and palm kernel oils catalyzed by commercial 1,3-specific lipase from Humicola lanuginosa and composition of glycerolysis products

Glycerolysis of palm and palm kernel oils were conducted using a commercial 1,3-specific lipase from Humicola lanuginosa (trade name: SP 398) as catalyst (500 units lipase g^–1 oil) at 40°C and oil:glycerol (1:2 mol mol^–1) in a solvent-free system. After 24 h, the glycerolysis products of palm and palm kernel oils consisted of 23% triacylglycerols, 18% monoacylglycerols, 38% diacylglycerols and 18% triacylglycerols, 31% monoacylglycerols, 42% diacylglycerols, respectively. The monoacylglycerol fraction of the glycerolysis product of palm oil was enriched in oleic acid. Palmitic acid content of the monoacylglycerol fraction of the same product was less than that of the original oil. Under the same conditions, monacylglycerol fraction of the palm kernel oil glycerolysis product was enriched in palmitic, stearic and oleic acids.     

Steady state and time resolved effects of guanidine hydrochloride on the structure of Humicola lanuginosa lipase revealed by fluorescence spectroscopy

Effects of guanidine hydrochloride (GdnHCl) on the structure and dynamics of wild-type Humicola lanuginosa lipase (HLL) and its two mutants were studied. The latter were S146A (with the active site Ser replaced by Ala) and the single Trp mutant W89m, with substitutions W117F, W221H, and W260H. Steady-state, stopped-flow, and time-resolved laser-induced fluorescence spectroscopy were carried out as a function of [GdnHCl]. The maximum emission wavelength and fluorescence lifetimes revealed the microenvironment of the tryptophan(s) in these lipases to become more polar upon increasing [GdnHCl]. However, significant extent of tertiary structure in GdnHCl is suggested by the observation that both wild-type HLL and W89m remain catalytically active at rather high GdnHCl concentrations of >6 and 4.0 M, respectively. Changes in steady-state emission anisotropy, as well as variation in rotational correlation times and residual anisotropy values, demonstrate that upon increasing [GdnHCl] the structure of the lipases became more loose, with increasing amplitude of structural fluctuations. Finally, intermediate states in the course of exposure of the proteins to GdnHCl were revealed by stopped-flow fluorescence measurements.     

Enzymatic resolution of 2-phenoxy-1-propanols through the enantioselective acylation mediated by Achromobacter sp. lipase

2-(Substituted phenoxy)-1-propanols, e.g. 2-(4-chlorophenoxy)-1-propanol, belonging to primary alcohols with an oxygen atom at the stereocenter, were resolved with moderate to good enantioselectivity, as judged by the value of enantiomeric ratio E (up to 27), through the enantioselective acylation with vinyl butanoate mediated by the little-known lipase from Achromobacter sp. in diisopropyl ether, after the examination of potential factors affecting the reaction such as organic solvents and acyl donors.     

Microbial kinetic resolution of 2-substituted-1-propanol

Micro-organisms that assimilate 2-phenylethanol were screened from soil and strains that enantioselectively oxidized 2-phenyl-1-propanol to 2-phenylpropanoic acid were selected. By optimizing the cultural conditions as well as the reaction conditions, various enantiomerically enriched 2-substituted propanoic acids and 2-aryl-1-propanols were obtained.     

Mycelial amylase activities of thermophilic species ofRhizomucor,Humicola andPapulaspora

Amylase activities in mycelia ofRhizomucor pusillus, Humicola grisea var.thermoidea, Humicola lanuginosa andPapulaspora thermophilia do not correspond directly with previously-measured extracellular values, and appear to decline within the time period corresponding to reduction in mycelial dry weight. The results are compared with previously-reported data on extracellular amylase.     

Enantioselective esterification of 2-methylbutyric acid catalyzed via lipase immobilized in microemulsion-based organogels

Chromobacterium viscosum lipase (c.v. lipase) was immobilized in microemulsion-based órganogels and successfully utilized for the enantioselective esterification of (+/?)-2-methylbutynic acid to preferentially form ethyl-(+)-2-methylbutyrate. The reaction time course and enantioselectivity obtained with the organogel—lipase system was compared and contrasted to that achieved in a reversed micellar solution system that contained lipase solubilized in its inner water core as well as that in which powdered lipases were directly dispersed in an organic solvent. The unique properties and potential benefits of the organogel system are discussed. © 1994 Wiley-Liss, Inc.     

Lipases fromRhizomucor miehei andHumicola lanuginosa: Modification of the lid covering the active site alters enantioselectivity

The homologous lipases fromRhizomucor miehei andHumicola lanuginosa showed approximately the same enantioselectivity when 2-methyldecanoic acid esters were used as substrates. Both lipases preferentially hydrolyzed theS-enantiomer of 1-heptyl 2-methyldecanoate (R. miehei:E _S =8.5;H. lanuginosa:E _S =10.5), but theR-enantiomer of phenyl 2-methyldecanoate (E _R =2.9). Chemical arginine specific modification of theR. miehei lipase with 1,2-cyclohexanedione resulted in a decreased enantioselectivity (E _R =2.0), only when the phenyl ester was used as a substrate. In contrast, treatment with phenylglyoxal showed a decreased enantioselectivity (E _S =2.5) only when the heptyl ester was used as a substrate. The presence of guanidine, an arginine side chain analog, decreased the enantioselectivity with the heptyl ester (E _S =1.9) and increased the enantioselectivity with the aromatic ester (E _R =4.4) as substrates. The mutation, Glu 87 Ala, in the lid of theH. lanuginosa lipase, which might decrease the electrostatic stabilization of the open-lid conformation of the lipase, resulted in 47% activity compared to the native lipase, in a tributyrin assay. The Glu 87 Ala mutant showed an increased enantioselectivity with the heptyl ester (E _S =17.4) and a decreased enantioselectivity with the phenyl ester (E _R =2.5) as substrates, compared to native lipase. The enantioselectivities of both lipases in the esterification of 2-methyldecanoic acid with 1-heptanol were unaffected by the lid modifications.     

Enantioselective resolution of 2-(1-hydroxy-3-butenyl)-5-methylfuran by immobilized lipase

An efficient and convenient strategy for synthesis of enantiomerically pure S-2-(1-hydroxy-3-butenyl)-5-methylfuran was for the first time described utilizing a lipase-mediated asymmetric acylation in organic solvents. Rhizopus arrhizus lipase was chosen as the biocatalyst, and different immobilization methods including sol–gel encapsulation and covalent attachment were adopted to improve its catalytic characteristics. Various influential factors of the reaction were also investigated. Finally, the results showed that the lipase covalently attached onto epoxy resin exhibited the highest enantioselectivity and operational stability. Under optimized reaction conditions, i.e., n-hexane as the solvent, 5/1 (mol/mol) of vinyl acetate to 2-(1-hydroxy-3-butenyl)-5-methylfuran and 30 °C, the ee value of S-1 reached up to above 98% at 52% conversion with an E value of 99.     

Kinetic resolution of 1-chloro-3-(1-naphthyloxy)-2-propanol,an intermediate in the synthesis of beta-adrenergic receptor blockers

(R)- and (S)-1-chloro-3-(1-naphthyloxy)-2-propanol are intermediates in the synthesis of β-adrenergic blocking agents and antihypertensive drugs such as propranolol and nadoxolol. Herein, improvement in the preparation of racemic 1-chloro-3-(1-naphthyloxy)-2-propanol generated from 1-naphthol and epichlorohydrin are reported. In addition, kinetic resolution studies have been conducted to obtain both (R) and (S)-1-chloro-3-(1-naphthyloxy)-2-propanol. These compounds were obtained in highly optically pure form by the stereoselective hydrolysis of its acyl derivatives using whole cell preparations containing enzymes from native sources. The results were compared with those obtained using commercial lipases.     

Enzymatic resolution of 2-phenyl-1-propanol by enantioselective hydrolysis of its ester having a bulky group in an acyl moiety

Enzymatic resolution of 2-phenyl-1-propanol, enantiomeric ratios of which were recently improved up to 31 and 41 with lipase PS and PPL, respectively, by transesterification using vinyl 3-phenylpropanoate, was more excellently attained by PPL-catalyzed hydrolysis of its ester of 3-phenylpropanoic acid in 107 of E value.     

Lactones 29 . Enzymatic resolution of racemic γ-lactones

Studies on the application of commercially available enzymes to resolution of the racemic unsaturated γ-lactones: 5-(3-methylbutylidene)-4-methyl-tetrahydrofuran-2-one (1a) and 5-(3,3-dimethylbutylidene)-4-methyl-tetrahydrofuran-2-one (2a) are presented. Lipase PS, Rhizopus niveus lipase, Rhizopus arrhizus lipase, porcine pancreas lipase and hog liver esterase transformed substrates into their respective γ-keto acids with good efficiency (50-75%). Three of them hydrolysed the studied lactones with moderate enantioselectivity. Enantiomeric excesses determined by GC for the unreacted lactones were in the range of 20-60%. Lipase PS preferentially hydrolysed the (+) enantiomers of lactones 1a and 2a whereas R. niveus lipase hydrolysed the (-) enantiomers, respectively.     

Enhanced activity and enantioselectivity of Candida rugosa lipase immobilized on macroporous adsorptive resins for ibuprofen resolution

The lipase from Candida rugosa was immobilized on three commercially available macroporous adsorptive resins for kinetic resolution of ibuprofen. One resin, CRB02, increased the enzyme activity by 50% to 0.027 g g(-1) min(-1). The deactivation constant (0.19 h(-1)) of the immobilized enzyme was half of that of the native enzyme and the enantioselectivity (E = 29.2) of the immobilized lipase was 2.2 times as much as that of the native lipase for the kinetic resolution of ibuprofen with 1-propanol in isooctane at 30 degrees C.     

Enantioselective ester hydrolase from Sphingobacterium sp. 238C5 useful for chiral resolution of β-phenylalanine and for its β-peptide synthesis

A novel enzyme, β-phenylalanine ester hydrolase, useful for chiral resolution of β-phenylalanine and for its β-peptide synthesis was characterized. The enzyme purified from the cell free-extract of Sphingobacterium sp. 238C5 well hydrolyzed β-phenylalanine esters (S)-stereospecifically. Besides β-phenylalanine esters, the enzyme catalyzed the hydrolysis of several α-amino acid esters with l-stereospecificity, while the deduced 369 amino acid sequence of the enzyme exhibited homology to alkaline d-stereospecific peptide hydrolases from Bacillus strains. Escherichia coli transformant expressing the β-phenylalanine ester hydrolase gene exhibited an about 8-fold increase in specific (S)-β-phenylalanine ethyl ester hydrolysis as compared with that of Sphingobacterium sp. 238C5. The E. coli transformant showed (S)-enantiomer specific esterase activity in the reaction with a low concentration (30 mM) of β-phenylalanine ethyl ester, while it showed both esterase and transpeptidase activity in the reaction with a high concentration (170 mM) of β-phenylalanine ethyl ester and produced β-phenylalanyl-β-phenylalanine ethyl ester. This transpeptidase activity was useful for β-phenylalanine β-peptide synthesis.     

Formation and activities of xylanhydrolysing enzymes of Humicola grisea var thermoidea

A thermophilic fungus, Humicola grisea var thermoidea, produced in liquid culture two endoxylanases (1,4--d-xylan-xylanohydrolase, EC 3.2.1.8) with M _r of 95 (Xyl I) and 13 (Xyl II) kDa. PAGE of the crude culture filtrate and of each fraction obtained by gel filtration produced three and one band, respectively. Cross-reaction of the culture filtrate and each fraction with polyclonal antibodies prepared against Xyl II produced two and one precipitin bands, respectively. Hydrolysis of wheat straw and rice husk xylan was maximal using a combination of Xyl I and Xyl II. The products formed after hydrolysis, xylo-oligosaccharides and traces of xylose, indicated an endotype enzyme action and the co-operative activities of the xylanases.     

Aminolysis of 2-hydroxy esters catalyzed by Candida antarctica lipase

Candida antarctica lipase catalyzed the aminolysis of 2-hydroxy esters with amines in organic solvents to yield the corresponding 2-hydroxy amides. The reactions proceeded at 28–30 °C in dioxane for 6 h with 3 mM substrates with yields ranging between 45% (w/w) (for branched substrates) to 88% (w/w) (for linear substrates). Although the reaction was not enantioselective, because of its simplicity it represents an alternative method for the synthesis of functionalised amides.     

Metabolic engineering of Thermobifida fusca for direct aerobic bioconversion of untreated lignocellulosic biomass to 1-propanol

Biofuel production from renewable resources can potentially address lots of social, economic and environmental issues but an efficient production method has yet to be established. Combinations of different starting materials, organisms and target fuels have been explored with the conversion of cellulose to higher alcohols (1-propanol, 1-butanol) being one potential target. In this study we demonstrate the direct conversion of untreated plant biomass to 1-propanol in aerobic growth conditions using an engineered strain of the actinobacterium, Thermobifida fusca. Based upon computational predictions, a bifunctional butyraldehyde/alcohol dehydrogenase was added to T. fusca leading to 1-propanol production during growth on glucose, cellobiose, cellulose, switchgrass and corn stover. The highest 1-propanol titer (0.48 g/L) was achieved for growth on switchgrass. These results represent the first demonstration of direct conversion of untreated lignocellulosic biomass to 1-propanol in an aerobic organism and illustrate the potential utility of T. fusca as an aerobic, cellulolytic bioprocess organism.     

Immobilization to improve the properties of Pseudomonas fluorescens lipase for the kinetic resolution of 3-aryl-3-hydroxy esters

Lipase AK “Amano” 20 from Pseudomonas fluorescens (PFL) was immobilized using diverse immobilization techniques. The methods developed, especially the optimized sol-gel procedure, enabled the fine tuning of enzymatic activity and enantioselectivity for the kinetic resolution of racemic ethyl 3-aryl-3-hydroxypropanoates. The aryl moieties of the racemates include furan-2 and 3-yl, thiophen-2 and 3-yl, benzofuran-2-yl, benzo[b]thiophen-2-yl, as well as phenyl and 4-chloro- and 4-methoxyphenyl groups. The optimized PFL sol-gel preparation (encapsulation from the aqueous solution of PFL, sucrose and Celite in situ) was shown to be efficiently reusable in ten cycles and highly enantioselective with E > 200 to all other substrates except furan-2 and 3-yl and thiophen-2 and 3-yl substituted compounds with E 108-184.     

Candida antarctica lipase-B-catalyzed kinetic resolution of 1,3-dialkyl-3-hydroxymethyl oxindoles

Candida antarctica (CAL-B) lipase-catalyzed resolution of 1,3-dialkyl-3-hydroxymethyl oxindoles has been performed to obtain (R)-1,3-dialkyl-3-acetoxymethyl oxindoles with up to 99% ee and (S)-1,3-dialkyl-3-hydroxymethyl oxindoles with up to 78% ee using vinyl acetate as acylating agent and acetonitrile as solvent transforming (S)-3-allyl-3-hydroxymethyl oxindole to (3S)-1′-benzyl-5-(iodomethyl)-4,5-dihydro-2H-spiro[furan-3,3′-indolin]-2′-one. The optically active 3-substituted-3-hydroxymethyl oxindoles and spiro-oxindoles are among the key synthons in the synthesis of potentially biologically active molecules.     

Enhancement of enzyme activity and enantioselectivity by cyclopentyl methyl ether in the transesterification catalyzed by <Emphasis Type="Italic">Pseudomonas cepacia</Emphasis> lipase co-lyophilized with cyclodextrins

The solvent effects of cyclopentyl methyl ether (CPME) on the reaction rates and enzyme enantioselectivity in the enantioselective transesterifications of racemic 6-methyl-5-hepten-2-ol (racemic sulcatol: SUL) and racemic 2,2-dimethyl-1,3-dioxolane-4-methanol (racemic solketal: SOL) with a series of enol esters catalyzed by Pseudomonas cepacia lipase co-lyophilized with cyclodextrins (-, -, -, partially methylated -,and 2,3,6-tri-O-methyl--cyclodextrin: CyD; CyD; CyD; Me_1.78 CyD; Me₃CyD) were investigated and compared with those in diisopropyl ether (IPE). In the case of SUL, enzyme activities of the co-lyophilizate with Me_1.78 CyD in CPME were lower than those in IPE with every acyl source, however, the absolute enantiopreference was shown in the transesterification with vinyl butyrate (VBR) in IPME. When the substrates were SOL and VBR, the enzyme activities in CPME were greatly enhanced as high as 1.6–9.8-fold, while the enantioselectivities in CPME were comparable to those in IPE.Revisions requested 16 December 2004; Revisions received 17 January 2005     

Resolution of 2-phenoxy-1-propanols through the enantioselective acylation mediated by Achromobacter sp. lipase as biocatalyst

Enantioselective acylation employing vinyl alkanoates as acyl donors was exploited for the resolution of 2-(substituted phenoxy)-1-propanols carrying different substituents on the benzene ring using Achromobacter sp. lipase. These primary alcohols with an oxygen atom at the stereocenter, were resolved with moderate to good enantioselectivity, based on the enantiomeric ratio E (up to 27), through acylation with vinyl butanoate in diisopropyl ether, after the examination of potential factors affecting the reaction such as organic solvents and acyl donors. Using this procedure, enantiomerically enriched (R)-2-(4-chlorophenoxy)-1-propanol was prepared in 97% e.e. and 33% yield in a gram-scale reaction.