东方栓孔菌在染料脱色中的应用及其脱色条件的优化

本研究利用东方栓孔菌(Trametes orientalis)菌株Cui 6300发酵所得的粗酶液,对刚果红、结晶紫、铬天青、亚甲基蓝和中性红5种染料进行了催化脱色试验,并对其中脱色效果较好的染料进行了脱色条件优化.结果表明:东方栓孔菌漆酶粗酶液对结晶紫有相对较好的脱色效果.添加2,2'-连氮-双(3-乙基苯并噻唑-6-磺酸) (ABTS)的粗酶液对结晶紫的降解效果没有明显促进作用,因此后续试验中直接采用粗酶液.脱色条件优化结果为:最佳初始pH值6.0,最佳培养温度55℃,最佳接种量2.0%,最佳转速160 r/min,最佳底物浓度160 mg/L.在此条件下反应96 h,脱色率可达98.45%.本试验说明东方栓孔菌在印染废水治理方面具有较好的应用前景,可以作为一种新型菌株应用于染料脱色.     

绒毛栓孔菌菌丝体在无营养条件下对偶氮染料刚果红的脱色作用

【目的】在无营养条件下,利用白腐真菌绒毛栓孔菌(Trametes pubescens)菌丝体对染料进行脱色可减少试验成本,提高染料处理的实用性。【方法】将该菌株液体培养的菌丝体在无营养条件下对染料进行脱色,并对其中脱色效果较好的偶氮染料刚果红的脱色过程进行分析。在此过程中,测定了该菌株分泌的胞外胞内酶活力,优化影响因子如初始pH值、温度、染料浓度和盐度,同时利用气相色谱-质谱联用技术分析无营养条件下偶氮染料刚果红的降解产物。植物毒性试验测定刚果红经绒毛栓孔菌菌丝体脱色前后的毒性变化。【结果】菌丝体对偶氮染料刚果红有较好的脱色效果,在初始pH值为2.0,温度为30°C,染料浓度为80 mg/L,盐度为2.5%(质量体积比)时,150 r/min转速下培养7 d后脱色率可达80.52%。在此过程中,菌丝体可被连续使用2次,且其所分泌的酶系可降解染料。此外,通过气相色谱-质谱联用分析得到刚果红的降解产物为萘胺、联苯胺和叠氮萘。植物毒性试验显示在无营养条件下的绒毛栓孔菌菌丝体对染料有明显的脱毒作用。【结论】研究发现绒毛栓孔菌菌丝体在无营养条件下的偶氮染料废水处理中具有广阔的应用前景。     

粗毛栓菌菌丝球非灭菌条件下对12种染料的脱色研究

以新型白腐真菌——粗毛栓菌Trametes gallica为材料,研究了优化后的该菌菌丝球在非灭菌条件下对直接染料、中性染料、三苯甲烷类染料以及蒽醌类染料共12种染料的脱色能力、脱色机制,以及pH、温度、染料初始浓度等参数对该菌菌丝球脱色效果的影响。结果表明,优化条件下制备的粗毛栓菌菌丝球脱色活力良好,4℃下保存20d后仍保持有原脱色活力的95%;活菌丝球比死菌丝球对染料具有更强的耐受性和更好的脱色效果;非灭菌条件下活菌丝球对12种染料的适宜脱色条件为pH 3.0–5.0、25℃、染料浓度为50mg/L、处理36–60h,该条件下粗毛栓菌菌丝球在60h内脱色率均在55%以上,其中粗毛栓菌菌丝球对亚甲基蓝脱色率最高可达到96.40%。紫外可见光谱分析和显微观察结果表明,48h内粗毛栓菌菌丝球在非灭菌条件下对12种染料的脱色是由吸附引起,无二次污染物的产生。粗毛栓菌的这些优良特性显示了其在工业染料废水处理中的广阔应用前景。     

禾本红酵母Y－5对结晶紫、孔雀石绿的吸附

研究了培养时间、初始pH、温度对禾本红酵母Y-5吸附结晶紫、孔雀石绿的影响,并对吸附剂的解吸和循环利用等进行考察.结果表明： 在染料浓度为50 mg·L^-1、pH 7.0、摇床转速150 r·min^-1、30 ℃、吸附10 h时,红酵母对结晶紫、孔雀石绿的吸附率分别达峰值,为93.8%和87.7%;解吸后的菌体对结晶紫、孔雀石绿的吸附率分别为85.5%和78.5%,说明菌体对染料的吸附是可逆的,循环利用效果良好,菌体可再生和循环利用;禾本红酵母Y-5对结晶紫、孔雀石绿的脱色机理为吸附作用,染料多被吸附在红酵母表面的羟基（-OH）上,其吸附染料快速、高效、可逆,在染料废水处理上具有潜在的应用价值.     

撕裂蜡孔菌在开放体系中对甲基橙染料的静态脱色研究

为了评价撕裂蜡孔菌处理偶氮染料的应用潜力,用性能稳定的甲基橙染料为材料,采用批次试验在开放性体系中研究了染料初始浓度、菌丝生物量、温度、pH等因素对该菌脱色能力的影响,运用菌丝体反接、染液光谱扫描、菌丝体显微观察等方法探讨了菌丝体脱色的可能机制,利用植物萌发试验进行了染料和脱色后溶液的毒性测试。结果表明,撕裂蜡孔菌在开放的静止体系中能够对甲基橙高效脱色,其最适脱色温度为35℃,最佳脱色pH值在6左右。菌丝对甲基橙的脱色表现在吸附和产酶降解两个方面,脱色过程中染料对菌丝体本身的影响较少。植物毒性分析显示撕裂蜡孔菌脱色48h后的产物对植物的毒性比甲基橙本身更强,若要彻底降解可能需要较长时间。本研究可为染料脱色工艺提供新的菌种。     

白腐真菌染料脱色菌株的筛选及一色齿毛菌脱色条件的研究

以平皿培养方式对采集自中国和芬兰的白腐真菌菌株降解6种不同结构的人工染料的能力进行了筛选研究。在40株菌株中,黑管孔菌Bjerkandera adusta Y5012,一色齿毛菌Cerrena unicolor Y5002,硬毛粗盖孔菌Funalia trogii Y4997,香栓孔菌Trametes suaveolens D8325和云芝栓孔菌Trametes versicolor Y4946对刚果红、橙黄G、茜素红、结晶紫、中性红和亚甲基蓝均显示出较强的脱色能力。对一色齿毛菌Cerrena unicolor Y5002的液体培养脱色条件进行了研究,其最适碳源和氮源分别为蔗糖和麦芽浸粉;在不同橙黄G浓度下均获得较高的脱色率,因此浓度为500mg/L的橙黄G未对该菌的脱色能力产生抑制作用,而浓度为400mg/L茜素红则对其脱色作用产生明显抑制。对菌丝生物量和染料脱色率的研究表明,在不同碳源和氮源条件下,两者之间具有明显的正相关性。     

粗毛栓菌和蜡状芽孢杆菌及其共固定菌对Pb2+的吸附

将粗毛栓菌菌丝球与蜡状芽孢杆菌共固定为共固定菌.以粗毛栓菌菌丝球、蜡状芽孢杆菌和共固定菌为研究对象,测定不同吸附时间、初始pH、吸附剂浓度和Pb²⁺浓度对3种生物吸附剂吸附Pb²⁺的影响,并将3种生物吸附剂吸附Pb²⁺前后的红外吸收光谱进行分析比较.结果表明： 在吸附剂浓度为2 g·L^-1、pH为5.0、Pb²⁺浓度为50 mg·L^-1条件下对Pb²⁺吸附1 h效果良好,其吸附率分别为71.7%、91.0%和96.9%.生物吸附剂红外光谱主要由蛋白质、碳水化合物和含硫、磷酸基团的吸收带组成,表明对Pb²⁺吸附起主要作用的官能团是羟基、羧基、磷酸基和含硫基团.     

粗毛栓菌和蜡状芽孢杆菌及其共固定菌对pb2+的吸附

将粗毛栓菌菌丝球与蜡状芽孢杆菌共固定为共固定菌.以粗毛栓菌菌丝球、蜡状芽孢杆菌和共固定菌为研究对象,测定不同吸附时间、初始pH、吸附剂浓度和pb2+浓度对3种生物吸附剂吸附pb2+的影响,并将3种生物吸附剂吸附pb2+前后的红外吸收光谱进行分析比较.结果表明:在吸附剂浓度为2g.L-1、pH为5.0、pb2+浓度为50 mg·L-1条件下对pb2+吸附lh效果良好,其吸附率分别为71.7％、91.0％和96.9％.生物吸附剂红外光谱主要由蛋白质、碳水化合物和含硫、磷酸基团的吸收带组成,表明对pb2+吸附起主要作用的官能团是羟基、羧基、磷酸基和含硫基团.     

三种白腐真菌脱色噻嗪染料亚甲基蓝

本研究通过含亚甲基蓝染料的固体培养基,从19株白腐真菌菌株中分离获得3个脱色能力较强的菌株,其在平板上的脱色圈大小分别为7.5cm、6.8cm和5.5cm。鉴定其为：云芝栓孔菌Trametes versicolor（ZT-197）,绒毛栓孔菌Trametes pubescens（ZT-230）和亚黑管孔菌Bjerkandera fumosa（ZT-307）。其中,ZT-230对染料亚甲基蓝的脱色能力最强,可以将染料浓度为50mg/L的100mL液体培养基在6d之内100%脱色,而ZT-197和ZT-307在接种第10天时的脱色率为98%和80%。同时测定了3株白腐真菌在降解染料过程中的漆酶、锰过氧化物酶和木素过氧化物酶3种酶活力的规律：ZT-197和ZT-230均可分泌Lac和MnP两种酶,ZT-307只分泌LiP。本研究说明绒毛栓孔菌ZT-197在印染废水治理方面具有较好的应用前景。     

固定化乳白耙齿菌脱色茜素红的研究

利用海藻酸钙法对乳白耙齿菌进行固定化,检测固定化乳白耙齿菌（固定化菌）对几种染料的脱色能力。同时,考察pH值、染料浓度、金属离子、碳源种类、氮源种类、盐浓度对固定化菌脱色茜素红的影响。结果表明,固定化菌的优化条件为海藻酸钠3%、氯化钙5%、固定化时间6h、接菌量10g/100mL;固定化菌对6种染料均可脱色,其中对茜素红染料的脱色效果最为明显;固定化菌对茜素红的脱色率随染料浓度的增加而下降,当染料浓度高于250mg/L时,其脱色效果明显下降;固定化菌对茜素红脱色的适宜pH为7,适宜碳源为可溶性淀粉、适宜氮源为硝酸铵。另外,固定化菌对茜素红的脱色率随盐浓度的升高,呈下降趋势,当盐浓度高于3%时,脱色率下降明显;固定化菌于生理盐水中保存10d后,脱色率维持在较高水平,达94.20%;固定化菌重复利用5次后,脱色率仍高达88.70%。     

白囊耙齿菌对茜素红脱色条件优化及其毒性变化检测

白囊耙齿菌Irpex lacteus是分离自倒木上的一株可以分泌漆酶和锰过氧化物酶的白腐真菌。利用I. lacteus对固体条件下的活性黑、活性红、结晶紫、茜素红和孔雀石绿进行脱色能力的检测,通过单因素和正交试验优化I. lacteus对茜素红的脱色条件,并以3种作物发芽率为指标测定茜素红被I. lacteus脱色前后的毒性变化。结果显示,I. lacteus对5种染料均可脱色,其中对茜素红染料的脱色更为彻底;单因素和正交试验优化I. lacteus对茜素红的脱色条件为：pH 7.0、葡萄糖10.0g/L、硫酸铵0.66g/L、接种量2片（Φ=8.0mm）、100.0mL三角瓶装液20.0mL,优化条件下I. lacteus对茜素红脱色10d时的脱色率为88.26%,与未优化前的脱色率相比提高了60.50%;茜素红染料被I. lacteus脱色前后毒性大小排序为：染料原液>染料脱色后>PDB培养基处理,表明茜素红染料存在一定的毒性,I. lacteus脱色茜素红后可以使其毒性减弱。通过本研究,为I. lacteus在茜素红等染料废水脱色以及降低染料废水毒性方面的应用奠定基础。     

Adsorption of methyl violet from aqueous solutions by the biochars derived from crop residues

The adsorption of methyl violet by the biochars from crop residues was investigated with batch and leaching experiments--adsorption capacity varied with their feedstock in the following order: canola straw char>peanut straw char>soybean straw char>rice hull char. This order was generally consistent with the amount of negative charge of the biochars. Zeta potentials and Fourier transform infrared photoacoustic spectroscopy, combined with adsorption isotherms and effect of ionic strength, indicated that adsorption of methyl violet on biochars involved electrostatic attraction, specific interaction between the dye and carboxylate and phenolic hydroxyl groups on the biochars, and surface precipitation. Leaching experiments showed that 156 g of rice hull char almost completely removed methyl violet from 18.2 L of water containing 1.0 mmol/L of methyl violet. The biochars had high removal efficiency for methyl violet and could be effective adsorbents for removal of methyl violet from wastewater.     

Extractive biodecolorization of triphenylmethane dyes in cloud point system by Aeromonas hydrophila DN322p

The biological treatment of triphenylmethane dyes is an important issue. Most microbes have limited practical application because they cannot completely detoxicate these dyes. In this study, the extractive biodecolorization of triphenylmethane dyes by Aeromonas hydrophila DN322p was carried out by introducing the cloud point system. The cloud point system is composed of a mixture of nonionic surfactants (20 g/L) Brij 30 and Tergitol TMN-3 in equal proportions. After the decolorization of crystal violet, a higher wet cell weight was obtained in the cloud point system than that of the control system. Based on the results of thin-layer chromatography, the residual crystal violet and its decolorized product, leuco crystal violet, preferred to partition into the coacervate phase. Therefore, the detoxification of the dilute phase was achieved, which indicated that the dilute phase could be discharged without causing dye pollution. The extractive biodecolorization of three other triphenylmethane dyes was also examined in this system. The decolorization of malachite green and brilliant green was similar to that of crystal violet. Only ethyl violet achieved a poor decolorization rate because DN322p decolorized it via adsorption but did not convert it into its leuco form. This study provides potential application of biological treatment in triphenylmethane dye wastewater.     

Characterization of mesoporous activated carbons prepared by pyrolysis of sewage sludge with pyrolusite

Activated carbons were prepared from sewage sludge by chemical activation. Pyrolusite was added as a catalyst during activation and carbonization. The influence of the mineral addition on the properties of the activated carbons produced was evaluated. The results show that activated carbons from pyrolusite-supplemented sewage sludge had up to a 75% higher BET surface area and up to a 66% increase in mesoporosity over ordinary sludge-based activated carbons. Batch adsorption experiments applying the prepared adsorbents to synthetic dye wastewater treatment yielded adsorption data well fitted to the Langmuir isotherm. The adsorbents from pyrolusite-supplemented sludges performed better in dye removal than those without mineral addition, with the carbon from pyrolusite-augmented sludge T2 presenting a significant increase in maximum adsorption capacity of 50 mg/g. The properties of the adsorbents were improved during pyrolusite-catalyzed pyrolysis via enhancement of mesopore production, thus the mesopore channels may provide fast mass transfer for large molecules like dyes.     

Staining Scab Actinomyces in Potato Tuber Tissues

Actinomyces hyphae imbedded in the middle lamellae of potato tuber cells may be stained in sections by the use of a modified Gram's stain. The modifications are: a very strong (5%) solution of crystal violet in anilin oil; a 24-hour exposure to both the dye and the iodine solution; and a slow decolorization in absolute alcohol until no more color flows.     

Decolorization and biotransformation of triphenylmethane dye, methyl violet, by Aspergillus sp. isolated from Ladakh, India

Methyl violet, used extensively in the commercial textile industry and as a biological stain, is a hazardous recalcitrant. Aspergillus sp. strain CB-TKL-1 isolated from a water sample from Tsumoriri Lake, Karzok, Ladakh, India, was found to completely decolorize methyl violet within 24 h when cultured under aerobic conditions at 25 degrees C. The rate of decolorization was determined by monitoring the decrease in the absorbance maxima of the dye by UV-visible spectroscopy. The decolorization of methyl violet was optimal at pH 5.5 and 30 degrees C when agitated at 200 rpm. Addition of glucose or arabinose (2%) as a carbon source and sodium nitrate or soyapeptone (0.2%) as a nitrogen source enhanced the decolorization ability of the culture. Furthermore, the culture exhibited a maximum decolorization rate of methyl violet after 24 h when the C:N ratio was 10. Nine N-demethylated decolorized products of methyl violet were identified based on UV-visible spectroscopy, Fourier transform infrared (FTIR), and LC-MS analyses. The decolorization of methyl violet at the end of 24 h generated mono-, di-, tri-, tetra-, penta-, and hexa-Ndemethylated intermediates of pararosaniline. The variation of the relative absorption peaks in the decolorized sample indicated a linear decrease of hexa-N-demethylated compounds to non-N-demethylated pararosaniline, indicating a stepwise N-demethylation in the decolorization process.     

Studies in gram staining.

Gram-negative bacteria stained with crystal violet are decolorized by 95% alcohol within 2 min, whereas Gram-positive bacteria require at least 3 min treatment. Aqueous solutions of safranin, neutral red, and fuschsin replace crystal violet from stained Gram-positive bacteria more quickly than alcohol alone, and alcoholic solutions of these counterstains are in most cases still more effective. Treatment of crystal violet-stained organisms with alcoholic safranin (0.25%) for 15 sec will distinguish Gram-positive bacteria (violet) from Gram-negative bacteria (pink). Alcohol containing very low concentrations of iodine generally decolorizes crystal violet-stained Gram-positive bacteria more quickly than alcohol alone. Increasing concentrations of iodine in alcohol reduce the rate of decolorization of stained bacteria, but stained Gram-negative bacteria are still readily decolorized. The addition of 0.1% iodine to alcohol increases the rate of extraction of crystal violet by alcohol from Gram-negative organisms, but delays extraction of dye from Gram-positive organisms, and this applies when counterstain is also present. A two-solution modification of Gram staining is described in which crystal violet-stained bacteria are treated with an alcoholic solution of safranin, fuchsin, and iodine.     

胶红酵母JB401降解脱色三苯甲烷类染料

从烟梗中分离筛选得到1株能够对三苯甲烷类染料高效脱色的微生物,经ITS-5.8S rDNA分析鉴定为胶红酵母,命名为Rhodotorula mucilaginosa JB401。全波长扫描实验结果证实染料的脱色由胶红酵母降解结晶紫引起。为了提高R.mucilaginosa JB401脱色结晶紫的能力,通过单因素试验对R.mucilaginosa JB401的培养条件进行了优化,得出菌体生长24 h后以2%接种量接入初始pH为5的脱色培养基并在37℃摇床培养,可以取得最优脱色效果,此时脱色50、100和200 mg/L的结晶紫达到90%去除率分别需要3、6和14 h。此外,胶红酵母对温度和pH良好的适应性使其具有应用于工业废水处理的潜力。