Pullulan fermentation using a prototype rotational reciprocating plate impeller

A rotational reciprocating plate impeller prototype, designed to improve the mixing homogeneity of viscous non-Newtonian fermentation broth, has been tested in pullulan fermentations. With this new impeller, the operating levels of several factors were investigated to improve pullulan production with Aureobasidium pullulans ATCC 42023 in a 22-L bioreactor using experimental designs. Because both high molecular weight (MW) and high concentration of pullulan were desired; the exopolysaccharide (EPS) concentration and the broth viscosity were used as optimization objective functions to be maximized. A 6-run uniform design was used to investigate five factors. Under the best operating conditions among the six runs, 29.0 g L^?1 EPS was produced at 102 h. This condition was used as the starting point for further investigation on the two statistically significant factors, the pH and the agitation speed. An 8-run 3-level custom design that investigates up to second-order effects was used in the second stage. An optimal zone of operating conditions for large quantity of high MW pullulan production was identified. A concentration of 23.3 g L^?1 EPS was produced at 78 h. This is equivalent to an EPS productivity of 0.30 g L^?1 h^?1. The corresponding apparent viscosity of the broth was 0.38 Pa s at the shear rate of 10 s^?1.     

Production and characterisation of exopolysaccharide from Streptomyces carpaticus isolated from marine sediments in Egypt and its effect on breast and colon cell lines

Twenty streptomycete strains were isolated from marine sediment samples collected from Nabq area, Sharm El-Sheikh, Red Sea Coast, Egypt. Four of them produce exopolysaccharides (EPS) showing marked in vitro antitumor activities. Morphological and cultural characteristics of the most significant strain (No. 3) were shown. Moreover, the sequence of this strain showed similarity with Streptomyces carpaticus. The results reveal that EPS produced by Streptomyces carpaticus No. 3 had high cytotoxicity reaching 51.7% and 59.1% against human tumor cells of breast and colon lines respectively. A chemical analysis of EPS indicated that the composing monosaccharides were galactouronic acid, glucose, xylose, galactose, mannose, and fructose with relative ratio of 3:1:1:2:2:1 respectively, with an average molecular weight (Mw) 1.180 × 10⁵?g/mol and of a number average molecular weight (Mn) 1.052 × 10⁵?g/mol. Also the EPS contained uronic acid (0.5072%) and monosaccharide sulphates (21.753%).     

A Novel EPS-Producing Strain of Bacillus licheniformis Isolated from a Shallow Vent Off Panarea Island (Italy)

A haloalkaliphilic, thermophilic Bacillus strain (T14), isolated from a shallow hydrothermal vent of Panarea Island (Italy), produced a new exopolysaccharide (EPS). Phylogenetic analysis based on 16S rRNA gene sequences showed that strain T14 was highly related (99 % similarity) to Bacillus licheniformis DSM 13^T and Bacillus sonorensis DSM 13779^T. Further DNA–DNA hybridization analysis revealed 79.40 % similarity with B. licheniformis DSM 13^T and 39.12 % with B. sonorensis DSM 13779^T. Sucrose (5 %) was the most efficient carbon source for growth and EPS production. The highest EPS production (366 mg l^?1) was yielded in fermenter culture at 300 rpm after 48 h of incubation. The purified fraction EPS1 contained fructose/fucose/glucose/galactosamine/mannose in a relative proportion of 1.0:0.75:0.28:tr:tr and possessed a molecular weight of 1,000 kDa displaying a trisaccharide unit constituted by sugars with a β-manno-pyranosidic configuration. Screening for biological activity showed anti-cytotoxic effect of EPS1 against Avarol in brine shrimp test, indicating a potential use in the development of novel drugs.     

Comparison of Thraustochytrids Aurantiochytrium sp., Schizochytrium sp., Thraustochytrium sp., and Ulkenia sp. for Production of Biodiesel,Long-Chain Omega-3 Oils,and Exopolysaccharide

Heterotrophic growth of thraustochytrids has potential in coproducing biodiesel for transportation, as well as producing a feedstock for omega-3 long-chain (≥C20) polyunsaturated fatty acids (LC-PUFA), especially docosahexaenoic acid (DHA) for use in nutraceuticals. In this study, we compared eight new endemic Australian thraustochytrid strains from the genera Aurantiochytrium, Schizochytrium, Thraustochytrium, and Ulkenia for the synthesis of exopolysaccharide (EPS), in addition to biodiesel and LC-PUFA. Aurantiochytrium sp. strains readily utilized glucose for biomass production, and increasing glucose from 2 to 4 % w/v of the culture medium resulted in increased biomass yield by an average factor of 1.7. Ulkenia sp. strain TC 010 and Thraustochytrium sp. strain TC 033 did not utilize glucose, while Schizochytrium sp. strain TC 002 utilized less than half the glucose available by day 14, and Thraustochytrium sp. strain TC 004 utilized glucose at 4 % w/v but not 2 % w/v of the culture suggesting a threshold requirement between these values. Across all strains, increasing glucose from 2 to 4 % w/v of the culture medium resulted in increased total fatty acid methyl ester content by an average factor of 1.9. Despite an increasing literature demonstrating the capacity of thraustochytrids for DHA synthesis, the production of EPS from these organisms is not well documented. A broad range of EPS yields was observed. The maximum yield of EPS was observed for Schizochytrium sp. strain TC 002 (299 mg/L). High biomass-producing strains that also have high lipid and high EPS yield may be better candidates for commercial production of biofuels and other coproducts.     

Biosynthesis of the carbohydrate moieties of arabinogalactan proteins by membrane-bound β-glucuronosyltransferases from radish primary roots

A membrane fraction from etiolated 6-day-old primary radish roots (Raphanus sativus L. var hortensis) contained β-glucuronosyltransferases (GlcATs) involved in the synthesis of the carbohydrate moieties of arabinogalactan proteins (AGPs). The GlcATs transferred [¹⁴C]GlcA from UDP-[¹⁴C]GlcA on to β-(1 → 3)-galactan as an exogenous acceptor substrate, giving a specific activity of 50–150 pmol min^?1 (mg protein)^?1. The enzyme specimen also catalyzed the transfer of [¹⁴C]GlcA on to an enzymatically modified AGP from mature radish root. Analysis of the transfer products revealed that the transfer of [¹⁴C]GlcA occurred preferentially on to consecutive (1 → 3)-linked β-Gal chains as well as single branched β-(1 → 6)-Gal residues through β-(1 → 6) linkages, producing branched acidic side chains. The enzymes also transferred [¹⁴C]GlcA residues on to several oligosaccharides, such as β-(1 → 6)- and β-(1 → 3)-galactotrioses. A trisaccharide, α-l-Araf-(1 → 3)-β-Gal-(1 → 6)-Gal, was a good acceptor, yielding a branched tetrasaccharide, α-l-Araf-(1 → 3)[β-GlcA-(1 → 6)]-β-Gal-(1 → 6)-Gal. We report the first in vitro assay system for β-GlcATs involved in the AG synthesis as a step toward full characterization and cloning.     

β-(1→6)-<Emphasis Type="SmallCaps">d</Emphasis>-glucan secreted during the optimised production of exopolysaccharides by <Emphasis Type="Italic">Paecilomyces variotii</Emphasis> has immunostimulatory activity

Paecilomyces variotii is a filamentous fungus that occurs worldwide in soil and decaying vegetation. Optimization of the fermentation process for exopolysaccharide (EPS) production from the fungus P. variotii, structure determination and immuno-stimulating activity of EPS were performed. Response surface methodology (RSM) coupled with central composite design (CCD) was used to optimize the physical and chemical factors required to produce EPS in submerged fermentation. Preliminary investigations to choose the three factors for the present work were made using a factorial experimental design. Glucose, ammonium nitrate (NH₄NO₃) and pH were used as variables for which, with constant temperature of 28 °C and agitation of 90 rpm, the optimal process parameters were determined as glucose values of 0.96%, NH₄NO₃ 0.26% and pH 8.0. The three parameters presented significant effects. In this condition of culture, the main composition of the isolated EPS was a linear β-(1 → 6)-linked-D-glucan, as determined by Nuclear Magnetic Resonance (NMR) and methylation analysis. This polysaccharide is a very unusual as an EPS from fungi, especially a filamentous fungus such as P. variotii. Murine peritoneal macrophages cultivated with β-glucan for 6 and 48 h showed an increase in TNF-α, IL-6 and nitric oxide release with increased polysaccharide concentrations. Therefore, we conclude that the β-(1 → 6)-linked-D-glucan produced in optimised conditions of P. variotii cultivation has an immune-stimulatory activity on murine macrophages.     

Screening for and Identification of Starch-, Amylopectin-, and Pullulan-Degrading Activities in Bifidobacterial Strains

Forty-two bifidobacterial strains were screened for α-amylase and/or pullulanase activity by investigating their capacities to utilize starch, amylopectin, or pullulan. Of the 42 bifidobacterial strains tested, 19 were capable of degrading potato starch. Of these 19 strains, 11 were able to degrade starch and amylopectin, as well as pullulan. These 11 strains, which were shown to produce extracellular starch-degrading activities, included 5 strains of Bifidobacterium breve, 1 B. dentium strain, 1 B. infantis strain, 3 strains of B. pseudolongum, and 1 strain of B. thermophilum. Quantitative and qualitative enzyme activities were determined by measuring the concentrations of released reducing sugars and by high-performance thin-layer chromatography, respectively. These analyses confirmed both the inducible nature and the extracellular nature of the starch- and pullulan-degrading enzyme activities and showed that the five B. breve strains produced an activity that is consistent with type II pullulanase (amylopullulanase) activity, while the remaining six strains produced an activity with properties that resemble those of type III pullulan hydrolase.     

Exploring potential applications of a novel extracellular polymeric substance synthesizing bacterium (<Emphasis Type="Italic">Bacillus licheniformis</Emphasis>) isolated from gut contents of earthworm (<Emphasis Type="Italic">Metaphire posthuma</Emphasis>) in environmental remediation

The aim was to isolate, characterize, and explore potentials of gut bacteria from the earthworm (Metaphire posthuma) and imply these bacteria for remediation of Cu(II) and Zn(II). An extracellular polymeric substance (EPS) producing gut bacteria (Bacillus licheniformis strain KX657843) was isolated and identified based on 16S rRNA sequencing and phylogenetic analysis. The strain showed maximum tolerance of 8 and 6 mM for Cu(II) and Zn(II) respectively. It removed 34.5% of Cu(II) and 54.4% of Zn(II) at 25 mg L^?1 after 72 and 96 h incubation respectively. The bacteria possessed a great potential to produce indole acetic acid (38.49 μg mL^?1) at 5 mg mL^?1 l-tryptophan following 12 days incubation. The sterilized seeds of mung beans (Vigna radiata) displayed greater germination and growth under bacterium enriched condition. We observed that the bacterial strain phosphate solubilization ability with a maximum of 204.2 mg L^?1 in absence of Cu(II) and Zn(II). Endowed with biosurfactant property the bacterium exhibited 24% emulsification index. The bacterium offered significant potential of plant growth promotion, Cu(II) and Zn(II) removal, and as such this study is the first report on EPS producing B. licheniformis KX657843 from earthworm which can be applied as powerful tool in remediation programs of Cu(II) and Zn(II) contaminated sites.     

Histamine-producing bacteria in blue scad (Decapterus maruadsi) and their abilities to produce histamine and other biogenic amines

Using decarboxylation medium and 16S rDNA sequence analysis, histamine-producing bacteria (HPB) in blue scad (Decapterus maruadsi) were isolated and identified, and the histamine-producing abilities of the isolated HPB were determined. Nine mesophilic strains (H1–H9) isolated from the muscle of blue scad were identified as the genera of HPB, including Arthrobacter bergeri (H1), Pseudomonas sp. (H2, H5 and H6), Psychrobacter sp. (H3), Shewanella baltica (H4 and H7), and Aeromonas salmonicida (H8 and H9), respectively. Results showed that most of the HPB strains were weak on histamine formation (13.0–20.4 mg/l), except for the H8 strain with the ability of producing 115 mg of histamine/l in trypticase soy broth containing 1.0 % l-histidine. As the strongest HPB in blue scad, bacterial strain H8 also presented a strong ability to produce other biogenic amines, such as putrescine, cadaverine, spermidine, spermine, tyramine and tryptamine. Therefore, the H8 strain identified as the genus of A. salmonicida was the dominant mesophilic HPB strain for producing histamine and other biogenic amines in blue scad at room temperature.     

Optimization of physico‐chemical and nutritional parameters for a novel pullulan‐producing fungus,Eurotium chevalieri

Aims: To isolate the novel nonmelanin pullulan‐producing fungi from soil and to optimize the physico‐chemical and nutritional parameters for pullulan production. Methods and Results: A selective enrichment method was followed for the isolation, along with development of a suitable medium for pullulan production, using shake flask experiments. Pullulan content was confirmed using pure pullulan and pullulanase hydrolysate. Eurotium chevalieri was able to produce maximum pullulan (38 ± 1·0 g l^?1) at 35°C, pH 5·5, 2·5% sucrose, 0·3% ammonium sulfate and 0·2% yeast extract in a shake flash culture medium with an agitation rate of 30 rev min^?1 for 65 h. Conclusions: The novel pullulan‐producing fungus was identified as E. chevalieri (MTCC no. 9614), which was able to produce nonmelanin pullulan at from poorer carbon and nitrogen sources than Aureobasidium pullulans and may therefore be useful for the commercial production of pullulan. Significance and Impact of the Study: Eurotium chevalieri could produce pullulan in similar amounts to A. pullulans. Therefore, in future, this fungus could also be used for commercial pullulan production, because it is neither polymorphic nor melanin producing, hence its handling during pullulan fermentation will be easier and more economical.     

Spontaneous mutation frequency and molecular mechanisms of Shigella flexneri fluoroquinolone resistance under antibiotic selective stress

The incidence of fluoroquinolone-resistant Shigella strains has risen rapidly, presumably in response to ciprofloxacin antibiotic stress. Understanding the molecular mechanisms underlying this resistance phenotype is critical to developing novel and effective therapeutic strategies. In this study, the frequency of ciprofloxacin-induced mutation was measured in antibiotic resistance genes (gyrA, gyrB, parC, parE, marOR, and marA) of Shigella flexneri. The S. flexneri 2a strain 301 was cultured on Luria–Bertani agar plates containing one of seven different ciprofloxacin concentrations (range: 0.03125–2 μg mL^?1). Resistant colonies were selected for gene-targeted sequencing analysis; the identified point mutations were subsequently confirmed by insertion into antibiotic cassette plasmids and growth under ciprofloxacin stress. The results demonstrated that the seven different ciprofloxacin concentrations produced dose-dependent frequencies of spontaneous mutations: 10^?8 (0.03125 and 0.0625 μg mL^?1), 10^?9 (0.125 μg mL^?1), and <10^?9 (0.25, 0.5, 1, 2 μg mL^?1). PCR sequencing of the ten randomly selected resistant colonies (minimum inhibitory concentrations (MICs) of 0.125 μg mL^?1, n = 5 and 0.25 μg mL^?1, n = 5) revealed that all colonies had mutations in the gyrA gene at either codon 83 (Ser83 → Leu) or 87 (Asp87 → Tyr or → Gly), both of which were confirmed at MIC of 0.125 μg mL^?1. None of the spontaneous mutation colonies exhibited gyrB, parC, parE, marOR, or marA mutations. In conclusion, S. flexneri is normomutable under ciprofloxacin antibiotic stress and fluoroquinolone resistance by spontaneous mutation occurs at a low rate. Codon mutations gyrA 83 and/or gyrA 87 cause a 4-fold increase in the ciprofloxacin MIC, and may represent the natural mechanism of fluoroquinolone resistance.     

Role of Bacterial Exopolysaccharides (EPS) in the Fate of the Oil Released during the Deepwater Horizon Oil Spill

Halomonas species are recognized for producing exopolysaccharides (EPS) exhibiting amphiphilic properties that allow these macromolecules to interface with hydrophobic substrates, such as hydrocarbons. There remains a paucity of knowledge, however, on the potential of Halomonas EPS to influence the biodegradation of hydrocarbons. In this study, the well-characterized amphiphilic EPS produced by Halomonas species strain TG39 was shown to effectively increase the solubilization of aromatic hydrocarbons and enhance their biodegradation by an indigenous microbial community from oil-contaminated surface waters collected during the active phase of the Deepwater Horizon oil spill. Three Halomonas strains were isolated from the Deepwater Horizon site, all of which produced EPS with excellent emulsifying qualities and shared high (97-100%) 16S rRNA sequence identity with strain TG39 and other EPS-producing Halomonas strains. Analysis of pyrosequence data from surface water samples collected during the spill revealed several distinct Halomonas phylotypes, of which some shared a high sequence identity (≥97%) to strain TG39 and the Gulf spill isolates. Other bacterial groups comprising members with well-characterized EPS-producing qualities, such as Alteromonas , Colwellia and Pseudoalteromonas , were also found enriched in surface waters, suggesting that the total pool of EPS in the Gulf during the spill may have been supplemented by these organisms. Roller bottle incubations with one of the Halomonas isolates from the Deepwater Horizon spill site demonstrated its ability to effectively produce oil aggregates and emulsify the oil. The enrichment of EPS-producing bacteria during the spill coupled with their capacity to produce amphiphilic EPS is likely to have contributed to the ultimate removal of the oil and to the formation of oil aggregates, which were a dominant feature observed in contaminated surface waters.     

Cryoprotective properties and preliminary characterization of exopolysaccharide (P-Arcpo 15) produced by the Arctic bacterium Pseudoalteromonas elyakovii Arcpo 15

Twenty-two bacterial strains that secrete exopolysaccharides (EPS) were isolated from marine samples obtained from the Chukchi Sea in the Arctic Ocean; of these, seven strains were found to be capable of producing cryoprotective EPS. The ArcPo 15 strain was isolated based on its ability to secrete large amounts of EPS, and was identified as Pseudoalteromonas elyakovii based on 16S rDNA analysis. The EPS, P-ArcPo 15, was purified by protease treatment and gel filtration chromatography. The purified EPS (P-ArcPo 15) had a molecular mass of 1.7 × 10⁷ Da, and its infrared spectrum showed absorption bands of hydroxyl and carboxyl groups. The principal sugar components of P-ArcPo 15 were determined to be mannose and galacturonic acid, in the ratio of 3.3:1.0. The cryoprotective properties of P-ArcPo 15 were characterized by an Escherichia coli viability test. In the presence of 0.5% (w/v) EPS, the survival percentage of E. coli cells was as high as 94.19 ± 7.81% over five repeated freeze–thaw cycles. These biochemical characteristics suggest that the EPS P-ArcPo 15 may be useful in the development of cryoprotectants for biotechnological purposes, and we therefore assessed the utility of this novel cryoprotective EPS.     

Endophytic actinomycetes from spontaneous plants of Algerian Sahara: indole-3-acetic acid production and tomato plants growth promoting activity

Twenty-seven endophytic actinomycete strains were isolated from five spontaneous plants well adapted to the poor sandy soil and arid climatic conditions of the Algerian Sahara. Morphological and chemotaxonomical analysis indicated that twenty-two isolates belonged to the Streptomyces genus and the remaining five were non-Streptomyces. All endophytic strains were screened for their ability to produce indole-3-acetic acid (IAA) in vitro on a chemically defined medium. Eighteen strains were able to produce IAA and the maximum production occurred with the Streptomyces sp. PT2 strain. The IAA produced was further extracted, partially purified and confirmed by thin layer chromatography (TLC) analysis. The 16S rDNA sequence analysis and phylogenetic studies indicated that strain PT2 was closely related to Streptomyces enissocaecilis NRRL B 16365^T, Streptomyces rochei NBRC 12908^T and Streptomyces plicatus NBRC 13071^T, with 99.52 % similarity. The production of IAA was affected by cultural conditions such as temperature, pH, incubation period and l-tryptophan concentration. The highest level of IAA production (127 μg/ml) was obtained by cultivating the Streptomyces sp. PT2 strain in yeast extract-tryptone broth supplemented with 5 mg l-tryptophan/ml at pH 7 and incubated on a rotary shaker (200 rpm) at 30 °C for 5 days. Twenty-four-hour treatment of tomato cv. Marmande seeds with the supernatant culture of Streptomyces sp. PT2 that contained the crude IAA showed the maximum effect in promoting seed germination and root elongation.     

Induction of hexanol dehydrogenase in Geotrichum spp. by the addition of hexanol

Excessive hexanol content distorts the flavor of foods and is harmful to human health. Previously, two strains of fungi were found capable of producing hexanol-degrading enzymes. The current study identified these strains as Galactomyces geotrichum according to the gene sequence of the 26 S rDNA D1/D2 region (strain S12) and genus Geotrichum according to the gene sequence of ITS region (strain S13). Parallel analysis of extracellular and intracellular enzyme activities showed that the enzymes mainly accumulated intracellularly. Native polyacrylamide gel electrophoresis with reactive dyes showed the enzymes were alcohol dehydrogenases induced by the addition of hexanol. Hexanol was catalyzed into hexanoic acid and hexanal by strain S12 and into hexanoic acid by strain S13. The optimum conditions for the induction of enzymes were determined to be 6–9 h in the presence of 0.7 g/l hexanol. The identification of two strains capable of enzymatically degrading hexanol and optimum conditions for their induction will facilitate their use in industrial applications.     

Culture and exopolysaccharide production from sugarcane molasses by Gordonia polyisoprenivorans CCT 7137, isolated from contaminated groundwater in Brazil

Gordonia polyisoprenivorans CCT 7137 was isolated from groundwater contaminated with leachate in an old controlled landfill (São Paulo, Brazil), and cultured in GYM medium at different concentrations of sugarcane molasses (2%, 6%, and 10%). The strain growth was analyzed by monitoring the viable cell counts (c.f.u. mL^?1) and optical density and EPS production was evaluated at the end of the exponential phase and 24 h after it. The analysis of the viable cell counts showed that the medium that most favored bacterial growth was not the one that favored EPS production. The control medium (GYM) was the one that most favored the strain growth, at the maximum specific growth rate of 0.232 h^?1. Differences in bacterial growth when cultured at three different concentrations of molasses were not observed. Production of EPS, in all culture media used, began during the exponential phase and continued during the growth stationary phase. The highest total EPS production, after 24 h of stationary phase, was observed in 6% molasses medium (172.86 g L^?1) and 10% (139.47 g L^?1) and the specific total EPS production was higher in 10% molasses medium (39.03 × 10^?11 g c.f.u.^?1). After the exponential phase, in 2%, 6%, and 10% molasses media, a higher percentage of free exopolysaccharides (EPS) was observed, representing 88.4%, 62.4%, and 64.2% of the total, respectively. A different result was observed in pattern medium, which presented EPS made up of higher percentage of capsular EPS (66.4% of the total). This work is the first study on EPS production by G. polyisoprenivorans strain in GYM medium and in medium utilizing sugarcane molasses as the sole nutrient source and suggests its potential use for EPS production by G. polyisoprenivorans CCT 7137 aiming at application in biotechnological processes.     

An extremely thermostable amylopullulanase from Staphylothermus marinus displays both pullulan- and cyclodextrin-degrading activities

A gene encoding an amylopullulanase of the glycosyl hydrolase (GH) family 57 from Staphylothermus marinus (SMApu) was heterologously expressed in Escherichia coli. SMApu consisted of 639 amino acids with a molecular mass of 75.3 kDa. It only showed maximal amino acid identity of 17.1 % with that of Pyrococcus furiosus amylopullulanase in all identified amylases. Not like previously reported amylopullulanases, SMApu has no signal peptide but contains a continuous GH57N_Apu domain. It had the highest catalytic efficiency toward pullulan (k _cat/K _m , 342.34 s^?1?mL?mg^?1) and was extremely thermostable with maximal pullulan-degrading activity (42.1 U/mg) at 105 °C and pH?5.0 and a half-life of 50 min at 100 °C. Its activity increased to 116 % in the presence of 5 mM CaCl₂. SMApu could also degrade cyclodextrins, which are resistant to the other amylopullulanases. The initial hydrolytic products from pullulan, γ-CD, and 6-O-maltooligosyl-β-CD were [6)-α-d-Glcp-(1?→?4)-α-d-Glcp-(1?→?4)-α-d-Glcp-(1→]_n, maltooctaose, and single maltooligosaccharide plus β-CD, respectively. The final hydrolytic products from above-mentioned substrates were maltose and glucose. These results confirm that SMApu is a novel amylopullulanase of the family GH57 possessing the cyclodextrin-degrading activity of cyclomaltodextrinase.     

Stress response of some lactic acid bacteria isolated from Romanian artisan dairy products

Understanding the mechanisms of stress response and adaptation to stress in the case of lactic acid bacteria (LAB), especially in the case of strains with functional properties, is very important when such strains are potential candidates for starter cultures or probiotics. In this context, our study shows the response of some LAB [four exopolysaccharide (EPS)-producing strains and one strain with potential probiotic effect] to the stresses induced by low and high incubation temperatures, acidity, NaCl, and bile salts, often encountered during the technological processes in food or during the passage through the human gastro-intestinal tract. The strains were able to grow at temperatures up to 40 °C (the mesophilic strains) and 47 °C (the thermophilic strain), in medium with an initial pH of at least 4.0 (Lactobacillus acidophilus IBB801), or in the presence of NaCl up to 10 % (Weissella confusa/cibaria 38.2), or bile salts up to 0.2 % (L. acidophilus IBB801). The protein and isoenzyme patterns of the strains subjected to various stress conditions presented several differences compared with the control patterns, among which the overexpression of some proteins of about 50–60 kDa, differences in the bands intensity in the case of the intracellular enzymes, or the complete loss of some of these bands. The best survival to low pH values and high temperatures was observed for strain L. acidophilus IBB801, the candidate probiotic strain. The EPS production of the four tested strains was, in general, directly related to the growth, the highest yields being obtained when strains were incubated at 24 °C.     

Selective production of two diastereomers of disaccharide sugar alcohol, mannosylerythritol by Pseudozyma yeasts

Mannosylerythritol (ME) is the hydrophilic backbone of mannosylerythritol lipids as the most promising biosurfactants produced by different Pseudozyma yeasts, and has been receiving attention as a new sugar alcohol. Different Pseudozyma yeasts were examined for the sugar alcohol production using glucose as the sole carbon source. P. hubeiensis KM-59 highly produced a conventional type of ME, i.e., 4-O-β-d-mannopyranosyl-d-erythritol (4-ME). Interestingly, P. tsukubaensis KM-160 produced a diastereomer of 4-ME, i.e., 1-O-β-d-mannopyranosyl-d-erythritol (1-ME). In shake flask culture with 200 g/l of glucose, strain KM-59 produced 4-ME at a yield of 33.2 g/l (2.2 g/l/day of the productivity), while strain KM-160 produced 1-ME at 30.0 g/l (2.0 g/l/day). Moreover, the two strains were found to produce ME from glycerol; the maximum yields of 4-ME and 1-ME from 200 g/l of glycerol were 16.1 g/l (1.1 g/l/day) and 15.8 g/l (1.1 g/l/day), respectively. The production of 1-ME as the new diastereomer was further investigated in fed batch culture using a 5-l jar-fermenter. Compared to the flask culture, strain KM-160 gave three times higher productivity of 1-ME at 38.0 g/l (6.3 g/l/day) from glucose and at 31.1 g/l (3.5 g/l/day) from glycerol, respectively. This is the first report on the selective production of two diastereomers of ME, and should thus facilitate the functional development and application of the disaccharide sugar alcohol in the food and relative industries.     

There it is! Fusarium pseudograminearum did not lose the fusaristatin gene cluster after all

Fusarium pseudograminearum is a significant pathogen of cereals in arid regions worldwide and has the ability to produce numerous bioactive secondary metabolites. The genome sequences of seven F. pseudograminearum strains have been published and in one of these strains, C5834, we identified an intact gene cluster responsible for biosynthesis of the cyclic lipopeptide fusaristatin A. The high level of sequence identity of the fusaristatin cluster remnant in strains that do not produce fusaristatin suggests that the absence of the cluster evolved once, and subsequently the resulting locus with the cluster fragments became widely dispersed among strains of F. pseudograminearum in Australia. We examined a selection of 99 Australian F. pseudograminearum isolates to determine how widespread the ability to produce fusaristatin A is in F. pseudograminearum. We identified 15 fusaristatin producing strains, all originating from Western Australia. Phylogenetic analyses could not support a division of F. pseudograminearum into fusaristatin producing and nonproducing populations, which could indicate the loss has occurred relatively recent.