Some environmental factors affect growth and antibiotic production by the mycoparasite Coniothyrium minitans

The effects of temperature and pH on growth and antibiotic production by three isolates of Coniothyrium minitans (Conio, Contans and IVT1), known to produce the macrolide antibiotic macrosphelide A, were examined in modified Czapek Dox broth (MCD). Antibiotic production was determined by incorporating heated (60°C for 5 min) C. minitans spent culture filtrates of MCD (10%, v/v) into potato dextrose broth and assessing the ability of the filtrates to inhibit growth of S. sclerotiorum. All isolates grew over the temperature range of 10–30°C, with the optimum at approximately 15–20°C. Antibiotics were produced by all isolates at 10–30°C. Culture filtrates of MCD from all isolates incorporated into PDB inhibited growth of S. sclerotiorum by >50%, whereas there was a reduction in inhibition at 30°C for Conio and IVT1 but not Contans. All three isolates grew over the pH range of 3–7, with greater biomass production in buffered pH 3–5 than the unbuffered control (pH 4.8) media. Antibiotics were produced by all isolates at pH 3–5. Culture filtrates of MCD from all three isolates grown at pH 3–5 inhibited growth of S. sclerotiorum, with the greatest effect on inhibition observed at pH 3. There were no differences in growth inhibition between isolates at pH 3 and 4, but culture filtrates from Conio grown at pH 5 inhibited S. sclerotiorum more than those of IVT1 grown at the same pH. The significance of these results for biocontrol and optimizing antibiotic production by C. minitans is discussed.     

Water-assisted dissemination of conidia of the mycoparasite Coniothyrium minitans in soil

A study was conducted to determine water-assisted dissemination of conidia of Coniothyrium minitans (Cm), a mycoparasite of Sclerotinia sclerotiorum (Ss), in four soils (yellow–brown soil, red-clay soil, fluvo-aquic soil and black soil) and one sand. Conidial suspensions (1×10⁷ conidia mL^?1) of Cm were applied to sieved (2 mm screen) soil or sand in glass tubes to test vertical dissemination (VD) and in aluminum boxes to test horizontal dissemination (HD) of conidia. Results showed that conidia of Cm could be disseminated with water and spread in soil or sand for 16–20 cm vertically and for 5–10 cm horizontally. The conidial concentration of Cm was logarithmically reduced with the increase in depth of VD or the distance of HD. Dissemination of Cm conidia in sand was better than that in four soils. Potting experiments were done to further understand the potential of water-assisted dissemination of Cm conidia in suppression of Ss carpogenic germination. Results showed that more apothecia were produced by Ss sclerotia located at the soil surface than those at 5 and 10 cm in depth. The minimum Cm concentration for suppression of Ss carpogenic germination was 1000 conidia g^?1 soil. Two-season field trials indicated that water-assisted application of Cm was an effective strategy used at the time for transplanting oilseed rape seedlings to suppress Ss carpogenic germination, thereby reducing the primary infection source for sclerotinia diseases of oilseed rape.     

Characterization of some culture factors affecting oxalate degradation by the mycoparasite Coniothyrium minitans

Aims:  To find possible approaches to utilize the mechanism of oxalate degradation by Coniothyrium minitans (Cm) in controlling the plant pathogen Sclerotinia sclerotiorum (Ss).
Methods and Results:  Differences in oxalate degradation by different Cm strains and effects of the initial oxalate concentration, ambient pH and nutrient factors on mycelial growth and oxalate degradation by Cm were studied in shaken cultures. Results showed that two wild-type Cm strains, Chy-1 and ZS-1, did not differ in oxalate degradation in modified potato dextrose broth (mPDB) amended with oxalic acid (OA). Cm could grow in mPDB amended with sodium oxalate (SO-mPDB) at pH 6·5 or with ammonium oxalate (AO-PDB) at pH 6·2, but oxalate degradation was very low; oxalate degradation was greatly enhanced in SO- or AO-mPDB with pH being lowered to 2·8–2·9. Similarly, oxalate degradation was higher than 90% in OA-amended mPDB at pH 4·4 but was reduced to be <22% at pH 7·0. Five carbon sources and three nitrogen sources investigated and nutrients from mycelia and sclerotia of Ss were favorable for the growth of Cm and OA degradation by Cm.
Conclusions:  Cm can degrade oxalate under acidic pH. Exudates from mycelia or sclerotia of Ss may serve as nutrients for Cm mycelial growth and degradation of oxalate secreted by Ss.
Significance and Impact of the Study:  The finding of oxalate degradation laid a foundation for mining-related genes in Cm for engineering plant resistance against Ss. Elucidation of the importance of acidic pH and nutrients from Ss in oxalate degradation by Cm will help to understand the interaction between Cm and Ss.     

盾壳霉在油菜菌核病菌生物防治中的应用

油菜核病菌(Sclerotiniasclerotiorum)是一种世界性病原菌,其分布广、危害大、难根治。盾壳霉(Coniothyriumminitans)是该病原菌的破坏性寄生真菌,可以有效、专一地降低病原菌菌核的形成与萌发,在该病原菌的生物防治方面具有较大的应用潜力。从油菜核盘菌的致病过程与特点、盾壳霉的生长特性、盾壳霉和油菜核盘菌间相互作用的规律及途径等几个方面阐述了盾壳霉对油菜核盘菌的生防特性,讨论了盾壳霉在生产实践中的应用潜力及存在问题,并提出了一些解决问题的可能途径及需要进一步研究的内容与方向 。     

Splash dispersal of Coniothyrium minitans in the glasshouse

Coniothyrium minitans, a mycoparasite with biocontrol activity against Sclerotinia sclerotiorum, was found to disperse during glasshouse trials where overhead irrigation was used. Consequently, the role of water splash in dispersal of C. minitans was investigated using soil-incorporated inoculum and a range of irrigation regimes found to occur in the glasshouse. The resulting inoculum deposition over horizontal distances up to 2 m was measured. Using drops < 6 mm diameter at 680 mm h^-1, C. minitans was splash-dispersed at least 2.0 m, whereas with drops > 6 mm diameter at 30 mm h^-1 it was dispersed to only 1.75 m. Irrigation with droplets < 1mm diameter at 49 mm h^-1 failed to disperse inoculum beyond 0.5 m. The dispersal gradient produced by drops < 6 mm diameter at 680 mm h^-1 was best described mathematically by the power function, whereas irrigation with drops > 6 mm diameter at 30 mm h^- resulted in a gradient described well by power or exponential functions. The latter regime produced a significantly steeper gradient than irrigation with drops < 6 mm diameter at 680 mm h^-1. C. minitans was isolated using an Andersen air sampler at concentrations of 2839 cfu m^-3 or 22 cfu m^-3 during irrigation with drops < 6 mm diameter at 680 mm h^-1 or > 6 mm diameter at 30 mm h^-1, respectively. After irrigation, deposition of C. minitans-canying aerosol particles declined exponentially and distance from source had no effect on the amount of inoculum isolated. Conidia of C. minitans, splash-dispersed by irrigation with drops < 6 mm diameter at 680 mm h^-1 were able to infect sclerotia of S. sclerotiorum such that almost all sclerotia at 0.5 m from the inoculum source, and c. 50% of those at 2.0 m, became infected with the mycoparasite.     

Antimicrobial activity of Coniothyrium minitans and its macrolide antibiotic macrosphelide A

Aims: Assessment of antimicrobial activity of the mycoparasite Coniothyrium minitans and its macrolide antibiotic macrosphelide A. Methods and Results: Thirteen isolates of C. minitans were tested for ability to inhibit a number of filamentous fungi, yeasts, oomycetes and bacteria in agar based tests. Activity was found against some ascomycetes, basidiomycetes, oomycetes and Gram‐positive bacteria, but not against zygomycetes, yeasts or Gram‐negative bacteria tested. Six C. minitans isolates (Conio, Contans, IVT1, CM/AP/3118, B279/1, A1/327/1) were found to produce macrosphelide A in liquid culture and no other antibiotics were detected. On agar, macrosphelide A inhibited growth of some ascomycetes, basidiomycetes, oomycetes and all four Gram‐positive bacteria tested, including the medically important Staphylococcus aureus with a minimum inhibitory concentration of ≤500 μg ml^?1. There was no inhibition observed against the yeasts and Gram‐negative bacteria when macrosphelide A was tested at 700 μg ml^?1. Conclusions: The spectrum and level of activity of macrosphelide A produced by C. minitans against micro‐organisms are extended markedly compared to previous reports. Significance and Impact of the Study: Macrosphelide A was effective against Staph. aureus. Further study on the control of this bacterium is merited in view of the development of antibiotic resistance.     

植病生防菌盾壳霉的研究进展

盾壳霉是世界性病原真菌核盘菌的主要拮抗真菌之一。许多研究表明盾壳霉具有控制温室和田间多种作物菌核病的潜力。目前欧洲一些国家已有盾壳霉商品制剂销售。为了加速盾壳霉产业化进程和更好地发挥其控制菌核病的作用 ,以及为了使人们对盾壳霉的研究不断深入 ,综述了盾壳霉生态学特性、遗传改良、对核盘菌的生防机制、在菌核病防治上的应用及基因工程研究等方面的研究进展。     

盾壳霉产生几丁质酶的条件研究

本实验采用摇瓶培养研究了盾壳霉(Coniothyrium minitans)产生几丁质酶的条件。改良的天然马铃薯葡萄糖培养基(mPDB)较合成培养基(SMCS)更适宜作为盾壳霉产生几丁质酶的基础培养基。添加9种不同碳源试验表明葡萄糖较适宜于盾壳霉产几丁质酶;氮源试验表明硝酸钾是产酶的较适宜氮源。盾壳霉形成几丁质酶的培养时间以15 d为佳,培养的适宜pH值为6.5。     

Characterization of Sclerotinia and mycoparasite Coniothyrium minitans interaction by microscale co-culture

Aims:  To characterize the interaction of Sclerotinia sclerotiorum and S. minor with strains of the mycoparasite and commercial biocontrol agent Coniothyrium minitans using novel perfusion chamber gasket co-culture.
Methods and Results:  Sclerotinia were cultured in perfusion chamber gaskets and then flooded with Coniothyrium conidia. After germination, Coniothyrium failed to show any form of directed growth, making contact with Sclerotinia hyphae in a random manner. In turn, some Coniothyrium hyphae coiled round Sclerotinia counterparts and although no intracellular growth was observed, Coniothyrium proliferated, while the hyphae of Sclerotinia became vacuolated and lost the cytoplasm. When co-cultures of Sclerotinia with Coniothyrium were flooded with FITC-lectins, small difference in fluorescence between the fungi was found with FITC-Con A suggesting that cell walls of both the species exposed mannose. In contrast, Coniothyrium fluoresced poorly in comparison with Sclerotinia when FITC-wheat germ agglutinin was used, indicating a marked paucity of N -acetylglucosamine exposure by cell walls of Coniothyrium, hence reduced exposure to chitinolytic enzyme action.
Conclusions, Significance and Impact of the Study:  The approach employed supported direct sequential microscopic observation of Coniothyrium and Sclerotinia as well as the utilization of representative fluorescent moieties to characterize relative carbohydrate cell wall exposure.     

Effects of colonisation by different strains of Coniothyrium minitans on the viability of sclerotia of Sclerotinia sclerotiorum

White mold is a major disease in commercial soybean production. An effective measure to reduce the negative effects of Sclerotinia sclerotiorum is the use of bio-fungicides. Strains of Coniothyrium minitans were isolated and efficacy tests against S. sclerotiorum was studied. The efficacy of pycnidiospores sprays of strain N09 (GenBank Accession No HQ908274) from Iowa, USA and strain CON/M/91-08 of Contans® WG were compared in a series of experiments. Sclerotia viability was significantly (P < 0.05) lower in both sclerotia-infested-sterilized-soils (SISS) and sclerotia-infested-unsterilized-soils (SIUS) sprayed with N09 compared with CON/M/91-08 and control at 3°C for 75d and 90d sampling. Similarly, sclerotia viability was significantly (P < 0.05) lower at 23°C for 45, 60 and 75d sampling in SISS and 45, 75 and 90 d sampling in SIUS compared with CON/M/91-08 and control. In contrast, viability of N09 colonies were significantly (P < 0.05) higher than that of CON/M/91-08 both at 3°C and 23°C in SISS across sampling periods. While in SIUS, N09 colonies were significantly higher at 3°C for 15, 30, 45, 75 and 90 d sampling, and at 23°C for 30, 60 and 75 d sampling. Also, (1) N09 had a faster growth rate and produced 1.5 times more pycnidiospores than CON/M/91-08; (2) mycoparasitism by N09 was faster than CON/M/91-08; and (3) co-inoculation of sclerotia and the strains, N09 showed lower sclerotia reproduction than CON/M/91-08. Our data suggest that the new strain N09 has a greater efficiency than CON/M/91-08 in killing sclerotia.     

Effect of volume and concentration of conidial suspensions of Coniothyrium minitans on infection of Sclerotinia sclerotiorum sclerotia

White mould, caused by Sclerotinia sclerotiorum, is a serious disease affecting a wide range of agricultural and horticultural crops. Biological control is one option available to limit its damage. Field experiments to evaluate various concentrations and volumes of Coniothyrium minitans spore suspensions applied to S. sclerotiorum-infected bean crops were conducted in 1997 and 1998. Percentage sclerotia infected by C. minitans were scored. Three replicate experiments were performed in time in 1997 with 21 combinations of isolates, volumes and concentrations, including two controls. In 1998, 22 combinations of isolates, volumes and concentrations plus two controls were used, combined with the absence or presence of a maize buffer, with two replicates for each. Isolates as well as concentration and volume had no effect on infection by C. minitans, but there was a significant effect of total dose (volume×concentration) of inoculum applied over the full range from 100 L ha^-1 at 10⁴ conidia mL^-1 to 1000 L ha^-1 at 10⁷ conidia mL^-1. Percentage infected sclerotia increased linearly with log (dose) as well as from 1 to 4 weeks after application of C. minitans, and reached a level of about 100% at high doses under the humid conditions of 1998. Apothecia of S. sclerotiorum developing from sclerotia in collected soil samples from the 1997 experiment showed no significant effect of C. minitans inoculum dose, but there was a significant effect of the replicate experiments. The influence of weather conditions is highlighted, and the implications of the results for cost-effective biocontrol of S. sclerotiorum are discussed.     

盾壳霉抗逆性菌株的筛选

通过测定野生型盾壳霉JN-CM菌株对所选的各种农药和化肥的耐受性,确定草甘膦、吡虫啉和磷肥对盾壳霉具有较大的抑制作用。采用紫外诱变方式分别筛选了对草甘膦、吡虫啉和磷肥具有一定耐受性的突变菌株,分别命名为UV-G(草甘膦抗性)、UV-I(吡虫啉抗性)和UV-P (磷肥抗性)。此3种抗性突变株具有良好的遗传稳定性,同时在生长繁殖能力及侵染相关酶活性方面与野生菌株无明显差异,具有良好的应用潜力。     

Transformation of Coniothyrium minitans, a parasite of Sclerotinia sclerotiorum, with Agrobacterium tumefaciens

Coniothyrium minitans is a potential biological control agent of the plant pathogenic fungus Sclerotinia sclerotiorum. In this research, T-DNA insertional transformation of strain ZS-1 of C. minitans mediated by Agrobacterium tumefaciens was obtained, with optimization of spore maturity for transformation. After confirmation by PCR, transformants were subjected to Southern blot analysis, and results showed that more than 82.7% of transformants had single T-DNA insertions, and 12.1% of transformants had two copies T-DNA insertions. The genomic DNA segments of transformants flanking the T-DNA could be amplified from both borders with TAIL-PCR. Four types of mutants were screened and identified from the T-DNA insertional library, which comprised sporulation deficient mutants, pathogenicity deficient mutants, pigment change mutants and antibiotic deficient mutant, and some of the mutants were described; the number and frequency of each type of mutant from the library were calculated, and the frequency of each type is 3.27 x 10(-3), 1.0 x 10(-4), 1.4 x 10(-4), 2.5 x 10(-4), respectively. The successful creation of the T-DNA insertional transformation library may help us to unravel the interaction between a parasite and its host at a molecular level, to clarify the differentiation and development of this fungus, and to analyze and clone functional genes from the biocontrol microorganism in tripartite associations.     

Effect of Carbon Source on Production of Lytic Enzymes by the Sclerotial Parasites Trichoderma atroviride and Coniothyrium minitans

Three isolates of Trichoderma atroviride and two isolates of Coniothyrium minitans known to efficiently degrade sclerotia of Sclerotinia sclerotiorum were cultured on minimal medium with sucrose, carboxymethyl cellulose (CMC), xylan, laminarin, colloidal chitin or powdered sclerotia as carbon source. The activity of endochitinase, endo‐β‐1,3‐glucanase, endoxylanase and endocellulase in culture filtrates was determined after 7 and 15 days of culture using dye‐labelled substrates. The strongest inducers of chitinase were colloidal chitin and sclerotia powder. Chitinase activity appeared to be faster induced in the isolates of T. atroviride than in the isolates of C. minitans, but the maximum level of activity present in culture filtrates of the two species was similar. With CMC and xylan as carbon source, concurrent production of the corresponding enzymes was observed for the Trichoderma isolates. The isolates of C. minitans produced cellulase on xylan but not on CMC, whereas xylanase was produced on both carbon sources. Laminarin induced the formation of glucanases in the three isolates of T. atroviride but not the isolates of C. minitans. However, in the sclerotia‐containing cultures of C. minitans glucanase activity was even higher than in the respective cultures of the Trichoderma isolates. During the 31‐day study period, the pattern of enzyme production in shake cultures containing sclerotia powder was very similar for the isolates of T. atroviride and C. minitans. Glucanase activity generally reached a peak 24 days after inoculation of the flasks, whereas the activity of chitinase, cellulase and xylanase remained fairly constant throughout the experiment.     

应用响应面方法优化Coniothyrium minitans固态发酵生产生物农药

利用响应面方法对固态发酵生产生物农药盾壳霉 (Coniothyriumminitans)孢子的培养基条件进行了优化研究。响应面分析结果表明 ,淀粉、尿素和KH2 PO4与Coniothyriumminitans的孢子产量存在显著的相关性 ,通过求解回归方程得到优化发酵条件 :当淀粉为 36 .4 3g L ,尿素3.91g L和KH2 PO41.0 2 g L时 ,孢子产量达到理论最大值 9.94× 10 9孢子 g麸皮 ,在摇瓶发酵条件下 ,实际最大孢子产量为 1.0 4× 10 10 孢子 g麸皮     

Biocontrol of Sclerotinia sclerotiorum infection of cabbage by Coniothyrium minitans and Trichoderma spp.

Nine fungal isolates [Clonostachys rosea (1), Coniothyrium minitans (1), Trichoderma crassum (1), T. hamatum (4), T. rossicum (1) and T. virens (1)] were tested in two bioassays for their ability to degrade sclerotia and reduce apothecial production and carpogenic infection of cabbage seedlings. C. minitans LU112 reduced apothecial production in both bioassays, with T. virens LU556 significantly reducing apothecial production in the sclerotial parasitism assay. Both isolates also reduced sclerotial viability in this assay to 5% for C. minitans and 22% for T. virens. C. minitans LU112 and T. virens LU556 reduced the infection of cabbage seedlings in the pot bioassay 126 days after sowing but not after 147 days, partly due to ascospore cross-infection between treatments. C. minitans LU112, T. virens LU556 and T. hamatum LU593 as maizemeal-perlite (MP) soil incorporation and transplant potting mix incorporation were evaluated for their ability to control Sclerotinia sclerotiorum disease of cabbage in field experiments. S. sclerotiorum infection of cabbage was reduced by 46–52% and 31–57% by both C. minitans LU112 and T. hamatum LU593 as MP soil incorporations, respectively, in the two field experiments. T. virens LU556 MP soil incorporation and C. minitans LU112 and T. hamatum LU593 transplant potting mix incorporations reduced S. sclerotiorum disease in the first experiment but not in the second experiment. A commercial C. minitans LU112 formulation, C. Mins LU112 WG, also significantly reduced S. sclerotiorum disease by 59%. Soil incorporation of C. minitans and T. hamatum was shown to have potential to control S. sclerotiorum disease in cabbage.     

植病生防菌盾壳霉的分子生物学研究进展

盾壳霉是一种重要的核盘菌寄生茵.近年来,该菌在分子水平的研究取得了一定的进展.本文概述了盾壳霉在产孢调控、与核盘菌互作、遗传转化以及动态检测和遗传多样性等方面的研究现状,并对研究中存在的问题进行了讨论.希望在此基础上能够促进该茵分子生物学研究的不断深入,更好地开发利用该菌的基因资源.     

Some Nutritional Factors Affecting Production of Biomass and Antifungal Metabolites of Coniothyrium minitans

The ability of the mycoparasite Coniothyrium minitans to utilize a range of C and N sources and vitamins for growth, pycnidial formation and antifungal metabolite production was examined using a defined liquid medium. Coniothyrium minitans was able to use all the C sources tested, with the exception of D -xylose, and all the N sources tested, although growth was generally better on organic N sources rather than NO 3 -N. Increasing C:N ratios from 9:1-202:1 with N constant (2.0 g L -l L -alanine) resulted in steadily increasing yields, whereas increasing C:N ratios with C constant (40.0 g L -l D -glucose) gradually decreased yield. Addition of thiamine to the glucose-alanine basal medium resulted in the greatest increase in growth but biomass was still less than that achieved using an undefined molasses-yeast medium. Pycnidial production was generally low or failed to occur in the basal medium + C + N sources in the absence of vitamins, but addition of thiamine consistently led to abundant pycnidial formation. Molasses-yeast static culture provided greater biomass and conidial yields than molasses-yeast shaken culture. Incorporation of C. minitans culture medium into potato dextrose broth (10% v/v) resulted in consistent reduction in growth of Sclerotinia sclerotiorum irrespective of C, N or vitamin content of the basal medium or whether molasses-yeast medium was used. This is the first report of consistent production of antifungal metabolites by C. minitans .     

Use of REMI and Agrobacterium-mediated transformation to identify pathogenicity mutants of the biocontrol fungus, Coniothyrium minitans

Restriction enzyme mediated integration (REMI) and Agrobacterium-mediated transformation (ATMT) were used to transform protoplasts or germinated conidia of the mycoparasite Coniothyrium minitans to hygromycin resistance. Using REMI, up to 32 transformants mug DNA(-1) were obtained, while 37.8 transformants 5 x 10(5) germlings(-1) were obtained using ATMT. Single-copy integrations occurred in 8% and 40% of REMI and ATMT transformants, respectively. A novel microtitre plate-based test was developed to expedite screening of 4000 REMI and ATMT C. minitans transformants. Nine pathogenicity mutants that displayed reduced or no pathogenicity on sclerotia of Sclerotinia sclerotiorum were identified.