Studies on κ-carrageenan/locust bean gum mixtures in the presence of sodium chloride and sodium iodide

The solution properties of κ-carrageenan and κ-carrageenan/locust bean gum mixtures have been studied by small deformation oscillation measurements and differential scanning calorimetry (DSC) in the presence of sodium chloride and sodium iodide. Both salts induced the κ-carrageenan to undergo a coil-helix conformational change as noted by an increase in the storage and loss moduli (G′, G′) and by an exothermic peak in the DSC cooling curves. The enthalpy ΔH_c-h and temperature of the conformational transition T_c-h were higher in Nal compared to NaCl and T_c-h increased with increasing the concentration of both electrolytes. Gelation was not observed for carrageenan or carrageenan/locust bean gum mixtures in the presence of up to 200 mM Nal. Although carrageenan alone did not gel in the presence of 100 mM NaCl, a weak gel was obtained for a mixture containing 0.9%/0.1% carrageenan/locust bean gum. Furthermore, the mixture showed hysteresis in both the rheological and DSC cooling and heating curves. A strong gel was produced for carrageenan alone in the presence of 200 mM NaCl and the gel strength increased on adding a small proportion of locust bean gum (0.9%/0.1%). © 1997 John Wiley & Sons, Inc. Biopoly 41: 657–671, 1997     

Effect of locust bean gum and konjac glucomannan oh the conformation and rheology of agarose and κ-carrageenan

Mixing with locust bean gum (LBG) induces obvious gel-like character in very dilute solutions of K⁺ κ-carrageenan (< 0.01% w/w in 100 mM KCl). At higher concentration (0.085%), addition of LBG (0.036%) gives a shoulder on the high-temperature side of the DSC (differential scanning calorimetry) exotherm associated with the carrageenan disorder-order transition, with an accompanying increase in gelation temperature and enhancement in gel strength (storage modulus, G′). On substitution of LBG by konjac glucomannan (KM) the shoulder in DSC cornverts to a discernable peak. Van't Hoff analysis of optical rotation data indicates that the high-temperature thermal processes could arise from association of LBG or KM chains to the carrageenan double helix as it forms, with the main transition at lower temperature corresponding to ordering of surplus carrageenan. With K -carrageenan in the nongelling tetra-methylaminonium salt form, addition of LBG causes no delectable change in DSC; rheological enhancement at high concentration (1% w/w) is limited to development of a very tenuous network, and in dilute solution a decrease in viscosity is observed. Agarose shows only a very slight increase in the disorder-order transition temperature on addition of KM, and it shows no detectable change with LBG. These observations are interpreted as showing that efficient binding of mannan or glucomannan chains requires some aggregation of the algal polysaccharide helices, but that extensive aggregation restricts synergistic interaction by competition with heterotypic association. © 1995 John Wiley & Sons, Inc.     

Conformation and association of κ-carrageenan in the presence of locust bean gum in mixed NaI/CsI solutions from rheology and cryo-TEM

Mixtures of locust bean gum (LBG) with κ-carrageenan (KC) in 0.1 M aqueous solutions of the mixed salts NaI/CsI were investigated by cryo-transmission electron microscopy (cryo-TEM) and dynamic viscoelastic measurements. Previous studies have shown that as the cesium content is increased in such mixed salt solutions, a transition occurs from molecularly dispersed helices to ‘superhelical rods’ of KC. We now found that LBG stabilises the superhelical rods, shifting the transition to a lower content of Cs for the mixtures than for KC alone. The formation of superhelical rods was evidenced both by cryo-TEM images and by an onset of thermal hysteresis in the coil–helix transition of KC. In the mixtures, the transition temperatures on cooling and heating were insensitive to the proportions of LBG and KC present at all cesium contents. Under conditions where no helix aggregation occurred (no hysteresis) the mixtures showed high tan δ values and low storage moduli. Under aggregated conditions, gels formed, and gels with added LBG had enhanced moduli compared to gels with KC alone. On the basis of these results we propose that LBG associates to the super-helical rods of KC.     

Phase separation in dextran/locust bean gum mixtures

Dextran/locust bean gum (LBG) mixtures have been prepared and investigated with respect to their phase separation behaviour. These systems exhibited phase separation at 20 °C, the upper phase, itself biphasic, being enriched with locust bean gum but also containing dextran, whereas the lower phase contained only dextran. This lower phase was a liquid. The upper phase, which did not flow, was characterized by means of rheological dynamic measurements. Clearly, its behaviour was typical of a gel, the three-dimensional structure of which can be ascribed to self-association of LBG chains owing to the very high concentration of the galactomannan in this upper phase. The self-association of the galactomannan was confirmed by fluorescence microscopy carried out on mixtures containing fluorescein isothiocyanate (FITC)-labelled dextran. The rheological behaviour of a concentrated LBG solution was also investigated as a function of time, clearly showing progressive formation of a weak gel structure.     

Rheology and fracture of mixed ι- and κ-carrageenan gels: Two-step gelation

It is shown that under certain circumstances, on cooling mixed ι- and κ-carrageenan solutions, the two forms gel separately at different temperatures, with the ι form gelling first. This ‘two-step gelation’ was only observed when both sodium and potassium ions were present, with a sodium/potassium mole ratio of between 1 and 100. For such mixed gels, a κ fraction as low as 2·5% of the total carrageenan has significant effects on their rheology, both at low deformation and fracture. In these systems, the κ form, gelling in the presence of an existing ι gel, produces measurable rheological effects at much lower concentrations than if it were alone. This behaviour can be used as a sensitive test of the ‘rheological purity’ of samples of ι-carrageenan.     

Mixtures of pregelatinised maize starch and κ-carrageenan: Compatibility, rheology and gelation

Compatibility, flow and visco-elastic properties of a pregelatinised maize starch mixed with κ-carrageenan were investigated. After cooking of the pregelatinised starch, some undissolved granules remained in solution. Aqueous mixtures of κ-carrageenan and starch were studied at 60 °C and 20 °C by combining rheological measurements and microscopic observations under conditions allowing gelation of carrageenan and non-gelation of starch. The viscometric study of mixed dilute solutions of amylose from pregelatinised starch and carrageenan showed that the components are slightly incompatible. Mixture viscosity and elastic modulus were studied at 60 °C in details as a function of mixture composition for a total polymer concentration of 3%; both were found to be significantly higher than the corresponding theoretical additive values. This finding was interpreted by starch granules excluded volume effect. At 20 °C, no noticeable increase of mixture elastic modulus was found as compared with the additive value. The absence of the synergistic effect is supposed to be due to the formation of highly inhomogeneous gels with agglomerates of undissolved granules.     

The conformational transition of κ-carrageenan using microcalorimetry

The interactions between inorganic cations and κ-carrageenan in aqueous solutions have been studied using microcalorimetry. The enthalpy of dilution and the enthalpy of mixing of κ-carrageenan in the coil conformation with an alkaline metal chloride have been investigated and are in agreement with theoretical predictions. The formation of helical dimer in a K⁺ salt form in the absence of a gel formation is confirmed.     

Mechanism of gel formation in κ-carrageenan

We present a general view of κ-carrageenan gelation and some new experimental results concerning their behavior in the presence of Na⁺, K⁺, or Rb⁺ counterions in semidilute concentration. The gelation mechanism is based on the aggregation of helical dimers.     

Mixed gels made from protein and κ-carrageenan

The rheological behavior of mixed gels made from soy or pea protein concentrates with the addition of κ-carrageenan was investigated using uniaxial compression and dynamic measurements. Pea protein concentrate (PPC) exhibited greater synergy with κ-carrageenan than soy protein concentrate (SPC) in relation to gel strength, gel stiffness and pH stability. A modified Takanayagi treatment of dynamic measurements indicated a shift in the continuous phase from protein to κ-carrageenan at concentrations of 4–8% κ-carrageenan in the total solids. This shift occurred at lower concentrations when PPC was used compared to SPC.     

Behavior of κ-carrageenan in glycerol and sorbitol solutions

The solubility of κ-carrageenan in low water-content solvents is important in food applications where complete solubilization is required for proper development of structure and rheology. The effect of glycerol and sorbitol on the gelation and conformational helix transition of κ-carrageenan was studied using rheology and optical rotation. Glycerol/water solutions from 0–100 wt% glycerol and sorbitol solutions from 0–100% saturation were studied over the temperature range 0–90°C. The results were analyzed in terms of solvent solubility parameters, water chemical potential, and solvent dielectric constant. Effective cohesive energy density parameters could not be inferred for the carrageenan, but the gelation temperature could be correlated with solvent dielectric constant. Hydrogen bonding interactions control the carrageenan helix formation. The cohesive energy density as a measure of solvent quality accounts for hydrogen bonding but not Coulombic interactions, and the Coulombic interactions scale on dielectric constant. This indicates the dominant role of electrostatics on the gelation process.     

Effect of galactomannan addition on the thermal behaviour of κ-carrageenan gels

Gelation/melting cycles of κ-carrageenan/galactomannan (guar, tara and locust bean gums) binary systems have been studied by measuring dynamic rheological parameters. Two experimental conditions were used, (i) the total polysaccharide concentration was kept at 1% and the κ-carrageenan/galactomannan ratio fixed at 4:1 and (ii) the κ-carrageenan concentration was fixed at 0·75% and the galactomannan content varied from 0% to 1·2%. A thermal hysteresis was observed for all mixed systems and was found to depend on the galactomannan used. From a comparison of the gelation temperature (T_g) and melting temperature (T_m) to values obtained with κ-carrageenan alone, it was suggested that galactomannan interferes with gel structure by the formation of a secondary network provided that the M/G ratio is high enough.     

127I-NMR studies of anion binding to κ-carrageenan

A preliminary ¹²⁷I-NMR relaxation study of the binding of the I^? ion to κ-carrageenan is presented. Signal loss caused by motional correlation times out of extreme narrowing makes it difficult to analyze line widths. Longitudinal relaxation times are more suitable for a comprehensive relaxation study. From the observation of nonextreme motional narrowing, the lower limit of the residence time at the binding site is estimated to be on the order of 10 ns. © 1993 John Wiley & Sons, Inc.     

Responsiveness of κ-carrageenan microgels to cationic surfactants and neutral salts

The objective of this study was to examine the responsiveness of chemically cross-linked κ-carrageenan microspheres to different types of neutral salt electrolytes as well as to surfactants of varying chain lengths. In the presence of increasing salt concentration microsphere size changed radically from D[4,3] values of 320 μm to approximately 160 μm. The level of salt concentration needed to bring about this change varied depending on electrolyte type. This common behaviour was attributed to the difference in free cationic counter-ions concentration between the inside and outside of the microsphere and can be explained due to the effect of the Donnan equilibrium. The rheological properties of these microgels in their swollen and collapsed states were also explored with results showing that the collapsed microspheres had a greater impact on the viscosity of the system probably as a result of some aggregation of the collapsed microgels at rest due to surface charge screening at these high salt concentrations. The effect of surfactant on microsphere size showed a dramatic drop in D[4,3] values from 320 μm to approximately 120 μm for BAC, DoTAB, MTAB and CTAB at specific critical concentrations. This critical aggregation concentration was found to increase linearly on a log–log scale with the critical micelle concentration of these surfactants in water, indicating that the alkyl chain length of the surfactants had an effect on the critical aggregation concentration.     

Rheological and calorimetric study of the sol–gel transition of κ-carrageenan

Rheological and DSC techniques were used to study the effect of κ-carrageenan and KCl concentrations, 0–300 mM, on the sol–gel transition as well as on the linear viscoelasticity, at 25 °C, of the resulting gels. In heating and cooling DSC tests, the peak temperature was taken as the sol–gel transition point. In rheological tests, sol–gel transitions were determined from the variation of dynamic moduli with frequency and temperature, the independence of the phase angle on frequency and the evolution with temperature of dynamic moduli on cooling and heating at constant frequency and strain. Transition temperatures from DSC and rheology were in good agreement among them and with those previously reported. The three procedures yielded similar results, but the transition temperatures were more easily determined through the independence of the phase angle on frequency. Frequency sweeps showed gel behavior with stiffness increasing with polysaccharide and salt concentration. Below 100 mM KCl, G′ increased notably, whereas higher concentrations produced only marginal increases.     

Anion effects on equilibria and kinetics of the disorder–order transition of κ-carrageenan

The effect of a number of tetramethylammonium salts on the equilibria and kinetics of the disorder to order transition in the polysaccharide κ-carrageenan have been investigated. Data from the temperature dependence of optical rotation show that anion stabilization of the ordered form follows the lyotropic series I^? > Br^? > NO > Cl^? > F^?. Stopped-flow polarimetry was used to study the kinetics of conformational ordering following a rapid increase in salt concentration. The transition to the new equilibrium position was shown to be biphasic for all of the tetramethylammonium salts studied. The rate equation for the fast phase and the temperature dependence of the observed forward rate constant accord with a cooperative dimerization process. Activation parameters for helix nucleation, ΔH^* and ΔS^*, vary with both salt concentration and (at constant ionic strength) the anion type, increasing through the lyotropic series from I^? to F^?. The slow phase shows second-order kinetics, and is interpreted as further stabilization of the ordered form either through limited aggregation or annealing. The rate constant for the slow phase also follows the lyotropic series. Thus we have shown that both the growth and nucleation processes are anion dependent.     

Physical and stability characteristics of Burkholderia cepacia lipase encapsulated in κ-carrageenan

In this work, a novel approach for lipase immobilization was exploited. Lipase from Burkholderia cepacia was encapsulated into κ-carrageenan by co-extrusion method to form a liquid core capsule. The diameter of the encapsulated lipase was found to be in the range of 1.3–1.8 mm with an average membrane thickness of 200 μm and 5% coefficient of variance. The encapsulation efficiency was 42.6% and 97% moisture content respectively. The encapsulated lipase was stable between pH 6 and 9 and temperature until 50 °C. The encapsulated lipase was stable until disintegration of the carrier when stored at 27 °C and retained 72.3% of its original activity after 6 cycles of hydrolysis of p-NPP. The encapsulated lipase was stable in various organic solvents including methanol, ethanol, iso-propanol, n-hexane and n-heptane. Kinetic parameters K_m and V_max were found to be 0.22 mM and 0.06 μmol/min for free lipase and 0.25 mM and 0.05 μmol/min for encapsulated lipase respectively.     

Conformational change and aggregation of κ-carrageenan studied by flow field-flow fractionation and multiangle light scattering

The relatively novel combination of flow field-flow fractionation (FFF) and multiangle light scattering (MALS) was employed to study a nondegraded κ-carrageenan in different 0.1M salt solutions. The applicability of the technique was tested, and the effects of salt type and salt composition on the molar mass and radius of gyration were studied. A conformational ordering was induced at room temperature by switching the solvent from 0.1M NaCl (coil form) to 0.1M NaI (helix form). An approximate doubling of the average molar mass and an increase in radius of gyration was then observed, in agreement with results obtained previously using size exclusion chromatography–MALS. This increase in size was attributed to conformational ordering and to the formation of double helices. Severe aggregation was observed above 40% CsI in the 0.1M mixed salt solution of CsI and NaI. This was ascribed to the association of helices into large aggregates. For these large associates, having molar masses of several millions, a reversal of the elution order in flow FFF was detected. © 1998 John Wiley & Sons, Inc. Biopoly 45: 85–96 1998     

O-maleoyl derivative of low-molecular-weight κ-carrageenan: Synthesis and characterization

Low-molecular-weight (LMW) κ-carrageenan was achieved through mild hydrochloric acid hydrolysis of κ-carrageenan. The acylation of low-molecular-weight κ-carrageenan was performed by use of tetrabutylammonium (TBA) salt of the anionic polysaccharide fragments, maleic anhydride, 4-dimethylaminopyridine and tributylamine under homogeneous conditions in N,N-dimethylformamide at 60 °C. Analysis of FT-IR spectrum of O-maleoyl κ-carrageenan showed that a monoester derivative with maleoyl group was formed when LMW κ-carrageenan reacted with maleic anhydride. Investigation of ¹H NMR spectroscopy revealed that the maleoylation took place regioselectively at C-2 of the κ-carrageenan 3-linked unit.