Microbial production of 2,3-butanediol from whey permeate

Summary Of four organisms tested in semi-synthetic medium for the production of 2,3-butanediol from lactose, Klebsiella pneumoniae N.C.I.B. 8017 proved to be the most promising. When tested using rennet whey permeate as substrate, a butanediol concentration of 7.5 g/l, representing a yield of 0.46 g/g lactose utilized, was observed after 96 h incubation. In whey permeate where the lactose had been hydrolysed enzymatically prior to the fermentation, a butanediol concentration of 13.7 g/l, representing a yield of 0.39 g/g sugar utilized was obtained. These results indicate that lactose utilization may be a limiting step in the fermentation process.     

Milk Clotting Enzyme from Microorganisms

Out of some 800 strains of microorganisms, a potent fungus for milk clotting enzyme was isolated from soil during the course of screening tests and was identified as one of strains of Mucor pusillus Lindt. Satisfactory results were obtained in cheese making experiments with this enzyme which could be produced effectively by solid culture on wheat bran at 30°C for about 70 hrs.

The balance between milk clotting activity and proteolytic activity of this enzyme resembled very much to that of rennet.

Microbial rennet from Mucor pusillus F-27 was obtained with high productivity by solid culture followed by water extraction. The enzyme could be precipitated by salting out with ammonium sulfate and also by mixing with various water-miscible organic solvents such as ethanol, methanol or acetone.

This enzyme is one of acid proteases having its optimal pH for milk casein digestion around 3.5. The ratio of milk clotting activity to proteolytic activity of this enzyme resembled that of calf rennet than those of other proteases of fungal origin. This was more heat stable and more resistant against pH changes than animal rennet. Apparent activity of milk clotting was more affected by Ca ion concentration in milk than that of calf rennet.

The liberation of 12% TCA soluble nitrogen from casein fraction was a little less specific than that of calf rennet. The optimal temperature for milk clotting lay around 56°C.

Electrophoretic patterns of α-peak of casein treated with this enzyme showed the weak proteolysis which resembled that with rennet.     

Specificity of a Nuclease from Penicillium citrinum

The enzyme with high milk clotting activity produced by Irpex lacteus was partially purified by a CM-cellulose chromatography. Throughout the over-all process, the enzyme was purified approximately 9-fold from a crude powder with about 22.8% recovery of the original activity. The MCA/PU ratio of this fraction was 2.51 and the specific milk clotting activity was 188.7.

The purified enzyme is a sort of acid protease with optimum pH of 2.5 for casein digestion and 4.0 for hemoglobin digestion. The Lineweaver-Burk plot, when casein was used as a substrate, showed that the Km value of the enzyme was about 0.07% and the V_max value was 0.4. The molecular weight of the enzyme is about 34,000, the isoelectric point is pH 5.2 and a ultraviolet absorption maximum is at 277 mμ. The enzyme has not yet been crystalized but seems to be a sort of glycoprotein, because the Molish reaction was positive at the present purification stage.

Some enzymological properties of the enzyme was studied and compared with those of a calf rennet and Mucor rennet. In some respects such as pH optima, pH stability, thermostability and temperature optima, the enzyme is Mucor rennet alike. On the other hand, as to the increase in activity along with decrease in pH of milk and the increase in activity along with the addition of Ca ion, the enzyme is not very different from the calf rennet. However, proteolysis of milk casein by the enzyme was fairly higher than by the calf rennet.

As to the production of enzymes, I. lacteus can produce at least three types of proteases into liquid media. When, for example, R medium was used, only one type of protease, that is the fraction A, could mainly be produced and it was this enzyme that assumed to be a rennet like enzyme.     

Factors affecting the use of chloramphenicol acetyltransferase as a marker for Brassica genetic transformation

The CAT gene which codes for the enzyme chloramphenicol acetyltransferase was found to be ineffective as a reporter gene in cells and tissues of Brassica species. High levels of endogenous CAT activity were found to be widespread among this genus and did not appear to be distributed in a tissue- or cell-specific manner. Moreover, the presence of an inhibitor of CAT activity was discovered in Brassica napus and Brassica juncea. This inhibitor appeared to act selectively on bacterial CAT in transgenic plants. These findings provided an explanation for difficulties experienced in the detection of transgenic CAT activity in B. napus.     

Production of highly active fungal milk-clotting enzyme by solid-state fermentation

Abstract

Cheese production is projected to reach 20 million metric tons by 2020, of which 33% is being produced using calf rennet (EC 3.4.23.4). There is shortage of calf rennet, and use of plant and microbial rennets, hydrolyze milk proteins non-specifically resulting in low curd yields. This study reports fungal enzymes obtained from cost effective medium, with minimal down streaming, whose activity is comparable with calf and Mucor rennet. Of the fifteen fungi that were screened, Mucor thermohyalospora (MTCC 1384) and Rhizopus azygosporus (MTCC 10195) exhibited the highest milk-clotting activity (MCA) of 18,383?±?486?U/ml and 16,373?± 558?U/ml, respectively. Optimization exhibited a 33% increase in enzyme production (30?g wheat bran containing 6% defatted soy meal at 30?°C, pH 7) for M. thermohyalospora. The enzyme was active from pH 5–10 and temperature 45–55?°C. Rhizopus azygosporus exhibited 31% increase in enzyme production (30?g wheat bran containing 4% defatted soy meal at 30?°C, pH 6) and the enzyme was active from pH 6–9 at 50?°C. Curd yields prepared from fungal enzyme extract decreased (5–9%), when compared with calf rennet and Mucor rennet. This study describes the potential of fungal enzymes, hitherto unreported, as a viable alternative to calf rennet     

Characterization and preparation of chymosin from calf rennet samples by means of isoelectric focusing

Chymosin has been identified in rennet samples from stomaches of living calfs by means of it's isoelectric points (IP), molecular weight (Mol. Wt.) and enzymatic activity. The values obtained by isoelectric focusing (IEF) and a two-dimensional electrophoretic technique, amount 4,5…4,7 (IP) and 36 300 (Mol. Wt.) respectively. Furthermore the fractionation of calf rennet by IEF has been performed in a preparative scale. From one gramme of calf rennet we obtained 53 mg of purified chymosin, which shall be used for preparing antisera against chymosin.     

Enzyme activity engineering based on sequence co-evolution analysis

The utility of engineering enzyme activity is expanding with the development of biotechnology. Conventional methods have limited applicability as they require high-throughput screening or three-dimensional structures to direct target residues of activity control. An alternative method uses sequence evolution of natural selection. A repertoire of mutations was selected for fine-tuning enzyme activities to adapt to varying environments during the evolution. Here, we devised a strategy called sequence co-evolutionary analysis to control the efficiency of enzyme reactions (SCANEER), which scans the evolution of protein sequences and direct mutation strategy to improve enzyme activity. We hypothesized that amino acid pairs for various enzyme activity were encoded in the evolutionary history of protein sequences, whereas loss-of-function mutations were avoided since those are depleted during the evolution. SCANEER successfully predicted the enzyme activities of beta-lactamase and aminoglycoside 3′-phosphotransferase. SCANEER was further experimentally validated to control the activities of three different enzymes of great interest in chemical production: cis-aconitate decarboxylase, α-ketoglutaric semialdehyde dehydrogenase, and inositol oxygenase. Activity-enhancing mutations that improve substrate-binding affinity or turnover rate were found at sites distal from known active sites or ligand-binding pockets. We provide SCANEER to control desired enzyme activity through a user-friendly webserver.     

Regulation of Escherichia coli phosphofructokinase in situ

The activity of E. coli phosphofructokinase in situ has been studied in cells permeabilized to its substrates, products and effectors by a toluene-freezing treatment. The in situ enzyme exhibits moderate cooperativity in respect to F6P (n_H up to 2.0), rather low affinity for ATP (with Km up to 1 mM when saturated with F6P), activation by ADP, and inhibition, within the physiological range of concentrations, by high ATP and phosphoenolpyruvate. This behaviour of the enzyme in situ at concentrations of the effector metabolites as those reported in intact cells in glycolytic and gluconeogenic conditions could account for the changes of phosphofructokinase activity needed for metabolic regulation in vivo.     

Chrysonila sitophila (TFB-27441): A hyperlignolytic strain

Summary C. sitophila strain TFB-27441 showed 2–3 times higher lignolytic activity thanPhanerochaete chrysosporium (BKM-F-1767 strain). Lignin had a marked effect on the ligninase activity indicating that some induction or activation mechanism is involved in lignin degradation byC. sitophila.     

Production of glucose isomerase by different strains ofStreptomyces

Summary The glucose isomerase activity ofStreptomyces haeochromogenes strains 1 and 2 varies considerably with the assay conditions (pH, glucose concentration,etc.). Nine other species of streptomyces were tested under conditions optimal forS.phaeochromogenes 2. The highest enzyme activity was found inS.nigrificans 3014.     

Antiplasmodial activity of Artemisia annua plant cell cultures

Extracts of Artemisia annua cultures have been assessed for in vitro activity against the malarial parasite Plasmodium falciparum. Callus and suspension cells and medium were analysed and examined for their activity at different stages of growth and development. Time-course experiments were carried out to investigate the influence of various basal media, plant growth regulators and light on both growth and possible artemisinin production. Two active fractions were obtained but artemisinin was not detected.     

Transient expression of electroporated DNA in monocotyledonous and dicotyledonous species

Transient expression of electroporated DNA was monitored in protoplasts of several monocot and dicot species by assaying for expression of chimeric chloramphenicol acetyltransferase (CAT) gene constructions. Expression was obtained in the dicot species of Daucus carota, Glycine max and Petunia hybrida and the monocot species of Triticum monococcum, Pennisetum purpureum, Panicum maximum, Saccharum officinarum, and a double cross, trispecific hybrid between Pennisetum purpureum, P. americanum, and P. squamulatum. Recovery and viability of protoplasts after electroporation decreased with increasing voltages and capacitance while CAT activity increased up to a critical combination of voltage and capacitance beyond which the activity dramatically decreased. The optimal compromise between DNA uptake and expression versus cell survival was determined for D. carota and applied successfully to the other species. Maximum transient expression occurred 36 hours after electroporation of D. carota. The potential for using this procedure to rapidly assay gene function in dicot and monocot cells and application of this technique to obtain transformed cereals is discussed.     

Expression of the threonine operon fromEscherichia coli inBrevibacterium flavum andCorynebacterium glutamicum

Summary The threonine operon fromEscherichia coli was cloned in plasmid pBR322, subcloned into the shuttle vector pCEM300 and the resulting recombinant plasmid was transferred intoBrevibacterium flavum andCorynebacterium glutamicum. The expression ofE. coli threonine genes in these coryneform bacteria was demonstrated by complementing thethrA andthrB mutations and by assaying homoserine dehydrogenase activity.     

Glyoxalase-I activity and cell cycle regulation in yeast

The status of glyoxalase-I was explored in exponentially growing and G₁ arrested temperature sensitive (ts) cell division cycle (cdc) mutants of Saccharomyces cerevisiae. It was observed that the specific activity of this enzyme was correlated with overall growth status. The activity was high in actively growing cells and was low in G₁ arrested cells. Specific activities of glyoxalase-I were also low in G₁ arrested prolonged stationary phase (PSP) cells of S. cerevisiae and Candida albicans. The activity of glyoxalase-I recovered when G₁ arrested S. cerevisiae (ts) cells were allowed to regrow under permissive conditions. Results demonstrate that although glyoxalase-I activity is a good indicator of cell growth status, it is not involved in cell cycle regulation of this eukaryotic organism.     

Regulation of cell proliferation and morphogenesis by amino acids inBrassica tissue cultures and its correlation with threonine deaminase

The effect of amino acids has been investigated with respect to the capacity ofBrassica cultures to undergo proliferation and differentiation. Hormone medium without any amino acid resulted in 6% shoot formation. Addition of optimal concentrations of L-leucine and L-isoleucine enhanced shoot formation upto 30% and 60%, respectively. L-methionine, L-threonine and pyruvic acid supported only proliferation but no differentiation. Amino acids had a marked effect on the activity of enzyme threonine deaminase (TD), bothin vivo andin vitro. TD in proliferating callus cultures was 3-fold higher than in differentiating cultures. Amino acids which induced cell proliferation increased TD while those which supported differentiation repressed it. Amino acids which did not alter TD activity had no effect on morphogenesis. The results suggest that amino acids play a regulatory role inBrassica morphogenesis which can be correlated with the activity of threonine deaminase.     

Cultivation and properties of ice-nucleation active bacteriaPseudomonas syringae CCM 4073

Summary An ice-nucleating bacteriumPseudomonas syringae CCM 4073 selected from 30 ice-nucleating bacteria was cultivated in pilot-plant bioreactors at 28°C; the cells showed a high ice-nucleation activity even in dry state, sublimation activity and activation after imposition into refrigenator.     

Genotypic and phenotypic correlationships among some strains ofLactobacillus helveticus

Summary Evidence for the presence of extrachromosomal elements inLactobacillus helveticus ATCC 15009 and the absence of plasmid DNA in two other strains ofL. helveticus is reported. These three strains did not show any difference in regard to lactose metabolism, proteolytic activity, and antibiotic resistance or in N-acetyl-D-glucosamine fermentation. The only difference found is a higher resistance to arsenate forL. helveticus ATCC 15009, suggesting linkage of this resistance to plasmids present in this strain.     

Effect of low-dose ultrasonic treatment on phystological variables inAnabaena flos-aquae andSelenastrum capricornutum

Summary Cell protein content in two species of cultured algaeAnabaena flos-aquae andSelenastrum capricornutum, was markedly enhanced by low-dose, short-duration ultrasonic treatment. Chlorophylla levels and¹⁴C-bicarbonate uptake rates were not affected by ultrasonic treatment in either species. Ultrasonically-activatedAnabaena cultures placed in media deficient in nitrogen and phosphorus produced more biomass per unit time, exhibited less cell-surface alkaline phosphatase activity per cell, and had a higher heterocyst frequency than non-sonicated, nutrient-deficient cultures. In contrast, sonicated, nutrient-deficientSelenastrum cultures grew more slowly and had higher alkaline phosphatase activity than non-sonicated variants. Collectively, the data suggest that key metabolic variables may be altered by ultrasonic treatment in algal cultures and that the magnitude and direction of change may be species-specific.     

Lipase production byCandida rugosa: Fermentation behaviour

Summary Extracellular lipase production byCandida rugosa growth has been studied. The main growth parameters, and the lipase activity in the culture broth were determined in order to identify the maximum of enzyme activity.The effect of lipidic material and size and growth phase of the inoculum on enzymatic production have been studied. Maximum extracellular lipase activity was associated with an increase in enzyme production when the number of viable cells started to decrease.     

Degradation of cholesterol to propionic acid by rat liver peroxisomes

Under standard assay conditions peroxisomes were found to contain less than 5% of the liver's cholesterol degradation activity. The remainder of the activity was localized in the mitochondria. When CaCl₂ was added to the standard assay mixture, peroxisomal cholesterol degradation activity increased to 34%. These results suggest that peroxisomes are capable of cholesterol catabolism, with the assay conditions used invitro determining the relative organelle contribution.