类球红细菌SOD发酵条件优化

本文对类球红细菌3757产SOD进行了发酵条件优化,结果得到了较优的培养基组成(g/L):苹果酸3,胰蛋白胨4,磷酸氢二钾0.9,磷酸二氢钾O.6,硫酸镁0.2,无水氯化钙0.075,硫酸亚铁0.012,EDATA 0.02,微量元素溶液10 mL,生长因子溶液10 mL,pH 7.5。其中,微量元素溶液配方(g/L):硼酸2.8,硫酸锰1.6,钼酸钠0.76,硫酸锌0.24,硫酸铜0.04;生长因子溶液配方(g/L):维生素B_1 1,烟酰胺(VPP)1,生物素0.016,对氨基苯甲酸1。较优培养条件为:接种量5%,转速150 r/min,种龄24 h,发酵温度32℃,发酵时间24 h。优化后酶活力较优化前提高了88.0%。     

酸溶辅助超声波法提取类球红细菌类胡萝卜素条件优化

通过单因素和正交试验,对类球红细菌3757产类胡萝卜素的提取条件进行了研究。先采用超声波法、酸溶法、研磨法、冻融法、酸溶辅助超声波法和冻融辅助超声波法优化了从类球红细菌3757菌株中提取类胡萝卜素的方法,然后开展了酸溶辅助超声波法的单因素和正交实验,最后进行了重复性实验。结果表明,酸溶辅助超声波法是较优的提取方法,丙酮是较好的提取溶剂。最佳提取条件为料液比110、超声波处理总时间20 min、酸浓度3 mol/L、酸溶时间25 min、超声波振幅40%、超声工作/间隔时间2 min/1 min、酸溶温度27℃,实验重现较好。优化后类胡萝卜素的提取率较优化前提高了74.8%,为其产业化创造了条件。     

粘红酵母发酵生产类胡萝卜素培养条件的优化

目的是通过测定不同条件下类胡萝卜素的产量找出粘红酵母发酵生产类胡萝卜素的最优条件。探讨了不同碳源、氮源对粘红酵母菌体生长和色素形成的影响,并通过正交实验确定了最佳条件组合。实验结果表明,最适发酵培养条件为：蔗糖40g/L、酵母粉20g/L、转速150r/min、装液量30mL/500mL、发酵时间84h。在此条件下,粘红酵母摇瓶发酵的生物量、类胡萝卜素含量及产量分别达15.17g/L、718.6μg/g、10.9mg/L,依次比初始发酵提高了1倍、7.4倍和15.8倍。发酵过程动态分析表明,84h色素产量达最高峰。     

类球红细菌类胡萝卜素抗氧化活性研究

研究了研磨法、超声波法、酸溶辅助超声波法和菌体浓度对类球红细菌类胡萝卜素抗氧化活性的影响。结果表明,不同提取方法和固液比条件下,类球红细菌类胡萝卜素均具有清除DPPH自由基能力、抗脂质过氧化能力和还原能力。酸溶辅助超声波法提取的类胡萝卜素产率最高、抗氧化活性最好。类球红细菌类胡萝卜素具有一定的抗氧化活性,其抗氧化活性随菌体浓度的增加而增加。     

红酵母类胡萝卜素高产菌株的筛选及其发酵生理学条件研究

从数株红酵母中选出了1株产类胡萝卜素能力较强的红酵母RY－98（生物量,类胡萝卜素含量和产量分别为19．9g/L,334.8ug/g和6．7mg/L);研究了该菌株产类胡萝卜素的最适营养与环境条件,获得了最佳的发酵生理学条件;葡萄糖40g/L,(NH4)2SO4 10g/L,酵母膏3g/L,蕃茄汁2mL/L,花生油0.5mL/L,接种量30mLL初始pH6.0和通气量（培养基装置040ml/250mL:,在此初步优化的培养条件下,红酵母RY－98经72小时摇瓶发酵其生物量,类胡萝卜素含量和产量分别可达26．8g/L,386.9ug/g和10．4mg/L,依次比初筛中提高了34．7％,15．6％,和55．2％。     

类球红细菌应用进展

类球红细菌(Rhodobacter Sphaeroides)属光合细菌,是目前研究最深入的光合微生物之一,具有多种代谢方式。不仅能够产生类胡萝卜素、辅酶Q10、超氧化物歧化酶、5-氨基乙酰丙酸和氢气,而且能够降解农药残留、有机废水和多环芳烃等有毒有害物质,应用领域十分广泛。本文综述了类球红细菌在食品、医药、农业、环境、氢气生产等领域中的应用进展,并对类球红细菌的应用前景进行展望。     

红酵母产类胡萝卜素固态发酵工艺条件的研究

该文研究了红酵母菌株D固态发酵产类胡萝卜素的培养基配方和发酵条件,得到初步优化的培养基为:啤酒糟∶豆粕∶麸皮=1∶3∶2.通过正交试验优化的培养条件是培养基含水量为60%,装量为6/150(即6g干基按设计的初始含水量用盐溶液配好后装于150ml三角瓶中),接种龄为24h,无机盐为0.5g/L MgSO4,其色素产量为14.2μg/g干基。色素产量随接种量增大而增大,细胞生物量、类胡萝卜素产量和含量均随发酵时间的增加逐渐增加,在96h分别达到最大值67.75mg dry-cell/g干基、9.88μg/g干基、145.80μg/g dry-cell,确定其最佳发酵周期为96h。     

酶法辅助超声波法提取类球红细菌辅酶Q10条件优化

采用单因素和正交实验优化了酶法辅助超声波法提取类球红细菌辅酶Q10的提取条件。结果表明,较优的辅酶Q10提取条件:超声波总时间14 min,超声波振幅30%,超声波工作/间歇时间1 min/1 min,料液比115,溶菌酶添加量300μL,酶解pH 7.2,酶解温度37℃,酶解时间90 min。优化后辅酶Q10的提取率比优化前提高了91.9%。     

红酵母RY—981类胡萝卜素发酵助剂的研究

通过探索几种促进剂和前体对红酵母RY－981类胡萝卜素发酵的影响,从中选出了番茄汁和花生油2种对红酵母生长及其类胡萝卜素合成具有显著促进作用的发酵助剂,并确定了适宜的用量。应用试验和发酵过程动态分析表明,这2种发酵助剂增产效果明显（当同时添加番茄汁2.6mL/L和花生油1ml/L时,菌体量、类胡萝卜素含量和产量可分别比对照组提高53．13％、20．29％和84．07％）,且对发酵过程菌体生长及生理代谢规律无不良影响。     

红酵母RY—98产类胡萝卜素培养基的优选及其发酵生理学研究

对红酵母ＲＹ－９８菌株产生类胡萝卜素的培养基组成和培养条件进行了初步研究,并对发酵过程作了动态分析。结果表明,培养基组成、糖浓度和添加剂以及培养基初始ｐＨ值、摇瓶装量与培养等均对该菌细胞生物量和类胡萝卜素产量有影响,其中ＺＳ添加剂的加入可以明显促进菌体类胡萝卜素的形成,这是研究新发现。在初步优化的培养基组成（葡萄糖４０ｇ／Ｌ、玉米浆１５ｇ／Ｌ、（ＮＨ４）２ＳＯ４２ｇ／Ｌ、ＺＳ添加剂１ｇ／Ｌ）和培养     

Optimization of activation conditions of Rhodobacter sphaeroides in hydrogen generation process

AIMS: To examine the effects of the culture age, illuminance intensity and changes in these parameters during activation on hydrogen generation process carried out by purple nonsulfur Rhodobacter sphaeroides bacteria. METHODS AND RESULTS: The following parameters were determined in all experiments: the amount of hydrogen evolved (measured using gas chromatography), biomass increase as dry mass, pH values and consumption of organic substance as chemical oxygen demand (COD). The medium used in the process of activation and hydrogen generation contained malic acid (15 mmol) and sodium glutamate (2 mmol). The optimum age of bacteria was 12-24 h and the best intensity of illuminance was found to be 5 cd sr m-2 on activation and 9 cd sr m-2 on hydrogen generation. These conditions provided hydrogen evolution of 1.39 l l-1 of the medium with the highest specific hydrogen production of 0.146 l H2 l-1 medium h-1 g-1 inoculum. An increase in the illuminance intensity resulted in a slight inhibition of the process. CONCLUSIONS: The activation stage of bacteria has a significant effect on the parameters of hydrogen photogeneration. The optimization of the activation stages allowed a shortening of the time of hydrogen generation and of the period after which hydrogen evolution starts. SIGNIFICANCE AND IMPACT OF THE STUDY: An innovative method of bacteria activation before the initiation of the hydrogen generation process has been used to optimize this process. The shortening of the process duration as well as the twice higher hydrogen yield can help in the designing of other systems (including also those operating under solar irradiation) in which R. sphaeroides bacteria are to be applied.     

Effects of growth conditions on production of methyl selenides in cultures of Rhodobacter sphaeroides

Rhodobacter sphaeroides 2.4.1 exposed to selenate or selenite produced volatile selenium compounds. Total amounts of dimethyl selenide, dimethyl diselenide, dimethyl sulfide and dimethyl disulfide in culture medium and headspace were determined. The highest selenate volatilization occurred in the late stationary phase of growth. However, cultures deprived of light in the stationary phase of growth produced much less of the volatile organo-selenium compounds. Lower culture pHs increased the rate of selenium volatilization. Low sulfate concentration limited biomass production and selenium volatilization; high sulfate concentrations had an enhancing effect on the release of organo-selenium compounds. Cultures of R. sphaeroides reacted very differently to amendments with increasing amounts of selenate and selenite. Only small amounts of selenite were volatilized; meanwhile high amounts of methylated selenides were found in selenate-poisoned cultures. Received 03 February 1997/ Accepted in revised form 16 May 1997     

Chromate reduction by Rhodobacter sphaeroides

Rhodobacter sphaeroides grew in the presence of up to 43 μM chromate and reduced hexavalent chromium to the trivalent form under both aerobic and anaerobic conditions. Reduced chromium remained in the external medium. Reductase activity was present in cells of R. sphaeroides independent of whether chromate was present or not in the growth medium. The reducing activity was found in the cytoplasmic cell fraction and was dependent on NADH. The chromate-reducing enzyme was purified by anion exchange, hydroxyapatite and hydrophobic interaction chromatography, and gel filtration. The molecular weight of the enzyme was 42 kDa as determined by gel filtration. The optimum of the reaction is at pH 7.0 and 30°C. The enzyme activity showed a hyperbolic dependence on the concentrations of both substrates, NADH and chromate, with a maximum velocity at 0.15 mM NADH. A K _m of 15±1.3 μM CrO₄ ²⁻ and a V _max of 420±50 μmol min⁻¹ mg protein⁻¹ was determined for the enzyme isolated from anaerobically grown cells and 29±6.4 μM CrO₄ ²⁻ and 100±9.6 μmol CrO₄ ²⁻ min⁻¹ mg protein⁻¹ for the one from aerobically grown ones. Journal of Industrial Microbiology & Biotechnology (2000) 25, 198–203. Received 05 January 2000/ Accepted in revised form 27 May 2000     

强化类球红细菌辅因子NADPH再生以提高法尼醇的产量

法尼醇(Farnesol,FOH)是由焦磷酸异戊烯基(IPP)和焦磷酸二甲基烯丙基(DMAPP)合成的法尼酰基焦磷酸盐(FPP)去焦磷酸化作用生成的。在类球红细菌中IPP和DMAPP是由MEP途径生成,而完整的MEP途径需要消耗大量的辅因子NADPH,增加胞内NADPH的量有可能强化FOH的合成。文中从增加NADPH的生成和降低NADPH的消耗这两个策略出发,分别干扰了编码6-磷酸葡萄糖异构酶基因(pgi)和谷氨酸脱氢酶基因(gdhA)的表达,同时强化了磷酸戊糖途径中6-葡萄糖磷酸脱氢酶基因(zwf)和6-葡萄糖酸磷酸脱氢酶基因(gnd)的表达。实验结果表明,经改造的菌株NADPH含量显著增加,干扰菌株中菌株RSpgii的产量较高,为3.91 mg/g,在过表达的菌株中同时过表达zwf和gnd基因的重组菌株(RSzg)的FOH产量提高到了3.43 mg/g。为了获得FOH产量更高的菌株,以RSpgii为出发菌株,分别与zwf和gnd组合调控,获得的菌株RSzgpi的产量达到了最高量为4.48 mg/g,是出发菌株RS-GY2产率的2.24倍。     

球形红杆菌L2的生物学特性及其应用

从淀粉废水中分离获得一株光合细菌,经形态特征,培养特征,生理生化特征及Ｇ＋Ｃｍｏｌ％含量等生物学特性分析,确定为球形红杆菌（Ｒｈｏｄｏｂａｃｔｅｒｓｐｈａｅｒｏｉｄｅｓ）Ｌ２。该菌应用于淀粉废水处理,ＣＯＤ去除率达９５．７％发酵产类胡萝卜素,产量达２９５ｍｇ／Ｌ;作为饲料添加剂进行肉鸡饲喂,增重１６．４０％。     

球形红细菌厌氧降解2,4-二硝基甲苯

【目的】研究不同环境条件对2,4-二硝基甲苯(2,4-DNT)生物降解的影响。【方法】采用光合细菌球形红细菌在温度为30 °C的光照培养箱中厌氧降解2,4-DNT,并用高效液相色谱仪测定其浓度。【结果】去除2,4-DNT的最佳条件是初始浓度40 mg/L、初始pH 7.0和接种量15%。另外,2,4-DNT在菌体延滞期被细胞吸收,然后在指数期作为碳源被降解。2,4-DNT的去除率在72 h达到98.8%。从液相色谱图中观察到有2种中间代谢产物,但在120 h内产物被逐渐降解。2,4-DNT的去除动力学符合一级速率模型。【结论】不同条件下2,4-DNT的去除率表明球形红细菌能有效降解2,4-DNT。     

Non-reciprocal regulation of Rhodobacter capsulatus and Rhodobacter sphaeroides recA genes expression

Abstract The Rhodobacter capsulatus recA gene has been isolated and sequenced. Its deduced amino acid sequence showed the closest identity with the Rhodobacter sphaeroides RecA protein (91% identity). However, the promoter regions of both R. capsulatus and R. sphaeroides recA genes are only 64% similar. An Escherichia coli -like LexA binding site was not present in the upstream region of the R. capsulatus recA gene. Nevertheless, the R. capsulatus recA gene is inducible by DNA damage in both hetero- and phototrophically growing conditions. The R. capsulatus recA gene is poorly induced when inserted into the chromosome of R. sphaeroides , indicating that the recA gene of both bacteria possess different control sequences despite their phylogenetically close relationship.     

Light-dependent transformation of anthranilate to indole by Rhodobacter sphaeroides OU5

Rhodobacter sphaeroides OU5 transformed anthranilate (2 mM) to an indole (0.7 mM) in a light-dependent process. Photobiotransformation was enhanced by tricarboxylic acid cycle intermediates and the indole formed was identified as 2,3 dihydroxy indole. Journal of Industrial Microbiology & Biotechnology (2000) 24, 219–221. Received 16 September 1999/ Accepted in revised form 20 December 1999