Influence of growth substrate on production of cellulase enzymes by Trichoderma harzianum E58

Cellulase production by Trichoderma harzianum E58 grown on lactose and various cellulosic substrates such as Solka Floe, Avicel, and steamed aspenwood was investigated. The culture filtrates of T. harzianum E58 obtained after growth on these substrates were assayed for their cellulase activities and overall hydrolytic activities. The severity of the steaming conditions used for the aspenwood had a pronounced effect on the cellulolytic activity of the produced culture filtrates. Those substrates that were more readily hydrolyzed by the cellulase complex were the poorest substrates for inducing an active cellulase complex. Substrates such as acid-impregnated aspenwood and lactose induced a less hydrolytic efficient cellulase complex than more recalcitrant substrates such as microcrystalline cellulose.     

Wheat straw,a potential substrate for cellulase production usingTrichoderma reesei

Wheat straw, pre-treated with either alkali or steam, or both together, was used 46% more efficiently byTrichoderma reesei than untreated straw. Carboxymethyl cellulase and filter paper cellulase were higher by 52% and 74%, respectively, in the treated substrate compared with the untreated one.     

Raffinose-induced mutanase production from Trichoderma harzianum

Abstract The enzyme α (1 → 3),3-glucanohydrolase (referred to as mutanase) from the filamentous fungus Trichoderma harzianum OMZ 779 is capable of degrading the water-insoluble glucan in dental plaque. Previously, it was necessary to produce the glucan (referred to as mutan) in vitro for use as the sole carbon source and inducer of mutanase synthesis in fungal cultures. We report here that raffinose also induces the production of mutanase. The metabolism of raffinose differed from that of other sugars in metabolic end products and secreted protein profile. In addition to mutanase, we observed an approximately 15 000 M _r protein that was also regulated by carbon source and by illumination conditions.     

Nutrient control for stationary phase cellulase production in Trichoderma reesei Rut C-30

This work describes the use of nutrient limitations with Trichoderma reesei Rut C-30 to obtain a prolonged stationary phase cellulase production. This period of non-growth may allow for dependable cellulase production, extended fermentation periods, and the possibility to use pellet morphology for easy product separation. Phosphorus limitation was successful in halting growth and had a corresponding specific cellulase production of 5 ± 2 FPU/g-h. Combined with the addition of Triton X-100 for fungal pellet formation and low shear conditions, a stationary phase cellulase production period in excess of 300 h was achieved, with a constant enzyme production rate of 7 ± 1 FPU/g-h. While nitrogen limitation was also effective as a growth limiter, it, however, also prevented cellulase production.     

Starch industry wastewater as a substrate for antagonist, Trichoderma viride production

Starch industry wastewater was investigated to assess and improve its potential as a raw material for the conidia production of biocontrol fungi, Trichoderma viride. The wastewater was tested with and without supplements of glucose, soluble starch, meat peptone and probable conidiation inducer chemicals in shake flask culture. Addition of complex carbon source (soluble starch, 1% and 2% w/v) produced maximum conidia ( approximately 3.02 and 4.2 x 10(10)CFU/mL, respectively). On the other hand, glucose addition as a simpler carbon source was either ineffective or, reduced conidia production (from 1.6 x 10(8) in control to 3.0 x 10(7)CFU/mL in 5% w/v glucose supplement). Supplement of nitrogen source showed a small increase of conidia concentration. Propionic, maleic and humic acids, EDTA, pyridine, glycerol and CaCO(3) were examined as probable conidiation inducers and showed effect only on initial rate of conidiation with no increase in final conidia concentration. Intra and extracellular ATP correlation with spore production showed dependence on growth media used and conidia concentration at the end of fermentation. Addition of carbon and nitrogen sources showed an increase in protease activity (from 0.4985 to 2.43 IU/mL) and entomotoxicity (from 10448 to 12335 spruce budworm unit (SBU)/microL). Entomotoxicity was improved by 11% in fermenter over shake flask when starch industry wastewater was supplemented with meat peptone.     

Addition of aluminum oxide microparticles to Trichoderma viride My preculture enhances cellulase production and influences fungal morphology

Morphological engineering techniques have recently become popular, since they are used to increase the production of a variety of metabolites and enzymes when fungi are grown in submerged cultures. This study aimed to facilitate cellulase production by adding aluminum oxide to Trichoderma viride My precultures.

The results showed that the highest cellulase activity was achieved when aluminum oxide at 10 g/L was used, and the activities of cellulase for filter paper and endoglucanase activity assays increased from 519.11 to 607.35 U/mL by 17.1%, and from 810.08 U/mL to 917.59 U/mL by 13.3%, compared with the control, respectively. Addition of aluminum oxide decreased the size of T. viride My pellets and increased the final pH. The changes in pellet diameter after the addition of different concentrations of aluminum oxide were fitted using a modified exponential decay model, which could precisely predict the pellet size by controlling aluminum oxide concentration.

The optimum concentration of microparticles, and therefore pellet size, could significantly improve cellulase production, which is an encouraging step towards commercial cellulase production.

     

Xylanase production by Trichoderma harzianum E58

Summary Growth of Trichoderma harzianum E58 on hemicellulose-rich media, both in batch and fermentor cultures, resulted in independent profiles for the production of xylanase and endoglucanase enzymes. Dramatic differences in the ratio of xylanase to endoglucanase activities were observed among cultures grown on cellulose-rich Solka Floc and xylan. These results indicated that the induction of xylanases and cellulases was likely to be under separate regulatory control. The specific activity and amount of xylanases produced were found to be dependent on the concentration of xylan in the growth media. Growth on oat spelts xylan or the hemicellulose-rich, water-soluble fraction from steam-treated aspenwood (SEA-WS) greatly enhanced the production of xylanases and xylosidase in the culture filtrates. Constitutive levels of xylanase and endoglucanase enzymes were detected during growth of the fungus on glucose.Offprint requests to: D. J. Senior     

Stimulatory effect of oxidized cellulose on cellulase formation by Trichoderma reesei

Crystalline cellulase has been electrochemically oxidized to yield preparations containing various different percentages of oxidized end-groups. These celluloses have been used as carbon sources for growth and cellulase production by Trichoderma reesei . A low content of oxidized end groups in the celluloses (0.1–0.65%) stimulated cellulase production but not growth, whereas higher contents (> 1%) where inhibitory to both. The cellulolytic enzyme system secreted under stimulated conditions contained the same proportion of individual cellulase enzymes (cellobiohydrolase I and II, endoglucanase I) as the control, indicating a general stimulatory effect of oxidized cellulose. Activity of cellulases against oxidized celluloses in vitro was not stimulated, and only slightly inhibitory at high degrees of oxidation. The data support a potential role of cellulose oxidation in regulating cellulase formation by T. reesei .     

Enrichment technique for the selection of catabolite repression-resistant mutants of Trichoderma as producers of cellulase

Abstract The enrichment technique for the preparation of catabolite repression-resistant producers of cellulase from Trichoderma reesei is based on the submerged cultivation of mutagenized conidia on 2% (w/v) cellobiose or carboxymethyl-cellulose and in the presence of 0.5% (w/v) 2-deoxyglucose as the catabolite repressor. Conidia that are resistant towards the catabolite repressor can produce enzymes necessary for hydrolysis of used substrates and grow under the given conditions. They can be separated from the ungerminated conidia by filtration and used for the production of new conidia which are already enriched with catabolite repression-resistant mutants.     

A method for increasing cellulase production by Trichoderma viride

A doubling of cellulase production by Trichoderma viride (QM9414) is possible by increasing the cellulose concentration in the medium from 0.75 to 2%, increasing the nitrogen concentration, and controlling pH during growth. A four-to fivefold increase in β -glucosidase is found with the higher cellulose concentration. Culture filtrates from 2% cellulose cultures can reduce the hydrolysis time in a practical saccharification to one-half that required by culture filtrates from 0.75% cellulose cultures.     

Sophorose metabolism and cellulase induction in Trichoderma

The cellulase inducer sophorose was rapidly catabolized to CO₂ and H₂O by Trichoderma: only small amounts were used to induce the synthesis of cellulase. ³H-sophorose uptake began after a lag of 1 h and its half-life in the medium was less than 5 h. Cellulase activity in the medium did not increase till 6 h after the addition of sophorose and reached a half maximum value at 14 h. The presence of free sophorose in the medium was required for continuous cellulase production. Several small sophorose addition induced much more cellulase than an equivalent single dose. These results are attributed to two pathways of sophorose utilization, a catabolic pathway that has a high capacity but low affinity for sophorose and an inductive pathway having a lower capacity but higher affinity for sophorose.     

Continuous production of enzymes under carbon-limited conditions by Trichoderma harzianum P49P11

Carbon-limited chemostat cultures were performed using different carbon sources (glucose, 10 and 20 g/L; sucrose, 10 g/L; fructose/glucose, 5.26/5.26 g/L; carboxymethyl cellulose, 10 g/L; and carboxymethyl cellulose/glucose, 5/5 g/L) to verify the capability of the wild type strain Trichoderma harzianum to produce extracellular enzymes. All chemostat cultures were carried out at a fixed dilution rate of 0.05 h^?1. Experiments using glucose, fructose/glucose and sucrose were performed in duplicate. Glucose condition was found to induce the production of enzymes that can catalyse the hydrolysis of p-nitrophenyl-β-d-glucopyranoside (PNPGase). A concentration of 20 g/L of glucose in the feed provided the highest productivity (1048 ± 16 U/mol h). Extracellular polysaccharides were considered the source of inducers. Based on the obtained results, a new PNPGase production process was developed using mainly glucose. This process raises interesting possibilities of synthesizing the inducer substrate and the induced enzymes in a single step using an easily assimilated carbon source under carbon-limited conditions.     

Roles of extracellular lactose hydrolysis in cellulase production by Trichoderma reesei Rut C30 using lactose as inducing substrate

Lactose, an inexpensive, soluble substrate, offers reasonably good induction for cellulase production by Trichoderma reesei. The fungus does not uptake lactose directly. Lactose is hydrolyzed to extracellular glucose and galactose for subsequent ingestion. The roles of this extracellular hydrolysis step were investigated in this study. Batch and continuous cultures were grown on the following substrates: lactose, lactose–glycerol mixtures, glucose, galactose, and glucose–galactose mixtures. Cell growth, substrate consumption, lactose hydrolysis, and lactase and cellulase production were followed and modeled. Cells grew much faster on glucose than on galactose, but with comparable cell yields. Glucose (at >0.3 g/L) repressed the galactose consumption. Cellulase synthesis was growth-independent while lactase synthesis was growth-dependent, except at D < ∼0.065 h⁻¹ where a basal level lactase production was observed. For cellulase production the optimal D was 0.055–0.065 h⁻¹ where the enzyme activity and productivity were both near maxima. The model suggested that lactase synthesis was subject to weak galactose repression. As the galactose concentration increased at high D (>0.1 h⁻¹), lactase synthesis became repressed. The insufficient lactase synthesis limited the lactose hydrolysis rate. Extracellular lactose hydrolysis was concluded to be the rate-limiting step for growth of T. reesei Rut C30 on lactose.     

Induction of cellulase formation in Trichoderma reesei by cellobiono-1,5-lacton

Induction of synthesis of cellulolytic enzymes in Trichoderma reesei QM 9414 by cellobiono-1,5-lactone (CBL) has been investigated in a replacement system lacking additional carbon source. CBL induced cellulase secretion optimally at pH 5 and a concentration of 70 g/ml. Higher concentrations lead to lower induction. De novo induction of cellulases was proven by the inhibitory effect of cycloheximide addition. Induction by CBL was shown to act synergistically on induction by sophorose, as it decreased the concentration of sophorose required for maximal induction. Maximal endo--1,4-glucanase activities induced by either sophorose or CBL were comparable. The CBL-induced cellulase system contained all the major cellulolytic enzymes of T. reesei, i.e. cellobiohydrolase I and II, and endoglucanase I, as shown by SDS-PAGE, Western blotting and detection with specific mono- and polyclonal antibodies. No differences were seen in the types of individual enzymes formed upon induction by either sophorose or CBL. No other hydrolytic enzymes appear to be induced by CBL (i.e. amylase, laminarinase, xylanase).Abbreviations SDS-PAGE polyacrylamide gel electrophoresis in the presence of sodium-dodecylsulfate - CBL cellobiono-1,5-lacton - CBH cellobiohydrolase - EG endoglucanase - IgG immunoglobulin G     

Improvement of ganoderic acid production by fermentation of Ganoderma lucidum with cellulase as an elicitor

Two-stage cultivation of Ganoderma lucidum was performed for the enhanced production of ganoderic acid (GA). Cellulase was identified to be an effective elicitor for the improvement of GA production, and GA titer reached 1334.5 mg/l compared to the control (779.6 mg/l) using lactose as the substrate without cellulase addition. Loading of 5 mg/l cellulase on day 3 resulted in the maximal GA titer of 1608 mg/l. To our knowledge, this is the first time that cellulase was used as the elicitor to enhance GA production. Submerged fermentation in a 2.0-l bioreactor was also conducted with cellulase as the elicitor, and as a result the maximal GA titer of 1252.7 mg/l was obtained on day 12. This is so far the best GA production obtained in submerged fermentation of G. lucidum.     

A long-wavelength fluorescent substrate for continuous fluorometric determination of cellulase activity: resorufin-beta-D-cellobioside

A simple and reliable continuous assay procedure for measurement of cellulase activity from several species using the new substrate resorufin-beta-D-cellobioside (Res-CB) has been developed. The product of enzyme reaction, resorufin, exhibits fluorescence emission at 585 nm with excitation at 571 nm and has a pK(a) of 5.8, which allows continuous measurement of fluorescence turnover at or near physiological pH values. The assay performed using purified cellulase from the microscopic fungus Trichoderma reesei has been shown to give the kinetic parameters K(m) of 112 microM and V(max) of 0.000673 micromol/mL/min. Methods for performing the assay using cellulases isolated from both live Arabidopsis thaliana plant and Aspergillus niger fungal species are presented.     

Dissolved oxygen as principal parameter for conidia production of biocontrol fungi Trichoderma viride in non-Newtonian wastewater

Dissolved oxygen (DO) concentration was selected as a principal parameter for translating results of shake flask fermentation of Trichoderma viride (biocontrol fungi) to a fermenter scale. All fermentations were carried out in a 7.5 l automated fermenter with a working volume of 4 l. Fermentation performance parameters such as volumetric oxygen transfer coefficient (k _L a), oxygen uptake rate (OUR), rheology, conidia concentration, glucose consumption, soluble chemical oxygen demand, entomotoxicity and inhibition index were measured. The conidia concentration, entomotoxicity and inhibition index were either stable or improved at lower DO concentration (30%). Variation of OUR aided in assessing the oxygen supply capacity of the fermenter and biomass growth. Meanwhile, rheological profiles demonstrated the variability of wastewater during fermentation due to mycelial growth and conidiation. In order to estimate power consumption, the agitation and the aeration requirements were quantified in terms of area under the curves, agitation vs. time (rpm h), and aeration vs. time (lpm h). This simple and novel strategy of fermenter operation proved to be highly successful which can be adopted to other biocontrol fungi.     

The use of lignocellulosic wastes for production of cellulase by Trichoderma reesei

Summary The feasibility of cellulase production by Trichoderma reesei using inexpensive lignocellulosic material was examined. Sulfite pulp used as standard substrate yielded 3.7 IU/ml filter paper units (FPU) and 2.15 IU/ml -glucosidase. The yield was 185 FPU per gram total carbohydrate (CH) in the fermentation medium. Steam treated wheat straw (2%) gave 1.9 FPU/ml, 0.83 IU/ml -glucosidase and 151 FPU/g CH, whereas the spent fibres remaining after enzymatic hydrolysis of steamed wheat straw gave 2.4 FPU/ml, 1.55 IU/ml -glucosidase and 147 FPU/g CH. A good substrate (3%) was also the combustible fraction of municipal waste (BRAM) treated with NaOH, which gave 2.5 FPU/ml, 0.86 IU/ml -glucosidase and 130 FPU/g CH. A further increase in the final enzyme titer is obtainable by increasing the substrate concentration. In shake cultures 5% steamed wheat straw gave 3.8 FPU/ml and 1.95 IU/ml -glucosidase. Untreated wheat straw gave only low final enzyme titers and low yields of FPU/g CH. In the case of lignocellulosic substrates a constant pH-value of pH 6.0 during the fermentation gave optimal yields.