Continuous gluconic acid production by the yeast-like Aureobasidium pullulans in a cascading operation of two bioreactors

The application of a new developed process for the continuous production of gluconic acid using a cascade of two bioreactors in a continuous process is shown reaching the highest concentration of gluconic acid described in the literature for continuous culture fermentation. Very high gluconic acid concentrations of 272-308 g/l have been achieved under continuous cultivation of free-growing cells of Aureobasidium pullulans in the first bioreactor at residence times (RT) between 19.5 and 24 h with formation rates for the generic product between 12.7 and 13.9 g/(l h). Gluconic acid, 350-370 g/l, was continuously reached in the second bioreactor at a total RT of 30.8-37 h with R (j) of 9.2-12 g/(l h). The highest specific gluconic acid production (m (p)) of 3.6 g/(g h) was found in the first bioreactor at the lowest RT of 19.5 h. The highest selectivity of 93.6% was determined in the first bioreactor as well. Complete glucose consumption was obtained at 37 h total residence time in the second bioreactor. Gluconic acid, 433 g/l, was continuously produced in the second bioreactor at a total RT of 37 h.     

Extractive fermentation for butyric acid production from glucose by Clostridium tyrobutyricum

A novel extractive fermentation for butyric acid production from glucose, using immobilized cells of Clostridium tyrobutyricum in a fibrous bed bioreactor, was developed by using 10% (v/v) Alamine 336 in oleyl alcohol as the extractant contained in a hollow-fiber membrane extractor for selective removal of butyric acid from the fermentation broth. The extractant was simultaneously regenerated by stripping with NaOH in a second membrane extractor. The fermentation pH was self-regulated by a balance between acid production and removal by extraction, and was kept at approximately pH 5.5 throughout the study. Compared with conventional fermentation, extractive fermentation resulted in a much higher product concentration (>300 g/L) and product purity (91%). It also resulted in higher reactor productivity (7.37 g/L. h) and butyric acid yield (0.45 g/g). Without on-line extraction to remove the acid products, at the optimal pH of 6.0, the final butyric acid concentration was only approximately 43.4 g/L, butyric acid yield was 0.423 g/g, and reactor productivity was 6.77 g/L. h. These values were much lower at pH 5.5: 20.4 g/L, 0.38 g/g, and 5.11 g/L. h, respectively. The improved performance for extractive fermentation can be attributed to the reduced product inhibition by selective removal of butyric acid from the fermentation broth. The solvent was found to be toxic to free cells in suspension, but not harmful to cells immobilized in the fibrous bed. The process was stable and provided consistent long-term performance for the entire 2-week period of study.     

Production of gluconic acid by immobilized in pumice stones mycelium of Aspergillus niger using unconventional oxygenation of culture

Gluconic acid was produced in repeated batch processes with Aspergillus niger AM-11, immobilized in pumice stone particles using an unconventional oxygenation of culture media based on the addition of H₂O₂, decomposed by catalase to O₂ and water. The highest gluconic acid productivity of 8.2 g l^–1 h^–1 was reached with 30 g immobilized mycelium per 150 ml, 10% (w/v) glucose, at 24 °C and pH 6.5, with O₂ at 100% saturation. The immobilized mycelium was successfully reused up to 8 times in 1-h batches with only a slight loss (11%) of gluconic acid productivity.     

5-酮基-D-葡萄糖酸发酵生产的工艺条件优化

葡萄糖酸氧化杆菌可将葡萄糖转化为5-酮基-D-葡萄糖酸(5-KGA),而5-KGA是重要食品添加剂L(+)-酒石酸的合成前体。为提高5-KGA产量及其对葡萄糖的转化率,对5-KGA发酵生产的工艺条件进行优化。在摇瓶水平最适的培养基和培养条件下,5-KGA最高产量为19.7 g/L,较优化前提高43.8%。在5 L发酵罐上控制恒定pH值5.5、溶氧浓度15%条件下,5-KGA产量达到46.0 g/L,较摇瓶最高产量提高1.3倍,应用葡萄糖流加工艺,5-KGA最高产量达到75.5 g/L,转化率超过70%,与已见报道的最高水平相比提高了32.0%,为实现微生物发酵生产5-KGA、进而合成L(+)-酒石酸的工业化提供了切实有效的途径。     

Bioconversion of grape must into modulated gluconic acid production by Aspergillus niger ORS-4.410

AIMS: Analysis of regulators for modulated gluconic acid production under surface fermentation (SF) condition using grape must as the cheap carbohydrate source, by mutant Aspergillus niger ORS-4.410. Replacement of conventional fermentation condition by solid-state surface fermentation (SSF) for semi-continuous production of gluconic acid by pseudo-immobilization of A. niger ORS-4.410. METHODS AND RESULTS: Grape must after rectification was utilized for gluconic acid production in batch fermentation in SF and SSF processes using mutant strain of A. niger ORS-4.410. Use of rectified grape must led to the improved levels of gluconic acid production (80-85 g l(-1)) in the fermentation medium containing 0.075% (NH4)2HPO4; 0.1% KH2PO4 and 0.015% MgSO4.7H2O at an initial pH 6.6 (+/-0.1) under surface fermentation. Gluconic acid production was modulated by incorporating the 2% soybean oil, 2% starch and 1% H2O2 in fermentation medium at continuously high aeration rate (2.0 l min(-1)). Interestingly, 95.8% yield of gluconic acid was obtained when A. niger ORS-4.410 was pseudo-immobilized on cellulose fibres (bagasse) under SSF. Four consecutive fermentation cycles were achieved with a conversion rate of 0.752-0.804 g g(-1) of substrate into gluconic acid under SSF. CONCLUSIONS: Use of additives modulated the gluconic acid production under SF condition. Semi-continuous production of gluconic acid was achieved with pseudo-immobilized mycelia of A. niger ORS-4.410 having a promising yield (95.8%) under SSF condition. SIGNIFICANCE AND IMPACT OF THE STUDY: The bioconversion of grape must into modulated gluconic acid production under SSF conditions can further be employed in fermentation industries by replacing the conventional carbohydrate sources and expensive, energy consuming fermentation processes.     

Citric and gluconic acid production from fig by Aspergillus niger using solid-state fermentation

The production of citric and gluconic acids from fig by Aspergillus niger ATCC 10577 in solid-state fermentation was investigated. The maximal citric and gluconic acids concentration (64 and 490 g/kg dry figs, respectively), citric acid yield (8%), and gluconic acid yield (63%) were obtained at a moisture level of 75%, initial pH 7.0, temperature 30°C, and fermentation time in 15 days. However, the highest biomass dry weight (40 g/kg wet substrate) and sugar utilization (90%) were obtained in cultures grown at 35°C. The addition of 6% (w/w) methanol into substrate increased the concentration of citric and gluconic acid from 64 and 490 to 96 and 685 g/kg dry fig, respectively. Journal of Industrial Microbiology & Biotechnology (2000) 25, 298–304. Received 15 April 2000/ Accepted in revised form 11 August 2000     

过量表达自身hemA基因的重组大肠杆菌发酵生产5-氨基乙酰丙酸的研究

研究了优化重组大肠杆菌产5-氨基乙酰丙酸（ALA）的条件,提高大肠杆菌发酵生产AL气的产量。在测定重组大肠杆菌GT48的生长曲线的基础上,确定诱导时间,优化摇瓶发酵条件。然后,进一步在5L发酵罐上进行间歇和流加发酵研究。摇瓶实验表明,细胞培养最佳初始pH为6．5,最佳诱导时间为稳定期前期,最佳接种量为2％,过高的葡萄糖浓度对细胞生长和产物合成均有一定的抑制作用。在5L发酵罐间歇发酵中,重组菌产ALA能力达到47．8mg／L。采用流加发酵可以进一步将产物产量提高到63．8mg／L。构建的过量表达自身的hemA基因的大肠杆菌具有较高的产ALA能力,通过发酵条件优化和采用流加发酵可以提高AL气产量。     

产酸丙酸杆菌生长特性及5L罐发酵动力学研究

论文在摇瓶水平对产酸丙酸杆菌基本生长特性（温度、pH、摇床转速、接种量、种龄等）、碳源、氮源利用情况、产物抑制及5 L罐发酵动力学进行了研究。结果表明,该菌在32℃,初始pH 6．5,摇床转速150 r/min,接种24 h的种子液,接种量为5％条件下,产酸丙酸杆菌生长及产酸水平达最高值;该菌可利用碳源十分广泛,但对氮源要求比较高,只可利用有机氮源;在不同初始葡萄糖浓度下,产酸丙酸杆菌生长及产酸水平差异不大,无明显底物抑制现象;在2g/L的初始丙酸盐浓度下,该菌生长受到明显抑制;在5L发酵罐中,初始葡萄糖浓度为58．8 g/L,发酵72 h,葡萄糖消耗完全,丙酸终浓度达22．4 g/L,丙酸得率和产率分别达0．381 g/g和0．295 g/（L·h）,丙酸占总酸比例达72．10％。     

Extractive fermentation for lactic acid production

Lactic acid extractive fermentation was demonstrated using Alamine 336 in oleyl alcohol at acidic pH. The use of an efficient extraction system was possible through employment of the cell immobilization procedure. Process modeling was performed to relate the various process parameters such as flow rate, concentration, and pH. In experiments with 15% Alamine 336/oleyl alcohol, the bioreactor operation resulted in a higher productivity (12 g/L gel h) compared to that of a control fermentation (7 g/L gel h). Strategies for optimizing the extractive fermentation process were proposed considering both productivity and product recovery.     

Continuous production of ammonium lactate by Streptococccus cremoris in a three-stage reactor

Batch and continuous fermentation studies were performed to optimize the production of ammonium lactate from whey to optimize the production of ammonium lactate from whey permeate. The product known as fermented ammoniated condensed whey permeate (FACWP) is a very promising animal feed. After an initial screening of four strains which produce predominantly L(+)- lactic acid, the desired isomer [D(-)-lactic acid is toxic], Streptococcus cremoris 2487 was chosen for further study. In batch mode, pH between 6.0 and 6.5 and 35 degrees C provided optimum incubation conditions. To stimulate a plug flow reactor, three CSTRs (continuous stirred tank reactors) were connected in tandem. For a 7.5-h retention time, 1.6-fold and 1.3-fold higher productivities were obtained for three-stage than for the single- and two-stage reactors, respectively. Various retentions times were examined (5, 7.5, and 10 h; 5g/L yeast extract). Although maximum lactate productivity occurred at a 5-h residence time (5.38 g/L H. 75% lactose utilization), lactose utilization was more complete at 7.5 h (4.38 g/L h productivity, 91% lactose utilization and a productivity, 91% lactose utilization). Retention time was increased to 15 h to obtain 95.9% lactose utilization and a productivity of 2.42g/L h for 2g/L yeast extract. Based on this lower yeast extract concentration, it was determined that ammonium lactate production and subsequent concentration by 11-fold would yield a product (FACWP) 17% more than soybean meal (crude protein contents are equivalent, 44%) at current market prices.     

大肠杆菌全细胞转化联产L-2-氨基丁酸和D-葡萄糖酸

以大肠杆菌BL21(DE3)为表达宿主,构建两株分别表达L-苏氨酸脱氨酶(LTD,基因来源大肠杆菌)和共表达亮氨酸脱氢酶(LDH,来源蜡样芽孢杆菌)/葡萄糖脱氢酶(GDH,来源枯草芽孢杆菌)的重组大肠杆菌,在此基础上,构建了一种以L-苏氨酸和D-葡萄糖为底物联产L-2-氨基丁酸(L-ABA)和D-葡萄糖酸的全细胞转化系统。通过转化条件(温度、p H、细胞通透性和菌体量)优化,并采用分批补料策略,164 g/L L-苏氨酸和248 g/L D-葡萄糖最终转化得到141.6 g/L的L-ABA和269.4 g/L的D-葡萄糖酸,时空得率分别达到7.1 g/(L?h)和13.5 g/(L?h),得率超过99%。本研究使用价格低廉的大宗化学品高效率生产出有较高附加值的产物,全细胞转化系统无需额外添加昂贵的辅酶,更适用于工业化生产。     

D-核糖发酵过程参数的研究与控制

以７Ｌ自控发酵罐进行Ｄ－核糖发酵实验,对Ｄ－核糖发酵过程参数进行优化,发现对数生长后期接种,溶氧控制在４０％左右,以葡萄糖酸补料并调节ｐＨ值在７．２左右,可使罐的发酵单位由４５ｇ／Ｌ提高至６５ｇ／Ｌ左右。     

Production of polymalic acid and malic acid by Aureobasidium pullulans fermentation and acid hydrolysis

Malic acid is a dicarboxylic acid widely used in the food industry and also a potential C4 platform chemical that can be produced from biomass. However, microbial fermentation for direct malic acid production is limited by low product yield, titer, and productivity due to end‐product inhibition. In this work, a novel process for malic acid production from polymalic acid (PMA) fermentation followed by acid hydrolysis was developed. First, a PMA‐producing Aureobasidium pullulans strain ZX‐10 was screened and isolated. This microbe produced PMA as the major fermentation product at a high‐titer equivalent to 87.6 g/L of malic acid and high‐productivity of 0.61 g/L h in free‐cell fermentation in a stirred‐tank bioreactor. Fed‐batch fermentations with cells immobilized in a fibrous‐bed bioreactor (FBB) achieved the highest product titer of 144.2 g/L and productivity of 0.74 g/L h. The fermentation produced PMA was purified by adsorption with IRA‐900 anion‐exchange resins, achieving a ～100% purity and a high recovery rate of 84%. Pure malic acid was then produced from PMA by hydrolysis with 2 M sulfuric acid at 85°C, which followed the first‐order reaction kinetics. This process provides an efficient and economical way for PMA and malic acid production, and is promising for industrial application. Biotechnol. Bioeng. 2013; 110: 2105–2113. © 2013 Wiley Periodicals, Inc.     

An artificial intelligence tool for bioprocess monitoring: application to continuous production of gluconic acid by immobilized Aspergillus niger

Experimental data on continuous fermentation of sucrose and glucose solution at low pH to gluconic acid by Asprgillus niger immobilized on cellulose fabric show complex dynamic behaviour including a decline in yield. The data have been analyzed using an artificial intelligence based symbolic regression technique to provide a mathematical model for predicting values of conversion 5, 10 and 15 h ahead values of conversion. These predictions can be used during continuous operations to monitor the bioprocess and adjust the residence time of fermentation to get complete and more efficient conversion of sucrose or glucose to gluconic acid.     

Production of mannitol by Lactobacillus intermedius NRRL B-3693 in fed-batch and continuous cell-recycle fermentations

Improved fermentation processes were developed for the production of mannitol by a heterofermentative lactic acid bacterium (Lactobacillus intermedius NRRL B-3693). A fed-batch fermentation protocol overcame limitations caused by high substrate concentrations. The process was developed using corn steep liquor and glucose as inexpensive industrial nutrient sources, supplemented with a small amount of soy peptone and manganese. The fed-batch process resulted in a concentration of 176 ± 0.5 g mannitol from 184 ± 0 g fructose and 92 ± 0.1 g glucose per L of final fermentation broth in 30 h with a volumetric productivity of 5.9 g/(L h). Further increases in volumetric productivity of mannitol were obtained in a continuous cell-recycle fermentation process that reached more than 40 g/(L h), despite reduced mannitol levels of 78–98 g/L and residual substrate of 10–20 g/L. This is the first report of such a high volumetric productivity of mannitol by a heterofermentative lactic acid bacterium.     

丙酸絮凝发酵新工艺研究

报道了丙酸发酵的一种新工艺:絮凝发酵工艺。采用谢氏丙酸杆菌(Propionibacterium shermanii)W125在批次发酵产酸达到29g/L的基础上,选择氢氧化钙作为中和剂兼絮凝剂,建立了絮凝半连续发酵工艺,连续运行250h,产酸量达到了35.4g/L,产酸率提高了22%,糖酸转化率达到了51.56%,体积效率达到了0.37g/(L/h)。     

Production of L(+)-lactic acid from glucose and starch by immobilized cells of Rhizopus oryzae in a rotating fibrous bed bioreactor

A rotating fibrous-bed bioreactor (RFB) was developed for fermentation to produce L(+)-lactic acid from glucose and cornstarch by Rhizopus oryzae. Fungal mycelia were immobilized on cotton cloth in the RFB for a prolonged period to study the fermentation kinetics and process stability. The pH and dissolved oxygen concentration (DO) were found to have significant effects on lactic acid productivity and yield, with pH 6 and 90% DO being the optimal conditions. A high lactic acid yield of 90% (w/w) and productivity of 2.5 g/L.h (467 g/h.m(2)) was obtained from glucose in fed-batch fermentation. When cornstarch was used as the substrate, the lactic acid yield was close to 100% (w/w) and the productivity was 1.65 g/L.h (300 g/h.m(2)). The highest concentration of lactic acid achieved in these fed-batch fermentations was 127 g/L. The immobilized-cells fermentation in the RFB gave a virtually cell-free fermentation broth and provided many advantages over conventional fermentation processes, especially those with freely suspended fungal cells. Without immobilization with the cotton cloth, mycelia grew everywhere in the fermentor and caused serious problems in reactor control and operation and consequently the fermentation was poor in lactic acid production. Oxygen transfer in the RFB was also studied and the volumetric oxygen transfer coefficients under various aeration and agitation conditions were determined and then used to estimate the oxygen transfer rate and uptake rate during the fermentation. The results showed that the oxygen uptake rate increased with increasing DO, indicating that oxygen transfer was limited by the diffusion inside the mycelial layer.     

Ethanol production from eucalyptus wood hemicellulose hydrolysate by Pichia stipitis

Ethanol production was evaluated from eucalyptus wood hemicellulose acid hydrolysate using Pichia stipitis NRRL Y-7124. An initial lag phase characterized by flocculation and viability loss of the yeast inoculated was observed. Subsequently, cell regrowth occurred with sequential consumption of sugars and production of ethanol. Polyol formation was detected. Acetic acid present in the hydrolysate was an important inhibitor of the fermentation, reducing the rate and the yield. Its toxic effect was due essentially to its undissociated form. The fermentation was more effective at an oxygen transfer rate between 1.2 and 2.4 mmol/L h and an initial pH of 6.5. The hydrolysate used in the experiences had the following composition (expressed in grams per liter): xylose 30, arabinose 2.8, glucose 1.5, galactose 3.7, mannose 1.0, cellobiose 0.5, acetic acid 10, glucuronic acid 1.5, and galacturonic acid 1.0. The best values obtained were maximum ethanol concentration 12.6 g/L, fermentation time 75 h, fermentable sugar consumption 99% ethanol yield 0.35 g/g sugars consumed, and volumetric ethanol productivity 4 g/L day. (c) 1992 John Wiley & Sons, Inc.     

The kinetics and physiology of stipitatic acid and gluconate production by carbon sufficient cultures of Penicillium stipitatum growing in continuous culture

The yield from glucose of ammonia-grown carbon-limited continuous cultures of Penicillium stipitatum was ca. 20% higher than that of nitrate-grown cultures at all growth rates examined. However, the yield from oxygen was similar during growth on both nitrogen sources. Under phosphate limitation the specific rate of gluconic acid and stipitatic acid production increased with growth rate, but the former product accounted for virtually 100% of the excreted carbon. Stipitatic acid was not produced under nitrogen limitation, and glucose supplied to the culture in excess of that required for growth was virtually quantatively converted into gluconic acid. Productivities of 11.4 g gluconic acid/L/h were stably maintained in continuous culture. Under conditions of glucose excess the enzyme glucose oxidase was excreted into the culture. The specific activity of this extracellular enzyme increased when the input glucose concentration to the culture was progressively increased. The excretion of a protein under nitrogen limitation suggests that this enzyme plays an important role under these conditions. Indeed, it was demonstrated that nitrogen-limited cultures did not overmetabolize gluconate at either pH 6.5 or 3.5, although up to 29 g/L gluconate was present in the culture. The Y(gluconate) and YO(2) of C- and N-limited gluconate-grown cultures were similar indicating that the rapid conversion of glucose to gluconate probably affords a means of regulating carbon flow in this organism. Nitrogen-limited cultures of P. stipitatum overmetabolized glucose to a much greater extent than acetate, fructose, or gluconate.     

出芽短梗霉产聚苹果酸发酵条件的优化

【背景】出芽短梗霉可发酵葡萄糖生成聚苹果酸,但存在转化率和转化效率低等瓶颈,阻碍其实现商业化生产。【目的】通过优化发酵培养条件,提高出芽短梗霉的聚苹果酸产量、糖酸转化率和生产强度。【方法】采用单因素试验优化适宜出芽短梗霉BK-10菌株产生聚苹果酸的培养条件,通过Plackett-Burman法对培养基组分筛选显著性影响因素,并对其培养基中无机盐进行正交试验优化,最后进行5 L发酵罐验证。【结果】最优培养基配方和培养条件:100 g/L葡萄糖,1.5 g/L尿素,0.20 g/L KH_2PO_4,0.20 g/L ZnSO_4,0.05 g/L MgSO_4,0.75 g/L KCl,30 g/L CaCO_3,0.01%吐温-80,发酵温度26°C,250 mL摇瓶装液量50 mL。【结论】通过优化,聚苹果酸的糖酸转化率达到0.71 g/g,生产强度达到0.89 g/(L·h),较优化前分别提高了18.33%和71.15%,为发酵葡萄糖合成聚苹果酸进而生产L-苹果酸工艺的工业化生产奠定经济性基础。