Probiotication of tomato juice by lactic acid bacteria

This study was undertaken to determine the suitability of tomato juice as a raw material for production of probiotic juice by four lactic acid bacteria (Latobacillus acidophilus LA39, Lactobacillus plantarum C3, Lactobacillus casei A4, and Lactobacillus delbrueckii D7). Tomato juice was inoculated with a 24-h-old culture and incubated at 30 degrees C. Changes in pH, acidity, sugar content, and viable cell counts during fermentation under controlled conditions were measured. The lactic acid cultures reduced the pH to 4.1 or below and increased the acidity to 0.65% or higher, and the viable cell counts (CFU) reached nearly 1.0 to 9.0 x 10(9)/ml after 72 h fermentation. The viable cell counts of the four lactic acid bacteria in the fermented tomato juice ranged from 10(6) to 10(8) CFU/ml after 4 weeks of cold storage at 4 degrees C. Probiotic tomato juice could serve as a health beverage for vegetarians or consumers who are allergic to dairy products.     

Yoghurt fermentation at elevated temperatures by strains of Streptococcus thermophilus expressing a small heat-shock protein: application of a two-plasmid system for constructing food-grade strains of Streptococcus thermophilus

Streptococcus thermophilus S4 expressing a small heat-shock protein from the plasmid pSt04-encoded copy of shsp, is able to carry out fermentation at elevated temperature, i.e., at 50 degrees C. In yoghurt culture together with Lactobacillus delbrueckii subsp. bulgaricus, fermentation at elevated temperature results in a mild yoghurt with low post-acidification and improved stability of the starter bacteria during storage at 4 degrees C. To transfer pSt04 into commercial S. thermophilus yoghurt starter strains, a two-plasmid system was constructed. A helper plasmid providing a selectable antibiotic marker, but relying on the repA gene of pSt04, was transformed together with pSt04. After isolation of transformants, the helper plasmid was readily lost upon incubation of transformants in antibiotic-free medium, thus yielding food-grade strains carrying pSt04 only. Successful application of the system was demonstrated.     

植物乳杆菌P8产共轭亚油酸条件的优化

以植物乳杆菌P8菌株为研究对象,系统研究了发酵条件对共轭亚油酸生成的影响。分别研究了培养条件和培养基成分对共轭亚油酸产量的影响。通过单因素和正交试验表明:植物乳杆菌P8产共轭亚油酸的最佳条件为:培养时间为22 h、亚油酸(LA)添加量为0.9 mg/mL、接种量为1.5%、氮源采用2 g/L的胰蛋白胨,碳源采用3 g/L的葡萄糖。     

固态发酵降低上部低次烟叶中淀粉及蛋白质的含量

利用固态发酵的方法降低上部低次烟叶中淀粉和蛋白质的含量,并对发酵过程中的厌氧细菌和酵母的数量进行检测。采用单因素和正交试验对固态发酵的条件进行优化,结果表明:各因素对发酵上部低次烟叶影响显著性主次次序依次为发酵时间(C)、发酵温度(A)和发酵水分质量分数(B),固态发酵的最佳条件为A2B2C3,即温度45℃、水分质量分数50%、发酵时间9 d。在该发酵条件下,上部低次烟叶的淀粉降解率为20.41%,蛋白质降解率为12.35%。通过固态厌氧发酵的方法可取得较好的、短期内快速降解上部低次烟叶中淀粉和蛋白质含量的效果。     

Effect of Glucose and Low Oxygen Tension on l-Asparaginase Production by a Strain of Escherichia coli B

Cultural and nutritional requirements for maximum l-asparaginase synthesis were determined. Conventional aerobic and anaerobic fermentations were not satisfactory. The former yielded larger quantities of cells containing minimal amounts of l-asparaginase, whereas the latter supplied only minute amounts of bacteria that contained an abundance of enzyme. However, the combination of these classical methods, i.e., allowing growth to proceed aerobically until the mid to late exponential phase and then forcing the facultative microbial cells toward anaerobic metabolism by static incubation, produced 2.6 international units of enzyme per ml of fermentation broth when glucose was present. Enzyme synthesis was not induced by terminating aeration-agitation in the absence of glucose, nor was it induced in the presence of glucose when aeration was continued. Use of 0.2 m phosphate buffer resulted in a constant pH near the optimum value of 7.5 during l-asparaginase formation. Addition of 0.05% l-asparagine prior to induction was also beneficial, but other amino acids or their catabolites failed to increase biosynthesis of l-asparaginase.     

利用嗜盐菌Salinivibrio YS生产2,3-丁二醇和琥珀酸

以从新疆艾丁湖采集的土样中分离出的中度嗜盐菌Salinivibrio YS为研究对象,利用该菌在厌氧条件下生产2,3-丁二醇和琥珀酸,在单因素摇瓶实验基础上,确定影响产物积累的各因素及其相应条件,再利用正交试验确定这些参数的最佳水平,即温度33℃,起始pH为8.0,发酵过程pH为7.0,乙酸添加量为3 g/L,NaCl浓度为l0 g/L.利用优化条件进行3L体系的发酵放大实验,经过108 h的无氧发酵,2,3-丁二醇的产量可达35.05 g/L,而琥珀酸的含量则高达22.46 g/L,且其糖的总转化率高达约50％.首次利用嗜盐菌在厌氧条件下生产2,3-丁二醇和琥珀酸,拓展了嗜盐菌的应用,同时也为生产2,3-丁二醇和琥珀酸提供了新的思路.     

Effect of pH on the metabolism and fertility of turkey spermatozoa

Oxygen uptake during a 4-h incubation period at 37 degrees C, and the motility of the spermatozoa before and after incubation, increased significantly with increasing pH from 6.3 to 8.8. No interaction between buffer and pH was noticed. In a second series of experiments on the aerobic metabolism of turkey spermatozoa, the effect of the pHs 6.8, 7.3 and 7.8 was studied. Fructose was formed from glucose without regard to the pH of the medium. The glucose consumption, i.e. the glucose disappearance minus fructose formation, the lactic acid accumulation, and the oxidation of glucose and of other substances, were higher, although not always statistically, at pH 7.8 than at pH 6.8. The percentage of fertile eggs during the 3rd week of collection after insemination with fresh semen diluted in the pH 7.8 medium was significantly lower than that with semen diluted in the pH 6.8 or 7.3 media. After 4 h of storage at 15 degrees C, the decrease in the fertility of spermatozoa in the high pH medium was apparent from the 1st week of collection.     

酸碱调控污泥厌氧发酵实现乙酸累积及微生物种群变化

摘要：【目的】通过对污泥厌氧发酵pH调控,研究挥发性脂肪酸的累积、产酸微生物种群变化及产氢产乙酸菌群对乙酸产生的贡献。【方法】测定不同pH条件下污泥厌氧发酵过程中挥发性脂肪酸的累积;分别应用末端限制性片段长度多态性（T-RFLP）和荧光原位杂交技术（FISH）分析产酸系统中微生物种群结构的变化及产氢产乙酸菌的数量。【结果】 pH为10.0时,有机酸和乙酸的产率在发酵结束时分别达到652.6 mg COD/g-VS和322.4 mg COD/g-VS,显著高于其它pH条件。T-RFLP结果表明,pH值为12     

Microbial diversity of soil from two hot springs in Uttaranchal Himalaya

Soil samples collected from two hot springs, Soldhar and Ringigad, both located in the Garhwal region of Uttaranchal Himalaya were analysed for their physical, chemical and microbial components. The alkaline pH, total absence of carbon and nitrogen, and high temperature were features common to soil samples from both sites. The Soldhar samples contained higher amounts of Cu, Fe and Mn. Ringigad soil was devoid of Cu, but had much higher phosphate. While the optimum incubation temperature for isolating the maximum microbial counts from soil samples from the two sites was 50 degrees C, microbial growth in broth was also observed when incubated at 80 degrees C. Microscopic examination revealed three types of microbial populations, i.e., bacteria, yeast and filamentous organisms. The soil samples were found to be dominated by spore forming rods. Out of 58 aerobic isolates, 53 were gram positive bacilli. Gram positive anaerobic oval rods were also observed up to 60 degrees C. Soil dilution plates revealed the presence of antagonistic and phosphate solubilizing populations.     

Evaluation of methods for storage of marine macroorganisms with optimal recovery of bacteria

Marine macroorganisms are a potential source for new bioactive substances. In many cases marine microorganisms--especially bacteria--associated with these macroorganisms are actually producing the bioactive substances. One often is not able to immediately isolate microorganisms from collected macroorganismic materials; we therefore evaluated different methods for storage of such material, e.g., on board research vessels. These methods were the following: storage of macerates in sintered glass beads and 5% trehalose at -20 degrees C (SGT method); storage of sections in 5% dimethyl sulfoxide at -70 degrees C (SD method); storage of macerates at -20 degrees C using the commercial ROTI-STORE system (RS method); storage of macerates at -20 degrees C in 50% glycerol (GC method); and storage of macerates covered by mineral oil at 4 degrees C (MO method). The SGT and SD methods resulted in numbers of and especially diversity of recoverable bacteria that were higher than for the other methods. Data for the RS method indicated its potential usefulness, too. The MO method resulted in growth during storage, thereby enriching a few selected microorganisms; the GC method resulted in a survival and diversity of recovered bacteria that was too low.     

Production of probiotic cabbage juice by lactic acid bacteria

Research was undertaken to determine the suitability of cabbage as a raw material for production of probiotic cabbage juice by lactic acid bacteria (Lactobacillus plantarum C3, Lactobacillus casei A4, and Lactobacillus delbrueckii D7). Cabbage juice was inoculated with a 24-h-old lactic culture and incubated at 30 degrees C. Changes in pH, acidity, sugar content, and viable cell counts during fermentation under controlled conditions were monitored. L. casei, L. delbrueckii, and L. plantarum grew well on cabbage juice and reached nearly 10x10(8) CFU/mL after 48 h of fermentation at 30 degrees C. L. casei, however, produced a smaller amount of titratable acidity expressed as lactic acid than L. delbrueckii or L. plantarum. After 4 weeks of cold storage at 4 degrees C, the viable cell counts of L. plantarum and L. delbrueckii were still 4.1x10(7) and 4.5x10(5) mL(-1), respectively. L. casei did not survive the low pH and high acidity conditions in fermented cabbage juice and lost cell viability completely after 2 weeks of cold storage at 4 degrees C. Fermented cabbage juice could serve as a healthy beverage for vegetarians and lactose-allergic consumers.     

Production of 2,3-Butylene Glycol from Citrus Wastes. II. The Bacillus polymyxa Fermentation

The conditions required for production of levo 2,3-butylene glycol by Bacillus polymyxa from citrus molasses were studied. Starter cultures required acclimatization to the substrate prior to inoculation of the fermentation medium. Maximal production of butylene glycol with minimal residual sugar was obtained with a medium consisting of molasses, diluted to 20 degrees Brix, and 0.4% urea. Optimal environmental conditions included aeration at 0.11 volumes of air per volume of medium per minute, maintenance of pH at 6.0 to 6.2, a fermentation temperature of 30 C, and a stirring rate of 420 rev/min. The concentration of butylene glycol obtained in the fermentation beer ranged from 2.3 to 4.4%. The optical rotation of the glycol ranged from [alpha](D) (23 degrees ) = -1.01 degrees to -10.45 degrees . The variation in rotation was probably due to the presence of contaminating substances in the distillate.     

Feasibility of hydrogen production in thermophilic mixed fermentation by natural anaerobes

The biological sludge from an animal wastewater treatment plant was treated to enrich hydrogen-producing mixed bacteria, and effects on hydrogen yield were investigated during anaerobic fermentation at 55 degrees C. Enrichment of hydrogen-producing bacteria was conducted at pH adjustment of inocula to 3 and 5 with and without additional heat treatment (NHT and HT). The enriched mixed bacteria were cultivated at initial pHs of 5, 6, and 7 with synthetic organic wastewater containing different levels of nitrogen (2.0 and 0.8 g/l as total nitrogen) under static batch conditions. The main effects of heat treatment and enrichment pH were significant on hydrogen production. There was no significant effect of different nitrogen concentrations on hydrogen production. The methane-free biogas contained hydrogen levels of up to 64% for a fermentative condition that showed maximum hydrogen evolution (at culture pH 5 after enrichment at pH 5 with HT). The dominating intermediate metabolites were acetate, n-butyrate, and ethanol. Yields of produced hydrogen were significantly dependent upon levels of n-butyrate.     

高效产氢菌株Enterococcus sp. LG1的分离及产氢特性

采用Hungate厌氧培养技术分别从厌氧污泥、好氧污泥及河底泥中分离出12株厌氧产氢细菌,并对其中的Enterococcus sp.LG1(注册号:EU258743)进行了研究.结果表明,该株细菌为专性厌氧菌,经革兰氏染色结果为阴性.通过16S rDNA碱基测序和比对证实,该菌株是目前尚未报道过的1个新菌种,初步确定其细菌学上的分类地位.同时,以灭菌预处理的污泥为底物培养基,对该菌的产氢能力及污泥发酵过程中底物性质变化(SCOD、可溶性蛋白质、总糖和pH值等)进行了探讨.实验结果显示,产氢茵Enterococcus sp.LG1的发酵过程中只有H2和CO2产生,无CH4产生.产气量最高为36.48 mL/g TCOD,氢气含量高达73.5%,为已报道文献中以污泥为底物发酵制氢中之最高.根据污泥发酵产物分析得知,该菌的发酵类行为典型的丁酸型发酵.     

Occurrence of Lactic Acid Bacteria During the Different Stages of Vinification and Conservation of Wines

We showed that the growth of lactic acid bacteria during alcoholic fermentation depends on the composition of the must. We illustrated how the addition of sulfur dioxide to the must before fermentation and the temperature of storage both affect the growth of these bacteria in the wine. Whereas species of Lactobacillus and Leuconostoc mesenteroides were isolated from grapes and must, Leuconostoc oenos was the only species isolated after alcoholic fermentation. This organism was responsible for the malolactic fermentation. Isolates of this species varied in their ability to ferment pentoses and hexoses. The survival of Leuconostoc oenos in wines after malolactic fermentation depended on wine pH, alcohol concentration, SO₂ concentration, and temperature of storage.     

pH, pCO2 and NADP changes during aerobic and anaerobic incubation of the brain cortex of young and adult rats

Wistar rats of both sexes, aged 5 and 90-110 days, bred in the author's department, were used for experiments in which pH, pCO2 and NADP changes induced by incubating brain cortex homogenate (30 min at 37 degrees C) under aerobic and anaerobic conditions were studied. The medium was S?rensen's buffer solution, with succinate as substrate. NADP was assayed by determining glucose-6-phosphate dehydrogenase activity, which is NADP-dependent. The pH and pCO2 were determined with an ABL-2 radiometer (Denmark). The NADP extinction curves showed that the adult rat cortex, with or without substrate, always contained significantly less NADP under anaerobic conditions (the amount of its reduced form increased). In 5-day-old rats, the course of changes in the extinction curves was completely analogous to that for adult rats if the tissue was incubated without substrate; in the presence of substrate, the amount of the oxidized form, i.e. of NADP, decreased and there was no difference between the course of extinction changes under anaerobic and aerobic conditions. Similarly, the pH fell significantly less in 5-day-old rats during anaerobic incubation than in adult rats and was practically no different from the pH changes found during aerobic incubation. In addition, we found that the increase in pCO2 during anaerobic incubation of the brain cortex of 5-day-old rats was very small (also compared with aerobic conditions) whereas the increase in pCO2 under aerobic and anaerobic conditions in adult rats was the same.(ABSTRACT TRUNCATED AT 250 WORDS)     

Effect of Dissolved Oxygen, Temperature, Initial Cell Count, and Sugar Concentration on the Viability of Saccharomyces cerevisiae in Rapid Fermentations

By using 7 x 10(8) cells of Saccharomyces cerevisiae per ml with which 25 degrees Brix honey solutions were fermented to 9.5% (wt/vol; 12% vol/vol) ethanol in 2.5 to 3 h at 30 C, i.e., rapid fermentation, the death rate was found to be high, with only 2.1% of the yeast cells surviving at the end of 3 h under anaerobic conditions. As the dissolved oxygen in the medium was increased from 0 to 13 to 20 to 100% in rapid fermentations at 30 C, there was a progressive increase in the percentage of cells surviving. The ethanol production rate and total were not seriously affected by a dissolved oxygen concentration of 13%, but fermentation was retarded by 20% dissolved oxygen and still further decreased as the dissolved oxygen content reached 100%. When the fermentation temperature was decreased to 15 C (at 13% dissolved oxygen), the rate of fermentation decreased, and the fermentation time to 9.5% ethanol (wt/vol) increased to 6 h. It was found that the higher the temperature between 15 and 30 C, the greater the rate of death as initial cell counts were increased from 1.1 x 10(7) to 7.8 x 10(8) cells per ml. At the lowest level of inoculum, 1.1 x 10(7) cells per ml, there was actual multiplication, even at 30 C; however, the fermentation was no longer rapid. The addition of 15% sugar, initially followed after an hour by the remaining 10%, or addition of the sugar in increments of 2.5 or 5% yielded a better survival rate of yeast cells than when the fermentation was initiated with 25% sugar.     

Characterization and identification of Pediococcus species isolated from forage crops and their application for silage preparation.

Pediococcus species isolated from forage crops were characterized, and their application to silage preparation was studied. Most isolates were distributed on forage crops at low frequency. These isolates could be divided into three (A, B, and C) groups by their sugar fermentation patterns. Strains LA 3, LA 35, and LS 5 are representative isolates from groups A, B, and C, respectively. Strains LA 3 and LA 35 had intragroup DNA homology values above 93.6%, showing that they belong to the species Pediococcus acidilactici. Strain LS 5 belonged to Pediococcus pentosaceus on the basis of DNA-DNA relatedness. All three of these strains and strain SL 1 (Lactobacillus casei, isolated from a commercial inoculant) were used as additives to alfalfa and Italian ryegrass silage preparation at two temperatures (25 and 48 degrees C). When stored at 25 degrees C, all of the inoculated silages were well preserved and exhibited significantly (P < 0.05) reduced fermentation losses compared to that of their control in alfalfa and Italian ryegrass silages. When stored at 48 degrees C, silages inoculated with strains LA 3 and LA 35 were also well preserved, with a significantly (P < 0.05) lower pH, butyric acid and ammonia-nitrogen content, gas production, and dry matter loss and significantly (P < 0.05) higher lactate content than the control, but silages inoculated with LS 5 and SL 1 were of poor quality. P. acidilactici LA 3 and LA 35 are considered suitable as potential silage inoculants.     

Immobilization of yeast cells containing beta-galactosidase

Cultural conditions optimum for beta-galactosidase production by Saccharomyces anamensis are pH 4.5, temperature 26 +/- 2 degrees C, and 30 h of incubation period. Addition of lactose at 24 h fermentation greatly increase the level of enzyme. Optimum pHl, temperature, pH stability, and thermostability of yeast beta-galactosidase are negligibly affected by immobilization. The K(m) values of enzyme in the native and immobilized cells are 102mM and 148mM, respectively. Glucose noncompetitively inhibits the enzyme activity. Addition of substances such as dithioerythritol, glutathione, and bovine serum albumin to the native cell during assay procedure and immobilized cell prior to immobilization have stimulatory effects on enzyme activity. Metal ions like Ca(2+), Mg(2+) enhance the beta-galactosidase activity for both intact and bound cells. Immobilized cells retain 68.6% of the beta-galactosidase activity of intact cells and there is no significant loss of activity on storage at 4 degrees C for 28 days.     

Survival of a Salmonella typhimurium poultry isolate in the presence of propionic acid under aerobic and anaerobic conditions

Propionic acid is commonly found as a fermentation product in the gastrointestinal tracts of food animals and has also been used to limit the microbial contaminants in animal feeds. Because propionic acid is known to have antibacterial activity, the propionic acid encountered by foodborne pathogens during their life cycles may play an important role in inhibiting the survival of the pathogens. The survival patterns of Salmonella typhimurium poultry isolate were determined both in aerobic and anaerobic tryptic soy broth (TSB; pH 5.0 or 7.0) containing various concentrations of propionic acid (0-200 mM). The levels of recovered cells were consistently greater at pH 7.0 compared to those at pH 5.0. For the first 4 days, the levels were significantly decreased by incubation under anaerobic conditions as compared to aerobic condition at pH 7.0 (P<0.05). However, there were fluctuations of cell populations with different patterns depending on both concentrations and growth conditions. To characterize the nature of the capability which allowed the cell multiplication following decreases in cell population during incubation at pH 7.0, the cells isolated from the outgrowth cultures were tested for survival in aerobic or anaerobic TSB (pH 5.0 or pH 7.0) containing propionic acid (50 mM). The outgrowth isolates did not show significant differences in the level of recovered cells in the presence of propionic acid when compared to the wild type strain (P>0.05), suggesting that the cells in the outgrowth cultures did not harbour mutation(s) conferring increased resistance to propionic acid. In addition, the level of recovered cells of isogenic rpoS mutant strain of S. typhimurium was not significantly different from that of the wild type strain in the same assay conditions (P<0.05). The results of this study show that the bactericidal activity of propionic acid on S. typhimurium can be affected by environmental conditions such as acidic pH levels and anaerobiosis in food materials and gastrointestinal tracts. However, S. typhimurium is also able to multiply in the presence of sublethal concentrations of propionic acid at neutral pH during prolonged incubation under both aerobic and anaerobic conditions.