Use of ionic liquids as media for the biocatalytic preparation of flavonoid derivatives with antioxidant potency

Biocatalytic preparation of acylated derivatives of flavonoid glycosides was performed using various immobilized lipases in two different ionic liquids, namely 1-butyl-3-methylimidazolium tetrafluoroborate ([bmim]BF(4)) and 1-butyl-3-methylimidazolium hexafluorophosphate ([bmim]PF(6)). The influence of various reaction parameters on the performance and the regioselectivity of the biocatalytic process was pointed out, using as model reaction the acylation of naringin and rutin with vinyl butyrate, catalyzed by immobilized Candida antarctica lipase at 60 degrees C. The biocatalytic modification of flavonoids strongly depended on the ionic liquid used, the molar ratio of substrates, as well as the acyl donor chain length. The highest conversion yield (about 65% after 96 h of incubation) was obtained with short chain acyl donors (up to four carbon atoms), at a relatively high molar ratio (10-15) in both ionic liquids used. The amount of monoacylated flavonoid derivatives produced in a single-step biocatalytic process in [bmim]BF(4) was up to 5.5 g/L for monoacylated rutin and 30 g/L for monoacylated naringin. The regioselectivity of the process was higher in [bmim]BF(4) than in [bmim]PF(6) or organic solvents. Reaction rates observed in ionic liquids were up to four times higher than those reported for organic media. The acylation of sugar moiety of rutin with various acyl donors affected its antioxidant potential towards both isolated LDL and total serum model in vitro. A significant increase of antioxidant activity was observed for rutin-4'-O-oleate.     

Obtaining high transesterification activity for subtilisin in ionic liquids

It is known that subtilisin shows poor transesterification activity in ionic liquids (ILs). The present work, taking subtilisin as the system, explores approaches for biocatalyst preparations, which are capable of yielding higher/adequate transesterification activity in these solvents. Of all the approaches tried, enzyme precipitated and rinsed with n-propanol (EPRP) gave the best results (about 10,000 times increase in initial rates in 1-butyl-3-methylimidazolium hexafluorophosphate ([Bmim][PF(6)]) over what is obtained with pH tuned lyophilized powders). In case of water soluble ionic liquid 1-butyl-3-methylimidazolium tetrafluoroborate ([Bmim][BF(4)]), pH tuned lyophilized subtilisin did not show any transesterification activity. EPRP, however, gave an initial rate (for transesterification) of 2.78 mmol mg(-1) h(-1).     

Ionic liquid-based aqueous two-phase system, a sample pretreatment procedure prior to high-performance liquid chromatography of opium alkaloids

An ionic liquid, 1-butyl-3-methylimidazolium chloride ([C4 mim]Cl)/salt aqueous two-phase systems (ATPS) was presented as a simple, rapid and effective sample pretreatment technique coupled with high-performance liquid chromatography (HPLC) for analysis of the major opium alkaloids in Pericarpium papaveris. To find optimal conditions, the partition behaviors of codeine and papaverine in ionic liquid/salt aqueous two-phase systems were investigated. Various factors were considered systematically, and the results indicated that both the pH value and the salting-out ability of salt had great influence on phase separation. The recoveries of codeine and papaverine were 90.0-100.2% and 99.3-102.0%, respectively, from aqueous samples of P. papaveris by the proposed method.     

Penicillin acylase catalysis in the presence of ionic liquids

Several ionic liquids were used as reaction media for penicillin G acylase catalysis. In all the assayed ionic liquids, [bmim]PF6 proved good media for PGA-catalyzed hydrolysis. A novel [bmim]PF6/water two-phase system is provided for 6-aminopenicillanic acid (APA) production, which will be more benefical than aquous batch systems used widely in industrial production of APA.     

Alpha-chymotrypsin catalysis in imidazolium-based ionic liquids

The transesterification reaction of N-acetyl-L-phenylalanine ethyl ester with 1-propanol catalyzed by alpha-chymotrypsin was examined in the ionic liquids 1-butyl-3-methylimidazolium hexafluorophosphate ([bmim][PF(6)]) and 1-octyl-3-methylimidazolium hexafluorophosphate ([omim][PF(6)]), and in combination with supercritical carbon dioxide (SC-CO(2)). The activity of alpha-chymotrypsin was studied to determine whether trends in solvent polarity, water activity, and enzyme support properties, observed with this enzyme in conventional organic solvents, hold for the novel environment provided by ionic liquids. alpha-Chymotrypsin freeze-dried with K(2)HPO(4), KCl, or poly(ethylene glycol) demonstrated no activity in [bmim][PF(6)] or [omim][PF(6)] at very low water concentrations, but moderate transesterification rates were observed with the ionic liquids containing 0.25% water (v/v) and higher. However, the physical complexation of the enzyme with poly(ethylene glycol) or KCl did not substantially stimulate activity in the ionic liquids, unlike that observed in hexane or isooctane. Activities were considerably higher in [omim][PF(6)] than [bmim][PF(6)]. Added water was not necessary for enzyme activity when ionic liquids were combined with SC-CO(2). These results indicate that [bmim][PF(6)] and [omim][PF(6)] provide a relatively polar environment, which can be modified with nonpolar SC-CO(2) to optimize enzyme activity.     

A paradoxical method for NAD(+)/NADH accumulation on an electrode surface using a hydrophobic ionic liquid

In this communication, we describe a novel and facile method for the immobilization of NAD(+)/NADH on an electrode surface using a hydrophobic ionic liquid, 1-butyl-3-methylimidazolium bis(trifluoromethanesulfonyl)imide ([C4mim][Tf(2)N]). By taking advantage of the insolubility of NAD(+)/NADH in hydrophobic ionic liquids, it is expected that NAD(+)/NADH can be retained on the electrode's surface. Alcohol dehydrogenase (ADH) and NAD(+)/NADH were immobilized with a gelatin hydrogel on an electrode that was modified with an electropolymerized ruthenium complex containing 5-amino-1,10-phenanthroline (pAPRu) as a mediator for NADH oxidation. The (ADH, NAD(+))/pAPRu-immobilized electrode exhibited the electrocatalytic oxidation of ethanol in [C4mim][Tf(2)N]. The obtained catalytic current in [C4mim][Tf(2)N] was comparable to that in buffer solution containing NAD(+). It was confirmed by UV-vis spectroscopy that NAD(+) did not dissolve in the [C4mim][Tf(2)N] and was retained on the electrode's surface. Furthermore, we succeeded in constructing an ethanol/O(2) biofuel cell comprised of an (ADH, NAD(+))/pAPRu anode and a bilirubin oxidase cathode using [C4mim][Tf(2)N] as an electrolyte.     

Properties of an ionic liquid-tolerant <Emphasis Type="Italic">Bacillus</Emphasis><Emphasis Type="Italic">amyloliquefaciens</Emphasis> CMW1 and its extracellular protease

An ionic liquid-tolerant bacterium, Bacillus amyloliquefaciens CMW1, was isolated from a Japanese fermented soybean paste. Strain CMW1 grew in the presence of 10 % (v/v) 1-butyl-3-methylimidazolium chloride ([BMIM]Cl), a commonly used ionic liquid. Additionally, strain CMW1 grew adequately in the presence of the hydrophilic ionic liquids 10 % (v/v) 1-ethyl-3-methylimidazolium trifluoromethanesulfonate ([EMIM]CF₃SO₃) or 2.5 % (v/v) 1-butyl-3-methylimidazolium trifluoromethanesulfonate ([BMIM]CF₃SO₃). Strain CMW1 produced an extracellular protease (BapIL) in the culture medium. BapIL was stable in the presence of 80 % (v/v) ionic liquids, [EMIM]CF₃SO₃, [BMIM]Cl, [BMIM]CF₃SO₃, 1-butyl-3-methylimidazolium tetrafluoroborate, 1-butyl-3-methylimidazolium hexafluorophosphate, and 1-butyl-3-methylimidazolium bis(trifluoromethylsulfonyl)imide, and functioned in 10 % (v/v) these ionic liquids. BapIL was stable at pH 4.0–12.6 or in 4004 mM NaCl solution, and exhibited activity in the presence of 50 % (v/v) hydrophilic or hydrophobic organic solvents. BapIL was completely inhibited by 1 mM PMSF and partially by 5 mM EDTA. BapIL belongs to the true subtilisins according to analysis of the deduced amino acid sequence. We showed that BapIL from the ionic liquid-tolerant B. amyloliquefaciens CMW1 exhibited tolerance to ionic liquid and halo, alkaline, and organic solvents.     

Feruloyl esterase-catalysed synthesis of glycerol sinapate using ionic liquids mixtures

The ability of a feruloyl esterase (AnFaeA), either in free or immobilised (cross-linked enzyme aggregates) form, to catalyse the esterification of glycerol, a major by-product of the biodiesel industry, with sinapic acid was studied in four hexafluorophosphate anion-containing ionic liquids: ([Bmim][PF(6)], [Omim][PF(6)], [C(2)OHmim][PF(6)] and [C(5)O(2)mim][PF(6)]). Such ionic liquids are considered 'green' reaction systems. The synthetic reaction was optimised in [C(2)OHmim][PF(6)] and the highest conversion yield was 72.5+/-2.1%, while, at the same reaction conditions in [C(5)O(2)mim] [PF(6)], a similar conversion yield was obtained (76.7+/-1.5%). AnFaeA was active in its free and immobilised form, with the latter retaining a part of its synthetic activity after 5 consecutive 24h-period reaction cycles. Sinapic acid was esterified to one of the primary hydroxyl groups of glycerol and retained, after esterification, 63.1+/-0.3% and 89.5+/-1.1% of its antioxidant activity against low-density lipoprotein oxidation, when added at concentrations of 10 and 60muM, respectively, in the assay mixture.     

Sugarcane bagasse pretreatment using three imidazolium-based ionic liquids; mass balances and enzyme kinetics

ABSTRACT: BACKGROUND: Effective pretreatment is key to achieving high enzymatic saccharification efficiency in processing lignocellulosic biomass to fermentable sugars, biofuels and value-added products. Ionic liquids (ILs), still relatively new class of solvents, are attractive for biomass pretreatment because some demonstrate the rare ability to dissolve all components of lignocellulosic biomass including highly ordered (crystalline) cellulose. In the present study, three ILs, 1-butyl-3-methylimidazolium chloride ([C4mim]Cl), 1-ethyl-3-methylimidazolium chloride ([C2mim]Cl), 1-ethyl-3-methylimidazolium acetate ([C2mim]OAc) are used to dissolve/pretreat and fractionate sugarcane bagasse. In these IL-based pretreatments the biomass is completely or partially dissolved in ILs at temperatures greater than 130[DEGREE SIGN]C and then precipitated by the addition of an antisolvent to the IL biomass mixture. For the first time mass balances of IL-based pretreatments are reported. Such mass balances, along with kinetics data, can be used in process modelling and design. RESULTS: Lignin removals of 10% mass of lignin in bagasse with [C4mim]Cl, 50% mass with [C2mim]Cl and 60% mass with [C2mim]OAc, are achieved by limiting the amount of water added as antisolvent to 0.5 water:IL mass ratio thus minimising lignin precipitation. Enzyme saccharification (24 h, 15FPU) yields (% cellulose mass in starting bagasse) from the recovered solids rank as: [C2mim]OAc(83%)>[C2mim]Cl(53%) = [C4mim]Cl(53%). Composition of [C2mim]OAc-treated solids such as low lignin, low acetyl group content and preservation of arabinosyl groups are characteristic of aqueous alkali pretreatments while those of chloride IL-treated solids resemble aqueous acid pretreatments. All ILs are fully recovered after use (100% mass as determined by ion chromatography). CONCLUSIONS: In all three ILs regulated addition of water as an antisolvent effected a polysaccharide enriched precipitate since some of the lignin remained dissolved in the aqueous IL solution. Of the three IL studied [C2mim]OAc gave the best saccharification yield, material recovery and delignification. The effects of [C2mim]OAc pretreatment resemble those of aqueous alkali pretreatments while those of [C2mim]Cl and [C4mim]Cl resemble aqueous acid pretreatments. The use of imidazolium IL solvents with shorter alkyl chains results in accelerated dissolution, pretreatment and degradation.     

Homogeneous sulfation of bagasse cellulose in an ionic liquid and anticoagulation activity

Homogeneous sulfation of bagasse cellulose (BC) with chlorosulfonic acid-dimethylformamide was accomplished in an ionic liquid 1-butyl-3-methylimidazolium chloride ([C(4)mim]Cl). The BCS products from the sulfation had degrees of substitution (DS) in the range of 0.52-2.95 and a simultaneous substitution pattern at C-6, C-2 and C-3 positions. The sulfated BCS attained significant anticoagulation activity, causing a dose-dependent prolongation of coagulation time and inhibition of FIIa and FXa activities in human plasma. The anticoagulation activity of BCS showed a positive correlation with DS, and some of the activity indexes exceeded those of heparin.     

Tyrosinase activity in ionic liquids

Activity of mushroom tyrosinase was studied in three ionic liquids, 1-butyl-3-methylimidazolium hexafluorophosphate ([BMIm][PF₆]), 1-butyl-3-methylimidazolium tetrafluoroborate ([BMIm][BF₄]) and 1-butyl-3-methylimidazolium methylsulfate ([BMIm][MeSO₄]), and was compared to that in chloroform. Kinetic parameters of the enzyme were determined and the results indicate that the enzyme in ionic liquids basically follows the same catalytic mechanism as in water, and that the ionic liquids may affect the enzyme activity by direct interacting with the enzyme and thus hindering the E–S binding due to their high hydrophilicity and polarity.     

Effects of 1-octyl-3-methylimidazolium bromide on the antioxidant system of Lemna minor

Ionic liquids have gained more attention due to their excellent properties in many different scientific fields. However, previous researches indicated that ionic liquids have adverse effects on organisms. The objective of this study was to evaluate the effects of 1-octyl-3-methylimidazolium bromide ([C(8)mim]Br) on the aquatic plant duckweed (Lemna minor) by exposure of the plant to 0.25 to 2 mg L(-1) of [C(8)mim]Br for 28 days. Exposure to [C(8)mim]Br significantly decreased the photosynthetic pigment contents at 21 and 28 days. The activities of superoxide dismutase and catalase and the total antioxidant capacity level increased at 7 days of exposure and decreased at the termination of exposure. In contrast, the H(2)O(2) content and peroxidase activity in all treatments increased during the period of exposure. Furthermore, marked increase of malondialdehyde content occurred in duckweed after 21 to 28 days of exposure. In addition, reactive oxygen species (ROS) scavenger dimethyl thiourea prevents duckweed from oxidative damage caused by [C(8)mim]Br. These results suggest that ROS might be involved in the mechanism of ionic liquid-induced toxicity in L. minor.     

Study of E. coli penicillin amidase. The pH dependence of the equilibrium constant of the enzymatic hydrolysis of benzylpenicillin]

The equilibrium constant for penicillin amidase-catalyzed hydrolysis of benzylpenicillin(Keg =3.00 +/- 0.24 x 10(-3) M at pH 5.0) and the ionization constants for phenylacetic acid (PAA) and the amino groups of 6-aminopenicillanic acid (6-APA) were determined (4.20 and 4.60 under conditions of the kinetic experiments respectively). The experimental data at pH 6.0 satisfactorily correlated with the theoretical pH-dependence for Keg constructed according to the hypothesis that benzylpenicillin synthesis has a thermodynamic optimum at pH 4.4 equal to a half-sum of the pK values for the carboxylic and amino groups of the PAA and 6-APA respectively.     

Production of 5-hydroxymethylfurfural in ionic liquids under high fructose concentration conditions

Acid-promoted, selective production of 5-hydroxymethylfurfural (HMF) under high fructose concentration conditions was achieved in ionic liquids (ILs) at 80 °C. A HMF yield up to 97% was obtained in 8 min using 1-butyl-3-methylimidazolium chloride ([C₄mim]Cl) catalyzed with 9 mol % hydrochloric acid. More significantly, an HMF yield of 51% was observed when fructose was loaded at a high concentration of 67 wt % in [C₄mim]Cl. Water content below 15.4% in the system had little effect on HMF yield, whereas a higher water content was detrimental to both reaction rate and HMF yield. In situ NMR analysis suggested that the transformation of fructose to HMF was a highly selective reaction that proceeded through the cyclic fructofuranosyl intermediate pathway. This work increased our capacity to produce HMF, and should be valuable to facilitate cost-efficient conversion of biomass into biofuels and bio-based products.     

Enzymatic selective acylation of glycosides in ionic liquids: significantly enhanced reactivity and regioselectivity

The enzymatic selective acylations of carbohydrates in ionic liquids were explored in both organic solvents and ionic liquids to see any significant differences in terms of reactivity and regioselectivity between two different classes of reaction media. Monoprotected glycosides (methyl-6-O-trityl-glucosides and galactosides) were chosen as the substrates with Candida rugosa lipase as an acylation enzyme. Two organic solvents, THF and chloroform, and two ionic liquids, [BMIM]⁺PF₆⁻ ([BMIM]⁺ = 1-butyl-3-methylimidazolium) and [MOEMIM]⁺PF₆⁻ ([MOEMIM]⁺ = 1-methoxyethyl-3-methylimidazolium), were employed as reaction media. The enzymatic reactions were performed in the presence of vinyl acetate at room temperature. It was observed that the reactions in ionic liquids took place more rapidly and more selectively than those in conventional organic solvents.     

含离子液体体系中固定化细胞转化甘草酸生成单葡萄糖醛酸基甘草次酸

研究疏水性离子液体1-丁基-3-甲基咪唑六氟磷酸盐([BMIM]PF6)与醋酸-醋酸钠缓冲液两相体系中,固定化产紫青霉Penicillium purpurogenum Li-3细胞转化甘草酸(GL)生成单葡萄糖醛酸基甘草次酸(GAMG)的反应,并与缓冲液单相体系作为对照.确定了在[BMIM]PF6/缓冲液两相体系中,最适离子液体加入比例、缓冲液pH、反应温度、底物浓度分别为10%、5.8、35℃和6.0mmol/L,在此条件下反应58h,甘草酸转化率为87.03%,比缓冲液单相体系提高了15.02%.离子液体循环使用8次后,回收利用率维持在85.28%.主产物GAMG和副产物甘草次酸(GA)在两相体系中得到有效分离,为后续产物分离带来便利.     

Partitioning of acidic, basic and neutral amino acids into imidazolium-based ionic liquids

In this paper, partitioning behaviors of typical neutral (Alanine), acidic (Glutamic acid) and basic (Lysine) amino acids into imidazolium-based ionic liquids [C₄mim][PF₆], [C₆mim][PF₆], [C₈mim][PF₆], [C₆mim][BF₄] and [C₈mim][BF₄] as extracting solvents were examined. [C₆mim][BF₄] showed the best efficiency for partitioning of amino acids. The partition coefficients of amino acids in ionic liquids were found to depend strongly on pH of the aqueous solution, amino acid and ionic liquid chemical structures. Different chemical forms of amino acids in aqueous solutions were pH dependent, so the pH value of the aqueous phase was a determining factor for extraction of amino acids into ionic liquid phase. Both water content of ionic liquids and charge densities of their anionic and cationic parts were important factors for partitioning of cationic and anionic forms of amino acids into ionic liquid phase. Extracted amino acids were back extracted into phosphate buffer solutions adjusted on appropriate pH values. The results showed that ionic liquids could be used as suitable modifiers on the stationary phase of an HPLC column for efficient separation of acidic, basic, and neutral amino acids.     

固定化青霉素酰化酶在光-pH敏感可回用两水相中裂解青霉素G为6-APA

两水相体系在发展中存在的关键问题是相体系回收困难.由于生产成本及降低污染的原因, 用过的相体系需要回收和重复使用.用环境敏感型溶解可逆聚合物形成可回用两水相体系是当前是为可行的回收方法。本文在光敏感可回用高聚物PNBC与pH敏感型可回用高聚物PADB形成的两水相体系中进行固定化青霉素酰化酶的相转移催化青霉素G产生6-APA的反应。在这个两水相体系中,通过优化,在1% NaCl 存在下,６－ＡＰＡ的分配系数可达5.78。催化动力学显示,达平衡的时间近7h,反应最高得率约85.3%（pH 7.8, 20℃）。较相近条件下的单水相反应得率提高近20%。在反应过程中,通过底物及产物的分配系数检测,发现底物分配系数变化不大,而产物6-APA及苯乙酸的分配系数发生很大变化,从而引起产物的得率变化。在两水相中,底物及产物主要分配在上相,固定化酶分配在下相,底物青霉素G进入下相经酶催化产生的6-APA及苯乙酸又转入上相,从而解除了青霉素酰化酶催化反应的底物及产物抑制作用,达到提高产物得率的效果。此外,采用固定化酶较固定化细胞效率高,占用下相体积小,较游离酶稳定性高,且完全单侧分配在下相。因此,在两水相中进行固定化酶的催化反应具有明显的优越性。形成两水相的高聚物PNBC通过488 nm 的激光照射或经滤光的450nm 光源照射得到回收;pH敏感型成相聚合物PADB可通等电点 4.1沉淀可实现循环利用,高聚物的回收率在95%-98%之间,按此回收率计算,聚合物可使用60次以上。     

Room-temperature ionic liquids as replacements for organic solvents in multiphase bioprocess operations

Organic solvents are widely used in a range of multiphase bioprocess operations including the liquid-liquid extraction of antibiotics and two-phase biotransformation reactions. There are, however, considerable problems associated with the safe handling of these solvents which relate to their toxic and flammable nature. In this work we have shown for the first time that room-temperature ionic liquids, such as 1-butyl-3-methylimi- dazolium hexafluorophosphate, [bmim][PF(6)], can be successfully used in place of conventional solvents for the liquid-liquid extraction of erythromycin-A and for the Rhodococcus R312 catalyzed biotransformation of 1, 3-dicyanobenzene (1,3-DCB) in a liquid-liquid, two-phase system. Extraction of erythromycin with either butyl acetate or [bmim][PF(6)] showed that values of the equilibrium partition coefficient, K, up to 20-25 could be obtained for both extractants. The variation of K with the extraction pH was also similar in the pH range 5-9 though differed significantly at higher pH values. Biotransformation of 1,3-DCB in both water-toluene and water-[bmim][PF(6)] systems showed similar profiles for the conversion of 1,3-DCB initially to 3-cyanobenzamide and then 3-cyanobenzoic acid. The initial rate of 3-cyanobenzamide production in the water-[bmim][PF(6)] system was somewhat lower, however, due to the reduced rate of 1,3-DCB mass transfer from the more viscous [bmim] [PF(6)] phase. It was also shown that the specific activity of the biocatalyst in the water-[bmim] [PF(6)] system was almost an order of magnitude greater than in the water-toluene system which suggests that the rate of 3-cyanobenzamide production was limited by substrate mass transfer rather than the activity of the biocatalyst.     

Cytochrome c dissolved in 1-allyl-3-methylimidazolium chloride type ionic liquid undergoes a quasi-reversible redox reaction up to 140°C

Solubility of cytochrome c, a typical heme protein, in a various ionic liquids has been analyzed. The solubility has been discussed with polarity parameters of the ionic liquids. Both hydrogen bond basicity and dipolarity/polarizability of the ionic liquids were confirmed to be influential factors to control the solubilization of cytochrome c. Polar ionic liquids such as 1-butyl-3-methylimidazolium chloride and 1-allyl-3-methylimidazolium chloride solubilized cytochrome c at 80°C, and the dissolved cytochrome c was found to keep its redox activity in these ionic liquids. The redox response of the dissolved cytochrome c was detected in 1-allyl-3-methylimidazolium chloride up to 140°C.