Stress-related differential expression of multiple beta-carotene ketolase genes in the unicellular green alga Haematococcus pluvialis

The unicellular green alga Haematococcus pluvialis is used as a biological production system for astaxanthin. It accumulates large amounts of this commercially interesting ketocarotenoid under a variety of environmental stresses. Here we report the identification and expression of three different beta-carotene ketolase genes (bkt) that are involved in the biosynthesis of astaxanthin in a single strain of the alga. Bkt1 and bkt2 proved to be the crtO and bkt previously isolated from two different strains of H. pluvialis. Bkt3 is a novel third gene, which shared 95% identical nucleotide sequence with bkt2. Nitrogen deficiency alone could not induce the alga cells to produce astaxanthin in 3 days even though it enhances the expression of the bkt genes to three times of that in normal growing cells within 16 h. High light irradiation (125 micromol m(-2)s(-1)) or 45 mM sodium acetate greatly increased the expression of bkt genes to 18 or 52 times of that in normal growing cells, resulting in an accumulation of substantial astaxanthin (about 6 mg g(-1) dry biomass) in 3 days. It is suggested that the existence of the multiple bkt genes and their strong up-regulation by different stress conditions is one of the reasons that H. pluvialis accumulates large amounts of astaxanthin in an instant response to stress environments.     

Changes in gene expression and biochemical composition of Haematococcus pluvialis grown under different light colors

Journal of Applied Phycology - The present study evaluated the effect of blue, red, and white light on the expression of four carotenogenic genes (psy, lyc, bkt, and crtr-r); one gene related to...     

雨生红球藻虾青素合成研究进展

虾青素是一种重要的次级类胡萝卜素,具有高活性的抗氧化功能,广泛应用于食品保健、医药、水产养殖等领域。雨生红球藻是一种在胁迫条件下能够大量积累虾青素的微藻。文中回顾了雨生红球藻虾青素的生物合成研究的进展,包括虾青素生物合成的诱导与调控、虾青素合成与光合作用及脂类代谢的关系等研究现状。     

UV-B对雨生红球藻生长及虾青素积累的影响

以雨生红球藻(Haematococcus pluvialis)为材料,研究不同强度的UV-B对雨生红球藻生长、光合作用及虾青素积累的影响和其作用机理。设置5种紫外线强度,分别在正常光照培养条件下补充不同强度UVB(100—500 lx),标记为CK、U100、U200、U300、U400和U500六组。结果表明,经UV-B辐射后雨生红球藻细胞密度、PSⅡ最大光化学效率(F_v/F_m)、非光化学淬灭系数(NPQ)和叶绿素(Chl.a和Chl.b)含量等均呈现下降趋势,且与辐射强度相关。相反,虾青素含量在100—400 lx强度下随UV-B辐射强度的增加而升高。与对照相比,高强度UV-B辐射(U400)36h和72h后藻细胞虾青素含量分别提高了35.68%和56.23%,达到5.82和7.06 mg/L。qRT-PCR检测发现雨生红球藻虾青素合成关键酶基因(IPI、PSY、BCH和BKT)的表达量随紫外辐射强度和辐射时间的增加均有不同程度升高。UV-B辐射亦调控紫外光受体UVR8及其信号转导通路核心元件(COP1、SPA1、HYH和HY5)的基因表...     

Metabolic engineering of ketocarotenoids biosynthesis in the unicelullar microalga Chlamydomonas reinhardtii

Most higher plants and microalgae are not able to synthesize ketocarotenoids. In this study the unicellular chlorophyte Chlamydomonas reinhardtii has been genetically engineered with the beta-carotene ketolase cDNA from Haematococcus pluvialis, bkt1 (GeneBank accession no. X86782), involved in the synthesis of astaxanthin, to obtain a transgenic microalga able to synthesize ketocarotenoids. The expression of bkt1 was driven by the Chlamydomonas constitutive promoter of the rubisco small subunit (RbcS2) and the resulting protein was directed to the chloroplast by the Chlamydomonas transit peptide sequences of Rubisco small subunit (RbcS2) or Ferredoxin (Fd). In all transformants containing the bkt1 gene fused to the RbcS2 or the Fd transit peptides a new pigment with the typical ketocarotenoid spectrum was detected. Surprisingly this ketocarotenoid was not astaxanthin nor canthaxanthin. The ketocarotenoid was identified on the basis of its mass spectrum as 3,3'-dihydroxy-beta,varepsilon-carotene-4-one (4-keto-lutein) or its isomer ketozeaxanthin.     

Transformation of the green alga Haematococcus pluvialis with a phytoene desaturase for accelerated astaxanthin biosynthesis

Astaxanthin is a high-value carotenoid which is used as a pigmentation source in fish aquaculture. Additionally, a beneficial role of astaxanthin as a food supplement for humans has been suggested. The unicellular alga Haematococcus pluvialis is a suitable biological source for astaxanthin production. In the context of the strong biotechnological relevance of H. pluvialis, we developed a genetic transformation protocol for metabolic engineering of this green alga. First, the gene coding for the carotenoid biosynthesis enzyme phytoene desaturase was isolated from H. pluvialis and modified by site-directed mutagenesis, changing the leucine codon at position 504 to an arginine codon. In an in vitro assay, the modified phytoene desaturase was still active in conversion of phytoene to zeta-carotene and exhibited 43-fold-higher resistance to the bleaching herbicide norflurazon. Upon biolistic transformation using the modified phytoene desaturase gene as a reporter and selection with norflurazon, integration into the nuclear genome of H. pluvialis and phytoene desaturase gene and protein expression were demonstrated by Southern, Northern, and Western blotting, respectively, in 11 transformants. Some of the transformants had a higher carotenoid content in the green state, which correlated with increased nonphotochemical quenching. This measurement of chlorophyll fluorescence can be used as a screening procedure for stable transformants. Stress induction of astaxanthin biosynthesis by high light showed that there was accelerated accumulation of astaxanthin in one of the transformants compared to the accumulation in the wild type. Our results strongly indicate that the modified phytoene desaturase gene is a useful tool for genetic engineering of carotenoid biosynthesis in H. pluvialis.     

UV-B辐射对雨生红球藻光合特性和虾青素含量的影响及其响应

实验研究了不同强度的UV-B(280-320 nm)辐射对雨生红球藻(Haematococcus pluvialis)的光合活性、生物量、色素含量、活性氧(ROS)含量和抗氧化酶活性等的影响, 以探讨利用UV-B辐射诱导虾青素生物合成增强的可能性。结果发现, 经UV-B辐射处理后,雨生红球藻的光合活性降低、生物量增长被抑制。UV-B辐射对叶绿素影响不大, 但会改变细胞的类胡萝卜素和虾青素含量:0.1和0.3 W/m2强度的UV-B辐射使细胞中的这两种色素含量升高, 0.5 W/m2组的色素含量短暂升高后恢复到对照水平。中低强度的UV-B可以促进雨生红球藻单细胞虾青素含量的增加, 但由于其对细胞生长的抑制作用, 并不能使虾青素大量积累。随辐射时间延长, 细胞内ROS含量未明显增加,但抗氧化酶(过氧化氢酶和超氧化物歧化酶)活性下降, 雨生红球藻可能主要依靠虾青素来淬灭ROS。以上结果表明, UV-B辐射对雨生红球藻的主要生理生化过程有抑制作用, UV-B辐射既可以诱导虾青素的合成又会消耗一部分虾青素, 对虾青素含量的影响与其强度有关, 而利用虾青素来清除细胞内的ROS可能是雨生红球藻抵御这种不利环境条件的最重要的途径。       

Expression in Escherichia coli and properties of the carotene ketolase from Haematococcus pluvialis

Abstract High level expression of the functional β-carotene ketolase gene bkt from Haematococcus pluvialis occurred in Escherichia coli transformants producing β-carotene or zeaxanthin as a result of the presence of additional carotenoid genes from Erwinia uredovora . Requirement of molecular oxygen for the insertion of the keto group was demonstrated. The final product of this two-step ketolase reaction from β-carotene is canthaxanthin (4,4'-diketo-β-carotene) with the 4-monoketo derivative echinenone as an intermediate. A reaction sequence for the formation of astaxanthin from β-carotene was established based on kinetic data on astaxanthin formation in E. coli transformants carrying the hydroxylase gene crtZ from Erwinia along with bkt . We conclude that the carotenoids zeaxanthin and adonixanthin which accumulate in addition to astaxanthin in this transformant are products of side reactions rather than direct precursors of astaxanthin. The possible mechanisms for the formation of the keto derivatives are discussed.     

雨生红球藻的光周期效应

雨生红球藻(Haematococcus pluvialis)是一种单细胞淡水绿藻, 是自然界已知的中虾青素含量最高的生物物种。通过分析3种光照强度(70、120和300 μmol·m^–2·s^–1)下雨生红球藻细胞形态、生长速率和虾青素含量的差异, 对其光周期效应进行了研究。结果表明, 不同光强下适宜雨生红球藻生长的光周期均为16小时光照/8小时黑暗, 光强为120 μmol·m^–2·s^–1时其细胞生长速率最大, 为0.43 d^–1; 细胞内虾青素含量随着光强和光照时间的增加而增加, 在300 μmol·m^–2·s^–1光强下连续光照15天后, 藻细胞呈亮红色, 平均直径为21.02 μm, 最大虾青素值达39.40 pg·cell^–1。     

Influence of environmental and nutritional factors in the production of astaxanthin from Haematococcus pluvialis

Astaxanthin extracted from green algae is desirable in the food and pharmaceutical industries due to its antioxidant properties. The green unicellular clear water microalga Haematococcus pluvialis has a high production rate of astaxanthin; indeed, it contains more than 80% astaxanthin content in its cells. This remarkable astaxanthin production is commonly obtained under stress conditions such as nutrient deficiency (N or P), high NaCl concentrations, variations of temperature, and other factors. In this vein, a great research effort has been oriented to determine optimal conditions for astaxanthin production by H. pluvialis.The objective of the present study was the analysis of environmental factors, such as light intensity, aeration and nutrients on the growth and astaxanthin production of H. pluvialis. Maximum growth of H. pluvialis obtained was 3.5x10(5) cells/ml in BBM medium at 28 degrees C under continuous illumination (177 micromol photon m(-2)s(-1)) of white fluorescent light, with continuous aeration (1.5 v.v.m.). Meanwhile, maximal astaxanthin production was 98 mg/g biomass in BAR medium with continuous illumination (345 micromol photon m(-2)s(-1)), with 1 g/l of sodium acetate and without aeration.     

城市生活污水用于培养雨生红球藻的研究

虾青素是自然界广泛存在的一种橘红色类胡萝卜素,广泛应用于食品、药品和化妆品行业。在虾青素的制备中,雨生红球藻是生产虾青素的最有效来源,目前提高虾青素产量的方式主要为提高生物量和产物合成率。目前已有大量研究针对生物量的优化,但依然存在改善空间。为此,尝试用城市生活污水作为培养基对雨生红球藻进行培养。结果表明,生活污水能促进雨生红球藻的生长,其产量是现有BG11培养基的2倍;虾青素的合成时期显著提前（P<0.05）,且体内重金属含量未明显富集,处在安全浓度范围。此外,养藻后的城市生活污水中氮、磷含量显著降低（P<0.05）,高氮、磷富余的情形得到有效改善。证实利用污水培养雨生红球藻的双重效应,一方面有利于积累藻类生物量,另一方面有助于净化水质,在经济效益和生态效益上具有极好的发展潜力。     

2,4-二氯苯氧乙酸(2,4-D)对雨生红球藻中虾青素积累的影响

本文初步研究了一定浓度范围内的2,4-D对雨生红球藻积累虾青素的影响.在对数生长 期的藻液中分别加入一系列不同浓度的2,4-D溶液,然后进行胁迫培养(25℃、24h、5000Lx连续光照 营养盐饥饿),诱导细胞内虾青素的合成积累.在诱导过程中,显微观察不同浓度2,4-D处理后细胞形态和虾青素积累的动态变化,并定期取样测定虾青素含量.结果表明,20.0mg/L的2,4-D能够明显促进雨生红球藻中积累虾青素.它不仅可以加快虾青素积累进程(比对照提前15 d),而且比对照能提高13.4%的虾青素产量.     

Efficient one-step production of astaxanthin by the microalga Haematococcus pluvialis in continuous culture

The performance of Haematococcus pluvialis in continuous photoautotrophic culture has been analyzed, especially from the viewpoint of astaxanthin production. To this end, chemostat cultures of Haematococcus pluvialis were carried out at constant light irradiance, 1,220 microE/m2.s, and dilution rate, 0.9/d, but varying the nitrate concentration in the feed medium reaching the reactor, from 1.7 to 20.7 mM. Both growth and biomass composition were affected by the nitrate supply. With saturating nitrate, the biomass productivity was high, 1.2 g/L.d, but astaxanthin accumulation did not take place, the C/N ratio of the biomass being 5.7. Under moderate nitrate limitation, biomass productivity was decreased, as also did biomass concentration at steady state, whereas accumulation of astaxanthin developed and the C/N ratio of the biomass increased markedly. Astaxanthin accumulation took place in cells growing and dividing actively, and its extent was enhanced in response to the limitation in nitrate availability, with a recorded maximum for astaxanthin cellular level of 0.8% of dry biomass and of 5.6 mg/L.d for astaxanthin productivity. The viability of a significant continued generation of astaxanthin-rich H. pluvialis cells becomes thus demonstrated, as also does the continuous culture option as an alternative to current procedures for the production of astaxanthin using this microalga. The intensive variable controlling the behavior of the system has been identified as the specific nitrate input, and a mathematical model developed that links growth rate with both irradiance and specific nitrate input. Moreover, a second model for astaxanthin accumulation, also as a function of irradiance and specific nitrate input, was derived. The latter model takes into account that accumulation of astaxanthin is only partially linked to growth, being besides inhibited by excess nitrate. Simulations performed fit experimental data and emphasize the contention that astaxanthin can be efficiently produced under continuous mode by adjustment of the specific nitrate input, predicting even higher values for astaxanthin productivity. The developed models represent a powerful tool for management of such an astaxanthin-generating continuous process, and could allow the development of improved systems for the production of astaxanthin-rich Haematococcus cells.     

雨生红球藻八氢番茄红素合成酶基因的克隆及表征

雨生红球藻是一种单细胞绿藻,在多种逆境胁迫条件下能够大量合成并迅速积累虾青素,其积累量最高可达细胞干重的4%,从而成为目前最理想的天然虾青素合成工具.八氢番茄红素合成酶(PSY)是虾青素合成途径中第一个限速酶.分离了八氢番茄红素合成酶基因(psy)的全长cDNA及基因组DNA.其全长cDNA包括1200个碱基,编码400个氨基酸,基因组DNA包括5个外显子,4个内含子.系统发育分析结果显示,绿藻的八氢番茄红素合成酶基因形成一个进化枝,它们与高等植物的psy亲缘关系比较近.通过GenomeWalking的方法,分离了psy基因约1kb的5′侧翼序列.将含有TATA-box和CAAT-box的297bp的序列与LacZ报告基因构成嵌合的表达载体,用基因枪法转化雨生红球藻.lacZ的瞬间表达检测结果表明,这段上游序列能够驱动lacZ表达,具有启动子活性.     

Cosmetic benefits of astaxanthin on humans subjects

Two human clinical studies were performed. One was an open-label non-controlled study involving 30 healthy female subjects for 8 weeks. Significant improvements were observed by combining 6 mg per day oral supplementation and 2 ml (78.9 μM solution) per day topical application of astaxanthin. Astaxanthin derived from the microalgae, Haematococcus pluvialis showed improvements in skin wrinkle (crow's feet at week-8), age spot size (cheek at week-8), elasticity (crow's feet at week-8), skin texture (cheek at week-4), moisture content of corneocyte layer (cheek in 10 dry skin subjects at week-8) and corneocyte condition (cheek at week-8). It may suggest that astaxanthin derived from H. pluvialis can improve skin condition in all layers such as corneocyte layer, epidermis, basal layer and dermis by combining oral supplementation and topical treatment. Another was a randomized double-blind placebo controlled study involving 36 healthy male subjects for 6 weeks. Crow's feet wrinkle and elasticity; and transepidermal water loss (TEWL) were improved after 6 mg of astaxanthin (the same as former study) daily supplementation. Moisture content and sebum oil level at the cheek zone showed strong tendencies for improvement. These results suggest that astaxanthin derived from Haematococcus pluvialis may improve the skin condition in not only in women but also in men.