Studies on the adaptation of influenza viruses to MDCK cells

The amino acid sequences and biological properties of the haemagglutinin of three variants of the influenza virus X-31 (H3N2) selected for their capacity to grow in MDCK cells are reported. In two variants, amino acid substitutions at HA1 residues 8 and 144 correlated with the loss of a site for glycosylation and specific changes in antigenicity, respectively. In all three variants substitution of an arginine residue for histidine at HA1 position 17 was correlated with increased pH optima of haemolysis. The importance of this substitution for cleavage of the haemagglutinin precursor required to produce infectious virus is discussed in relation to the three-dimensional structure of X-31 haemagglutinin.     

Production of Sindbis,influenza, and vesicular stomatitis viruses in chicken embryo and rat embryo cell suspensions

Studies were carried out on the production of Sindbis, influenza and vesicular stomatitis viruses in suspensions of chicken embryo and rat embryo cells. The yield of Sindbis virus in chicken embryo cell suspensions was independent of the multiplicity of infection over the range 0.0001 to 0.01 although reduction in multiplicity caused a delay in virus production. With influenza virus the use of higher multiplicities gave increased virus yields possibly due to the very slow production at low multiplicities. In both monolayer and suspension cultures of chicken embryo cells addition of serum or use of media richer than minimum essential medium (Eagle) had little effect on Sindbis virus production, but if the glucose were omitted the virus yield was markedly reduced. In cell suspensions, a marked reduction in virus yield occurred if infection were delayed more than 24 hr after cell preparation whereas in monolayers the delay of infection allowed cell propagation and hence a higher yield of virus. It was also shown that vesicular stomatitis virus can be produced in chicken embryo cell suspensions, and that rat embryo primary cell suspensions can be used to prepare both Sindbis and vesicular stomatitis viruses. Sindbis virus obtained from chicken embryo cell suspensions was purified by polyethylene glycol precipitation and sucrose density gradient centrifugation and shown to contain only those proteins previously identified as viral, without any contamination from chicken cell proteins. The relative ease and economics of virus production by cell suspension and monolayer methods is compared.     

Molecular basis of the variability of epidemic strains of human influenza viruses

The data from literature and authors own studies are reviewed on variability of human influenza viral strains, isolated during the same epidemic season in different periods of pandemic cycle. The data obtained indicate that variability of epidemic strains of human influenza virus deals with the genes coding for outer membrane proteins (hemagglutinin and neuraminidase) as well as nonglycosylated proteins. Circulation of a number of viral variants of the same serotype, differing in antigenic specificity of outer membrane proteins or in the genes coding for nonglycosylated proteins was registered during one and the same season of one epidemic. During circulation of viral variants of the same serotype recombination may take place. Heterogeneity of viral strains circulating during different epidemic seasons of the same pandemic cycle is different. The possible mechanisms of development of the new epidemic variants of human influenza virus are discussed.     

Growth determinants for H5N1 influenza vaccine seed viruses in MDCK cells

H5N1 influenza A viruses are exacting a growing human toll, with more than 240 fatal cases to date. In the event of an influenza pandemic caused by these viruses, embryonated chicken eggs, which are the approved substrate for human inactivated-vaccine production, will likely be in short supply because chickens will be killed by these viruses or culled to limit the worldwide spread of the infection. The Madin-Darby canine kidney (MDCK) cell line is a promising alternative candidate substrate because it supports efficient growth of influenza viruses compared to other cell lines. Here, we addressed the molecular determinants for growth of an H5N1 vaccine seed virus in MDCK cells, revealing the critical responsibility of the Tyr residue at position 360 of PB2, the considerable requirement for functional balance between hemagglutinin (HA) and neuraminidase (NA), and the partial responsibility of the Glu residue at position 55 of NS1. Based on these findings, we produced a PR8/H5N1 reassortant, optimized for this cell line, that derives all of its genes for its internal proteins from the PR8(UW) strain except for the NS gene, which derives from the PR8(Cambridge) strain; its N1 NA gene, which has a long stalk and derives from an early H5N1 strain; and its HA gene, which has an avirulent-type cleavage site sequence and is derived from a circulating H5N1 virus. Our findings demonstrate the importance and feasibility of a cell culture-based approach to producing seed viruses for inactivated H5N1 vaccines that grow robustly and in a timely, cost-efficient manner as an alternative to egg-based vaccine production.     

Properties of reassortants of human and avian influenza viruses. Reproduction in MDCK cells at suboptimum temperatures

A series of reassortants has been constructed by crossing of UV-inactivated avian influenza virus of H3N8 subtype and live human influenza virus of H1N1 subtype, adapted to growth in continuous canine kidney cell line (MDCK). The analysis of RNA duplexes has shown that the reassortants contain HA gene of avian influenza virus whereas the other genes belong to human parent virus. The reassortants were efficiently reproduced in MDCK cells at low temperature (limiting for the avian parent virus). The data suggest that the avian virus HA gene does not hamper the reproduction of reassortant viruses in mammalian cells under the conditions unfavorable for the multiplication of avian influenza subtype H3N8 viruses.     

Genome composition analysis of the reassortant influenza viruses used in seasonal and pandemic live attenuated influenza vaccine

The cold-adapted, temperature sensitive and attenuated influenza master donor viruses A/Leningrad/134/17/57 (H2N2) and B/USSR/ 60/69 were used to generate the vaccine viruses to be included in live attenuated influenza vaccine. These vaccine viruses typically are 6:2 reassortant viruses containing the surface antigens hemagglutinin and neuraminidase of current wild type influenza A and influenza B viruses with the gene segments encoding the internal viral proteins, and conferring the cold-adapted, temperature sensitive and attenuated phenotype, being inherited from the master donor viruses. The 6:2 reassortant viruses were selected from co-infections between master donor virus and wild type viruses that theoretically may yield as many as 256 combinations of gene segments and thus 256 genetically different viruses. As the time to generate and isolate vaccine viruses is limited and because only 6:2 reassortant viruses are allowed as vaccine viruses, screening needs to be both rapid and unambiguous. The screening of the reassortant viruses by RT-PCRs using master donor virus and wild type virus specific primer sets was described to select both influenza A and influenza B 6:2 reassortant viruses to be used in seasonal and pandemic live attenuated vaccine.     

Flow cytometric monitoring of influenza A virus infection in MDCK cells during vaccine production

Background  

In cell culture-based influenza vaccine production the monitoring of virus titres and cell physiology during infection is of great importance for process characterisation and optimisation. While conventional virus quantification methods give only virus titres in the culture broth, data obtained by fluorescence labelling of intracellular virus proteins provide additional information on infection dynamics. Flow cytometry represents a valuable tool to investigate the influences of cultivation conditions and process variations on virus replication and virus yields.     

Additional inhibitory effect of tea extract on the growth of influenza A and B viruses in MDCK cells

It has been previously reported that green-tea extract (GTE) inhibits the growth of influenza virus by preventing its adsorption. In this study, we further investigated whether GTE exerts an additional inhibitory effect on the acidification of intracellular compartments such as endosomes and lysosomes (referred to as ELS) and thereby inhibits the growth of influenza A and B viruses in Madin-Darby canine kidney cells. The vital fluorescence microscopic study showed that GTE inhibited acidification of ELS in a concentration-dependent manner. Moreover, the growth of influenza A and B viruses was equally inhibited when the cells were treated with GTE within as early as 5 to 15 min after infection, depending on the virus strains. The fact that (-)epigallocatechin (EGC), one of major catechin molecules in GTE, exerts the inhibitory effects on the acidification of ELS and virus growth in a manner similar to that of GTE strongly suggests that EGC is one of the active components in the extract.     

Changes in paracellular and cellular ionic permeabilities of monolayers of MDCK cells infected with influenza or vesicular stomatitis viruses

Summary MDCK cells (epithelioid line derived from the kidney of a normal dog) form monolayers which retain the properties of transporting epithelia. In these cells viruses bud asymmetrically: influenza from the apical, and vesicular stomatitis (VSV) from the basolateral membrane (E. Rodríguez-Boulán and D. D. Sabatini,Proc. Natl. Acad. Sci. USA 75: 5071–5075, 1978; E. Rodríguez-Boulán and M. Pendergast,Cell 20: 45–54, 1980). In the present study, we analyzed whether these viruses affect specific ion-translocating mechanisms located in the plasma membrane. We studied the effect of infection on membrane and transepithelial conductance, passive and active unidirectional fluxes of Na⁺ and K⁺, intracellular potentials, cellular content of Na⁺ and K⁺, and formation of blisters which, in these preparations, are due to the vectorial transport of fluid. Two main observations are derived from these studies. First, infection with VSV caused an increase in transepithelial electrical conductance, due to the opening of tight junctions, 5 to 6 hr after the start of infection, coincident with the accumulation of envelope protein in the cell surface and with the rise in the curve of virus budding. Infection with influenza, on the other hand, increased the transepithelial conductance only late in the infection (12 to 14 hr) when virus production has already stopped. Second, viruses did affect membrane permeability. Yet, the changes observed may not be ascribed to a perturbation of the specific translocating mechanisms for Na⁺ and K⁺ which operate in the same region of the plasma membrane that the viruses use to penetrate and leave MDCK cells. The methods used in the present study are not suitable to decide whether the nonspecific changes in permeability elicited by the viruses occur over the whole cell membrane or are restricted to a given region.     

Structured model of influenza virus replication in MDCK cells

Intracellular events that take place during influenza virus replication in animal cells are well understood qualitatively. However, to better understand the complex interaction of the virus with its host cell and to quantitatively analyze the use of cellular resources for virion formation or the overall dynamic for the entire infection cycle, a mathematical model for influenza virus replication has to be formulated. Here, we present a structured model for the single-cell reproductive cycle of influenza A virus in animal cells that accounts for the individual steps of the process such as attachment, internalization, genome replication and translation, and progeny virion assembly. The model describes an average cell surrounded by a small quantity of medium and infected by a low number of virus particles. The model allows estimation of the cellular resources consumed by virus replication. Simulation results show that the number of cellular surface receptors and endosomes, as well as other resources, such as the number of free nucleotides or amino acids, is not significantly influenced by influenza virus propagation. A factor that limits the growth rate of progeny viruses and their release is the total amount of matrix proteins (M1) in the nucleus while other newly synthesized viral proteins (e.g., nucleoprotein NP) and viral RNAs accumulate. During budding, synthesis of vRNPs (viral ribonucleoprotein complexes) represents another limiting factor. Based on this model it is also possible to analyze effects of parameter changes on the dynamics of virus replication, to identify possible targets for molecular engineering, or to develop strategies for improving yields in vaccine production processes. Furthermore, a better insight into the interactions of viruses and host cells might help to improve our understanding of virus-related diseases and to develop therapies.     

Isolation of clonal strains of chicken embryo fibroblasts

A method for cloning of chicken embryo fibroblasts (CEF) was developed, yielding a cloning efficiency of up to 50% without use of feeder cells or conditioned medium. An analysis of the growth potential of over 200 randomly selected clones showed that only approx. 4% of the clones were capable of doubling more than 35 times before undergoing cellular senescence. A positive correlation between initial growth rate and in vitro lifespan was observed. This served as a basis for a simple selection procedure for fibroblast strains suitable for long-term culturing. None of over 200 clones thus isolated could be established into a line. Subclones from clonal CEF strains were more homogeneous than uncloned CEF cultures with respect to morphology and growth behaviour, but still heterogeneous in their in vitro life span. All fibroblast strains tested could be effectively infected and transformed by a variety of avian sarcoma and leukosis viruses.     

Trypsin promotes efficient influenza vaccine production in MDCK cells by interfering with the antiviral host response

Trypsin is commonly used in Madin–Darby canine kidney (MDCK) cell culture-based influenza vaccine production to facilitate virus infection by proteolytic activation of viral haemagglutinin, which enables multi-cycle replication. In this study, we were able to demonstrate that trypsin also interferes with pathogen defence mechanisms of host cells. In particular, a trypsin concentration of 5 BAEE U/mL (4.5 μg/mL porcine trypsin) used in vaccine manufacturing strongly inhibited interferon (IFN) signalling by proteolytic degradation of secreted IFN. Consequently, absence of trypsin during infection resulted in a considerably stronger induction of IFN signalling and apoptosis, which significantly reduced virus yields. Under this condition, multi-cycle virus replication in MDCK cells was not prevented but clearly delayed. Therefore, incomplete infection can be ruled out as the reason for the lower virus titres. However, suppression of IFN signalling by overexpression of viral IFN antagonists (influenza virus PR8-NS1, rabies virus phosphoprotein) partially rescued virus titres in the absence of trypsin. In addition, virus yields could be almost restored by using the influenza strain A/WSN/33 in combination with fetal calf serum (FCS). For this strain, FCS enabled trypsin-independent fast propagation of virus infection, probably outrunning cellular defence mechanisms and apoptosis induction in the absence of trypsin. Overall, addition of trypsin provided optimal conditions for high yield vaccine production in MDCK cells by two means. On the one hand, proteolytic degradation of IFN keeps cellular defence at a low level. On the other hand, enhanced virus spreading enables viruses to replicate before the cellular response becomes fully activated.