有机硫对生物脱硫过程的抑制机理及其研究进展

作为一种绿色、经济的新兴技术,生物脱硫技术正逐渐受到人们的青睐.然而,处理气体中的有机硫对生物脱硫过程的抑制是一个不容忽视的问题.文中总结了近年来国际上对生物脱硫过程中有机硫影响的相关研究,主要包括有机硫的种类及理化特征、有机硫对脱硫过程的影响、有机硫的作用机理、操作条件与有机硫的相互关系以及耐受有机硫微生物的种类,并...     

Cultivation of a desulfurizing bacterium, Mycobacterium strain G3

Various carbon and sulfur sources on the growth and desulfurization activity of Mycobacterium strain G3, which is a dibenzothiophene (DBT)-degrading microorganism, were studied. Ethanol, glucose or glycerol as the sole carbon source and MgSO₄, taurine or dimethyl sulfoxide (DMSO) as the sole sulfur source were suitable for the growth. In addition, desulfurization activity was expressed in medium containing taurine, MgSO₄ or DMSO at 0.1 mM, when 217 mM ethanol was used as the sole carbon source. The highest desulfurization activity was in the stationary phase cells after 5 days' growth, rather than those harvested during active growth, when Mycobacterium G3 was cultivated in medium containing 217 mM ethanol and 0.1 mM MgSO₄. Thus alternative sulfur sources to DBT can be used for the cultivation of this desulfurizing microorganism.     

生物酶/γ-Al2O3小球催化氧化柴油脱硫性能研究

通过吸附法将生物酶负载在γ-Al₂O₃小球载体上,并对生物酶/γ-Al₂O₃及载体进行扫描电镜(SEM)、比表面积分析(BET)、傅里叶红外光谱(FT-IR)及圆二色谱(CD)表征。结果表明:生物酶被吸附在载体上。将制备的生物酶/γ-Al₂O₃催化真实柴油氧化脱硫,考察了反应温度、反应流速和酶溶液浓度对真实柴油脱硫效果的影响,并对脱硫效果进行定性及定量分析;进一步对脱硫工艺条件进行响应面设计优化,找出最优反应条件。实验结果显示:反应温度49℃、反应流速1.0 mL/min、酶溶液浓度15.5%(酶载量为28.13 g),得出的最优脱硫率为93.16%;最后考察了该固定化酶的重复使用性能,该催化剂使用7次活性无明显降低,表明该固定化酶催化氧化柴油脱硫效果显著,具有潜在的工艺应用价值。     

石油生物催化脱硫的研究进展

石油生物催化脱硫技术是新兴的极具潜力的石油非加氢脱硫技术,在降低轻质油品生产成本、提高油品质量和环境保护等方面显示出潜在的优势,被誉为21世纪的石油脱硫技术。本文主要对石油生物催化脱硫技术特点、各种降解路线和研究现状进行了综述,指出了石油生物催化脱硫技术存在的问题,并提出了进一步研究发展的方向。     

柴油生物酶催化氧化脱硫的研究进展

柴油作为热值高、消耗率低的石油馏分燃料,可搭配大功率机械的使用标准,在传统能源中使用占比越来越高,被广泛应用于各种大型器械运作和生产中。随着柴油消耗的增多,柴油使用的污染问题也开始得到重视。硫作为主要污染物,在新的柴油标准中有了更高的要求,有必要对各脱硫方法进行深入探讨和工艺创新。传统加氢脱硫局限性过大,因此开发了各种非加氢脱硫方式进行脱硫研究,旨在研发出高效率和环境友好的绿色脱硫方式。综述了各种常规脱硫方法的优点和不足,归纳了生物酶催化氧化脱硫的研究现状和国内外最新进展,重点讨论了生物酶的各种脱硫方式的反应机理和具体研究实例,并对未来新型脱硫方式研究前景进行展望。     

脱硫废弃物对碱胁迫下水稻叶片钙分布、Ca2+-ATPase活性及抗氧化特征的影响

为了探讨脱硫废弃物提高水稻抗盐碱的作用机制,采用盆栽法,研究脱硫废弃物对碱胁迫下水稻幼苗叶片总钙含量、Ca2+分布、细胞膜Ca2+-ATPase活性及活性氧含量等的变化.结果表明:对照处理的细胞中钙颗粒零星分布于细胞壁和叶绿体中,添加脱硫废弃物和CaSO4处理的细胞质膜、细胞间隙、细胞壁和液泡中有大量的钙颗粒分布;随着脱硫废弃物和CaSO4添加量的增加,叶片总钙含量增加,质膜和液泡膜Ca2+-ATPase活性呈上升趋势,质膜透性、MDA含量和活性氧O2-产生速率呈下降趋势,SOD、POD等保护酶活性升高.添加脱硫废弃物在一定程度上能够减缓碱胁迫对水稻造成的细胞伤害,起主要作用的物质可能是其主要成分CaSO4.     

Microbial desulfurization of motor fuel

Deep desulfurization of oil and its fractions is currently performed by hydration at high temperature and hydrogen pressure, which makes the process rather expensive. Searches for alternative modes for desulfurization, among which is biodesulfurization, are intensely in progress. In this review, the following subjects are discussed: microorganisms capable of desulfurizing petroleum products, mechanisms of their activity, achievements in the field of process development, and disadvantages of the method. The existing level of knowledge is insufficient for immediate implementation of an industrial biotechnological process for sulfur elimination from oil and motor fuel and it can only be regarded as a medium-term (10–15 years) prospect.     

脱硫废弃物对碱胁迫下水稻叶片钙分布、Ca2+-ATPase活性及抗氧化特征的影响

为了探讨脱硫废弃物提高水稻抗盐碱的作用机制,采用盆栽法,研究脱硫废弃物对碱胁迫下水稻幼苗叶片总钙含量、Ca2+分布、细胞膜Ca2+-ATPase活性及活性氧含量等的变化.结果表明： 对照处理的细胞中钙颗粒零星分布于细胞壁和叶绿体中,添加脱硫废弃物和CaSO4处理的细胞质膜、细胞间隙、细胞壁和液泡中有大量的钙颗粒分布;随着脱硫废弃物和CaSO4添加量的增加,叶片总钙含量增加,质膜和液泡膜Ca2+-ATPase活性呈上升趋势,质膜透性、MDA含量和活性氧O2〖SX(B-*3〗-〖〗·〖SX)〗产生速率呈下降趋势,SOD、POD等保护酶活性升高.添加脱硫废弃物在一定程度上能够减缓碱胁迫对水稻造成的细胞伤害,起主要作用的物质可能是其主要成分CaSO4.     

脱硫废弃物对碱胁迫下油葵幼叶细胞钙分布及Ca2+-ATPase活性的影响

利用脱硫废弃物改良盐碱地对于确保国家粮食安全和生态安全,发展循环经济具有重要意义。为了探索脱硫废弃物提高植物抗盐碱机理,采用盆栽试验法, 研究了施入不同量脱硫废弃物和CaSO₄对碱胁迫下油葵叶片细胞钙分布、总钙含量以及质膜和液泡膜Ca²⁺-ATPase活性的影响。结果表明:在碱胁迫下(CK),Ca²⁺与焦锑酸钾结合成黑色颗粒成团零星分布于叶绿体和液泡中,叶绿体超微结构受到不同程度的破坏。施入脱硫废弃物和CaSO₄,叶绿体结构完整,细胞间隙、细胞壁和液泡中的钙颗粒逐渐增多,同时,质膜和液泡膜Ca²⁺-ATPase活性随脱硫废弃物和纯品硫酸钙施量的增加而增加,其中液泡膜Ca²⁺-ATPase活性无论是对照(CK)还是处理的活性均高于质膜Ca²⁺-ATPase活性。叶片细胞内总钙含量也随脱硫废弃物和CaSO₄施用量的增加呈升高趋势。说明脱硫废弃物和CaSO₄通过增加Ca²⁺-ATPase活性,有利于钙通过质膜和液泡膜进入细胞内,维持膜结构的稳定性,缓解碱对油葵的胁迫。     

Optimization of the copy number of dibenzothiophene desulfurizing genes to increase the desulfurization activity of recombinant Rhodococcus sp.

Dibenzothiophene (DBT) degradation activity of recombinant Rhodococcus sp. T09/pRKPP was increased by about 3.5-fold by introduction of the NAD(P)H/FMN oxidoreductase gene (dszD), while DBT desulfurization activity remained the same with production of dibenzo[1,2]oxathiin-6-oxide, which was caused by insufficient activity of the last desulfurization step involving a desulfinase. Introduction of an additional dsz operon resulted in a 3.3-fold increase DBT desulfurization activity (31 mol g dry cell^–1 h^–1) compared with that of T09/pRKPP (9.5 mol g dry cell^–1 h^–1). Furthermore, optimization of DBT at 25 mg l^–1 and glucose at 10 g l^–1, increased the total DBT desulfurization activity 2- to 3-fold due to increases in the DBT desulfurizing specific activity and the final cell concentration.     

血红蛋白基因在脱硫菌R-8中的表达及其在柴油脱硫中的应用

摘要：【目的】旨在构建一株优良的工程菌株,对血红蛋白基因在柴油的生物脱硫领域的应用做初步的探索。【方法】以德氏假单胞菌（Pseudomonas delafieldii） R-8为出发菌株,通过基因工程的手段,构建透明颤菌（Vitreoscilla）血红蛋白基因表达质粒并电击导入原始菌株,得到重组菌P. delafieldii R-8-2。【结果】R-8-2菌株的CO差光谱在419 nm处有特征峰出现,表明血红蛋白在脱硫菌中得到了有效表达。R-8-2菌株和R-8菌株相比,生长得到改善,相同培养条件下菌体密度比R-8提高了20%,最大脱硫活性能够达到R-8的2.4倍。在实际柴油脱硫实验中,R-8-2菌株能将柴油的硫含量降至96.6 mg/L,脱硫率达到69.9%,而R-8仅为57.2%。【结论】R-8-2是在较低溶氧条件下仍能保持较高的菌体密度和脱硫活性的基因工程菌株,具有良好的应用前景,该研究为血红蛋白基因在生物脱硫工业的应用提供参考。     

Desulfurization of 2,4,6,8-tetraethyl dibenzothiophene by recombinant Mycobacterium sp. strain MR65

Recombinant Mycobacterium sp. strain MR65 harboring dszABCD genes was used to desulfurize alkyl dibenzothiophenes (C_x-DBTs) in n-hexadecane. The specific desulfurization activity for 2,4,6,8-tetraethyl DBT (C₈-DBT) by DszC enzyme was about twice that for 4,6-dipropyl DBT (C₆-DBT). However, the degradation rate of 2,4,6,8-tetraethyl DBT in n-hexadecane by resting cells of strain MR65 was only about 40% of that of 4,6-dipropyl DBT. These results indicated that the desulfurization ability for Cx-DBTs by resting cells depends on carbon number substituted at positions 4 and 6 and that the rate-limiting step in the desulfurization reaction of highly alkylated C_x-DBTs is the transfer process from the oil phase into the cell.     

Comparison of the emulsion characteristics of Rhodococcus erythropolis and Escherichia coli SOXC-5 cells expressing biodesulfurization genes

Biodesulfurization of fuel oils is a two-phase (oil/water) process which may offer an interesting alternative to conventional hydrodesulfurization due to the mild operating conditions and reaction specificity afforded by the biocatalyst. For biodesulfurization to realize commercial success, a variety of process considerations must be addressed including reaction rate, emulsion formation and breakage, biocatalyst recovery, and both gas and liquid mass transport. This study evaluates emulsion formation and breakage using two biocatalysts with differing hydrophobic characteristics. A Gram-positive (Rhodococcus erythropolis) biocatalyst, expressing the complete 4S desulfurization pathway, and a Gram-negative biocatalyst (Escherichia coli), expressing only the gene for conversion of dibenzothiophene (DBT) to DBT sulfone, are compared relative to their ability to convert DBT and the ease of phase separation as well as biocatalyst recovery following desulfurization.     

微生物烟气脱硫中硫酸盐还原阶段的限制性因素及其影响

【目的】利用硫酸盐还原菌(SRB)厌氧活性污泥进行烟气脱硫,探索硫酸盐生物还原的最适条件及重金属离子对硫酸盐生物还原的影响,以提高硫酸盐还原阶段的效率。【方法】对取自污水处理厂的SRB厌氧活性污泥进行高浓度硫酸盐胁迫驯化。分析生物脱硫过程中SRB厌氧污泥还原硫酸盐的限制性因素及影响。【结果】在最适生长条件下(pH 6.5,32°C),经驯化获得的SRB厌氧活性污泥有较强的硫酸盐还原能力。Fe2+的适量添加对硫酸盐还原有一定促进作用。SRB厌氧污泥还原硫酸盐的ThCOD/SO42-最适值为3.00,ThCOD=3.33为最适理论化学需氧量,硫酸盐还原率可达72.15%。SRB厌氧污泥还原硫酸盐反应体系中抑制SRB活性的硫化物浓度为300 mg/L。Pb2+和Ni2+在较低的浓度下(1.0 mg/L和2.0 mg/L)对硫酸盐的还原产生较强的抑制作用,而Cu2+在稍高的浓度下(8.0 mg/L)显示出明显的抑制作用。【结论】经驯化,SRB厌氧活性污泥显示出较强的硫酸盐还原能力,具有应用于工业烟气生物脱硫的潜力。去除重金属离子Pb2+、Ni2+和Cu2+可有效解除对硫酸盐生物还原作用的抑制。     

Biodesulfurization of refractory organic sulfur compounds in fossil fuels

The stringent new regulations to lower sulfur content in fossil fuels require new economic and efficient methods for desulfurization of recalcitrant organic sulfur. Hydrodesulfurization of such compounds is very costly and requires high operating temperature and pressure. Biodesulfurization is a non-invasive approach that can specifically remove sulfur from refractory hydrocarbons under mild conditions and it can be potentially used in industrial desulfurization. Intensive research has been conducted in microbiology and molecular biology of the competent strains to increase their desulfurization activity; however, even the highest activity obtained is still insufficient to fulfill the industrial requirements. To improve the biodesulfurization efficiency, more work is needed in areas such as increasing specific desulfurization activity, hydrocarbon phase tolerance, sulfur removal at higher temperature, and isolating new strains for desulfurizing a broader range of sulfur compounds. This article comprehensively reviews and discusses key issues, advances and challenges for a competitive biodesulfurization process.     

Medium composition overturns the widely accepted sulfate-dependent repression of desulfurization phenotype in Rhodococcus qingshengii IGTS8

Microbial desulfurization has been extensively studied as a promising alternative to the widely applied chemical desulfurization process. Sulfur removal from petroleum and its products becomes essential, as the environmental regulations become increasingly stringent. Rhodococcus qingshengii IGTS8 has gained ground as a naturally occurring model biocatalyst, due to its superior specific activity for desulfurization of dibenzothiophene (DBT). Recalcitrant organic sulfur compounds—DBT included—are preferentially removed by selective carbon-sulfur bond cleavage to avoid a reduction in the calorific value of the fuel. The process, however, still has not reached economically sustainable levels, as certain limitations have been identified. One of those bottlenecks is the repression of catalytic activity caused by ubiquitous sulfur sources such as inorganic sulfate, methionine, or cysteine. Herein, we report an optimized culture medium for wild-type stain IGTS8 that completely alleviates the sulfate-mediated repression of biodesulfurization activity without modification of the natural biocatalyst. Medium C not only promotes growth in the presence of several sulfur sources, including DBT, but also enhances biodesulfurization of resting cells grown in the presence of up to 5 mM sulfate. Based on the above, the present work can be considered as a step towards the development of a more viable commercial biodesulfurization process.     

Organic sulfur removal from coal by microorganisms from extreme environments

Abstract: Microbial samples were collected from sulfurous, near neutral pH, thermal waters of Yellowstone Park. Thermophilic mixed cultures were identified that removed 90% of pyritic and sulfate sulfur and 33% of the organic sulfur from North Dakota lignite. The 30–40% organic desulfurization barrier was studied for possible inhibitors to organic sulfur removal from coal.     

Purification, characterization and crystallization of enzymes for dibenzothiophene desulfurization

DszC and DszA, DBT monooxygenase and DBT sulfone monooxygenase, respectively, involved in dibenzothiophene (DBT) desulfurization, were purified to homogeneity from Rhodococcus erythropolis D-1. The two enzymes were crystallized and enzymologically characterized. We found a high activity of flavin reductase in the non-DBT-desulfurizing bacterium, Paenibacillus polymyxa A-1, which is essential for DszC and A activities, and purified to homogeneity and characterized the enzyme.     

Methoxylation pathway in biodesulfurization of model organosulfur compounds with Mycobacterium sp.

A metabolic pathway for the biodesulfurization of model organosulfur compounds e.g., dibenzothiophene (DBT), is proposed. This pathway, defined as extended 4S pathway, incorporates the traditional 4S pathway with the methoxylation pathway from 2-hydroxybiphenyl (HBP) to 2-methoxybiphenyl (2-MBP). The formation of 2-MBP was confirmed by the gas chromatography–mass spectrometry (GC–MS) analysis. A similar pathway was also obtained in the desulfurization of 4,6-dimethyldibenzothiophene (4,6-DMDBT), confirming the methoxylation reaction in the desulfurization process by the Mycobacterium sp. strain. Compared with 2-HBP, 2-MBP has much slighter inhibition effect on the cell growth and desulfurization activity. Thus, the methoxylation pathway from 2-HBP to 2-MBP would make less inhibitory effect on the microbe. The new pathway with 2-MBP as the end product may be an alternative for the further desulfuration of the fossil fuels.     

Combining co-culturing of Paenibacillus strains and Vitreoscilla hemoglobin expression as a strategy to improve biodesulfurization

Enhancement of the desulfurization activities of Paenibacillus strains 32O-W and 32O-Y were investigated using dibenzothiophene (DBT) and DBT sulfone (DBTS) as sources of sulphur in growth experiments. Strains 32O-W, 32O-Y and their co-culture (32O-W plus 32O-Y), and Vitreoscilla hemoglobin (VHb) expressing recombinant strain 32O-Yvgb and its co-culture with strain 32O-W were grown at varying concentrations (0·1–2 mmol l⁻¹) of DBT or DBTS for 96 h, and desulfurization measured by production of 2-hydroxybiphenyl (2-HBP) and disappearance of DBT or DBTS. Of the four cultures grown with DBT as sulphur source, the best growth occurred for the 32O-Yvgb plus 32O-W co-culture at 0·1 and 0·5 mmol l⁻¹ DBT. Although the presence of vgb provided no consistent advantage regarding growth on DBTS, strain 32O-W, as predicted by previous work, was shown to contain a partial 4S desulfurization pathway allowing it to metabolize this 4S pathway intermediate.