Sorption immobilization of alpha-amylase from Bacillus subtilis using meshed carboxyl polyelectrolytes

Immobilization of alpha-amylase from Bacillus subtilis by adsorption on carboxyl polyelectrolytes, copolymers of methacrylic acid and ethylene glycol dimethacrylate, was being investigated depending on the structure of the polymeric matrix. It is demonstrated that cation exchange resins can be successfully used for reversible sorption and immobilization of alpha-amylase. It was found that the more heterogeneous the structure of the polymeric carrier, the higher is reversibility of the enzyme adsorption. The isothermic process of Bac. subtilis alpha-amylase adsorption on copolymers of different structures was studied as well. The equilibrium of the sorption system was proved to be true.     

Conformational stability of spectrin and fodrin

The conformational stability of erythrocyte spectrin and brain spectrin-like protein (fodrin) has been studied by circular dichroism. In agreement with previous reports the circular dichroism spectra of both proteins in the peptide region were almost identical. The essential differences, on the other hand, were found in the near u.v. range, most probably due to differences in the conformation of intrachain disulphide bonds. Heat denaturation curves, relating to the level of secondary structure (ellipticity at 221 nm) showed that fodrin is more stable than spectrin: curves of reversible as well as irreversible denaturation are shifted to higher temperatures and also the amount of alpha-helices in the denatured state is higher. Spectrin conformation was found to be very sensitive to the presence of water-soluble organic solvents; the denaturation curves exhibit maxima and minima not typical of protein isothermic denaturation. The observed low conformational stability of spectrin is discussed in the context of its molecular environment and function in the red cell membrane.     

用超大孔树脂吸附和低乙醇浓度洗脱提纯异黄酮的研究

传统大孔吸附树脂吸附分离中草药有效成分通常需要高浓度的有机溶剂作为洗脱剂,在大规模生产中具有安全隐患和对环境的污染。本文以异黄酮为目标产物,考察了8种不同骨架、不同孔径的树脂对异黄酮的吸附分离性能,其中包括本实验室自制的孔径为1000nm的超大孔树脂。实验结果表明,与传统大孔树脂吸附层析法相比,超大孔树脂吸附层析不仅工艺简单、快速而且大幅度降低了有机溶剂的使用量。洗脱时,乙醇浓度由70％降低到20％。     

多环芳烃类化合物在土壤上的吸附

研究了几种多环芳烃化合物在土壤上的吸附行为．通过一个连续投药－取样试验装置,在没有任何其它有机试剂干扰的情况下,测定了荧蒽与菲在土壤上的吸附量．研究表明,这两种多环芳烃化合物在土壤上的吸附量与土壤有机质含量之间呈显著相关．对多环芳烃化合物的分子结构及理化特性,如辛醇－水分配系数、溶解度等参数与ＬｏｇＫｏｃ关系的研究发现多环芳烃化合物的ＬｏｇＫｏｃ与化合物的水溶性、辛酸－水分配系数以及分子结构中的苯环数线性相关．     

Reversed micelle solvents as tools of enzyme purification and enzyme-catalyzed conversion

Reversed micelle solvents represent nanometer-sized aqueous droplets stabilized by surfactants inside the bulk organic solvents. The aqueous cores can host various hydrophilic solutes, including bioactive substances thus revealing a challenge to the biotechnology's needs of the safe media for bioseparations and bioconversions. This review discusses the structure and the properties of reversed micelle solvents in view of the parameters that can be easily operated in technology to achieve safe liquid-liquid extraction of proteins/enzymes or bioconversion of hydrophobic substrates. The paper highlights the importance of how the reversed micelle microenvironment should be arranged with respect to the preservation of the activity of the enzyme as target product or biocatalyst. The main aspects are demonstrated with own experimental results on alpha-amylase purification and lipase-catalyzed esterification using cationic reversed micelle solvents. The trials of performing continuous processes involving reversed micellar separation and reaction media are also reviewed and the current problems are addressed.     

On the issue of interfacial activation of lipase in nonaqueous media

The question of whether lipases can be activated by adsorption onto an interface in organic solvents was addressed using Rhizomucor miehei lipase as a model. In aqueous solution, this enzyme was shown to undergo a marked interfacial activation. However, lipase (either lyophilized or precipitated from water with acetone) suspended in ethanol or 2-(2-ethoxyethoxy)ethanol containing triolein exhibited no jump in catalytic activity when the concentration of triolein exceeded its solubility in these solvents, thereby resulting in formation of an interface. To test whether the lack of interfacial activation was due to the insolubility of the enzyme in organic media, lipase was covalently modified with poly(ethylene glycol). The modified lipase, although soluble in nonaqueous media, was still unable to undergo interfacial activation, regardless of the hydrophobicity of the interface. This inability was found to be caused by the absence of adsorption of lipase onto interfaces in organic solvents, presumably because of the absence of the hydrophobic effect (the driving force of lipase adsorption onto hydrophobic interfaces in water) in such media. The uncovered lack of interfacial adsorption and activation suggests that the short alpha-helical "lid" covering the active center of the lipase remains predominantly closed in nonaqueous media, thus contributing to diminished enzymatic activity. (c) 1996 John Wiley & Sons, Inc.     

Interaction of organic solvents with protein structures at protein-solvent interface

The effect of non-denaturing concentrations of three different organic solvents, formamide, acetone and isopropanol, on the structure of haloalkane dehalogenases DhaA, LinB, and DbjA at the protein-solvent interface was studied using molecular dynamics simulations. Analysis of B-factors revealed that the presence of a given organic solvent mainly affects the dynamical behavior of the specificity-determining cap domain, with the exception of DbjA in acetone. Orientation of organic solvent molecules on the protein surface during the simulations was clearly dependent on their interaction with hydrophobic or hydrophilic surface patches, and the simulations suggest that the behavior of studied organic solvents in the vicinity of hyrophobic patches on the surface is similar to the air/water interface. DbjA was the only dimeric enzyme among studied haloalkane dehalogenases and provided an opportunity to explore effects of organic solvents on the quaternary structure. Penetration and trapping of organic solvents in the network of interactions between both monomers depends on the physico-chemical properties of the organic solvents. Consequently, both monomers of this enzyme oscillate differently in different organic solvents. With the exception of LinB in acetone, the structures of studied enzymes were stabilized in water-miscible organic solvents.     

Role of organic solvents on Pa-hydroxynitrile lyase interfacial activity and stability

Catalytic activity and adsorption of Pa-hydroxynitrile lyase (Pa-Hnl) was investigated at various organic solvent/water interfaces. We focused on the role of solvent polarity in promoting activity and stability in two-phase systems, specifically for the solvents heptane, dibutyl ether (DBE), diisopropyl ether (DIPE), butylmethyl ether (BME), and methyl tert-butyl ether (MTBE). Enzyme activity towards mandelonitrile cleavage was determined in a recycle reactor with a well-defined interfacial area as described by Hickel, et al. 1999. Here the recycle reactor was modified to permit exchange of the aqueous phase. With this modification, irreversibility of enzyme adsorption was determined as a function of the adsorption time at the interface. Irreversibility of enzyme adsorption was also investigated by measuring the surface pressure of a sessile-drop upon washout. We find that Pa-Hnl exhibits the highest stability but the lowest initial catalytic activity at the aqueous/organic solvent interface with the most polar organic solvents. Thus, DIPE and MTBE display no loss in enzyme activity over a period of several hours. However, the more apolar the solvent is the higher the initial Pa-Hnl activity, but the faster the loss of activity. Dynamic tensiometry reveals that Pa-Hnl adsorbs more strongly at the interface of the more apolar solvents. Surprisingly, Pa-Hnl develops some irreversible adsorption after 30 min at the DIPE/water interface, but does not lose catalytic activity.     

Identification of a Pea Component Stimulatory for Heat-Stressed Putrefactive Anaerobe 59-123 Spores

Pea extract contains a factor which improves recovery counts of heat-stressed putrefactive anaerobe spores in a complex medium up to threefold. The factor is heat-stable and nondialyzable. Most of the active principle is found in the precipitate which forms during storage of pea extract at 4 C. The precipitate disperses upon heating, is high in starch content, and retains activity after extraction with organic solvents and water. Treatment of pea extract with alpha-amylase results in complete destruction of the active principle. These observations indicate that starch is the factor in pea extract responsible for increased recovery counts of heat-stressed putrefactive anaerobe spores.     

Effect of solvents on hydrolysis of olive oil by immobilized lipase in reverse phase system

Summary Lipase fromCandida rugosa was immobilized by adsorption on three supports which could contain water available for the hydrolysis of olive oil in a reverse phase system. To select the most suitable solvent for this system, the effect of organic solvents on the stability and catalytic activity of immobilized lipase for the hydrolysis reaction has been examined. The results revealed that isooctane was superior to any other solvents tested in this study for enzymatic fat splitting in a reverse phase system. Also the effect of the solvent polarity on the hydrolysis of olive oil has been examined in detail using various organic solvents mixed with an equivolume of isooctane. It was found that the hydrolysis of olive oil by immobilized lipase was markedly affected by the polarity of reaction solvents.     

Phospholipids hydrolysis in organic solvents catalysed by immobilised phospholipase C

Phospholipase C from Bacillus cereus has been immobilised on XAD7, Sepabeads FP-DA, Eupergit C, Celite 547, Silica gel 60 by covalent attachment or by adsorption. Preparates obtained with the two different immobilisation techniques show good hydrolytic activity in water-saturated organic solvents with phosphatidylcholine (PC) as a substrate. The chiral 1,2-diacyl glycerol can easily be obtained from the organic phase. The catalysts obtained by covalent attachment have been prepared with a higher specific activity and are suitable for repeated uses, while the ones prepared by adsorption with lower specific activity can only be used once. The initial rates of hydrolysis of PC solutions in different organic solvents and water content are compared.     

Effect of water activity on enzyme hydration and enzyme reaction rate in organic solvents

The effects of water on enzyme (protein) hydration and catalytic efficiency of enzyme molecules in organic solvents have been analyzed in terms of the thermodynamic activity of water, which has been estimated by the NRTL or UNIFAC equations. When the amount of water bound to the enzyme was plotted as a function of water activity, the water adsorption isotherms obtained from the water-solvent liquid mixtures were similar to the reported water-vapor adsorption isotherms of proteins. The water adsorption of proteins from the organic media was not significantly dependent on the properties of the solvents or the nature of the proteins. It is also shown that there is a linear relationship between the logarithm of the enzyme reaction rate and water activity. However, the dependence of the enzyme reaction rate on water activity was found to be different depending on the properties of the solvent. The relationship between water activity and other solvent parameters such as solvent hydrophobicity and the solubility of water in the solvent is also discussed.     

Polyvinyl alcohol--trypsin as a catalyst for amino acid ester synthesis in organic media

The bovine trypsin-catalyzed synthesis of N-alpha-benzoyl-DL-arginine esters from N-benzoyl-DL-arginine were studied in various organic solvents. Trypsin was immobilized to polyvinyl alcohol (PVA) by adsorption from its aqueous solutions. Immobilized enzyme showed higher catalytic activities than free enzyme for amino acid esterification in ethanol. The yield of ester is strongly dependent upon the PVA/trypsin ratio and water content in the reaction medium. The rate and equilibrium constant of the ester formation reaction are also dependent on water content.     

Characterization of a glucose polymer from PC12 cells and neuronal cells of rat embryo

A large-sized glucose polymer was isolated by pronase digestion from line PC12 pheochromocytoma cells metabolically labeled with [1-3H]galactose. The polymer was included on a column of concanavalin A-Sepharose and could be eluted with 10 mM methyl-alpha-mannoside. Its slight retention in a column of Bio-Gel A-5m suggested that its molecular weight was in the several millions. Glucose was the component monosaccharide and there were two minor lipophilic components present. The polymer was digested with alpha-amylase into a series of oligosaccharides and was cleaved by glucoamylase into glucose residues. The disaccharide obtained by digestion with alpha-amylase was identified as maltose in several HPLC systems and by NMR spectroscopy. NMR measurement revealed the trisaccharide to be maltotriose. Susceptibility of the polymer molecule to alpha-amylase, and the digestion products obtained, indicated a resemblance to glycogen. An analysis for saccharide compositions before and after reduction of the polymer suggested the presence of an aglycon part. Contrary to expectations based on the presence of this moiety, the polymer displayed good solubility in neutral organic solvents. Two-thirds of the glucose polymer was also soluble in 10% TCA. A similar glucose polymer was isolated from neuronal cells of rat embryos metabolically labeled with [1-3H]galactose. Mouse neuroblastoma cells did not synthesize the polymer.     

东北红豆杉细胞两液相培养中紫杉醇释放行为研究

在东北红豆杉细胞悬浮培养中,分别研究了稀土化合物(硫酸铈铵)、有机溶剂(油酸和邻苯二甲酸二丁脂)和稀土化合物与有机溶剂的协同作用对紫杉醇释放的影响。在此基础上深入研究了在东北红豆杉细胞两液相培养中,紫杉醇释放率随不同的有机溶剂(烷烃、有机酸、醇和脂)、有机溶剂的体积分数、有机溶剂的加入时间和有机溶剂相毒性的变化规律。结果表明分别加入稀土化合物和有机溶剂都明显促进紫杉醇的释放,特别是有机溶剂更显著促进紫杉醇的释放。但在东北红豆杉细胞两液相培养中,稀土化合物加入不能进一步促进紫杉醇的释放。因此两液相培养中有机溶剂本身就是很好的产物释放剂。紫杉醇的释放率由对照组的40%提高到75%以上。     

Adsorption of gold ions from industrial wastewater using activated carbon derived from hard shell of apricot stones - an agricultural waste

In this study, hard shell of apricot stones was selected from agricultural solid wastes to prepare effective and low cost adsorbent for the gold separation from gold-plating wastewater. Different adsorption parameters like adsorbent dose, particle size of activated carbon, pH and agitation speed of mixing on the gold adsorption were studied. The results showed that under the optimum operating conditions, more than 98% of gold was adsorbed onto activated carbon after only 3 h. The equilibrium adsorption data were well described by the Freundlich and Langmuir isotherms. Isotherms have been used to obtain thermodynamic parameters. Gold desorption studies were performed with aqueous solution mixture of sodium hydroxide and organic solvents at ambient temperatures. Quantitative recovery of gold ions is possible by this method. As hard shell of apricot stones is a discarded as waste from agricultural and food industries, the prepared activated carbon is expected to be an economical product for gold ion recovery from wastewater.     

High-affinity binding of water by proteins is similar in air and in organic solvents

Published data for water adsorption by proteins suspended in organic solvents (of interest as enzyme reaction mixtures) have been converted to a basis of thermodynamic water activity (aw). The resulting adsorption isotherms have been compared with those known for proteins equilibrated with water from a gas phase. This comparison can show any effects of the solvent on the interaction between the protein and water at the molecular level. At lower water contents (aw less than about 0.4), similar adsorption isotherms are found in each solvent and in the gas phase; differences are probably less than the likely errors. Hence, it may be concluded that the presence of an organic solvent has little effect on the interaction between proteins and tightly bound water; on a molecular scale there is probably little penetration of the primary hydration layer by solvent molecules, even fairly polar ones such as EtOH. At higher aw values, there are differences between the isotherms which probably are significant. Nonpolar solvents increase the amount of water bound by the enzyme (at fixed aw), while polar solvents (mainly EtOH) may reduce the amount of water bound by the enzyme, presumably by occupying part of the secondary hydration layers in place of water.     

Performance of hydrophobic chromatography in purification of alpha-amylase

Hydrophobic ligands were introduced onto agarose beads, and the adsorption capacity of the beads was measured. The adsorption capacity increased with increase in the carbon number of the ligand, ionic strength of the buffer solution, and temperature. Crude alpha-amylase was purified with these hydrophobic adsorbents and the breakthrough and elution curves were estimated based on the mass transfer theory. Under strongly hydrophobic conditions, impurities contained in crude feeds and the lack of uniformity of packing caused by aggregation of beads affected adsorption and elution behaviors.     

Effects of substrate branching characteristics on kinetics of enzymatic depolymerization of mixed linear and branched polysaccharides: II. Amylose/glycogen alpha-amylolysis

Enzymatic depolymerization of polysaccharides with alpha-amylase has been studied in mixed aqueous dimethylsulfoxide (DMSO)/water solvents. Polysaccharide substrate chemical compositions, configurational structures, and bonding pattersn are known to affect observed enzymatic reaction kinetics. The branching structures of polysaccharides and their effects on the kinetic mechanisms of depolymerization reactions via endo-acting hydrolyzing enzyme was studied via size exclusion chromatography coupled to low angle laser light scattering (SEC/LALLS). The glycogen branching structure is a heterogeneously distributed "cluster" structure rather than a homogeneously distributed "treelike" structure. The action pattern of alpha-amylase on glycogen, which is composed of highly branched clusters, as end-products, has a "pseudo-exo-attack" in contrast to an expected "endoattack" as seen in the hydrolysis of amylose or amylopectin substrates. These effects of branched substrates for mixed amylose/glycogen alpha-amylolysis have been predicted and demonstrated by both experimental and theoretical analysis using the kinetic model presented in this report. The "lumped" kinetic model employed, assumes that the enzyme simultaneously attacks both linear and branched substrates. In general, excellent agreement between the model predictions and the experimental observations, both qualitatively and quantitatively, was obtained. (c) 1995 John Wiley & Sons, Inc.     

Co-production of alpha-amylase and beta-galactosidase by Bacillus subtilis in complex organic substrates

Various nutrients belonging to three categories, carbon, organic nitrogen and complex organic sources, were investigated for the first time in terms of their effect on the co-production of extracellular thermostable alpha-amylase and beta-galactosidase by Bacillus subtilis, a bacterium isolated from fresh sheep's milk. Among the organic nitrogen sources tested, tryptone and corn steep liquor favored their production. Substitution of soluble starch by various starchy substrates, such as corn flour, had a positive effect on both enzyme yields. Furthermore, a two-fold higher production of both enzymes was achieved when corn steep liquor or tryptone was used in combination with the different flours. Among the divalent cations examined, calcium ions appeared to be vital for alpha-amylase production. The crude alpha-amylase and beta-galactosidase produced by this B. subtilis strain exhibited maximal activities at 135 degrees C and 65 degrees C, respectively, and were also found to be significantly stable at elevated temperatures.