氧化还原电位对Actinobacillus succinogenes厌氧发酵生产丁二酸的影响

为提高琥珀酸放线菌Actinobacillus succinogenes CGMCC1593厌氧发酵产丁二酸的水平。研究了以葡萄糖为C源,发酵液中不同氧化还原电位（VORP）对A．succirtogenes CGMCC1593生长和代谢产物分布的影响。结果表明：菌体生长和丁二酸积累的较佳VORP分别为-220mV和-270mV;利用代谢流分析法,比较VORP在-220mV和-270mV时发酵对数生长期（8h）和稳定期（20h）的代谢通量分布,以及发酵过程中磷酸烯醇式丙酮酸（PEP）、丙酮酸（Pyr）节点,NADH通量分配的变化,由此得出在VORP为-270mV时,NADH总通量和丁二酸方向代谢通量增幅明显。在发酵过程中,通过降低VORP至-270mV,使丁二酸的产率从70％提高到85％。     

产丁二酸工程菌的构建及其厌氧发酵

为了考察过量表达苹果酸酶对于E.coli NZN111(ldhA::Kan pfl::Cam)厌氧发酵产丁二酸的影响, 将连接有苹果酸酶基因sfcA的表达载体pTrc99a-sfcA转化进NZN111中, 构建了重组NZN111(pTrc99a-sfcA)。0.5 mmol/L IPTG诱导8 h后, 测定的苹果酸酶比酶活为30.67 u/mg, 比受体菌提高了140倍。采用两阶段发酵模式, 结果表明: 过量表达的苹果酸酶在NZN111体内催化了从丙酮酸到苹果酸的逆向反应, 丁二酸是发酵过程中积累的主要有机酸, 且当加入0.7 mmol/L IPTG诱导, 初始葡萄糖糖浓度为18.5 g/L时, 选择对数生长期后期的菌种以10%的接种量转入厌氧发酵, 发酵结束时发酵液中丁二酸的浓度为12.84 g/L, 对葡萄糖的收率为69.43%, 乙酸为0.58 g/L, 二者浓度比为22:1, 没有检测到甲酸和乳酸。构建的菌种具有高产丁二酸和副产物极少的优点, 在同类菌种中处于先进水平。     

环境因素对琥珀酸放线杆菌Actinobacillus succinogenes CGMCC 1593发酵生产丁二酸的影响

琥珀酸放线杆菌是发酵生产有应用前景的生物基原料-丁二酸的微生物。本研究室从牛瘤胃中筛选获得一株琥珀酸放线杆菌Actinobacillus succinogenes CGMCC 1593, 分析了环境气体、pH、氧化还原电位(ORP)环境因素对琥珀酸放线杆菌A. succinogenes CGMCC 1593发酵生产丁二酸的影响。结果表明: CO2不仅提供了A. succinogenes CGMCC 1593发酵生产丁二酸的最佳气体环境, 也是发酵生产丁二酸的底物之一; MgCO3是A. succinogenes CGMCC 1593发酵过程较好的pH调节剂, 发酵过程维持pH7.1~6.2, 可满足菌体生长与产酸的要求; 发酵液初始ORP过低, 不利于菌体生长, ORP在-270 mV时对丁二酸产生有利。在菌体对数生长期结束时, 通过Na2S·9H2O降低发酵液ORP到-270 mV, 发酵48 h时可产丁二酸37 g/L, 摩尔产率达到129%。这对深入研究A. succinogenes CGMCC 1593发酵生产丁二酸具有参考价值。     

环境因素对琥珀酸放线杆菌Actinobacillus succinogenes CGMCC 1593发酵生产丁二酸的影响

琥珀酸放线杆菌是发酵生产有应用前景的生物基原料-丁二酸的微生物。本研究室从牛瘤胃中筛选获得一株琥珀酸放线杆菌Actinobacillus succinogenes CGMCC 1593, 分析了环境气体、pH、氧化还原电位(ORP)环境因素对琥珀酸放线杆菌A. succinogenes CGMCC 1593发酵生产丁二酸的影响。结果表明: CO2不仅提供了A. succinogenes CGMCC 1593发酵生产丁二酸的最佳气体环境, 也是发酵生产丁二酸的底物之一; MgCO3是A. succinogenes CGMCC 1593发酵过程较好的pH调节剂, 发酵过程维持pH7.1~6.2, 可满足菌体生长与产酸的要求; 发酵液初始ORP过低, 不利于菌体生长, ORP在-270 mV时对丁二酸产生有利。在菌体对数生长期结束时, 通过Na2S·9H2O降低发酵液ORP到-270 mV, 发酵48 h时可产丁二酸37 g/L, 摩尔产率达到129%。这对深入研究A. succinogenes CGMCC 1593发酵生产丁二酸具有参考价值。     

碳源对重组大肠杆菌两阶段发酵产丁二酸的影响

研究了在好氧培养基中分别添加不同碳源对两阶段发酵菌体生长、酶活及代谢产物分布的影响,结果表明添加4mmol/L葡萄糖和12,54,80mmol/L乙酸钠均可以提高好氧阶段的菌体密度和相关酶活。将不同条件下培养的菌体转接厌氧发酵后,厌氧阶段的酶活和代谢产物分布也发生改变。进一步对酶活及代谢产物分析表明：Escherichia coli NZN111(sfcA)厌氧发酵过程中,磷酸烯醇式丙酮酸羧化激酶(PCK)是产丁二酸的关键酶,丙酮酸激酶(PYK)主要和副产物丙酮酸的积累有关,异柠檬酸裂解酶(ICL)对丁二酸产量也有一定影响。好氧培养基中添加80mmol/L乙酸钠,厌氧发酵结束时丁二酸的质量收率可达89.0%,相比对照提高了16.6%。     

过量表达苹果酸脱氢酶对大肠杆菌NZN111产丁二酸的影响

大肠杆菌NZN111是敲除了乳酸脱氢酶的编码基因 (ldhA) 和丙酮酸-甲酸裂解酶的编码基因 (pflB) 的工程菌,厌氧条件下由于辅酶NAD(H) 的不平衡导致其丧失了代谢葡萄糖的能力。构建了苹果酸脱氢酶的重组菌大肠杆菌NZN111/pTrc99a-mdh,在厌氧摇瓶发酵过程中通过0.3 mmol/L的IPTG诱导后重组菌的苹果酸脱氢酶 (Malate dehydrogenase,MDH) 酶活较出发菌株提高了14.8倍,NADH/NAD+的比例从0.64下降到0.26,同时NAD+和NADH浓度分别     

谷氨酸棒状杆菌厌氧产丁二酸的发酵条件

考察谷氨酸棒状杆菌ATCC13032Δldh厌氧产丁二酸的发酵条件。结果发现:补加NaHCO3的效果最好,并且考察了NaHCO3浓度对葡萄糖转化速率及丁二酸生成速率的影响。运用代谢流分析方法分析了乳酸脱氢酶基因敲除对谷氨酸棒状杆菌厌氧代谢的影响,发现乳酸脱氢酶基因敲除导致磷酸烯醇式丙酮酸生成丁二酸的流量提高了214.3%,流向乳酸的流量变为0;分批厌氧转化36 h生成41.2 g/L丁二酸,产率45.0%。     

外源添加代谢中间体对产琥珀酸放线杆菌厌氧发酵制备丁二酸的影响

考察了外源添加中间代谢产物对菌体生长及发酵产酸的影响,结果表明添加0.5g/L磷酸烯醇式丙酮酸(PEP)时丁二酸产量最高。围绕产琥珀酸放线杆菌NJ113厌氧发酵产丁二酸的代谢网络进行代谢通量分析,发现添加PEP后己糖磷酸途径(HMP)与糖酵解途径(EMP)的通量比由39.4∶60.3提高至76.8∶22.6,解决了丁二酸合成过程中还原力不足的矛盾,导致PEP生成草酰乙酸的通量提高了23.8%,丁二酸代谢通量从99.8mmol/(gDCW·h)增至124.4mmol/(gDCW·h),而副产物乙酸及甲酸的代谢通量分别降低了22.9%、15.4%;关键酶活分析结果表明,添加0.5g/LPEP后PEP羧化激酶比酶活达到1910U/mg,与对照相比提高了74.7%,而丙酮酸激酶的比酶活降低了67.5%。最终丁二酸浓度为29.1g/L,收率达到76.2%,比未添加PEP时提高了11.0%。     

微生物转化洛伐他汀条件的初步研究

以本实验室筛出的一株菌ST2710为出发菌,研究不同培养条件对转化率的影响。结果发现,菌株ST2710在种子培养基进行预培养,再转入转化培养基中培养2d后,加入洛伐他汀溶液1.0mL(10mg／mL)后再培养5d,产物的产率可达43．41％;就四种溶剂溶解底物条件进行了研究,结果发现用二甲基甲酰胺溶解洛伐他汀,产物产率为最高,并且转化作用不需要底物的诱导;以单独的菌丝体和上清液转化洛伐他汀时均低于培养液对洛伐他汀的转化作用。     

酵母菌产麦角固醇发酵条件的研究

为了提高酵母菌麦角固醇的产量,采用摇瓶培养法,对筛选出的一株酵母菌YN2产麦角固醇发酵条件进行了研究。结果表明,酵母菌YN2产麦角固醇适宜的培养基配方为：酵母粉1％,牛肉膏2．5％,葡萄糖8％,K2HPO4 0．3％,MgSO4 0．15％,该菌株产麦角固醇最适培养条件为：培养温度28℃,起始pH6．5,发酵时间72h。在优化的实验条件下,麦角固醇含量可达2．2％,100ml发酵液中麦角固醇产量达25．30mg。     

耐铵型产琥珀酸放线杆菌的选育

以Actinobacillus succinogenes NJ113为出发菌株,经硫酸二乙酯(DES)诱变,在含8～20 g/L硫酸铵平板中筛选到一株耐铵型突变株YZ25,该菌株在含8 g/L硫酸铵培养基中厌氧发酵,琥珀酸产量达32.68 g/L,比出发菌提高了180.5%,对葡萄糖收率达65.4%,副产物乙酸、甲酸产量分别下降3.5%、28.7%,琥珀酸/乙酸比值由0.63提高到2.5。在7.5 L发酵罐中,用氨水调节pH分批实验,发酵34 h琥珀酸产量达27.13 g/L,较出发菌株提高了85.3%。     

Efficient succinic acid production from high-sugar-content beverages by Actinobacillus succinogenes

This study presents the production of succinic acid (SA) by Actinobacillus succinogenes using high-sugar-content beverages (HSCBs) as feedstock. The aim of this study was the valorization of a by-product stream from the beverage industry for the production of an important building block chemical, such as SA. Three types of commercial beverages were investigated: fruit juices (pineapple and ace), syrups (almond), and soft drinks (cola and lemon). They contained mainly glucose, fructose, and sucrose at high concentration—between 50 and 1,000 g/L. The batch fermentation tests highlighted that A. succinogenes was able to grow on HSCBs supplemented with yeast extract, but also on the unsupplemented fruit juices. Indeed, the bacteria did not grow on the unsupplemented syrup and soft drinks because of the lack of indispensable nutrients. About 30–40 g/L of SA were obtained, depending on the type of HSCB, with yield ranging between 0.75 and 1.00 g_SA/g_S. The prehydrolysis step improved the fermentation performance: SA production was improved by 6–24%, depending on the HSCB, and sugar conversion was improved of about 30–50%.     

响应面优化产琥珀酸放线杆菌生产丁二酸

丁二酸是一种重要的C4化合物平台,可以合成一系列重要化合物。文中对产琥珀酸放线杆菌Actinobacillus succinogenes GXAS137发酵生产丁二酸培养基成分进行优化。通过单因素和Plackett-Burman试验设计筛选出影响丁二酸发酵的重要参数,采用最陡爬坡实验逼近最大丁二酸生产区域后,利用Box-Behnken设计确定重要参数的最佳水平。筛选结果表明,影响丁二酸产量的重要参数是葡萄糖、酵母提取物和碱式碳酸镁浓度。最佳条件为(g/L)：葡萄糖70.00,酵母提取物9.20,碱式碳酸镁58.10。优化后丁二酸产量达到47.64 g/L。与初始条件 (36.89 g/L) 相比,丁二酸浓度提高了30 %。在最佳工艺条件下得到的试验结果与模型预测值很吻合,说明建立的模型是有效的。     

耐铵型产琥珀酸放线杆菌的选育及铵离子对其生长代谢的影响

经硫酸二乙酯(DES)诱变,在含61～242mmol/LNH4+梯度平板中,筛选到一株耐铵型突变株YZ25,该菌株在含121mmol/LNH4+发酵培养基中,琥珀酸产量达32.68g/L,转化率为65.4%,比出发菌提高了180.5%。进一步考察了不同形态铵盐对YZ25生长的影响,结果表明添加少量铵盐能够提高突变菌的生长速率,但当超过一定量后菌株生长受到抑制,不同铵盐对菌株的抑制程度不同,硫酸铵、碳酸氢铵、氯化铵和硝酸铵对突变株YZ25的半抑制浓度分别为:215mmol/L、265mmol/L、235mmol/L、210mmol/L。为了考察铵离子对YZ25发酵产琥珀酸的影响过程,在3.0L发酵罐以氨水作为pH的调控剂发酵,结果表明在稳定期前菌株生长基本不受铵离子抑制,生物量能够达到正常水平,但是进入稳定期后铵离子抑制作用越来越明显,导致菌株生长提前结束,耗糖不完全,产酸受阻。最后结合产琥珀酸放线杆菌Actinobacillus succinogenes代谢途径分析了铵离子对菌株抑制作用的机理。     

产琥珀酸放线杆菌发酵生产琥珀酸的研究进展

近年来,因瘤胃微生物产琥珀酸放线杆菌Actinobacillus succinogenes具有高的琥珀酸产量,并能够利用多种碳源进行发酵等优点,在利用发酵法生产琥珀酸领域具有广泛的应用前景和商业化价值,因而其代谢途径和发酵工艺等基础研究成为国内外研发的热点。近年来,人们在产琥珀酸放线杆菌的代谢途径、琥珀酸发酵动力学模型、新型经济培养基以及高产菌株选育等方面的研究取得了很大进展,对研发琥珀酸发酵工艺、降低生产成本和节能减耗等具有重要的理论意义。     

产琥珀酸放线杆菌的原生质体制备与再生

基因组重组技术是一项重要的菌种改造技术,原生质体制备和再生是进行基因组重组的前提和基础。目前少有关于产琥珀酸放线杆菌(Actinobacillus succinogenes)CGMCC2650原生质体研究的报道。为了优化该菌的原生质体制备和再生条件,及利用基因组重组技术构建优良菌种提供参考,研究了甘氨酸预处理,菌龄,酶浓度,作用时间,温度对产琥珀酸放线杆菌原生质体制备和再生的影响,并考察了不同渗透压稳定剂对其再生的影响。结果表明,菌体在添加了0.6mg/ml甘氨酸的TSB培养基中培养5h后收集,用SMM稀释到OD660=1.0,用0.025mg/ml溶菌酶在37℃下酶解45min制备原生质体,将原生质体涂布于含0.3mol/L蔗糖的再生培养基中,再生率最大,达到40.9%。确定了产琥珀酸放线杆菌原生质体制备和再生的最佳条件,所用的原生质体制备的方法对琥珀酸的产生没有影响,这为进一步开展该菌的原生质体诱变及基因组重组等研究奠定了基础。     

A complete industrial system for economical succinic acid production by Actinobacillus succinogenes

An industrial fermentation system using lignocellulosic hydrolysate, waste yeast hydrolysate, and mixed alkali to achieve high-yield, economical succinic acid production by Actinobacillus succinogenes was developed. Lignocellulosic hydrolysate and waste yeast hydrolysate were used efficiently as carbon sources and nitrogen source instead of the expensive glucose and yeast extract. Moreover, as a novel method for regulating pH mixed alkalis (Mg(OH)₂ and NaOH) were first used to replace the expensive MgCO₃ for succinic acid production. Using the three aforementioned substitutions, the total fermentation cost decreased by 55.9%, and 56.4 g/L succinic acid with yield of 0.73 g/g was obtained, which are almost the same production level as fermentation with glucose, yeast extract and MgCO₃. Therefore, the cheap carbon and nitrogen sources, as well as the mixed alkaline neutralize could be efficiently used instead of expensive composition for industrial succinic acid production.     

Enhancement of succinic acid production by osmotic-tolerant mutant strain of Actinobacillus succinogenes

Fermentation and succinic acid production by Actinobacillus succinogenes YZ0819 was inhibited by high NaCl. To enhance the resistance of this strain to osmotic stress, an NaCl-tolerant mutant strain of A. succinogenes (CH050) was screened and selected through a continuous culture using survival in 0.7 M NaCl as the selection criterion. Using Na₂CO₃ as the pH regulator and glucose as the carbon source in batch fermentation, the isolated osmo-resistant stain, A. succinogenes CH050, produced up to 66 g/l succinic acid with a yield of 73.37% (w/w). The concentration of succinic acid and mass yield were increased by 37.5 and 4.37%, respectively, compared to the parent strain. The dry cell weight reached 10.1 g/l, which is 37% higher than that of the parent strain. The high tolerance of A. succinogenes CH050 to osmotic stress increased improved the succinic acid production from batch fermentation.     

碳源对琥珀酸放线杆菌发酵产丁二酸的影响及其代谢流量分析

在厌氧条件下, Actinobacillus succinogenes能够利用单糖、双糖和糖醇等碳水化合物发酵生成丁二酸, 其中以山梨醇为碳源时丁二酸的产量最高。代谢流量分析结果表明: 与葡萄糖发酵相比较, 由于代谢系统中积累了更多的NADH, 使得代谢网络关键节点PYR和AcCoA处的代谢流量分配有了较大的变化, 导致更多的碳源流向丁二酸和乙醇, 而乙酸和甲酸的分泌相对减少。     

Environmental and physiological factors affecting the succinate product ratio during carbohydrate fermentation by Actinobacillus sp. 130Z

Actinobacillus sp. 130Z fermented glucose to the major products succinate, acetate, and formate. Ethanol was formed as a minor fermentation product. Under CO₂-limiting conditions, less succinate and more ethanol were formed. The fermentation product ratio remained constant at pH values from 6.0 to 7.4. More succinate was produced when hydrogen was present in the gas phase. Actinobacillus sp. 130Z grew at the expense of fumarate and l-malate reduction, with hydrogen as an electron donor. Other substrates such as more-reduced carbohydrates (e.g., d-sorbitol) resulted in higher succinate and/or ethanol production. Actinobacillus sp. 130Z contained the key enzymes involved in the Embden-Meyerhof-Parnas and the pentose-phosphate pathways and contained high levels of phosphoenolpyruvate (PEP) carboxykinase, malate dehydrogenase, fumarase, fumarate reductase, pyruvate kinase, pyruvate formate-lyase, phosphotransacetylase, acetate kinase, malic enzyme, and oxaloacetate decarboxylase. The levels of PEP carboxykinase, malate dehydrogenase, and fumarase were significantly higher in Actinobacillus sp. 130Z than in Escherichia coli K-12 and accounted for the differences in succinate production. Key enzymes in end product formation in Actinobacillus sp. 130Z were regulated by the energy substrates. Received: 2 September 1996 / Accepted: 10 January 1997