黑曲霉生产菊粉酶工艺条件的研究

从徐州市沛县河口镇秦庄村牛蒡种植基地取得的土壤样本中,筛选出产菊粉酶的菌株,对从土壤中分离到的40株产菊粉酶的各类微生物进行酶活的测定。通过透明圈法初筛及摇瓶复筛,获得产菊粉酶能力较高的霉菌菌株3株,为C122803、D081506和D081513,这3株菌株的酶活分别达到：C122803：1.411 U/ml;D081506 ：1.895U/ml;D081513 ：1.792U/ml。其中D081506的酶活最高,为1.895U/ml;对D081506号黑曲霉产菊粉酶的发酵条件进行了研究,确定了优化的发酵条件为：牛蒡汁2%,酵母膏1.6%,(NH4)2SO41.6%,NaCl 0.5%,K2HPO4 0.5%,pH 5.0,在27℃、140 r/min条件下,摇瓶培养24h, D081506酶活力为2.958U/ml,酶活力提高56.09%。     

黑曲霉产菊粉酶菌株的选育及培养基优化

为获得高产菊粉酶的黑曲霉菌株,以Aspergillus niger YH-1为出发菌株,经过亚硝基胍(NTG)诱变,以高温高菊芋粉相结合的方式进行梯度驯化,选育出一株产菊粉酶菌株YH-3,并运用响应面实验方法对该菌株的培养基进行优化。确定了最佳培养基组成:菊芋粉25.2 g/L、豆饼粉40 g/L、蔗糖酯4.9 g/L、NaCl 5.5 g/L。发现内切菊粉酶活力(I)由60.9 U/mL提高到165.0 U/mL,比出发菌株提高了1.7倍。研究证明蔗糖酯对于黑曲霉YH-3发酵产菊粉酶是一种有效的促进剂。     

黑曲霉发酵产橙皮苷酶的工艺优化

目的:对黑曲霉WP124发酵产橙皮苷酶的工艺条件进行优化,旨在为利用酶法改造橙皮苷打下基础.方法:采用摇瓶培养,对培养基的成分和培养条件进行了优化.结果:黑曲霉WP124发酵产橙皮苷酶的最佳培养基组成是:蔗糖30g/L,酵母膏20g/L,磷酸二氢钾3g/L,桔皮粉50g/L;最佳培养条件是:起始pH为5.5,培养温度为30℃,摇瓶转速是180r/min.在上述条件下,经过72h的培养,橙皮苷酶酶活达到1398U/mL.结论:该菌株发酵过程具有较好的工业化应用的前景.     

黑曲霉(Aspergillus niger)产菊粉酶菌株的筛选及培养条件的研究

Ak3个地区7个土壤样品中筛选高产菊粉酶的黑曲霉菌株,对筛选出的黑曲霉菌株进行了形态鉴定,探讨了温度、pH值对菊粉酶活力的影响,比较了固体和液体两种扩大培养法对黑曲霉菌株产菊粉酶的影响。结果表明：经过初筛和复筛得到A4、A6、A8、A12、At4、A15和A16共7株黑曲霉菌株,菊粉酶活力大于15．0U／mL,经数码生物摄影显微镜镜检符合黑曲霉的形态特征。A8菌株的菊粉酶酶活最高,达到25．0U／mL,在60℃、pH值5．0的条件下酶活性最大。     

黑曲霉产木聚糖酶发酵条件的研究

正交设计试验结果表明,黑曲霉（Ａｓｐｅｒｇｉｌｌｕｓ ｎｉｇｅｒ ｍ１２）产木聚糖酶活力达７６．６０ｕ／ｍｌ,合适的产酶发酵条件如下,培养基（ｇ／Ｌ）：麸皮４０,尿素６．６７,ＫＨ２ＰＯ４ １．０,ＭｇＳＯ４．７Ｈ２Ｏ０．５,ＮａＣｌ０．３,Ｔｗｅｅｎ－８０ ３．０,ＣａＣＯ３ ２．０,２８℃,１２０ｒ／ｍｉｎ水浴振荡培养５．５ｄ。     

黑曲霉M89菊粉酶的提纯与性质

黑曲霉(Aspergillusniger）M89菊粉酶经硫酸铵分级盐析、SephadexG-200凝胶过滤、DEAE-纤维素离子交换层析、聚丙烯酞胺凝胶电泳（PAGE）制备分离,提纯到4个菊粉酶组分EⅠ、EⅡ、EⅢ和EⅣ。用SDS-PAGE测定分子量分别为102．6、97．9、61．2和36．5kD;用等电聚焦电泳测得其等电点分别为4．15、4．24、4．48和4．15。4个组分的最适反应温度均为55～60℃;EⅠ的最适pH为pH4．0,其余3个组分为pH4．5．各组分的热稳定性有一定差异,分子量越小的组分,热稳定性越好,55℃处理90min,EⅠ有一定的热失活,其余3个组分无活力丧失,4个组分都是外切酶。     

黑曲霉DB056产柚苷酶发酵条件初步优化

以α-鼠李糖苷酶活力和柚苷酶活力为考察指标, 研究了发酵条件对黑曲霉DB056产柚苷酶的影响。结果表明: 发酵温度、菌丝形态、培养基初始pH、接种量和装液量对黑曲霉DB056产柚苷酶都具有重要影响。初步优化得到黑曲霉DB056产柚苷酶的条件为: 培养基初始pH 8.0, 玻璃珠添加个数5个, 装液量45 mL, 接种量7%, 发酵温度34°C, 摇床转速190 r/min。采用此条件进行发酵, 高效液相色谱法检测α-鼠李糖苷酶活力最大可达1076.32 U/mL, 柚苷酶活力最大可达420.68 U/mL, 分别比初始条件提高了72.35%和78.03%。黑曲霉DB056不仅在对数生长期能快速合成柚苷酶, 在稳定期及衰亡期也会不断地分泌柚苷酶。阐明了发酵条件对黑曲霉DB056产柚苷酶的影响并获得了经过初步优化的发酵条件, 为进一步优化发酵条件, 提高黑曲霉DB056产柚苷酶的产量奠定了良好的基础。     

产脂肪酶细菌RYXP的诱变选育及突变株产酶条件优化

以"凤丹"牡丹根际土壤中分离筛选到的产脂肪酶菌株Pseudomonas sp. RYXP作为出发菌株,对其进行了紫外线诱变选育,并采用单因素试验和正交试验方法对活性最强正突变株的产脂肪酶基本特性进行了测定。结果表明,出发菌株Pseudomonas sp. RYXP的紫外线诱变最佳条件为:15 W紫外灯30 cm距离照射1 min;将产脂肪酶活性最强的正突变菌株编号为RYXP-3,单因素试验表明RYXP-3产脂肪酶适宜的碳源为玉米淀粉,适宜氮源为豆饼粉,适宜的磷酸二氢钾含量是0.3%,适宜的初始pH值为7;正交试验表明RYXP-3的最佳的产酶培养基成分组成是:玉米淀粉7%,豆饼粉3%,磷酸二氢钾0.3%,初始pH值为8。在优化方案A1B2C2D3产酶条件下,突变株RYXP-3最高的产酶活性达到56.1 U/mL。突变菌株RYXP-3可作为产油牡丹"凤丹"专用促生菌肥开发的备选资源菌株。     

碳源对产紫青霉产菊粉酶的影响

试验不同碳源对产紫青霉菊粉酶生产情况的影响。结果表明,果糖、菊糖、菊芋浸汁作为碳源是菊粉酶生产较理想的诱导因子,但过量的果糖会产生阻遏。经菊糖作为主要碳源和唯一碳源筛选的菌株产酶能力可提高6－7倍。同时在发酵前期加入易利用的碳源培养菌体,后期利用菊糖诱导酶的产生,可使酶产量提高2倍。     

Enhancement of inulinase production by Aspergillus niger van Teighem

P. VISWANATHAN AND P.R. KULKARNI. 1995. Aspergillus niger van Teighem, a soil isolate, was mutagenized by u.v. light. A mutant strain with 3 times increased productivity was generated on exposure of the parent strain to u.v. for 15 min. This mutant on further exposure to u.v. yielded second generation mutants with only marginal increase in inulinase productivity with respect to the parent mutant, but the best yield of 377 U ml⁻¹ was considered promising for industrial use.     

Medium optimization and kinetic modeling for the production of Aspergillus niger inulinase

Bioprocess and Biosystems Engineering - The goals of this study were to optimize the medium formulation for enhanced production of Aspergillus niger inulinase using Plackett–Burman Design...     

Evaluation of carbon sources for the production of inulinase by Aspergillus niger A42 and its characterization

Bioprocess and Biosystems Engineering - Inulinases are used for the production of high-fructose syrup and fructooligosaccharides, and are widely utilized in food and pharmaceutical industries. In...     

Production and properties of inulinase from Aspergillus niger

Summary A thermostable inulinase was identified in a strain of A. niger. The highest activity was observed at 50 °C (50 Lml^–1) and 77% and 34% of this was retained at 60° and 65°C, respectively. pH stability, the effect of thermal stabilizers such as Propylene glycol (10%) and Sorbitol (10%) and effects of different cations were investigated. It was found that the activity was completely inhibited by Ag⁺ and Hg²⁺, while Na⁺ had an activator effect.     

Aspergillus niger mutants with increased glucose oxidase production

Summary Aspergillus niger NRRL-3, an organism used for the industrial scale production of d-gluconic acid and glucose oxidase (EC 1.1.3.4), was subjected to mutagenesis and selection for acid production on diagnostic media containing methyl red. The plates contained 0.1 M d-glucose, a concentration that does not produce a color change in the medium surrounding mycelia of the parental strain under the conditions employed. Mutagenized spores yielded occasional colonies which were able to grow rapidly and were surrounded by a reddish zone. A number of such presumptive mutants were selected and isolated. Twenty-six such strains were grown in shaken cultures with liquid media containing 0.01, 0.1 or 0.5 M d-glucose, harvested, disrupted and the specific activity of d-glucose oxidase determined. Seven of the mutant strains had glucose oxidase specific activities markedly higher than the parental strain.Paper No. 8393, Nebraska Agricultural Research Division.     

Biochemical studies of citric acid production and accumulation by Aspergillus niger mutants

The biochemical rationale for the inhibition of citric acid fermentation by Aspergillus niger in the presence of Mn²⁺ ions has been investigated using high citric acid-yielding, Mn²⁺ ion-sensitive as well as Mn²⁺ ion-tolerant mutant strains of A. niger. In the presence of Mn²⁺ (1.5 mg/l), citric acid production by the Mn²⁺ ion-sensitive strain (KCU 520) was reduced by about 75% with no apparent effect on citric acid yield by the Mn²⁺ ion-tolerant mutant strain (GS-III) of A. niger. The significantly increased level of the Mn²⁺ ion-requiring NADP⁺-isocitrate dehydrogenase activity in KCU 520 cells and the lack of effect on the activity level of the enzyme in GS-III mutant cells by Mn²⁺ ions during fermentation seem to be responsible for the Mn²⁺ ion inhibition of citric acid production by the KCU 520 strain and the high citric acid yield by the mutant strain GS-III of A. niger even in the presence of Mn²⁺.     

Production of inulinase by mixed culture of Aspergillus niger and Kluyveromyces marxianus

Summary Inulinase activity produced by a mixed culture of Aspergillus niger and Kluyveromyces marxianus growing on Jerusalem artichoke powder was investigated. Inulinase produced by this mixed culture had a higher invertase-type activity than inulinase from respective monocultures. When hydrolysis was carried out at 50°C with Jerusalem artichoke exctract (total sugar 16% w/v) at pH 5.0, 90% hydrolysis was achieved after 4 h with 5% v/v of crude cell free enzyme preparation.     

Citric acid production by selected mutants of Aspergillus niger from cane molasses

The present investigation deals with citric acid production by some selected mutant strains of Aspergillus niger from cane molasses in 250 ml Erlenmeyer flasks. For this purpose, a conidial suspension of A. niger GCB-75, which produced 31.1 g/l citric acid from 15% (w/v) molasses sugar, was subjected to UV-induced mutagenesis. Among the 3 variants, GCM-45 was found to be a better producer of citric acid (50.0 +/- 2a) and it was further improved by chemical mutagenesis using N-methyl, N-nitro-N-nitroso-guanidine (MNNG). Out of 3,2-deoxy-D-glucose resistant variants, GCMC-7 was selected as the best mutant, which produced 96.1 +/- 1.5 g/l citric acid 168 h after fermentation of potassium ferrocyanide and H2SO4 pre-treated blackstrap molasses in Vogel's medium. On the basis of kinetic parameters such as volumetric substrate uptake rate (Qs), and specific substrate uptake rate (qs), the volumetric productivity, theoretical yield and specific product formation rate, it was observed that the mutants were faster growing organisms and produced more citric acid. The mutant GCMC-7 has greater commercial potential than the parental strain with regard to citrate synthase activity. The addition of 2.0 x 10(-5) M MgSO4 x 5H2O into the fermentation medium reduced the Fe2+ ion concentration by counter-acting its deleterious effect on mycelial growth. The magnesium ions also induced a loose-pelleted form of growth (0.6 mm, diameter), reduced the biomass concentration (12.5 g/l) and increased the volumetric productivity of citric acid monohydrate (113.6 +/- 5 g/l).     

Selection of biochemical mutants of Aspergillus niger with enhanced catalase production

 The production of extracellular catalase in a submerged culture by a number of biochemical mutants has been evaluated. Eight of these mutants showed increased extracellular catalase, the level of which ranged widely in individual cases from 44% to over 94% in comparison with the parental strain. Studies of the relationship between a criterion of selection and the frequency of mutation showed that the highest frequency of positive mutations (15.8% and 24.2%) was obtained with respect to mutants resistant to ethidium bromide (1 mmol/l) and sodium gluconate (45%) respectively. The time course of growth and enzyme production by the most active mutant, AM-20, showed extra- and intracellular catalase activities increasing about 2- and 2.6-fold respectively, compared with the parental strain. Received: 4 September 1996 / Received revision: 29 October 1996 / Accepted: 2 November 1996