Reduction of volatile acidity of acidic wines by immobilized Saccharomyces cerevisiae cells

Excessive volatile acidity in wines is a major problem and is still prevalent because available solutions are nevertheless unsatisfactory, namely, blending the filter-sterilized acidic wine with other wines of lower volatile acidity or using reverse osmosis. We have previously explored the use of an empirical biological deacidification procedure to lower the acetic acid content of wines. This winemaker’s enological practice, which consists in refermentation associated with acetic acid consumption by yeasts, is performed by mixing the acidic wine with freshly crushed grapes, musts, or marc from a finished wine fermentation. We have shown that the commercial strain Saccharomyces cerevisiae S26 is able to decrease the volatile acidity of acidic wines with a volatile acidity higher than 1.44 g?L^?1 acetic acid, with no detrimental impact on wine aroma. In this study, we aimed to optimize the immobilization of S26 cells in alginate beads for the bioreduction of volatile acidity of acidic wines. We found that S26 cells immobilized in double-layer alginate–chitosan beads could reduce the volatile acidity of an acidic wine (1.1 g?L^?1 acetic acid, 12.5 % (v/v) ethanol, pH 3.12) by 28 and 62 % within 72 and 168 h, respectively, associated with a slight decrease in ethanol concentration (0.7 %). Similar volatile acidity removal efficiencies were obtained in medium with high glucose concentration (20 % w/v), indicating that this process may also be useful in the deacidification of grape musts. We, therefore, show that immobilized S. cerevisiae S26 cells in double-layer beads are an efficient alternative to improve the quality of wines with excessive volatile acidity.     

Reduction of volatile acidity of wines by selected yeast strains

Herein, we isolate and characterize wine yeasts with the ability to reduce volatile acidity of wines using a refermentation process, which consists in mixing the acidic wine with freshly crushed grapes or musts or, alternatively, in the incubation with the residual marc. From a set of 135 yeast isolates, four strains revealed the ability to use glucose and acetic acid simultaneously. Three of them were identified as Saccharomyces cerevisiae and one as Lachancea thermotolerans. Among nine commercial S. cerevisiae strains, strains S26, S29, and S30 display similar glucose and acetic acid initial simultaneous consumption pattern and were assessed in refermentation assays. In a medium containing an acidic wine with high glucose-low ethanol concentrations, under low oxygen availability, strain S29 is the most efficient one, whereas L. thermotolerans 44C is able to decrease significantly acetic acid similar to the control strain Zygosaccharomyces bailii ISA 1307 but only under aerobic conditions. Conversely, for low glucose-high ethanol concentrations, under aerobic conditions, S26 is the most efficient acid-degrading strain, while under limited-aerobic conditions, all the S. cerevisiae strains studied display acetic acid degradation efficiencies identical to Z. bailii. Moreover, S26 strain also reveals capacity to decrease volatile acidity of wines. Together, the S. cerevisiae strains characterized herein appear promising for the oenological removal of volatile acidity of acidic wines.     

Effects of acetic acid on growth and fermentative activity of Saccharomyces cerevisiae

The effect of acetic acid on the growth and the fermentative activity of S. cerevisiae was analysed comparatively with the pH. This study showed that the pH does not affect these two activities. On the contrary, the acetic acid has an inhibition effect. This effect was modelised by the relation of Levenspiel. Finally, it was shown that the quantities of acetic acid produced by Brettanomyces were not sufficient to explain the inhibition of Saccharomyces.     

Induction of acetic acid tolerance and trehalose accumulation by added and produced ethanol in Saccharomyces cerevisiae

Both added (49.6 g/l) and produced ethanol (46.2 g/l) caused an increase in the acetic acid tolerance of Saccharomyces cerevisiaegrown in an anaerobic chemostat; added ethanol, however, to a less extent than produced ethanol. The ethanol induced acetic acid tolerance of the cells was linked with an accumulation of trehalose within the cells. These results indicate that trehalose plays a role in the ethanol induced acetic acid tolerance of S. cerevisiae.     

Effect of pH and lactic or acetic acid on ethanol productivity by Saccharomyces cerevisiae in corn mash

The effects of lactic and acetic acids on ethanol production by Saccharomyces cerevisiae in corn mash, as influenced by pH and dissolved solids concentration, were examined. The lactic and acetic acid concentrations utilized were 0, 0.5, 1.0, 2.0, 3.0 and 4.0% w/v, and 0, 0.1, 0.2, 0.4, 0.8 and 1.6% w/v, respectively. Corn mashes (20, 25 and 30% dry solids) were adjusted to the following pH levels after lactic or acetic acid addition: 4.0, 4.5, 5.0 or 5.5 prior to yeast inoculation. Lactic acid did not completely inhibit ethanol production by the yeast. However, lactic acid at 4% w/v decreased (P<0.05) final ethanol concentration in all mashes at all pH levels. In 30% solids mash set at pH ≤5, lactic acid at 3% w/v reduced (P<0.05) ethanol production. In contrast, inhibition by acetic acid increased as the concentration of solids in the mash increased and the pH of the medium declined. Ethanol production was completely inhibited in all mashes set at pH 4 in the presence of acetic acid at concentrations ≥0.8% w/v. In 30% solids mash set at pH 4, final ethanol levels decreased (P<0.01) with only 0.1% w/v acetic acid. These results suggest that the inhibitory effects of lactic acid and acetic acid on ethanol production in corn mash fermentation when set at a pH of 5.0–5.5 are not as great as that reported thus far using laboratory media.     

Effects of acetic acid on the temperature profile of ethanol tolerance inSaccharomyces cerevisiae

Summary In a strain ofSaccharomyces cerevisiae, acetic acid at concentrations up to 1% (v/v) depressed the tolerance to added ethanol, from 11% (v/v) down to zero, and simultaneously narrowed the temperature range of growth from 3–42°C to 19–26°C. In addition, acetic acid shifted the associative temperature profile of growthand death to lower temperatures, and depressed the growth yield on glucose.     

Effects of acetic acid on the kinetics of xylose fermentation by an engineered, xylose-isomerase-based Saccharomyces cerevisiae strain

Acetic acid, an inhibitor released during hydrolysis of lignocellulosic feedstocks, has previously been shown to negatively affect the kinetics and stoichiometry of sugar fermentation by (engineered) Saccharomyces cerevisiae strains. This study investigates the effects of acetic acid on S. cerevisiae RWB 218, an engineered xylose-fermenting strain based on the Piromyces XylA (xylose isomerase) gene. Anaerobic batch cultures on synthetic medium supplemented with glucose–xylose mixtures were grown at pH 5 and 3.5, with and without addition of 3 g L⁻¹ acetic acid. In these cultures, consumption of the sugar mixtures followed a diauxic pattern. At pH 5, acetic acid addition caused increased glucose consumption rates, whereas specific xylose consumption rates were not significantly affected. In contrast, at pH 3.5 acetic acid had a strong and specific negative impact on xylose consumption rates, which, after glucose depletion, slowed down dramatically, leaving 50% of the xylose unused after 48 h of fermentation. Xylitol production was absent (<0.10 g L⁻¹) in all cultures. Xylose fermentation in acetic –acid-stressed cultures at pH 3.5 could be restored by applying a continuous, limiting glucose feed, consistent with a key role of ATP regeneration in acetic acid tolerance.     

Effects of T-2 toxin on ethanol production by Saccharomyces cerevisiae.

A trichothecene mycotoxin, T-2 toxin, inhibits several aspects of cellular physiology in Saccharomyces cerevisiae, including protein synthesis and mitochondrial functions. We have studied growth of, glucose utilization by, and ethanol production by S. cerevisiae and show that they are inhibited by T-2 toxin between 20 and 200 micrograms/ml in a dose-dependent manner. At 200 micrograms/ml, T-2 toxin causes cell death. This apparent inhibition of ethanol production was found to be the result of growth inhibition. On the basis of biomass or glucose consumption, T-2 toxin increased the amount of ethanol present in the culture. This suggests that T-2 inhibits oxidative but not fermentative energy metabolism by inhibiting mitochondrial function and shifting glucose catabolism toward ethanol formation. As T-2 toxin does not directly inhibit ethanol production by S. cerevisiae, this system could be used for ethanol production from trichothecene-contaminated grain products.     

Effects of acetic acid and lactic acid on the growth of Saccharomyces cerevisiae in a minimal medium

Specific growth rates (μ) of two strains of Saccharomyces cerevisiae decreased exponentially (R ²>0.9) as the concentrations of acetic acid or lactic acid were increased in minimal media at 30°C. Moreover, the length of the lag phase of each growth curve (h) increased exponentially as increasing concentrations of acetic or lactic acid were added to the media. The minimum inhibitory concentration (MIC) of acetic acid for yeast growth was 0.6% w/v (100 mM) and that of lactic acid was 2.5% w/v (278 mM) for both strains of yeast. However, acetic acid at concentrations as low as 0.05–0.1% w/v and lactic acid at concentrations of 0.2–0.8% w/v begin to stress the yeasts as seen by reduced growth rates and decreased rates of glucose consumption and ethanol production as the concentration of acetic or lactic acid in the media was raised. In the presence of increasing acetic acid, all the glucose in the medium was eventually consumed even though the rates of consumption differed. However, this was not observed in the presence of increasing lactic acid where glucose consumption was extremely protracted even at a concentration of 0.6% w/v (66 mM). A response surface central composite design was used to evaluate the interaction between acetic and lactic acids on the specific growth rate of both yeast strains at 30C. The data were analysed using the General Linear Models (GLM) procedure. From the analysis, the interaction between acetic acid and lactic acid was statistically significant (P≤0.001), i.e., the inhibitory effect of the two acids present together in a medium is highly synergistic. Journal of Industrial Microbiology & Biotechnology (2001) 26, 171–177. Received 06 June 2000/ Accepted in revised form 21 September 2000     

Improvements in ethanol production from xylose by mating recombinant xylose-fermenting Saccharomyces cerevisiae strains

To improve the ability of recombinant Saccharomyces cerevisiae strains to utilize the hemicellulose components of lignocellulosic feedstocks, the efficiency of xylose conversion to ethanol needs to be increased. In the present study, xylose-fermenting, haploid, yeast cells of the opposite mating type were hybridized to produce a diploid strain harboring two sets of xylose-assimilating genes encoding xylose reductase, xylitol dehydrogenase, and xylulokinase. The hybrid strain MN8140XX showed a 1.3- and 1.9-fold improvement in ethanol production compared to its parent strains MT8-1X405 and NBRC1440X, respectively. The rate of xylose consumption and ethanol production was also improved by the hybridization. This study revealed that the resulting improvements in fermentation ability arose due to chromosome doubling as well as the increase in the copy number of xylose assimilation genes. Moreover, compared to the parent strain, the MN8140XX strain exhibited higher ethanol production under elevated temperatures (38 °C) and acidic conditions (pH 3.8). Thus, the simple hybridization technique facilitated an increase in the xylose fermentation activity.     

Effects of xylulokinase activity on ethanol production from D-xylulose by recombinant Saccharomyces cerevisiae

AIMS: Recombinant Saccharomyces cerevisiae strains harbouring different levels of xylulokinase (XK) activity and effects of XK activity on utilization of xylulose were studied in batch and fed-batch cultures. METHODS AND RESULTS: The cloned xylulokinase gene (XKS1) from S. cerevisiae was expressed under the control of the glyceraldehyde 3-phosphate dehydrogenase promoter and terminator. Specific xylulose consumption rate was enhanced by the increased specific XK activity, resulting from the introduction of the XKS1 into S. cerevisiae. In batch and fed-batch cultivations, the recombinant strains resulted in twofold higher ethanol concentration and 5.3- to six-fold improvement in the ethanol production rate compared with the host strain S. cerevisiae. CONCLUSIONS: An effective conversion of xylulose to xylulose 5-phosphate catalysed by XK in S. cerevisiae was considered to be essential for the development of an efficient and accelerated ethanol fermentation process from xylulose. SIGNIFICANCE AND IMPACT OF THE STUDY: Overexpression of the XKS1 gene made xylulose fermentation process accelerated to produce ethanol through the pentose phosphate pathway.     

Improved ethanol tolerance of Saccharomyces cerevisiae strains by increases in fatty acid unsaturation via metabolic engineering

To enhance the ethanol tolerance of Saccharomyces cerevisiae, the Arabidopsis thaliana FAD2 gene and/or the S. cerevisiae OLE1 gene were over-expressed in this yeast. The transformant over-expressing both these genes could not only synthesize dienoic fatty acids but also increased the unsaturated fatty acid content of membrane lipid and then showed the highest viability in the presence of 15% (v/v) ethanol.     

High temperature stimulates acetic acid accumulation and enhances the growth inhibition and ethanol production by Saccharomyces cerevisiae under fermenting conditions

Cellular responses of Saccharomyces cerevisiae to high temperatures of up to 42 °C during ethanol fermentation at a high glucose concentration (i.e., 100 g/L) were investigated. Increased temperature correlated with stimulated glucose uptake to produce not only the thermal protectant glycerol but also ethanol and acetic acid. Carbon flux into the tricarboxylic acid (TCA) cycle correlated positively with cultivation temperature. These results indicate that the increased demand for energy (in the form of ATP), most likely caused by multiple stressors, including heat, acetic acid, and ethanol, was matched by both the fermentation and respiration pathways. Notably, acetic acid production was substantially stimulated compared to that of other metabolites during growth at increased temperature. The acetic acid produced in addition to ethanol seemed to subsequently result in adverse effects, leading to increased production of reactive oxygen species. This, in turn, appeared to cause the specific growth rate, and glucose uptake rate reduced leading to a decrease of the specific ethanol production rate far before glucose depletion. These results suggest that adverse effects from heat, acetic acid, ethanol, and oxidative stressors are synergistic, resulting in a decrease of the specific growth rate and ethanol production rate and, hence, are major determinants of cell stability and ethanol fermentation performance of S. cerevisiae at high temperatures. The results are discussed in the context of possible applications.     

Variation in 4-mercapto-4-methyl-pentan-2-one release by Saccharomyces cerevisiae commercial wine strains

The volatile thiol 4-mercapto-4-methylpentan-2-one (4MMP) is a potent contributor to wine aroma. In grape juice, 4MMP is bound to cysteine as a non-volatile compound and requires the action of yeast during fermentation to release the aroma active thiol. A method was developed to measure 4MMP release from the precursor by headspace solid-phase microextraction and separation by gas chromatography with atomic emission detection to screen the ability of wine yeast to release 4MMP. Yeast commonly used in white wine making were grown with the precursor at two different temperatures, and the amount of 4MMP released was measured. The results demonstrate that yeast strain selection and fermentation temperature can provide an important tool to enhance or modulate the grape-derived aromas formed during wine fermentation.     

Efficient extraction of thioreodoxin from Saccharomyces cerevisiae by ethanol

Thioredoxin, an antioxidant protein, is a promising molecule for development of functional foods because it protects the gastric mucosa and reduces the allergenicity of allergens. To establish a method for obtaining an ample amount of yeast thioredoxin, we found here that thioredoxin is released from Saccharomyces cerevisiae by treatment with 20% ethanol. We also found that Japanese sake contains a considerable amount of thioredoxin.     

Transcriptional repression of ADH2-regulated beta-xylanase production by ethanol in recombinant strains of Saccharomyces cerevisiae

The regulation of endo-beta-(1,4)-xylanase production by two different strains of Saccharomyces cerevisiae, each transformed with the XYN2 gene from Trichoderma reesei under control of the promoter of the alcohol dehydrogenase II (ADH2) gene of S. cerevisiae, was investigated. In batch culture, the rate of xylanase production was severely reduced by the pulse addition of 390 mmol ethanol l(-1). Pulses of 190-630 mmol ethanol l(-1) into aerobic glucose-limited steady-state continuous cultures reduced the xylanase activity about five-fold and showed that ethanol repressed the ADH2 promoter, as was evident from Northern blot analyses. Derepression of the ADH2-regulated xylanase gene occurred at ethanol concentrations below approximately 50 mmol l(-1).