Effectiveness of a steam-vacuum sanitizer for reducing Escherichia coli O157:H7 inoculated to beef carcass surface tissue

A steam-vacuum sanitizer reduced aerobic plate counts associated with bovine faecal contamination from 5.5 log₁₀ cfu cm⁻² to 3.0 ± 0.21 log₁₀ cfu cm⁻² on beef carcass short plates. The same beef carcass short plates inoculated wiht 7.6 ± 0.09 log₁₀ cfu cm⁻² Escherichia coli O157: H7 in faeces, yielded an average residual level of E. coli O157: H7 of 2.1 ± 0.21 log₁₀ cfu cm⁻² after steam-vacuum treatments. This study demonstrates the effectiveness of a steam-vacuum sanitizer for removing E. coli O157: H7 from beef carcasses.     

Incorporation of nisin into a meat binding system to inhibit bacteria on beef surfaces

In two separate experiments, the bacteriocin, nisin, was incorporated into a commercially available meat binding system (Fibrimex^®) and applied to meat surfaces as a way of inhibiting the meat spoilage organism, Brochothrix thermosphacta during extended refrigerated storage. In experiment 1, pre-rigor lean beef carcass tissue (BCT) was inoculated with B. thermosphacta , left untreated (U), treated with 10 μg ml⁻¹ nisin (N), Fibrimex^® (F) or Fibrimex^® containing 10 μg ml⁻¹ nisin (FN), held aerobically at 4 °C for up to 7 d, and populations of B. thermosphacta and nisin activity determined. Experiment 2 determined the effects of the same treatments but on post-rigor, frozen and thawed lean BCT that was inoculated, vacuum-packaged, and stored at 4 °C for up to 14 d. In both experiments, N- and FN-treated tissues exhibited significantly lower populations of B. thermosphacta compared to U- and F-treated tissues, for the duration of refrigerated storage. Nisin activity was detected up to 7 d in N- and FN-treated samples from experiment 1. However, activity was detected only to days 0 and 2 in FN- and N-treated samples, respectively, from experiment 2. These studies indicate that the addition of a bacteriocin to a meat binding system and application to meat surfaces may be useful in reducing undesirable bacteria in restructured meat products.     

Survival of Escherichia coli O157 : H7 in yoghurt during preparation and storage at 4°C

Cow's milk was inoculated with ca 10³ and 10⁷ cfu ml⁻¹ Escherichia coli O157 : H7. After fermentation at 42°C for 0–5 h, the yoghurt was stored at 4°C. Two kinds of yoghurt were used : traditional yoghurt (TY), made with Streptococcus thermophilus and Lactobacillus bulgaricus starter cultures, and 'bifido' yoghurt (BY), made with the two starter cultures plus Bifidobacterium bifidum . After 7 d E. coli O157 : H7 decreased from 3·52 to 2·72 log₁₀ cfu ml⁻¹ and from 7·08 to 5·32 log₁₀ cfu ml⁻¹ in TY, and from 3·49 to 2·73 log₁₀ cfu ml⁻¹ and from 7·38 to 5·41 log₁₀ cfu ml⁻¹ in BY. The pH values of yoghurt dropped from 6·6 to 4·5 and 4·4 in TY (for low and high pathogen inocula, respectively), and from 6·6 to 4·6 and 4·5 in BY (for low and high pathogen inocula, respectively).     

Immunodot detection of nisin Z in milk and whey using enhanced chemiluminescence

A highly specific antisera was produced in New Zealand white rabbits against nisin Z, a 3400 Da bacteriocin produced by Lactococcus lactis ssp. lactis biovar. diacetylactis UL 719. A dot immunoblot assay was then developed to detect nisin Z in milk and whey. As few as 1·5 10⁻¹ international units per ml (IU ml⁻¹), corresponding to 0·003 μg ml⁻¹ of pure nisin Z, were detected in carbonate-bicarbonate buffer within 6 h using chemiluminescence. When milk and whey samples were tested, approximately 0·155 μg ml⁻¹ (7·9 IU ml⁻¹) of nisin Z was detected. The detection limit obtained was lower than that of traditional methods including microtitration and agar diffusion.     

In vitro efficacy of nisin Z against Candida albicans adhesion and transition following contact with normal human gingival cells

Aim:  To investigate the nisin Z innocuity using normal human gingival fibroblast and epithelial cell cultures, and its synergistic effect with these gingival cells against Candida albicans adhesion and transition from blastospore to hyphal form.
Methods and Results:  Cells were cultured to 80% confluence and infected with C. albicans in the absence or presence of various concentrations of nisin Z. Our results indicate that only high concentrations of nisin Z promoted gingival cell detachment and differentiation. Determination of the LD₅₀ showed that the fibroblasts were able to tolerate up to 80  μ g ml⁻¹ for 24 h, dropping thereafter to 62  μ g ml⁻¹ after 72 h of contact, compared to 160  μ g ml⁻¹ after 24 h, and 80  μ g ml⁻¹ after 72 h recorded by the gingival epithelial cells which displayed a greater resistance to nisin Z. The use of nisin Z even at low concentration (25  μ g ml⁻¹) at appropriate concentrations with gingival cells significantly reduced C. albicans adhesion to gingival monolayer cultures and inhibited the yeast's transition.
Conclusion:  These findings show that when used at non-toxic levels for human cells, nisin Z can be effective against C. albicans adhesion and transition and may synergistically interact with gingival cells for an efficient resistance against C. albicans .
Significance and Impact of the Study:  This study suggests the potential usefulness of nisin Z as an antifungal agent, when used in an appropriate range.     

Effect of high-temperature, short-time (HTST) pasteurization on milk containing low numbers of Mycobacterium paratuberculosis

The efficacy of high-temperature, short-time (HTST) pasteurization (72 °C/15 s) when low numbers (≤ 10³ cfu ml ⁻¹ ) of Mycobacterium paratuberculosis are present in milk was investigated. Raw cows' milk spiked with Myco. paratuberculosis (10³ cfu ml⁻¹, 10² cfu ml⁻¹, 10 cfu ml⁻¹, and 10 cfu 50 ml⁻¹) was subjected to HTST pasteurization using laboratory pasteurizing units. Ten bovine strains of Myco. paratuberculosis were tested in triplicate. Culture in BACTEC Middlebrook 12B radiometric medium detected acid-fast survivors in 14·8% and 10% of HTST-pasteurized milk samples at the 10³ and 10² cfu ml⁻¹ inoculum levels, respectively, whereas conventional culture on Herrold's egg yolk medium containing mycobactin J detected acid-fast survivors in only 3·7% and 6·7% of the same milk samples. IS900-based PCR confirmed that these acid-fast survivors were Myco. paratuberculosis . No viable Myco. paratuberculosis were isolated from HTST-pasteurized milk initially containing either 10 cfu ml⁻¹ or 10 cfu 50 ml⁻¹.     

Increased ELISA sensitivity using a modified extraction buffer for detection of Xanthomonas campestris pv. vesicatoria in leaf tissue

In vitro and in planta sensitivity of an indirect enzyme-linked immunoassaytechnique, using a monoclonal antibody specific for the lipopolysaccharide (LPS) of Xanthomonas campestris pv. vesicatoria , was increased 10-foldby using a newextraction buffer (gl of : KH₂PO₄, 2; NaHPO₄, 11·5; EDTAdisodium, 0·14; thimerosal, 0·02; and lysozyme, 0·2). The procedure improvedsensitivity without increasing background levels. In vitro , the limit of detection wasbetween 1×10⁷ and 1×10⁸ cells ml⁻¹ with the conventionalextraction buffer phosphate-buffered saline (PBS) and less than 1×10⁶ cells ml⁻¹ when lysozyme extraction buffer was substituted for PBS. In comparing 22 X. c.vesicatoria strains, absorbance readings were increased close to three-fold with the lysozymeextraction buffer as opposed to PBS. When leaf tissue extract was spiked with the bacterium, thelimit of detection was 1×10⁷ cfu ml⁻¹ and 1×10⁸ cfu ml⁻¹ with the lysozyme solution and PBS, respectively, as the extraction buffers. Whenusing the lysozyme extraction buffer in combination with a commercial amplification system, thelimit of detection was decreased to less than 1×10⁵ cfu ml⁻¹ in leaftissue. The addition of the lysozyme and EDTA to the phosphate buffer resulted in release of asignificant quantity of LPS and concomitant dramatic increase in sensitivity. The new procedure,termed lysozyme ELISA (L-ELISA), should increase sensitivity of ELISA reactions where LPS isthe reacting epitope.     

Electroporation of abalone sperm enhances sperm-DNA association

The ability of sperm from the black-footed abalone Haliotis iris to take up foreign DNA in solution has been demonstrated. The efficiency of DNA uptake is related to the conditions of electroporation, including field strength (625 V cm⁻¹, 1000 V cm⁻¹), pulse length (18.6 ms, 27.4ms) and number of pulses (1, 2), and DNA concentration (20, 100 μg ml⁻¹). Sperm motility decreased with increased field strength and pulse number. At a field strength of 625 V cm⁻¹, neither the pulse length nor pulse number enhanced DNA uptake. A 40% enhancement in DNA uptake was observed when the sperm were shocked at 1000 V cm⁻¹ with two long pulses (27.4 ms each). Linear regression analysis revealed that pulse number ( p = 0.013) and field strength ( P =0.039) were the most important factors in sperm–DNA interaction. Higher DNA concentration enhanced sperm DNA uptake irrespective of field strength, pulse length and pulse number. The optimal electroporation conditions for DNA uptake were 1000 V cm', with two pulses of 27.4 ms each, and a DNA concentration of 100 μg ml⁻¹.     

Anti-bacterial activity of synthetic N-heterocyclic oxidizing compounds

Synthetic chlorochromate derivatives of pyridine and quinoline were active in vitro against type cultures of Escherichia coli (ATCC 128), Staphylococcus aureus (ATCC 14775), Pseudomonas aeruginosa (ATCC 10145) and Bacillus subtilis (NCTC 8236). The minimum inhibitory concentrations (MIC) were 125–250 μg ml⁻¹ and 250–500 μg ml⁻¹ for pyridinium chlorochromate and quinolinium chlorochromate, respectively. An established derivative of quinoline (Perfloxacin) had an MIC of 125–250 μg ml⁻¹. The extinction time for 10⁵ cfu in broth was 90 min for pyridinium chlorochromate and 120 min for quinolinium chlorochromate, except for B. subtilis which survived up to about 180 min and 360 min. A combination of the two compounds produced an antagonistic effect. The 50% lethal dose (LD₅₀ toxicity) in mice was estimated at 76 μg g⁻¹ and 33 μg g⁻¹ body weight for the quinolinium and pyridinium chlorochromates. The compounds also exhibited some potential for suppressing a simulated staphylococcal infection in mice at the dosage levels of ca 22 μg g⁻¹ for pyridinium chlorochromate and 45 μg g⁻¹ for quinolinium chlorochromate.     

Decreased time for detection and quantification of virulent Bacillus anthracis and Yersinia pestis using a BioNanoPore (BNPTM) membrane technology

Many aspects of biodefense research require quantitative growth assessments of the test agent. This study evaluated the BioNanoPore (BNP™) technology to quantitate Bacillus anthracis and Yersinia pestis faster than traditional plate counting methods. The BNP™ technology enabled quantification of B. anthracis and Y. pestis in phosphate-buffered saline and naïve rabbit blood at 6 and 24 h, respectively. After 6 h of growth, counts for B. anthracis ranged from 6·19–6·45 log₁₀ CFU ml⁻¹ on BNP™, while counts after 24 h on tryptic soy agar (TSA) ranged from 6·51–6·58 log₁₀ CFU ml⁻¹. For Y. pestis , counts on BNP™ at 24 h ranged from 6·31–6·41 log₁₀ CFU ml⁻¹ on BNP™ and ranged from 6·44–6·89 log₁₀ CFU ml⁻¹ on TSA at 48 h. This study demonstrates that the BNP™ technology provides a more rapid detection of B. anthracis and Y. pestis , which could aid in the evaluation of potential medical countermeasures and treatments as well as other biological defense applications such as surface sampling or decontamination efficacy.     

The effect of cryptolepine on the morphology and survival of Escherichia coli, Candida albicans and Saccharomyces cerevisiae

The antimicrobial activity of the indoloquinoline alkaloid, cryptolepine, isolated from Cryptolepis sanguinolenta (Fam. Periplocaceae) was determined against selected micro-organisms. The minimum inhibitory concentration (MIC) ranges obtained, expressed as μg ml⁻¹, were: 5–10 for Saccharomyces cerevisiae NCPF 3139; 10–20 for S. cerevisiae NCPF 3178; 20–40 for Escherichia coli NCTC 10418; 40–80 for E. coli NCTC 11560, Candida albicans ATCC 10231 and C. tropicalis NCPF; and 80–160 for C. albicans NCPF 3242 and NCPF 3262.
Biocidal effects were noted at concentrations 2–4 times those of the MIC of the alkaloid following challenge with 10⁶ cfu ml⁻¹ of micro-organisms. Time-kill studies showed a reduction in viable count from 10⁶ to < 10 cfu ml⁻¹ in 4 h in C. albicans ATCC 10231 exposed to 320 μg ml⁻¹ of the agent; 3 log cycle reductions were recorded for the 6 h counts of E. coli NCTC 10418 and S. cerevisiae NCPF 3139 exposed to 40μg ml⁻¹ and 160 μg ml⁻¹ of the alkaloid respectively.
These results were consistent with findings using scanning electron microscopy. Exposure of cells to biocidal concentrations of cryptolepine produced filamentation prior to lysis in E. coli NCTC 10418 and extreme disturbance of surface structure, including partial and total collapse, followed by lysis in C. albicans ATCC 10231 and S. cerevisiae NCPF 3139.     

Combined effect of organic acids and supercritical carbon dioxide treatments against nonpathogenic Escherichia coli, Listeria monocytogenes, Salmonella typhimurium and E. coli O157:H7 in fresh pork

Aims:  To evaluate the effectiveness of organic acids and supercritical carbon dioxide (SC-CO₂) treatments as well as their combined effect for the reduction of nonpathogenic Escherichia coli and three pathogenic bacteria in fresh pork.
Methods and Results:  The different treatment conditions were as follows: (i) treatment with acetic (1%, 2% or 3%) or lactic acid (1%, 2% or 3%) only, (ii) treatment with SC-CO₂ at 12 MPa and 35°C for 30 min only and (iii) treatment with 3% acetic or lactic acid followed by treatment with SC-CO₂. Within the same organic acid concentration, the lactic and acetic acid treatments had similar reductions. For the combined treatment of lactic acid and SC-CO₂, micro-organism levels were maximally reduced, ranging from 2·10 to 2·60 log CFU cm⁻² ( E. coli , 2·58 log CFU cm⁻²; Listeria monocytogenes , 2·60 log CFU cm⁻²; Salmonella typhimurium , 2·33 log CFU cm⁻²; E. coli O157:H7, 2·10 log CFU cm⁻²).
Conclusions:  The results of this study indicate that the combined treatments of SC-CO₂ and organic acids were more effective at destroying foodborne pathogens than the treatments of SC-CO₂ or organic acids alone.
Significance and Impact of the Study:  The combination treatment of SC-CO₂ and organic acids may be useful in the meat industry to help increase microbial safety.     

The comparative effects of nitrogen and oxygen on the microflora of beef steaks in carbon dioxide-containing modified atmosphere vacuum skin-packaging (MA-VSP) systems

The effects of 80% oxygen–20% carbon dioxide (O₂–CO₂) and 80% nitrogen–20% carbon dioxide (N₂–CO₂) atmospheres were compared with respect to the microbial and sensory characteristics of vacuum skin-packaged grain-fed beef steaks stored at −1 and 4 °C. In both N₂–CO₂ and O₂–CO₂ atmospheres, lactobacilli were predominant over Brochothrix , pseudomonads, enterobacteria and yeasts and moulds. The results of the current investigation showed that the O₂–CO₂ atmospheres did not yield total viable counts in excess of 10⁵ cfu cm⁻² on beef steaks after 4 weeks of storage. However, the sensory analysis and thiobarbituric acid (TBA) values (as a measure of oxidative rancidity) of the products were unacceptable at this time. In contrast, the N₂–CO₂ atmospheres yielded maximum total viable counts of approximately 10⁷ cfu cm⁻² and the sensory analysis and TBA values of the product were judged to be acceptable after 4 weeks of storage at −1 °C. These results indicate that sensory effects of the product were influenced to a greater extent by the chemical effects of high concentration of O₂ on rancidity than by the high levels of lactobacilli.     

Comparison of conductimetric and traditional plating techniques for detecting yeasts in fruit juices

Frozen fruit juice concentrates containing an average microbial population of log₁₀ 1.54 cfu ml^-1 were examined by traditional plating techniques and direct and indirect conductimetry. The initial populations in diluted (1:4) concentrates increased to an average of log₁₀ 3.82 cfu ml^-1 during incubation at 25°C for 24 h. Incubation before plating and subjecting to conductimetric tests also facilitated the resuscitation of cells that may have been freeze-injured. Yeasts were recovered in equal numbers on acidified (pH 3.5) potato dextrose agar and dichloran rose bengal chloramphenicol agar (pH 5.6). Yeasts and bacteria were recovered on orange serum agar. Detection times determined by indirect conductimetry correlated fairly well ( r = -0.73) with populations (cfu ml^-1) detected on traditional plating media. Populations in diluted concentrates which were not incubated before examination were detected conductimetrically in an average of 48.9 h, whereas detection times for diluted concentrates incubated for 24 h at 25°C before testing were reduced to an average of 14.1 h. Examination by conventional (direct) conductimetry required an additional 10–20 h to reach changes in conductance of 5 μS h^-1.     

In vitro susceptibility of Clostridium perfringens isolated from farm animals to growth-enhancing antibiotics

Minimal inhibitory concentration (MIC) determinations were carried out with seven growth-enhancing antibiotics against 95 Clostridium perfringens field isolates obtained during 1991 and 1992 from poultry, pigs and calves. All were resistant to 64 μg ml⁻¹ of the bambermycin antibiotic, flavomycin (flavophospholipol) and susceptible to avoparcin (MIC₉₀ 0.25 μg ml⁻¹), avilamycin (MIC₉₀ 0.5 μg ml⁻¹) and salinomycin (MIC₉₀≤ 0.12 μg ml⁻¹). Acquired resistance against bacitracin was detected in some isolates from poultry and bovines and resistance to tylosin and virginiamycin in some strains from all species investigated. Overall, the prevalence of resistance was comparable to the low levels recorded in 1979 in Cl. perfringens isolates from the same animal host species.     

Nisin, temperature and pH effects on growth and viability of Pectinatus frisingensis, a Gram-negative, strictly anaerobic beer-spoilage bacterium

Pectinatus frisingensis , a Gram-negative and strictly anaerobic beer spoilage bacterium is sensitive to nisin. An increase in nisin concentration (0 to 1100 IU ml⁻¹) added to the culture medium prolonged the lag phase, and decreased the growth rate of the bacterium. In addition, late exponential cells of P. frisingensis exposed to low concentrations of nisin lost immediately a part of their intracellular K⁺. Presence of Mg²⁺ up to 15 mmol l⁻¹ did not protect P. frisingensis from nisin-induced loss of viability and K⁺ efflux. Potassium leaks were also measured in P. frisingensis late exponential phase cells exposed to combined effects of nisin addition (100–500 IU ml⁻¹), 10 min mild heat-treatment (50 °C) or rapid cooling (2 °C), and pH (4·0 and 6·2). Net K⁺ efflux from both starving and glucose-metabolizing cells, was more important at pH 6·2, whatever the temperature treatment and nisin addition. Reincubation at 30 °C of P. frisingensis glucose-metabolizing cells exposed to a preliminary combination of nisin addition and mild heat or cooling down treatment, showed that cells exposed to rapid cooling reaccumulated more K₊ than heat-treated cells, whatever the pH conditions. A combination of nisin and mild heat-treatment could thus be of interest to prevent P. frisingensis growth in beers.     

Physiological stress effects of continuous- and pulsed-DC electroshock on juvenile bull trout

Juvenile bull trout Salvelinus confluentus exposed to continuous- or pulsed-DC electroshock exhibited rapid elevations in plasma cortisol and glucose, but plasma chloride did not change. In a 1-h experiment using 240 V at 1·4 A of 60-Hz pulsed DC (voltage gradient 0·81 V cm⁻¹), which proved lethal, plasma cortisol and glucose rose significantly within 15 min of a 10-s electroshock. Plasma cortisol reached a peak level of 156 ± 18 ng ml⁻¹ at 45 min and then decreased, whereas plasma glucose reached its highest level of 179 ± 7·5mg dl⁻¹ at 1 h. In a 24-h experiment using lower dosages, plasma cortisol increased from 6·1-16 ng ml⁻¹ to peak levels of 155–161 ng ml⁻¹ in 1 h in response to a 10-s electroshock of continuous (130 V, 0·5 A, 1·45 V cm⁻¹) or pulsed (120 V, 0·5 A, 60 Hz, 0·55 V cm⁻¹) DC. Although plasma concentrations declined thereafter, levels remained above control values at 24 h. Plasma glucose was elevated from 60–65 to 120–134 mg dl⁻¹ after 1h by both electroshock treatments and remained near or above those levels for the 24-h duration. Plasma cortisol and glucose levels were much higher in electroshocked bull trout at 1 h compared with those in fish 1 h after receiving a 30-s handling stressor (cortisol, 90 ± 12 ng ml⁻¹; glucose, 82 ± 6·1 mg dl⁻¹). The results indicate that both continuous and pulsed DC were more stressful to juvenile bull trout than handling and that recovery, at least for pulsed DC, may take longer than 24 h.     

Electrotransformation of whole cells of Brevibacterium sp. R312 a nitrile hydratase producing strain: Construction of a cloning vector

Abstract: A rapid and effective method is described for electroporation of Brevibacterium sp. R312, a coryneform strain producing nitrile hydratase and amidase. The transformation efficiency of the method is 10⁸ transformants per μg of plasmid under optimal conditions. Parameters optimised included field strength (11.8 kV cm⁻¹), pulse length (2.4 ms), plasmid DNA concentration (0.25 μg ml⁻¹ and cell density (10¹⁰ cells ml⁻¹). Surprisingly, the transformation efficiency did not vary with the growth stage, in contrast to results in the literature. A shuttle vector was constructed containing several unique cloning sites down-stream of the SP6 RNA polymerase promoter.     

Development and characterization of a lux-modified 2,4-dichlorophenol-degrading Burkholderia sp. RASC

lux -marked biosensors for assessing the toxicity and bioremediation potential of polluted environments may complement traditional chemical techniques. lux CDABE genes were introduced into the chromosome of the 2,4-dichlorophenol (2,4-DCP)-mineralizing bacterium, Burkholderia sp. RASC c2, by biparental mating using the Tn 4431 system. Experiments revealed that light output was constitutive and related to cell biomass concentration during exponential growth. The transposon insertion was stable and did not interrupt 2,4-DCP-degradative genes, and expression of lux CDABE did not constitute a metabolic burden to the cell. A bioluminescence response was detectable at sublethal 2,4-DCP concentrations: at < 10.26 μg ml⁻¹, bioluminescence was stimulated (e.g. 218% of control), but at concentrations > 60 μg ml⁻¹ it declined to < 1%. Investigating the effect of [14C]-2,4-DCP concentration on the evolution of ¹⁴CO₂ revealed that, for initial concentrations of 2.5–25 μg ml⁻¹, ≈55% of the added ¹⁴C was mineralized after 24 h compared with < 1% at 50 and 100 μg ml⁻¹. Inhibition of 2,4-DCP mineralization between 25 and 50 μg ml⁻¹ corresponded well to the EC₅₀ value (33.83 μg ml⁻¹) obtained from bioluminescence inhibition studies. lux -marked RASC c2 may therefore be used as a functionally (i.e. 2,4-DCP degrader) and environmentally relevant biosensor of toxicity and biodegradation inhibition.     

Sensitization of Escherichia coli to nisin by maltol and ethyl maltol

F. SCHVED, M.D. PIERSON AND B.J. JUVEN. 1996. When used separately, 20 mmol 1^-1 maltol or 1600 AU ml^-1 nisin resulted in a 0–0.6 log₁₀ reduction in viable counts of Escherichia coli in a buffer system. However, when added in combination they yielded a 1.8–5. 5–log-cycle reduction in viable counts of E. coli at pH 5.0 and 6.8 respectively. It is postulated that maltol (and ethyl maltol) destabilizes the cell outer membrane by chelation of Mg²⁺ and/or Ca²⁺, thus permeabilizing the E. coli cell to nisin.