Control of Flavor Development in Wine during and after Malolactic Fermentation by Oenococcus oeni

During malolactic fermentation in wine by Oenococcus oeni, the degradation of citric acid was delayed compared to the degradation of malic acid. The maximum concentration of diacetyl, an intermediary compound in the citric acid metabolism with a buttery or nutty flavor, coincided with the exhaustion of malic acid in the wine. The maximum concentration of diacetyl obtained during malolactic fermentation was strongly dependent on the oxygen concentration and the redox potential of the wine and, to a lesser extent, on the initial citric acid concentration. The final diacetyl concentration in the wine was also dependent on the concentration of SO₂. Diacetyl combines rather strongly with SO₂ (K_f = 7.2 × 10³ M⁻¹ in 0.1 M malate buffer [pH 3.5] at 30°C). The reaction is exothermic and reversible. If the concentration of SO₂ decreases during storage of the wine, the diacetyl concentration increases again.     

Impact of different malolactic fermentation inoculation scenarios on Riesling wine aroma

During malolactic fermentation (MLF), lactic acid bacteria influence wine aroma and flavour by the production of volatile metabolites and the modification of aroma compounds derived from grapes and yeasts. The present study investigated the impact of different MLF inoculation strategies with two different Oenococcus oeni strains on cool climate Riesling wines and the volatile wine aroma profile. Four different timings were chosen for inoculation with bacteria to conduct MLF in a Riesling must/wine with a high acidity (pH 2.9–3.1). Treatments with simultaneous inoculation showed a reduced total fermentation time (alcoholic and malolactic) compared to the sequential inoculations. No negative impact of simultaneous alcoholic and malolactic fermentation on fermentation success and on the final wine volatile aroma composition was observed. Compared to sequential inoculation, wines with co-inoculation tended to have higher concentrations of ethyl and acetate esters, including acetic acid phenylethylester, acetic acid 3-methylbutylester, butyric acid ethylester, lactic acid ethylester and succinic acid diethylester. Results of this study provide some alternatives to diversify the number of wine styles by safely conducting MLF in low-pH, cool-climate white musts with potential high alcohol content.     

Regulation of hdc expression and HDC activity by enological factors in lactic acid bacteria

Aims: The aim of this work was to study the influence of enological factors on the histidine decarboxylase gene (hdc) expression and on histidine decarboxylase enzyme (HDC) activity in Lactobacillus hilgardii, Pediococcus parvulus and Oenococcus oeni. Methods and Results: Cell extracts and whole cells were used. Glucose, fructose, malic acid and citric acid diminished the hdc expression. Ethanol did not increase hdc expression or activity in cells, but increased HDC activity. Temperature and pH had effect on the activity of HDC but not on hdc expression. Tartaric acid and l -lactic acid, and sulphur dioxide (SO₂) had no effect on enzyme synthesis and activity. Bacterial species differ in the relative enzymatic activity but all the factors affected similarly to L. hilgardii, P. parvulus and O. oeni. Conclusions: The hdc gene expression was lowered by glucose, fructose, malic acid, and citric acid, whereas ethanol enhanced the HDC enzyme activity. The conditions that normally occur during malolactic fermentation and later on, could favour histamine production. SO₂ could prevent bacterial growth, but does not diminish the HDC enzyme activity. Significance and Impact of the Study: Information on hdc expression and HDC activity can contribute to the prevention of histamine formation during wine production and storage.     

Immobilization of Oenococcus oeni in lentikats® to develop malolactic fermentation in wines

Entrapment of Oenococcus oeni into a polymeric matrix based on polyvinyl alcohol (PVA) (Lentikats®) was successfully used to get a better development of malolactic fermentation (MLF) in wine. The incubation of immobilized cells in a nutrient medium before starting the MLF, did not improve the degradation of malic acid. In only one day, 100% of conversion of malic acid was achieved using a high concentration of immobilized cells (0.35 g gel/ml of wine with a cell‐loading of 0.25 mg cells/mg of gel). While a low concentration of 0.21 g gel/ml of wine (cell‐loading of 0.25 mg cells/mg of gel) needed 3 days to get a reduction of 40%. The entrapped cells could be reused through six cycles (runs of 3 days), retaining 75% of efficacy for the conversion of malic acid into lactic acid. The immobilized cells in PVA hydrogels gave better performance than free cells because of the increase of the alcohol toleration. Consequently, the inhibitory effect of ethanol for developing MLF could be reduced using immobilized cells into PVA hydrogels. © 2012 American Institute of Chemical Engineers Biotechnol. Prog., 2013     

Oenococcus oeni preference for peptides: qualitative and quantitative analysis of nitrogen assimilation

Optimization of malolactic fermentation in wine depends mainly on better understanding of nitrogen nutritional requirements of Oenococcus oeni. Four widely used starter strains and the reference ATCC BAA-1163 strain were grown in media containing different N sources: free amino acids, oligopeptides (0.5–10 kDa) or polypeptides (> 10 kDa). Amino acid auxotrophies were determined by the single omission technique. The tested strains were indifferent to only two to four amino acids and two of the starter strains appeared to be particularly demanding. Nitrogen consumption was investigated and a significant level of nitrogen was consumed by O. oeni only in the free amino acid medium. In media containing complex nitrogen sources, a global balance above 5 mg N l⁻¹ was enough to ensure biomass formation of all tested strains. Moreover, for all strains, bacterial growth yield was higher in the presence of nitrogen from peptides than that from free amino acids. However, no direct relationship between the bacterial growth level and the amount of nitrogen metabolized could be established. These findings were discussed in relation to the physiology of wine malolactic bacteria.     

A mathematical model of the link between growth and L-malic acid consumption for five strains of Oenococcus oeni

In winemaking, after the alcoholic fermentation of red wines and some white wines, L-malic acid must be converted into L-lactic acid to reduce the acidity. This malolactic fermentation (MLF) is usually carried out by the lactic acid bacteria Oenococcus oeni. Depending on the level of process control, selected O. oeni is inoculated or the natural microbiota of the cellar is used. This study considers the link between growth and MLF for five strains of O. oeni species. The kinetics of growth and L-malic acid consumption were followed in modified MRS medium (20 °C, pH 3.5, and 10 % ethanol) in anaerobic conditions. A large variability was found among the strains for both their growth and their consumption of L-malic acid. There was no direct link between biomass productivities and consumption of L-malic acid among strains but there was a link of proportionality between the specific growth of a strain and its specific consumption of L-malic acid. Experiments with and without malic acid clearly demonstrated that malic acid consumption improved the growth of strains. This link was quantified by a mathematical model comparing the intrinsic malic acid consumption capacity of the strains.     

Technological properties of Oenococcus oeni strains isolated from typical southern Italian wines

Aims: To isolate indigenous Oenococcus oeni strains suitable as starters for malolactic fermentation (MLF), using a reliable polyphasic approach. Methods and Results: Oenococcus oeni strains were isolated from Nero di Troia wines undergoing spontaneous MLF. Samples were taken at the end of alcoholic fermentation and during MLF. Wine samples were diluted in a sterile physiological solution and plated on MRS and on modified FT80. Identification of O. oeni strains was performed by a polymerase chain reaction (PCR) experiment using strain‐specific primers. Strains were further grouped using a multiplex RAPD‐PCR analysis. Then, six strains were inoculated in two wine‐like media with two different ethanol concentrations (11 and 13% vol/vol) with a view to evaluate their capacity to grow and to perform MLF. In addition, a quantitative PCR (qRT‐PCR) approach was adapted to monitor the physiological state of the strains selected. Conclusion: A positive correlation between the malolactic activity performance and the ability to develop and tolerate stress conditions was observed for two selected O. oeni strains. Significance and Impact of the Study: The results reported are useful for the selection of indigenous MLF starter cultures with desired oenological traits from typical regional wines. It should be the base for the improvement in organoleptic quality of typical red wine.     

A multiplex PCR method for simultaneous species identification and strain typification of Oenococcus oeni

Selected starter cultures of Oenococcus oeni are widely used to initiate malolactic fermentation (MLF) in wine. Nevertheless, the inoculated culture does not always develop as expected and undesired strains can grow causing wine spoilage. Therefore, methods that can reliably differentiate O. oeni strains are essential to monitor the population dynamics of MLF. This work presents a new multiplex PCR method that allows the simultaneous species identification and strain typification of O. oeni, based on the combined use of species-specific PCR primers and a Random Polymorphic DNA (RAPD)-PCR primer. This method represents an useful tool for the control of wine MLF.     

Correlation between indigenous <Emphasis Type="Italic">Oenococcus oeni</Emphasis> strain resistance and the presence of genetic markers

This study reports on monitoring Oenococcus oeni intraspecific diversity evolution during winemaking. Three different wines were monitored. The proportion of O. oeni species was determined by species-specific PCR and O. oeni strains were distinguished by multiplex PCR-RAPD. Each strain was tested by PCR for 16 significant markers revealed by a previous genetic comparison between a strong oenological potential strain and one with poor oenological potential. Population levels and diversity changed according to winemaking stages, oenological practices and the chemical properties of the wine. In all situations, O. oeni was the best-adapted species. Within the O. oeni group, intraspecific strain diversity decreased and the malolactic fermentation was the result of the most resistant strains with the highest number of markers.     

Leuconostoc oenos and malolactic fermentation in wine: a review

This review article summarizes the state of the art on Leuconostoc oenos, the bacteria responsible for malolactic fermentation in wine. Both basic and practical aspects related to the metabolism of this microorganism and malolactic fermentation in general are critically reviewed. The former examines the role of genetics for the identification and classification of L. oenos and energetic mechanisms on solute transport (malic and lactic acid). The latter includes practical information on biomass production, optimal growth conditions and stress factors, which are important in growth optimization of malolactic starter cultures. Extensive data and references on the effect of malolactic fermentation on wine composition and sensory analysis are also included. Received 06 May 1999/ Accepted in revised form 13 July 1999     

Impact of acetaldehyde- and pyruvic acid-bound sulphur dioxide on wine lactic acid bacteria

Aims: To investigate the impact of acetaldehyde‐ and pyruvic acid‐bound sulphur dioxide on wine lactic acid bacteria (LAB). Methods and Results: Growth studies were performed where Oenococcus oeni, Pediococcus parvulus, Ped. damnosus and Lactobacillus hilgardii were inoculated into media containing various concentrations of acetaldehyde or pyruvic acid and an equimolar concentration of SO₂ at pH 3·50 and 3·70. Low concentrations of acetaldehyde‐ and pyruvic acid‐bound SO₂ were inhibitory to the growth of all bacteria although acetaldehyde‐bound SO₂ was generally more inhibitory than pyruvic acid‐bound SO₂. Inhibition was greater at pH 3·50 than 3·70, and Lact. hilgardii was the most sensitive to acetaldehyde‐bound SO₂, while O. oeni was the most sensitive to pyruvic acid‐bound SO₂. Degradation of SO₂‐bound acetaldehyde was observed for all LAB, and aside from O. oeni, there was also complete degradation of SO₂‐bound pyruvic acid at both pH values. O. oeni only degraded pyruvic acid at pH 3·70. Degradation of SO₂‐bound acetaldehyde or pyruvic acid did not correlate with bacterial growth as inhibition was always observed in media containing bound SO₂. Conclusions: Acetaldehyde‐ and pyruvic acid‐bound SO₂ were inhibitory to wine LAB growth at concentrations as low as 5 mg l^?1. Despite this inhibition, all wine LAB degraded SO₂‐bound acetaldehyde and pyruvic acid suggesting that bound SO₂ may have a bacteriostatic rather than bacteriocidal action. Significance and Impact of the Study: Sulphur dioxide bound to acetaldehyde or pyruvic acid is inhibitory to growth of wine LAB and must be considered when conducting the malolactic fermentation or controlling the growth of spoilage bacteria such as Pediococcus and Lactobacillus.     

Impact of winemaking practices on arginine and citrulline metabolism during and after malolactic fermentation

AIMS: To study arginine degradation and carcinogenic ethyl carbamate precursor citrulline formation during and after malolactic fermentation (MLF). METHODS AND RESULTS: MLF was induced in white wine with two commercial Oenococcus oeni strains under different winemaking conditions regarding the type of alcoholic fermentation (spontaneous, induced) and the lees management (racked, on lees). Arginine degradation and citrulline formation did not occur during malic acid degradation in any treatment. In five of the six treatments in which arginine degradation took place, it occurred 3 weeks after malic acid depletion and significant amounts of citrulline were formed. Presence of yeast lees in wines led to increased citrulline formation. Conclusions: This study suggests that arginine metabolism is inhibited in oenococci at low pH values (< 3.5) and that in the postalcoholic fermentation phase, citrulline formation from arginine degradation can be avoided if MLF is induced by pure cultures of O. oeni with inhibition of the bacterial biomass after malic acid depletion. Residual yeast lees in the wine have been identified as a significant risk factor for increased citrulline formation. SIGNIFICANCE AND IMPACT OF THE STUDY: Conclusions drawn from this study allow reducing the risk of carcinogenic ethyl carbamate formation from citrulline excretion by wine lactic acid bacteria.     

Biochemical characterisation of the esterase activities of wine lactic acid bacteria

Esters are an important group of volatile compounds that can contribute to wine flavour. Wine lactic acid bacteria (LAB) have been shown to produce esterases capable of hydrolysing ester substrates. This study aims to characterise the esterase activities of nine LAB strains under important wine conditions, namely, acidic conditions, low temperature (to 10°C) and in the presence of ethanol (2–18% v/v). Esterase substrate specificity was also examined using seven different ester substrates. The bacteria were generally found to have a broad pH activity range, with the majority of strains showing maximum activity close to pH 6.0. Exceptions included an Oenococcus oeni strain that retained most activity even down to a pH of 4.0. Most strains exhibited highest activity across the range 30–40°C. Increasing ethanol concentration stimulated activity in some of the strains. In particular, O. oeni showed an increase in activity up to a maximum ethanol concentration of around 16%. Generally, strains were found to have greater activity towards short-chained esters (C2–C8) compared to long-chained esters (C10–C18). Even though the optimal physicochemical conditions for enzyme activity differed from those found in wine, these findings are of potential importance to oenology because significant activities remained under wine-like conditions.     

Continuous malolactic fermentation by Oenococcus Oeni entrapped in LentiKats

A continuous process to deacidify apple juices and cider was developed by entrapping Oenococcus oeni in LentiKats, a new polyvinyl alcohol hydrogel. For a residence time of 0.55 h, malic acid was completely converted into lactic acid when the LentiKats bioreactor was fed with apple juice at pH 4.46 and 3.95 and thirty three percent of initial malic acid (6.7 g l^–1) was converted when the initial apple juice pH was 2.30. The optimal malolactic activity of this bioreactor was obtained at 30°C and a 50% reduction in malic acid conversion was measured between 15°C and 20°C, at a residence time of 0.3 h. The LentiKats bioreactor gave better performance than continuous reactor with Oenococcus oeni immobilised in alginate beads (specific malic acid consumption increased by a factor of 4.6) due to the increase of the ratio external surface to volume, allowing better mass transfer.     

Dynamics of Indigenous Lactic Acid Bacteria Populations in Wine Fermentations from La Rioja (Spain) During Three Vintages

Diversity of lactic acid bacteria (LAB) species has been analyzed for three consecutive years (2006, 2007, and 2008) during alcoholic and malolactic fermentations of Tempranillo wine in a winery at La Rioja. The results showed differences in malolactic fermentation duration, and in both diversity of LAB species and diversity of Oenococcus oeni genotypes. O. oeni was shown to be the predominant species (73% of total isolates). Monitoring the different strains of O. oeni using pulsed-field gel electrophoresis of chromosomal DNA digested with SfiI and ApaI allowed detection of a total of 37 distinct genotypes, most of them comprised at least two isolates. Six appeared in more than one vintage, one of them being present in the three studied years. Moreover, four genotypes were indistinct of the strains isolated from the air of this same winery in 2007 vintage. The frequency of participation of each genotype varied from year to year, thus dominant genotypes at one year were minority or not present at another year. This suggests that distinct indigenous O. oeni strains are better adapted to the different winery conditions every year. Predominant genotypes that appeared in more than one vintage and lead to quality wines with low histamine contents could be considered as interesting for selecting of new malolactic starter cultures.     

In Vivo PCR-DGGE Analysis of <Emphasis Type="Italic">Lactobacillus plantarum</Emphasis> and <Emphasis Type="Italic">Oenococcus oeni</Emphasis> Populations in Red Wine

In order to monitor Lactobacillus plantarum and Oenococcus oeni in red wine produced with Italian grape (variety “Primitivo di Puglia”), a polymerase chain reaction– denaturing gradient gel electrophoresis (PCR-DGGE) approach using the rpoB as gene target was established. Wine was treated or not with potassium metabisulphite and supplemented with a commercial bacterial starter of O. oeni to encourage malolactic fermentation. Samples were taken from the vinification tanks at 4, 10, 16, 22, and 28 days after the start of alcoholic fermentation. Genomic DNA was directly isolated from wine and identification of lactic acid bacteria was performed using primers rpoB1, rpoB1O, and rpoB2 able to amplify a region of 336 bp corresponding to the rpoB gene. Amplified fragments were separated in a 30–60% DGGE gradient, and the ability of the PCR-DGGE analysis to distinguish L. plantarum and O. oeni was assessed. The results reported suggest that the PCR-DGGE method, based on the rpoB gene as molecular marker, is a reproducible and suitable tool and may be of great value for wine makers in order to monitor spoilage microorganisms during wine fermentation.     

Identification of pOENI-1 and Related Plasmids in Oenococcus oeni Strains Performing the Malolactic Fermentation in Wine

Plasmids in lactic acid bacteria occasionally confer adaptive advantages improving the growth and behaviour of their host cells. They are often associated to starter cultures used in the food industry and could be a signature of their superiority. Oenococcus oeni is the main lactic acid bacteria species encountered in wine. It performs the malolactic fermentation that occurs in most wines after alcoholic fermentation and contributes to their quality and stability. Industrial O. oeni starters may be used to better control malolactic fermentation. Starters are selected empirically by virtue of their fermentation kinetics and capacity to survive in wine. This study was initiated with the aim to determine whether O. oeni contains plasmids of technological interest. Screening of 11 starters and 33 laboratory strains revealed two closely related plasmids, named pOENI-1 (18.3-kb) and pOENI-1v2 (21.9-kb). Sequence analyses indicate that they use the theta mode of replication, carry genes of maintenance and replication and two genes possibly involved in wine adaptation encoding a predicted sulphite exporter (tauE) and a NADH:flavin oxidoreductase of the old yellow enzyme family (oye). Interestingly, pOENI-1 and pOENI-1v2 were detected only in four strains, but this included three industrial starters. PCR screenings also revealed that tauE is present in six of the 11 starters, being probably inserted in the chromosome of some strains. Microvinification assays performed using strains with and without plasmids did not disclose significant differences of survival in wine or fermentation kinetics. However, analyses of 95 wines at different phases of winemaking showed that strains carrying the plasmids or the genes tauE and oye were predominant during spontaneous malolactic fermentation. Taken together, the results revealed a family of related plasmids associated with industrial starters and indigenous strains performing spontaneous malolactic fermentation that possibly contribute to the technological performance of strains in wine.     

Bacterial biodiversity and dynamics during malolactic fermentation of Tempranillo wines as determined by a culture-independent method (PCR-DGGE)

The bacterial population during malolactic fermentation of Tempranillo wine was studied using the polymerase chain reaction-denaturing gradient gel electrophoresis, a culture-independent method successfully used for identification and monitoring of bacterial population in different habitats included food fermentations. The results showed that Oenococcus oeni was the predominant species in the malolactic fermentation of Tempranillo wines, although the presence of Gluconobacter oxydans, Asaia siamensis, Serratia sp., and Enterobacter sp. was also observed. These results were partly coincidental with those obtained from a culture-dependent method, using a selective medium. Therefore, it may be concluded that for a more complete knowledge of the bacterial community present during malolactic fermentation of Tempranillo wine, an approach that combines a culture-independent method and a culture-dependent method would be advisable.     

Evidence for exopolysaccharide production by Oenococcus oeni strains isolated from non‐ropy wines

Aims: The aim of this study was to assess the exopolysaccharide (EPS) production capacities of various strains of Oenococcus oeni, including malolactic starters and strains recently isolated from wine . Methods and Results: Fourteen O. oeni strains displaying or not (PCR check on genomic DNA) the gtf gene generally associated with β‐glucan formation and ropiness were grown on grape juice medium, dialysed MRS‐derived medium or synthetic medium. The soluble polysaccharides (PS) remaining in the culture supernatant were alcohol precipitated, and their concentration was quantified by the phenol‐sulfuric method. Most of the O. oeni strains studied produced significant amounts of EPS, independently of their genotype (gtf+ or gtf?). The EPS production was not directly connected with growth and could be stimulated by changing the growth medium composition. The molecular weight distribution analysis and attempts to determine the PS chemical structure suggested that most strains produce a mixture of EPS. Conclusion: Oenococcus oeni strains recently isolated from wine or cultivated for many generations as a malolactic starter are able to produce EPS other than β‐glucan. Significance and Impact of the Study: These EPS may enhance the bacteria survival in wine (advantage for malolactic starters) and may contribute to the wine colloidal equilibrium.     

Differential Real-Time PCR Assay for Enumeration of Lactic Acid Bacteria in Wine

Oenococcus oeni is often employed to perform the malolactic fermentation in wine production, while nonoenococcal lactic acid bacteria often contribute to wine spoilage. Two real-time PCR assays were developed to enumerate the total, and nonoenococcal, lactic acid bacterial populations in wine. Used together, these assays can assess the spoilage risk of juice or wine from lactic acid bacteria.