雨生红球藻的光周期效应

雨生红球藻(Haematococcus pluvialis)是一种单细胞淡水绿藻, 是自然界已知的中虾青素含量最高的生物物种。通过分析3种光照强度(70、120和300 μmol·m^–2·s^–1)下雨生红球藻细胞形态、生长速率和虾青素含量的差异, 对其光周期效应进行了研究。结果表明, 不同光强下适宜雨生红球藻生长的光周期均为16小时光照/8小时黑暗, 光强为120 μmol·m^–2·s^–1时其细胞生长速率最大, 为0.43 d^–1; 细胞内虾青素含量随着光强和光照时间的增加而增加, 在300 μmol·m^–2·s^–1光强下连续光照15天后, 藻细胞呈亮红色, 平均直径为21.02 μm, 最大虾青素值达39.40 pg·cell^–1。     

Multistage operation of airlift photobioreactor for increased production of astaxanthin from Haematococcus pluvialis

An internally radiating photobioreactor was applied for the production of astaxanthin using the unicellular green alga Haematococcus pluvialis. The cellular morphology of H. pluvialis was significantly affected by the intensity of irradiance of the photobioreactor. Small green cells were widespread under lower light intensity, whereas big reddish cells were predominant under high light intensity. For these reasons, growth reflected by cell number or dry weight varied markedly with light conditions. Even under internal illumination of the photobioreactor, light penetration was significantly decreased as algal cells grew. Therefore, we employed a multistage process by gradually increasing the internal illuminations for astaxanthin production. Our results revealed that a multistage process might be essential to the successful operation of a photobioreactor for astaxnthin production using H. pluvialis.     

Two-stage cultures for the production of astaxanthin from Haematococcus pluvialis

A two-stage culture system was established for the production of astaxanthin from Haematococcus pluvialis. In a first stage green vegetative cells were produced in semicontinuous cultures maintained with daily renewal rates between 10 and 40%. The steady-state cell density decreased with increasing renewal rates. Highest cell productivity, 64 x 10(6) cells l(-1) day(-1) was obtained with a daily renewal rate of 20%. In a second stage the harvested cultures were submitted to high light (240 micromol photon m(-2) s(-1)) under batch conditions for 15 days in order to stimulate the transition to the aplanospore stage and the accumulation of astaxanthin. No decrease in cell density was recorded during the induction period in any of the cultures. Cultures obtained at high renewal rates continued growing during the induction period and no astaxanthin was accumulated until all nitrogen in the media had been consumed. The final concentration of astaxanthin was inversely correlated to the growth rate at which first-stage cultures were maintained. Optimal renewal rate for maximal astaxanthin production depended on the duration of the induction period. After a 12-day induction period the highest astaxanthin production, 5.8 mg l(-1) of semi-continuous culture day -1, was obtained with cultures maintained at a renewal rate of 20%. When the induction period was increased to 15 days maximal astaxanthin productivity, 9.6 mg l(-1) of semi-continuous culture day -1, was obtained from cultures maintained at a renewal rate of 40% despite the much lower astaxanthin concentration achieved in these cultures. Results demonstrate the feasibility of semi-continuous cultivation of H. pluvialis for the two-stage production of astaxanthin.     

Stress-related differential expression of multiple beta-carotene ketolase genes in the unicellular green alga Haematococcus pluvialis

The unicellular green alga Haematococcus pluvialis is used as a biological production system for astaxanthin. It accumulates large amounts of this commercially interesting ketocarotenoid under a variety of environmental stresses. Here we report the identification and expression of three different beta-carotene ketolase genes (bkt) that are involved in the biosynthesis of astaxanthin in a single strain of the alga. Bkt1 and bkt2 proved to be the crtO and bkt previously isolated from two different strains of H. pluvialis. Bkt3 is a novel third gene, which shared 95% identical nucleotide sequence with bkt2. Nitrogen deficiency alone could not induce the alga cells to produce astaxanthin in 3 days even though it enhances the expression of the bkt genes to three times of that in normal growing cells within 16 h. High light irradiation (125 micromol m(-2)s(-1)) or 45 mM sodium acetate greatly increased the expression of bkt genes to 18 or 52 times of that in normal growing cells, resulting in an accumulation of substantial astaxanthin (about 6 mg g(-1) dry biomass) in 3 days. It is suggested that the existence of the multiple bkt genes and their strong up-regulation by different stress conditions is one of the reasons that H. pluvialis accumulates large amounts of astaxanthin in an instant response to stress environments.     

Photoautotrophic high-density cultivation of vegetative cells of Haematococcus pluvialis in airlift bioreactor

This work aimed to investigate the effects of the bioreactor configurations and their design variables on the cultivation of vegetative cells Haematococcus pluvialis to achieve sustainable high cell density. The addition of vitamin B to F1 growth medium could appreciably enhance the final cell density. Employing this medium, the cultivation in the airlift bioreactor was demonstrated to outperform the bubble column at the same operating conditions. Aeration was crucial for a proper growth of the alga in the airlift bioreactor, but it must be maintained at low level to minimize shear stress. The most appropriate aeration velocity (superficial velocity) was at the lower limit of the pump, i.e. 0.4 cm s(-1) and a smaller riser was shown to have positive influence on the cell growth. A 1% CO(2) supplement to the air supply considerably enhanced the growth rate of H. pluvialis and the most suitable light intensity for the growth was at 20 micromol photon m(-2) s(-1). The semi-continuous culture was successfully implemented with the optimal airlift bioreactor design and under optimal conditions the harvest could be performed every four days with the specific growth rate of 0.31 d(-1).     

氮胁迫对雨生红球藻色素积累与抗氧化系统的影响

选用雨生红球藻CG-06为试验藻株,以BBM为基础培养基,分别设置了0、13.7、27.5、41.2mg·L-1四个硝态氮浓度梯度,分析并探讨在不同硝态氮浓度条件下雨生红球藻生长、生理特性、细胞内主要色素含量的变化以及抗氧化酶活性。结果表明：细胞中色素的积累量和积累速率与初始硝态氮浓度成反比,与抗氧化酶活性呈负相关。缺氮时,培养到第3天的藻细胞中虾青素含量达到4.95μg·mg-1,而对照组在培养到第9天的细胞中才开始产生虾青素,而且在整个培养周期内细胞中的虾青素最大含量仅为4.17μg·mg-1。酶活测定结果显示,虾青素含量较高的红色细胞中,超氧化物歧化酶（SOD）、过氧化氢酶（CAT）和谷胱甘肽过氧化物酶（GSH-Px）的活性明显高于绿色细胞,且GSH-Px活性最高。研究表明,雨生红球藻可能有两种过氧化防御机制,绿色细胞阶段以抗氧化酶作用为主,在培养后期启动虾青素保护机制,两种机制具有协同作用。     

Efficient one-step production of astaxanthin by the microalga Haematococcus pluvialis in continuous culture

The performance of Haematococcus pluvialis in continuous photoautotrophic culture has been analyzed, especially from the viewpoint of astaxanthin production. To this end, chemostat cultures of Haematococcus pluvialis were carried out at constant light irradiance, 1,220 microE/m2.s, and dilution rate, 0.9/d, but varying the nitrate concentration in the feed medium reaching the reactor, from 1.7 to 20.7 mM. Both growth and biomass composition were affected by the nitrate supply. With saturating nitrate, the biomass productivity was high, 1.2 g/L.d, but astaxanthin accumulation did not take place, the C/N ratio of the biomass being 5.7. Under moderate nitrate limitation, biomass productivity was decreased, as also did biomass concentration at steady state, whereas accumulation of astaxanthin developed and the C/N ratio of the biomass increased markedly. Astaxanthin accumulation took place in cells growing and dividing actively, and its extent was enhanced in response to the limitation in nitrate availability, with a recorded maximum for astaxanthin cellular level of 0.8% of dry biomass and of 5.6 mg/L.d for astaxanthin productivity. The viability of a significant continued generation of astaxanthin-rich H. pluvialis cells becomes thus demonstrated, as also does the continuous culture option as an alternative to current procedures for the production of astaxanthin using this microalga. The intensive variable controlling the behavior of the system has been identified as the specific nitrate input, and a mathematical model developed that links growth rate with both irradiance and specific nitrate input. Moreover, a second model for astaxanthin accumulation, also as a function of irradiance and specific nitrate input, was derived. The latter model takes into account that accumulation of astaxanthin is only partially linked to growth, being besides inhibited by excess nitrate. Simulations performed fit experimental data and emphasize the contention that astaxanthin can be efficiently produced under continuous mode by adjustment of the specific nitrate input, predicting even higher values for astaxanthin productivity. The developed models represent a powerful tool for management of such an astaxanthin-generating continuous process, and could allow the development of improved systems for the production of astaxanthin-rich Haematococcus cells.     

Influence of sodium orthovanadate on the production of astaxanthin from green algae Haematococcus lacustris

Astaxanthin production is commonly induced under stress conditions such as nutrient deficiency (N or P), high light stress, and variations of temperature, high NaCl concentrations, and other factors. The objective of the present study is the analysis of the effect of oxidative stress by sodium orthovanadate (SOV), a nonspecific inhibitor of protein tyrosine phosphatases, on the cells growth and astaxanthin production of H. lacustris. In the presence of SOV (lower than 5.0 mM), maximum growth of H. lacustris obtained was 2.4 × 10⁵ cells/mL in MBBM medium at 24°C under continuous illumination (40 μE/m²/s) of white fluorescent light, with continuous aeration of CO₂ (0.2 vvm). Total carotenoids accumulated per cell biomass unit treated with 2.5 mM SOV has approximately shown 2.5 folds higher than the control after short period of SOV induction time as 2 days, despite that cells were grown under normal light. Meanwhile, maximal astaxanthin production from H. lacustris was 10.7 mg/g biomass in MBBM with 5 days of continuous illumination at 40 μE/m²/s, which has been established as optimal light intensity for the control culture of H. lacustris. Treating algae H. lacustris with sodium orthovanadate showed promoting the accumulation of astaxanthin by advancing either the inhibition of dephosphorylation or synthesis of ATP. Its potential role of PTPases in microalgae H. lacustris is discussed. The first two authors are equally contributed to this work.     

Comparative analysis of astaxanthin and its esters in the mutant E1 of Haematococcus pluvialis and other green algae by HPLC with a C30 column

A gradient reversed-phase high-performance liquid chromatography (HPLC) method using a C30 col-umn was developed for the simultaneous determination of astaxanthin, astaxanthin monoesters and astaxanthin diesters in the green algae Chlorococcum sp., Chlorella zofingiensis, Haematococcus plu-vialis and the mutant E1, which was obtained from the mutagenesis of H. pluvialis by exposure to UV-irradiation and ethyl methanesulphonate (EMS) with subsequent screening using nicotine. The re-sults showed that the contents of total astaxanthins including free astaxanthin and astaxanthin esters ranged from 1.4 to 30.9 mg/g dry biomass in these green algae. The lower total astaxanthin levels (< 2 mg/g dry biomass) were detected in the green algae Chlorococcum sp. and C. zofingiensis. The higher total astaxanthin levels (>16 mg/g dry biomass) were found in the green alga H. pluvialis and its mutant E1. It is notable that the mutant E1 is found to have considerably higher amounts of total astaxanthin (30.9 mg/g) as compared to the wild strain of H. pluvialis (16.1 mg/g). This indicates that UV-irradiation and EMS compound mutagenesis with subsequent screening using nicotine is an effective method for breeding of a high-producing astaxanthin strain of H. pluvialis. In addition, the green alga C. zofingien-sis had a remarkably higher percentage of astaxanthin diesters (76.3% of total astaxanthins) and a re-markably lower percentage of astaxanthin monoesters (18.0% of total astaxanthins) in comparison with H. pluvialis (35.5% for diesters and 60.9% for monoesters), the mutant E1 (49.1% and 48.1%) and Chlorococcum sp. (18.0% and 58.6%).     

Astaxanthin production by <Emphasis Type="Italic">Phaffia rhodozyma</Emphasis> and <Emphasis Type="Italic">Haematococcus pluvialis</Emphasis>: a comparative study

Phaffia rhodozyma (now Xanthophyllomyces dendrorhous) and Haematococcus pluvialis are known as the major prominent microorganisms able to synthesize astaxanthin natural pigment. Important research efforts have been made to determine optimal conditions for astaxanthin synthesis. When the focus is on astaxanthin production, the maximal reported value of 9.2 mg/g cell is obtained within H. pluvialis grown on BAR medium, under continuous illumination (345 μmol photon m⁻² s⁻¹) and without aeration. Whereas fermentation by mutated R1 yeast grown on coconut milk produced 1,850 μg/g yeast. However, when looking at astaxanthin productivity, the picture is slightly different. The figures obtained with P. rhodozyma are rather similar to those of H. pluvialis. Maximal reported values are 170 μg/g yeast per day with a wild yeast strain and 370 μg/g yeast per day with mutated R1 yeast. In the case of H. pluvialis, maximal values ranged from 290 to 428 μg/g cell per day depending on the media (BG-11 or BAR), light intensity (177 μmol photon m⁻² s⁻¹), aeration, etc. The main aim of this work was to examine how astaxanthin synthesis, by P. rhodozyma and H. pluvialis, could be compared. The study is based on previous works by the authors where pigment productions have been reported.     

Production of astaxanthin by Haematococcus pluvialis: taking the one-step system outdoors

The feasibility of a one-step method for the continuous production of astaxanthin by the microalga Haematococcus pluvialis has been verified outdoors. To this end, influence of dilution rate, nitrate concentration in the feed medium, and irradiance on the performance of continuous cultures of H. pluvialis was firstly analyzed indoors in bubble column reactors under daylight cycles, and then outdoors, using a tubular photobioreactor. At the laboratory scale, the behavior of the cultures agreed with that previously recorded in continuous illumination experiences, and attested that the major factors determining biomass and astaxanthin productivity were average irradiance and specific nitrate supply. The rate of astaxanthin accumulation was proportional to the average irradiance inside the culture, provided that a nitrate limiting situation had been established. The accumulation of astaxanthin under daylight cycles was maximal for a specific nitrate input of 0.5 mmol/g day. The recorded performance has been modeled on the basis of previously developed equations, and the validity of the model checked under outdoor conditions. Productivity values for biomass and astaxanthin of 0.7 g/L day and 8.0 mg/L day respectively, were obtained in a pilot scale tubular photobioreactor operating under continuous conditions outdoors. The magnitude of the experimental values, which matched those simulated from the obtained model, demonstrate that astaxanthin can be efficiently produced outdoors in continuous mode through a precise dosage of the specific nitrate input, taking also into consideration the average irradiance inside the culture.     

2,4-二氯苯氧乙酸(2,4-D)对雨生红球藻中虾青素积累的影响

本文初步研究了一定浓度范围内的2,4-D对雨生红球藻积累虾青素的影响.在对数生长 期的藻液中分别加入一系列不同浓度的2,4-D溶液,然后进行胁迫培养(25℃、24h、5000Lx连续光照 营养盐饥饿),诱导细胞内虾青素的合成积累.在诱导过程中,显微观察不同浓度2,4-D处理后细胞形态和虾青素积累的动态变化,并定期取样测定虾青素含量.结果表明,20.0mg/L的2,4-D能够明显促进雨生红球藻中积累虾青素.它不仅可以加快虾青素积累进程(比对照提前15 d),而且比对照能提高13.4%的虾青素产量.     

A novel double-layered photobioreactor for simultaneous Haematococcus pluvialis cell growth and astaxanthin accumulation

This study proposes a novel double-region photobioreactor to simplify the commercial two-stage process of astaxanthin production by the cultivation of Haematococcus pluvialis. The feasibility of the double-region photobioreactor has been investigated and found to achieve high biomass yield in the inner core region and simultaneous astaxanthin accumulation in the outer jacket region. Among many environmental factors, light condition and nitrate level were manipulated for selective cell growth and astaxanthin production. In the outer jacket region, efficient astaxanthin production was accomplished by excessive irradiation (770+/-20 microE m(-2)s(-1)) and nitrate starvation, resulting in a dramatic increase of astaxanthin productivity (357 mg l(-1)). Meanwhile, attenuated light energy (40+/-3 microE m(-2)s(-1)) and sufficient nitrates were supplied to the vegetative cells in the inner core region, which continued to grow to a high cell concentration of 4.0 x 10(5) cells ml(-1). The sequential batch run was performed by utilizing the high-density vegetative cells as inoculum for the next batch run. The cultivation results exhibited similar trends as the previous run, reaching high cell density (4.3 x 10(5) cells ml(-1)) in the inner core region and high astaxanthin content (5.79% on a dry weight basis) in the outer jacket region. The present study indicates that the double-region photobioreactor and its method of operation possess a good potential for commercial production of astaxanthin by H. pluvialis.     

Agricultural fertilizers as economical alternative for cultivation of Haematococcus pluvialis

A Haematococcus pluvialis strain isolated from the ruins of Ephesus in Turkey was investigated as regards its adaptation to laboratory conditions and maximum growth rate. In the first stage of the experiment, the growth of H. pluvialis was compared in common culture media. Furthermore, in an effort to minimize the culture costs, the second stage of the experiment compared the growth rate in the culture medium selected in the first stage with that in commercial plant fertilizers. The results demonstrated that the maximum cell concentration of 0.90 g/l, corresponding to a growth rate of 0.150 d(-1), was found with an N-P-K 20:20:20 fertilizer under a light intensity of 75 micromol photons m(-2) s(-1) on the 12th day of cultivation.     

Efficiency assessment of the one-step production of astaxanthin by the microalga Haematococcus pluvialis

Continuous cultivation of Haematococcus pluvialis under moderate nitrogen limitation represents a straightforward strategy, alternative to the classical two-stage approach, for astaxanthin production by this microalga. Performance of the one-step system has now been validated for more than 40 combinations of dilution rate, nitrate concentration in the feed medium, and incident irradiance, steady state conditions being achieved and maintained in all instances. Specific nitrate input and average irradiance were decisive parameters in determining astaxanthin content of the biomass, as well as productivity of the system. The growth rate of the continuous photoautotrophic cultures was a hyperbolic function of average irradiance. As long as specific nitrate input was above the threshold value of 2.7 mmol/g day, cells performed green and astaxanthin was present at basal levels only. Below the threshold value, under moderate nitrogen limitation conditions, astaxanthin accumulated to reach cellular levels of up to 1.1% of the dry biomass. Increasing irradiance resulted in enhancement of astaxanthin accumulation when nitrogen input was limiting, but never under nitrogen sufficiency. Mean daily productivity values of 20.8 +/- 2.8 mg astaxanthin/L day (1.9 +/- 0.3 g dry biomass/L day) were consistently achieved for a specific nitrate input of about 0.8 mmol/g day and an average irradiance range of 77-110 microE/m(2) s. Models relating growth rate and astaxanthin accumulation with both average irradiance and specific nitrate input fitted accurately experimental data. Simulations provided support to the contention of achieving efficient production of the carotenoid through convenient adjustment of the determining parameters, and yielded productivity estimates for the one-step system higher than 60 mg astaxanthin/L day. The demonstrated capabilities of this production system, as well as its product quality, made it a real alternative to the current two-stage system for the production of astaxanthin-rich biomass.     

雨生红球藻β－胡萝卜素酮化酶（bkt）启动子功能分析

单细胞绿藻———雨生红球藻在逆境条件下积累大量的虾青素。β-胡萝卜素酮化酶(bkt)催化在β-胡萝卜素和玉米黄素的β-紫罗酮环C-4位引入酮基的反应,是虾青素合成过程中的关键酶。我们利用凝胶阻滞的方法研究雨生红球藻中bkt基因309bp(-617/-309)启动子区域的转录因子结合位点并发现在-396/-338的59bp探针存在特异的核蛋白结合位点。通过序列分析,发现此59bp区域并不包含TATA或者CAAT-box,而是存在对光、缺氧、p-香豆酸及激素反应的G-box。     

Evaluation of factors promoting astaxanthin production by a unicellular green alga,Haematococcus pluvialis,with fractional factorial design

Factors affecting the astaxanthin production by a unicellular green alga, Haematococcus pluvialis UTEX 16, were evaluated with sequential fractional factorial design. To simulate an actual production mode, a two-stage process was adapted for astaxanthin production: the alga was first cultivated under vegetative growth conditions, and then astaxanthin production was induced by applying various induction methods. A high dose of irradiation was most effective for the production of astaxanthin both in weight (mg/g) and in cellular (pg/cell) contents. A combination of nitrogen deficiency and acetate addition also significantly increased the astaxanthin content of cells on a dry weight basis. Meanwhile, the acetate addition alone increased only the cellular content of astaxanthin. Although the addition of ferrous ion alone had a negative effect on the weight content of astaxanthin, simultaneous addition of ferrous ion and acetate was effective for increasing the cellular content of astaxanthin.     

利用雨生血球藻(Haematococcus pluvialis)生产天然虾菁素的研究进展

本文综述了当前国内、外利用雨生血球藻生产天然虾菁素的优化条件、雨生血球藻的大规模培养方法以及虾菁素的最佳提取工艺。     

UV-B辐射对雨生红球藻光合特性和虾青素含量的影响及其响应

实验研究了不同强度的UV-B(280-320 nm)辐射对雨生红球藻(Haematococcus pluvialis)的光合活性、生物量、色素含量、活性氧(ROS)含量和抗氧化酶活性等的影响, 以探讨利用UV-B辐射诱导虾青素生物合成增强的可能性。结果发现, 经UV-B辐射处理后,雨生红球藻的光合活性降低、生物量增长被抑制。UV-B辐射对叶绿素影响不大, 但会改变细胞的类胡萝卜素和虾青素含量:0.1和0.3 W/m2强度的UV-B辐射使细胞中的这两种色素含量升高, 0.5 W/m2组的色素含量短暂升高后恢复到对照水平。中低强度的UV-B可以促进雨生红球藻单细胞虾青素含量的增加, 但由于其对细胞生长的抑制作用, 并不能使虾青素大量积累。随辐射时间延长, 细胞内ROS含量未明显增加,但抗氧化酶(过氧化氢酶和超氧化物歧化酶)活性下降, 雨生红球藻可能主要依靠虾青素来淬灭ROS。以上结果表明, UV-B辐射对雨生红球藻的主要生理生化过程有抑制作用, UV-B辐射既可以诱导虾青素的合成又会消耗一部分虾青素, 对虾青素含量的影响与其强度有关, 而利用虾青素来清除细胞内的ROS可能是雨生红球藻抵御这种不利环境条件的最重要的途径。       

On the relative efficiency of two- vs. one-stage production of astaxanthin by the green alga Haematococcus pluvialis

Haematococcus pluvialis under stress conditions overproduces the valuable red ketocarotenoid astaxanthin. Two proposed strategies for commercial production are under current analysis. One separates in time the production of biomass (optimal growth, green stage) and pigment (permanent stress, red stage), while the other uses an approach based on continuous culture under limiting stress at steady state. The productivities, efficiencies and yields for the pigment accumulation in each case have been compared and analyzed in terms of the algal basic physiology. The two-stage system indoors yields a richer astaxanthin product (4% of dry biomass) with a final astaxanthin productivity of 11.5 mg L(-1) day(-1), is more readily upscalable and amenable to outdoors production. Furthermore, each stage can be optimized for green biomass growth and red pigment accumulation by adjusting independently the respective ratio of effective irradiance to cell density. We conclude that the two-stage system performs better (by a factor of 2.5-5) than the one-stage system, and the former is best fit in an efficient mass production setup.