Growth of Chaetomium cellulolyticum in solid-state fermentation of sugar cane bagasse treated with water and alkali at several liquid/solid ratios

Sugar cane bagasse was water- or alkali-treated at three liquid/solid (L/S) ratios and its digestibility was measured as microbial protein production of Chaetomium cellulolyticum grown on solid-state fermentation columns. The treatments significantly enhanced fungus growth compared to non-treated bagasse, which was used as a control, although the composition of bagasse did not change greatly. Alkali-treated bagasse reached an average protein content of about 7.6% and the lower the L/S ratio, the higher the protein content. L/S ratio did not have an effect in water-treated bagasse. Protein content of water-treated bagasse was also high, approximately 80% of that one of alkali-treated bagasse. Both treatments look promising to enhance sugar cane bagasse potential as an animal feed.Currently at Universidad Francisco de Miranda. Coro, Venezuela.Currently at Ciclo Básico, Facultad de Ingeniería, Universidad del Zulia. Maracaibo, Venezuela.     

Effect of nutritional factors on cellulase enzyme and microbial protein production by Aspergillus terreus and its evaluation

The biomass yield, cellulolytic activity, and protein recovery using Aspergillus terreus GN1 with alkali-treated sugarcane bagasse was studied using different levels (250-600 mg of N/L of broth) of organic and inorganic nitrogen sources. e.g., cattle urine, urea, cornsteep liquor, ammonium sulfate, ammonium nitrate, ammonium iron sulfate, ammonium chloride, and sodium nitrate. Among different levels of alkali-treated bagasse substrate concentrations (0.5-4.0% w/v) tested, 1.0% substrate yielded the highest crude protein content, protein recovery, and cellulolytic activity. The biomass recovery with 1.0% substrate ranged from 290-380 mg/500 mg bagasse substrate in a 50-mL broth with a nitrogen level of 250-600 mg of N/L in all the sources except ammonium iron sulfate, which yielded 402-439 mg/500 mg bagasse substrate. However, crude protein content of biomass obtained with an ammonium iron sulfate nitrogen source was the lowest. Cornsteep liquor nitrogen source at the rate of 600 mg of N/L yielded the maximum crude protein of 32.9%, protein recovery of 22.2 g/100 g of bagasse, and carboxymethyl cellulase and filter paper enzyme activities of 1.1 and 0.09 units/mL, among the organic and inorganic nitrogen sources studied. In general, the organic nitrogen sources and inorganic nonammonium nitrogen sources were utilized preferentially for protein production over the inorganic ammonium nitrogen sources. The fermentation time required under optimum cultural and nutritional conditions for A. terreus GN1 was also evaluated. The crude protein content of the biomass increased gradually up to the seventh day of fermentation, but the protein recovery rate was high up to two or three days. It was observed that the cellulose utilization rate increased after an initial lag of one day up to the third day and gradually increased further, which corresponded positively with protein content, biomass protein recovery, and cellulase enzyme activity. On the seventh day of fermentation, the crude protein content, biomass protein recovery, water-soluble carbohydrate, bagasse cellulose utilization, CMCase, and FPase activities were 32.8%, 20.1 g/100 g of bagasse, 6.2%, 82.7%, 1.0. and 0.08 U/mL, respectively. The final biomass recovered contained 32.8% crude protein content and had an in vitro rumen digestibility (IVRD) coefficient of 68.8%. The biomass contained almost all the essential and nonessential amino acids and was comparable with FAO reference protein. It is concluded that a fermentation time of 72 h gave a faster rate of protein production of 16.9 g/100 g of bagasse with 69.8% bagasse cellulose utilization with 76.0% IVRD. and contained almost all the essential and nonessential amino acids.     

Production of cellulases from alkali-treated bagasse in Trichoderma reesei

Summary Most of the mutants of Trichoderma reesei had good cellulase productivity on Avicel but this was low on alkali-treated bagasse, which could be a most promising cellulosic biomass to use as an inexpensive carbon source for cellulase production. Two T. reesei mutants, PC-3-7 and X-31, in which strong cellulase activity is inducible by l-sorbose, were, however, found to produce cellulase on alkali-treated bagasse. They produced about 100 units of CMCase per ml in 5-1 jar fermentor culture with 4% alkali-treated bagasse as carbon source. They also showed higher cellulase productivity than other mutants on other easily saccharified substrates, such as alkali-treated rice straw and Walseth's cellulose.Production of Ethanol from Biomasses Part IV.Production of Ethanol from Biomasses Part IV.     

Cellulolytic enzymes of a thermotolerantAspergillus terreus strain and their action on cellulosic substrates

A thermotolerant fungal strainAspergillus terreus produced high activities of cellulolytic enzymes when grown in shake flasks for 8 days at 40°C or 14 days at 28°C in medium containing 2.5% (w/v) cellulose powder and 1% (w/v) wheat bran. There was little difference between the final activities of endo-(1,4)--glucanase (ca. 14.4 U/ml); filter paper activity (ca. 1.3 U/ml) and -glucosidase (ca. 10 U/ml). Endoglucanase had maximum activity at 60°C and pH 3.8; the other two enzymes were optimal at 60°C and pH 4.8. The maximum hydrolysis of different cellulosic substrates (about 50%) was obtained within 48 h when 1.1 U/ml of filter paper cellulase activity were employed to saccharify 100 mg alkali-treated cotton, filter paper, bagasse, and rice straw at 50°C and pH 4.8. The major end-product, glucose, was produced from all substrates, with traces of cellobiose and other larger oligosaccharides being present in rice straw hydrolysates.     

Degradation of cellulosic materials by Sporotrichum thermophile culture filtrate for sugar production

Sporotrichum thermophile Apinis, was the most active carboxymethyl-cellulose (CMC)-ase producer among seven thermophilic and four thermotolerant fungal species isolated from Egyptian soil and screened for their ability to produce extracellular cellulase in culture media containing CMC as a sole carbon source. The fungus also efficiently hydrolysed filter paper cellulose. Comparison of various untreated and alkali-treated cellulosic and lignocellulosic materials as substrates for cellulase production by S. thermophile revealed the most easily degraded substrate was sugarcane bagasse at 2% concentration. This substrate when alkali treated was the most susceptible to enzymic hydrolysis by culture filtrates of S. thermophile grown on untreated bagasse. Optimum hydrolysis was obtained after 18 h incubation with the filtrate at pH 3·5–4 and 45°C. Alkali treatment of bagasse reduced its lignin content significantly and the culture filtrate of S. thermophile grown on untreated bagasse was found to contain xylanase and polygalacturonase in addition to cellulase and cellobiase.     

Protein enrichment of lignocellulose resulting from the growth of two Streptomyces strains

Two Streptomyces strains were grown on sugarcane bagasse and groundnut hulls lignocelluloses in semi-solid state culture at 37°C for 12 weeks. Best results gave a 45% depletion of sugarcane bagasse lignocellulose with a 21% crude protein content of final material. The possibility of using S. viridosporus to improve the protein content of both lignocelluloses for use as an animal feedstock supplement is discussed.At the time of this research the authors were with the Department of Biological Sciences, Rivers State University of Science & Technology, PMB 5080, Port Harcourt, Nigeria and the Department of Biological Sciences, University of Calabar, PMB 1115, Calabar, Nigeria. Dr lyo is now with the Department of Microbiology, University of Guelph, Guelph, Ontario N1G 2W1, Canada.     

Saccharification of cellulosic substrates byAspergillus niger cellulase

Chemical pre-treatment enhanced saccharification of agricultural lignocellulosic residues usingAspergillus niger cellulase by between 16 and 38%. Maximum saccharification (76%) of alkali-treated bagasse was with 0.5% substrate over 48 h using 0.3 U enzyme/ml.

---

Résumé Le pré-traitement chimique augmente de 16 à 38% la saccharification de résidus agricoles ligno-cellulosiques lorsque l'on utilise la cellulase d'Aspergillus niger. On a obtenu la saccharification maximum (76%) de la bagasse traitée à l'alcali avec 0.5% de substrat en 48 h de traitement avec 0.3 unités d'enzyme par ml.

     

Bioconversion of cellulose into ethanol by Clostridium thermocellum--product inhibition

Direct anaerobic bioconversion of cellulosic substances into ethanol by Clostridium thermocellum ATCC 27405 has been carried out at 60 degrees C and pH 7.0 (initial for 100 L) under continuous sparging of oxygen free nitrogen in a culture vessel. Raw bagasse, mild alkali-treated bagasse, and solka floc were used as substrates. The extent of conversion of raw bagasse (cellulose, 50%; hemicellulose, 25%; lignin, 19%) was observed as 52% (w/w) and 79% (w/w) in the case of mild alkali and steam-treated bagasse (cellulose, 72%; hemicellulose, 11%; lignin, 12%), respectively. Use of bagasse concentration above 10 g/L showed a decreased rate in ethanol production. An inoculum age between 28-30 h and cell mass content of 0.027-0.036 g/L (dry basis) were used. The results obtained with raw and pretreated bagasse have been compared with those of highly pure Solka Floc (hemicellulose, 10%). Studies on the product inhibition indicated a linear fall of the percent of survivors with time. An Arrhenius type correlation between the cell decay rate constant and the product concentration was predicted. Even at low levels, the inhibitory effects of products on cell viability, the specific growth rate, and extracellular cellulase enzyme were observed.     

Use of sugarcane bagasse as an alternative low-cost support material during the rooting stage of apple micropropagation

Summary Studies were carried out to evaluate sugarcane bagasse as an alternative to agar for micropropagation of apple clones to reduce the cost of micropropagation and improve the quality of the propagules. Significant improvement in the in vitro rooting process, coupled with cost reduction, were obtained by the use of sugarcane bagasse as a substitute for the traditionally used agar-gelled medium. The tests were undertaken with micro-cuttings of the apple rootstock Marubakaido (Malus prunifolia Borkh.) using a rooting medium composed of half-strength Murashige and Skoog salts and vitamins, 3% (w/v) sucrose, and 0.49 μM indole-3-butyric acid. The plants grown on sugarcane bagasse yielded a 22% increase in root length, 20% increase in plant length, and 63% increase in the number of roots, compared with agar-grown micro-cuttings. Particle size of the sugarcane bagasse had a significant impact on all those parameters, and the best results were obtained with bagasse comprising particles smaller than 0.18 mm. The results demonstrated that the sugarcane bagasse could be used effectively as a substitute for agar during rooting of apple shoots.     

Influence of ethanol on the activities of 3-hydroxy-3-methylglutaryl-coenzyme A-reductase and squalene-hopene-cyclase in Zymomonas mobilis

Summary The influence of different primary aliphatic alcohols on the activities of two key enzymes in hopanoid biosynthesis of Zymomonas mobilis was investigated. By use of ¹⁴C- and ³H-labelled substrates the enzymes 3-hydroxy-3-methylglutaryl-CoA-reductase and squalene-hopenecyclase were detected with activities of 1.6 pmol x (min x mg protein)^-1 and 2.3 pmol x- (min x mg protein)^-1, respectively. Cells grown in the presence of 6% (v/v) ethanol did not show higher activities of these enzymes than cells grown in the presence of 1% (v/v) ethanol. Furthermore, 3-hydroxy-3-methylglutaryl-CoA-reductase was not activated by ethanol. However, ethanol activated the squalene-hopene-cyclase when added to the enzyme test system. Besides ethanol, propanol also had a positive effect on the squalene-hopene-cyclase: the enzyme's activity increased 1.7-fold in the presence of either alcohol at a concentration of 6% (v/v). This corresponded with a similar increase of hopanoid content of whole cells when grown in the presence of 6% (v/v) added ethanol or propanol. These results indicated that the squalene-hopene-cyclase has a regulatory function in the alcohol dependent hopanoid biosynthesis of Z. mobilis.Abbreviation HMG-CoA-reductase 3-hydroxy-3-methylglutaryl-coenzyme A-reductase     

Evaluation of holocellulase production by plant-degrading fungi grown on agro-industrial residues

Agaricus brasiliensis CS1, Pleurotus ostreatus H1 and Aspergillus flavus produced holocellulases when grown in solid and submerged liquid cultures containing agro-industrial residues, including sugar cane bagasse and dirty cotton residue, as substrates. These isolates proved to be efficient producers of holocellulases under the conditions used in this screening. Bromatological analysis of agro-industrial residues showed differences in protein, fiber, hemicellulose, cellulose and lignin content. Maximal holocellulase activity (hemicellulase, cellulase and pectinase) was obtained using solid-state cultivation with 10% substrate concentration. In this case, remarkably high levels of xylanase and polygalacturonase activity (4,008 and 4,548 IU/l, respectively) were produced by A. flavus when grown in media containing corn residue, followed by P. ostreatus H1 with IU/l values of 1,900 and 3,965 when cultivated on 5% and 10% sugar cane bagasse, respectively. A. brasiliensis CS1 showed the highest reducing sugar yield (11.640 mg/ml) when grown on medium containing sugar cane bagasse. A. brasiliensis was also the most efficient producer of protein, except when cultivated on dirty cotton residue, which induced maximal production in A. flavus. Comparison of enzymatic hydrolysis of sugar cane bagasse and dirty cotton residue by crude extracts of A. brasiliensis CS1, P. ostreatus H1 and A. flavus showed that the best reducing sugar yield was achieved using sugar cane bagasse as a substrate.     

Production of SCP and cellulase by Aspergillus terreus from bagasse substrate

The fermentation of 1.0% untreated bagasse under optimum cultural and nutritional conditions with Aspergillus terreus GN1 indicated that the maximum rate of protein and cellulase production could be obtained during three days of submerged fermentation. Even though 16.4% protein recovery, 0.55 units CMCase/mL, and 0.027 FPase units/mL were obtained on the seventh day, the rates of increase in protein recovery and cellulase production were slower than those obtained up to these days, which were 14.3% protein recovery, 0.45 units CMCase/mL, and 0.019 units FPase/mL. There was an initial lag in the utilization of cellulose up to two days due to the utilization of the water-soluble carbohydrate present in untreated bagasse. Cellulose utilization and water-soluble carbohydrate content during fermentation were correlated with protein recovery and enzyme production. The protein and cellulase production during three days fermentation with 1.0% untreated and treated bagasse were compared and the protein content of the total biomass was calculated and treated bagasse were compared and the protein content of the biomass was calculated into constituent protein contributed by the fungal mycelium and the under graded bagasse. The total biomass recovered with untreated and treated bagasse was 1020 and 820 mg/g bagasse substrate, respectively, and contained 14.3 and 20.6% crude protein, respectively. The contribution of fungal biomass and under graded bagasse was 309 and 711, and 373 and 447 mg/g untreated and treated bagasse substrates, respectively. In an 8-L-flask trial during three days of fermentation, the recovery of SCP and cellulase were 66 g and 32,400 units (Sigma) for treated bagasse and 82 g and 8200 units (Sigma) for untreated bagasse, respectively.     

Influence of the burning of sugar cane prior to its harvesting upon the production of single-cell protein from bagasse pith

Summary A culture of Cellulomonas sp. and Bacillus subtilis was grown using sugar cane bagasse pith from unburnt sugar cane (UCP) as the source of carbohydrates. The yield and production values were proved to be higher than those obtained with burnt sugar cane (BCP).For UCP the maximum protein production was 7.8 g/l, the cellulolytic activity being 70 %, with a protein/hydrolyzed pith yield of 22 %. For BCP, the maximum protein value was 4.6 g/l, with a cellulolytic activity of 55 % and a protein/hydrolyzed pith of 17 %.The possibility of a chemical inhibitor being present in BCP is discarded because of the alkaline pretreatment and the results obtained on treating the pith from burnt cane with a benzene-ethanol (2:1) mixture. These results were the same as the ones obtained without the benzene-ethyl alcohol mixture extraction.     

Evaluation of different alkali treatments of bagasse pith for cultivation of Cellulomonas sp.

Biomass production of Cellulomonas was optimal with 1% (w/v) bagasse pith pre-treated with either 0.2 M NaOH for 1 h at 80°C or 0.4 M NaOH for 40 h at 28 to 30°C. Growth was similar to that obtained with a more severe treatment used as control and compared well with other reports for cellulolytic bacteria cultivated on pre-treated bagasse pith.     

Extracellular enzyme production byThermomonospora curvata grown on bagasse

Summary Extracellular enzyme production by the actinomycete,Thermomonospora curvata, was characterized during growth at 55°C on bagasse as sole carbon source. Mycelia adhered to the bagasse fibers during early growth and were released in mature cultures. Extracellular protein reached a maximum on 4% (w/v) bagasse and yielded an electrophoretic profile similar to those produced on purified cellulose. Cellulase production on bagasse exceeded that observed forT. curvata on any previously employed substrate. Amylase and pectinase, which were diminished by their instability in culture fluid at growth temperature and by the lack of inducing substrate, were readily inducible by addition of starch or pectin, respectively. Extracellular activities of -glucosidase and -xylosidase remained insignificant throughout growth. Xylanase production equaled or exceeded that observed on a variety of other substrates. The combined activity of extracellular enzymes from bagasse-grownT. curvata caused a 27% solubilization of the fiber, yielding a mixture of cellooligosaccharides, cellobiose, xylobiose, glucose, xylose, fructose, arabinose and mannitol. Fractionation of concentrated extracellular proteins by size exclusion chromatography yielded single peaks for amylase and pectinase (estimated molecular weights of 58 K and 34 K respectively), while cellulase and xylanase activities were distributed throughout a series of multiple unresolved peaks spanning a molecular weight range of 26–180 K.     

四种添加物对铁皮石斛原球茎生长及多糖含量的影响

为探讨铁皮石斛(Dendrobium officinale)培养基中添加物的作用,在1/2MS培养基中加入椰肉、甘蔗渣、香蕉皮和麦麸等4种添加物,研究不同浓度添加物和培养时间对原球茎生长和多糖含量的影响。结果表明,4种添加物对铁皮石斛原球茎的增殖、分化和多糖含量均有一定影响,其中添加15.0 g L–1甘蔗渣,培养60 d能明显促进铁皮石斛原球茎的增殖与分化(146.1%);而添加20.0 g L–1甘蔗渣,培养40 d能显著提高铁皮石斛原球茎多糖含量(50.4%)。这说明甘蔗渣是培养铁皮石斛原球茎的适宜添加物,既能促进铁皮石斛原球茎的生长发育,还能降低生产成本。     

Xylanase production using inexpensive agricultural wastes and its partial characterization from a halophilic <Emphasis Type="Italic">Chromohalobacter</Emphasis> sp. TPSV 101

A halophilic and alkali-tolerant Chromohalobacter sp. TPSV 101 with an ability to produce extracellular halophilic, alkali-tolerant and moderately thermostable xylanase was isolated from solar salterns. Identification of the bacterium was done based upon biochemical tests and 16S rRNA sequence. The culture conditions for higher xylanase production were optimized with respect to NaCl, pH, temperature, substrates and metal ions and additives. Maximum xylanase production was achieved in the medium with 20% NaCl, pH-9.0 at 40°C supplemented with 1% (w/v) sugarcane bagasse and 0.5% feather hydrolysate as carbon and nitrogen sources. Sugarcane bagasse (250 U/ml) and wheat bran (190 U/ml) were the best inducer of xylanase when used as carbon source as compared to xylan (61 U/ml). The xylanase that was partially purified by protein concentrator had a molecular mass of 15 kDa approximately. The xylanase from Chromohalobacter sp. TPSV 101 was active at pH 9.0 and required 20% NaCl for optimal xylanolytic activity and was active over a broad range of temperature 40–80°C with 65°C as optimum. The early stage hydrolysis products of sugarcane bagasse were xylose and xylobiose, after longer periods of incubation only xylose was detected.     

Variations of two pools of glycogen and carbohydrate in <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis> grown with various ethanol concentrations

Glycogen, a major reservoir of energy in Saccharomyces cerevisiae, is found to be present as soluble and membrane-bound insoluble pools. Yeast cells can store excess glycogen when grown in media with higher concentration of sugar or when subjected to nutritional stress conditions. Saccharomyces cerevisiae NCIM-3300 was grown in media having ethanol concentrations up to 12% (v/v). The effects of externally added ethanol on glycogen and other carbohydrate content of yeast were studied by using alkali digestion process. Fermentative activities of cells grown in the presence of various ethanol concentrations (2–8% v/v) exhibited increase in values of glycogen and other carbohydrate, whereas cells grown with higher concentrations of ethanol (10–12% v/v) exhibited depletion in glycogen and carbohydrate content along with decrease in cell weight. Such inhibitory effect of ethanol was also exhibited in terms of reduction in total cell count of yeast grown in media with 2–16% (v/v) ethanol and 8% (w/v) sugar. These data suggest that, as the plasma membrane is a prime target for ethanol action, membrane-bound insoluble glycogen might play a protective role in combating ethanol stress. Elevated level of cell-surface α-glucans in yeast grown with ethanol, as measured by using amyloglucosidase treatment, confirms the correlation between ethanol and glycogen.     

Action of Trichoderma reesei QM9414 and C30 cellulase on substrates with varying crystallinity

The action of cellulase [see 1,4-(1,3;1,4)-β-d-glucan 4-glucanohydrolase, EC 3.2.1.4] preparations from Trichoderma reesei QM9414 and C30 has been compared on Sigmacell, Solka Floc and alkali-treated bagasse in the presence and absence of added d-glucose and cellobiose. On the basis of equal filter paper activity the two preparations acted similarly on the two cellulosic substrates, while in the case of alkali-treated bagasse the C30 preparation gave greater d-glucose release. The relative levels of cellobiose produced from alkali-treated bagasse suggests that the non-cellobiose route was more important in d-glucose release by the C30 preparation compared to the QM9414 preparation.     

Rhizopus oligosporus grown on natural rubber waste serum for production of single cell protein: a preliminary study

Maximum production of mycelium and utilization of total organic carbon byR. oligosporus grown on natural rubber waste serum was achieved at 28°C with an inoculum size of 7.5% (v/v) and grown for 144 h with an initial pH of 4.0. The maximum production of total crude protein, however, was when culture medium was inoculated with 2% (v/v) of spore suspension under the same conditions. Natural rubber waste serum may be a potential substrate for the production of single cell protein.