The survival of Listeria monocytogenes in cottage cheese

Because of the difficulty of ensuring that cottage cheese is produced in conditions that prevent contamination with Listeria monocytogenes, the ability of this bacterium to survive in cottage cheese from three sources was investigated (a) during shelf-life at chill temperature and (b) in conditions of temperature abuse. Three batches of creamed cottage cheese, from three sources, received within 24 h of production, were inoculated with L. monocytogenes strain F6861 and stored at 4, 8 or 12 degrees C for 14 d. The three batches differed in their initial pH, titratable acidity and content of lactic acid and of lactic acid bacteria. No increase in numbers of L. monocytogenes occurred in the cottage cheeses during storage in these conditions. The numbers of listeria decreased; the rate of decrease differed in products from the three sources and was least in the product with the highest pH and lowest content of lactic acid. Acid formation by lactic acid bacteria during storage of the products probably contributed to the inhibition of listeria.     

The effect of nisin on Listeria monocytogenes in culture medium and long-life cottage cheese

M.A.S.S. FERREIRA AND B.M. LUND. 1996. The sensitivity to nisin of 27 strains of Listeria monocytogenes , four of L. innocua and one of L. ivanovii was estimated at pH 6.8 and pH 5.5. Strains of L. monocytogenes showed differences in sensitivity which were not correlated with serotype. Strains of L. innocua were as resistant as the most resistant strains of L. monocytogenes , whereas the strain of L. ivanovii was relatively sensitive. Two of the most resistant strains of L. monocytogenes multiplied in aerated liquid medium adjusted to pH 5.0 with HCl, incubated at 20°C; nisin, 500 IU ml^-1, prevented multiplication and caused death. Following inoculation of a resistant strain into long-life cottage cheese, pH 4.6–4.7, the number of viable L. monocytogenes decreased approximately 10-fold during storage at 20°C for 7 d; addition of nisin, 2000 IU g^-1, to the cottage cheese increased the rate of inactivation to approximately a 1000-fold decrease in 3 d.     

The impact of nisin on sensitive and resistant mutants of Listeria monocytogenes in cottage cheese

Aims: Listeria monocytogenesΔgadD1 and ΔlisK mutants display enhanced and reduced sensitivity, respectively, to the food preservative nisin in laboratory media. However, the behaviour of these strains in a nisin‐containing food has not been assessed. Here we use cottage cheese as a model food to address this issue. Materials and Results: Antibiotic‐resistant forms of the wild‐type and mutant strains were employed to investigate the behaviour of multiple strains in a single food sample, thereby eliminating the problem of intersample variation. Using this approach, it was established that percentage survival of the ΔlisK mutant was greater than the parent strain in the absence of nisin and that this relative difference became even more dramatic in cottage cheese supplemented with nisin. The numbers of the ΔgadD1 mutant decreased more rapidly than the parent in cottage cheese without nisin, but surprisingly this trend was reversed in nisin‐supplemented cheese. Upon the addition of 10 mmol l^?1 monosodium glutamate, a substrate for the glutamate decarboxylase (GAD) system, the wild‐type LO28 strain regained its relative advantage over ΔgadD1. Conclusions: Care needs to be taken when predicting the behaviour of mutants of L. monocytogenes with altered resistance to nisin in food as experiments in laboratory media are not always a good indicator of how the strains will behave in such food environments. Significance and impact of the Study: This study further emphasizes the importance of utilizing food matrices to confirm observations made using laboratory media.     

Inhibition of Listeria monocytogenes in cottage cheese manufactured with a lacticin 3147-producing starter culture

The efficacy of using a lacticin 3147-producing starter as a protective culture to improve the safety of cottage cheese was investigated. This involved the manufacture of cottage cheese using Lactococcus lactis DPC4268 (control) and L. lactis DPC4275, a bacteriocin-producing transconjugant strain derived from DPC4268. A number of Listeria monocytogenes strains, including a number of industrial isolates, were assayed for their sensitivity to lacticin 3147. These strains varied considerably with respect to their sensitivity to the bacteriocin. One of the more tolerant strains, Scott A, was used in the cottage cheese study; the cheese was subsequently inoculated with approximately 10(4) L. monocytogenes Scott A g-1. The bacteriocin concentration in the curd was measured at 2560 AU ml-1, and bacteriocin activity could be detected throughout the 1 week storage period. In cottage cheese samples held at 4 degrees C, there was at least a 99.9% reduction in the numbers of L. monocytogenes Scott A in the bacteriocin-containing cheese within 5 d, whereas in the control cheeses, numbers remained essentially unchanged. At higher storage temperatures, the kill rate was more rapid. These results demonstrate the effectiveness of lacticin 3147 as an inhibitor of L. monocytogenes in a food system where post-manufacture contamination by this organism could be problematic.     

Improved detection of Listeria monocytogenes in soft mould-ripened cheese

In comparison with standard methods, enrichment in half-Fraser broth for 24 h at 30 degrees C, followed by plating out onto Listeria monocytogenes blood agar (LMBA) and PALCAM medium combined with an additional streak proved to be the most rapid and specific method for the detection of indigenous L. monocytogenes populations from soft mould-ripened cheese. This procedure, with a high sensitivity (93%) and a low detection limit (1-10 cfu 25 g-1), provided negative and presumptive positive results within 2-3 d. Differences between LMBA, PALCAM and Oxford medium turned out to be highly significant (at 99% significance level); plating on LMBA after standard enrichment protocols giving the best overall results. An improvement in detection was also obtained by modifying the confirmation procedure. A loopful of culture (an additional streak) from PALCAM or Oxford medium was streaked on non-selective medium in addition to streaking only separate colonies as specified in the standards.     

The growth of Listeria monocytogenes in cheese packed under a modified atmosphere

The effect of modified atmosphere Packaging (MAP) on the growth of Listeria monocytogenes in mould ripened cheeses was studied at refrigeration temperatures (2-8.3 degrees C) over a storage period of 6 weeks. Control experiments in cling film with no atmospheric modification produced a lag time before growth of up to 1 week and rapid subsequent growth. MAP with a CO2 concentration of less than 20% allowed growth to occur but when O2 was incorporated; the lag time was reduced from 3 to 2 weeks and subsequent growth was also faster, producing an increase in cell numbers of 1.4 log cycles over the incubation period. N2-MAP in the absence of O2 increased the lag time to 3 weeks and slowed growth, while the inclusion of CO2 extended the lag to 3 weeks and slowed subsequent growth even more. In MAP with 80:10:10 (v/v/v) N2:CO2:O2, there was a lag period of 2-3 weeks before growth of L. monocytogenes occurred, while the total viable aerobic count (TVAC) decreased by 2-3 log cycles and the total Lactobacillus count showed little change. It was concluded that MAP was not suitable for preventing the growth of L. monocytogenes in such cheeses.     

Behaviour of Listeria monocytogenes in packaged water buffalo mozzarella cheese

Aims: The aim of the study was to evaluate the behaviour of Listeria monocytogenes in the conditioning liquid of packaged water buffalo mozzarella cheese (WBMC). Methods and Results: The conditioning liquid was contaminated with L. monocytogenes, and the contaminated samples were stored at four different storage temperatures: 5 and 10°C for 22 days; 20°C for 9 days; 20°C for 3 days and then at 5°C for 6 days. The results showed that L. monocytogenes concentration decreased when contaminated samples were stored at 5°C. When WBMC was stored at 20°C and at 10°C, L. monocytogenes started to grow after a lag phase of 3 and 10 days, respectively. When samples were stored at variable temperature conditions, L. monocytogenes numbers showed a lag phase of 5 days. Conclusions: Use of a conditioning liquid characterized by acidity and a correct storage temperature is able to counteract pathogen replication during shelf life. A high concentration of lactic acid bacteria was associated with effective control of L. monocytogenes but the role of lactic acid bacteria in WBMC conditioning liquid requires further investigation. Significance and Impact of the Study: According to European regulations, food producers should be able to justify decision‐making on the shelf life assigned to their products, taking into account reasonable storage conditions and use by consumers. The results of the trial yielded information for producers of WBMC and similar cheeses for decision‐making on product shelf life.     

Methods for improved recovery of Listeria monocytogenes from cheese

Method of homogenization (Waring blender versus stomacher), type of diluent (tryptose broth [TB] versus aqueous 2% trisodium citrate), and temperature of diluent (20 versus 40 degrees C) were compared for recovery of Listeria monocytogenes from freshly made and ripened Colby cheese. By using direct plating on McBride listeria agar, significantly higher numbers of L. monocytogenes were recovered when cheese samples were (i) homogenized for 2 min with the blender rather than the stomacher (P less than 0.01), (ii) diluted in trisodium citrate rather than TB (P less than 0.01), and (iii) diluted in diluents at 40 rather than 20 degrees C (P less than 0.05). Based on these results, a new diluent/enrichment medium was developed by adding 2% trisodium citrate to TB (TBC). Despite superior results with the blender, biosafety concerns led to use of the stomacher for homogenization of cheese samples; hence, the stomaching time was increased to 3 min. Results obtained by direct plating indicated that recovery of L. monocytogenes from Colby cheese and from curd samples taken during manufacture of brick cheese increased when samples were diluted 1:10 in TBC at 45 degrees C and stomached for 3 min, as compared with similarly treated samples diluted in TB at 25 degrees C. A similar comparison of both diluents for recovery of L. monocytogenes from cold-pack cheese food yielded bacterial counts which were not significantly different. Recovery of L. monocytogenes from cold-enriched (at 4 degrees C for up to 8 weeks) samples of Colby cheese and cold-pack cheese food was generally similar for samples homogenized in TBC or TB.     

Methods for improved recovery of Listeria monocytogenes from cheese.

Method of homogenization (Waring blender versus stomacher), type of diluent (tryptose broth [TB] versus aqueous 2% trisodium citrate), and temperature of diluent (20 versus 40 degrees C) were compared for recovery of Listeria monocytogenes from freshly made and ripened Colby cheese. By using direct plating on McBride listeria agar, significantly higher numbers of L. monocytogenes were recovered when cheese samples were (i) homogenized for 2 min with the blender rather than the stomacher (P less than 0.01), (ii) diluted in trisodium citrate rather than TB (P less than 0.01), and (iii) diluted in diluents at 40 rather than 20 degrees C (P less than 0.05). Based on these results, a new diluent/enrichment medium was developed by adding 2% trisodium citrate to TB (TBC). Despite superior results with the blender, biosafety concerns led to use of the stomacher for homogenization of cheese samples; hence, the stomaching time was increased to 3 min. Results obtained by direct plating indicated that recovery of L. monocytogenes from Colby cheese and from curd samples taken during manufacture of brick cheese increased when samples were diluted 1:10 in TBC at 45 degrees C and stomached for 3 min, as compared with similarly treated samples diluted in TB at 25 degrees C. A similar comparison of both diluents for recovery of L. monocytogenes from cold-pack cheese food yielded bacterial counts which were not significantly different. Recovery of L. monocytogenes from cold-enriched (at 4 degrees C for up to 8 weeks) samples of Colby cheese and cold-pack cheese food was generally similar for samples homogenized in TBC or TB.     

Effect of enterocin CCM 4231 on Listeria monocytogenes in Saint-Paulin cheese

The bacteriocin production byEnterococcus faecium strain in cheese milk and cheese was demonstrated. Purified enterocin CCM 4231 exhibited an anti-listerial effect during Saint-Paulin cheese manufacture. During cheese production the strain grew to a final concentration of 10.1±0.01 log CFU per mL per g in cheese. Then only a slight decrease of the cell concentration was noticed during ripening and was almost stable for 8 weeks. No significant differences in pH were observed between the experimental and reference cheeses. Bacteriocin production during cheese manufacture was detected only in milk samples and curd, reaching a level of 100 AU/mL. After addition of purified enterocin CCM 4231 (concentration 3200 AU/mL) into the experimental cheese, the initial concentration of 6.7±0.06 log CFU per mL ofListeria monocytogenes Ohio was reduced up to 1.9±0.01 log CFU per mL per g. After 6 weeks and at the end of the experiment the difference of surviving cells ofL. monocytogenes Ohio in ECH was only one or 0.7 log cycle compared to the control cheese. Although enterocin CCM 4231 partially inhibitedL. monocytogenes in Saint-Paulin cheese manufacture, an inhibitory effect of enterocin added was shown in 1-week cheese; however, it was not possible to detect bacteriocin activity by the agar spot test. The traditional fermentation and ripening process was not disturbed, resulting in acceptable end-products, including sensory aspects.     

The sophisticated survival strategies of the pathogen Listeria monocytogenes.

The function of the ActA protein of Listeria monocytogenes has been partially elucidated. These results illustrate the sophistication with which intracellular pathogens like Listeria use the host cell to their advantage, and have provided new insights into some of the molecular mechanisms of complex cell functions such as actin-promoted cell motility. The clarification of these processes is of fundamental importance not only for understanding elementary processes such as development and growth, but also for the treatment of both diseases caused by cytopathogenic bacteria such as Listeria and pathophysiological processes arising from disorders in cell motility and cell adhesion.     

Fate of Listeria monocytogenes during manufacture and ripening of semi-hard cheese

Semi-hard cheeses were experimentally elaborated with pasteurized milk from sheep, goat and cow (15: 35: 50) and inoculated to contain 1.9 times 10⁵ Listeria monocytogenes /ml in cheeses 1 and 2 and 4 times 10³ L. monocytogenes /ml in cheeses 3 and 4. Counts of L. monocytogenes were determined by direct surface plating of samples on listeria selective agar medium. The results show the substantial survival of L. monocytogenes present in milk during manufacture and ripening of this type of cheese.     

Comparison of growth limits of Listeria monocytogenes in milk,broth and cheese

Aim: To determine growth initiation differences of Listeria monocytogenes between a cheesemaking context, milk and tryptic soy broth (TSB). Methods and Results: A laboratory‐scale cheese was made with a mix of two strains of L. monocytogenes at four initial pH values, five water activity (a_w) values and two contamination levels at 30°C. Counts of L. monocytogenes were determined at time 0 and after 8 h of cheese manufacture. Milk and TSB at the same pH and a_w conditions were inoculated with the L. monocytogenes mix in multi‐well plates. Growth was determined by plating each well onto Agosti & Ottaviani Listeria Agar after 8 h of incubation at 30°C. Each condition was repeated six times, and growth initiation probability was modelled with logistic regression models. Growth initiation boundaries were obtained for each matrix type. The results showed that the growth limits were matrix dependent. In the three matrix types, a_w was the most important factor affecting the probability of growth initiation. Contamination level affected growth TSB and cheesemaking conditions. Conclusions: The interface wideness and position in cheese, milk and TSB were dissimilar, indicating that the use of models evaluated in TSB or milk could not be used to predict the behaviour of L. monocytogenes under cheesemaking conditions. Significance and Impact of the Study: Predictive models generated in liquid media are not necessarily adaptable to solid food, and the generation of real food models is necessary.     

Behaviour of Listeria monocytogenes during the traditional manufacture of water-buffalo Mozzarella cheese

F. VILLANI, O. PEPE, G. MAURIELLO, G. MOSCHETTI, L. SANNINO AND S. COPPOLA. 1996. The behaviour of a four-strains mixture of Listeria monocytogenes (strains Scott A, V7, OH and Cal) during the traditional manufacture of water-buffalo Mozzarella cheese was investigated at two levels of inoculation: ca 10⁵and 10³cfu ml^-1of vat milk. No significant change in Listeria counts was observed during the curd ripening (4.0–4.5 h), at the end of which the pH ranged between 4.83 and 4.91. A decrease of about 2 log was observed after stretching of the curd in hot water (95°C), followed by complete elimination of Listeria after 48 and 24 h of storage of the final cheese in the conditioning liquid (skim water resulting from the stretching, pH ca 4.0) with initial high and low contamination of the cheese milk respectively. Results also indicated that a 1.7 log reduction of L. monocytogenes could be achieved during the preparation of the natural whey culture utilized as starter in cheesemaking.     

Epigallocatechin gallate inhibits intracellular survival of Listeria monocytogenes in macrophages

Epigallocatechin gallate (EGCg), the major tea catechin, is known as a potent anti-microbial and anti-tumor compound. The effects of EGCg on host defense mechanisms against Listeria monocytogenes infection were examined in vitro using mouse peritoneal exudate cells. The study showed that EGCg inhibited the intracellular growth of L. monocytogenes in macrophages. The enhancement of in vitro anti-L. monocytogenes activity by EGCg is not due to the modulation of reactive oxygen intermediates or the production of reactive nitrogen intermediates but due to the inhibition of its escaping from the phagosome into cytosolic space. Anti-L. monocytogenes of EGCg is through the inhibition of hemolytic and cholesterol-binding activity of listeriolysin O, which usually disrupts the phagosomal membrane in the escaping phase of L. monocytogenes.     

Detection of Listeria monocytogenes in cheese with the magnetic immuno-polymerase chain reaction assay.

A new detection system, the magnetic immuno-polymerase chain reaction (PCR) assay (MIPA) has been developed to detect Listeria monocytogenes in food. This method separates Listeria cells from PCR-inhibitory factors present in enrichment broths containing food samples by using magnetic beads coated with specific monoclonal antibodies (MAbs). The separated bacteria were lysed, and the supernatant containing the bacterial DNA was subjected to the PCR. Detection of L. monocytogenes in three naturally contaminated cheese samples with two different MAbs and PCR primers specific for the gene encoding the delayed-hypersensitivity factor showed that with MAb 55 all three samples were positive whereas with MAb A two samples were positive. A further improvement of the method was obtained by using a PCR step based on the listeriolysin O gene. A MIPA employing MAb 55 and the listeriolysin O gene primer set detected L. monocytogenes after 24 h of culture in Listeria Enrichment Broth samples from Port Salut artificially contaminated with 40 CFU/25 g. We could detect 1 CFU of L. monocytogenes per g of cheese after a second enrichment for 24 h in Fraser broth. The analysis time including both enrichments is approximately 55 h.     

Acid adaptation and survival of Listeria monocytogenes in Italian-style soft cheeses

AIMS: The ability of Listeria monocytogenes to survive and grow at high salt concentrations and low pH makes it a potential hazard after the consumption of milk and dairy products, often implicated in severe outbreaks of listeriosis. This study was designed to evaluate the behaviour of L. monocytogenes in traditional acid and salted Italian-style soft cheeses and to investigate whether Listeria occurrence and growth in these environments may represent a potential increase of hazard. METHODS AND RESULTS: A first approach was addressed to in vitro evaluate survival, acid tolerance response, ability to produce biofilm, and capability to invade intestinal-like cells of a L. monocytogenes strain grown under experimental conditions mimicking environmental features that this pathogen encounters in soft cheeses (such as acid pH and high NaCl content). A second set of experiments was performed to monitor, during the storage at 4 degrees C, the survival of acid-adapted and nonadapted Listeriae in artificially contaminated soft cheeses. Both acid tolerance response and invasion efficiency of acid-adapted bacteria resulted in an increase, even when bacteria were simultaneously pre-exposed to increasing salt stress. The contamination of cheeses with acid-adapted and nonadapted bacteria evidenced in all products a good survival. A significant increased survival, the recovery of bacterial cells highly resistant to lethal pH exposure, and the prevalence of filamentous structures were observed in crescenza cheese during the storage. CONCLUSIONS: The Listeria survival and acid pH tolerance observed during refrigerated storage are probably related to the intrinsic acid and saline features of soft cheeses analysed. SIGNIFICANCE AND IMPACT OF THE STUDY: Italian soft cheeses tested may represent a potential hazard for the recovery of acid-adapted L. monocytogenes cells with enhanced ability to adhere to inert surfaces and/or to penetrate host cells.     

Modelling the growth,survival and death of Listeria monocytogenes

In this paper, the predictive microbiology approach has been generalized to the study of growth, survival and death of Listeria monocytogenes. As this micro-organism is involved in food poisoning, its growth, survival and death were studied as functions of low temperatures, NaCl and phenol compounds, in a synthetic medium, by a factorially designed experiment. A significant inactivation of L. monocytogenes was obtained with 20 ppm of phenol and 4% (w/v) NaCl at temperatures from 4 to 12 degrees C. An empirical model is proposed to describe, in a single step, the biomass profile vs studied factors. Thereby, the influence of temperature, NaCl and phenol concentration on L. monocytogenes biomass quantity (0.5-8 log cfu ml(-1)) are presented as a function of storage duration. The comparisons of the proposed model with existing models (Gompertz for growth, vitalistic for survival and death) were performed. The use of a single equation allows the prediction of contamination levels in all experimental conditions without knowledge a priori. The model offers considerable prospects for its use in food microbiology.     

Inhibition of Listeria monocytogenes by enterocin 4 during the manufacture andripening of Manchego cheese

The inhibitory effect of enterocin 4, a bacteriocin produced by Enterococcus faecalis INIA 4, on Listeria monocytogenes strains Ohio and Scott A during themanufacture and ripening of Manchego cheese was investigated. Raw ewe's milk wasinoculated with ca 10⁵ cfu ml⁻¹ of L.monocytogenes and with 1% of a commercial lactic starter, 1% of an Ent. faecalis INIA 4 culture, or 1% of each culture. Manchego cheeses were manufactured according tousual procedures. Listeria monocytogenes Ohio counts decreased by 3 log units after8 h and by 6 log units after 7 d in cheese made from milk inoculated with Ent. faecalis INIA 4 or with both cultures, whereas no inhibition was recorded after 60 d in cheese made frommilk inoculated with commercial lactic starter. Listeria monocytogenes Scott A wasnot inhibited by enterocin 4 during cheese manufacture, but decreases of 1 log unit after 7 d andof 2 log units after 60 d were achieved in cheese made from milk inoculated with bothcommercial lactic starter and Ent. faecalis INIA 4.