Characterization of the lectin purified fromCanavalia ensiformis shoots

Lectin is a cell-agglutinating and carbohydrate-binding protein present in many plants. The lectin ofCanavalia ensiformis shoot with specific affinity ford-glucose was purified by affinity chromatography using Sephadex G-100, and some of its biochemical characterizations were studied. Lectin was purified 8.87-fold and exhibited final specific activity of 225.74 units/mg protein with a 2.3% yield. SDS-PAGE analysis demonstrated that the purified shoot lectin exists as a tetramer of 102 kD, composed of two subunits with molecular weight of 29 and 22 kD. The purified lectin was observed to agglutinate rabbit blood cell. The optimal temperature for the activity of this lectin was 40°C, and this lectin was relatively stable to heat with the highest activity at 50∼60°C. The maximal activity was observed at pH 7.2.     

Purification and Characterization of Trypsin-like Enzymes from <Emphasis Type="Italic">Neomysis japonica</Emphasis> Using BApNA as Substrate

Using N-α-benzoyl-l-arginine p-nitroanilide (BApNA) as substrate, trypsin-like enzymes (TLEs) were purified from mysis (Neomysis japonica) following two chromatographic steps, Sephacryl S100 HR gel filtration and Benzamidine-Sepharose 4B affinity. They presented a high stability in the raw material, retaining over 45% of the initial activity after 30 days of storage at pH 8.0, 45 °C. The purified TLEs had relative molecular mass between 32 kDa and 33 kDa. With higher stability and greater activity, they had similar stability and activity profiles (pH 6.0–11.0, 15–65 °C) as bovine trypsin but had a different optimum temperature (35 °C for trypsin and 45 °C for TLEs). Similar to bovine trypsin, the purified TLEs could be activated by Ca²⁺ and Mg²⁺. And the purified TLEs also showed similar inhibitory profiles as bovine trypsin with the exception of chicken egg ovomucoid (CEOM), an effective inhibitor of bovine trypsin but less so for purified TLEs. Having TLEs with physiological efficiency 3.6 times that of bovine trypsin, the use of mysis as a source for commercial production of TLEs is discussed.     

Purification,characterization and molecular cloning of a monocot mannose-binding lectin from <Emphasis Type="Italic">Remusatia vivipara</Emphasis> with nematicidal activity

A mannose-binding lectin (RVL) was purified from the tubers of Remusatia vivipara, a monocot plant by single-step affinity chromatography on asialofetuin-Sepharose 4B. RVL agglutinated only rabbit erythrocytes and was inhibited by mucin, asialomucin, asialofetuin and thyroglobulin. Lectin activity was stable up to 80°C and under wide range of pH (2.0–9.3). SDS-PAGE and gel filtration results showed the lectin is a homotetramer of Mr 49.5 kDa, but MALDI analysis showed two distinct peaks corresponding to subunit mass of 12 kDa and 12.7 kDa. Also the N-terminal sequencing gave two different sequences indicating presence of two polypeptide chains. Cloning of RVL gene indicated posttranslational cleavage of RVL precursor into two mature polypeptides of 116 and 117 amino-acid residues. Dynamic light scattering (DLS) and gel filtration studies together confirmed the homogeneity of the purified lectin and supported RVL as a dimer with Mr 49.5 kDa derived from single polypeptide precursor of 233 amino acids. Purified RVL exerts potent nematicidal activity on Meloidogyne incognita, a root knot nematode. Fluorescent confocal microscopic studies demonstrated the binding of RVL to specific regions of the alimentary-tract and exhibited a potent toxic effect on M. incognita. RVL-mucin complex failed to interact with the gut confirming the receptor mediated lectin interaction. Very high mortality (88%) rate was observed at lectin concentration as low as 30 μg/ml, suggesting its potential application in the development of nematode resistant transgenic-crops.     

Proteolytic Activity from an Alkali-Thermotolerant <Emphasis Type="Italic">Streptomyces gulbargensis</Emphasis> sp. nov.

Multiple proteases were produced and partially purified from an alkali-thermotolerant novel species of Streptomyces (i.e., Streptomyces gulbargensis DAS 131) after 48 h of growth at 45°C. The enzyme preparation exhibited activity over a broad range of pH (4–12) and temperature (27–55°C). Optimum activity was observed at a pH of 9.0 and a temperature of 45°C. Starch and protease peptone was found to be a good source of carbon and nitrogen to enhance the enzyme activity. Two active zones in the range of 19 to 35 kDa were detected on sodium dodecyl sulfate polyacrylamide gel electrophoresis (SDS-PAGE).     

An alkali-tolerant xylanase produced by the newly isolated alkaliphilic <Emphasis Type="Italic">Bacillus pumilus</Emphasis> from paper mill effluent

An alkaline active xylanase, XynBYG, was purified from an alkaliphilic Bacillus pumilus BYG, which was newly isolated from paper mill effluent. It had an optimum pH of 8.0–9.0, and showed good stability after incubated at pH 9.0 for 120 min. The optimum temperature for the activity was 50°C, and the enzyme retained below 55% of its original activity for 30 min at 55°C. The gene coding for XynBYG consists of 687 bp and encodes 229 amino acids. Similarity analysis indicated that XynBYG belong to family 11 glycosyl hydrolases. Site-directed mutagenesis was performed to replace five sites (Tyr/Ser) to Arg/Glu and the results demonstrated that the optimum temperature of the mutant Y7 (S39R-T146E) increased 5°C and the half-life of inactivation (T1/2) at 60 and 65°C was 1 h and 25 min, respectively. Thus, it provides a potential xylanase that can meet the harsh conditions in the industrial applications.     

Purification and characterization of a thermostable mycelial lectin from basidiomycete Lentinus squarrosulus

Lectins are non-immune carbohydrate-binding proteins or glycoproteins with specific binding sites for certain glycoconjugates. Fungal lectins have been documented for their antitumour, antiproliferative, immunomodulatory, hypotensive and insecticidal effects. In the present study, a mycelial lectin having molecular mass 55 kDa has been purified and characterized from Lentinus squarrosulus. Biological action spectrum of the lectin revealed agglutination of all human blood types (A, B, O, AB), goat, sheep, rabbit and pig erythrocytes. Neuraminidase treatment of blood type O erythrocytes considerably augmented hemagglutination titre. Carbohydrate inhibition studies showed its high affinity to mucin and asialofetuin. Lectin was purified by a combination of ammonium sulphate precipitation, dialysis, ion exchange chromatography and gel filtration chromatography. Optimum pH for lectin activity was observed to be 6.5–8.0 and optimum temperature was 25–30°C. Lectin showed poor pH stability and was stable within pH 7.0–7.5. It was highly thermostable and could withstand temperature upto 70°C. Lectin activity was sensitive to ethylenediaminetetraacetic acid and denaturants.     

Purification and biological characterization of a halophilic thermostable protease from <Emphasis Type="Italic">Haloferax lucentensis</Emphasis> VKMM 007

An extremely halophilic archaeon Haloferax lucentensis VKMM 007, isolated from a solar saltern, was found to produce a protease. This extracellular enzyme consisted of a single polypeptide chain of 57.8 kDa as determined by SDS–PAGE and was purified by a combination of ultrafiltration, bacitracin–Sepharose affinity chromatography and Sephadex G-100 gel filtration. The purified protein was stable in a wide range of temperatures (20–70°C), NaCl concentrations (0.85–5.13 M) and pH (5.0–9.0) with maximal activity observed at 60°C, 4.3 M NaCl and pH 8.0. Proteolytic activity was enhanced by Ca²⁺, K⁺, Mg²⁺, Na⁺, and Fe²⁺ ions and the protein was classified as a trypsin-like serine protease. Further assays indicated highest degree of specificity when hemoglobin was used as an enzyme substrate. Most importantly, the proteolytic activity remained stable or only marginally inhibited in the presence of various polar and non-polar solvents, surfactants and reducing agents thus emphasizing the biotechnological potential of this novel halophilic protease.     

Production,optimization and purification of a novel extracellular protease from the moderately halophilic bacterium <Emphasis Type="Italic">Halobacillus karajensis</Emphasis>

The production of a protease was investigated under conditions of high salinity by the moderately halophilic bacterium Halobacillus karajensis strain MA-2 in a basal medium containing peptone, beef extract, maltose and NaCl when the culture reached the stationary growth phase. Effect of various temperatures, initial pH, salt and different nutrient sources on protease production revealed that the maximum secretion occurred at 34°C, pH 8.0–8.5, and in the presence of gelatin. Replacement of NaCl by various concentrations of sodium nitrate in the basal medium also increased the protease production. The secreted protease was purified 24-fold with 68% recovery by a simple approach including a combination of acetone precipitation and Q-Sepharose ion exchange chromatography. The enzyme revealed a monomeric structure with a relative molecular mass of 36 kDa by running on SDS-PAGE. Maximum caseinolytic activity of the enzyme was observed at 50°C, pH 9.0 and 0.5 M NaCl, although at higher salinities (up to 3 M) activity still remained. The maximum enzyme activity was obtained at a broad pH range of 8.0–10.0, with 55 and 50% activity remaining at pH 6 and 11, respectively. Moreover, the enzyme activity was strongly inhibited by phenylmethylsulfonyl fluoride (PMSF), Pefabloc SC and EDTA; indicating that it probably belongs to the subclass of serine metalloproteases. These findings suggest that the protease secreted by Halobacillus karajensis has a potential for biotechnological applications from its haloalkaline properties point of view.     

Expression,purification and functional characterization of a recombinant 2,3-dihydroxybiphenyl-1,2-dioxygenase from <Emphasis Type="Italic">Rhodococcus rhodochrous</Emphasis>

A 2,3-dihydroxybiphenyl (2,3-DHBP) dioxygenase gene from a Rhodococcus sp. strain, named RrbphCI and involved in the degradation of polychlorinated biphenyls (PCBs), was synthesized. RrbphCI was expressed in Escherichia coli and its encoded enzyme was purified. SDS–PAGE analysis indicated that the size of the protein encoded by RrbphCI was about 32 kDa. The activity of the 2,3-DHBP dioxygenase was 82.8 U/mg when the substrate was 2,3-DHBP, with optimum pH 8.0 at 30°C, and optimum temperature was 40°C at pH 8.0. The RrbphCI gene was transformed into Pseudomonas putida strain EG11, to determine the ability of the enzyme to degrade 2,3-DHBP. The wild type EG11 degraded 61.86% of supplied 2,3-DHBP and the transformed EG11 (hosting the RrbphCI gene) utilized 52.68% after 2 min of treatment at 30°C. The overexpressed and purified enzyme was able to degrade 2,3-DHBP. The 2,3-DHBP dioxygenase is a key enzyme in the PCB degradation pathway. RrbphCI and its encoded 2,3-DHBP dioxygenase may have transgenic applications in bioremediation of PCBs.     

Purification and characterization of a high-thermostable β-xylanase from newly isolated Thermomyces lanuginosus THKU-49

Highly thermostable β-xylanase produced by newly isolated Thermomyces lanuginosus THKU-49 strain was purified in a four-step procedure involving ammonium sulfate precipitation and subsequent separation on a DEAE-Sepharose fast flow column, hydroxylapatite column, and Sephadex G-100 column, respectively. The enzyme purified to homogeneity had a specific activity of 552 U/mg protein and a molecular weight of 24.9 kDa. The optimal temperature of the purified xylanase was 70°C, and it was stable at temperatures up to 60°C at pH 6.0; the optimal pH was 5.0–7.0, and it was stable in the pH range 3.5–8.0 at 4°C. Xylanase activity was inhibited by Mn²⁺, Sn²⁺, and ethylenediaminetetraacetic acid. The xylanase showed a high activity towards soluble oat spelt xylan, but it exhibited low activity towards insoluble oat spelt xylan; no activity was found to carboxymethylcellulose, avicel, filter paper, locust bean gum, cassava starch, and p-nitrophenyl β-d-xylopyranoside. The apparent K _m value of the xylanase on soluble oat spelt xylan and insoluble oat spelt xylan was 7.3 ± 0.236 and 60.2 ± 6.788 mg/ml, respectively. Thin-layer chromatography analysis showed that the xylanase hydrolyzed oat spelt xylan to yield mainly xylobiose and xylose as end products, but that it could not release xylose from the substrate xylobiose, suggesting that it is an endo-xylanase.     

Production of a <Emphasis Type="Italic">Trichoderma reesei</Emphasis> QM9414 xylanase in <Emphasis Type="Italic">Pichia pastoris</Emphasis> and its application in biobleaching of wheat straw pulp

The purpose of this study was to produce a Trichoderma reesei xylanase (XYN2) in Pichia pastoris and to test its potential application for pulp bleaching. The recombinant xylanase was purified by a two-step process of ultrafiltration and gel filtration chromatography. The molecular mass of the recombinant enzyme was 21 and 25 kDa by SDS–PAGE analysis, due to different glycosylation of the native protein. The optimum pH and temperature of the recombinant XYN2 was 5.0 and 50 °C. Enzyme activity was stable at 50 °C and at pH 5.0–7.0. The bleaching ability of the recombinant xylanase was also studied at 50 °C and pH 6.0, using wheat straw pulp. Biobleaching of the xylanase produced chlorine dioxide savings of up to 60%, while retaining brightness at the control level and led to a lower kappa number and small enhancements in tensile, burst and tear strength of pulp fibers.     

Purification and characterization of a novel thermoacid-stable fibrinolytic enzyme from <Emphasis Type="Italic">Staphylococcus</Emphasis> sp. strain AJ isolated from Korean salt-fermented Anchovy-<Emphasis Type="Italic">joet</Emphasis>

A novel fibrinolytic enzyme (AJ) was purified from Staphylococcus sp. strain AJ screened from Korean salt-fermented Anchovy-jeot. Relative molecular weight of AJ was determined as 26 kDa by using SDS-PAGE and fibrin zymography. Based on a 2D gel, AJ was found to consist of three active isoforms (pI 5.5–6.0) with the same N-terminal amino acid sequence. AJ exhibited optimum pH and temperature at 2.5–3.0 and 85°C, respectively. AJ kept 85% of the initial activity after heating at 100°C for 20 min on the zymogram gel. The Michaelis constant (K _m) and K _cat values of AJ towards α-casein were 0.38 mM and 19.73 s⁻¹, respectively. AJ cleaved the Aα-chain of fibrinogen but did not affect the Bβ- and γ-chains, indicating that it is an α-fibrinogenase. The fibrinolytic activity was inhibited by diisopropyl fluorophosphate, indicating AJ is a serine protease. Interestingly, AJ was very stable at acidic condition, SDS, and heat (100°C), whereas it was easily degraded at neutral and alkaline conditions. In particular, AJ formed an active homo-dimer in the pH range from 7.0 to 8.0. To our knowledge, a similar combination of acid and heat stability has not yet been reported for other fibrinolytic enzymes.     

Purification and characterization of a cold active alkaline protease from <Emphasis Type="Italic">Stenotrophomonas</Emphasis> sp., isolated from Kashmir,India

A Psychrotolerant alkaline protease producing bacterium IIIM-ST045 was isolated from a soil sample collected from the Thajiwas glacier of Kashmir, India and identified as Stenotrophomonas sp. on the basis of its biochemical properties and 16S ribosomal gene sequencing. The strain could grow well within a temperature range of 4–37°C however, showed optimum growth at 15°C. The strain was found to over-produce proteases when it was grown in media containing lactose as carbon source (157.50 U mg⁻¹). The maximum specific enzyme activity (398 U mg⁻¹) was obtained using soya oil as nitrogen source, however, the inorganic nitrogen sources urea, ammonium chloride and ammonium sulphate showed the lowest production of 38.9, 62.2 and 57.9 U mg⁻¹. The enzyme was purified to 18.45 folds and the molecular weight of the partially purified protease was estimated to be ~55 kDa by SDS-PAGE analysis. The protease activity increased as the increase in enzyme concentration while as the optimum enzyme activity was found when casein (1% w/v) was used as substrate. The enzyme was highly active over a wide range of pH from 6.5 to 12.0 showing optimum activity at pH 10.0. The optimum temperature for the enzyme was 15°C. Proteolytic activity reduced gradually with higher temperatures with a decrease of 56% at 40°C. The purified enzyme was checked for the removal of protein containing tea stains using a silk cloth within a temperature range of 10–60°C. The best washing efficiency results obtained at low temperatures indicate that the enzyme may be used for cold washing purposes of delicate fabrics that otherwise are vulnerable to high temperatures.     

A novel thermo-alkali stable catalase–peroxidase from Oceanobacillus oncorhynchi subsp. incaldaniensis: purification and characterization

A novel thermo-alkali-stable catalase–peroxidase from Oceanobacillus oncorhynchi subsp. incaldaniensis subsp. nov., strain 20AG, was purified and characterized. The protein purified from the cells resulted in 110-fold purification with a specific activity of 35,000 U/mg. The enzyme consisted of four identical subunits of 72 kDa as determined by SDS-PAGE and the total molecular mass measured by gel filtration was 280 kDa. The heme content was determined to be 1 heme per homodimer. The enzyme showed a Soret peak at 406 nm in the oxidized form and was easily reduced by dithionite. The enzyme showed an appreciable peroxidase activity in addition to high catalase activity. The behaviour of this heme-enzyme was typical of the class of prokaryotic catalase–peroxidases, which are sensitive to cyanide and insensitive to the eukaryotic catalase inhibitor 3-amino-1,2,4-triazole. The enzyme was active over a temperature range from 30 to 60°C and a pH range from 5 to 10, with an optimum pH about 9.0 and an optimum temperature of 40°C. The enzyme was stable in the pH range of 5.0 to 10.0 after 1 h of treatment at 40°C. The enzyme was stable for 24 h at 40°C with a half-life of 4 h 60°C. The enzyme had a K _m of 24 mM for hydrogen peroxide. The amino terminal amino acid sequence of the catalase–peroxidase from strain 20AG was SEKRKMTTAFGA and it showed no homology with other catalases.     

Novel, thermostable family-13-like glycoside hydrolase fromMethanococcus jannaschii

A novel glycoside hydrolase from the hyperthermophilic archaeonMethanococcus jannaschii has been cloned intoEscherichia coli. Extremely thermoactive and thermostable amylolytic activity was confirmed in partially purified enzyme solution. This enzyme exhibited a temperature optimum of 100 °C and a pH optimum pH 5.0–8.0. Hydrolysis of large 1,6-α- and 1,4-α-linked polysaccharides yielded glucose polymers of 1–7 units. Incubation with amylose displayed the highest activity. The catalyst was activated and stabilized by Ca²⁺ and exhibited extreme thermostability at 100 °C with a half-life of 78 h.     

Purification and characterization of an endoxylanase from the culture broth of <Emphasis Type="Italic">Bacillus cereus</Emphasis> BSA1

An extracellular xylanase from the fermented broth of Bacillus cereus BSA1 was purified and characterized. The enzyme was purified to 3.43 fold through ammonium sulphate precipitation, DEAE cellulose chromatography and followed by gel filtration through Sephadex-G-100 column. The molecular mass of the purified xylanse was about 33 kDa. The enzyme was an endoxylanase as it initially degraded xylan to xylooligomers. The purified enzyme showed optimum activity at 55°C and at pH 7.0 and remained reasonably stable in a wide range of pH (5.0–8.0) and temperature (40–65°C). The K _m and V _max values were found to be 8.2 mg/ml and 181.8 μmol/(min mg), respectively. The enzyme had no apparent requirement of cofactors, and its activity was strongly inhibited by Cu²⁺, Hg²⁺. It was also a salt tolerant enzyme and stable upto 2.5 M of NaCl and retained its 85% activity at 3.0 M. For stability and substrate binding, the enzyme needed hydrophobic interaction that revealed when most surfactants inhibited xylanase activity. Since the enzyme was active over wide range of pH, temperature and remained active in higher salt concentration, it could find potential uses in biobleaching process in paper industries.     

Pre and post cloning characterization of a β-1,4-endoglucanase from <Emphasis Type="Italic">Bacillus</Emphasis> sp.

Consistent with its precloning characterization from the cellulolytic Bacillus sp., β-1,4-endoglucanase purified from the recombinant E. coli exhibited maximum activity at 60°C and pH 7.0. It was highly specific for CMC hydrolysis, with stability up to 70°C and over a pH range of 6.0–8.0. The K _m and V _max values for CMCase activity of the enzyme were 4.1 mg/ml and 25 μmole/ml min⁻¹, respectively. The purified enzyme was a monomer of 65 kDa, as determined by SDS-PAGE. The presence of sucrose and IPTG in fermentation media increased the endoglucanase activity of the recombinant enzyme to 5.2-folds as compared with that of the actual one.     

High-level expression of the xylanase from <Emphasis Type="Italic">Thermomyces lanuginosus</Emphasis> in <Emphasis Type="Italic">Escherichia coli</Emphasis>

According to the amino acid sequence, a codon-optimized xylanase gene (xynA1) from Thermomyces lanuginosus DSM 5826 was synthesized to construct the expression vector pHsh-xynA1. After optimization of the mRNA secondary structure in the translational initiation region of pHsh-xynA1, free energy of the 70 nt was changed from −6.56 to −4.96 cal/mol, and the spacing between AUG and the Shine-Dalgarno sequence was decreased from 15 to 8 nt. The expression level was increased from 1.3 to 13% of total cell protein. A maximum xylanase activity of 47.1 U/mL was obtained from cellular extract. The recombinant enzyme was purified 21.5-fold from the cellular extract of Escherichia coli by heat treatment, DEAE-Sepharose FF column and t-Butyl-HIC column. The optimal temperature and pH were 65 °C and pH 6.0, respectively. The purified enzyme was stable for 30 min over the pH range of 5.0–8.0 at 60 °C, and had a half-life of 3 h at 65 °C.     

Biochemical confirmation and characterization of the family-57-like α-amylase ofMethanococcus jannaschii

The gene encoding a family-57-like α-amylase in the hyperthermophilic archaeonMethanococcus jannaschii, has been cloned intoEscherichia coli. Extremely thermoactive α-amylase was confirmed in partially purified enzyme solution of the recombinant culture. This enzyme activity had a temperature optimum of 120°C and a pH optimum 5.0–8.0. The amylase activity is extremely stable against denaturants. Hydrolysis of large sugar polymers with α-1–6 and α-1–4 linkages yields products including glucose polymers of 1–7 units. Highest activity is exhibited on amylose. The catalyst exhibited a half-life of 50 h at 100°C, among the highest reported thermostabilities of natural amylases.     

Molecular characterization of an endochitinase from <Emphasis Type="Italic">Bacillus thuringiensis</Emphasis> subsp. konkukian

A chitinase gene from Bacillus thuringiensis serovar konkukian S4 was cloned, sequenced, and heterologously expressed in Escherichia coli M15. Recombinant enzyme (Chi74) was purified by Ni-NTA affinity column chromatography. The chi74 gene contains an open reading frame (ORF), with a capacity to encode an endochitinase with a deduced molecular weight 74 kDa and predicted isoelectric point of 5.67. Comparison of Chi74 with other chitinases has shown that it contains a modular structure with an N-terminal family 18 catalytic-domain, a Fibronectin-III like domain and a C-terminal carbohydrate binding module (CBM-II). Turn over rate (K _cat ) of the enzyme was determined using colloidal chitin (28.3 ± 0.70 S⁻¹) as substrate. The Purified enzyme was active at a broad range of pH (pH 3.5–7.5) and temperature (20–70°C) with a peak activity at pH 5.5 and 55°C. However, the enzyme was found to be stable up to 30°C for longer incubation periods. Moreover, the purified enzyme was shown to inhibit fungal spore germination and hyphal growth in the pathogenic fungi Fusarium oxysporum and Aspergillus niger. These studies will lead us to develop broad spectrum resistance in the crop plants via co-expression of the chitinases and the insecticidal proteins.