樟叶越桔细胞悬浮培养条件的优化

为了提高樟叶越桔(Vacciniumdunalianum)悬浮培养细胞的生物量,以樟叶越桔叶片愈伤组织为试材,通过单因素试验探究不同蔗糖浓度、培养基pH值、培养基体积、初始接种量和摇床转速对悬浮培养细胞生长的影响,并根据响应面法Box-Behnken试验设计原理进行组合试验以优化培养条件。结果显示,以改良WPM培养基为基础培养基,樟叶越桔细胞悬浮培养的最优条件为40 g·L^–1蔗糖、培养基pH5.2、培养基体积45 mL、初始接种量2.64 g和摇床转速为149 r·min^–1,其细胞生物量干重为0.184 4 g,与理论预测值0.184 5 g较为接近,且细胞的生长曲线呈S型。研究结果为樟叶越桔悬浮培养细胞次生代谢产物的生产调控奠定了技术基础。     

水母雪莲悬浮培养细胞生长和黄酮类活生成分合成

在ＭＳ培养基上进行水母雪莲细胞悬浮培养,研究了摇床转速、接种量、培养液初始ｐＨ、碳源等的影响。结果表明,摇床转速为９０￣１２０ｒ／ｍｉｎ,接种量为５０￣８０ｇＦＷ／Ｌ,培养液初始ｐＨ５．５￣６．０,对水母雪莲悬浮培养细胞生长和黄酮合成最有利。碳源以蔗糖最适合,蔗糖浓度则以４０ｇ／Ｌ较好,此时细胞生长量为１８￣１９ｇＤＷ／Ｌ,总黄酮合成量可达１４２３．２５ｍｇ／Ｌ。用ＨＰＬＣ检测显示４＇,５,７－三     

甲基营养菌MP688胞外多糖合成的影响因素研究

目的：考察培养基组分和发酵条件对甲基营养菌MP688合成胞外多糖的影响,确定最主要的影响因素。方法：将甲基营养菌MP688接种到基础培养基中,通过改变基础培养基的氮源、培养温度、初始pH值和培养时摇床转速等条件,检测在每种条件下培养5 d后发酵液中的多糖含量,确定每种因素的最适范围;进而选取8个因素,通过Plackett-Burman实验设计12组实验,通过检测每种组合条件下的多糖产量和结果统计分析,确定影响多糖合成的最主要因素。结果：甲基营养菌合成胞外多糖的最适氮源为硝酸钠,最适温度为30-37°C,最适pH值为6.5-7.0,最适摇床转速为200-250 r/min;甲醇、硝酸钠、初始pH值和接种量是MP688合成多糖的主要影响因子。结论：运用Plack-ett-Burman实验设计筛选到甲基营养菌MP688胞外多糖合成的主要影响因子,MP688是具有多糖生产潜力的菌株。     

海洋红酵母的液体培养

目的探讨提高海洋红酵母的液体高密度培养方法。方法在摇瓶培养条件下,测定温度、pH、装液量、接种量及摇床转速对海洋红酵母BY2菌株生长的影响,进一步放大培养至50L发酵罐,在培养过程流加氨水以控制pH稳定在5.3~5.5的条件下,考察不同葡萄糖浓度对海洋红酵母BY2菌株发酵菌量的影响。结果摇瓶最适培养条件为温度25℃,pH 5.5,接种量8%、装液量40mL/250mL三角瓶、摇床转速200r/min,在此培养条件下,24h时菌量达到8.9×108 CFU/mL;扩大至50L发酵罐,葡萄糖初始浓度为40、60、80、100g/L各罐20~24h时的菌量相应达到26.6×108、29.5×108、47.8×108、66.8×108 CFU/mL。结论提高初始葡萄糖浓度,流加氨水稳定发酵过程的pH,可以显著提高BY2菌株的发酵菌量。     

固定化白腐真菌降解水溶液中2,4-二氯酚的研究

研究固定化黄孢原毛平革菌对水溶液中2,4-二氯酚（2,4-DCP）的降解效果,探讨固定化黄孢原毛平革菌处理水溶液中氯酚类污染物的可行性．结果表明,采用固定化方法处理的白腐真菌．其产酶稳定性及酶活均比游离态白腐真菌有显著提高．2,4-DCP降解效果受固定化孢子接种量、pH值、摇床转速、2,4-DCP的初始浓度和表面活性剂浓度的影响．当pH为4．5,摇床转速180r／min,培养基含有1％的Tween 80,2,4-DCP初始浓度为40mg／L时,加入10mL固定化白腐真菌孢子,2,4-DCP去除效果最好．     

水母雪莲悬浮培养细胞生长和黄酮类活性成分合成

在ＭＳ培养基上进行水母雪莲（ＳａｕｓｕｒｅａｍｅｄｕｓａＭａｘｉｍ．）细胞悬浮培养,研究了摇床转速、接种量、培养液初始ｐＨ、碳源等的影响。结果表明,摇床转速为９０～１２０ｒ／ｍｉｎ,接种量为５０～８０ｇＦＷ／Ｌ,培养液初始ｐＨ５．５～６．０,对水母雪莲悬浮培养细胞生长和黄酮合成最有利。碳源以蔗糖最适合,蔗糖浓度则以４０ｇ／Ｌ较好,此时细胞生长量为１８～１９ｇＤＷ／Ｌ,总黄酮合成量可达１４２３．２５ｍｇ／Ｌ。用ＨＰＬＣ检测显示４′,５,７三羟基３′,６二甲氧基黄酮（ｊａｃｅｏｓｉｄｉｎ）和４′,５,７三羟基６甲氧基黄酮（ｈｉｓｐｉｄｕｌｉｎ）的含量分别达到总黄酮含量的２２．１１％和０．１５％。     

短小芽胞杆菌产碱性木聚糖酶发酵条件的研究

碱性木聚糖酶在碱性条件下催化水解木聚糖,广泛应用于造纸、纺织等领域.着重对短小芽胞杆菌M-11产碱性木聚糖酶的发酵条件进行初步的探索.研究了菌株的生长曲线、确定最佳接种龄为16 h、最佳接种量为1％;确定最适碳源浓度为7％、最适单一氮源为氯化铵、其浓度为1.0％、最适无机盐为氯化铁、其浓度为3 mmol/L;在此基础之上进行6因素3水平的正交试验,确定最适产酶培养基组成:麸皮5％,接种量3％,氯化铵1.2％,氯化铁3.5 mmol/L,硫酸镁0.03％,氯化钠5 mmol/L,磷酸氢二钾0.4％;最适培养条件:接种龄16 h,初始pH 8.0,温度37℃,300 mL摇瓶装液量50 mL,摇床转速220 r/min,发酵周期48 h.通过对发酵条件的优化使发酵液酶活达613 IU/mL.无机氮源为其最适氮源,因此短小芽胞杆菌M-11在碱性木聚糖酶的产品开发上优于短小芽胞杆菌M -26.     

杜仲细胞悬浮培养产黄酮及其动力学研究

本文应用正交设计对杜仲细胞悬浮培养的基本培养基和植物生长物质浓度进行了筛选,并对影响杜仲细胞悬浮培养和总黄酮含量的不同因素进行了考察。结果表明,B5培养基+0.5mg/L NAA+0.6mg/L 6-BA、蔗糖30g/L、初始pH 5.0-5.5、接种量20g(FW)/L以及摇床转速110r/min为杜仲细胞悬浮培养的适宜条件。通过对杜仲悬浮细胞生长和代谢动力学的分析表明：杜仲细胞悬浮培养生长符合Logistic生长模型,最大比生长速率( m)为0.417d-1;细胞基于蔗糖的真正比生长得率(YG)与维持系数(m)分别为0.619g/g和0.0206g/(g·d-1);黄酮合成属部分生长耦联型,可用Luedeking-Piret模型进行描述。研究结果为杜仲细胞大规模悬浮培养生产天然活性成分奠定了基础。     

纺锤芽孢杆菌CGMCC1347发酵生产异丁香酚单加氧酶的条件优化

对从土壤中筛选获得的纺锤芽孢杆菌CGMCCl347生产异丁香酚单加氧酶的发酵条件进行了单因素考察及正交实验优化,确定了最适的发酵摇瓶培养基组成和培养条件。在发酵培养基组成为尿素1g／L,玉米浆55g/L,K2HP042g／L,MgSO4·7H2O1g／L,初始pH7．5,发酵温度37℃,摇床转速180r／min的条件下培养16h获得的细胞,能转化2％的异丁香酚生成2．49g／L香兰素,异丁香酚单加氧酶酶活达3．79U／L。     

酿酒酵母突变株J-X25胞内合成GSH的研究

以筛选得高产谷胱甘肽(GSH)产生酵母甲硫氨酸缺陷型变株J-X25为试验菌株。对其培养条件进行研究,结果表明：发酵培养基的最适初始pH值为6.0、最佳发酵温度为30℃、最佳装液量为100ml/500ml、接种量10%、摇床转速为220r/min。在酵母细胞培养到对数期,加入过氧化氢刺激细胞发生应激反应和乳酸钠作为表面活性剂改变细胞通透性,GSH总量达到0.253g/L,比不添加两者情况下的GSH产量高出52％。结果表明优化培养条件后,J-X25胞内积累GSH比出发株提高79％。     

长春花激素完全适应型细胞的生长和阿玛碱合成特性

从长春花激素依赖型细胞系(C20D)筛选出一种激素完全适应型的细胞系(C20hi),考察了两种细胞生长、阿玛碱合成和与吲哚生物碱生物合成相关的酶的活性,结果表明:在生长培养基上二者生长无显著差异,而C20hi细胞平均阿玛碱含量是C20D的31.9倍,在生产培养基上C20hi细胞生长较C20D快,C20hi平均阿玛碱含量是C20D的18.4倍.通过比较生产和生长培养基中C20hi细胞的色氨酸脱羧酶、异胡豆苷合酶和牛儿醇-10-脱氢酶活性,发现在生产培养基中培养细胞的3种酶活性均显著高于生长培养基,但与阿玛碱积累没有密切关系.研究结果还表明,通过5年的继代培养,激素完全适应型细胞系C20hi的阿玛碱含量是比较稳定的.     

长春花激素完全适应型细胞的生长和阿玛碱合成特性

从长春花激素依赖型细胞系（C20D）筛选出一种激素完全适应型的细胞系（C20hi),考察了两种细胞生长、阿玛碱合成和引吲哚生物碱生物合成相关的酶的活性,结果表明：在生长培养基上二生长无显差异,而C20hi细胞平均阿玛碱含量是C20D的31.9倍,在生产培养基上C20hi细胞生长较C20D快,C20hi平均阿玛碱含量是C20D的18.4倍。通过比较生产和生长培养基中C20hi细胞的色氨酸脱羧酶、异胡豆苷合酶和long牛儿醇-10-脱氢酶活性,发明,通过5年的继代培养,激素完全适应型细胞系C20hi的阿玛碱含量是比较稳定的。     

Anticarcinogenic Alkaloids in the Cultured Cells of Cephalotaxus fortunei

Calli were induced from the leaves and stems of Cephalotaxus fortunei Hook. f. on MS medium supplemented with 0. 1 mg/L KT and 3 mg/L NAA, and from which the suspension culture cell line of this plant was established for the first time. Factors such as light, pH value of the medium, concentration of plant hormone, carbon resources and addition of substances to the medium, which affect the growth of suspension cells were investigated. The results showed that suspension cells grew appropriately at pH 5.8 with a low concentration of sucrose or glucose, and a low level of NAA. No difference effect on cell growth was seen between sucrose and glucose. Phenylalanine and protein hydrolysate were not suitable for cell growth in suspension cultures, and light inhibited cell growth. A sensitive and rapid high-performance liquid chromatographic method has been developed for detecting the alkaloids in cultured cells. The results revealed the following contents of cephalotaxine and its anticancer esters in cultured cells: harringtonine, isoharringtonine and homoharringtonine. The total alkaloid production in cell suspension cultures was doubled as that in solid cultures. The relative amounts of cephalotaxine, drupacine, harringtonine, homoharringtonine and isoharringtonine in suspension cells was 22%, 6%, 8%, 23% and 41% respectively. In addition, other alkaloid as deoxyharringtonine and some steroids, including ergdst-5-en-3-ol. stigmasta-5, 22-dien-3-ol, β-sitosterin and 2-naphthalenamine have also been detected in cell cultures using GC/MS combined technique.     

Enhanced hyaluronic acid production by a two-stage culture strategy based on the modeling of batch and fed-batch cultivation of Streptococcus zooepidemicus

This study aimed to enhance hyaluronic acid (HA) production by a two-stage culture strategy based on the modeling of batch and fed-batch culture of Streptococcus zooepidemicus. Batch culture had higher specific HA synthesis rate while fed-batch culture had higher specific cell growth rate. The lower specific HA synthesis rate in fed-batch culture resulted from the competition of cell growth for the common precursors at a low substrate concentration. Based on the modeling of batch and fed-batch culture of S. zooepidemicus, a two-stage culture strategy was proposed to enhance HA production. S. zooepidemicus were cultured in a fed-batch mode with sucrose concentration maintained at 1.0+/-0.2g/L during 0-8h and then batch culture was performed during 8-20h with an initial sucrose concentration of 15g/L. With the proposed two-stage culture strategy, HA production was increased to 6.6g/L compared with 5.0g/L in batch culture with the same total sucrose. The enhanced HA production by the proposed two-stage culture strategy resulted from the decreased inhibition of cell growth and the increased transformation rate of sucrose to HA.     

Characteristics of growth and tropane alkaloid production in Hyoscyamus albus hairy roots transformed with Agrobacterium rhizogenes A4

Summary Hairy root culture of Hyoscyamus albus was established by transformation with Agrobacterium rhizogenes strain A4. The growth and production of five tropane alkaloids were investigated under various culture conditions. Among the four basal culture media tested, Woody Plant medium was the best for growth of the hairy roots, but a high amount of tropane alkaloids was obtained with Gamborg's B5 medium. Sucrose concentration in B5 medium had little effect on the growth, while 3% sucrose was suitable for the alkaloid production. Addition of KNO₃ to Woody Plant medium affected the growth, whereas the alkaloid content was not markedly improved. Supplement of some metal ions to B5 medium stimulated the alkaloid production. In particular, Cu²⁺ remarkably enhanced both the growth and the alkaloid yield. The hairy roots cultured under 16 h/day light survived for more than 32 days compared with those cultured in the dark.Abbreviations EDTA ethylenediaminetetraacetic acid - HPLC high performance liquid chromatography - MeOH methanol - MS medium Murashige and Skoog medium - WP medium McCown's Woody Plant medium - B5 medium Gamborg B5 medium - wt weight     

流加发酵对重组Bacillus subtilis发酵生产角质酶的影响

为实现基因工程菌Bacillus subtilis WSHB06-07生产角质酶的高产,在3L发酵罐中考察了不同初糖浓度对菌体生长和产酶的影响,并在选择38 g/L初始蔗糖浓度的基础上,进行碳源的分批流加和恒速流加,结果表明发酵16 h开始流加碳源,采用总补糖量60g/L,蔗糖平均流速为4g/(L·h)的恒速补料方式,角质酶酶活在31h可达到最大545.87U/ml,比分批发酵酶活提高67.8%,并获得较高的角质酶生产强度,满足工业化生产要求。     

Studies on the optimization of growth and indole alkaloid production by hairy root cultures of Catharanthus roseus

Catharanthus roseus hairy root cultures, genetically transformed with Agrobacterium rhizogenes, produce a wide variety of indole alkaloids. The effect of sucrose, phosphate, nitrate, and ammonia concentrations on growth and indole alkaloid production of C. roseus hairy root cultures were studied by using statistical experimental designs and linear regression analysis. Contradictory effects of these nutrients on growth and indole alkaloid production were found. The maximal growth was obtained by having 77. 8 mg NaH(2)PO(4) . H(2)O/L and 1. 311 g KNO(3)/L in the medium, whereas the specific production of alkaloids was highest at the lowest levels of all the nutrients studied. The maximal dry weight was obtained with high values of sucrose and ammonia, but clear optimum concentrations could not be found. When having enough nutrients to support reasonable growth, it appeared difficult to affect the specific alkaloid production rates considerably. The growth (dry wt.) with the optimized nutrient concentrations in the medium was more than 50% better than in the control medium with about the same alkaloid production.     

Growth and alkaloid production of callus culture induced from Securinega suffruticosa

The growth of, and production of alkaloids by, callus derived from budding stem explants of the germinated seeds of Securinega suffruticosa has been studied. The major alkaloids produced were securinine and allosecurinine with the latter being present in the greatest amount. The effects of pH, growth hormones, sucrose concentration and light and dark on callus growth and alkaloid production have been examined in detail. The pattern of alkaloid production in the callus culture appeared to be similar to that in the root of the securinega plant.     

Influence of auxins and sucrose in monoterpenoid oxindole alkaloid production by Uncaria tomentosa cell suspension cultures

Growth and alkaloid production in Uncaria tomentosa cell suspension cultures were studied in Murashige and Skoog medium supplemented with 10 microM 2,4-dichlorophenoxyacetic acid, 10 microM kinetin, and 58 mM sucrose for maintenance and with 10 microM indole-3-acetic acid, 10 microM kinetin, and 58 mM sucrose for production. A U. tomentosa pale Uth-3 cell line, cultured in the production medium, showed a reduced lag phase and a specific growth rate (mu) of 0.27 day(-1), while cells growing in the maintenance medium showed mu = 0.20 day(-1). U. tomentosa cells growing in the production medium produced monoterpenoid oxindole alkaloids (MOA) in amounts of 10.2 +/- 1.6 microg g(-1) dry weight (DW). The chemical profile of MOA produced by in vitro cell cultures was similar to that found in the plant. After 10 subcultures, maximum MOA production decreased to 2.0 +/- 0.7 microg g(-1) DW, while tryptamine alkaloids (TA) were produced with a maximum of 6.2 +/- 0.4 microg g(-1) DW. The increase of initial sucrose concentration up to 145 mM in the production medium enhanced the cell biomass by 3.2-fold (from 10.2 +/- 0.1 to 32.8 +/- 1.1 g DW L(-1)), reduced mu from 0.27 to 0.23 day(-1), and provoked a substantial accumulation of TA (23.1 +/- 4.7 microg g(-1) DW). A high sucrose concentration stimulated MOA production in the maintenance medium (2.7 +/- 0.5 microg g(-1) DW), even in the presence of 2,4-dichlorophenoxyacetic acid.     

A study on the alkaloid production by resting cell suspensions of Catharanthus roseus in a continuous flow reactor

Summary During batch cultivation of Catharanthus roseus cell suspensions, alkaloids were found in the culture medium after growth had ceased. Resting cell suspensions with high alkaloid content were obtained by transferring the cells to a medium devoid of 2.4 D (2.4 dichlorophenoxy-acetic acid). A production system with continuous feeding was developped to study alkaloid production by these resting cell suspensions.