Effects of ammonia and glucosamine on the heterogeneity of erythropoietin glycoforms

Recombinant human erythropoietin (EPO) is a glycoprotein produced as a therapeutic agent from mammalian cell cultures for the treatment of anemia associated with severe kidney damage. The EPO structure has a high glycan content which is essential for bioactivity but shows considerable molecular heterogeneity. The cell culture conditions that affect the heterogeneity of the glycoforms of EPO are not well understood. However, the accumulation of ammonia in culture is one factor that has been associated with an enhanced heterogeneity of glycoforms. In this report we investigate the metabolic perturbations associated with ammonia and glucosamine that may give rise to an altered pattern of EPO glycosylation. Recombinant human erythropoietin was synthesized in serum-free cultures of transfected Chinese hamster ovary (CHO) cells. The molecular heterogeneity of erythropoietin was increased by supplementation of cultures with either ammonia or glucosamine. The enhanced molecular heterogeneity was shown to be due to variable glycosylation that resulted in EPO with an enhanced molecular weight and isoelectric point range. Enzymatic removal of the glycan moiety of EPO in all cases resulted in a single molecular form with a molecular weight of 18 000, which corresponded to non-glycosylated EPO. The variable glycosylation was consistent with reduced sialylation and antennarity of the carbohydrate structures present on the three N-linked sites of EPO. In the presence of ammonia (>30 mM) the proportion of tetrasialylated and tetraantennary glycan structures were reduced by 73% and 57%, respectively, as determined by HPLC analysis. Such changes were also observed, although to a lesser extent (41% and 37%), by an increase in the glucosamine concentration (>10 mM) in the medium. The enhanced heterogeneity of the glycan structures coincided with a significant increase in the intracellular UDP-N-acetylhexosamine (UDP-GNAc) pool. The measured UDP-GNAc level was up to 2 orders of magnitude higher in the presence of either glucosamine or ammonia. However, the changes in the glycosylation profiles induced by either glucosamine or ammonia were significantly different even at the same intracellular UDP-GNAc concentration. This suggests that the enhanced EPO heterogeneity could not be mediated solely by the increased UDP-GNAc level. Glucosamine (but not ammonia) was shown to cause significant inhibition of glucose transport into the cells, which could induce a different pattern of primary metabolism.     

Effect of ammonia on the glycosylation of human recombinant erythropoietin in culture

Recombinant human erythropoietin (EPO) was produced by a stable transfected CHO-K1 cell clone (EPO-81) grown in serum-free medium. Our previous work showed that there was a significant increase in the heterogeneity of the glycoforms of EPO and a reduction of the sialylation at 20 mM NH(4)Cl. In the work presented here, the effects of ammonia on EPO N-linked oligosaccharides were analyzed. EPO was purified from culture supernatants by immunoaffinity chromatography. The N-linked oligosaccharides were released enzymatically and analyzed by fluorophore-assisted carbohydrate electrophoresis (FACE) and HPLC. The FACE N-linked oligosaccharide profile showed that the sialylated glycans contain one prominent band at a position corresponding to eight glucose units. The density of the major band was greatly diminished and the width was significantly increased in cultures containing added ammonia. The proportion of tetraantennary structures was reduced by 60%, while the tri- and biantennary structures were increased proportionally in the presence of ammonia. Glycan analysis by HPLC using a weak anion exchange column showed that the most significant characteristic effect of ammonia was a reduction of the proportion of glycans with four sialic acids from 46% in control cultures to 29% in ammonia-treated cultures. Analysis of the desialylated glycans by normal phase chromatography indicated a distribution of tetra-, tri-, and biantennary structures similar to that shown by FACE. The N-linked glycan sequence was determined by sequential exoglycosidase digestion followed by FACE. The results indicated a typical N-linked complex oligosaccharide structure. Glycans from ammonia-containing cultures showed the same sequence pattern. In conclusion, we showed that ammonia in the culture medium affected EPO glycosylation, which was observed as a reduction of the tetraantennary and tetrasialylated oligosaccharide structures. However, the presence of ammonia in the cultures did not change the oligosaccharide sequence.     

The effect of ammonia on the O-linked glycosylation of granulocyte colony-stimulating factor produced by chinese hamster ovary cells

Ammonium ion concentrations ranging from 0 to 10 mM are shown to significantly reduce the sialylation of granuiocyte colony-stimulating factor (G-CSF) produced by recombinant Chinese hamster ovary cells. Specifically, the degree of completion of the final reaction in the O-linked glycosylation pathway, the addition of sialic acid in an alpha(2,6) linkage to N-acetylgalactosamine, is reduced by NH(4) (+) concentrations of as low as 2 mM. The effect of ammonia on sialylation is rapid, sustained, and does not affect the secretion rate of G-CSF. Additionally, the effect can be mimicked using the weak base chloroquine, suggesting that the effect is related to the weak base characteristics of ammonia. In support of this hypothesis, experiments using brefeldin A suggest that the addition of sialic acid in an alpha(2,6) linkage to N-acetylgalactosamine occurs in the trans-Golgi compartment prior to the trans-Golgi network, which would be expected under normal conditions to have a slightly acidic pH in the range from 6.5 to 6.75. Ammonium ion concentrations of 10 mM would be expected to reduce significantly the differences in pH between acidic intracellular compartments and the cytoplasm. The pH-activity profile for the CHO O-linked alpha(2,6) sialytransferase using monosialylated G-CSF as a substrate reveals a twofold decrease in enzymatic activity across the pH range from 6.75 to 7.0.Mathematical modeling of this sialylation reaction supports the hypothesis that this twofold decrease in sialyltransferase activity resulting from an ammoniainduced increase in trans-Golgi pH could produce the observed decrease in G-CSF sialylation. (c) 1995 John Wiley & Sons, Inc.     

Impact of dynamic online fed-batch strategies on metabolism, productivity and N-glycosylation quality in CHO cell cultures

As we pursue the means to improve yields to meet growing therapy demands, it is important to examine the impact of process control on glycosylation patterns to ensure product efficacy and consistency. In this study, we describe a dynamic on-line fed-batch strategy based on low glutamine/glucose concentrations and its impact on cellular metabolism and, more importantly, the productivity and N-glycosylation quality of a model recombinant glycoprotein, interferon gamma (IFN-gamma). We found that low glutamine fed-batch strategy enabled up to 10-fold improvement in IFN-gamma yields, which can be attributed to reduced specific productivity of ammonia and lactate. Furthermore, the low glutamine concentration (0.3 mM) used in this fed-batch strategy could maintain both the N-glycosylation macro- and microheterogeneity of IFN-gamma. However, very low glutamine (<0.1 mM) or glucose (<0.70 mM) concentrations can lead to decreased sialylation and increased presence of minor glycan species consisting of hybrid and high-mannose types. This shows that glycan chain extension and sialylation can be affected by nutrient limitation. In addition to nutrient limitation, we also found that N-glycosylation quality can be detrimentally affected by low culture viability. IFN-gamma purified at low culture viability had both lower sialylation as well as glycans of lower molecular masses, which can be attributed to extensive degradation by intracellular glycosidases released by cytolysis. Therefore, in order to maintain good N-glycosylation quality, there is a need to consider both culture viability and nutrient control setpoint in a nutrient-limiting fed-batch culture strategy. A greater understanding of these major factors that affect N-glycosylation quality would surely facilitate future development of effective process controls.     

Differential glycosylation produces heterogeneity in elevated esterases associated with insecticide resistance in the brown planthopper Nilaparvata lugens Stål

The major insecticide resistance mechanism in the brown planthopper Nilaparvata lugens involves overproduction of esterases. Esterases purified from a resistant strain appeared as a ladder of bands on isoelectric focussing (IEF) gels from pI 4.7 to 5.0. Two-dimensional electrophoresis showed that isozymes ranged in size from 66 to 68 kDa with those of lower pI being apparently smaller. All isozymes detected by two-dimensional electrophoresis were glycosylated. N-glycosidase A reduced the number of isozymes on IEF to two, with increased pI and an increased molecular weight of 69 kDa. No O-linked glycans were detected. Deglycosylation had no effect on esterase activity, hence glycosylation is not involved in active site conformation. As N-glycosidase F completely deglycosylated the esterases, none of the glycans has an alpha1,3-bound core fucose. Reactivity with the lectins GNA, MAA and DSA, combined with differential cleavage of N-linked glycans with endoglycosidases F1 and F2, indicated that terminally linked mannose is present in high mannose and/or hybrid type glycans and that terminally linked sialic acid and galactose-beta(1-4)-N-acetylglucosamine are present in biantennary complexes. Neuraminidase treatment had the same effect on pI of isozymes as complete deglycosylation. Therefore, the majority of the heterogeneity of elevated esterases on IEF is due to differential attachment of sialic acid to glycans of the two proteins.     

The African lungfish, Protopterus dolloi, detoxifies ammonia to urea during environmental ammonia exposure

The African lungfish, Protopterus dolloi, was able to maintain a low level of blood plasma ammonia during exposure to high concentrations of environmental ammonia. After 6 d of exposure to 30 or 100 mM NH(4)Cl, the total ammonia concentrations in the blood plasma were 0.288 and 0.289 mM, respectively, which were only 1.7-fold greater than the control value of 0.163 mM. In addition, accumulation of ammonia occurred only in the muscle, but not in the liver. This was achieved in part through urea synthesis, as reflected by significant increases in urea contents in the muscle, liver, and plasma of the experimental animals. In contrast with plasma ammonia, the plasma urea concentrations of specimens exposed to 30 or 100 mM NH(4)Cl for 6 d increased 15.4-fold and 18.8-fold, respectively. Taken together, these results suggest that P. dolloi upregulated the rate of urea synthesis to detoxify ammonia during environmental ammonia exposure and that the increased rate of urea synthesis was fast enough to compensate for the rate of endogenous ammonia production plus the net influx of exogenous ammonia in these experimental animals. Simultaneously, there were increases in the rates of urea excretion in the experimental animals between day 2 and day 6 of environmental ammonia exposure. Interestingly, the rates of urea excretion in specimens exposed to 100 mM NH(4)Cl were lower than those exposed to 30 mM NH(4)Cl, despite the presumably greater load of ammonia to be detoxified to urea in the former situation. It would appear that P. dolloi was regulating the rate of urea excretion during ammonia exposure to retain urea, which might have some physiological functions under environmental stresses yet to be determined. There were decreases in the contents of glutamate, glutamine, and total free amino acids in the liver of the experimental animals, which indirectly suggest that a reduction in the rate of proteolysis and/or amino acid catabolism would have occurred that might lead to a decrease in ammonia production. Our results suggest that, unlike marine elasmobranchs and coelacanths, which synthesize and retain urea for osmoregulatory purposes, the ureogenic P. dolloi was adapted to synthesizing and excreting urea for the purpose of ammonia detoxification.     

The effect of dissolved oxygen on the production and the glycosylation profile of recombinant human erythropoietin produced from CHO cells

Human recombinant erythropoietin (rHuEPO) was produced from Chinese hamster ovary (CHO) cells transfected with the human EPO gene. The cells were grown in batch cultures in controlled bioreactors in which the set-points for dissolved oxygen varied between 3% and 200%. The cell-specific growth rate and final cell yield was significantly lower under hyperoxic conditions (200% DO). However, there was no significant difference in growth rates at other oxygen levels compared to control cultures run under a normoxic condition (50% DO). The specific productivity of EPO was significantly lower at a DO set-point of 3% and 200% but maintained a consistently high value between 10% to 100% DO. The EPO produced under all conditions as analyzed by two-dimensional electrophoresis showed a molecular weight range of 33 to 37 kDa and a low isoelectric point range of 3.5 to 5.0. This corresponds to a highly glycosylated and sialylated protein with a profile showing at least seven distinct isoforms. The glycan pattern of isolated samples of EPO was analyzed by weak anion exchange (WAX) HPLC and by normal-phase HPLC incorporating sequential digestion with exoglycosidase arrays. Assigned structures were confirmed by mass spectrometry (MALDI-MS). The most prominent glycan structures were core fucosylated tetranntenary with variable sialylation. However, significant biantennary, triantennary, and non-fucosylated glycans were also identified. Detailed analysis of these glycan structures produced under variable dissolved oxygen levels did not show consistently significant variations except for the ratio of fucosylated to non-fucosylated isoforms. Maximum core fucosylation (80%) was observed at 50% and 100% DO, whereas higher or lower DO levels resulted in reduced fucosylation. This observation of lower fucosylation at high or low DO levels is consistent with previous data reported for glycoprotein production in insect cells.     

Influence of culture medium supplementation of tobacco NT1 cell suspension cultures on the N-glycosylation of human secreted alkaline phosphatase

We report for the first time that culture conditions, specifically culture medium supplementation with nucleotide-sugar precursors, can alter significantly the N-linked glycosylation of a recombinant protein in plant cell culture. Human secreted alkaline phosphatase produced in tobacco NT1 cell suspension cultures was used as a model system. Plant cell cultures were supplemented with ammonia (30 mM), galactose (1 mM) and glucosamine (10 mM) to improve the extent of N-linked glycosylation. The highest levels of cell density and active extracellular SEAP in supplemented cultures were on average 260 g/L and 0.21 U/mL, respectively, compared to 340 g/L and 0.4 U/mL in unsupplemented cultures. The glycosylation profile of SEAP produced in supplemented cultures was determined via electrospray ionization mass spectrometry with precursor ion scanning and compared to that of SEAP produced in unsupplemented cultures. In supplemented and unsupplemented cultures, two biantennary complex-type structures terminated with one or two N-acetylglucosamines and one paucimannosidic glycan structure comprised about 85% of the SEAP glycan pool. These three structures contained plant-specific xylose and fucose residues and their relative abundances were affected by each supplement. High mannose structures (6-9 mannose residues) accounted for the remaining 15% glycans in all cases. The highest proportion (approximately 66%) of a single complex-type biantennary glycan structure terminated in both antennae by N- acetylglucosamine was obtained with glucosamine supplementation versus only 6% in unsupplemented medium. This structure is amenable for in vitro modification to yield a more human-like glycan and could serve as a route to plant cell culture produced therapeutic glycoproteins.     

Enhanced erythropoietin heterogeneity in a CHO culture is caused by proteolytic degradation and can be eliminated by a high glutamine level

The molecular heterogeneity of recombinant humanerythropoietin (EPO) increased during the course of abatch culture of transfected Chinese hamster ovary(CHO) cells grown in serum-free medium. This wasshown by both an increased molecular weight and pIrange of the isolated EPO at the end of the culture. However, analysis of the N-glycan structures of themolecule by fluorophore-assisted carbohydrateelectrophoresis (FACE) and HPLC anion exchangechromatography indicated a consistent pattern ofglycosylation. Seven glycoforms were identified, thepredominant structure being a fully sialylatedtetra-antennary glycan. The degree of sialylationwas maintained throughout the culture. Analysis ofthe secreted EPO indicated a time-dependent increasein the molecular weight band width of the peptideconsistent with proteolytic degradation. A highglutamine concentration (16–20 mM) in the culturedecreased the apparent degradation of the EPO.     

Utilization of nitrogen from 15NH4Cl and [15N]alanine for urea synthesis in hepatocytes from fed and starved rats

Utilization of N from 15NH4Cl and [15N]alanine for urea synthesis in hepatocytes isolated from fed and 24 hr starved rats was investigated. In hepatocytes isolated from fed rats, 54 and 65% of the added [15N]ammonia was utilized for urea synthesis in the presence of 0.5 and 2.0 mM NH4Cl, respectively. This utilization of [15N]ammonia in hepatocytes from starved rats was 2-fold lower. The amount of urea synthetized from endogenous sources was, in the presence of 0.5 and 2.0 mM NH4Cl, about 44 and 60% higher than in the control conditions (without NH4Cl). The considerable amount of added ammonia (30-44%) was utilized in processes other than urea synthesis. Alanine markedly diminished the utilization of 15N from NH4Cl in hepatocytes from both fed and starved rats. In these conditions (NH4Cl present), alanine significantly increased the urea formation in hepatocytes from starved rats and failed to affect the urea production in hepatocytes from fed rats. On the basis of 15N determination, it was concluded that both NH4Cl and alanine caused an increase in the utilization of nitrogen from endogenous sources in rat hepatocytes. This conclusion is in contrast with the results based only on the changes in ammonia and urea concentrations.     

Enhancement of recombinant human EPO production and glycosylation in serum-free suspension culture of CHO cells through expression and supplementation of 30Kc19

We previously reported that the expression of Bombyx mori 30Kc19 gene in CHO cells significantly improved both the production and sialylation of recombinant human EPO (rHuEPO) in adhesion culture mode. In this study, the effects of 30Kc19 expression and supplementation of 30Kc19 recombinant protein on the productivity and glycosylation pattern of rHuEPO were investigated in the serum-free suspension culture mode. Especially, glycosylation pattern was examined in detail using a quantitative MALDI-TOF MS method. The expression of 30Kc19 increased the EPO production by 2.5-folds and the host cells produced rHuEPO with more complex glycan structures and a larger content of sialic acid and fucose. The glycan structures of rHuEPO in the 30Kc19-expressing cell consisted of bi-, tri-, tetra-, and penta-antennary branching (35, 18, 33, and 14?%, respectively), while the control cells produced predominantly bi-antennary branching (70?%). About 53?% of the glycans from rHuEPO in the 30Kc19-expressing cell was terminally sialylated, while no obvious sialylated glycan was found in the control cells. The percentage of fucosylated glycans from the 30Kc19-expressing cell culture was 77?%, whereas only 61?% of the glycans from the control cell were fucosylated glycans. We also examined whether these effects were observed when the recombinant 30Kc19 protein produced from Escherichia coli was supplemented into the culture medium for CHO cells. In the control cell line without the 30Kc19 gene, EPO production increased by 41.6?% after the addition of 0.2?mg/mL of the recombinant 30Kc19 protein to the culture medium. By the Western blot analysis after two-dimensional electrophoresis (2-DE) of isoforms of EPO, we confirmed that 30Kc19 enhanced the sialylation of EPO glycans. These results demonstrated that both 30Kc19 gene expression and the recombinant 30Kc19 protein addition enhanced rHuEPO productivity and glycosylation in suspension culture. In conclusion, the utilization of 30Kc19 in CHO cell culture holds great promise for use in the manufacturing of improved biopharmaceutical glycoproteins.     

Changes in free amino acid synthesis in the perfused liver of an air-breathing walking catfish, Clarias batrachus infused with ammonium chloride: a strategy to adapt under hyperammonia stress

The changes in the free amino acid (FAA) levels, the rate of efflux of FAAs from the perfused liver, and the activity of some enzymes related to amino acid metabolism such as glutamate dehydrogenase (GDH, both reductive amination and oxidative deamination), glutamine synthetase (GS), aspartate aminotransferase (AST), and alanine aminotransferase (ALT) were studied in the liver of a freshwater air-breathing teleost, the walking catfish, Clarias batrachus, perfused with 5 and 10 mM NH(4)Cl. The level of the various non-essential FAAs increased significantly, with a total increase of about 150%, which was accompanied by a significant increase of both ammonia and urea-N in the perfused liver both with 5 and 10 mM NH(4)Cl. The rate of efflux of these non-essential FAAs from the perfused liver also increased significantly with a total increase of about 115% and 160% at 5 and 10 mM NH(4)Cl, respectively. The activity of the mentioned amino acid metabolism-related enzymes in the perfused liver also got stimulated, except for GDH in the ammonia forming direction and ALT, under a higher ammonia load. The activity (both tissue and specific) of GDH in the glutamate forming direction increased maximally, followed by AST and GS in a decreasing order. Owing to these physiological adaptive strategies related to amino acid metabolism along with the presence of a functional and regulatory urea cycle (reported earlier), it is believed that this catfish is able to survive in very high ambient ammonia or in the air or in the mud during habitat drying.     

Substitution of glutamine by glutamate enhances production and galactosylation of recombinant IgG in Chinese hamster ovary cells

The effect of ammonia on Chinese hamster ovary (CHO) cell growth and galactosylation of recombinant immunoglobulin (rIgG) was investigated using shaking flasks with serum free media containing 0–15 mM NH₄Cl. The elevated ammonia inhibited cell growth and negatively affected the galactosylation of rIgG. At 15 mM NH₄Cl, the proportions of monogalactosylated glycan with fucosex (monogalactosylated glycan with fucose) and digalactosylated glycan with fucose (G2F) were 23.9% and 6.3% lower than those at 0 mM NH₄Cl, respectively. To reduce ammonia formation by cells, glutamate was examined as a substitute for glutamine. The use of glutamate reduced the accumulation of ammonia and enhanced the production of rIgG while depressing cell growth. At 6 mM glutamate, ammonia level did not exceed 2 mM, which is only one third of that at 6 mM glutamine. Also, a 1.7-fold increase in the titer of rIgG and specific rIgG productivity, q _rIgG, was achieved at 6 mM glutamate. The galactosylation of rIgG was favorable at 6 mM glutamate. The proportion of galactosylated glycans, G1F and G2F, at 6 mM glutamate was 59.8%, but it was 50.4% at 6 mM glutamine. The use of glutamate also increased complement-dependent cytotoxicity activity, one of the effector functions of rIgG. Taken together, substitution of glutamine by glutamate can be considered relevant for the production of rIgG in CHO cells since glutamate not only enhances q _rIgG but also generates a higher galactosylation essential for the effector function of rIgG.     

African sharptooth catfish Clarias gariepinus does not detoxify ammonia to urea or amino acids but actively excretes ammonia during exposure to environmental ammonia

The African sharptooth catfish Clarias gariepinus lives in freshwater, is an obligatory air breather, and exhibits high tolerance of environmental ammonia. This study aimed at elucidating the strategies adopted by C. gariepinus to defend against ammonia toxicity during ammonia exposure. No carbamoyl phosphate synthetase (CPS) I or III activities were detected in the liver or muscle of the adult C. gariepinus. In addition, activities of other ornithine-urea cycle (OUC) enzymes, especially ornithine transcarbamylase, were low in the liver, indicating that adult C. gariepinus does not have a "functional" hepatic OUC. After being exposed to 50 or 100 mM NH4Cl for 5 d, there was no induction of hepatic OUC enzymes and no accumulation of urea in tissues of the experimental animals. In addition, the rate of urea excretion remained low and unchanged. Hence, ammonia exposure did not induce ureogenesis or ureotely in C. gariepinus as suggested elsewhere for another obligatory air-breathing catfish of the same genus, Clarias batrachus, from India. Surprisingly, the local C. batrachus did not possess any detectable CPS I or III activities in the liver or muscle as had been reported for the Indian counterpart. There were no changes in levels of alanine in the muscle, liver, and plasma of C. gariepinus exposed to 50 or 100 mM NH4Cl for 5 d; neither were there any changes in the glutamine levels in these tissues. Yet even after being exposed to 100 mM NH4Cl for 5 d, there was no significant increase in the level of ammonia in the muscle, which constitutes the bulk of the specimen. In addition, the level of ammonia accumulated in the plasma was relatively low compared to other tropical air-breathing fishes. More importantly, for all NH4Cl concentrations tested (10, 50, or 100 mM), the plasma ammonia level was maintained relatively constant (2.2-2.4 mM). These results suggest that C. gariepinus was able to excrete endogenous ammonia and infiltrated exogenous ammonia against a very steep ammonia gradient. When exposed to freshwater (pH 7.0) with or without 10 mM NH4Cl, C. gariepinus was able to excrete ammonia continuously to the external medium for at least 72 h. This was achieved while the plasma NH4+ and NH3 concentrations were significantly lower than those of the external medium. Diffusion trapping of NH3 through boundary layer acidification can be eliminated as the pH of the external medium became more alkaline instead. These results represent the first report on a freshwater fish (C. gariepinus) adopting active excretion of ammonia (probably NH4+) as a major strategy to defend against ammonia toxicity when exposed to environmental ammonia.     

Ammonium alters N-glycan structures of recombinant TNFR-IgG: degradative versus biosynthetic mechanisms

The effect of ammonium on the glycosylation pattern of the recombinant immunoadhesin tumor necrosis factor-IgG (TNFR-IgG) produced by Chinese hamster ovary cells is elucidated in this study. TNFR-IgG is a chimeric IgG fusion protein bearing one N-linked glycosylation site in the Fc region and three complex-type N-glycans in the TNF-receptor portion of each monomer. The ammonium concentration of batch suspension cultures was adjusted with glutamine and/or NH(4)Cl. The amount of galactose (Gal) and N-acetylneuraminic acid (NANA) residues on TNFR-IgG correlated in a dose-dependent manner with the ammonium concentration under which the N-linked oligosaccharides were synthesized. As ammonium increased from 1 to 15 mM, a concomitant decrease of up to 40% was observed in terminal galactosylation and sialylation of the molecule. Cell culture supernatants contained measurable beta-galactosidase and sialidase activity, which increased throughout the culture. The beta-galactosidase, but not the sialidase, level was proportional to the ammonium concentration. No loss of N-glycans was observed in incubation studies using beta-galactosidase and sialidase containing cell culture supernatants, suggesting that the ammonium effect was biosynthetic and not degradative. Several biosynthetic mechanisms were investigated. Ammonium (a weak base) is known to affect the pH of acidic intracellular compartments (e.g., trans-Golgi) as well as intracellular nucleotide sugar pools (increases UDP-N-acetylglucosamine and UDP-N-acetylgalactosamine). Ammonium might also affect the expression rates of beta1, 4-galactosyltransferase (beta1,4-GT) and alpha2,3-sialyltransferase (alpha2,3-ST). To separate these mechanisms, experiments were designed using chloroquine (changes intracellular pH) and glucosamine (increases UDP-GNAc pool [sum of UDP-GlcNAc and UDP-GalNAc]). The ammonium effect on TNFR-IgG oligosaccharide structures could be mimicked only by chloroquine, another weak base. No differences in N-glycosylation were found in the product synthesized in the presence of glucosamine. No differences in beta1, 4-galactosyltransferase (beta1,4-GT) and alpha2,3-sialyltransferase (alpha2,3-ST) messenger RNA (mRNA) and enzyme levels were observed in cells cultivated in the presence or absence of 13 mM NH(4)Cl. pH titration of endogenous CHO alpha2,3-ST and beta-1,4-GT revealed a sharp optimum at pH 6.5, the reported trans-Golgi pH. Thus, at pH 7.0 to 7.2, a likely trans-Golgi pH range in the presence of 10 to 15 mM ammonium, activities for both enzymes are reduced to 50% to 60%. Consequently, ammonium seems to alter the carbohydrate biosynthesis of TNFR-IgG by a pH-mediated effect on glycosyltransferase activity.     

An investigation of intracellular glycosylation activities in CHO cells: Effects of nucleotide sugar precursor feeding

Controlling glycosylation of recombinant proteins produced by CHO cells is highly desired as it can be directed towards maintaining or increasing product quality. To further our understanding of the different factors influencing glycosylation, a glycosylation sub‐array of 79 genes and a capillary electrophoresis method which simultaneously analyzes 12 nucleotides and 7 nucleotide sugars; were used to generate intracellular N‐glycosylation profiles. Specifically, the effects of nucleotide sugar precursor feeding on intracellular glycosylation activities were analyzed in CHO cells producing recombinant human interferon‐γ (IFN‐γ). Galactose (±uridine), glucosamine (±uridine), and N‐acetylmannosamine (ManNAc) (±cytidine) feeding resulted in 12%, 28%, and 32% increase in IFN‐γ sialylation as compared to the untreated control cultures. This could be directly attributed to increases in nucleotide sugar substrates, UDP‐Hex (～20‐fold), UDP‐HexNAc (6‐ to 15‐fold) and CMP‐sialic acid (30‐ to 120‐fold), respectively. Up‐regulation of B4gal and St3gal could also have enhanced glycan addition onto the proteins, leading to more complete glycosylation (sialylation). Combined feeding of glucosamine + uridine and ManNAc + cytidine increased UDP‐HexNAc and CMP‐sialic acid by another two‐ to fourfold as compared to feeding sugar precursors alone. However, it did not lead to a synergistic increase in IFN‐γ sialylation. Other factors such as glycosyltransferase or glycan substrate levels could have become limiting. In addition, uridine feeding increased the levels of uridine‐ and cytidine‐activated nucleotide sugars simultaneously, which could imply that uridine is one of the limiting substrates for nucleotide sugar synthesis in the study. Hence, the characterization of intracellular glycosylation activities has increased our understanding of how nucleotide sugar precursor feeding influence glycosylation of recombinant proteins produced in CHO cells. It has also led to the optimization of more effective strategies for manipulating glycan quality. Biotechnol. Bioeng. 2010;107: 321–336. © 2010 Wiley Periodicals, Inc.     

Analysis of erythropoietin glycoform produced by recombinant CHO cells using the Lectin-blotting technique

The glycosylation pattern of Erythropoietin (EPO), produced by recombinant CHO cells, was studied using the simple and rapid technique of ‘Lectin-blotting’. In this experiment we used three different kinds of lectins, MAA (Maackia amurensis agglutinine), RCA (Ricinus communis agglutinine), and DSA (Datura stramonium agglutinine), which bind to the terminal sialic acid, galactose, and the N-acetyllactosamine chain respectively. The lectin-blotting technique was used to analyze the carbohydrate structure of EPO produced in the presence of two physiologically active chemical compounds, ammonium and chloroquine. The effect of the ammonium ion on the glycosylation of EPO was studied because it accumulated in the medium mainly as a by-product of glutamine metabolism. Ammonium chloride significantly inhibited the sialylation of the terminal galactose residue at concentrations of 8 mM or more. Chloroquine, a potent inhibitor of glycosylation, inhibited terminal sialylation at concentrations of 100 and 200 μM, and at a concentration of 300 μM also inhibited N-acetyllactosamine chain synthesis.     

Glycosylation of erythropoietin affects receptor binding kinetics: role of electrostatic interactions

Erythropoietin (EPO) is a cytokine produced by the kidney whose function is to stimulate red blood cell production in the bone marrow. Previously, it was shown that the affinity of EPO for its receptor, EPOR, is inversely related to the sialylation of EPO carbohydrate. To better understand the properties of EPO that modulate its receptor affinity, various glycoforms were analyzed using surface plasmon resonance. The system used has been well characterized and is based on previous reports employing an EPOR-Fc chimera captured on a Protein A surface. Using three variants of EPO containing different levels of sialylation, we determined that sialic acid decreased the association rate constant (k(on)) about 3-fold. Furthermore, glycosylated EPO had a 20-fold slower k(on) than nonglycosylated EPO, indicating that the core carbohydrate also negatively impacted k(on). The effect of electrostatic forces on EPO binding was studied by measuring binding kinetics in varying NaCl concentrations. Increasing NaCl concentration resulted in a slower k(on) while having little impact on k(off), suggesting that long-range electrostatic interactions are primarily important in determining the rate of association between EPO and EPOR. Furthermore, the glycosylation content (i.e., nonglycosylated vs glycosylated, sialylated vs desialylated) affected the overall sensitivities of k(on) to [NaCl], indicating that sialic acid and the glycan itself each impact the overall effect of these electrostatic forces.     

The O-linked glycosylation of secretory/shed MUC1 from an advanced breast cancer patient's serum

MUC1 is a high molecular weight glycoprotein that is overexpressed in breast cancer. Aberrant O-linked glycosylation of MUC1 in cancer has been implicated in disease progression. We investigated the O-linked glycosylation of MUC1 purified from the serum of an advanced breast cancer patient. O-Glycans were released by hydrazinolysis and analyzed by liquid chromatography-electrospray ionization-mass spectrometry and by high performance liquid chromatography coupled with sequential exoglycosidase digestions. Core 1 type glycans (83%) dominated the profile which also confirmed high levels of sialylation: 80% of the glycans were mono-, di- or trisialylated. Core 2 type structures contributed approximately 17% of the assigned glycans and the oncofoetal Thomsen-Friedenreich (TF) antigen (Galbeta1-3GalNAc) accounted for 14% of the total glycans. Interestingly, two core 1 type glycans were identified that had sialic acid alpha2-8 linked to sialylated core 1 type structures (9% of the total glycan pool). This is the first O-glycan analysis of MUC1 from the serum of a breast cancer patient; the results suggest that amongst the cell lines commonly used to express recombinant MUC1 the T47D cell line processes glycans that are most similar to patient-derived material.     

Recombinant carboxyl-terminal fibrin-binding domain of human fibronectin expressed in mouse L cells

The carboxyl-terminal fibrin-binding domain, Fib2, of human fibronectin was expressed in mouse L cells as a fusion protein with the signal sequence of human protein C inhibitor. The recombinant Fib2 (rFib2) protein synthesized by transfected cells retained the ability to form dimers with each other or with mouse fibronectin subunits and was secreted to the medium after extensive glycosylation. Only a small fraction of the secreted protein was incorporated into the pericellular matrix. Interestingly, the secreted rFib2 protein displayed a remarkable heterogeneity upon sodium dodecyl sulfate-polyacrylamide gel electrophoresis, giving rise to a broad band corresponding to Mr of 60,000-90,000. The heterogeneity was eliminated mostly by treatment with neuraminidase and further by treatment with endo-alpha-N-acetylgalactosaminidase. Treatment with peptide:N-glycosidase F did not alter the heterogeneity of the protein, indicating that differential sialylation of O-linked, but not N-linked, glycans is largely responsible for the apparent heterogeneity. The presence of O-linked but absence of N-linked glycans was further supported by the observations that peanut agglutinin specifically bound to the desialylated rFib2 protein, whereas neither concanavalin A nor lentil lectin bound to the protein irrespective of prior neuraminidase treatment. Since the apparent heterogeneity of the rFib2 protein was only observable with the secreted, but not the cytoplasmic form, sialylation of O-linked glycans may be essential for, or regulate as a rate-limiting step, the transit of the recombinant protein to the extracellular space.